不同冻藏条件对鸡胸肉品质特性的影响

为研究不同冻藏条件对鸡胸肉品质特性的影响,本实验以新鲜鸡胸肉为原料,于-16、-26和-36 ℃分别冻藏1、2、3、4、5、6个月,分析比较不同冻藏温度和时间对鸡胸肉的系水力、色泽、蛋白质变性程度、嫩度、脂肪酸败及新鲜度的影响情况。结果表明,随着冻藏温度的升高及冻藏时间的延长,pH呈现先降低后升高的趋势,鸡胸肉的解冻损失率、蒸煮损失率、剪切力以及b*值也逐渐增加,L*值、总蛋白及肌原纤维蛋白溶解度显著降低(p<0.05),但对肌浆蛋白的溶解度无显著影响(p<0.05);a*值则在冻藏前1个月显著增加(p<0.05),但随后逐渐降低,且随着冻藏温度升高而减小(p<0.05)。衡量系水力指标的解冻损失和蒸煮损失结果,衡量色差的L*、a*和b*值以及衡量蛋白变性指标的三大蛋白溶解度和TBARS值与TVB-N值均表明,鸡胸肉在冻藏温度为-36~-26 ℃及冻藏时间为5个月内能有效维持较好的鸡胸肉食用品质。此外,各指标间的相关性分析表明,不同冻藏条件下解冻损失率、蒸煮损失率、剪切力、TVB-N值、TBARS值、a*值、b*值、蛋白溶解度与新鲜鸡胸肉呈现显著的差异(p<0.05),而pH、L*值与新鲜鸡胸肉差异不明显(p>0.05)。本文为快速发展的冷冻禽肉的加工及贮藏环境提供了理论依据。     

Validation of a Combi Oven Cooking Method for Preparation of Chicken Breast Meat for Quality Assessment

ABSTRACT: Quality assessment results of cooked meat can be significantly affected by sample preparation with different cooking techniques. A combi oven is a relatively new cooking technique in the U.S. market. However, there was a lack of published data about its effect on quality measurements of chicken meat. Broiler breast fillets deboned at 24‐h postmortem were cooked with one of the 3 methods to the core temperature of 80 °C. Cooking methods were evaluated based on cooking operation requirements, sensory profiles, Warner–Bratzler (WB) shear and cooking loss. Our results show that the average cooking time for the combi oven was 17 min compared with 31 min for the commercial oven method and 16 min for the hot water method. The combi oven did not result in a significant difference in the WB shear force values, although the cooking loss of the combi oven samples was significantly lower than the commercial oven and hot water samples. Sensory profiles of the combi oven samples did not significantly differ from those of the commercial oven and hot water samples. These results demonstrate that combi oven cooking did not significantly affect sensory profiles and WB shear force measurements of chicken breast muscle compared to the other 2 cooking methods. The combi oven method appears to be an acceptable alternative for preparing chicken breast fillets in a quality assessment.     

高强度超声对鹅胸肉嫩度及品质的影响

为了解超声技术对鹅胸肉品质的影响,采用高强度超声（超声功率800 W,超声总时间42 min,工作时间 2 s、停歇时间3 s）对鹅胸肉进行处理。测定未超声和超声处理的鹅胸肉于4 ℃下放置不同时间（0、6、12、24、 36、48 h）的pH值、肌原纤维小片化指数、蒸煮损失率、剪切力、表面微观结构、肌原纤维蛋白降解情况、肉品 的热力学性质等指标。结果显示：与未经超声处理的鹅胸肉相比,超声处理后随着放置时间的延长,肉品pH值升 高,肌原纤维小片化指数显著增大,蒸煮损失率和剪切力显著减小（P＜0.05）;表面微观结构发生明显变化,肌 动蛋白和肌球蛋白热敏性增大,导致更多肌原纤维蛋白降解,游离肌动蛋白含量显著增加（P＜0.05）,从而显著 改善鹅胸肉的嫩度。因此,超声处理可破坏鹅胸肉肌原纤维的完整结构,缩短宰后肉品成熟所需时间,进一步提高 鹅胸肉的品质。     

禁食对僵直前后鸡肉加工特性的影响

三黄鸡分别禁食0、8、16h和24h,采用三管齐断法宰杀,于宰后僵直前(0h)、僵直阶段(3h)和僵直后(24h)分别制成鸡肉糜,测定新鲜肌肉的pH值,鸡肉肠的蒸煮损失、加压损失、剪切力值、肉色和质构等指标,观察不同禁食时间对僵直前后鸡肉糜制品品质的影响。结果表明：随着禁食时间延长,pH值先升高后降低(P＜0.05),蒸煮损失和加压损失都有增加的趋势,剪切力值有降低的趋势,未禁食组僵直前鸡肉肠的硬度、弹性、黏聚性、胶黏性和咀嚼性最高,禁食16h组僵直和僵直前的质构特性优于禁食8h和24h组。随着宰后时间延长,pH值显著降低,持水力显著下降,僵直后鸡肉肠的质构特性劣于僵直和僵直前鸡肉肠的质构特性。     

Injection of sodium chloride, sodium tripolyphosphate, and sodium lactate improves Warner-Bratzler shear and sensory characteristics of pre-cooked inside round roasts

Paired inside rounds (n=30 pairs) were removed from randomly selected USDA Select quality grade carcasses to examine the effects of injecting a solution of sodium lactate, sodium tripolyphosphate, and sodium chloride on Warner-Bratzler shear force, cooking loss, lipid oxidation, and sensory characteristics of pre-cooked beef. Injected treatments were more tender (P<0.05) than control products, as measured by Warner-Bratzler shear force and consumer sensory panel ratings. Injected treatments had lower (P<0.01) cooking and re-heating loss percentages when compared to control samples. Lipid oxidation in injected treated samples was significantly reduced as compared to control meat samples. Results of lipid oxidation also revealed that 14-day samples were less (P<0.01) than 0-day samples. Results of this experiment have shown that injection of this solution enhanced sensory panel characteristics, and decreased WBS values and cooking loss.     

Apoptosis during postmortem conditioning and its relationship to duck meat quality

The aim of this work was to examine the relationship of skeletal muscle apoptosis and postmortem development of meat quality. Colour, cooking loss, myofibril fragmentation index (MFI) and shear force of duck breast and thigh meat postmortem were measured, and changes of positive nuclei were assessed with Terminal deoxynucleotidyl transferase-mediated deoxyuridine triphosphophate nick end-labelling method (TUNEL). Correlation analysis revealed that apoptosis were positively correlated with colour (L^∗, a^∗ and b^∗), cooking loss and MFI (P < 0.05), while it is negatively correlated with shear force (P < 0.05). Our results indicate the growing level of duck skeletal muscle cell apoptosis was associated with the postmortem development of meat quality traits such as meat colour, water holding capacity and tenderness.     

Quality Characteristics of Broiler Chicken Meat on Salt at Different Temperatures

The aim of this investigation was to compare the quality characteristics and muscle structure of broiler chicken meat stored at different temperatures in the retail market in Oman. The meat quality characteristics of broiler breast meat were analysed. Ten samples were randomly selected from each group of fresh, frozen, and chilled chicken meat. Colour L?, a?, b?, pH, expressed juice, cooking loss, sarcomere length, W-B-shear force and muscle structure (using scanning electron microscopy) were determined. Fresh meat samples had significantly (P < 0.05) lower pH values and lightness L? than those of chilled and frozen samples. The chilled meat samples were significantly (P < 0.05) lighter and had lower shear force values than fresh and frozen samples. Frozen samples had significantly (P < 0.05) higher expressed juice and cooking loss values than either fresh or chilled samples. The pH values of fresh, chilled, and frozen breast samples were related to colour and expressed juice. Electron microscopy demonstrated that the changes in the physical properties of the chilled meat were related to breakdown of the muscle fiber bundles. The quality characteristics of broiler meat from different storage temperatures varied significantly.     

Influence of cooking conditions on cooking loss and tenderness of raw and marinated chicken breast meat

The influence of different cooking treatments on tenderness and cooking loss, as main quality characteristics of chicken breast meat, was investigated. Industrial skinless chicken breast meat samples were designated as raw and marinated and cooked in the oven by hot air and hot air-steam mixture at 130, 150 and 170 °C, for 4, 8 and 12 min. Cooking losses were evaluated by weight changes before and after cooking, and tenderness changes were determined on cooked samples by measuring shear force using instrumental texture analysis. Results showed that marination, followed by air-steam cooking is the best combination to obtain the most tender chicken breast slices. The time and temperature of cooking showed similar effects on cooking loss and tenderness: short cooking time (4 min) and temperatures of 130–150 °C resulted in lower cooking losses and best meat tenderness, in both not marinated and marinated meat. Statistically significant correlations between tenderness and cooking loss indicated that the cooking loss correlated better with cooking time than with cooking temperature. An opposite phenomenon was observed for meat tenderness.     

调理鸡肉制品的加工条件对鸡肉质地的影响

以鸡胸肉为原料,通过研究鸡肉的加工条件(切片厚度、食盐添加量、磷酸盐添加量以及腌制、滚揉和热处理三段时间)对鸡肉剪切力、韧性和蒸煮损失率的影响,筛选出最佳鸡肉质地的加工条件。在单因素试验基础上进行正交试验考察磷酸盐添加量、腌制时间、滚揉时间和热处理时间对鸡肉的协同作用。结果表明:鸡肉的最优加工条件为鸡肉片厚度8 mm、腌制液(啤酒)中食盐添加量0.1%、磷酸盐添加量0.1%、腌制处理时间60 min;滚揉中食盐添加量1.5%、滚揉时间15 min、热处理时间8 min。鸡肉剪切力、韧性和蒸煮损失率分别为2230.10g、10 503.88g·s和5.33%。     

响应面法优化微波联合蒸汽预处理黄羽肉鸡原料肉工艺

以黄羽肉鸡为对象,研究微波联合蒸汽保温预处理黄羽肉鸡原料的最优加工工艺。以微波加热时间、蒸汽保温时间和微波联合蒸汽处理循环次数为单因素影响因子,预处理黄羽肉鸡原料鸡胸肉的剪切力和蒸煮损失率为响应值,通过响应面优化试验确定黄羽肉鸡预处理最佳工艺参数。结果表明,黄羽肉鸡最佳预处理工艺为微波加热时间30 s、蒸汽保温时间55 s、微波结合蒸汽处理循环7 次,在此预处理条件下黄羽肉鸡胸肉的剪切力为18.31 N,蒸煮损失率为13.10%,与预测值接近。     

加热处理对北京油鸡和黄羽肉鸡质构以及蛋白特性的影响

北京油鸡和黄羽肉鸡加热过程中的蒸煮损失、pH、剪切力变化及肌肉蛋白降解对其特殊质构和风味的形成具有重要意义。本研究以北京油鸡和黄羽肉鸡不同加热阶段为研究对象,采用常规物化特性测定方法及SDS-PAGE电泳分析北京油鸡和黄羽肉鸡肌肉质构的变化及蛋白降解情况。结果表明:随着加热温度的升高,北京油鸡和黄羽肉鸡的蒸煮损失均有明显的增加,而两者的剪切力和pH值以及蛋白质的降解呈现不同的变化。     

优质鸡肉质性状相互关系的研究

本试验研究了优质鸡胸肌和腿肌肌肉性状间的相互关系,并对肉质性状进行了主成分分析。结果表明,肌肉IMF与pH1、pH2、肌纤维密度呈正相关,而与烹饪损失、肌肉剪切力、肌纤维直径呈负相关。肌肉pH与烹饪损失、剪切力、肌纤维直径呈负相关,而与肌纤维密度呈极显著正相关。滴水损失与烹饪损失、肌纤维密度呈负相关,而与剪切力、肌纤维直径呈正相关。肌肉烹饪损失、剪切力与肌纤维直径呈正相关,而与肌纤维密度呈显著负相关。另外,主成分分析表明,胸肌肉质性状可以用4个主成分因子进行表示,腿肌肉质性状可以用2个主成分因子进行表示。     

Tenderization of chicken and turkey breasts with electrically produced hydrodynamic shockwaves

Eighty early deboned (45 min, post mortem) postrigor chicken breasts were exposed (24 h post mortem) to two levels (number of pulse firing networks, PFN; 45% energy) of electrically produced hydrodynamic shockwaves (HSW). In addition, 21 turkey breasts (72 h post mortem) were HSW treated (two PFN, 72% energy). Samples were water cooked in bags (78°C internal). Two PFN's were required to decrease (P<0.05) chicken Warner-Bratzler shear (WBS) force by 22% from the control (4.67 kg). WBS force of the HSW treated turkey breast decreased (P<0.05) by 12% from the control (3.20 kg). Cooking loss was higher (P<0.05) in the turkey breast portions but not in the chicken breasts. The electrically produced shockwave process has the potential to provide chicken processors with the ability to early debone and produce tender breasts and to provide turkey processors with tenderness-enhanced fillets.     

冻融次数对牦牛肉胶原蛋白特性及品质的影响

为探究冻融次数对牦牛肉胶原蛋白特性和品质的影响。以牦牛肉为研究对象,分析不同冻融次数下牦牛肉剪切力、pH、解冻损失、蒸煮损失、色差、质构、胶原蛋白含量及溶解性、酶活性及微观结构的变化规律。结果表明,随着冻融次数的增加,牦牛肉剪切力下降了59.72%,牦牛肉胶原蛋白溶解性、β-半乳糖苷酶和β-半乳糖醛酶活力、解冻损失、蒸煮损失和b^*值显著上升(P<0.05),胶原蛋白含量、剪切力、pH、L^*值、a^*值以及质构显著下降(P<0.05)。相关性分析表明:剪切力与L^*值、a^*值、pH、胶原蛋白含量和溶解性、质构指标呈显著正相关(P<0.01),与解冻损失、蒸煮损失、b^*值、β-半乳糖苷酶活性和β-葡糖醛酸酶活性呈极显著负相关(P<0.001);pH与胶原蛋白特性呈极显著正相关(P<0.001);胶原蛋白特性与质构指标呈极显著正相关(P<0.001)。牦牛肉组织结构随冻融次数增加表现为破坏严重,肌纤维边界模糊。综上,冻融次数增加,...     

真空滚揉工艺优化对复合低钠替代盐调理牛肉的品质改善

为了满足复合低钠替代盐调理牛肉的工业化生产需求,该研究在单因素试验基础上,研究液料比、滚揉时间、真空度对腌制吸收率和蒸煮损失率的影响,通过中心组合（Box-Behnken）和响应面法确定调理牛肉真空滚揉的最佳工艺,并对静置腌制和滚揉腌制调理牛肉的质构特征、剪切力、水分分布、微观结构进行分析。结果所得最佳滚揉工艺参数：液料比32%、滚揉时间3.0 h、真空度0.06 MPa,在此条件下得到腌制吸收率24.65%,蒸煮损失率为26.39%。滚揉组调理牛肉的硬度、弹性、咀嚼性和剪切力均显著低于静腌组（P<0.05）,不易流动水和自由水弛豫时间显著低于静腌组（P<0.05）,并且自由水弛豫峰面积显著高于静腌组（P<0.05）。扫描电镜图显示,滚揉组的肌原纤维结构更加松散,并且有碎片化结构附着表面。结果表明,滚揉处理能够改善调理牛肉的质构特征,提高嫩度,提高保水性,微观上使肌原纤维产生碎片化结构。该研究为复合低钠替代盐调理牛肉的滚揉工艺提供技术支持,为营养型低钠调理肉制品工业化生产提供理论依据。     

不同冷却方式及涂膜种类对鸡肉品质的影响

研究不同冷却方式涂膜种类对鸡肉品质的影响。采用普通冷却、二阶段冷却、真空冷却3种不同冷却方式对海藻酸钠及壳聚糖涂膜鸡肉进行处理,然后对冷却肉的肉色、剪切力等指标进行测定。结果表明:鸡肉经过涂膜后再冷却处理,感官明显得到改善;二阶段冷却处理后鸡肉的剪切力值最低,涂膜处理可提高肉的嫩度;经涂膜处理后再进行冷却能显著降低鸡肉的冷却质量损失率、汁液损失率及蒸煮损失率;冷却及涂膜处理对鸡肉的pH值影响不显著(P0.05)。因此,涂膜处理能有效地防止鸡肉冷却过程中引起的干耗、色泽暗淡、pH值下降等问题,改善肉的品质,冷却方式中二阶段冷却最佳。     

Descriptive Sensory Analysis of Irradiated Frozen or Refrigerated Chicken

The effects of irradiation of refrigerated and frozen chicken on sensory properties were investigated on skinless boneless breasts (white) and leg quarters (dark). Irradiation did not affect appearance of moistness and glossiness of raw chicken (white or dark). Leg quarters irradiated while refrigerated were darker (p 0.05) than controls (nonirradiated chicken). Raw irradiated chicken had higher “fresh chickeny,” bloody, and sweet aromatic aroma intensities compared to nonirradiated samples. Cooked irradiated frozen dark meat had more chicken flavor, and cooked irradiated refrigerated dark meat was more tender than controls. No other sensory attributes of cooked chicken were affected. The state at which chicken had been irradiated (refrigerated or frozen) did not affect sensory properties.     

Quality and Nutritional Minerals in Chicken Breast Muscle Treated with Low and High Pulsed Electric Fields

The present research investigated the effects of pulsed electric fields (PEF), low PEF (LPEF, 2.5 kV, 200 Hz and 20 μs) and high PEF (HPEF, 10 kV, 200 Hz and 20 μs), on the quality of chicken breast at 1 and 4 days post-treatment and on the concentrations of minerals (phosphorus, iron, zinc and potassium) in raw and cooked samples. HPEF increased (P < 0.001) the temperature of the chicken breasts. The shear force of chicken breasts was not affected by treatment and post-treatment storage time and their interaction (P > 0.05). The concentrations of P, K, and Zn were decreased by cooking (P < 0.001) only. The concentration of Fe was not affected by treatment, storage time, or cooking. Both LPEF and HPEF treatments did not have negative effects on the quality of chicken breast, indicating that PEF processing of chicken breast does not have a negative impact on the quality.     

水煮中心温度对鸡胸肉食用品质的影响

以鸡胸肉为原料,研究水煮中心温度对鸡胸肉感官品质、蒸煮损失、剪切力、肉色等食用指标的影响,为鸡肉在加工时选择合适的煮制温度提供参考。结果表明:水煮中心温度为90℃时,鸡胸肉的感官品质最佳;在70～90℃时蒸煮损失显著增加,持水性下降速率较快;80℃是鸡胸肉剪切力值改变的关键温度点;70,90℃是鸡胸肉肉色改变的关键温度点。