The antimicrobial effect of thyme essential oil, nisin, and their combination against Listeria monocytogenes in minced beef during refrigerated storage

The antimicrobial effect of thyme essential oil (EO) at 0.3%, 0.6%, or 0.9%, nisin at 500 or 1000IU/g, and their combination against Listeria monocytogenes was examined in both tryptic soy broth (TSB) and minced beef meat. Thyme EO at 0.3% possessed a weak antibacterial activity against the pathogen in TSB, whereas at 0.9% showed unacceptable organoleptic properties in minced meat. Thus, only the level of 0.6% of EO was further examined against the pathogen in minced meat. Treatment of minced beef meat with nisin at 500 or 1000IU/g showed antibacterial activity against L. monocytogenes, which was dependent on the concentration level of nisin and the strains used. Treatment of minced beef meat with EO at 0.6% showed stronger inhibitory activity against L. monocytogenes than treatment with nisin at 500 or 1000IU/g. All treatments showed stronger inhibitory activity against the pathogens at 10 degrees C than at 4 degrees C. The combined addition of EO at 0.6% and nisin at 500 or 1000IU/g showed a synergistic activity against the pathogen. Most efficient among treatments was the combination of EO at 0.6% with nisin at 1000IU/g, which decreased the population of L. monocytogenes below the official limit of the European Union recently set at 2logcfu/g, during storage at 4 degrees C.     

Survival of Escherichia coli O157:H7 and Salmonella enterica serovars Typhimurium in iceberg lettuce and the antimicrobial effect of rice vinegar against E. coli O157:H7

The microbiological safety of fresh produce is a significant concern of consumers and industry. After applying at an inoculated level (about 10(6) CFUg(-1)) of E. coli O157:H7 and Salmonella enterica serovars Typhimurium on shredded iceberg lettuce and water samples individually, they were stored at 4 degrees C for 14 days and 22 degrees C for 7 days to monitor the growth and survival of pathogens. The results showed that at the end of 4 degrees C storage, populations of two pathogens in lettuce and water decreased approximately 1 log CFUg(-1). However, microbial levels on shredded lettuce increased 3 logs within 3 days at 22 degrees C. Vinegar (acetic acid) had been used to reduce populations of foodborne pathogens in foods; hence, the antimicrobial effect of rice vinegar on the survival of E. coli O157:H7 in inoculated lettuce (10(4) and 10(7) CFUg(-1)) is examined in this study. Results were observed that the treatment of inoculated lettuce (10(7) CFUg(-1)) with commercial vinegar containing 5% acetic acid (pH 3.0) for 5 min would reduce 3 logs population at 25 degrees C. Less than a 1-log decrease in bacterial numbers was recovered during 5 min exposure to 0.5% (pH 3.26) acetic acid.     

Development of PCR assays for detection of Escherichia coli O157:H7 in meat products

A multiplex polymerase chain reaction (PCR) procedure based on fliC_h7 and rfbE genes was developed for the detection of Escherichia coli O157:H7 in raw pork meat and ready-to-eat (RTE) meat products. Two different DNA extraction procedures were evaluated for application on meat products. MasterPure™ DNA Purification kit in combination with immunomagnetic separation was found to be the best method in a meat system. The optimized PCR included an enrichment step in brilliant green bile 2% broth at 37 °C. This method was applied to artificially inoculated meat and RTE meat products with different concentrations of E. coli O157:H7. The results indicate that the PCR assay developed could sensitively and specifically detect E. coli O157:H7 in raw pork meat and RTE meat products in approximately 10 h, including a 6 h enrichment step. Thus, this method could be proposed for screening E. coli O157:H7 in raw pork and RTE meat products.     

A note on Escherichia coli O157:H7 serotype in Turkish meat products

255 minced beef, 101 soudjouk and 50 uncooked hamburger samples were analyzed for the presence of Escherichia coli O157:H7 serotype. m-EC and LST broths were used as selective enrichment media and SMAC agar was used as a selective isolation medium. A total of 3 E. coli O157 were isolated by conventional culture techniques; one from each of minced beef, uncooked hamburger and soudjouk but none were identified as the H7 serotype. For determination of selective media-growing cohabitant bacteria, 2645 isolates were obtained from SMAC agar. Results showed that E. coli type 1, Hafnia alvei and Citrobacter freundii were dominant competitive flora. As selective enrichment broth-growing cohabitant microflora existed at higher levels, it was too difficult to isolate E. coli O157 from these mixed flora. Therefore, conventional methods are not suitable for these types of products, because of isolation difficulties and failure to confirm.     

Efficacy of trimming chilled beef during fabrication to control Escherichia coli O157:H7 surrogates on subsequent subprimals

Effectiveness of trimming external carcass surfaces from subprimals during fabrication to reduce Escherichia coli O157:H7 surrogates was evaluated. Carcass sides (n = 10 sides) were inoculated along the hide pattern opening before entering the blast chill cooler with a gelatin slurry containing a bacterial cocktail of three rifampicin-resistant, nonpathogenic E. coli biotype I strains. Following a 48 h chill, sides were fabricated to produce eight subprimals. Microbiological samples were taken from the original carcass fat surface area, initial lean surface area, trimmed fat surface area (where applicable), and trimmed lean surface area (where applicable). Newly exposed lean surfaces had lower (P < 0.05) counts of rifampicin-resistant E. coli than did the external fat surfaces. However, fat and lean surfaces that were not inoculated became contaminated during the fabrication process. Trimming external surfaces reduced levels of pathogens, but under normal fabrication processes, pathogens were still spread to newly exposed surfaces.     

Fate of Escherichia coli O157:H7 in field-inoculated lettuce

Impact of drip and overhead sprinkler irrigation on the persistence of attenuated Escherichia coli O157:H7 in the lettuce phyllosphere was investigated using a split-plot design in four field trials conducted in the Salinas Valley, California, between summer 2007 and fall 2009. Rifampicin-resistant attenuated E. coli O157:H7 ATCC 700728 (BLS1) was inoculated onto the soil beds after seeding with a backpack sprayer or onto 2- or 4-week-old lettuce plant foliage with a spray bottle at a level of 7 log CFU ml⁻¹. When E. coli O157:H7 was inoculated onto 2-week-old plants, the organism was recovered by enrichment in 1 of 120 or 0 of 240 plants at 21 or 28 days post-inoculation, respectively. For the four trials where inoculum was applied to 4-week-old plants, the population size of E. coli O157:H7 declined rapidly and by day 7, counts were near or below the limit of detection (10 cells per plant) for 82% or more of the samples. However, in 3 out 4 field trials E. coli O157:H7 was still detected in lettuce plants by enrichment 4-weeks post-inoculation. Neither drip nor overhead sprinkler irrigation consistently influenced the survival of E. coli O157:H7 on lettuce.     

Antibacterial activity of oregano and thyme essential oils against Listeria monocytogenes and Escherichia coli O157:H7 in feta cheese packaged under modified atmosphere

The antibacterial activity of the essential oils (EO) of oregano and thyme added at doses of 0.1 or 0.2 and 0.1 ml/100 g, respectively, to feta cheese inoculated with Escherichia coli O157:H7 or Listeria monocytogenes was investigated during cheese storage under modified atmosphere packaging (MAP) of 50% CO₂ and 50% N₂ at 4 °C. Compositional analysis showed that the predominant phenols were carvacrol and thymol for both EO. In control feta inoculated with the pathogens and stored under MAP, results showed that E. coli O157:H7 and L. monocytogenes strains survived up to 32 and 28 days of storage. However, in feta cheese treated with oregano EO at the dose of 0.1 ml/100 g, E. coli O157:H7 or L. monocytogenes survived up to 22 and 18 days, respectively, whereas at the dose of 0.2 ml/100 g up to16 or 14 days, respectively. Feta cheese treated with thyme EO at 0.1 ml/100 g showed populations of E. coli O157:H7 or L. monocytogenes not significantly different (P > 0.05) than those of feta cheese treated with oregano at 0.1 ml/100 g. Although both essential oils exhibited equal antibacterial activity against both pathogens, the populations of L. monocytogenes decreased faster (P < 0.05) than those of E. coli O157:H7 during the refrigerated storage, indicating a stronger antibacterial activity of both essential oils against the former pathogen.     

Ecology of Escherichia coli O157:H7 in commercial dairies in southern Alberta

Shedding of Escherichia coli O157:H7 was monitored monthly over a 1-yr period by collecting pooled fecal pats (FECAL) and manila ropes orally accessed for 4 h (ROPE) from multiple pens of cattle in 5 commercial dairies in southern Alberta, Canada. Using immunomagnetic separation, E. coli O157:H7 was isolated from cows on 4 of the dairies and from 13.5% of FECAL and 1.1% of ROPE samples. Pulsed-field gel electrophoresis of XbaI- and SpeI-digested bacterial DNA of the 65 isolates produced 23 unique restriction endonuclease digestion patterns, although 92% of the isolates belonged to 3 restriction endonuclease digestion pattern clusters sharing a minimum 90% homology. Collection of positive isolates was 15 times more likely from June through September. Across dairies, peak somatic cell count occurred in July, August, September, and November. The likelihood of positive isolates was 2.6 times higher in calves and heifers compared with mature cows. This study indicates that ROPE would be of little value for the detection of E. coli O157:H7 in dairy herds unless oral contact with ROPE could be increased in mature animals. Additionally, mitigation strategies for E. coli O157:H7 should be targeted to the months of July, August, and September and toward immature animals for maximum impact. All farms displayed unique combinations of seasonality of shedding and diversity of E. coli O157:H7 subtypes. The fact that seasonal prevalence of E. coli O157:H7 largely coincided with peak somatic cell count within climatically controlled dairy barns suggests that similar environmental factors may be enhancing fecal shedding E. coli O157:H7 and the incidence of mastitis.     

Cloning of genes encoding colicin E2 in Lactococcus lactis subspecies lactis and evaluation of the colicin-producing transformants as inhibitors of Escherichia coli O157:H7 during milk fermentation

Colicin E2 (ColE2) is a proteinaceous bacterial toxin produced by some strains of Escherichia coli and other members of the Enterobacteriaceae that exhibits inhibitory activity against some strains of E. coli O157:H7. A 2.0-kb DNA fragment, containing the ColE2 structural gene ceaB and immunity gene ceiB from E. coli NCTC 50133 (pColE2-P9), was cloned into the lactococcal plasmid vector pNZ2103. The lysis gene, celB, was not cloned. The plasmid, pLR-E2, encoding the cloned genes was transformed into E. coli DH5α and Lactococcus lactis ssp. lactis LM0230 and PN-1 using electroporation. The bacteriocin ColE2 was expressed in transformants of both E. coli and L. lactis ssp. lactis. Secretion of ColE2 into media was verified by spot-on-lawn assays and measurement of ColE2 activity in the growth medium of transformants. The level of ColE2 produced by transformants containing pLR-E2 was similar to that produced by the parental strain, E. coli NCTC 50133 (pColE2-P9). Evaluation of a ColE2-producing transformant of L. lactis ssp. lactis as a starter culture revealed that, although ColE2 was produced by transformants and could be detected in milk during fermentation, the inhibitory activity of ColE2 against E. coli O157:H7 was significantly decreased in milk compared with buffered growth medium.     

Sucrose monolaurate improves the efficacy of sodium hypochlorite against Escherichia coli O157:H7 on spinach

It is well-recognized that chlorine has limited efficacy when applied to inactivate pathogens on fresh produce. One of the many factors limiting efficacy is the high interfacial tension of chlorine-based sanitizers that limits the access of chlorine to the microorganisms. In this work, we investigated the efficacy of sodium hypochlorite (200 ppm, pH 6.0) at 4 and 20 °C against Escherichia coli O157:H7 inoculated on baby spinach leaves as affected by the surfactant sucrose monolaurate (SML) at below (100 ppm), above (250 ppm), and well above (10,000 ppm) the critical micelle concentration (CMC) of ~ 200 ppm at 20 °C. The surfactant-containing chlorine treatments were compared to those with buffer only, surfactant only, and chlorine only. Significantly improved inactivation, as evidenced by survival of E. coli O157:H7 was achieved when 250 or 10,000 ppm SML was added with chlorine. This is attributed to the reduction of interfacial tension between the sanitizing solutions and spinach surface. Treatments at 20 °C resulted in greater mean inactivation than those at 4 °C but the difference was not significant. Comparisons of SML concentrations in treatment solutions before and after sanitization showed that SML decreased more at a lower temperature and when chlorine was present, resulting from adsorption of SML onto spinach matrix. Our work illustrates the importance of using surfactants at concentrations above the CMC to enhance the efficacy of chlorine sanitization.     

Effect of Meat Binding Formulations on Thermal Inactivation of Escherichia coli O157:H7 Internalized in Beef

ABSTRACT:  This study evaluated the effects of meat binding or restructuring formulations, including salt/phosphate, algin/calcium, Activa™RM, and Fibrimex®, with or without 0.27% (wt/wt) lactic acid, on thermal inactivation of internalized Escherichia coli O157:H7 in ground beef, serving as a model system for restructured products. Ground beef batches (700 g; approximately 5% fat) were mechanically mixed with a 5-strain composite of E. coli O157:H7 (7 log CFU/g) and then with the restructuring formulations. Product portions (30 g) were extruded into plastic test tubes (2.5 × 10 cm) and stored at 4 °C (18 h), before heating to 60 or 65 °C in a circulating water bath to simulate rare or medium-rare doneness of beef, respectively. Cooking to 60 or 65 °C reduced ( P < 0.05) bacterial counts of control samples by 1.8 and 3.2 log CFU/g, respectively. Thermal destruction at 60 °C was not different ( P > 0.05) among all treatments and the control. At 65 °C, greater ( P < 0.05) thermal inactivation of E. coli O157:H7, as compared to the control, was obtained in samples treated with lactic acid alone (reductions of 4.9 log CFU/g), whereas for all other treatments, microbial destruction (reductions of 2.2 to 4.5 log CFU/g) was comparable ( P > 0.05) to that of the control. Cooking weight losses were lower ( P < 0.05) in salt/phosphate samples (<1%) compared to other formulations and the control (7.4% to 15.9%). Findings indicated that, under the conditions examined, restructuring of beef with salt/phosphate, algin/calcium, Activa™RM, or Fibrimex® did not affect inactivation of internalized E . coli O157:H7 in undercooked (60 or 65 °C) samples, whereas inclusion of lactic acid (0.27%) in nonintact beef products enhanced pathogen destruction at 65 °C.     

Attachment and biofilm formation by Escherichia coli O157:H7 at different temperatures, on various food-contact surfaces encountered in beef processing

Escherichia coli O157:H7 attached to beef-contact surfaces found in beef fabrication facilities may serve as a source of cross-contamination. This study evaluated E. coli O157:H7 attachment, survival and growth on food-contact surfaces under simulated beef processing conditions. Stainless steel and high-density polyethylene surfaces (2 × 5 cm) were individually suspended into each of three substrates inoculated (6 log CFU/ml or g) with E. coli O157:H7 (rifampicin-resistant, six-strain composite) and then incubated (168 h) statically at 4 or 15 °C. The three tested soiling substrates included sterile tryptic soy broth (TSB), unsterilized beef fat-lean tissue (1:1 [wt/wt]) homogenate (10% [wt/wt] with sterile distilled water) and unsterilized ground beef. Initial adherence/attachment of E. coli O157:H7 (0.9 to 2.9 log CFU/cm²) on stainless steel and high-density polyethylene was not affected by the type of food-contact surface but was greater (p < 0.05) through ground beef. Adherent and suspended E. coli O157:H7 counts increased during storage at 15 °C (168 h) by 2.2 to 5.4 log CFU/cm² and 1.0 to 2.8 log CFU/ml or g, respectively. At 4 °C (168 h), although pathogen levels decreased slightly in the substrates, numbers of adherent cells remained constant on coupons in ground beef (2.4 to 2.5 log CFU/cm²) and increased on coupons in TSB and fat-lean tissue homogenate by 0.9 to 1.0 and 1.7 to 2.0 log CFU/cm², respectively, suggesting further cell attachment. The results of this study indicate that E. coli O157:H7 attachment to beef-contact surfaces was influenced by the type of soiling substrate and temperature. Notably, attachment occurred not only at a temperature representative of beef fabrication areas during non-production hours (15 °C), but also during cold storage (4 °C) temperatures, thus, rendering the design of more effective sanitation programs necessary.     

Immunosensors for rapid detection of Escherichia coli O157:H7 - perspectives for use in the meat processing industry

This review critically evaluates different types of immunosensors proposed for rapid identification of Escherichia coli O157:H7. The methods are compared with approved USDA-FSIS standard procedures for determination of this pathogen in raw or ready-to-eat meat products. Major advantages and disadvantages for each method are highlighted. Our analysis suggests that application of immunosensors in the meat-processing industry may be limited to identification of uncontaminated samples after conventional selective enrichment in broth. Use for detection appears limited at the present time.     

Development and validation of a probabilistic second-order exposure assessment model for Escherichia coli O157:H7 contamination of beef trimmings from Irish meat plants

A second-order quantitative Monte Carlo simulation model was developed for Escherichia coli O157:H7 contamination of beef trimmings in Irish abattoirs. The assessment considers initial contamination levels, cross-contamination and decontamination events during the cattle slaughter process. The mean simulated prevalence of E. coli O157:H7 on trimmings was 2.36% and the mean simulated counts of E. coli O157:H7 on contaminated trimmings was -2.69log(10)CFU/g. A parallel validation survey provided some confidence in the model predictions. An uncertainty analysis indicated that microbial test sensitivity is a significant factor contributing to model uncertainty and requires further investigation while also indicating that risk reduction measures should be directed towards reducing the hide to carcass transfer (correlation coefficient 0.25) during dehiding and reducing the initial prevalence and counts on bovine hides (correlation coefficients 0.19 and 0.16, respectively). A characterisation of uncertainty and variability indicating that further research is required to reduce parameter uncertainty and to achieve better understanding of microbial transfer in meat plants. The model developed in this study highlights the need for further development of quantitative risk assessments in the food industry.     

Implementation of targeted interventions to control Escherichia coli O157:H7 in a commercial abattoir

The objective of this study was to define locations on the carcass with highest contamination of E. coli O157 throughout the harvest process and implement targeted interventions to reduce or eliminate contamination. To establish a pathogen baseline, samples were collected at the foreshank, hindshank, inside round, neck and midline area and evaluated for E. coli O157:H7 presence. Environmental samples were also collected in the harvest area and the fabrication area of the facility. E. coli O157:H7 prevalence was highest on the foreshank, hindshank and inside rounds in the baseline study and steam vacuums/cones were implemented as an intervention in these specific areas on the harvest floor. At pre-evisceration, foreshank prevalence of E. coli O157:H7 was significantly (P<0.05) reduced from 21.7% to 3.1% after the application of steam interventions. At the final rail, foreshank prevalence in the baseline study was 4.2% while no E. coli O157:H7 was detected post-intervention implementation. E. coli O157:H7 on hindshanks and inside rounds was significantly reduced after intervention implementation from 24.2 to 11.5% and 37.5 to 16.7%, respectively at the final rail. Pathogen contamination of environmental samples collected in fabrication declined from 6.7% to 0.7% after slaughter interventions were implemented. Data indicate the identifying areas of contamination on the carcass and implementing interventions can significantly reduce E. coli O157 on the carcasses and in the fabrication environment.     

Influence of transportation stress and animal temperament on fecal shedding of Escherichia coli O157:H7 in feedlot cattle

To test the influence of transportation stress and temperament on shedding of Escherichia coli O157:H7, cattle (n=150) were classified at various stages of production as Excitable, Intermediate or Calm based on a variety of disposition scores. Presence of E. coli O157:H7 was determined by rectal swabs from live animals and from colons collected postmortem. Percentage of cattle shedding E. coli O157:H7 at arrival at the feedlot was approximately equal among temperament groups. Before shipment to the processing facility, a higher (P=0.03) proportion of cattle from the Calm group shed E. coli O157:H7 compared to the other temperament groups. When pooled across all sampling periods, cattle from the Calm group had a greater percentage test positive for E. coli O157:H7. Neither the acute stressor of transportation nor a more excitable temperament led to increased shedding of E. coli O157:H7 in cattle.     

A review of quantitative microbial risk assessment in the management of Escherichia coli O157:H7 on beef

Since Escherichia coli O157:H7 first emerged as a food borne pathogen in the mid 1980s, it has been linked to many cases of food poisoning across the world. While multiple sources and routes of transmission for this pathogen are now recognised, beef and beef products remain an important vehicle of the pathogen and continue to be linked to outbreaks across the developed world. Much research has been directed at E. coli O157:H7 transmission, survival and control in the beef chain and this paper presents an overview of current knowledge on this pathogen in the beef chain from primary production through slaughter, processing, distribution, final preparation and cooking. In order to strategically manage E. coli O157:H7 and to devise approaches to reduce the public health risk posed, many national and international groups have applied quantitative risk assessment techniques to model the risk posed by E. coli O157:H7 in beef, particularly in ground/minced beef which is most often linked with infection. This paper reviews these quantitative risk assessments and their application in managing the risk posed by E. coli O157:H7 in beef.     

应用DPO-PCR技术检测肠出血性大肠杆菌O157∶H7

利用双启动寡核苷酸引物（dual-priming oligonucleotide,DPO）聚合酶链式反应（polymerase chain reaction,PCR）技术检测肠出血性大肠杆菌O157∶H7。根据DPO引物设计原则,以肠出血性大肠杆菌O157∶H7 rfbE 基因为靶基因设计一对DPO引物,经过反应体系的优化,建立了肠出血性大肠杆菌O157∶H7 DPO-PCR检测方法, 其检测灵敏度约为94 CFU/mL。与常规PCR方法相比,所建立的DPO-PCR方法对退火温度不敏感,在引物设计和实 验过程中不需要对引物及其退火温度反复优化,同时基于DPO引物的特殊结构又增强了其特异性。DPO-PCR方法 设计简易、特异性强,为致病性微生物的快速准确检测提供了新途径。     

抗大肠杆菌O157:H7的卵黄特异性IgY的研究

以大肠杆菌O157:H7为抗原免疫产蛋母鸡,从鸡卵黄中提取免疫球蛋白,建立抗大肠杆菌O157:H7的特异性IgY的效价检测方法,并研究母鸡的免疫应答性,以及抗体的提取方法和体外抑菌效果.研究结果表明,初次免疫后第6d,在卵黄中可以检测到抗大肠杆菌O157:H7 IgY,效价为1:7200;经加强免疫后效价迅速上升,至第44d达到最高效价1:230400;免疫后360 d,效价仍维持在1:7200.用水稀释法、硫酸铵分级盐析和Sephadex G-25凝胶过滤以提取IgY,提纯后IgY的效价是之前的4倍.SDS-PAGE鉴定抗体的纯度,电泳图谱中出现抗体的轻链和重链两条带.体外抑菌实验表明,IgY能抑制大肠杆菌O157:H7的生长.     

Enhancing the thermal destruction of Escherichia coli O157:H7 in ground beef patties by trans-cinnamaldehyde

The effect of trans-cinnamaldehyde (TC) on the inactivation of Escherichia coli O157:H7 in undercooked ground beef patties was investigated. A five-strain mixture of E. coli O157:H7 was inoculated into ground beef (7.0 log CFU/g), followed by addition of TC (0, 0.15, and 0.3%). The meat was formed into patties and stored at 4 °C for 5 days or at −18 °C for 7 days. The patties were cooked to an internal temperature of 60 or 65 °C, and E. coli O157:H7 was enumerated. The numbers of E. coli O157:H7 did not decline during storage of patties. However, cooking of patties containing TC significantly reduced (P < 0.05) E. coli O157:H7 counts, by >5.0 log CFU/g, relative to the reduction in controls cooked to the same temperatures. The D-values at 60 and 65 °C of E. coli O157:H7 in TC-treated patties (1.85 and 0.08 min, respectively) were significantly lower (P < 0.05) than the corresponding D-values for the organism in control patties (2.70 and 0.29 min, respectively). TC-treated patties were more color stable and showed significantly lower lipid oxidation (P < 0.05) than control samples. TC enhanced the heat sensitivity of E. coli O157:H7 and could potentially be used as an antimicrobial for ensuring pathogen inactivation in undercooked patties. However detailed sensory studies will be necessary to determine the acceptability to consumers of TC in ground beef patties.