Effects of the concentration of insoluble calcium phosphate associated with casein micelles on the functionality of directly acidified cheese

Directly acidified cheeses with different insoluble Ca (INS Ca) contents were made to test the hypothesis that the removal of INS Ca from casein micelles (CM) would directly contribute to the softening and flow behavior of cheese at high temperature. Skim milk was directly acidified with dilute lactic acid to pH values of 6.0, 5.8, 5.6, or 5.4 to remove INS Ca (pH trial). Lowering milk pH also reduced protein charge repulsion, which could influence melt. In a second treatment, EDTA (0, 2, 4, or 6 mM) was added to skim milk that was subsequently acidified to pH 6.0 (EDTA trial). Both types of milks were then made into directly acidified cheese. Cheese properties were determined at approximately 10 h after pressing to reduce possible confounding effects of proteolysis. The INS Ca content was determined by the acid-base titration method. Dynamic low-amplitude oscillatory rheology was used to measure the viscoelastic properties of cheese during heating from 5 to 80°C. The composition of all cheeses was as similar as possible, with cheese-making procedures being modified to obtain similar moisture contents (∼55%). Insoluble Ca contents of cheeses significantly decreased with a reduction in pH or with the addition of EDTA to skim milk. The pH values of cheeses in the pH trial varied, but all cheeses in the EDTA trial had similar pH values (∼5.73). In the pH trial, the reduction in cheese pH and consequent decrease in INS Ca content resulted in a reduction in the G′ values of cheeses at 20°C. In contrast, the G′ values at 20°C in cheeses from the EDTA trial increased with EDTA addition up to 4 mM EDTA. The G′ values at 70°C of cheeses from the pH trial decreased with a decrease in cheese pH, and a similar decrease was observed in the G′ values of cheese from the EDTA trial with an increase in EDTA concentration even though these cheeses had a similar pH value. In both trials, loss tangent (LT) values increased with temperatures >30°C and reached a maximum at approximately 70°C. In the pH trial, LT values at 70°C increased from 1.50 to 4.24 with a decrease in cheese pH from 5.78 to 5.21. The LT values increased from 1.43 to 3.23 with an increase in the concentration of added EDTA from 0 to 6 mM. In the EDTA trial, the decrease in G′ and increase in LT values at 70°C were due to the reduction in INS Ca content, because the pH values of these cheeses were the same. It can be concluded that the loss of INS Ca increases the melting in cheeses that have the same pH and gross chemical composition, and removal of INS Ca can even make cheese at high pH (∼5.73) exhibit reasonable melt characteristics.     

Effect of trisodium citrate on rheological and physical properties and microstructure of yogurt

The effect of trisodium citrate (TSC) on the rheological and physical properties and microstructure of yogurt was investigated. Reconstituted skim milk was heated at 85° C for 30 min, and various concentrations (5 to 40 mM) of TSC were added to the milk, which was then readjusted to pH 6.50. Milk was inoculated with 2% yogurt culture and incubated at 42° C until pH was 4.6. Acid-base titration was used to determine changes in the state of colloidal calcium phosphate (CCP) in milk. Total and soluble Ca contents of the milk were determined. The storage modulus (G′) and loss tangent (LT) values of yogurts were measured as a function of pH using dynamic oscillatory rheology. Large deformation rheological properties were also measured. Microstructure of yogurt was observed using confocal scanning laser microscopy, and whey separation was also determined. Addition of TSC reduced casein-bound Ca and increased the solubilization of CCP. The G′ value of gels significantly increased with addition of low levels of TSC, and highest G′ values were observed in samples with 10 to 20 mM TSC; higher ( > 20 mM) TSC concentrations resulted in a large decrease in G′ values. The LT of yogurts increased after gelation to attain a maximum at pH ∼5.1, but no maximum was observed in yogurts made with ≥ 25 mM of TSC because CCP was completely dissolved prior to gelation. Partial removal of CCP resulted in an increase in the LT value at pH 5.1. At low TSC levels, the removal of CCP crosslinks may have facilitated greater rearrangement and molecular mobility of the micelle structure, which may have helped to increase G′ and LT values of gels by increasing the formation of crosslinks between strands. At high TSC concentrations the micelles were completely disrupted and CCP crosslinks were dissolved, both of which resulted in very weak yogurt gels with large pores obvious in confocal micrographs. Gelation pH and yield stress significantly decreased with the use of high TSC levels. Lowest whey separation levels were observed in yogurt made with 20 mM TSC, and whey separation greatly increased at > 25 mM TSC. In conclusion, low concentrations of TSC improved several important yogurt characteristics, whereas the use of levels that disrupted casein micelles resulted in poor gel properties. We also conclude that the LT maximum observed in yogurts made from heated milk is due to the presence of CCP because the modification of the CCP content altered this peak and the removal of CCP eliminates this feature in the LT profiles.     

Effect of Tetrasodium Pyrophosphate on the Physicochemical Properties of Yogurt Gels

The effect of tetrasodium pyrophosphate (TSPP) on the properties of yogurt gels was investigated. Various concentrations (0.05 to 0.2%) of TSPP were added to preheated (85°C for 30 min) reconstituted skim milk, which was readjusted to pH 6.50. Milk was inoculated with 2% starter culture and incubated at 42°C until the pH reached 4.6. Acid-base buffering profiles of milk and total and soluble calcium levels were measured. Turbidity measurements were used to indicate changes in casein dispersion. Storage modulus (G′) and loss tangent (LT) values of yogurts were monitored during fermentation using dynamic oscillatory rheology. Large deformation properties of gels were also measured. Microstructural properties of yogurt were observed using fluorescence microscopy. The addition of TSPP resulted in the disappearance of the buffering peak during acid titration at pH ∼5.1 that is due to the solubilization of colloidal calcium phosphate (CCP), and a new peak was observed at lower pH values (pH 4.0-4.5). The buffering peak at pH 6.0 during base titration virtually disappeared with addition of TSPP and a new peak appeared at pH ∼4.8. The addition of TSPP reduced the soluble Ca content of milk and increased casein-bound Ca values. The addition of up to 0.125% TSPP resulted in a reduction in turbidity because of micelle dispersion but at 0.15%, turbidity increased and these samples exhibited a time-dependent increase in turbidity because of aggregation of casein particles. Gels made with 0.20% TSPP were very weak and had a very high gelation pH (6.35), probably due to complete dispersion of the micelle structure in this sample. The LT value of gels at pH 5.1 decreased with an increase in TSPP concentration, probably due to the loss of CCP with the addition of TSPP. The G′ values at pH 4.6 of gels made with ≤0.10% TSPP were not significantly different but the addition of ≥0.125% TSPP significantly decreased G′ values. The addition of 0.05 to 0.125% TSPP to milk resulted in a reduction in the yield stress values of yogurt compared with yogurt made without TSPP. Greater TSPP levels (>0.125%) markedly reduced the yield stress values of yogurt. Lowest whey separation levels were observed in yogurts made with 0.10% TSPP. High TSPP levels (>0.10%) greatly increased the apparent pore size of gels. Addition of very low levels of TSPP to milk for yogurt manufacture may be useful in reducing the whey separation defect, but at TSPP concentrations ≥0.125% very weak gels were formed.     

Effect of increasing the colloidal calcium phosphate of milk on the texture and microstructure of yogurt

The effect of increasing the colloidal calcium phosphate (CCP) content on the physical, rheological, and microstructural properties of yogurt was investigated. The CCP content of heated (85°C for 30 min) milk was increased by increasing the pH by the addition of alkali (NaOH). Alkalized milk was dialyzed against pasteurized skim milk at approximately 4°C for 72 h to attempt to restore the original pH and soluble Ca content. By adjustment of the milk to pH values 7.45, 8.84, 10.06, and 10.73, the CCP content was increased to approximately 107, 116, 123, and 128%, respectively, relative to the concentration in heated milk. During fermentation of milk, the storage modulus (G′) and loss tangent values of yogurts were measured using dynamic oscillatory rheology. Large deformation rheological properties were also measured. The microstructure of yogurt was observed using fluorescence microscopy, and whey separation was determined. Acid-base titration was used to evaluate changes in the CCP content in milk. Total Ca and casein-bound Ca increased with an increase in the pH value of alkalization. During acidification, elevated buffering occurred in milk between pH values 6.7 to 5.2 with an increase in the pH of alkalization. When acidified milk was titrated with alkali, elevated buffering occurred in milk between pH values 5.6 to 6.4 with an increase in the pH of alkalization. The high residual pH of milk after dialysis could be responsible for the decreased contents of soluble Ca in these milks. The pH of gelation was higher in all dialyzed samples compared with the heated control milk, and the gelation pH was higher with an increase in CCP content. The sample with highest CCP content (128%) exhibited gelation at very high pH (6.3), which could be due to alkali-induced CN micellar disruption. The G′ values at pH 4.6 were similar in gels with CCP levels up to 116%; at higher CCP levels, the G′ values at pH 4.6 greatly decreased. Loss tangent values at pH 5.1 were similar in all samples except in gels with a CCP level of 128%. For dialyzed milk, the whey separation levels were similar in gels made from milk with up to 107% CCP but increased at higher CCP levels. Microstructure of yogurt gels made from milk with 100 to 107% CCP was similar but very large clusters were observed in gels made from milk with higher CCP levels. By dialyzing heated milk against pasteurized milk, we may have retained some heat-induced Ca phosphate on micelles that normally dissolves on cooling because, during dialysis, pasteurized milk provided soluble Ca ions to the heated milk system. Yogurt texture was significantly affected by increasing the casein-bound Ca (and total Ca) content of milk as well as by the alkalization procedure involved in that approach.     

Effect of heat treatment on the rennet coagulation properties of recombined high total solids milk made from milk protein concentrate powder

The effects of heat treatment on the small and large deformation rheological properties of rennet gels made from recombined high total solids milk made from milk protein concentrate were studied. Heat treatment of recombined milk resulted in a slower rate of increase in the storage modulus (G') of rennet induced gels, a reduction in the gelation time and a decrease in the yield force required to fracture gels. The extent of whey protein denaturation (as a result of heat treatment) was related to the decrease in the G' value of gels as well as the yield force.     

Rheological properties of milk gels formed by a combination of rennet and glucono-delta-lactone

The effects of heat treatment of milk, and a range of rennet and glucono-delta-lactone (GDL) concentrations on the rheological properties, at small and large deformation, of milk gels were investigated. Gels were made from reconstituted skim milk at 30 degrees C, with two levels each of rennet and GDL. Together with controls this gave a total of sixteen gelation conditions, eight for unheated and eight for heated milk. Acid gels made from unheated milks had low storage moduli (G') of < 20 Pa. Heating milks at 80 degrees C for 30 min resulted in a large increase in the G' value of acid gels. Rennet-induced gels made from unheated milk had G' values in the range approximately 80-190 Pa. However, heat treatment severely impaired rennet coagulation: no gel was formed at low rennet levels and only a very weak gel was formed at high levels. In gels made with a combination of rennet and GDL unusual rheological behaviour was observed. After gelation, G' initially increased rapidly but then remained steady or even decreased, and at long ageing times G' values increased moderately or remained low. The loss tangent (tan delta) of acid gels made from heated milk increased after gelation to attain a maximum at pH approximately 5.1 but no maximum was observed in gels made from unheated milk. Gels made by a combination of rennet and GDL also exhibited a maximum in tan delta, indicating increased relaxation behaviour of the protein-protein bonds. We suggest that this maximum in tan delta was caused by a loosening of the intermolecular forces in casein particles caused by solubilization of colloidal calcium phosphate. We also suggest that in combination gels made from unheated milk a low value for the fracture stress and a high tan delta during gelation indicated an increased susceptibility of the network to excessive large scale rearrangements. In contrast. combination gels made from heated milk formed firmer gels crosslinked by denatured whey proteins and underwent fewer large scale rearrangements.     

Effect of temperature and pH on the properties of skim milk gels made from a tamarillo (Cyphomandra betacea) coagulant and rennet

Reconstituted skim milk was gelled with a crude protease extract from tamarillo [Cyphomandra betacea or Solanum betacea (syn.)] fruit and compared with gels prepared with calf rennet. The effects of temperature and pH on the gelation of skim milk were investigated by small deformation oscillatory rheology. The tamarillo extract-induced gels had a faster rate of increase in the elastic modulus (G′) at the early stage of gelation than rennet-induced milk gels. This was probably due to the broader proteolytic activity of tamarillo protease extracts as shown by sodium dodecyl sulfate–PAGE analysis. Confocal microscopy also showed that the milk gels resulting from the addition of tamarillo extracts had larger voids than rennet-induced milk gels. The proteolytic activity of tamarillo extracts was found to be optimal at pH 11. For both rennet and tamarillo extracts, the aggregation time was similar between pH 6.7 and 6.5, but the aggregation time of rennet-induced milk gels was lower than that of milk gels obtained by the addition of tamarillo extracts at pH lower than 6.5. An increase in temperature was found to have a significant effect on aggregation time, particularly at 20°C, where rennet did not coagulate milk in 3 h but the tamarillo extracts coagulated milk within 2 h. The results of this study suggest that extracts from tamarillo fruit could be used for milk gelation, particularly under lower temperature or high pH conditions.     

Effect of buttermilk made from creams with different heat treatment histories on properties of rennet gels and model cheeses

Although many studies have reported negative effects on cheese properties resulting from the use of buttermilk in cheese milk, the cause of these effects has not been determined. In this study, buttermilk was manufactured from raw cream and pasteurized cream, as well as from a cream derived from pasteurized whole milk. Skim milks with the same heat treatments were also manufactured to be used as controls. Compositional analysis of the buttermilks revealed a pH 4.6-insoluble protein content approximately 10% lower than that of the skim milk counterparts. Milk fat globule membrane (MFGM) proteins remained soluble at pH 4.6 in raw cream buttermilk; however, when heat was applied to cream or whole milk before butter making, MFGM proteins precipitated with the caseins. Rennet gel characterization showed that MFGM material in the buttermilks decreased the firmness and increased the set-to-cut time of rennet gels, but this effect was amplified when pasteurized cream buttermilk was added to cheese milk. The microstructure of gels was studied, and it was observed that gel appearance was very different when pasteurized cream buttermilk was used, as opposed to raw cream buttermilk. Model cheeses manufactured with buttermilks tended to have a higher moisture content than cheeses made with skim milks, explaining the higher yields obtained with buttermilk. Superior retention of MFGM particles was observed in model cheeses made from pasteurized cream buttermilk compared with raw cream buttermilk. The results from this study show that pasteurization of cream and of whole milk modifies the surface of MFGM particles, and this may explain why buttermilk has poor coagulation properties and therefore yields rennet gels with texture defects.     

Rennet Coagulability of High-Heat Treated Milk Influenced By Time of pH Adjustment

The coagulability of high-heat treated (91°C for 16 or 60 set) milk was measured with a Formagraph. Coagulation (hysteresis) and curd formation by such milk was increased by direct acidification to pH<6.4 before rennet addition. Coagulation properties were increased greatly when such milk was pH-cycled (i.e., acidified to pH 5.5, held overnight at 4°C, then neutralized to pH 6.2–6.4) before rennet addition.     

Effect of sodium chloride and pH on the rennet coagulation and gel firmness

The effect of sodium chloride concentration and pH of milk at renneting on the rennet clotting time (RCT) and gel firmness was studied. The results showed that rennet clotting activity and gel firmness decreased with increasing NaCl concentration in milk. The RCT increased as the pH of the salted milk decreased below 6.4. Milk containing 5 and 10 g NaCl/100 g did not coagulate at pH 5.0. The gel firmness increased with decreasing milk pH to 6.2 for unsalted milk. However, the firmness decreased as the pH of milk decreased below 6.2. In case of using salted milk, the firmness decreased as the pH at renneting dropped below 6.4.     

Insoluble calcium content and rheological properties of Colby cheese during ripening

Colby cheese was made using different manufacturing conditions (i.e., varying the lactose content of milk and pH values at critical steps in the cheesemaking process) to alter the extent of acid development and the insoluble and total Ca contents of cheese. Milk was concentrated by reverse osmosis (RO) to increase the lactose content. Extent of acid development was modified by using high (HPM) and low (LPM) pH values at coagulant addition, whey drainage, and curd milling. Total Ca content was determined by atomic absorption spectroscopy, and the insoluble (INSOL) Ca content of cheese was measured by the cheese juice method. The rheological and melting properties of cheese were measured by small amplitude oscillatory rheometry and UW-Melt Profiler, respectively. There was very little change in pH during ripening even in cheese made from milk with high lactose content. The initial (d 1) cheese pH was in the range of 4.9 to 5.1. The INSOL Ca content of cheese decreased during the first 4 wk of ripening. Cheeses made with the LPM had lower INSOL Ca content during ripening compared with cheese made with HPM. There was an increase in melt and maximum loss tangent values during ripening except for LPM cheeses made with RO-concentrated milk, as this cheese had pH <4.9 and exhibited limited melt. Curd washing reduced the levels of lactic acid produced during ripening and resulted in significantly higher INSOL Ca content. The use of curd washing for cheeses made from high lactose milk prevented a large pH decrease during ripening; high rennet and draining pH values also retained more buffering constituents (i.e., INSOL Ca phosphate), which helped prevent a large pH decrease.     

Effects of mineral salts and calcium chelating agents on the gelation of renneted skim milk

The effects of adding CaCl2, orthophosphate, citrate, EDTA, or a mixture of these, to reconstituted skim milk (90 g of solids/kg solution) on the gelation of renneted milk were mediated by changes in Ca2+ activity and the casein micelle. At pH 6.65, the addition of citrate or EDTA, which removed more than 33% of the original colloidal calcium phosphate with the accompanying release of 20% casein from the micelle, completely inhibited gelation. Reformation of the depleted colloidal calcium phosphate and casein in the micelle, by the addition of CaCl2, removed this inhibition. When the minimum requirements for colloidal calcium phosphate and casein in the micelle were met, the coagulation time decreased with increasing Ca2+ activity, leveling off at high Ca2+ activity. The storage modulus of renneted gels, measured at 3 h, increased with increasing colloidal calcium phosphate content of micelles up to a level at which it was approximately 130% of the original colloidal calcium phosphate in the micelles. Further increases in colloidal calcium phosphate by the addition of CaCl2, orthophosphate, or mixtures of these, which did not change the proportion of casein in the micelle, decreased the storage modulus. The gelation of the renneted milk was influenced by Ca2+ activity, the amounts of colloidal calcium phosphate, and casein within the micelle, with the effects of colloidal calcium phosphate and casein within the micelle clearly dominating the storage modulus. These results are consistent with the model of Horne (Int. Dairy J. 8:171-177, 1998) which postulates that, following cleavage of the stabilizing K-casein hairs by rennet, the properties of the rennet gel are determined by the balance between the electrostatic and hydrophobic forces between casein micelles.     

Acid and rennet gelation properties of sheep,goat, and cow milks: Effects of processing and seasonal variation

Gelation is an important functional property of milk that enables the manufacture of various dairy products. This study investigated the acid (with glucono-δ-lactone) and rennet gelation properties of differently processed sheep, goat, and cow milks using small-amplitude oscillatory rheological tests. The impacts of ruminant species, milk processing (homogenization and heat treatments), seasonality, and their interactions were studied. Acid gelation properties were improved (higher gelation pH, shorter gelation time, and higher storage modulus (G′) by intense heat treatment (95°C for 5 min) to comparable extents for sheep and cow milks, both better than those for goat milk. Goat milk produced weak acid gels with low G′ (<100 Pa) despite improvements induced by heat treatments. Seasonality had a marked impact on the acid gelation properties of sheep milk. The acid gels of late-season sheep milk had a lower gelation pH, no maximum in tan δ following gel formation, and 70% lower G′ values than those from other seasons. We propose the potential key role of a critical acid gelation pH that induces structural rearrangements in determining the viscoelastic properties of the final gels. For rennet-induced gelation, compared with cow milk, the processing treatments of the goat and sheep milks had much smaller impacts on their gelation properties. Intense heat treatment (95°C for 5 min) prolonged the rennet gelation time of homogenized cow milk by 8.6 min (74% increase) and reduced the G′ of the rennet gels by 81 Pa (85% decrease). For sheep and goat milks, the same treatment altered the rennet gelation time by only less than 3 min and the G′ of the rennet gels by less than 14 Pa. This difference may have been caused by the different physicochemical properties of the milks, such as differences in their colloidal stability, proportion of serum-phase caseins, and ionic calcium concentration. The seasonal variations in the gelation properties (both acid and rennet induced) of goat milk could be explained by the minor variation in its protein and fat contents. This study provides new perspectives and understandings of milk gelation by demonstrating the interactive effects among ruminant species, processing, and seasonality.     

Interactive Effects of Milk Fat Globule and Casein Micelle Size on the Renneting Properties of Milk

The size of the casein micelles (CM) and the milk fat globules (MFG) vary depending on farming factors, such as seasonal variation and stage of lactation, and cow genetics. The MFG and CM size of milk can influence the renneting behavior and texture of manufactured dairy products. In this work, we investigated the combined effects of MFG and CM size on the onset of gelation, the maximum rate of gelation, the value for G′_60 min (the final storage modulus) and G″_60 min (the final loss modulus), and tan δ upon renneting. Fractionation of MFG on the basis of size was carried out using laboratory-based centrifugation, whereas milk of predominantly large (184–218 nm) or small (147–159 nm) CM was selected naturally on-farm. Casein micelle size had the dominant effect on curd firmness and gelation rates of milk, where small CM milk formed rennet gels earlier and resulted in a firmer gel than milk with large CM. However, MFG size also influenced the renneting properties. The strongest rennet gels were obtained when large MFG (3.88–5.78 μm) was combined with small CM (153–159 nm). Selecting milk on the basis of the microstructure of key milk components could be achieved by natural selection of dairy cows or via fractionation technologies. Selection may provide a useful tool for efficient manufacturing of different dairy products based on the desirable characteristics specific to each.     

Low-fat akawi cheese made from bovine-camel milk blends: Rheological properties and microstructural characteristics

Camel milk (CM) can be used as an ingredient to produce various dairy products but it forms weak rennet-induced and acid-induced gels compared with bovine milk (BM). Therefore, in this study, we aimed to investigate the effect of blending bovine milk with camel milk on the physicochemical, rheological (amplitude sweep and frequency sweep), and microstructural properties of low-fat akawi (LFA) cheese. The cheeses were made of BM only or BM blended with 15% (CM15%) or 30% (CM30%) camel milk and stored at 4°C for 28 d. The viscoelastic properties as a function of temperature were assessed. The LFA cheeses made from blended milks had higher moisture, total Ca, and soluble Ca contents, and had higher pH 4.6–water-soluble nitrogen compared with those made from BM. Analysis by scanning electron microscopy demonstrated that the microstructures formed in BM cheese were rough with granular surfaces, whereas those in blended milk cheeses had smooth surfaces. Hardness was lower for LFA cheeses made from blended milk than for those made from BM only. The LFA cheeses demonstrated viscoelastic behavior in a linear viscoelastic range from 0.1 to 1.0% strain. The storage modulus (G′) was lower in LFA cheese made from BM over a range of frequencies. Adding CM reduced the resistance of LFA cheeses to flow as temperature increased. Blended cheeses exhibited lower complex viscosity values than BM cheeses during temperature increases. Thus, the addition of camel milk improved the rheological properties of LFA cheese.     

Effect of controlled kappa-casein hydrolysis on rheological properties of acid milk gels

An experimental method based on the controlled chymosin-induced kappa-casein hydrolysis of milk was proposed to modify micellar reactivity. Milk samples with a degree of kappa-casein hydrolysis of 19, 35, and 51% were obtained. The physicochemical properties of partially converted casein micelles were determined. The net negative charge of casein micelles was reduced with increasing degree of kappa-casein hydrolysis and a small but significant decrease in hydrodynamic diameter and micellar hydration were noted. Dynamic low amplitude oscillatory rheology was used to monitor the rheological properties of acid milk gels (GDL) made with partially chymosin-hydrolyzed milks in comparison with those of strictly acid and rennet gels. An increase in the gelation pH value was observed with increasing the degree of kappa-casein hydrolysis. The moduli values (G' and G') reached 2 h after the point of gel were, for all degrees of hydrolysis tested, significantly higher than those of strictly rennet and acid gels. Comparison of changes in delta G'/delta t with time indicated differences in gel formation that could be related to the increased values of G' obtained for acid gel made with chymosin-treated milk. At a given time after gelation (2 h), increasing the degree of kappa-casein hydrolysis in milk led also to an increase in the loss tangent and the serum holding capacity of acid milk gels suggesting a correlation between these two parameters.     

Protein interactions in heat-treated milk and effect on rennet coagulation

Skim milk was heated at different pH values to cause differential association of whey proteins (WP) with the casein micelles. All of these milk treatments coagulated poorly with rennet. To understand this in more detail, the casein micelles from heated milk were redispersed in unheated serum or unheated micelles were suspended in the sera from heat-treated milk. Systems containing micelles from milk heated at pH 6.7 and 7.1 were marginally better than the heated milk, but that from milk heated at pH 6.3 was not. The sera from milk heated at pH 6.7 and 7.1 impaired the clotting of native micelles but that from the pH 6.3 milk did not. Native casein micelles were suspended in permeates or dialyzed (against unheated milk) sera from heat-treated milk. Permeate systems free of WP/κ-casein complexes produced significantly stronger rennet gels; as did dialyzed systems. The impaired rennet clotting of heat-treated milk was attributed to a synergistic effect of the casein micelles with their heat-modified surfaces, the soluble serum WP/κ-casein complexes, and other dialyzable serum components.     

Rennet gelation properties of milk: Influence of natural variation in milk fat globule size and casein micelle size

Seasonal and farming practises can influence milk composition and functionality. An understanding of changes in milk fat globule (MFG) and casein micelle (CM) size may help to guide the selection of milk on the basis of MFG or CM size for manufacturing of different products and product quality. Milk was obtained from cows known to produce predominantly large or small MFG and CM. The rennet gelation properties of this milk were investigated by measuring the rheological properties during gel development. The structure of the CM and MFG network within the rennet gel were characterised by a series of microscopy techniques. Milk with small CM produced firmer curds, and the combination of large MFG (4.49–5.38 μm) with small CM (164–168 nm) produced the firmest curd of any of the combinations tested. MFG size can influence rennet gel firmness, an effect that is dependent upon the pore structure of the CM network.     

The formation and structure of milk protein gels

The formation of gels from milk proteins is irreversible. Most are not suitable for optical or rheological approaches.Various gels from milk products are discussed: those made by the action of rennet on whole milk, yoghurt, those from heated milk and by the storage of heated milk and gels made from whey protein of very high nutritional quality.     

Ripening of Camembert-type cheese made from caprine milk using calf rennet or kid rennet as coagulant

Camembert-type cheese was made from caprine milk using either calf rennet or kid 'Grandine' rennet as coagulant. The pH of all cheeses increased throughout ripening and levels of pH 4.6-soluble nitrogen increased from 8.1 to 18.2% of total nitrogen (TN) and from 6.9 to 20% TN for the cheeses made using calf rennet and kid rennet, respectively. Degradation of β-casein, measured by urea–polyacrylamide gel electrophoresis, and total and free amino acids were greater in the cheese made using kid rennet. Production of peptides, analysed by high performance liquid chromatography (HPLC), was slightly more extensive in the Camembert-type cheese made using calf rennet as coagulant. In general, a higher degree of proteolysis was found in Camembert-type cheese made from caprine milk using kid rennet than in cheese made using calf rennet as coagulant.