共查询到20条相似文献,搜索用时 93 毫秒
1.
按生产工艺的需要选择合适的疏水阀才能充分发挥设备的能力、节约能源和提高热效率。本文从疏水阀的过冷度、背压度、漏气率及使用寿命等项工作性能的角度探讨了各种类型的疏水阀所适用的工艺要求,从而介绍了自由浮球式疏水阀优良性能。 相似文献
2.
3.
4.
<正> 蒸汽疏水阀是蒸汽系统中不可缺少的主要部件之一,其性能的优劣对系统的正常运行,设备热效率的提高和能源的有效利用等都具有重要的作用。 疏水阀的种类很多,目前比较先进的是日本“TLV”公司发明的“UFO”即自由浮球式蒸汽疏水阀。 相似文献
5.
6.
7.
8.
在石墨阳极电解槽上采用液位自控,国内曾有过报道。其原理是通过浮球来控制进槽盐水流量。当电槽液位升高或降低,浮球自动升降,从而调节入槽盐水量,达到电解槽液位升高或降低到所要求的高度,使电槽液位稳定,从而保证电槽的水位合格率和电解液浓度。在电流升降频繁的地方是比较适宜的.同时也降低了 相似文献
9.
10.
11.
阐述了抚顺石化分公司石油一厂新区 2 0 0 1年新建成的凝结水回收精处理装置的自动控制系统结构、功能、技术特点。介绍了其作为国内第一套炼化凝结水回收装置自控系统所具有的可靠性和稳定性。通过实施该项目 ,回收处理后的凝结水不仅满足锅炉补水的要求 (可作为高品质的除盐水直接使用 ) ,同时还回收了凝结水中蕴涵的大量热能 ,并可显著降低蒸汽消耗 ,凝结水最大处理能力为 5 0万t a。经标定 ,全年可回收利用蒸汽凝结水 2 0万t,创效 1 90万元 相似文献
12.
13.
针对水处理改扩建中一级水阳离子浮动床出现的出水质量差、运行周期短等问题 ,对其进行改造 ,通过改变床体类型 ,并采用固定床逆流再生工艺 ,以实现树脂完全充分地再生 ,从而保证了装置的正常供水 ,降低了酸的消耗 ,节约了生产费用。 相似文献
14.
汽提塔的浮阀与燃料气预热器管束发生电化学反应,导致换热器内漏,初期少量冷凝液进入换热器管侧,汽化后与燃料气进入一段炉,造成烧嘴燃烧不好,一段炉燃料气用量增加;当内漏量增加时,堵塞管侧,在调节阀处憋压,造成一段炉停车。 相似文献
15.
在水流量标准装置上刻度气体浮子流量计后,分别在水流量标准装置和气体流量标准装置上研究了其测量误差。实验研究发现,在水装置上检定的气体浮子流量计测量空气流量时测量值大于真实值,其原因为:检定介质的动力粘度大于被测介质的动力粘度。故为了保证浮子流量计的精度等级,在水装置上检定气体浮子流量计时,必须考虑流体粘度的影响,在刻度换算公式中引入粘性系数k。 相似文献
16.
17.
Scott Bloomer Patrick Adlercreutz Bo Mattiasson 《Journal of the American Oil Chemists' Society》1992,69(10):966-973
Scaling up of Lipozyme-catalyzed ester synthesis with >99% conversion and a reflux trap to remove product water from the reaction
mixture is reported. Ethyl stearate was synthesized in 2000-g batch reactions from technical stearic acid. The ethyl stearate
was purified to 97% by crystallization and interesterified with sunflower seed oil by means of a lipase catalyst to investigate
reaction parameters of temperature, substrate ratio, enzyme content and catalyst water activity. The endpoint of the reaction
was defined as the incorporation of stearate into sunflower seed oil corresponding to the amount of stearate necessary to
be incorporated into palm oil mid-fraction to produce a cocoa butter substitute. No tristearate was formed at the reaction
endpoint in any of the reactions conducted. Reaction times decreased and levels of free fatty acids and diglycerides increased
with increasing temperature and with increasing ratio of acyl donor to triglyceride. Increasing the enzyme content of the
reaction mixture reduced reaction times but caused higher levels of free fatty acids and diglycerides. In reactions catalyzed
by Lipozyme of defined water activity, the shortest reaction times were obtained at intermediate water activity, while free
fatty acid and diglyceride levels increased with water activity. When the interesterification reaction was carried out in
refluxing pentane with the condensed solvent dried by passage through a reflux trap, the free fatty acid and diglyceride levels
were reduced to 6 and 3.3%, respectively. 相似文献
18.
19.
20.
针对热力厂及宾馆、饭店蒸汽锅炉产生的冷凝回水中由于二氧化碳的腐蚀引起回水“发红”不能回用的问题,采用在蒸汽中加入中和胺,提高pH值的方法,可以有效的提高回水回收率,经济效益显著。 相似文献