乳清浓缩蛋白在酸奶生产中的应用

以鲜奶，奶粉，乳清蛋白等乳成分为主要原料，研究了乳清浓缩蛋白在酸奶生产中的制做方法，对乳清浓缩蛋白代替部分高档脱脂奶粉生产酸奶产品的保水率，粘度，口感及组织状态进行了比较分析。结果表明，在酸奶生产中，添加一定的浓缩乳清蛋白代替高档脱脂奶粉是可行的，产品较为理想。     

乳清浓缩蛋白对搅拌型酸奶品质特性影响的研究

研究了以全脂奶粉和乳清浓缩蛋白（WPC-3503）为原料，按照全脂奶粉：乳清浓缩蛋白为100：0，90：10，80：20，70：30的质量配比生产乳固形物含量为12％的酸奶，对含有不同乳清蛋白比例的酸奶在贮藏过程中理化特性、乳酸菌总数的变化以及感官特性进行了比较分析。结果表明，WPC-3503代替10％-20％全脂奶粉生产酸奶时，在贮藏过程中可减缓pH值及酸度的变化速度，提高酸奶的黏度和保水率，改善感官特性，但对乳酸菌总数无明显的影响。     

Influence of skimmed milk concentrate replacement by dry dairy products in a low fat set‐type yoghurt model system. I: Use of whey protein concentrates,milk protein concentrates and skimmed milk powder

Ten commercial samples of dry dairy products used for protein fortification in a low fat yoghurt model system at industrial scale were studied. The products employed were whey protein concentratres, milk protein concentrates, skimmed milk concentrates and skimmed milk powder which originated from different countries. The gross chemical composition of these dried products were determined, including polyacrylamide gel electrophoresis (SDS‐PAGE) and isoelectric focusing of the proteins, and minerals such as Na, Ca, K and Mg. Yoghurts were formulated using a skim milk concentrated as a milk base enriched with different dry dairy products up to a 43 g kg⁻¹ protein content. Replacement percentage of skim milk concentrated by dry dairy products in the mix was between 1.49 and 3.77%. Yoghurts enriched with milk protein concentrates did not show significantly different viscosity (35.12 Pa s) and syneresis index (591.4 g kg⁻¹) than the two control yoghurts obtained only from skimmed milk concentrates (35.6 Pa s and 565.7 g kg⁻¹) and skimmed milk powder (32.77 Pa s and 551.5 g kg⁻¹), respectively. Yoghurt fortified with the whey protein concentrates, however, was less firm (22.59 Pa s) and had less syneresis index (216 g kg⁻¹) than control yoghurts. Therefore, whey protein concentrates may be useful for drinking yoghurt production. © 1999 Society of Chemical Industry     

Functional properties of biscuits with whey protein concentrate and honey

The effects of honey, lemon juice, and two different whey protein concentrates (WPC) on the structural and functional properties of biscuits, were analysed. Firmness, elasticity, relaxation time, adhesiveness, consistency and cohesiveness of dough and colour, fracture stress and fracture strain of biscuits were also determined. The presence of WPC with a high protein content produced a decrease in the firmness and consistency and an increase in the cohesiveness of dough. Honey increased the adhesiveness of dough, mainly in samples with the WPC of lower protein content and lemon juice, and tended to decrease dough relaxation time. The fracture stress of biscuits decreased with the incorporation of WPC. Also, honey increased the red undertone and yellowness of biscuits and decreased their lightness; however, the addition of lemon juice reduced these effects.     

The effect of bleaching agent on the flavor of liquid whey and whey protein concentrate

The increasing use and demand for whey protein as an ingredient requires a bland-tasting, neutral-colored final product. The bleaching of colored Cheddar whey is necessary to achieve this goal. Currently, hydrogen peroxide (HP) and benzoyl peroxide (BPO) are utilized for bleaching liquid whey before spray drying. There is no current information on the effect of the bleaching process on the flavor of spray-dried whey protein concentrate (WPC). The objective of this study was to characterize the effect of bleaching on the flavor of liquid and spray-dried Cheddar whey. Cheddar cheeses colored with water-soluble annatto were manufactured in duplicate. Four bleaching treatments (HP, 250 and 500 mg/kg and BPO, 10 and 20 mg/kg) were applied to liquid whey for 1.5 h at 60°C followed by cooling to 5°C. A control whey with no bleach was also evaluated. Flavor of the liquid wheys was evaluated by sensory and instrumental volatile analysis. One HP treatment and one BPO treatment were subsequently selected and incorporated into liquid whey along with an unbleached control that was processed into spray-dried WPC. These trials were conducted in triplicate. The WPC were evaluated by sensory and instrumental analyses as well as color and proximate analyses. The HP-bleached liquid whey and WPC contained higher concentrations of oxidation reaction products, including the compounds heptanal, hexanal, octanal, and nonanal, compared with unbleached or BPO-bleached liquid whey or WPC. The HP products were higher in overall oxidation products compared with BPO samples. The HP liquid whey and WPC were higher in fatty and cardboard flavors compared with the control or BPO samples. Hunter CIE Lab color values (L*, a*, b*) of WPC powders were distinct on all 3 color scale parameters, with HP-bleached WPC having the highest L* values. Hydrogen peroxide resulted in a whiter WPC and higher off-flavor intensities; however, there was no difference in norbixin recovery between HP and BPO. These results indicate that the bleaching of liquid whey may affect the flavor of WPC and that the type of bleaching agent used may affect WPC flavor.     

Process development for a novel milk protein concentrate with whey proteins as fibrils

Milk protein concentrate (MPC) is a preferred ingredient to provide nutritional and functional benefits in various dairy and food products. Altering the protein configuration and protein-protein interactions in MPC can provide a novel functionality and may open doors for new applications. The fibrilization process converts the globular structure of whey proteins to fibrils and consequently increases viscosity and water holding capacity compared with the native protein structure. The objective of the current work was to selectively convert the whey proteins in MPC as fibrils. For this purpose, simulated control model MPC was prepared by combining solutions of micellar casein concentrate (MCC) and milk whey protein isolate (mWPI) to give casein and whey protein in an 80:20 ratio. The mWPI solution was converted to fibrils by heating at low pH, neutralized, and combined with MCC solution similar to control model MPC and termed “fibrillated model MPC.” Thioflavin T fluorescence value, transmission electron microscopy, and gel electrophoresis confirmed the fibril formation and their survival after neutralization and mixing with MCC. Further, the fibrillated mWPI showed significantly higher viscosity and consistency coefficient than nonfibrillated mWPI. Similarly, fibrillated model MPC showed significantly higher viscosity and consistency coefficient compared with control model MPC. Hence, the fibrillated model MPC can be used as ingredient to increase viscosity. Heat coagulation time was found to be significantly higher for control model MPC compared with fibrillated model MPC.     

Physical properties of yoghurt manufactured with milk whey and transglutaminase

The effect of milk protein polymerization prior to the yoghurt fermentation process was evaluated by enzymatic reaction with microbial transglutaminase (Streptoverticillium mobaraense). Yoghurt samples were manufactured with 100% milk or by substituting milk with 20 or 30% of liquid milk whey, aimed at determining the use of natural milk whey in dairy products. Transglutaminase was added at a protein ratio of 0.5 U g⁻¹ to all samples and evaluated regarding rheological behavior, syneresis index and texture profile. The addition of enzyme transglutaminase contributed to syneresis prevention and increased the consistency index in yoghurt samples manufactured with milk whey. Yoghurt manufactured from 70% milk plus 20% milk whey, followed by enzymatic treatment, presented similar characteristics to traditionally manufactured yoghurt (C 100), with no alteration in the syneresis of the samples (p > 0.05) and presented texture parameters similar to the control yoghurt (C 100).     

The effect of acidification of liquid whey protein concentrate on the flavor of spray-dried powder

Off-flavors in whey protein negatively influence consumer acceptance of whey protein ingredient applications. Clear acidic beverages are a common application of whey protein, and recent studies have demonstrated that beverage processing steps, including acidification, enhance off-flavor production from whey protein. The objective of this study was to determine the effect of preacidification of liquid ultrafiltered whey protein concentrate (WPC) before spray drying on flavor of dried WPC. Two experiments were performed to achieve the objective. In both experiments, Cheddar cheese whey was manufactured, fat-separated, pasteurized, bleached (250 mg/kg of hydrogen peroxide), and ultrafiltered (UF) to obtain liquid WPC that was 13% solids (wt/wt) and 80% protein on a solids basis. In experiment 1, the liquid retentate was then acidified using a blend of phosphoric and citric acids to the following pH values: no acidification (control; pH 6.5), pH 5.5, or pH 3.5. The UF permeate was used to normalize the protein concentration of each treatment. The retentates were then spray dried. In experiment 2, 150 μg/kg of deuterated hexanal (D₁₂-hexanal) was added to each treatment, followed by acidification and spray drying. Both experiments were replicated 3 times. Flavor properties of the spray-dried WPC were evaluated by sensory and instrumental analyses in experiment 1 and by instrumental analysis in experiment 2. Preacidification to pH 3.5 resulted in decreased cardboard flavor and aroma intensities and an increase in soapy flavor, with decreased concentrations of hexanal, heptanal, nonanal, decanal, dimethyl disulfide, and dimethyl trisulfide compared with spray drying at pH 6.5 or 5.5. Adjustment to pH 5.5 before spray drying increased cabbage flavor and increased concentrations of nonanal at evaluation pH values of 3.5 and 5.5 and dimethyl trisulfide at all evaluation pH values. In general, the flavor effects of preacidification were consistent regardless of the pH to which the solutions were adjusted after spray drying. Preacidification to pH 3.5 increased recovery of D₁₂-hexanal in liquid WPC and decreased recovery of D₁₂-hexanal in the resulting powder when evaluated at pH 6.5 or 5.5. These results demonstrate that acidification of liquid WPC80 to pH 3.5 before spray drying decreases off-flavors in spray-dried WPC and suggest that the mechanism for off-flavor reduction is the decreased protein interactions with volatile compounds at low pH in liquid WPC or the increased interactions between protein and volatile compounds in the resulting powder.     

Physiochemical,textural, sensory properties and probiotic survivability of Chinese Laosuan Nai (protein‐fortified set yoghurt) using polymerised whey protein as a co‐thickening agent

A new Chinese Laosuan Nai (protein‐fortified set yoghurt) was developed using polymerised whey protein (PWP, 0.4%, w/v) as a co‐thickening agent. The prototype was analysed for physiochemical, textural, sensory properties and probiotic survivability and compared with a commercial sample. Experimental yoghurts were significantly higher in pH, protein content, hardness and viscosity (P < 0.01). Microstructure indicated a uniform and denser protein network. Probiotics remained stable for Bifidobacterium during a 10‐week storage period. Results indicated that polymerised whey protein may be a novel protein‐based co‐thickening agent for making Chinese Laosuan Nai.     

酪蛋白与乳清蛋白比例对酸奶凝胶性质的影响

研究了乳中酪蛋白和乳清蛋白比例对凝固型酸奶流变学特性和微观结构的影响,结果表明,固定蛋白质质量分数、降低酪蛋白和乳清蛋白的比例,可以明显提高酸奶凝胶的质量.乳中蛋白质质量分数一致时,酸奶凝胶的硬度、黏度、持水力随着酪蛋白和乳清蛋白比例的减小而增大,凝胶网络结构变得更规则、致密,孔隙更小.在低蛋白质质量分数下,降低乳中酪...     

Nutritional,physicochemical, and textural properties of gluten-free extruded snacks containing cowpea and whey protein concentrate

Ready-to-eat extruded snacks with high protein and fibre were developed from a composite flour comprising rice flour, cowpea flour and whey protein concentrate (WPC). Nutritional, physicochemical, and textural properties of extrudates were evaluated, at five ratios of cowpea: WPC (10:0, 15:05, 20:10, 25:15, 30:20); rice flour was used as a control. The protein and fibre content in the extrudates significantly increased (P ≤ 0.05) with cowpea (10%–30%) and WPC (5%–20%) incorporation compared to the control. The extrudates with higher levels of cowpea and WPC showed a significant increase in bulk density and hardness. A slight decrease of 12% was observed in the expansion of 15% cowpea and 5% WPC fortified extrudates compared to the control. The number of peaks during compression increased with incorporations of cowpea and WPC. All cowpea and WPC containing snacks were darker than the control. Significant correlations were found between the protein, fibre, colour values and textural properties. The essential and non-essential amino acid profiles increased in the extrudates, proportionally to the cowpea and WPC fortification.     

Astringency of bovine milk whey protein

Whey protein solutions at pH 3.5 elicited an astringent taste sensation. The astringency of whey protein isolate (WPI), the process whey protein (PWP) that was prepared by heating WPI at pH 7.0, and the process whey protein prepared at pH 3.5 (aPWP) were adjusted to pH 3.5 and evaluated by 2 sensory analyses (the threshold method and the scalar scoring method) and an instrumental analysis (taste sensor method). The taste-stimulating effects of bovine and porcine gelatin were also evaluated. The threshold value of astringency of WPI, PWP, and aPWP was 1.5, 1.0, and 0.7 mg/mL, respectively, whereas the gelatins did not give definite astringency. It was confirmed by the scalar scoring method that the astringency of these proteins increased with the increase in protein concentration, and these proteins elicited strong astringency at 10 mg/mL under acidic conditions. On the other hand, the astringency was not elicited at pH 3.5 by 2 types of gelatin. A taste sensor gave specific values for whey proteins at pH 3.5, which corresponded well to those obtained by the sensory analysis. Elicitation of astringency induced by whey protein under acidic conditions would be caused by aggregation and precipitation of protein molecules in the mouth.     

Texture of nonfat yoghurt as influenced by whey protein concentrate and Gum Tragacanth as fat replacers

Seven batches of nonfat yoghurt stabilized with different concentrations of whey protein concentrate (WPC) and Gum Tragacanth (GT) were produced to study the effects of WPC and GT as fat replacers on the rheological properties of yoghurt. By increasing the WPC up to 15 g/L, storage modulus (G'), loss modulus (G") and complex dynamic viscosity (η*) values were increased and sensory impressions of texture and appearance were improved when compared with the control nonfat yoghurt. Addition of gum above 0.5 g/L led the decrease of G', G", η* and resulted in lower scores for sensory attributes than control nonfat yoghurt.     

乳清蛋白-黄油乳液凝胶对低脂酸奶理化特性及品质的影响

乳液凝胶是一种新型的脂肪替代物,乳清蛋白和黄油是乳品中常用的原、辅料,利用乳清蛋白和黄油制作的乳液凝胶在乳制品加工中具有良好的应用前景.制备不同蛋白和脂肪含量的乳清蛋白-黄油乳液凝胶颗粒(whey protein-butter emulsion gel particles,WPI-EG),研究其对低脂酸奶理化特性及感官...     

Production of a high gel strength whey protein concentrate from cheese whey

In order to develop a process for the production of a whey protein concentrate (WPC) with high gel strength and water-holding capacity from cheese whey, we analyzed 10 commercially available WPC with different functional properties. Protein composition and modification were analyzed using electrophoresis, HPLC, and mass spectrometry. The analyses of the WPC revealed that the factors closely associated with gel strength and water-holding capacity were solubility and composition of the protein and the ionic environment. To maintain whey protein solubility, it is necessary to minimize heat exposure of the whey during pretreatment and processing. The presence of the caseinomacropeptide (CMP) in the WPC was found to be detrimental to gel strength and water-holding capacity. All of the commercial WPC that produced high-strength gels exhibited ionic compositions that were consistent with acidic processing to remove divalent cations with subsequent neutralization with sodium hydroxide. We have shown that ultrafiltration/diafiltration of cheese whey, adjusted to pH 2.5, through a membrane with a nominal molecular weight cut-off of 30,000 at 15 degrees C substantially reduced the level of CMP, lactose, and minerals in the whey with retention of the whey proteins. The resulting WPC formed from this process was suitable for the inclusion of sodium polyphosphate to produce superior functional properties in terms of gelation and water-holding capacity.     

The effect of starter culture and annatto on the flavor and functionality of whey protein concentrate

The flavor of whey protein can carry over into ingredient applications and negatively influence consumer acceptance. Understanding sources of flavors in whey protein is crucial to minimize flavor. The objective of this study was to evaluate the effect of annatto color and starter culture on the flavor and functionality of whey protein concentrate (WPC). Cheddar cheese whey with and without annatto (15 mL of annatto/454 kg of milk, annatto with 3% wt/vol norbixin content) was manufactured using a mesophilic lactic starter culture or by addition of lactic acid and rennet (rennet set). Pasteurized fat-separated whey was then ultrafiltered and spray dried into WPC. The experiment was replicated 4 times. Flavor of liquid wheys and WPC were evaluated by sensory and instrumental volatile analyses. In addition to flavor evaluations on WPC, color analysis (Hunter Lab and norbixin extraction) and functionality tests (solubility and heat stability) also were performed. Both main effects (annatto, starter) and interactions were investigated. No differences in sensory properties or functionality were observed among WPC. Lipid oxidation compounds were higher in WPC manufactured from whey with starter culture compared with WPC from rennet-set whey. The WPC with annatto had higher concentrations of p-xylene, diacetyl, pentanal, and decanal compared with WPC without annatto. Interactions were observed between starter and annatto for hexanal, suggesting that annatto may have an antioxidant effect when present in whey made with starter culture. Results suggest that annatto has a no effect on whey protein flavor, but that the starter culture has a large influence on the oxidative stability of whey.     

Effect of anthocyanin-absorbed whey protein microgels on physicochemical and textural properties of reduced-fat Cheddar cheese

Reduced-fat foods have become more popular due to their health benefits; however, reducing the fat content of food affects the sensory experience. Therefore, it is necessary to improve the sensory acceptance of reduced-fat foods to that of full-fat equivalents. The aim of this study was to evaluate the effect of adding whey protein microgels (WPM) with an average diameter of 4 μm, or WPM with adsorbed anthocyanins [WPM (Ant)] on the textural and sensory properties of reduced-fat Cheddar cheese (RFC). Reduced-fat Cheddar cheese was prepared in 2 ways: (1) by adding WPM, designated as RFC+M, or (2) by adding WPM (Ant), designated as RFC+M (Ant). For comparison, RFC without fat substitutes and full-fat Cheddar cheese were also prepared. We discovered that the addition of WPM and WPM (Ant) increased the moisture content, fluidity, and meltability of RFC, and reduced its hardness, springiness, and chewiness. The textural and sensory characteristics of RFC were markedly inferior to those of full-fat Cheddar cheese, whereas addition of WPM and WPM (Ant) significantly improved the sensory characteristics of RFC. The WPM and WPM (Ant) showed a high potential as fat substitutes and anthocyanin carriers to effectively improve the acceptance of reduced-fat foods.     

High hydrostatic pressure modification of whey protein concentrate for improved functional properties

Whey protein concentrate (WPC) has many applications in the food industry. Previous research demonstrated that treatment of whey proteins with high hydrostatic pressure (HHP) can enhance solubility and foaming properties of whey proteins. The objective of this study was to use HHP to improve functional properties of fresh WPC, compared with functional properties of reconstituted commercial whey protein concentrate 35 (WPC 35) powder. Fluid whey was ultrafiltered to concentrate proteins and reconstituted to equivalent total solids (8.23%) as reconstituted commercial WPC 35 powder. Solutions of WPC were treated with 300 and 400 MPa (0- and 15-min holding time) and 600 MPa (0-min holding time) pressure. After HHP, the solubility of the WPC was determined at both pH 4.6 and 7.0 using UDY and BioRad protein assay methods. Overrun and foam stability were determined after protein dispersions were whipped for 15 min. The protein solubility was greater at pH 7.0 than at pH 4.6, but there were no significant differences at different HHP treatment conditions. The maintenance of protein solubility after HHP indicates that HHP-treated WPC might be appropriate for applications to food systems. Untreated WPC exhibited the smallest overrun percentage, whereas the largest percentage for overrun and foam stability was obtained for WPC treated at 300 MPa for 15 min. Additionally, HHP-WPC treated at 300 MPa for 15 min acquired larger overrun than commercial WPC 35. The HHP treatment of 300 MPa for 0 min did not improve foam stability of WPC. However, WPC treated at 300 or 400 MPa for 15 min and 600 MPa for 0 min exhibited significantly greater foam stability than commercial WPC 35. The HHP treatment was beneficial to enhance overrun and foam stability of WPC, showing promise for ice cream and whipping cream applications.