The effect of different cooking procedures on microbiological and chemical quality characteristics of Tekirdaǧ meatballs

In this research, the effects of different cooking processes (grilling, oven, and microwave cooking) on microbial flora and chemical composition of the raw and cooked meatballs as consumed in Tekirdaǧ were investigated. Microbial flora of the raw meatballs was as follows: total bacteria, 6.02×10⁶ cfu/g; psychrophilic bacteria, 1.3×10⁵ cfu/g; yeast and mould, 2.4×10⁵ cfu/g; coliforms, 1.1×10⁵ cfu/g; Escherichia coli, 1.0×10² cfu/g; total staphylococcae, 3.3×10² cfu/g; Staphylococcus aureus, 85 cfu/g. While Salmonella was found in only one sample, none of the samples contained Clostridium perfringens. The cooking processes clearly decreased the microbial flora (2–3 log cycles in grilling (71°C) and oven‐cooked (79°C( 3–4 log cycles in microwave (97°C) heating) of the meatballs. However, because of the crust formation and high moisture losses from the meatball surface in microwave heating, some sensorial defects were observed in the final product. Also, fat and moisture losses were higher in microwave cooking compared to the other cooking processes. In conclusion, it is advised to use slightly higher temperatures than used in the grilling or conventinal cooking procedures to increase microbial quality of the meatballs studied in this research.     

Behaviour of Escherichia coli O157:H7 during the fermentation of Datta and Awaze, traditional Ethiopian fermented condiments, and during product storage at ambient and refrigeration temperatures

The survival of E. coli O157:H7 in fermenting foods and its prolonged survival in refrigerated fermented foods is documented. This prompted the study to evaluate survival of E. coli O157:H7 during the fermentation of Datta and Awaze, traditional Ethiopian condiments. Datta was prepared by wet milling a variety of spices along with green or red chilli and fermenting it by lactic acid bacteria. Awaze is a slurry made of red pepper, garlic and ginger to which various other spices were added and fermented by lactic acid bacteria (LAB) and yeasts. The Datta or Awaze slurry was separately inoculated with three strains of E. coli O157:H7 and the fermentation was allowed to proceed at ambient (20–25°C) temperatures for 7 days. When fermenting Datta or Awaze was initially inoculated at low inoculum level (3 log cfu/g), the test strains were not recovered after 24 h of fermentation. At higher initial inoculum level (6 log cfu/g), however, counts of the test strains in Datta at day 7 were less by about 1.5 log unit than the initial inoculum level. In fermenting Awaze, all test strains were completely eliminated in 7 days. The pH of the fermenting green and red Datta was reduced from 5.2 to 4.4 and that of Awaze dropped from 4.9 to 3.8 during this time. In another experiment, the fermented products were separately inoculated with the E. coli O157:H7 test strains at levels of 6 log cfu/g and incubated at ambient and refrigeration (4°C) temperatures for 7 days. In fermented Datta, two of the three strains were not recovered by enrichment after 6 days of storage at ambient temperatures. In fermented Awaze, all strains were below countable levels at day 5, but could still be recovered by enrichment at day 7. At refrigeration storage, counts of the test strains in Datta and Awaze products were <3 log cfu/g at day 7. The inhibition of our E. coli O157:H7 test strains in Datta and Awaze may be due to the antimicrobial activity of spices and other metabolites produced by LAB which may be effective at low pH.     

Models of the behavior of Escherichia coli O157:H7 in raw sterile ground beef stored at 5 to 46 °C

Escherichia coli O157:H7 can contaminate raw ground beef and cause serious human foodborne illness. Previous reports describe the behavior of E. coli O157:H7 in ground beef under different storage conditions; however, models are lacking for the pathogen's behavior in raw ground beef stored over a broad range of temperature. Using sterile irradiated raw ground beef, the behavioral kinetics of 10 individual E. coli O157:H7 strains and/or a 5- or 10-strain cocktail were measured at storage temperatures from 5° to 46 °C. Growth occurred from 6 to 45 °C. Although lag phase duration (LPD) decreased from 10.5 to 45 °C, no lag phase was observed at 6, 8, or 10 °C. The specific growth rate (SGR) increased from 6 to 42 °C then declined up to 45 °C. In contrast to these profiles, the maximum population density (MPD) declined with increasing temperature, from approximately 9.7 to 8.2 log cfu/g. Bias (B_f) and accuracy (A_f) factors for an E. coli O157:H7 broth-based aerobic growth model (10 to 42 °C) applied to the observations in ground beef were 1.05, 2.70, 1.00 and 1.29, 2.87, 1.03, for SGR, LPD and MPD, respectively. New secondary models increased the accuracy of predictions (5 to 45 °C), with B_f and A_f for SGR, LPD, and MPD of 1.00, 1.06, and 1.00 and 1.14, 1.33, and 1.02, respectively. These new models offer improved tools for designing and implementing food safety systems and assessing the impact of E. coli O157:H7 disease.     

Fate of Escherichia coli O157:H7 in field-inoculated lettuce

Impact of drip and overhead sprinkler irrigation on the persistence of attenuated Escherichia coli O157:H7 in the lettuce phyllosphere was investigated using a split-plot design in four field trials conducted in the Salinas Valley, California, between summer 2007 and fall 2009. Rifampicin-resistant attenuated E. coli O157:H7 ATCC 700728 (BLS1) was inoculated onto the soil beds after seeding with a backpack sprayer or onto 2- or 4-week-old lettuce plant foliage with a spray bottle at a level of 7 log CFU ml⁻¹. When E. coli O157:H7 was inoculated onto 2-week-old plants, the organism was recovered by enrichment in 1 of 120 or 0 of 240 plants at 21 or 28 days post-inoculation, respectively. For the four trials where inoculum was applied to 4-week-old plants, the population size of E. coli O157:H7 declined rapidly and by day 7, counts were near or below the limit of detection (10 cells per plant) for 82% or more of the samples. However, in 3 out 4 field trials E. coli O157:H7 was still detected in lettuce plants by enrichment 4-weeks post-inoculation. Neither drip nor overhead sprinkler irrigation consistently influenced the survival of E. coli O157:H7 on lettuce.     

Effectiveness of chitosan edible coatings to improve microbiological and sensory quality of fresh cut broccoli

The effects of chitosan edible coating on microbiological and sensory quality of refrigerated broccoli were studied. The antimicrobial effects of chitosan on the native microflora (mesophilic, psychrotrophic, yeast and molds, lactic acid bacteria and coliforms) and on the survival of E. coli O157:H7 inoculated in broccoli were evaluated.Chitosan treatments resulted in a significant reduction in total mesophilic and psychrotrophic bacteria counts with respect to the control samples during the entire storage period. There was an immediate decontaminating activity of chitosan. At the end of the storage, yeast and molds was the most dominant flora representing the largest part of the total aerobic counts. Lactic acid bacteria (LAB) numbers remained relatively low during the whole storage in all samples. Chitosan coating inhibited the growth of total coliform throughout the storage time. Also, chitosan treatments resulted in a bactericidal effect on E. coli endogenous and a significant decreased in total E. coli counts (endogenous and O157:H7). The application of chitosan coating on fresh cut broccoli inhibited the yellowing and opening florets. The results of this experiment showed that the use of chitosan coating is a viable alternative in controlling the microorganisms present in minimally processed broccoli, improving its sensory quality.     

Effects of salt, acid, and MSG on cold storage survival and subsequent acid tolerance of Escherichia coli O157:H7

The combined effects of salt, monosodium glutamate (MSG), and pH on cold storage survival and subsequent acid tolerance of Escherichia coli O157:H7 were determined. Cold storage survival was evaluated in tryptic soy broth (TSB) with combinations of pH (7.2, 5.0, or 4.0), MSG (0, 0.5, 1%) and salt (0, 2, 4%). Survival through 21 d at 5°C and acid tolerance in simulated gastric fluid were evaluated weekly. In separate experiments, strains were tested individually for the effect of growth in the presence of MSG on subsequent acid resistance and for the ability of MSG to impact growth under acid conditions. The impact of salt on cold storage survival was greater at pH 4.0 and 7.0 compared to pH 5.0. MSG did not enhance cold storage survival. The presence of MSG alone enhanced acid tolerance following cold storage at pH 5.0 and 7.2 compared to control cells. At pH 4.0, MSG alone enhanced acid tolerance compared to control cells following 21 days cold storage. Overnight growth in TSB containing MSG did not affect subsequent acid tolerance in acidified TSB (pH 2.0). The presence of MSG in TSB (37°C) did not enable growth at lower pH.     

Effects of cooking methods and chemical tenderizers on survival of Escherichia coli O157:H7 in ground beef patties

This study evaluated chemical tenderizers and cooking methods to inactivate Escherichia coli O157:H7 in ground beef patties (model system for non-intact beef). Ground beef was inoculated with E. coli O157:H7 and mixed with (i) nothing (control), (ii) calcium chloride (CC) and flavoring agents (FA), (iii) CC, FA, and acetic acid (AA), (iv) sodium chloride (SC), sodium tripolyphosphate (ST), and potassium lactate (PL), and (v) the combination of SC, ST, PL, and AA. Patties were stored in aerobic or vacuum bags at − 20, 4, and 12 °C. Samples were grilled, broiled, or pan-fried to 60 or 65 °C. Total bacterial and E. coli O157:H7 populations remained unchanged during storage. Broiling was more effective in reducing E. coli O157:H7 than grilling and pan-frying, and acidified tenderizers reduced E. coli O157:H7 more than non-acidified tenderizers in broiling. Higher reductions were observed at 65 °C than 60 °C in broiled and grilled samples. These results indicate that acidified tenderizers and broiling may be useful in non-intact beef safety.     

Safety and quality assessment of packaged spinach treated with a novel ozone-generation system

The quality and safety of packaged salad are major concerns to consumers. Ozone gas is a non-thermal processing technology capable of treating food to reduce pathogens. The ozone generation system (PK-1) used in this study consisted of a pair of electrodes with an adjustable gap inside a package. Individual, fresh, prepackaged, whole spinach leaves inoculated with Escherichia coli O157:H7 6460 were treated in packaging with ozone generated in air and oxygen. Samples were treated for 5 min and stored at room temperature (22 °C) or refrigeration (5 °C) for 0.5, 2, and 24 h. Gas composition and relative humidity were measured. All treated samples showed reductions in E. coli O157:H7 populations with the largest reductions (3-5 log₁₀ CFU/leaf) after 24 h of storage. After 5 min of treatment, ozone concentrations were 1.6 and 4.3 mg/L for air and oxygen gas, respectively. The concentrations of ozone decreased with time and were not detectable after 24 h. A 5-point Spinach Color Quality (SCQ) scale was established (5-best, 1-worst). Treated spinach showed discoloration with SCQ-values of 3.83 and 1.00 for air and oxygen gas exposed leaves after 24 h. These results indicate that the PK-1 system is capable of reducing E. coli O157:H7 in packaged spinach; however, minimizing quality changes after treatment requires further research.     

基于dsDNA-CuNCs的荧光ELISA检测牛奶中的E.coli O157:H7

目的:建立了一种灵敏检测牛奶中大肠杆菌O157:H7的新型荧光酶联免疫吸附方法。方法:以碱性磷酸酶水解焦磷酸盐-Cu²⁺配位复合物,释放出Cu²⁺形成铜纳米簇作为信号报告探针,通过对关键因素Cu²⁺浓度、焦磷酸盐浓度、DNA模板的浓度和长度进行优化。结果:在最优条件下,大肠杆菌O157:H7的菌数为5×10⁴～1×10⁸ CFU/mL时,与荧光信号值有较好的线性关系(R²=0.980 8),最低检出限为2.4×10⁴ CFU/mL。结论:该方法成功地应用于低脂牛奶和脱脂牛奶样本中大肠杆菌O157:H7的测定,平均回收率为92.2%～108.5%,相对标准偏差为4.9%～10.4%。     

特异性抗肠出血性大肠杆菌O157:H7内毒素鸡卵黄抗体的制备

目的:比较研究LPS和O-SP的免疫原性,制备出特异性抗内毒素(LPS)鸡卵黄免疫球蛋白(eggyolkimmunoglobulin,IgY),用于对E.coliO157:H7的免疫预防及检测。方法:分别用灭活E.coliO157:H7菌体、不同浓度内毒素(LPS)及O-特异性多糖链(O-SP)与不完全弗氏佐剂充分乳化后作抗原免疫临产蛋母鸡,以水稀释法从卵黄中提取抗体,阴离子交换色谱法实现对抗体的纯化,间接ELISA及双向免疫扩散检测抗体产生效价与活性。结果与结论:所制内毒素(LPS)和O-SP均有较好的免疫原性,刺激鸡体后可产生高效价抗体,灭活菌体、600μg/mlLPS、1200μg/mlLPS、2000μg/mlLPS、O-SP抗体产生效价最高可分别达1:32000、1:28000、1:32000、1:12000、1:40000。结合离子交换色谱,用0.185mol/L的离子强度可实现一步洗脱纯化抗体,制备出高纯度、高活性、特异性强的鸡卵黄免疫球蛋白IgY,为大肠杆菌O157:H7的感染防治提供了可靠的保证,在此实验基础之上可进一步探讨应用特异性IgY对大肠杆菌O157:H7的检测。     

Development of PCR assays for detection of Escherichia coli O157:H7 in meat products

A multiplex polymerase chain reaction (PCR) procedure based on fliC_h7 and rfbE genes was developed for the detection of Escherichia coli O157:H7 in raw pork meat and ready-to-eat (RTE) meat products. Two different DNA extraction procedures were evaluated for application on meat products. MasterPure™ DNA Purification kit in combination with immunomagnetic separation was found to be the best method in a meat system. The optimized PCR included an enrichment step in brilliant green bile 2% broth at 37 °C. This method was applied to artificially inoculated meat and RTE meat products with different concentrations of E. coli O157:H7. The results indicate that the PCR assay developed could sensitively and specifically detect E. coli O157:H7 in raw pork meat and RTE meat products in approximately 10 h, including a 6 h enrichment step. Thus, this method could be proposed for screening E. coli O157:H7 in raw pork and RTE meat products.     

A review of quantitative microbial risk assessment in the management of Escherichia coli O157:H7 on beef

Since Escherichia coli O157:H7 first emerged as a food borne pathogen in the mid 1980s, it has been linked to many cases of food poisoning across the world. While multiple sources and routes of transmission for this pathogen are now recognised, beef and beef products remain an important vehicle of the pathogen and continue to be linked to outbreaks across the developed world. Much research has been directed at E. coli O157:H7 transmission, survival and control in the beef chain and this paper presents an overview of current knowledge on this pathogen in the beef chain from primary production through slaughter, processing, distribution, final preparation and cooking. In order to strategically manage E. coli O157:H7 and to devise approaches to reduce the public health risk posed, many national and international groups have applied quantitative risk assessment techniques to model the risk posed by E. coli O157:H7 in beef, particularly in ground/minced beef which is most often linked with infection. This paper reviews these quantitative risk assessments and their application in managing the risk posed by E. coli O157:H7 in beef.     

食品中大肠杆菌O157:H7控制新技术研究进展

论述了杀菌剂清洗技术、高压脉冲电场技术、高密度CO2技术、超高压技术和辐照技术等新技术的原理及其在控制食品中大肠杆菌O157:H7应用方面的研究进展。展望了未来该研究领域的发展趋势。     

A simplified method for numerical simulation of gas grilling of non-intact beef steaks to eliminate Escherichia coli O157:H7

The objective of this work was to develop a numerical simulation method to study the heat transfer process and inactivation of Escherichia coli O157:H7 during gas grilling of non-intact beef steaks (NIBS). A finite difference and optimization algorithm was developed to determine the effective heat transfer parameters during grilling. After validation, these parameters were used in a finite element method to simulate the temperature profiles at various locations of NIBS (2.54 cm in thickness). The computer simulation results showed that E. coli O157:H7 may survive the heating processes if normal grilling conditions for intact beef steaks were used. Computer simulation results also suggested that E. coli O157:H7 might be effectively inactivated if NIBS (2.54 cm) were evenly flipped (every 4 min) and cooked for 16 min during cooking. The result of this study may help the food service industry to develop more adequate grilling methods and conditions to cook NIBS.     

The prevalence of Escherichia coli O157 and O157:H7 in ground beef and raw meatball by immunomagnetic separation and the detection of virulence genes using multiplex PCR

The present study was conducted to investigate the presence of Escherichia coli O157 and O157:H7 strains and to detect the presence of the stx1, stx2, and eaeA genes in isolates derived from 200 samples (100 samples from fresh ground beef and 100 samples from raw meatball). The samples were purchased from the Samsun Province in Turkey, over a period of 1 year. Enrichment-based immunomagnetic separation and multiplex polymerase chain reaction were applied for these analyses. E. coli O157 was detected in five of the 200 (2.5%) samples tested (one isolated from ground beef and four from meatball samples), whereas E. coli O157: H7 was not detected in any sample. During the analysis, eight strains of E. coli O157 were obtained. The genes stx1, stx2, and eaeA were detected in two E. coli O157 isolates obtained from two meatball samples, whereas only the eaeA and the stx2 genes were detected in four E. coli O157 strains that were isolated from one meatball sample. None of the stx1, stx2, and eaeA was detected in the E. coli O157 isolates obtained from the ground beef and the one meatball samples.     

A note on Escherichia coli O157:H7 serotype in Turkish meat products

255 minced beef, 101 soudjouk and 50 uncooked hamburger samples were analyzed for the presence of Escherichia coli O157:H7 serotype. m-EC and LST broths were used as selective enrichment media and SMAC agar was used as a selective isolation medium. A total of 3 E. coli O157 were isolated by conventional culture techniques; one from each of minced beef, uncooked hamburger and soudjouk but none were identified as the H7 serotype. For determination of selective media-growing cohabitant bacteria, 2645 isolates were obtained from SMAC agar. Results showed that E. coli type 1, Hafnia alvei and Citrobacter freundii were dominant competitive flora. As selective enrichment broth-growing cohabitant microflora existed at higher levels, it was too difficult to isolate E. coli O157 from these mixed flora. Therefore, conventional methods are not suitable for these types of products, because of isolation difficulties and failure to confirm.     

Assessment of Escherichia coli O157:H7-specific bacteriophages e11/2 and e4/1c in model broth and hide environments

The efficacy of bacteriophages e11/2 and e4/1c as potential biocontrol agents for Escherichia coli O157:H7 in food applications was assessed under conditions relevant to the food chain environment. The stability of each phage was determined following exposure to varying environmental conditions (pH, temperature, water activity, and sodium chloride) and the ability of each phage to infect and reduce E. coli O157:H7 numbers under selected conditions was also examined. Both e11/2 and e4/1c significantly (p < 0.05) reduced numbers of E. coli O157:H7 when exposed to pH values ranging from pH > 4 to pH 9, temperatures from 4 °C to 37 °C, water activity values of 0.87 or 0.91 to 1.00 and NaCl concentrations of 1% to 2.5%. Subsequently, a cocktail of both phages was used (e11/2 and e4/1c) to assess reduction of E. coli O157:H7 on cattle hide pieces. This involved inoculating pieces of hide (20 × 20 cm) with E. coli O157:H7 (approximately 10⁶ cfu/cm²) which were subsequently treated with either a suspension of a phage cocktail, consisting of e11/2 and e4/1c (multiplicity of infection of 1000 and 10,000, respectively) or water or not treated. Two different investigations were carried out; immediately or 1 h after treatment application was performed in different experiments. Swab samples taken immediately after phage treatment showed no significant (p > 0.05) reduction of E. coli O157:H7 numbers compared to the water treated or untreated samples. However, an extended exposure time of 1 h following phage application revealed a significant reduction (p < 0.05) (1.5 log₁₀ cfu/cm² reduction) in E. coli O157:H7 numbers compared to the numbers recovered on samples treated with water only. These findings demonstrate the potential use of e11/2 and e4/1c phages as a biocontrol agent for E. coli O157:H7 within various stages of the food chain, including on cattle hide.     

Mathematical modeling the cross-contamination of Escherichia coli O157:H7 on the surface of ready-to-eat meat product while slicing

Microbial cross-contamination either at home or production site is one of the major factors of causing contamination of foods and leading to the foodborne illness. The knowledge regarding Escherichia coli O157:H7 surface transfer on ready-to-eat (RTE) deli meat and the slicer used for slicing different RTE products are needed to ensure RTE food safety. The objectives of this study were to investigate and to model the surface cross-contamination of E. coli O157:H7 during slicing operation. A five-strain cocktail of E. coli O157:H7 was inoculated directly onto a slicer's round blade rim area at an initial level of ca. 4, 5, 6, 7 or 8 log CFU/blade (ca. 3, 4, 5, 6 or 7 log CFU/cm² of the blade edge area), and then the RTE deli meat (ham) was sliced to a thickness of 1–2 mm. For another cross-contamination scenario, a clean blade was initially used to slice ham which was pre-surface-inoculated with E. coli O157:H7 (ca. 4, 5, 6, 7 or 8 log CFU/100 cm² area), then, followed by slicing un-inoculated ham. Results showed that the developed empirical models were reasonably accurate in describing the transfer trend/pattern of E. coli O157:H7 between the blade and ham slices when the total inoculum level was ≥5 log CFU on the ham or blade. With an initial inoculum level at ≤4 log CFU, the experimental data showed a rather random microbial surface transfer pattern. The models, i.e., a power equation for direct-blade-surface-inoculation, and an exponential equation for ham-surface-inoculation are microbial load and sequential slice index dependent. The surface cross-contamination prediction of E. coli O157:H7 for sliced deli meat (ham) using the developed models were demonstrated. The empirical models may provide a useful tool in developing the RTE meat risk assessment.     

Effect of cooking procedures of kiymali pide,a traditional Turkish fast-food,on destruction of Escherichia coli O157:H7

The objective of the present study was to obtain data about cooking time and temperature of kiymali pide in the restaurants and to investigate thermal inactivation of E. coli O157:H7 during experimental kiymali pide making. A field study was conducted in randomly selected 23 of 87 pide restaurants. Processing parameters including oven temperature, cooking period and post-cooking temperature were determined. Kiymali pide samples were prepared using ground beef filling experimentally inoculated with E. coli O157:H7 (7.6 log₁₀ CFU/g). Pide samples were cooked at a conventional oven at 180 °C for 180, 240, 270, 300 and 330 s. Results of the current study suggest that cooking kiymali pide at 180 °C for at least 330 s (5.5 min) may provide sufficient food safety assurance (≥ 6 log₁₀ CFU/g) for E. coli O157:H7.     

Cloning of genes encoding colicin E2 in Lactococcus lactis subspecies lactis and evaluation of the colicin-producing transformants as inhibitors of Escherichia coli O157:H7 during milk fermentation

Colicin E2 (ColE2) is a proteinaceous bacterial toxin produced by some strains of Escherichia coli and other members of the Enterobacteriaceae that exhibits inhibitory activity against some strains of E. coli O157:H7. A 2.0-kb DNA fragment, containing the ColE2 structural gene ceaB and immunity gene ceiB from E. coli NCTC 50133 (pColE2-P9), was cloned into the lactococcal plasmid vector pNZ2103. The lysis gene, celB, was not cloned. The plasmid, pLR-E2, encoding the cloned genes was transformed into E. coli DH5α and Lactococcus lactis ssp. lactis LM0230 and PN-1 using electroporation. The bacteriocin ColE2 was expressed in transformants of both E. coli and L. lactis ssp. lactis. Secretion of ColE2 into media was verified by spot-on-lawn assays and measurement of ColE2 activity in the growth medium of transformants. The level of ColE2 produced by transformants containing pLR-E2 was similar to that produced by the parental strain, E. coli NCTC 50133 (pColE2-P9). Evaluation of a ColE2-producing transformant of L. lactis ssp. lactis as a starter culture revealed that, although ColE2 was produced by transformants and could be detected in milk during fermentation, the inhibitory activity of ColE2 against E. coli O157:H7 was significantly decreased in milk compared with buffered growth medium.