Preparation and Spectra Properties of BaO-Al2O3-P2O5-Sm2O3 System Protection Glasses

The forming-regions of phosphate glasses doped with high Sm2O3 contents were studied by two step melting method. The relationship between absorption spectrum and rare earth contents was also discussed. The spectra of BASP glasses were measured by spectrophotometer. The results show that the forming regions will shrink with the increase of Al2O3 and it is difficult to form glass when [PO4]/[AlO4]＜2. The forming regions tend to be a closed elliptical, and the intensity of characteristic absorption peak increases gradually with the increase of Sm2O3, the absorption lines broadens non-uniformly and there is approximate linear relation between optical density at the 1064 nm wavelength and Sm2O3 content.     

Formation and Properties of Phosphate System Protection Glasses Doped by Rare Earth

The forming-regions and properties were studied on phosphate system glasses Sm2O3 doped by two step melting method. It shows that with the increasing of rare earth content, the forming-regions would shrink and the content of Sm2O3 should be controlled in 15 mol %. The structure and absorption spectrum were tested by infra-red spectrum and spectrophotometer. The experimental results provide that with the. increasing of Sm2O3 content, the characteristic absorption peak of 1280 cm- 1 would move to the low wave numbers and vibration weakening, in the absorption spectrum,the intensity of characteristic absorption peak was enhanced and broadened at 1075 nm, and the transmittance of 1060 nm is lessthan 1% .     

Effect of rare earths on viscosity and thermal expansion of soda-lime-silicate glass

Viscosity of soda-lime-silicate glass doped with rare earth oxides(Pr6O11,Eu2O3,Yb2O3) was investigated by the rotating crucible viscometer,the melting temperature and activation energy for viscous flow of the studied melt were derived on the basis of the Arrhenius Equation,the coefficient of thermal expansion,glass transition temperature and dilatometric softening temperature were also determined with dilatometry,in order to reveal the effects of rare earth elements on the behavior of soda-lime-silicate glass.The results showed that introduction of rare earth oxides decreased the viscosity of soda-lime-silicate glass and melting temperature of corresponding melt,increased coefficient of thermal expansion of soda-lime-silicate glass.The glass transition temperature,dilatometric softening temperature,and melting temperature of soda-lime-silicate glass doped with rare earth oxides increased with increasing cationic field strength of corresponding rare earth ions.     

Effect of Y2O3 on Dielectric Properties of BaTiO3 Ceramics

Tiny amount of rare earth Y2O3 can restrain the growth of grains and broaden the peak of BaTiO3 ceramics.Proper characteristics of capacitance change with temperature were obtained. Meanwhile, the insulation resistance increased with the increasing contents of Y2O3. In this system, the cooperation of Y2O3 with Ho2O3 was also discussed.It is concluded that the insulation resistivity reduces if the content of Y2 O3 is below 0.25 %. With the increasing content of additives, weak-binding electrons in grains will be compensated by V"8a so the insulation resistivity increased. The breakdown voltage is enhanced to 15 kV · mm-1.     

Preparation and Thermal Stability of Phosphate System Protection Glasses Doped with Rare Earths

The formation ability and thermal stability of phosphate laser protection glass doped with high Sm2O3 content were discussed. The characteristic temperatures (Tg, Tc, Tm) were measured by DSC and the crystallization parameter β was calculated. The results show that the forming regions would shrink and tend to closed ellipse with increasing of Sm2O3 content. Increasing of BaO/Al2O3 ratio changes the network structure of rare earth glass and improves the thermal stability finally. However, with the increasing of Sm2O3 content, the β increases firstly and then decreases, and finally the thermal stability also increases firstly and then decreases.     

Preparation and laser induced damage properties of rare earth doped BAS glass

Rare earth doped B2O3-Al2O3-SiO2 glass （RExBAS, x=5, 10, 20; RE=La, Sm） were prepared by solid state reaction method. Optical transmission spectra of such glass were characterized by ultraviolet spectrometers, and 1064 nm laser induced damage performance was investigated through the method of ＂1-on-1＂. The results indicated that there was a strong absorptive peak near 1064 nm in SmxBAS glass, the peak was enhanced with increasing x. While LaxBAS glass was transparent to 1064 nm laser, at the same time, the results of laser induced damage showed that the anti-laser induced damage performance of such glass was strengthened with the addition of rare earth oxide. Furthermore, the laser induced damage threshold （LIDT） of SmxBAS glass was significantly higher than that of LaxBAS glass. Consequently, Sm^3＋ doping was favor in the improvement of anti-laser induced damage performance for BAS glass.     

稀土对硼铝硅酸盐玻璃形成及热膨胀性能的影响

探索了稀土掺杂Al2O3-B2O3-SiO2玻璃的形成区范围、稀土掺入量对玻璃形成区的影响,利用热膨胀的测试分析手段,分析了不同掺杂稀土氧化物对玻璃热膨胀性能的影响情况。结果表明:当稀土外掺含量逐渐增加时,玻璃形成区范围先扩大后缩小。稀土氧化物的引入可以有效的改善玻璃硼反常现象的发生,同时也有可能改变网络中间体氧化铝对玻璃网络的作用,即发生了从以网络外体为主变为以网络形成体为主的转变,玻璃的膨胀率降低。     

Research on Glass Forming Ability of Er2O3 -Al2O3 -B2O3 -SiO2 System

The glass forming range of Er2O3-Al2O3-B2O3-SiO2 system was explored, and the effect of the content of Al2 O3 and Er2 O3 on glass-forming region was experimentally examined. It is shown that the region of glass formation range expends when the content of Al2O3 is changed from 15% to 20%, while it shrinks when the content of Er2O3 is changed from 20% to 30%. At the same time, the glass forming ability of Er2O3-Al2O3-B2O3-SiO2 system was also discussed using a value of β, which is an indication of crystallization tendency of glasses, calculated from thermo-analysis data. It is found that the glass forming ability of Er2O3-Al2O3-B2O3- SiO2 glasses is poor, while the glasses network may be enhanced when Al2O3 is added to the system, the glass forming ability being heightened. In addition, the crystallization temperatures of the rare earth glasses were determined using differential thermal analysis technique. The Er2O3-Al2O;-B2O3-SiO2 glass samples were heat treated at 1000,1100 and 1260℃ respectively. The results show that it is the Er2O3 phase that separates out from the glasses after crystaline heat treatment, and it is tiered up in glasses, as detected through XRD and SEM. This indicates that the phase separation occurs when the glasses are heated, Er3 being mainly distributed in the boron rich phase, then separated out from glasses, while the silicate rich phase remaining glassy state.     

稀土氧化物对连铸保护渣结晶温度的影响

为了解决稀土钢浇注时因稀土氧化物进入保护渣导致保护渣性能改变的问题,用热重一差热分析仪系统地观测了稀土氧化物对不同碱度及BaO、B2O3和Li2O含量的保护渣结晶温度的影响。结果表明,稀土氧化物对保护渣结晶温度影响显著,特别是稀土氧化物从零增至5％时最为明显。随着稀土氧化物含量的继续增加,保护渣结晶温度缓慢升高。低碱度可以抑制保护渣中稀土矿物初生晶核的析出;BaO有利于稀土氧化物在保护渣中的溶解和扩散;B2O3基本上可消除稀土氧化物引起的保护渣结晶温度升高的不良影响;Li2O可阻止高熔点结晶相的析出,降低含稀土氧化物保护渣的结晶温度。     

Bonding of Silicon Nitride Ceramic Composite with RE_2O_3Al_2O_3SiO_2 Glass Solders

Ｓｉｌｉｃｏｎｎｉｔｒｉｄｅｃｅｒａｍｉｃｈａｓａｓｅｒｉｅｓｏｆｅｘｃｅｌｌｅｎｔｐｒｏｐｅｒｔｉｅｓ,ｆｏｒｅｘａｍｐｌｅ,ｈｉｇｈｓｔｒｅｎｇｔｈ,ｈｉｇｈｈａｒｄｎｅｓｓ,ｗｅａｒ,ｃｏｒｒｏｓｉｏｎ,ｏｘｉｄａｔｉｏｎａｎｄｓｈｏｃｋｒｅｓｉｓｔａｎｃｅｅｔｃ．,ａｎｄｉｓａｋｉｎｄｏｆｈｉｇｈｔｅｍｐｅｒａｔｕｒｅｓｔｒｕｃｔｕｒａｌｍａｔｅｒｉａｌｗｉｔｈｅｎｏｒｍｏｕｓｐｏｔｅｎｔｉａｌｉｔｉｅｓｆｏｒｆｕｔｕｒｅｄｅｖｅｌｏｐｍｅｎｔ．Ｂｕｔｈｉｇｈｃｏｓｔｆｏｒ…     

Study on Dihydrated Praseodymium Acetylacetonate by Photoacoustic Spectra with Broad Wavelength Range

Photoacousticspectroscopy (PAS)hasbeenusedtonondestructivelyinvestigatealmostallkindsofsam ples,whetherthesampleiscrystalline ,powderorgel .PAspectr oscopyisacalorimetrictechniquewhichmeasurestheenergyabsorbedandsubsequentheatingofthesamplesduetoanonradiativerelaxationpro cess .ThereforePAScanbeusedtostudyopaque ,highlyreflectiveandscatteringsamples ,whicharedif ficulttostudybyconventionalspectroscopytech niques[1] .Withouttheneedofsamplepreparation ,PASavoidstheriskofsamplealteration ,pre…     

Photoluminescent properties of Ca2Gd8(SiO4)6O2: Dy3+ phosphor films prepared by sol-gel process

There are growing interests on phosphor thin films owing to their potential application in high-resolution devices such as cathode ray tubes and flat panel display devices. The solution-based sol-gel method is one of the most important techniques for the synthesis of vari-ous functional coating films. Compounds with the apatite structure are very suitable host lattices for various luminescent ions. Ca2RE8(SiO4)6O2 ( RE=Y, Gd, La ) is a kind of ternary rare-earth-metal silicate with oxyapatite structure, which has been used as host mate-rial for the luminescence of various rare earth and mercury-like ions. In this article, Ca2Gd8(SiO4)6O2:Dy3 phosphor films were dip-coated on quartz glass substrates through the sol-gel process. X-ray diffraction (XRD), atomic force microscopy (AFM), photoluminescence (PL) spectra, as well as lifetimes were used to characterize the resulting films. AFM study revealed that the phosphor films consisted of homoge-neous particles. The Dy3 showed its characteristic emission in crystalline phosphor films, i.e., 4F9/2–6H15/2 and 4F9/2–6H13/2.     

含氟铈基稀土抛光粉的制备及其抛光性能

以碳酸镧铈为前驱体,采用氢氟酸氟化、高温焙烧、机械搅拌磨的方法制备中位粒径较小的含氟铈基稀土抛光粉。结果表明,所得产物中固溶体具有立方萤石结构;随着氟掺杂量的增加,开始析出四方结构的LaOF相,CeO2的XRD特征峰向右偏移,结晶度提高,粉体的振实密度随之增大;对光学玻璃的抛光能力在氟掺杂量为6%时出现极大值,被抛光物体的表面光洁度随氟掺杂量的增大而下降。     

Effects of neodymium and gadolinium on weathering resistance of ZnO-B2O3-SiO2 glass

The ZnO-B203-SiO2 glass doped with Nd2O3 and Gd2O3 was prepared by high temperature melt cooling method. The standard sample of the zinc borosilicate glass was placed in the constant temperature and humidity chamber in order to simulate the atmospheric corrosion process. The surface of the weathered glass was analyzed by scanning electron microscope and energy disper- sive spectrometry and the filtrate was analyzed by inductively coupled plasma-atomic emission spectrometry. The results showed that humidity was the most important factor influencing weathering; the morphology of glass surface of altered layer and the product on the surface was observed; the corroding degree of the zinc borosilicate glass doped with Nd or Gd was significantly lighter than that of the base glass. Adding rare earth Nd or Gd in the zinc borosilicate glass could suppress Na, Zn, Si ion release in weathering.     

Review on Rare Earth／Polymer Composite

The epecial properties of rare earth/polymer composite were described.More emphasis was put on the radiation shielding and magnetic properties,In the application to X-ray shielding,rare earth/polymer composite can make up the feeble absorbing area.If the rare earth content is high enough,it can demonstrate strong ability for thermal neutron absorption,The composite has strong paramagnetism.The feasibility of preparing magnetic rare earth/polymer compostite was discussed,In addition,three preparation methods were introducde:simlle polymerization,mixing and reaction processing,The effect of the rare earth/polymer composties pre-sturcture and the coordinate number of rare eatrh ions on the light property was analyzed,Rare earth/polmer compostie may have the structure and property simlar to those of the ionomer,The feasibility of the in-situ preparation of the rare earth/polymer nano structure is indicated ,Besides,the relationship between struchture and properties of the rare earth/polymer composite was discussed,The problems associated with such composite materials were also presented.     

Fabrication and Luminescence Properties of Ca2Gd8(SiO4)6O2:Er3+ Phosphors via Sol-Gel Process

Ca2RE8(SiO4)6O2 (RE=Y, Gd, La) is a kind of ternary rare-earth-metal silicate with the oxyapatite structure, which was used as host materials for the luminescence of various rare earth and mercury-like ions. Ca2Gd8(SiO4)6O2:Er3 phosphors were prepared through the sol-gel process. X-ray diffraction (XRD), scanning electron microscopy (SEM) and photoluminescence spectra were used to characterize the resulting phosphors. The results of XRD indicate that the phosphors crystallized completely at 1000 ℃. SEM study reveals that the average grain size is 400～1000 nm. In Ca2Gd8(SiO4)6O2:Er3 phosphors, the Er3 shows its characteristic green emission at 528 nm (2H11/2-4I15/2) and 548 nm(4S3/2-4I15/2) upon excitation into 382 nm, with an optimum doping concentration of 5% (mole fraction) of Gd3 in the host lattices.     

熔融制样-X射线荧光光谱法测定轻稀土矿石中8种主量稀土氧化物

稀土矿种类繁多,矿物组成复杂,常富含Ca、P、Fe、Ba、Si、S、Mn、Pb等元素,而采用熔融法制样时,富含Fe、Mn、Pb等单质元素的稀土矿样会腐蚀Pt-Au坩埚。试验将稀土矿石与混合熔剂[m(Li₂B₄O₇)∶m(LiBO₂)=33∶67]以质量比1∶14(稀释比)混合,再加入1mL 500g/L NH₄NO₃溶液为氧化剂、0.2mL 100g/L LiBr溶液为脱模剂,在1050℃下熔融制成均匀玻璃片,使用波长色散X射线荧光光谱法(WDXRF)测定轻稀土矿石中La₂O₃、CeO₂、Pr₆O₁₁、Nd₂O₃、Sm₂O₃、Eu₂O₃、Gd₂O₃、Y₂O₃等8种主量稀土氧化物。方法中稀土氧化物的检出限为5~159μg/g。实验方法用于测定两个稀土矿石标准物质GSB04-3549-2019(稀土总量为4.44%)和GSB04-3309-2016(稀土总量为29.09%)中8种稀土氧化物,低品位稀土矿石标准物质(GSB04-3549-2019)中稀土氧化物测定结果的相对标准偏差(RSD,n=7)小于13%,高品位稀土矿石标准物质(GSB04-3309-2016)中稀土氧化物测定结果的相对标准偏差(RSD,n=7)小于2%。选取2个轻稀土矿石样品(稀土总量分别为2.55%和24.64%),按照实验方法进行稀土总量的加标回收试验,回收率为96%~100%。选取2个稀土矿石标准物质GSB04-3550-2019和GSB04-3311-2016以及2个轻稀土矿石样品,按照实验方法测定La₂O₃、CeO₂、Pr₆O₁₁、Nd₂O₃、Sm₂O₃、Eu₂O₃、Gd₂O₃、Y₂O₃,测定值与标准值或电感耦合等离子体原子发射光谱法(ICP-AES)测定值相吻合。实验方法具有较广的适应性,能满足复杂矿物组成轻稀土矿石中主量稀土氧化物的检测。     

间接碘量法测定稀土硫化物中硫

试验提出了一种用间接碘量法测定稀土硫化物中硫含量的方法:稀土硫化物易与盐酸反应生成硫化氢,而硫化氢气体易和碘反应,故用已知浓度和用量的碘标准溶液完全吸收硫化氢气体,再用已知浓度的硫代硫酸钠标准溶液滴定出未反应的碘标准溶液,从而间接计算出稀土硫化物中硫含量。通过溶剂的选择、碘标准溶液用量及反应摇动时间的研究,确定了适宜的反应条件。结果表明,在稀土硫化物中硫质量分数为10%～25%时的最佳反应条件是:用盐酸作为反应溶剂,0.1 mol/L碘标准溶液用量为35 mL,反应开始至滴定前的剧烈摇动时间为2 min。采用实验方法对稀土硫化物中具有代表性的Ce₂S₃、Sm₂S₃及La₂S₃这3种样品中的硫进行了测定,结果的相对标准偏差(RSD,n=11)小于1%。测定结果与高频红外吸收法及硫酸钡重量法的测定值基本相符。     

微山稀土矿原生矿选矿试验研究

以微山稀土矿原生矿为研究对象，用Ｎａ２ＣＯ３作ｐＨ值调整剂、ＣＨ与ｘｐ－２作混合捕收剂、Ｎａ２ＳｉＯ３和Ｎａ２ＳｉＦ６为联合抑制剂，采用单一浮选流程获得了品位为６８．４８％的高品位精矿和品位为３８．６％的中品位精矿，稀土总收率为８１．０５％。     

Effects of flaky rare earth oxide additives on the high temperature performance of nickel electrodes

Effects of flaky rare earth oxide additives including Er2O3,Tm2O3,and Yb2O3,Lu2O3 on high temperature and high rate discharge performance of nickel electrodes were investigated.The discharge efficiency at 0.2C reached 96% at 60 oC for electrodes with 1 at.% flaky rare earth oxides.The high rate discharge performance for electrodes with flaky rare earth oxides were improved significantly,for example,discharge efficiency at 5C improved from 50% to 70%.The results showed that the end charging potential of the ...