Fate of Listeria monocytogenes during freezing,thawing and home storage of frankfurters

Little information is available regarding the fate of Listeria monocytogenes during freezing, thawing and home storage of frankfurters even though recent surveys show that consumers regularly store unopened packages in home freezers. This study examined the effects of antimicrobials, refrigerated storage, freezing, thawing method, and post-thawing storage (7 °C) on L. monocytogenes on frankfurters. Inoculated (2.1 log CFU/cm²) frankfurters formulated without (control) or with antimicrobials (1.5% potassium lactate plus 0.1% sodium diacetate) were vacuum-packaged, stored at 4 °C for 6 or 30 d and then frozen (−15 °C) for 10, 30, or 50 d. Packages were thawed under refrigeration (7 °C, 24 h), on a countertop (23 ± 2 °C, 8 h), or in a microwave oven (2450 MHz, 1100 watts, 220 s followed by 120 s holding), and then stored aerobically (7 °C) for 14 d. Bacterial populations were enumerated on PALCAM agar and tryptic soy agar plus 0.6% yeast extract. Antimicrobials completely inhibited (p < 0.05) growth of L. monocytogenes at 4 °C for 30 d under vacuum-packaged conditions, and during post-thawing aerobic storage at 7 °C for 14 d. Different intervals between inoculation and freezing (6 or 30 d) resulted in different pathogen levels on control frankfurters (2.1 or 3.9 log CFU/cm², respectively), while freezing reduced counts by <1.0 log CFU/cm². Thawing treatments had little effect on L. monocytogenes populations (<0.5 log CFU/cm²), and post-thawing fate of L. monocytogenes was not influenced by freezing or by thawing method. Pathogen counts on control samples increased by 1.5 log CFU/cm² at d-7 of aerobic storage, and reached 5.6 log CFU/cm² at d-14. As indicated by these results, consumers should freeze frankfurters immediately after purchase, and discard frankfurters formulated without antimicrobials within 3 d of thawing and/or opening.     

Effect of fat content on survival of Listeria monocytogenes during simulated digestion of inoculated beef frankfurters stored at 7 °C

Potential effects of the fat content of frankfurters on the gastrointestinal survival of Listeria monocytogenes were investigated. At various stages of storage (7 °C, up to 55 days), inoculated frankfurters of low (4.5%) and high (32.5%) fat content were exposed to a dynamic gastrointestinal model (37 °C) and L. monocytogenes counts were determined at intervals during exposure in each gastrointestinal compartment (gastric, GC; intestinal, IC). Bacterial survival curves in each compartment were fitted with the Baranyi and Roberts mathematical model. L. monocytogenes populations on low- and high-fat frankfurters exceeded 8.0 log CFU/g at 39 and 55 days of storage, respectively. Major declines in populations occurred after 60 min on low-fat frankfurters in the GC, with reductions of 2.6 to >7.2 log CFU/g at 120 min on days 1 and 39 of storage, respectively. L. monocytogenes reductions in high-fat frankfurters ranged from 1.6 (day-1) to 5.2 (day-55) log CFU/g. Gastric inactivation rates were 0.080–0.194 and 0.030–0.097 log CFU/g/min for low- and high-fat samples, respectively. Since gastric emptying began while the gastric pH was >5, initial counts (enumerated 30 min after ingestion) reaching the IC depended on initial contamination levels on each product, which increased during storage. Subsequent reductions during the intestinal challenge were 0.1–1.4 log CFU/g. Findings indicated protective effects of fat against gastric destruction of L. monocytogenes. However, since the effects of fat were observed mainly at later stages of gastric exposure, they did not influence numbers of viable cells reaching the IC.     

Effectiveness of potassium lactate and sodium diacetate in combination with irradiation to control Listeria monocytogenes on frankfurters

ABSTRACT:  The use of antimicrobial ingredients in combination with irradiation is an effective antilisterial intervention strategy for ready-to-eat meat products. Microbial safety was evaluated for frankfurters formulated with 0% or 3% added potassium lactate/sodium diacetate solution and inoculated with Listeria monocytogenes before or after treatment with irradiation (0, 1.8, or 2.6 kGy). Frankfurters were stored aerobically or vacuum packaged and L. mo nocytogenes counts and APCs were determined while refrigerated. The incorporation of lactate/diacetate with or without irradiation had a strong listeriostatic effect for aerobically stored frankfurters. Outgrowth was suppressed and counts were not different from initial counts (5.2 log CFU/frank compared with 5.0 log CFU/frank); however, those without the additive increased steadily (5.4 to 9.3 log CFU/frank). Irradiation treatments alone had higher L. monocytogenes counts after 3 wk. For vacuum-packaged frankfurters, both the addition of lactate/diacetate and irradiation were effective at controlling growth after 8 wk. Large and incremental reductions in total counts were seen for irradiation treatments. Initial counts were reduced by 3 log CFU with the application of 1.8 kGy while 2.6 kGy decreased counts over 5 log CFU. These reductions were maintained throughout storage for lactate/diacetate-treated frankfurters. By 8 wk, L. monocytogenes counts on 1.8 and 2.6 kGy irradiated frankfurters without lactate/diacetate increased to 7.43 and 6.13 log CFU, respectively. Overall, lactate/diacetate retarded the outgrowth of L. monocytogenes on frankfurters throughout aerobic storage and the combination of irradiation and 3% lactate/diacetate reduced and retarded growth of L. monocytogenes , especially during the last 2 wk of vacuum-packaged storage.     

Evaluation of Changes in Listeria monocytogenes Populations on Frankfurters at Different Stages from Manufacturing to Consumption

ABSTRACT: This study evaluated the fate of inoculated Listeria monocytogenes on frankfurters stored under conditions simulating those that may be encountered between manufacturing and consumption. Frankfurters with or without 1.5% potassium lactate and 0.1% sodium diacetate (PL/SD) were inoculated (1.8 ± 0.1 log CFU/cm²) with a 10‐strain composite of L. monocytogenes, vacuum‐packaged, and stored under conditions simulating predistribution storage (24 h, 4 °C), temperature abuse during transportation (7 h, 7 °C followed by 7 h, 12 °C), and storage before purchase (60 d, 4 °C; SBP). At 0, 20, 40, and 60 d of SBP, samples were exposed to conditions simulating delivery from stores to homes or food establishments (3 h, 23 °C), and then opened or held vacuum‐packaged at 4 or 7 °C for 14 d (SHF). Pathogen counts remained relatively constant on frankfurters with PL/SD regardless of product age and storage conditions; however, they increased on product without antimicrobials. In vacuum‐packaged samples, during SHF at 4 °C, the pathogen grew faster (P < 0.05) on older product (20 d of SBP) compared to product that was fresh (0 d of SBP); a similar trend was observed in opened packages. At 7 °C, the fastest growth (0.35 ± 0.02 log CFU/cm²/d) was observed on fresh product in opened packages; in vacuum‐packages, growth rates on fresh and aged products were similar. By day 40 of SBP the pathogen reached high numbers and increased slowly or remained unchanged during SHF. This information may be valuable in L. monocytogenes risk assessments and in development of guidelines for storage of frankfurters between package opening and product consumption.     

Reductionin Listeria monocytogenes,Salmonella enterica and Escherichia coli O157:H7 in vitro and on tomato by sophorolipid and sanitiser as affected by temperature and storage time

Increased consumption of produce by consumers has been attributed to perceived health benefits of postharvest produce. Pathogen control is crucial because periodic occurrences and contamination of tomato and leafy greens have exacerbated food safety risks for consumers. We investigated the effects of temperatures (5 and 25 °C), storage time (30 min and 24 h) for inactivation of Listeria monocytogenes, Salmonella enterica and Escherichia coli O157:H7 by sophorolipid (SL‐p) produced fermentatively using palmitic acid as a co‐substrate at different concentrations in vitro. Reduction in pathogenic bacteria on grape tomato by SL‐p, sanitiser (Lovit) and combinations of SL‐p and sanitiser was determined. Temperature and storage time significantly (P < 0.05) affected pathogen inactivations by SL‐p as pathogen reductions were greater at 25 °C and 24 h than at 5 °C and 30 min of storage. L. monocytogenes was the most sensitive to SL‐p treatment as reductions of 5 log relative to untreated controls were attained at 0.12% of SL‐p. Significant reductions in S. enterica (1.91–3.85 logs) and E. coli O157:H7 (0.87–4.09 logs) were recorded at 2–5% of SL‐p. Lower populations of Salmonella and E. coli O157:H7 were inactivated than L. monocytogenes. On grape tomato, pathogen populations inactivated increased at higher SL‐p levels at 25 °C. Sanitiser and sanitiser + SL‐p reduced bacterial populations on tomato by 5.29–5.76 logs and 0.71–3.3.66 logs, respectively. These results imply the interactions of temperature, storage time and SL‐p significantly (P < 0.05) affected pathogen strain reductions. The combination of SL‐p with sanitiser led to synergistic effect on E. coli O157:H7, but not L. monocytogenes and S. enterica.     

Reduction of Listeria monocytogenes populations during exposure to a simulated gastric fluid following storage of inoculated frankfurters formulated and treated with preservatives

The effect of a simulated gastric fluid (adjusted to pH 1.0 with HCl) on Listeria monocytogenes, inoculated postprocessing on pork frankfurters formulated with sodium lactate (SL) and sodium diacetate (SD) and not dipped or dipped in solutions of lactic acid or acetic acid, was evaluated during storage of the frankfurters at 10 degrees C for 40 days. Pork frankfurters containing 1.8% SL, 0.25% SD, 1.8% SL+0.125% SD, or 1.8% SL+0.25% SD were inoculated with 10(2)-10(3) CFU/cm2 of a 10-strain preparation of L. monocytogenes and were not dipped or dipped for 2 min in solutions of 2.5% lactic or acetic acid before they were vacuum-packaged and stored. Survival of L. monocytogenes was determined after exposure of frankfurters for 0, 20, 40, and 60 min to the simulated gastric fluid after storage for 0, 10, 20, 30, or 40 days. Growth of L. monocytogenes on frankfurters formulated with antimicrobials was inhibited in the order control 相似文献   

Efficacy of freezing, frozen storage and edible antimicrobial coatings used in combination for control of Listeria monocytogenes on roasted turkey stored at chiller temperatures

The presence and growth of Listeria monocytogenes on ready-to-eat (RTE) turkey is an important food safety issue. The antilisterial efficacy of four polysaccharide-based edible coatings (starch, chitosan, alginate and pectin) incorporating sodium lactate (SL) and sodium diacetate (SD) as well as commercial preparations Opti.Form PD4, NovaGARD™ CB1, Protect-M and Guardian™ NR100 were compared against L. monocytogenes on roasted turkey. Pectin coating treatments incorporating SL/SD, Opti.Form PD4 with or without Protect-M, and NovaGARD™ CB1 displayed higher antimicrobial efficacy against.L. monocytogenes than the other antimicrobials and coating materials. In the second phase of the study, it was investigated whether frozen storage could enhance the antilisterial effectiveness of pectin coating treatments on chilled roasted turkey. Inoculated roasted turkey samples coated with pectin-based treatments were frozen for up to 4 weeks and subsequently stored at 4 °C for 8 weeks. Frozen storage significantly enhanced the antilisterial activity of various coating treatments; with selected treatments reducing the L. monocytogenes populations by as much as 1.1 log CFU/cm² during the subsequent 8-week chilled storage. This study demonstrates that pectin-based antimicrobial edible coatings hold promise in enhancing the safety of RTE poultry products and frozen storage has the potential to enhance their effectiveness.     

Effects and interactions of sodium lactate, sodium diacetate, and pediocin on the thermal inactivation of starved Listeria monocytogenes on bologna

The effects and interactions of temperature (56.3-60 °C), sodium lactate (SL; 0-4.8%), sodium diacetate (SDA; 0-2.5%), and pediocin (0-10,000 AU) on starved Listeria monocytogenes (10⁷ CFU/g) on bologna were investigated. Bologna slices containing SL and SDA in the formulation were dipped in pediocin, surface inoculated, and treated at various temperatures using combinations of parameters determined by central composite design. D-values were calculated. The observed D-values ranged from 2.8 min at 60 °C to 24.61 min at 56.3 °C. Injury ranged from 9.1 to 76% under various conditions. The observed D-values were analyzed using second order response surface regression for temperature, SL, SDA, and pediocin, and a predictive model was developed. Predicted D-values were calculated and ranged from 3.7 to 19 min for various combinations of parameters. Temperature alone reduced the predicted D-values from 33.96 min at 56.3 °C to 11.51 min at 60 °C. Addition of SL showed a protective effect. Other combination treatments either reduced or increased D-values depending on temperature. The combination of SL and SDA was effective at lower temperatures, however, higher levels of SDA at higher temperatures made the organism more heat resistant. Pediocin (up to 5000 AU) with increasing temperature and SDA reduced D-values. Depending on temperature and concentration, the interactions between various additives can affect thermal inactivation of L. monocytogenes on bologna. Starvation rendered L. monocytogenes more susceptible to heat and additives.     

Control of Listeria monocytogenes on frankfurters with antimicrobials in the formulation and by dipping in organic acid solutions

The antilisterial activity of sodium lactate (SL) and sodium diacetate (SD) was evaluated in a frankfurter formulation and in combination with a dipping treatment into solutions of lactic acid or acetic acid after processing and inoculation. Pork frankfurters were formulated with 1.8% SL or 0.25% SD or combinations of 1.8% SL with 0.25 or 0.125% SD. After processing, frankfurters were inoculated (2 to 3 log CFU/cm2) with a 10-strain composite of Listeria monocytogenes and left undipped or were dipped (2 min) in 2.5% solutions of lactic acid or acetic acid (23 +/- 2 degrees C) before vacuum packaging and storage at 10 degrees C for 40 days. Total microbial populations and L. monocytogenes, lactic acid bacteria, and yeasts and molds were enumerated during storage. Sensory evaluations also were carried out on frankfurters treated and/or formulated with effective antimicrobials. The combination of 1.8% SL with 0.25% SD provided complete inhibition of L. monocytogenes growth throughout storage. Dipping in lactic acid or acetic acid reduced initial populations by 0.7 to 2.1 log CFU/cm2, but during storage (12 to 20 days), populations on dipped samples without antimicrobials in the formulation reached 5.5 to 7.9 log CFU/cm2. For samples containing single antimicrobials and dipped in lactic acid or acetic acid, L. monocytogenes growth was completely inhibited or reduced over 12 and 28 days, respectively, whereas final populations were lower (P < 0.05) than those in undipped samples of the same formulations. Bactericidal effects during storage (reductions of 0.6 to 1.0 log CFU/ cm2 over 28 to 40 days) were observed in frankfurters containing combinations of SL and SD that were dipped in organic acid solutions. Inclusion of antimicrobials in the formulation and/or dipping the product into organic acid solutions did not affect (P > 0.05) the flavor and overall acceptability of products compared with controls. The results of this study may be valuable to meat processors as they seek approaches for meeting new regulatory requirements in the United States.     

Sodium lactate,sodium diacetate and pediocin: Effects and interactions on the thermal inactivation of Listeria monocytogenes on bologna

The effects and interactions of temperature (56.3–60 °C), sodium lactate (SL; 0–4.8%), sodium diacetate (SD; 0–0.25%) and pediocin (0–10,000 AU) on Listeria monocytogenes on bologna were studied and a predictive inactivation model was developed. Bologna was manufactured with different SL/SD concentrations in the formulation, dipped in pediocin solution and treated at different temperatures using combinations of parameters determined by central composite design. D-values were calculated and analyzed using second order response regression. Predicted D-values were also calculated. The observed D-values for L. monocytogenes on bologna ranged from 2.10 to 35.59 min. Temperature alone decreased predicted D-values from 99.02 min at 56.3 °C to 44.71 min at 60.0 °C. Adding SL decreased D-values (85.43–22.71 min) further; however, heat and SD combined was the most effective for reducing L. monocytogenes on bologna. An SD level of 0.25% at 58.2 °C had the overall lowest predicted D-value (15.95 min). Combination treatments increased or decreased D-values, depending on the temperature. Pediocin (2500 and 5000 AU) and heat decreased D-values, but exhibited a protective effect at higher concentrations (≥7500 AU). The results showed that interactions between additives in formulations can vary at different temperatures/concentrations, thereby affecting thermal inactivation of foodborne pathogens in meat products. Hence, food processors should modify food formulations carefully, and verify with adequate testing so that product safety is not compromised.     

Application of an active alginate coating to control the growth of Listeria monocytogenes on poached and deli turkey products

The relatively high prevalence of Listeria monocytogenes in ready-to-eat (RTE) turkey products is of great concern. The overall objective of this study was to develop antimicrobial edible coating formulations to effectively control the growth of this pathogen. The antimicrobials studied were nisin (500 IU/g), Novagard CB 1 (0.25%), Guardian NR100 (500 ppm), sodium lactate (SL, 2.4%), sodium diacetate (SD, 0.25%), and potassium sorbate (PS, 0.3%). These were incorporated alone or in binary combinations into five edible coatings: alginate, κ-carrageenan, pectin, xanthan gum, and starch. The coatings were applied onto the surface of home-style poached and processed deli turkey discs inoculated with ~ 3 log CFU/g of L. monocytogenes. The turkey samples were then stored at 22 °C for 7 days. For poached and processed deli turkey, the coatings were found to be equally effective, with pectin being slightly less effective than the others. The most effective poached turkey treatments seemed to be SL (2.4%)/SD (0.25%) and Nisin (500 IU/g)/SL (2.4%), which yielded final populations of 3.0 and 4.9 log CFU/g respectively compared to the control which was 7.9 log CFU/g. For processed deli turkey, the most effective antimicrobial treatments seemed to be Nisin (500 IU/g)/SD (0.25%) and Nisin (500 IU/g)/SL (2.4%) with final populations of 1.5 and 1.7 log CFU/g respectively compared to the control which was 6.5 log CFU/g. In the second phase of the study, home-style poached and store-purchased roasted (deli) turkey inoculated with the pathogen at a level of ~ 3 log CFU/g were coated with alginate incorporating selected antimicrobial combinations and stored for 8 weeks at 4 °C. Alginate coatings supplemented with SL (2.4%)/PS (0.3%) delayed the growth of L. monocytogenes with final counts reaching 4.3 log CFU/g (home-style poached turkey) and 6.5 log CFU/g (roasted deli turkey) respectively while the counts in their untreated counterparts were significantly higher (P < 0.05) reaching 9.9 and 7.9 log CFU/g, respectively. This study therefore demonstrates the effectiveness of using alginate-based antimicrobial coatings to enhance the microbiological safety and quality of RTE poultry products during chilled storage.     

Evaluating the growth of Listeria monocytogenes in refrigerated ready-to-eat frankfurters: influence of strain, temperature, packaging, lactate and diacetate, and background microflora

This research was conducted to study the growth of Listeria monocytogenes inoculated on frankfurters stored at different conditions as a basis for a safety-based consume by shelf life date label. Three L. monocytogenes strains were separately inoculated at 10 to 20 CFU/cm2 onto frankfurters that were previously formulated with or without high pressure and with or without added 2% potassium lactate (PL) and 0.2% sodium diacetate (SD). Inoculated frankfurters were air or vacuum packaged; stored at 4, 8, or 12 degrees C; and L. monocytogenes and psychrotrophic plate counts were determined for 90, 60, and 45 days, respectively, or until the stationary phase was reached. The data (log CFU per square centimeter versus time) were fitted using the Baranyi-Roberts model to determine maximum growth rates and lag-phase time. The maximum growth rates and the lag time under each growth condition were used to calculate the time to reach 100-fold the initial Listeria population. In frankfurters lacking PL and SD, the count of all strains increased by 2 log after 18 to 50 days at 4 degrees C and 4 to 13 days at 8 degrees C. The growth was inhibited at 4 and 8 degrees C in frankfurters containing PL and SD, but one ribotype was capable of growing, with the time to reach 100-fold the initial Listeria population ranging from 19 to 35 days at 12 degrees C. In most cases, the time to reach 100-fold the initial Listeria population of L. monocytogenes was significantly longer in vacuum-packaged frankfurters as compared with air-packaged samples. Inclusion of PL and SD also inhibited the growth of psychrotrophs, but at all temperatures the psychrotrophic plate counts were greater than 4 log CFU/cm2 at the end of the experiments. These results indicated that despite the use of antimicrobials, certain L. monocytogenes strains could be capable of growing under storage-abuse conditions. Growth kinetics data could be useful for establishing a shelf life date label protocol under different handling scenarios.     

Effects of natural antimicrobials on inhibition of Listeria monocytogenes and on chemical, physical and sensory attributes of naturally-cured frankfurters

Due to regulations for natural and organic processed meats, sodium nitrite and many antimicrobials cannot be used. Therefore, natural and organic processed meats are more susceptible to pathogenic bacterial growth, and natural alternatives to chemical preservatives are needed. Inhibition of Listeria monocytogenes, and quality characteristics of frankfurters manufactured with 3% cranberry powder, or with 1% or 2% cranberry powder each with either cherry powder (0.6%), lime powder (60 mg/kg), or a blend of cherry, lime and vinegar (1.4%) were investigated. Cranberry powder at 3% significantly reduced L. monocytogenes growth by 5.3 log CFU/g compared to the uncured co006Etrol (P < 0.05). However, cranberry addition over 1% also resulted in significant product pH decline and negatively impacted the color, texture and sensory attributes of the frankfurters.     

Inhibition of Listeria monocytogenes by Nisin Combined with Grape Seed Extract or Green Tea Extract in Soy Protein Film Coated on Turkey Frankfurters

The objective of this study was to evaluate the inhibitory effect of grape seed extract (GSE), green tea extract (GTE), nisin and their combinations (nisin with either GSE or GTE) against Listeria monocytogenes. The inhibitory effect of these natural compounds was evaluated in phosphate buffer solution (PBS) medium containing approximately 10⁹ colony‐forming units (CFU/mL) of L. monocytogenes. The effectiveness of these compounds in a meat model system was evaluated by surface inoculation (approximately 10⁶ CFU/g) of L. monocytogenes onto turkey frankfurters. The inoculated frankfurters were dipped into soy protein film‐forming solutions with and without the addition of antimicrobial agents (GSE 1% or GTE 1% or nisin 10000 IU or combinations). Samples were stored at either 4 °C or 10 °C. The inhibitory effects of edible coatings were evaluated on a weekly basis for 28 d. The greatest inhibitory effect was observed in the PBS medium containing GSE (1%) and nisin (10000 IU/mL), which caused a 9‐log cycle reduction of L. monocytogenes population after 3 h incubation at 37 °C. In the meat system, the L. monocytogenes population (7.1 CFU/g) was decreased by more than 2 log cycle after 28 d at 4 °C and 10 °C, in the samples containing nisin (10000 IU) combined with either GSE (1%) or GTE (1%). This research has demonstrated that the use of an edible film coating containing both nisin and natural extracts is a promising means of controlling the growth and recontamination of L. monocytogenes on ready‐to‐eat meat products.     

Shelf Life Determination of Sliced Portuguese Traditional Blood Sausage—Morcela de Arroz de Monchique through Microbiological Challenge and Consumer Test

Morcela de Arroz (MA) is a ready‐to‐eat blood and rice cooked sausage produced with pork, blood, rice, and seasonings, stuffed in natural casing and cooked above 90 °C/30 min. It is commercialized whole, not packed, with a restricted shelf life (1 wk/0 to 5 °C). The objective of this work was to establish sliced MA shelf life considering both the behavior of L. monocytogenes through a microbiological challenge test (MCT) and the consumer acceptability of MA stored: vacuum packed (VP), modified atmosphere packed (MAP: 80% CO₂/20% N₂), and aerobic packed (AP). The MCT was conducted inoculating ±3 log CFU/g of L. monocytogenes cell suspension on the MA slices. Packaged samples were stored at 3 ± 1 °C and 7 ± 1 °C until 20 d. At 3 ± 1 °C, L. monocytogenes behavior was not affected by packaging or storage time. At 7 ± 1 °C, the pathogen increased nearly 1 log CFU/g in the first 4 d. L. monocytogenes populations in AP were higher (P < 0.05) than in MAP. The pathogen may grow to hazardous levels in the 1st days if a temperature abuse occurs. Considering the acceptability by the consumers, the shelf life of MA stored at 3 ± 1 °C was 4.4 d for AP, 8.1 d for VP, and 10.4 d for MAP. The sensory shelf life established based on sensory spoilage is shorter than the shelf life to maintain the population of L. monocytogenes in safe levels.     

Control of Listeriamonocytogenes on commercially-produced frankfurters prepared with and without potassium lactate and sodium diacetate and surface treated with lauric arginate using the Sprayed Lethality in Container (SLIC®) delivery method

Viability of Listeriamonocytogenes was monitored on frankfurters formulated with or without potassium lactate and sodium diacetate at a ratio of ca. 7:1 and treated with lauric arginate (LAE; 22 or 44 ppm) using the Sprayed Lethality in Container (SLIC®) delivery method. Without antimicrobials, pathogen numbers remained relatively constant at ca. 3.3 log CFU/package for ca. 30 d, but then increased to ca. 8.4 log CFU/package over 120 d. Regardless of whether or not lactate and diacetate were included, when treated with LAE, pathogen numbers decreased from ca. 3.3 log CFU/package to ca. 1.5 log CFU/package within 2 h, but then increased to 7.3 and 6.7 log CFU/package, respectively, after 120 d. When frankfurters were formulated with lactate and diacetate and treated with LAE, pathogen numbers decreased by ca. 2.0 log CFU/package within 2 h and remained relatively unchanged over the 120 d. These data confirm that LAE provides an initial lethality towards L. monocytogenes and when used in combination with reduced levels/ratio of lactate and diacetate as an ingredient for frankfurters provides inhibition throughout shelf life.     

Synergistic antimicrobial effect of lactocin AL705 and nisin combined with organic acid salts against Listeria innocua 7 in broth and a hard cheese

The effectiveness of antimicrobial mixtures against Listeria innocua 7, used as a L. monocytogenes surrogate, was investigated in broth and a food system. Synergistic effects were found for nisin (Nis), potassium sorbate (PS), calcium propionate (CP) and sodium lactate (SL), Nis + PS being the most effective binary mixture that exhibited listericidal activity in broth. To assess the effect of adding lactocin AL705 (AL705) to Nis + organic acid salt combinations, tridimensional isobolograms were generated. Sub-MIC combinations of the antimicrobials exerted bactericidal activity against L. innocua 7 after AL705 addition to the binary mixtures. However, when applied on Sardo cheese contaminated with L. innocua 7 (initial inoculum 4.45 ± 0.06 CFU g⁻¹), only Nis + PS + AL705 produced count reductions respect to the control, reaching 3.04 ± 0.35 CFU g⁻¹ counts after 15 days at 15 °C. Ternary combinations containing AL705 showed potential to reduce antimicrobial usages for L. innocua 7 inhibition.     

Combined Effect of Thermosonication and Slightly Acidic Electrolyzed Water to Reduce Foodborne Pathogens and Spoilage Microorganisms on Fresh‐cut Kale

This study evaluated the efficacy of individual treatments (thermosonication [TS+DW] and slightly acidic electrolyzed water [SAcEW]) and their combination on reducing Escherichia coli O157:H7, Listeria monocytogenes, and spoilage microorganisms (total bacterial counts [TBC], Enterobacteriaceae, Pseudomonas spp., and yeast and mold counts [YMC]) on fresh‐cut kale. For comparison, the antimicrobial efficacies of sodium chlorite (SC; 100 mg/L) and sodium hypochlorite (SH; 100 mg/L) were also evaluated. Each 10 g sample of kale leaves was inoculated to contain approximately 6 log CFU/g of E. coli O157:H7 or L. monocytogenes. Each inoculated or uninoculated samples was then dip treated with deionized water (DW; control), TS+DW, and SAcEW at various treatment conditions (temperature, physicochemical properties, and time) to assess the efficacy of each individual treatment. The efficacy of TS+DW or SAcEW was enhanced at 40 °C for 3 min, with an acoustic energy density of 400 W/L for TS+DW and available chlorine concentration of 5 mg/L for SAcEW. At 40 °C for 3 min, combined treatment of thermosonication 400 W/L and SAcEW 5 mg/L (TS+SAcEW) was more effective in reducing microorganisms compared to the individual treatments (SAcEW, SC, SH, and TS+DW) and combined treatments (TS+SC and TS+SH), which significantly (P < 0.05) reduced E. coli O157:H7, L. monocytogenes, TBC, Enterobacteriaceae, Pseudomonas spp., and YMC by 3.32, 3.11, 3.97, 3.66, 3.62, and >3.24 log CFU/g, respectively. The results suggest that the combined treatment of TS+SAcEW has the potential as a decontamination process in fresh‐cut industry.     

Control of Listeria monocytogenes on turkey frankfurters by generally-recognized-as-safe preservatives

Generally-recognized-as-safe chemicals applied to the surfaces of turkey frankfurters were evaluated for their ability to reduce populations of or inhibit the growth of Listeria monocytogenes. Frankfurters were treated prior to inoculation by dipping for 1 min in a solution of one of four preservatives (sodium benzoate, sodium propionate, potassium sorbate, and sodium diacetate) at three different concentrations (15, 20, and 25% [wt/vol]), with < 0.3% of the preservative being present for each frankfurter. Subsequently, 0.1 ml of a five-strain mixture of L. monocytogenes (10(6) CFU/ml) was used to surface inoculate each frankfurter separately in a sterile stomacher bag. Inoculated frankfurter bags were held at 4, 13, and 22 degrees C, and L. monocytogenes cells were enumerated at 0, 3, 7, 10, and 14 days of storage. The results of this study revealed that at all three concentrations of all four preservatives, the initial populations of L. monocytogenes decreased immediately by 1 to 2 log10 CFU/g. After 14 days of storage at 4 degrees C, L. monocytogenes counts for all treated frankfurters were 3 to 4 log10 CFU/g less than those for the untreated frankfurters. After 14 days of storage at 13 degrees C, L. monocytogenes counts for frankfurters treated with 25% sodium benzoate or 25% sodium diacetate were 3.5 to 4.5 log10 CFU/g less than those for untreated frankfurters, and those for frankfurters treated with 25% sodium propionate or 25% potassium sorbate were 2.5 log10 CFU/g less than those for untreated frankfurters. In all instances, the degree of growth inhibition was directly proportional to the concentration of the preservative. Only frankfurters treated with 25% sodium diacetate or sodium benzoate were significantly inhibitory to L. monocytogenes when held at 22 degrees C for 7 days or longer. Interestingly, the untreated frankfurters held at 22 degrees C were spoiled within 7 days, with copious slime formation, whereas there was no evidence of slime on any treated frankfurters after 14 days of storage.     

Effects of potential antimicrobial ingredients used to control Listeriamonocytogenes on quality of natural casing frankfurters

Listeriosis concerns have led to increased antimicrobial use; reformulation may affect quality. The objective was to determine the effects of potential antimicrobials on quality of natural casing frankfurters. Eleven treatments were used: no antimicrobials (control); 3.0% sodium lactate and sodium diacetate blend (SL+SD); 1.0%, 2.5%, and 3.5% buffered sodium citrate (SC); 1.0%, 2.5%, and 3.5% buffered sodium citrate and sodium diacetate blend (SC+SD); and 1.0%, 2.5%, and 5.0% whey protein peptides (WP). Trained and consumer panelists analyzed sensory characteristics. Cooking yield was unaffected by treatment (P>0.05). Addition of SC and SC+SD decreased pH (P<0.05). Texture profile analysis was conducted. Hunter color values and growth of aerobic bacteria and lactic acid bacteria were monitored over 15 weeks of storage. No samples reached spoilage. SL+SD 3% caused few changes; WP caused changes perceived as negative; and SC and SC+SD caused changes often perceived as positive.