基于Langmuir-Hinshelwood动力学解析O2/CO2/H2O气氛下烟煤焦反应机理

流化床富氧燃烧湿烟气循环兼具经济与环保优势。湿烟气循环（O₂/CO₂/H₂O）条件下煤焦与O₂、CO₂及H₂O的反应同时发生。为探究O₂/CO₂/H₂O气氛下煤焦-O₂、煤焦-CO₂、煤焦-H₂O反应间的相互作用机制,在自制高精度热重实验装置上系统考察了O₂、CO₂、H₂O及其混合气氛下,典型烟煤焦在900℃的反应特性。基于吸附和脱附原理的Langmuir-Hinshelwood（L-H）机理性模型分别计算了烟煤焦与O₂、CO₂和H₂O反应的动力学参数。通过采用单独活性位点与竞争活性位点两种假设分析了O₂/CO₂、O₂/H₂O和CO₂/H₂O气氛下烟煤焦-O₂、烟煤焦-CO₂和烟煤焦-H₂O两两反应间的作用机制,揭示了H₂O分子优先吸附于烟煤焦表面活性位点,O₂分子次之,而CO₂分子相对滞后。O₂/CO₂/H₂O气氛下烟煤焦-O₂、烟煤焦-CO₂、烟煤焦-H₂O反应表现出部分竞争反应活性位点,传统的单独活性位点与竞争活性位点假设均无法准确描述其反应速率特性。基于H₂O分子优先,O₂分子次优先吸附的原理,建立了O₂、CO₂、H₂O混合气氛下煤焦反应速率L-H动力学方程,方程计算结果与实验值良好吻合。研究结果为深入分析煤焦颗粒流化床富氧燃烧特性及构建可靠、准确的燃烧反应模型提供了理论支撑。     

O2/H2O燃烧方式下石灰石的间接硫化反应特性

利用水平管式炉和热重实验台架,对O₂/H₂O、O₂/N₂和O₂/CO₂ 3种不同燃烧方式下石灰石的间接硫化反应特性进行了研究。重点探究了燃烧方式、水蒸气浓度对石灰石间接硫化反应的影响规律与机理。同时,对硫化产物进行了X射线荧光光谱（XRF）、X射线衍射（XRD）、孔结构特性和扫描电镜（SEM）分析。结果表明,O₂/H₂O燃烧方式相比于相同氧浓度下的O₂/N₂和O₂/CO₂燃烧方式,石灰石间接硫化反应的钙转化率在化学反应控制阶段基本相同,在扩散控制阶段O₂/H₂O燃烧方式下的钙转化率有显著的提高。主要原因是水蒸气促进了硫化反应后期产物层内的固态离子扩散。此外,O₂/H₂O燃烧方式下,不同的水蒸气浓度对石灰石的钙转化率基本没有影响。     

基于热重-质谱联用的煤粉富氧燃烧动力学及污染物生成特性

富氧燃烧是最具工业化前景的燃烧中碳捕集技术之一,为更深入掌握煤粉富氧燃烧的着火模式和污染物生成特性,本文构建了热重-质谱联用实验系统,以烟煤和无烟煤标准煤样为对象,针对3个不同的氧气体积分数：21%、30%和50%,研究了O₂/Ar和O₂/CO₂气氛下煤粉的富氧燃烧特性。结果表明,O₂/CO₂气氛下煤粉着火温度和燃尽温度均降低,燃烧速率提高,燃烧时间缩短;两种煤粉在O₂/Ar气氛下的燃烧都属于非均相着火,而富氧燃烧都属于均相着火模式;氧气体积分数在30%以上时,无烟煤O₂/CO₂燃烧的表观活化能明显低于O₂/Ar气氛,在相同工况下烟煤的表观活化能均低于无烟煤;O₂/CO₂气氛促进了CO和挥发分NO的逸出,生成温度均低于O₂/Ar气氛,CO会对NO起到还原作用。     

添加剂CH3COONH4对介质阻挡-电晕放电耦合法脱除NO、SO2的影响

采用自行研究设计的介质阻挡-电晕放电等离子体反应装置在模拟烟气中进行NO、SO₂的脱除研究。考察了O₂、CO₂、水蒸气等气体组分对脱除NO、SO₂的影响,并进一步探讨了添加剂CH₃COONH₄对脱除NO、SO₂的影响及作用机理。实验结果表明：O₂、CO₂和水蒸气浓度的增加对NO脱除有抑制作用,而引入CH₃COONH₄后,这些抑制作用会被减弱,使NO的脱除率得到大幅度提升,但这些抑制作用不会完全消除。在引入CH₃COONH₄后,气体组分和输入电流的变化对脱除SO₂的影响不明显,SO₂脱除率可达到94%左右。在N₂/O₂/CO₂/H₂O/NO/SO₂体系中加入0.27%的CH₃COONH₄后,NO初始浓度不变的条件下,SO₂含量较少时,对NO的脱除影响不明显,随着SO₂浓度的增加,NO的脱除率不断下降,增加CH₃COONH₄的添加量可消除SO₂的影响;另一方面,在SO₂初始浓度恒定的条件下,随着NO含量的增加,SO₂的脱除率保持在94%左右。在N₂/O₂/CO₂/H₂O/NO/SO₂体系中加入0.51%的CH₃COONH₄后,输入电流2.5A时,NO的脱除率达到72%。     

不同烟气组分对粉状活性焦吸附汞的影响机理

在模拟燃煤热烟气为热源和介质条件下，以准东褐煤为原料，通过一维沉降炉进行炭化活化（一步法）制备粉状活性焦，考察了活性焦对Hg⁰的吸附能力，探索了SO₂、H₂O、O₂、CO₂、H₂O+O₂、SO₂+O₂及H₂O+SO₂+O₂气氛对活性焦吸附Hg⁰的影响机理。结果表明：一步法获得的活性焦对Hg⁰具有较高的吸附性能。N₂气氛作对比，H₂O、H₂O+O₂、CO₂和SO₂气氛下抑制活性焦对Hg⁰的吸附；O₂、SO₂+O₂和H₂O+SO₂+O₂促进活性焦对Hg⁰的吸附。通过Hg 4f的XPS分析证明了不同气氛组成对活性焦吸附Hg⁰的抑制和促进机理。H₂O覆盖在活性焦活性位上和堵塞孔隙而抑制活性焦对Hg⁰的吸附；SO₂与Hg⁰在活性焦上发生竞争吸附而抑制对Hg⁰的吸附；CO₂ 吸附在活性焦微孔上而抑制对Hg⁰的吸附；O₂气氛下主要形成了HgO, SO₂+O₂气氛下Hg⁰被氧化成HgSO₃，进一步氧化成HgSO₄； H₂O+SO₂+O₂气氛下，Hg⁰被氧化成HgO和HgSO₄。     

温度和气氛对高K高S糠醛渣灰分的烧结特性研究

糠醛渣的能源化利用是糠醛产业清洁生产和碳减排的有效途径。然而,现有的直接燃烧利用常面临着因糠醛渣高K引起的灰分烧结严重、高S导致的SO_x排放量大和高水含量导致的燃烧效率低等难题。基于此,在管式炉中考察了单一气氛(N₂、CO₂、O₂)和混合气氛(N₂+H₂O、CO₂+H₂O、O₂+H₂O)中糠醛渣灰在不同温度下的烧结特性,并对灰分颜色、收缩率、微观形貌、矿物质成分和K/S释放等特性进行系统分析。灰分热收缩行为显示,随温度升高,灰样收缩率增加;在单一气氛中添加水蒸气能促进灰分烧结。SEM分析发现,在灰分烧结前,其微观结构在低温下已出现熔融和结渣。XRD分析表明,灰分烧结与低熔点矿物生成紧密相关。单一气氛中,高温下N₂促进钾长石生成;CO₂抑制钾长石生成;O₂促进钙铝黄长石和透辉石生成。在混合气氛中,水蒸气的出现促进多种低熔点钾铝硅酸盐生成,如钾长石和白榴石等。XRF分析显示,随温度升高,灰样中K的固留率(G_K)和S的固留率(G_S)降低;在考察的单一气氛中,高温时,N₂中G_K最低;G_S受气氛的影响较小。在考察的复合气氛中,高温时,G_K受气氛影响较小;G_S受气氛影响严重,特别地,O₂+H₂O气氛中G_S最高,S逸散最少。为抑制糠醛渣灰分烧结和K/S元素逸散到气相中,糠醛渣在流化床燃烧过程中应控制运行温度(低于900℃)、降低气氛中N₂的含量。     

褐煤氧化和气化反应协同作用下夹带流反应器的建模

为了建立?80mm×3000mm下行夹带流煤气化反应器模型,以胜利褐煤为原料,在该反应器中进行了N₂、O₂、H₂O、H₂O+O₂气氛下800℃/900℃气化实验,研究了流场分布、主要反应发生区域,并结合反应机理和缩合模型推导了不同速控步/气化气氛下C-O₂氧化和C-H₂O气化速率方程。结果发现,实验条件下,喷嘴附近的射流区及其周围的回流区仅占反应器高度的5%,气相主要以平推流流动;热解和燃烧反应同时发生,反应器分为热解燃烧区和气化区;气膜扩散控制下的C-O₂氧化速率方程和化学反应控制时C-H₂O气化速率方程与实验数据吻合较好;相对H₂O气氛,H₂O+O₂气氛下C-H₂O气化反应的表观气化反应速率常数明显较大,尤其在高温下,建模时需分别考虑H₂O和H₂O+O₂气氛下气化速率。这主要是由于氧化反应的开孔/扩孔作用使碳颗粒微孔数量、比表面积、孔容增加,促进了C-H₂O气化反应。采用MATLAB编程拟合求解模型中未知参数和模型,对12组实验（60个数据点）进行预测,85%预测值误差小于20%,70%预测值误差小于10%。对褐煤转化率的预测,75%预测值误差小于4.6%。建立的反应器模型误差较小,为反应器设计和放大奠定基础。     

乙醇胺对介质阻挡耦合电晕放电同时脱除NO、SO2的影响

采用自行设计的介质阻挡耦合电晕放电等离子体反应装置进行了模拟烟气同时脱硫脱硝的研究,分别考察乙醇胺（HOCH₂CH₂NH₂,MEA）在不同模拟烟气体系中对NO、SO₂脱除的影响,深入探讨了MEA在放电过程中与NO的作用机理。结果表明：在N₂/O₂/SO₂/NO体系中,0.56% MEA的加入可以显著消除O₂对NO脱除的抑制作用;在N₂/CO₂/SO₂/NO体系中,MEA会吸收进入体系中的部分CO₂,以减弱CO₂对NO脱除的抑制;在N₂/O₂/CO₂/H₂O/NO/SO₂体系中,0.56% MEA的加入既可以有效减弱H₂O的影响,也可以使NO的脱除率达到71.28%,继续将MEA的体积分数增大至1.20%时,可将该体系下NO脱除率提高到81.25%;同时,MEA可以在短时间内高效吸收体系内的SO₂,且几乎不受其他气体成分的影响,SO₂脱除率保持在95%左右。     

带压环境中CO2/H2O/N2气体稀释对合成气层流火焰速度的影响

合成气稀释燃烧是燃气轮机高效低污染燃烧的重要运行方式。本文以CO₂、H₂O和N₂为稀释气体,利用数值模拟方法研究稀释比对不同压力下合成气（CO/H₂/CH₄）层流火焰速度（S_L）的影响规律,并从自由基浓度变化、敏感性数值和生成速率（rate of production,ROP）三个方面解析三种气体的物理和化学作用机理。结果表明,S_L随燃烧压力和稀释比的增大而不断减小,其中CO₂对层流火焰速度的抑制最为显著。稀释气体的物理效应对层流火焰速度的影响远大于化学效应,但CO₂和H₂O的化学效应不能忽略。化学效应则是通过改变H和OH自由基浓度影响S_L,其中CO₂稀释降低H和OH自由基浓度,H₂O稀释则是降低H自由基浓度,从而降低合成气的层流火焰速度。进一步反应动力学分析发现了H/OH浓度变化在低压、加压下的主要化学反应路径,且受H₂O稀释的化学反应速率对压力较CO₂更为敏感。     

干馏层气氛对半焦结构及其CO2气化活性影响

固定床煤气化炉中气氛对干馏层生成半焦的活性影响较大。对不同气氛下制得的半焦进行了CO₂气化活性实验，并采用拉曼光谱和氮吸附对半焦进行了表征。结果表明：与N₂气氛下制得的半焦相比，通入其他气体可以提高半焦的CO₂气化活性，单组分中H₂O气氛下制得的半焦的CO₂气化活性最强，双组分中CO₂+H₂和CO+H₂O气氛下制得的半焦的气化活性明显增加，而且双组分气氛下的CO₂气化活性比前者强；半焦比表面积的增加有利于其CO₂气化活性的提高，但半焦化学结构的变化对其CO₂气化活性的提高作用更明显。     

Effect of gas composition on nitric oxide removal from simulated flue gas with DBD-NPC method

A new method for nitric oxide (NO) removal was developed by combining dielectric barrier discharge (DBD) and negative pulse corona (NPC). The effects of gas composition (O₂, CO₂, and H₂O) on NO removal were investigated with this method, and the effect of alcohols (methanol and ethanol) addition on NO removal was also investigated as well as the reaction mechanisms to enhance the NO removal efficiency. The experimental results showed that O₂, CO₂, and H₂O had obvious inhibition effects on NO removal, and the negative effects were in the following order:O₂ > CO₂ > H₂O. The addition of methanol or ethanol in the reaction system could mitigate the negative effects of O₂, CO₂, and H₂O on NO removal, and also eliminated the production of NO₂. The positive effect of alcohols addition with DBD-NPC denitration method was also validated in the simulated flue gas, in which the NO_x (NO, NO₂) was mainly converted into N².     

Effects of selective reduction of nitric oxide on zeolite structure

The chemical changes that occurred in a Cu-ZSM-5 catalyst during the selective reduction of NO with i-C₄H₁₀ in the presence and absence of O₂ were catalogued. In the presence of excess O₂ complete conversion of the NO to N₂ and the hydrocarbon to CO₂ and H₂O occurred and the Cu²⁺ concentration estimated from the integrated intensity of the electron paramagnetic resonance (EPR) signal was not significantly changed from its initial value. When the oxygen concentration was lowered below the point of stoichiometry, however, both of these conversions decreased modestly, but when O₂ was eliminated from the feed both conversions fell precipitously and the acid catalyzed decomposition products of isobutane appeared in the products instead of CO₂ and H₂O. These changes were accompanied by corresponding changes in the EPR data. Lowering the O₂ below the point of stoichiometry effected a loss of from 30% to 50% of the intensity of the Cu²⁺ signal. Eliminating O₂ reduced the signal by several orders of magnitude. Remarkably, these reduced catalysts could be restored to their initial oxidation states by adding excess O₂ into the feed stream, even when there was evidence that Cu⁰ was present. Dealumination accompanied selective reduction even in excess O₂, particularly above 623 K. This was probably caused by steaming of the catalyst by the H₂O produced in the reaction.     

水/二氧化碳气氛下酒糟催化气化反应特性的研究

在固定床气化装置中,以赤泥为催化剂、水/二氧化碳为气化剂对酒糟进行气化实验。研究了赤泥添加量、气化温度和V（水）/V（二氧化碳）对酒糟气化活性的影响,并对水/二氧化碳共气化协同机理进行了探讨。结果表明：当赤泥添加量为20%（质量分数）时气化活性最佳;升高气化温度有利于提高气化反应活性;随着V（水）/V（二氧化碳）的增大,合成气产量、n（氢气）/n（一氧化碳）均增加,分别达到270.7 mmol/g和6.67;在水/二氧化碳混合气氛下共气化反应产生了明显的协同效应,协同因子在60%水-40%二氧化碳（体积分数）时达到峰值。拉曼光谱、扫描电子显微镜及比表面积分析表明：水/二氧化碳混合气氛下酒糟焦无定形碳和非晶碳结构的破坏程度比在纯水或二氧化碳中更严重,验证了二氧化碳和水在酒糟气化中存在协同效应;二氧化碳更容易在酒糟焦表面发生气化反应,形成大量微孔使其比表面积增加;水炭渗透力较强有利于形成中孔;在水/二氧化碳混合气氛下,二氧化碳与水产生的交互作用促进了孔结构的发育,使酒糟焦的微孔发展为中孔和大孔并促使气化反应向酒糟颗粒内部发展,这是协同效应产生的主要原因。     

Quantified NOx adsorption on Pt/K/gamma-Al2O3 and the effects of CO2 and H2O

A multi-component NO_x-trap catalyst consisting of Pt and K supported on γ-Al₂O₃ was studied at 250 °C to determine the roles of the individual catalyst components, to identify the adsorbing species during the lean capture cycle, and to assess the effects of H₂O and CO₂ on NO_x storage. The Al₂O₃ support was shown to have NO_x trapping capability with and without Pt present (at 250 °C Pt/Al₂O₃ adsorbs 2.3 μmols NO_x/m²). NO_x is primarily trapped on Al₂O₃ in the form of nitrates with monodentate, chelating and bridged forms apparent in Diffuse Reflectance mid-Infrared Fourier Transform Spectroscopy (DRIFTS) analysis. The addition of K to the catalyst increases the adsorption capacity to 6.2 μmols NO_x/m², and the primary storage form on K is a free nitrate ion. Quantitative DRIFTS analysis shows that 12% of the nitrates on a Pt/K/Al₂O₃ catalyst are coordinated on the Al₂O₃ support at saturation.

When 5% CO₂ was included in a feed stream with 300 ppm NO and 12% O₂, the amount of K-based nitrate storage decreased by 45% after 1 h on stream due to the competition of adsorbed free nitrates with carboxylates for adsorption sites. When 5% H₂O was included in a feed stream with 300 ppm NO and 12% O₂, the amount of K-based nitrate storage decreased by only 16% after 1 h, but the Al₂O₃-based nitrates decreased by 92%. Interestingly, with both 5% CO₂ and 5% H₂O in the feed, the total storage only decreased by 11%, as the hydroxyl groups generated on Al₂O₃ destabilized the K–CO₂ bond; specifically, H₂O mitigates the NO_x storage capacity losses associated with carboxylate competition.     

Investigation of CO oxidation and NO reduction on three-way monolith catalysts with transient response techniques

The kinetics of CO oxidation and NO reduction reactions over alumina and alumina-ceria supported Pt, Rh and bimetallic Pt/Rh catalysts coated on metallic monoliths were investigated using the step response technique at atmospheric pressure and at temperatures 30–350°C. The feed step change experiments from an inert flow to a flow of a reagent (O₂, CO, NO and H₂) showed that the ceria promoted catalysts had higher adsorption capacities, higher reaction rates and promoting effects by preventing the inhibitory effects of reactants, than the alumina supported noble metal catalysts. The effect of ceria was explained with adsorbate spillover from the noble metal sites to ceria. The step change experiments CO/O₂ and O₂/CO also revealed the enhancing effect of ceria. The step change experiments NO/H₂ and H₂/NO gave nitrogen as a main reduction product and N₂O as a by-product. Preadsorption of NO on the catalyst surface decreased the catalyst activity in the reduction of NO with H₂. The CO oxidation transients were modeled with a mechanism which consistent of CO and O₂ adsorption and a surface reaction step. The NO reduction experiments with H₂ revealed the role of N₂O as a surface intermediate in the formation of N₂. The formation of NN bonding was assumed to take place prior to, partly prior to or totally following to the NO bond breakage. High NO coverage favors N₂O formation. Pt was shown to be more efficient than Rh for NO reduction by H₂.     

Water vapor sensitivity of nanosized La(Co, Mn, Fe)1−x(Cu, Pd)xO3 perovskites during NO reduction by C3H6 in the presence of oxygen

A series of La(Co, Mn, Fe)_1−x(Cu, Pd)_xO₃ perovskites having high specific surface areas and nanosized crystal domains was prepared by reactive grinding. The solids were characterized by N₂ adsorption, X-ray diffraction (XRD), scanning electron microscopy (SEM), temperature programmed desorption (TPD) of O₂, NO + O₂, C₃H₆, in the absence or presence of 5% H₂O, Fourier transform infrared (FTIR) spectroscopy, as well as activity tests towards NO reduction by propene under the conditions of 3000 ppm NO, 3000 ppm C₃H₆, 1% O₂, 0 or 10% H₂O, and 50,000 h⁻¹ space velocity. The objective was to investigate the influence of H₂O addition on catalytic behavior. A good performance (100% NO conversion, 77% N₂ yield, and 90% C₃H₆ conversion) was achieved at 600 °C over LaFe_0.8Cu_0.2O₃ under a dry feed stream. With the exposure of LaFe_0.8Cu_0.2O₃ to a humid atmosphere containing 10% water vapor, the catalytic activity was slightly decreased yielding 91% NO conversion, 51% N₂ yield, and 86% C₃H₆ conversion. A competitive adsorption between H₂O vapor with O₂ and NO molecules at anion vacancies over LaFe_0.8Cu_0.2O₃ was found by means of TPD studies here. A deactivation mechanism was therefore proposed involving the occupation of available active sites by water vapor, resulting in an inhibition of catalytic activity in C₃H₆ + NO + O₂ reaction. This H₂O deactivation was also verified to be strictly reversible by removing steam from the feed.