Tolerance mechanism of the ethanol-tolerant mutant of sake yeast

Several ethanol-tolerant mutants have been bred from industrial sake yeasts, but the mechanism of ethanol tolerance in these mutants has not been elucidated. After the determination of the entire genome sequence of Saccharomyces cerevisiae, various methods to monitor the whole-gene expression of the yeast have been developed. In this study, we used a commercially available nylon membrane on which virtually every gene of S. cerevisiae was spotted to compare expression profiles between the ethanol-tolerant mutant and its parent sake yeast to investigate the mechanism of ethanol tolerance in this mutant. As a result, we found that several genes were highly expressed only in the ethanol-tolerant mutant but not in the parent strain. These genes were known to be induced in cells that were exposed to various stresses, such as ethanol, heat, and high osmolarity, or at the stationary-phase but not at the log-phase. In the ethanol-tolerant mutant, the expression level of these stress-responsive genes was further increased after exposure to ethanol. We also found that substances such as catalase, glycerol and trehalose that may have protective roles under stressful conditions were accumulated in high amounts in the ethanol-tolerant mutant. The ethanol-tolerant mutant also exhibited resistance to other stresses including heat, high osmolarity and oxidative stress in addition to ethanol tolerance. These results indicate that the mutant exhibits multiple stress tolerance because of elevated expression of stress-responsive genes, resulting in accumulation of stress protective substances.     

Breeding of a high tyrosol‐producing sake yeast by isolation of an ethanol‐resistant mutant from a trp3 mutant

A novel breeding strategy for a high tyrosol‐producing sake yeast was developed by isolating an ethanol‐resistant mutant from a tryptophan auxotrophic mutant of a sake brewery yeast. Since tyrosol has antioxidant, cardioprotective and taste‐sharpening effects, increasing the tyrosol level of alcohol beverages could be beneficial in alcohol production. Since the transporters of aromatic amino acids are degraded by several stresses and mutants defective in the synthesis of aromatic amino acids are sensitive to ethanol, it was hypothesized that the degradation of these transporters should be inhibited in ethanol resistant mutants isolated from the auxotrophic mutants of aromatic amino acids, and that the uptake of aromatic amino acids would be increased in the mutants. Consistent with this hypothesis, sake was brewed with the ethanol‐resistant mutant of a tryptophan auxotrophic mutant and the sake was found to contain a lesser content of tyrosine and a higher content of tyrosol relative to the sake brewed with the parental strains. The taste of the sake brewed with the mutant strain could be discriminated from the sake brewed with the parental strains, probably because of the altered concentrations of tyrosol and certain amino acids and organic acids. The results suggest that combining the isolation of an ethanol‐resistant mutant and an auxotrophic mutant is an effective method to breed a brewing strain with a modified metabolism of these substances. Copyright © 2012 The Institute of Brewing & Distilling     

Inhibition of mitochondrial fragmentation during sake brewing causes high malate production in sake yeast

We previously demonstrated the presence and fragmentation of mitochondria during alcohol fermentation. Here, we show that Fis1p induces mitochondrial fragmentation, and inhibition of mitochondrial fragmentation causes higher malate production during sake brewing. These findings indicate that mitochondrial morphology affects the metabolism of constituents, providing a breeding strategy for high-malate-producing yeasts.     

Isolation and characterization of sake yeast mutants deficient in gamma-aminobutyric acid utilization in sake brewing

Sake yeasts take up gamma-aminobutyric acid (GABA) derived from rice-koji in the primary stage of sake brewing. The GABA content in sake brewed with the UGA1 disruptant, which lacked GABA transaminase, was higher than that brewed with the wild-type strain K701. The UGA1 disruptant derived from sake yeast could not grow on a medium with GABA as the sole nitrogen source. We have isolated the sake yeast mutants of K701 that were unable to grow on a medium containing GABA as the sole nitrogen source. The growth defect of GAB7-1 and GAB7-2 mutants on GABA plates was complemented by UGA1, which encodes GABA transaminase, and UGA2, which encodes succinic semialdehyde dehydrogenase (SSADH), respectively. DNA sequence analysis revealed that GAB7-1 had a homozygous nonsense mutation in UGA1 and GAB7-2 had a heterozygous mutation (G247D) in UGA2. The GABA transaminase activity of GAB7-1 and the SSADH activity of GAB7-2 were markedly lower than those of K701. These GAB mutants displayed a higher intracellular GABA content. The GABA contents in sake brewed with the mutants GAB7-1 and GAB7-2 were 2.0 and 2.1 times higher, respectively, than that brewed with the wild-type strain K701. These results suggest that the reduced function of the GABA utilization pathway increases the GABA content in sake.     

Improvement of isoamyl acetate productivity in sake yeast by isolating mutants resistant to econazole

Sake yeast strains were improved so as to produce larger amounts of isoamyl acetate than the parental strain by isolating econazole-resistant mutants. Econazole, an imidazole antimycotic, directly interacts with unsaturated fatty acids in the yeast cell membrane, where it also inhibits the synthesis of ergosterol and decreases the ratio of unsaturated to saturated fatty acids. In contrast, alcohol acetyltransferase (AATase), which catalyzes the synthesis of isoamyl acetate, is inhibited by unsaturated fatty acids. Fifty econazole-resistant mutants were isolated from a sake yeast, Kyokai no. 701, several of which produced approximately 1.4 to 2.4 times more isoamyl acetate and an almost equal amount of isoamyl alcohol compared with the parental strain. The AATase activities of the mutants in koji extract were 1.2 to 1.4 times higher, and the unsaturated to saturated fatty acid ratios were lower, than in the parental strain.     

Characteristics of the high malic acid production mechanism in Saccharomyces cerevisiae sake yeast strain No. 28

We characterized a high malic acid production mechanism in sake yeast strain No. 28. No considerable differences in the activity of the enzymes that were involved in malic acid synthesis were observed between strain No. 28 and its parent strain, K1001. However, compared with strain K1001, which actively took up rhodamine 123 during staining, the cells of strain No. 28 were only lightly stained, even when cultured in high glucose concentrations. In addition, malic acid production by the respiratory-deficient strain of K1001 was 2.5-fold higher than that of the wild-type K1001 and wild-type No. 28. The findings of this study demonstrated that the high malic acid production by strain No. 28 is attributed to the suppression of mitochondrial activity.     

Effect of NAD+-dependent isocitrate dehydrogenase gene (IDH1, IDH2) disruption of sake yeast on organic acid composition in sake mash

The ratio of organic acids in sake mash is a very important factor affecting the taste of alcoholic beverages. To alter the organic acid composition in sake and investigate the mechanism of producing organic acids in sake mash, we examined the effect of NAD+-dependent isocitrate dehydrogenase (IDH) activity deficiency in sake yeast by disrupting the IDH1 or IDH2 gene. Two haploid strains (MATa or MATa genotype) isolated from sake yeast Kyokai no. 701 (K701) were disrupted using the aureobasidin A resistant gene (AUR1-C) as a selection marker. These disruptants were defective in the activity of IDH and failed to grow on medium containing glycerol as a sole carbon source. Sake meter, alcohol concentration, and glucose consumption in sake brewed with the disruptants were reduced in comparison with those of the parental strains. The production of citrate (including isocitrate), malate, and acetate by the disruptants was increased, but succinate production was reduced to approximately half in comparison with the parental strains. These results indicate that approximately half the amount of succinate in sake mash is produced via the oxidative pathway of the TCA cycle in sake yeast. While the diploid strain constructed by mating haploid disruptants for the IDH gene exhibited stronger fermentation ability than the haploid disruptants, almost similar profiles of components in sake were obtained for both strains.     

Cloning and analysis of the AWA1 gene of a nonfoaming mutant of a sake yeast

Almost all sake yeasts form a thick foam layer on sake mash during fermentation. To reduce the amount of foam, nonfoaming mutants were bred from foam-forming sake yeasts. To elucidate the mechanism of this foam formation, we have cloned a gene from a foam-forming sake yeast that confers foam-forming ability to a nonfoaming mutant. This gene, named AWA1, encodes a glycosylphosphatidylinositol (GPI) anchor protein that is localized to the cell wall and is required for cell surface hydrophobicity. In this paper, we describe the genomic analysis of the AWA1 gene in a nonfoaming mutant strain K701 derived from a foam-forming sake yeast strain K7. K701-AWA1 was cloned in a cosmid and its sequence was compared with that of K7-AWA1. Although the 5' half of K701-AWA1 was identical to that of K7-AWA1, the 3' half of K701-AWA1 was different from that of K7-AWA1, resulting in a loss of the C-terminal hydrophobic sequence of Awa1p. Since this sequence is considered to be required for the anchoring of Awa1p to the cell wall, K7-Awa1p could not confer both cell surface hydrophobicity and foam-forming ability to strain K701 cells. Since the change found in K701-AWA1 was not a point mutation but a larger scale event, we analyzed chromosome rearrangement by pulsed-field gel electrophoresis Southern blot analyses. The results suggest that the left subtelomeric region of chromosome IX in strain K7 was translocated to the AWA1 gene in chromosome XV by a nonreciprocal recombination.     

Mitochondrial dynamics of yeast during sake brewing

The presence of mitochondria during alcohol fermentation has not been studied. Here, we examined the yeast mitochondrial structure during sake brewing using the green fluorescent protein. Mitochondrial structures were observed throughout brewing and they fragmented as brewing proceeded. This study is the first to show direct evidence of the presence of mitochondria during alcohol fermentation.     

QTL mapping of sake brewing characteristics of yeast

A haploid sake yeast strain derived from the commercial diploid sake yeast strain Kyokai no. 7 showed better characteristics for sake brewing compared to the haploid laboratory yeast strain X2180-1B, including higher production of ethanol and aromatic components. A hybrid of these two strains showed intermediate characteristics in most cases. After sporulation of the hybrid strain, we obtained 100 haploid segregants of the hybrid. Small-scale sake brewing tests of these segregants showed a smooth continuous distribution of the sake brewing characteristics, suggesting that these traits are determined by multiple quantitative trait loci (QTLs). To examine these sake brewing characteristics at the genomic level, we performed QTL analysis of sake brewing characteristics using 142 DNA markers that showed heterogeneity between the two parental strains. As a result, we identified 25 significant QTLs involved in the specification of sake brewing characteristics such as ethanol fermentation and the production of aromatic components.     

Mitochondrial activity of sake brewery yeast affects malic and succinic acid production during alcoholic fermentation

The mitochondrial states and activities of production yeasts used in the fermentation industry vary according to the availability of oxygen, size of the fermentation tank and temperature of the raw material. However, the involvement of the mitochondrial states of these yeasts in the production profile of organic acids during alcoholic fermentation has not been investigated in detail. In this study, the effects of the mitochondrial state of a sake brewing yeast on the organic acid production profile during an alcoholic fermentation process were investigated. It was elucidated that the mitochondrial state during the propagation stage significantly affected the mitochondrial morphology and the organic acid production profile during the alcoholic fermentation. When yeast mitochondria were active, they were highly branched in the propagation stage, and the yeast cells produced significantly more succinate and less malate. In contrast, when the yeast mitochondria were inactive, they were long and filamentous in appearance, and the yeast produced significantly less succinate and more malate. The change in malic acid content was reversed when an uncoupler of mitochondrial membrane potential, carbonylcyanide p‐trifluoromethoxyphenylhydrazone, was added to the culture, indicating that the change in the organic acid production profile could be attributed to mitochondrial activity. Furthermore, the content of malic acid and succinic acid could be converted from a respirative to a fermentative profile by exposing the yeast to a mitochondrion‐inactivating environment for 12 or 24 h. Taken together, it was shown that the mitochondrial status of the yeast affects malic acid production during alcoholic fermentation. Copyright © 2012 The Institute of Brewing & Distilling     

基于常压室温等离子体诱变技术选育高产色氨酸突变株的研究

本研究通过常压室温等离子体(ARTP)微生物育种技术,选育到一株高产L-色氨酸的突变株TRP-YP-3-2.与出发菌TRP-1201相比,该突变株生长及耗糖更快、产酸更高.TRP-YP-3-2色氨酸产量达到61.4 g/L,糖酸转化率达到19.25％,比出发菌分别提高了15.41％和22.77％.TRP-YP-3-2的产酸遗传稳定性研究发现经过30代培养后,仍具有很好的遗传稳定性.本研究不仅获得了一株高产色氨酸的突变株,具有很大的经济价值;同时确立的育种方法可为其他工业微生物的诱变育种提供有益的参考.     

Characterization of a carotenoid-hyperproducing yeast mutant isolated by low-dose gamma irradiation

To isolate a carotenoid-hyperproducing yeast, Phaffia rhodozyma was treated by low-dose gamma irradiation below 10 kGy. Through repeated rounds of gamma irradiation and visual screening, a mutant 3A4-8 was isolated. It produced 3.3 mg of carotenoid per gram of yeast, 50% higher carotenoid content than that of the unirradiated strain. Glucose and peptone were the most suitable carbon and nitrogen sources for production of carotenoid based on the growth experiment of the mutant under various carbon and nitrogen sources. This result suggests that low-dose gamma irradiation could be used as a means of mutagenesis for isolation of a carotenoid-hyperproducing strain of P. rhodozyma because only the carotenoid-hyperproducing yeast survives gamma irradiation by scavenging oxygen radicals generated by radiolysis of water.     

Breeding of high malate‐producing diploid sake yeast with a homozygous mutation in the VID24 gene

Malate is an important taste component of sake (a Japanese alcoholic beverage) that is produced by the yeast Saccharomyces cerevisiae during alcoholic fermentation. A variety of methods for generating high malate‐producing yeast strains have been developed to date. We recently reported that a high malate‐producing strain was isolated as a mutant sensitive to dimethyl succinate (DMS), and that a mutation in the vacuolar import and degradation protein (VID) 24 gene was responsible for high malate productivity and DMS sensitivity. In this work, the relationships between heterozygous and homozygous mutants of VID24 and malate productivity in diploid sake yeast were examined and a method was developed for breeding a higher malate‐producing strain. First a diploid yeast was generated with a homozygous VID24 mutation by genetic engineering. The homozygous integrants produced more malate during sake brewing and grew more slowly in DMS medium than wild‐type and heterozygous integrants. Thus, the genotype of the VID24 mutation influenced the level of malate production and sensitivity to DMS in diploid yeast. Then a homozygous mutant from a heterozygous mutant was obtained without genetic engineering by ultraviolet irradiation and culturing in DMS with nystatin enrichment. The non‐genetically modified sake yeast with a homozygous VID24 mutation exhibited a higher level of malate productivity than the parent heterozygous mutant strain. These findings provide a basis for controlling malate production in yeast, and thereby regulating malate levels in sake. Copyright © 2016 The Institute of Brewing & Distilling     

啤酒酵母发酵产有机酸的生理代谢机制

以微波破壁和高效液相色谱法,对通风发酵过程中的啤酒酵母细胞胞外、胞内六种有机酸含量的动态变化进行了跟踪检测。研究结果表明,酵母细胞对一部分有机酸有着非常亲缘性的代谢途径和生理机制;柠檬酸等某些有机酸在酵母细胞衰老凋亡时作为碳底物代谢,存在着非常严格的精确保守性、经济效能性调控机制。