Improvement of Foaming Property of Egg White Protein by Phosphorylation through Dry-Heating in the Presence of Pyrophosphate

ABSTRACT:  Egg white protein (EWP) was phosphorylated by dry-heating in the presence of pyrophosphate at pH 4 and 85 °C for 1 d, and the foaming properties of phosphorylated EWP (PP-EWP) were investigated. The phosphorus content of EWP increased to 0.71% as a result of phosphorylation. To estimate the foaming properties of EWP, the foams were prepared by 2 methods: bubbling of the 0.1% (w/v) protein solution and whipping of the 10% (w/w) protein solution with an electric mixer. The foaming power, which was defined as an initial conductivity of foam from 0.1% (w/v) protein solution, was a little higher in PP-EWP than in native EWP (N-EWP), and the foaming stability of PP-EWP was much higher than that of dry-heated EWP (DH-EWP) and N-EWP. The microscopic observation of foams from the 10% (w/w) solution showed that the foams of PP-EWP were finer and more uniform than those of N- and DH-EWP. Although there were no significant differences in the specific gravity and overrun of the foams between PP- and DH-EWP ( P  < 0.05), the specific gravity and overrun of the foams from PP-EWP were smaller and higher, respectively, than that of the foams from N-EWP. The drainage volume was smaller in the foams from PP-EWP than in those from N- and DH-EWP. These results demonstrated that phosphorylation of EWP by dry-heating in the presence of pyrophosphate improved the foaming properties, and that it was more effective for the foam stability than for the foam formation.     

Influence of pH-Induced Unfolding and Refolding of Egg Albumen on Its Foaming Properties

ABSTRACT: The foaming properties of egg albumen, which had been subjected to low and high pH unfolding followed by refolding, were investigated. The foaming capacity of egg albumen, the stability of the foam, or both, could be improved by an unfolding and refolding regime by choosing proper unfolding and refolding pH values. The foaming capacities of egg albumen were greatly improved when the refolding was at pH 6.5, 7.5, or 8.5, whereas the foaming capacities could be either slightly increased or decreased when the refolding was at pH 4.5 or 5.5 compared with the controls. The foam stability was in almost all cases improved by the unfolding and refolding treatments except for a few cases of unfolding at pH 1.5 or 10.5. The foam stability and liquid drainage were improved most when the unfolding was at pH 12.5. Analysis of total and surface sulfhydryl groups, surface hydrophobicity, and protein analysis by sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) provided strong evidence that the partial unfolding of egg albumen proteins as well as the interactions among egg albumen proteins through disulfide and/or hydrophobic groups dictated the improvements in foaming properties. The increase in surface hydrophobicity showed better correlation with the improvement of foaming properties than the change of surface sulfhydryl content did.     

球磨处理对鸡蛋清蛋白结构、性质及起泡性的影响

蛋清因具有优良的起泡性而在焙烤等食品加工领域中被广泛应用,因此,提升蛋清蛋白的起泡性有重要意义.本实验对鸡蛋清蛋白进行球磨处理,通过测定球磨处理后蛋清蛋白的游离巯基含量、表面疏水性、水解度、Zeta-电位和粒径,并分析其热力学性质、二级结构、起泡特性和微观结构,以研究球磨处理对蛋清蛋白结构性质及其起泡性的影响.结果表明...     

超声处理对蛋清蛋白结构性质及蛋清液起泡性的影响

研究脉冲式超声处理对蛋清液拉曼光谱、内源性荧光光谱、静态流变学性质、粒径和理化结构的影响,结合起泡性的变化进行相关性分析。研究发现,超声处理能够改变蛋清蛋白二硫键构象,降低蛋清液黏度,减少总巯基含量,对无规卷曲、β-转角含量和酪氨酸残基峰强比（I850/I830）影响较小,蛋清液依旧为假塑性流体。在超声处理15 min内,蛋清蛋白质粒径、表面巯基含量、热变性焓（ΔH）、α-螺旋和β-折叠含量逐渐减少,内源性荧光强度和表面疏水性逐渐增强,色氨酸残基趋向于“暴露的”展开形式;起泡性得到改善,且泡沫体积小,呈均匀紧密的排列,泡沫稳定性小幅降低。随着超声时间的延长,β-折叠含量继续降低,粒径、表面巯基含量、ΔH、α-螺旋含量、色氨酸残基峰强比（I1 363/I1 338）、内源性荧光强度和表面疏水性呈现不同的变化趋势,起泡性逐渐降低,但泡沫稳定性有所升高。相关性分析表明,起泡性与I1 363/I1 338、表面疏水性呈正相关,与ΔH、平均粒径、α-螺旋含量和表面巯基含量呈负相关,泡沫稳定性与表面疏水性呈负相关。     

茶多酚及其单体和加工环境对蛋清蛋白起泡性能影响的研究

本实验用电动打蛋机搅拌、直接测量的方法测定了茶多酚及其单体对蛋清蛋白质起泡能力和泡沫稳定性的影响,发现茶多酚添加量为0.2% 到0.4% 之间对蛋清蛋白质起泡性有显著的改善,并且发现主要单体EGCG 和ECG的活性羟基是茶多酚提高起泡性能的主要原因。同时也初步探讨了加工环境的改变(不同的NaCl 浓度、蔗糖浓度、pH 值等)对茶多酚- 蛋白质混合溶液相互作用的影响规律。     

木糖醇对大豆分离蛋白结构和起泡特性的影响

研究添加不同质量分数木糖醇时大豆分离蛋白的结构、溶解性、表面疏水性、内源荧光强度以及起泡特性的变化情况,以期更加深入了解木糖醇对大豆分离蛋白结构和功能特性的影响。结果表明：在木糖醇的作用下,大豆分离蛋白的溶解性增加,而表面疏水性和内源荧光强度降低,原来暴露的酪氨酸和色氨酸残基则被包裹到分子内部。同时,大豆分离蛋白的结构也发生了改变,其二级结构变得更加有序、致密。由于大豆分离蛋白结构的变化,其起泡能力受到抑制。另外,木糖醇使大豆分离蛋白溶液的表观黏度增加,有利于提高其泡沫稳定性。     

干热处理对大豆分离蛋白乳化与起泡性能的影响

研究了60℃、80℃和90℃下干热处理对大豆分离蛋白乳化和起泡性能的影响.研究发现,干热处理4 d使大豆分离蛋白的乳化活性增加到最大值,其乳化稳定性也增加到接近最大值的水平,长时间的热处理降低大豆分离蛋白的乳化活性;60℃干热处理1 d使大豆蛋白的膨胀率增加到最大值880%,此后随热处理时间的延长而持续下降,80℃和90℃热处理降低了大豆分离蛋白的泡沫稳定性;干热处理使大豆分离蛋白7S亚基各组分和部分11S酸挂亚基发生共价聚合形成高分子量的聚合物.     

复合酶法改善大豆分离蛋白起泡性的工艺优化

运用配料试验设计解决了多酶复配的比例优化问题,采用米曲蛋白酶、木瓜蛋白酶、胰蛋白酶对大豆分离蛋白进行水解,建立复合酶配合比例与起泡性之间的数学模型。确定最佳比例为:米曲蛋白酶5.68%、胰蛋白酶39.03%、木瓜蛋白酶55.29%;最佳水解条件为:[S]=8%、[E]/[S]=2%、pH=7.0、T=40℃、t=2h。     

高场强超声对蛋清液起泡特性的影响

为改善蛋清液的起泡性,采用不同超声功率(120,240 W)和超声时间(1,5,10,20,30 min)的高场强超声(20 kHz)对蛋清蛋白进行改性.结果表明,在功率120 W下超声处理20 min,蛋清蛋白的起泡性最佳(266.7％),是未处理蛋清的6.9倍.超声处理显著降低了蛋清液的表观黏度、表面张力和粒径大小...     

蛋白质量浓度对鸡蛋热诱导凝胶特性的影响

以蛋清、蛋黄和全蛋液为原料,研究蛋清、蛋黄和全蛋蛋白热诱导凝胶的形成能力以及蛋白质量浓度对蛋清、蛋黄和全蛋蛋白热诱导凝胶特性的影响。结果表明：蛋清、蛋黄和全蛋形成热诱导凝胶的最低蛋白质量浓度分别为50、55、50mg/mL;在50～135mg/mL范围内,随蛋白质量浓度的增加,蛋清、蛋黄和全蛋蛋白的凝胶强度和保水性不断增大,蒸煮损失整体呈下降趋势;蛋白质量浓度对蛋清、蛋黄和全蛋凝胶的弹性也有显著影响。     

转谷氨酰胺酶提高蛋清粉凝胶性能的研究

为改善蛋清粉的加工品质,探讨了酶交联反应对提高蛋清粉凝胶性能的影响。通过研究转谷氨酰胺酶用量、反应温度及作用时间对蛋清粉凝胶强度的影响,采用Box-Benhnken设计对转谷氨酰胺酶交联蛋清粉的凝胶强度进行优化。以蛋清粉凝胶强度为响应值,进行响应面分析。结果表明,转谷氨酰胺酶交联蛋清粉的优化工艺条件为:酶用量6U/g蛋清粉,作用时间3.99h,温度35℃,在此条件下,蛋白粉的凝胶强度达到820g/cm2,与实测值基本一致,说明利用该试验建立的模型在实践中具有可行性。     

Foaming Properties of Egg Albumen with a Bubbling Apparatus Compared with Whipping

Neither standard method nor instrument exists to accurately measure foaming properties in food. Usually, whipping methods are used but they are only moderately reproducible. We used an original apparatus in which foam was generated by bubbling and then analyzed by conductimetry (liquid in the foam) and a uniline camera (foam volume). The foaming properties of a series of egg-white powders were studied. Among parameters describing foam formation and destabilization, three were repeatable and discriminating. They were correlated with those obtained with whipping methods. Easy to use and rapid, the bubbling method is an alternative for controlling and measuring the foaming properties of egg-white.     

干热处理下焦磷酸钠改性大豆蛋白乳化和起泡性质研究

研究了在80℃干热条件下焦磷酸钠改性大豆蛋白的乳化和起泡性质。研究发现:改性大豆蛋白的乳化性质和起泡性质得到明显的改善,蛋白质结合磷的量随干热处理时间的延长而增加。在干热处理前对大豆蛋白进行适度的预热处理大大提高了蛋白质结合磷的量,80℃预热处理10min使改性大豆蛋白表现出最好的乳化性质,而预热处理20min的改性蛋白质却表现出最好的起泡性质。红外光谱分析发现,焦磷酸钠以磷酸根的形式与蛋白质分子的游离羟基缩合。SDS-凝胶电泳表明,焦磷酸钠能抑制干热处理时大豆蛋白各亚基之间的聚合作用,从而提高其功能性质。该研究为大豆蛋白的改性提供了新的思路。     

超高压和巴氏杀菌对蛋清蛋白结构及起泡性能的影响

本实验以市售鲜蛋制备得到的蛋清为原料,分别利用巴氏杀菌和超高压杀菌处理(200～300MPa,2.5～12.5 min),经喷雾干燥后,采用圆二色光谱、傅里叶变换红外光谱、紫外光谱、荧光光谱和动态光散射激光粒度仪等研究超高压杀菌处理对蛋清蛋白的构象、粒径、表面电位、起泡特性的影响.结果 表明,巴氏杀菌和超高压杀菌处理均...     

Foaming Properties of Lipid-Reduced and Calcium-Reduced Whey Protein Concentrates

The ability of whey protein concentrates (WPC) to form highly expanded and stable foams is critical for food applications such as whipped toppings and meringue-type products. The foaming properties were studied on six experimental and three commercial WPC, manufactured by membrane fractionation processes to contain reduced lipids and calcium. Lipid-reduced WPC had excellent foaming properties. Experimental delipidized WPC MF 0.45 and commercial delipidized WPC E had higher (P < 0.05) foam expansion than egg white protein (EWP). However. WPC B made bv low-pH UF and isoelectric orecinitation did not form a foam. Lipids and ash were the main factors affecting foaming properties.     

Flavourzyme酶水解蛋清蛋白的工艺研究

以水解度和蛋白质残留量为指标,研究温度、pH、酶用量及蛋清浓度对Flavourzyme酶解蛋清蛋白的影响,并通过正交试验来确定其最佳工艺。结果是温度55℃、pH6.5、加酶量为质量分数6%、蛋清料液质量体积比1 g:5 m L为最佳工艺参数。在该条件下,6 h酶解物的蛋白质残留率为27.68%,水解度为38.75%,水解物的相对分子质量大部分集中在300以下,即主要以游离氨基酸及二肽形式存在。     

TGase交联对alcalase水解大豆分离蛋白起泡性的影响

为了提高大豆分离蛋白(SPI)的起泡性,对SPI经alcalase有限水解产物中不同分子大小的肽段采用谷氨酰胺转移酶TGase进行交联。结果表明:TGase交联可有效提高SPI的起泡性,特别是显著地提高了其泡沫稳定性;MW﹥10 ku的大分子肽当加酶量为15 U/g底物且交联4 h时得到最佳的泡沫稳定性为88.5%;MW﹥10ku和MW﹤5 ku的大分子和小分子肽混合物当加酶量为50U/g(底物),交联时间为4 h、大分子与小分子肽摩尔比为1∶1时得到的最佳泡沫稳定性为60.3%;MW>10 ku的大分子肽交联产物的分子质量显著高于MW>10ku的大分子肽和MW<5 ku的小分子肽(摩尔比1∶1)交联产物的分子质量。     

米糠蛋白的起泡特性及其泡沫微观形态

考察pH值和NaCl浓度对米糠蛋白起泡特性及泡沫微观形态的影响,并对二者之间的内在关系进行阐述。结果表明,当米糠蛋白溶液中不添加NaCl、pH?4时起泡能力较差,但泡沫稳定性可达最大值（88.3±7.3）%,而当溶液的pH值偏离4时起泡能力增加,在pH10和12条件下起泡能力分别可达（73.3±0）%和（168.9±10.2）%,泡沫稳定性分别为（74.7±2.5）%和（68.5±2.1）%;另外在米糠蛋白溶液pH值为4和7条件下分别添加1%的NaCl后,可显著提高起泡能力至（77.8±3.8）%和（90.0±5.8）%。米糠蛋白泡沫的微观形态随时间变化规律说明,不同pH值条件下起始阶段气泡的直径大小分布与泡沫稳定性相关,而当添加NaCl后米糠蛋白起泡能力和泡沫稳定性的改变则与气泡数量和平均面积二者的综合效应有关。     

酶法水解对罗非鱼下脚料蛋白功能特性的影响

以罗非鱼下脚料为原料,采用Alcalase蛋白酶、中性蛋白酶、风味蛋白酶对其进行控制酶解,通过pH-stat法控制水解程度,制备不同水解度(1.0%～15.0%)的罗非鱼下脚料酶解蛋白,探讨酶的种类和水解度对其乳化性和发泡性的影响。结果表明:在水解度较低(3.0%～5.0%)时,酶解蛋白的乳化性和发泡性较好,随着水解度进一步增大,酶解蛋白的乳化性和发泡性均降低;比较而言,由中性蛋白酶水解得到的酶解蛋白乳化性较好,而风味蛋白酶水解得到的酶解蛋白发泡性较好;此外,pH值(2～10)对轻度酶解蛋白的乳化性和发泡性影响较大,在pH 4.0～5.0范围内,酶解蛋白的乳化性和发泡性最差。     

Proteose Peptones and Physical Factors Affect Foaming Properties of Whey Protein Isolate

Effects of peptides and nonprotein components of whey on whey protein isolate (WPI) were studied using a differential pressure method. Decay of WPI foam followed biphasic first-order kinetics, but was affected by solution conditions. WPI foam stability exhibited two pH optima (5.0 and 8.5). Addition of 0.02–0.15M NaCl progressively decreased foaming capacity and foam stability. Addition of 0.01–0.2% proteose-peptones caused a sharp decrease in foam stability, but did not affect WPI foaming capacity. Foam stability was increased by addition of up to 20% lactose. Removal of proteose-peptones should greatly improve foaming properties of whey proteins.