HYGIENIZATION OF INDIAN CHICKEN MEAT BY IONIZING RADIATION

Both fresh and frozen chicken meat were evaluated for microbiological status by screening for total bacterial counts and for the presence of pathogens like Enterobacteria , Bacillus cereus, coagulase positive Staphylococci and Salmonella spp. Most of the samples exhibited heavy bacterial contamination (1.2 × 10⁵ - 2.6 × 10⁶/g), mainly with Staphylococcus spp. (1.5 × 10⁴ - 2.8 × 10⁵/g). All the chicken samples also showed the presence of Salmonellae (3 × 10¹ - 2.1 × 10²/g). Among the different serotypes observed in chickens . S. typhimurium was common in fresh as well as frozen chicken. Radicidation at 2 kGy at cryogenic conditions (−40°C) was efficient in eliminating the natural pathogenic contamination of the poultry . Salmonella spp. viz. S. seftenberg and S. typhimurium differed in radiation sensitivity, the D₁₀ values in phosphate buffer (pH 7.2) being 0.25 kGy and 0.12 kGy, respectively. Chicken homogenate (10%) offered approximately 2-fold protection to these cells. Chicken samples artificially inoculated with a heavy inoculum (10⁸ cells/g) of these 2 serotypes required higher gamma radiation doses of 4–5 kGy. The findings suggested that a dose of 2 kGy is adequate for normally contaminated chicken samples, but for the heavily contaminated chicken a dose of 4–5 kGy, depending upon the predominating Salmonella serotype present, is required .     

INFLUENCE OF MOISTURE CONTENT AND STORAGE TEMPERATURE ON THE PRODUCTION OF AFLATOXIN BY ASPERGILLUS FLAVUS EA-81 IN MAIZE AFTER EXPOSURE TO GAMMA RADIATION

The effect of gamma radiation on aflatoxin production by Aspergillus flavus EA-81 in maize with different initial moisture levels was determined over a 15-day period. The viability of A. flavus on maize decreased over time with increasing moisture contents and storage at 8C. After 45 days at 28C, levels of viable conidiospores of A. flavus increased from 4.5 × 10⁷ to about 3.0 × 10⁸ per gram of maize. Levels of aflatoxin B₁ produced by A. flavus were 10 μg kg^-1 in the maize stored at 8C after 45 days. Production of aflatoxin was highest at 40% moisture and 28C. Irradiation of 1.0 or 2.0 kGy greatly reduced the level of mold growth relative to unirradiated controls. A dose of 4.0 kGy eliminated all viable fungi. Aflatoxin B₁ production decreased with increased levels of irradiation and was negligible at 4.0 kGy. When maize was inoculated after irradiation and stored, the spore counts and aflatoxin levels were higher than in unirradiated and inoculated controls after 30 days. Apparently, the natural competitive microflora prevented growth and thus limited higher concentrations of aflatoxin in maize.     

CHANGES IN PARBOILED ROUGH RICE CAUSED BY IMPROPER DRYING AND MICROBIAL INFECTION

Molds and bacteria contaminate parboiled rough rice when it is improperly dried or while awaiting drying due to humid rainy weather. When IR 20 parboiled rough rice was not dried for 7 days due to humid weather molds increased to 2.45 × 10⁷ per gram from 6 × 10⁴ per gram and bacteria increased to 75.9 × 10⁶ per gram from 5.1 × 10⁶ per gram observed initially. The milled rice yield decreased to 60.1% from 72.2% and the head rice yield decreased to 55.0% from 98.8% due to infection. The resultant bran contained only 12.1% oil compared to 31.9% in normally dried and milted paddy with about 40.0% free fatty acids in oil. The infection induced breakdown changes increased the levels of sugars, amino acids and polyphenols in grains which might cause kernel discolouration in the associated heat development during infection.     

Aflatoxins in spices marketed in Portugal

Seventy-nine prepackaged samples of 12 different types of spice powders (five cardamom, five cayenne pepper, eight chilli, five cloves, seven cumin, five curry powder, five ginger, five mustard, 10 nutmeg, 12 paprika, five saffron and seven white pepper) were selected from supermarkets and ethnic shops in Lisbon (Portugal) for estimation of aflatoxins by immmunoaffinity column clean-up followed by HPLC. Aflatoxin B (AFB) was detected in 34 samples of prepackaged spices (43.0%). All of the cayenne pepper samples were contaminated with levels ranging from 2 to 32 µ g AFB / kg. Three nutmeg samples contained levels ranging from 1 to 5 µ g/kg, three samples had levels ranging from 6 to 20 µ g/kg, and there were two with 54 µ g/kg and 58 µ g/ kg. Paprika contained levels of aflatoxin B₁ ranging from 1 to 20 µ g/kg. Chilli, cumin, curry powder, saffron and white pepper samples had levels ranging from 1 to 5 µ g/kg. Aflatoxins were not detected in cardamom, cloves, ginger and mustard. None of the samples analysed contained aflatoxins B₂, G₁ and G₂.     

DECONTAMINATION OF SPICES BY IRRADIATION

The feasibility of inactivating microflora of foreign spices by means of gamma radiation, without causing significant organoleptic or chemical changes, was studied. Ground cinnamon, clove, coriander, nutmeg, white and black pepper were irradiated with doses of 7 and 10 kGy¹ of ⁶⁰Co.
Chemical analysis were performed so as to verify the Argentine Alimentary Codex specifications and the effect of radiation on those characteristics by which spices are appreciated, such as color and volatiles. No differences between control and irradiated samples could be found in any of these parameters.
Microbiological results showed that aerobic plate count was reduced by 2.5 to 4.0 log cycles with 7 kGy. At 10 kGy survivors could only be found in cinnamon (1.7 log cfu/g)².
Cinnamon and clove were sensorily evaluated. No differences due to irradiation were found.
So, it can be concluded that 10 kGy of gamma radiation suffice the purpose of this work. This good market condition was held at least during one year.     

Rapid dye reduction tests for the determination of microbiological quality of meat

Rapid dye reduction tests have been developed to determine the quality of meat. Three chemical indicators, resazurin and two tetrazolium compounds, were used to correlate the microbial numbers and reduction times in meat samples. Twenty-five surface samples from sheep carcasses were subjected to each reduction test. Total viable counts given were obtained at 37°C. Resazurin reduction time was 90–120 min when the bacterial counts ranged from 1.5×10⁶ to 7.7×10⁶/cm². Samples showing bacterial counts between 1.5×10⁶ and 6.0×10⁶/cm² reduced tetrazolium (NBT) in 360–390 min whereas samples containing bacterial counts of 2.1×10⁶/cm² took 420–450 min to reduce iodophenyl nitrophenyl tetrazolium (INT) dye. Regression equations relating the number of organisms per cm² and reduction time were applied to predict the microbiological quality of meat samples from reduction time data. Among the three dyes, resazurin gave the lowest reduction time.     

MICROBIOLOGICAL QUALITY OF THE DAIRY PRODUCT PEDHA AND ITS IMPROVEMENT USING GAMMA RADIATION

Eighteen pedha samples procured from A and B grade retail shops were examined for their overall microbiological quality and for the presence of foodborne pathogens viz. Staphylococcus aureus, Salmonella sp., Coliforms , Listeria monocytogenes, Yersinia enterocolitica and Bacillus cereus. The microbiological quality of pedha samples from B grade shops was very poor as compared to pedha from A grade shop as evidenced by the very high total bacterial counts (6 × 10⁷ cfu/g), high counts of S. aureus (as high as 7 × 10⁶ cfu/g) and presence of coliforms and Listeria and Yersinia sp. in 33% of the samples. All the samples from A grade shops were also positive for S. aureus though negative for coliforms , Yersinia, Salmonella, Listeria and B. cereus. Gamma irradiation of pedha at a dose of 3kGy at 0C reduced overall bacterial load by five log cycles and S. aureus and coliforms could be totally eliminated. However, 5 kGy dose was necessary to eliminate S. aureus if the initial number exceed 1 × 10⁵ cfu/g. Inoculated pack studies confirmed that 3 kGy dose was sufficient for the complete elimination of up to 1 × 10⁵ cfu/g of S. aureus. A dose of 3 kGy had minimal effect on the sensory quality of pedha and even pedha samples irradiated at 5 kGy dose were acceptable. Treatment with 3 kGy dose of gamma radiation totally eliminated S. aureus and coliforms in pedha, thereby ensuring their microbial safety.     

QUANTITATIVE STUDIES OF PROTEOLYTIC AND LIPOLYTIC BACTERIA IN FROZEN MINCED BEEF AND HAMBURGER

Sixty frozen samples (30 hamburger patties and 30 minced meat) purchased from different retail markets in Ismailia, Egypt were examined for incidence of proteolytic and lipolytic bacteria. Mean values of proteolytic psychrophiles in the examined samples of hamburger and minced meat were 2×10⁵ and 6×10⁴, respectively. Lipolytic psychrophiles in hamburger were 8×10⁵ and 3×10⁵ in minced meat. Proteolytic mesophiles in hamburger and minced meat were 6×10⁵ and 5×10⁴, respectively. Mean values of lipolytic mesophiles were 5×10⁴ for hamburger and 5×10³ for minced meat. Proteolytic thermophiles in hamburger and minced meat were 3×10³ and 10³, respectively. Both proteolytic and lipolytic activities were exhibited by various bacteria that were identified.     

RHEOLOGICAL AND CHEMICAL PROPERTIES OF MOZZARELLA CHEESE

Dynamic viscoelastic parameters and chemical properties of Mozzarella cheese produced using a "no-brine" cheese making method with 3 different cooking temperatures (38, 41, and 44C) were determined. Samples were stored for 3 weeks at 4C before dynamic mechanical analysis at 22C. G', G" and tan δ were 5.8 – 6.4 × 10⁵ dyne/cm², 1.9 – 2.1 × 10⁵ dyne/cm², and 0.33 – 0.35, respectively, at 1% strain and 10 rad/s. The percentage of intact α_s-casein and β-casein were 38–40% and 33–35% of total protein in the cheese, respectively. The range of cooking temperatures used in this experiment had little effect on dynamic viscoelastic properties or the amount of intact protein for the cheese.     

MICROBIOLOGICAL STATUS OF EGYPTIAN SALTED MEAT (BASTERMA) AND FRESH SAUSAGE

The microbiological quality of 125 samples of the most popular Egyptian meat products (75 Egyptian fresh sausage "EPS" and 50 basterma) was determined. The aerobic plate count (APC) and Lactobacillaceae count of basterma ranged from 1 × 10⁴ to 9 × 10⁶ CFU/g, respectively . Enterobacteriaceae, mold and yeast counts for basterma were similar (<1 × 10² CFU/g). Artificially contaminated slices of meat and garlic paste of basterma showed that the paste inhibited growth of Salmonella typhimurium. APC and Enterobacteriaceae counts of EFS ranged from 1.1 × 10⁴ to 1 × 10⁸ and from 1 × 10² to 1 × 10⁷ CFU/g, respectively. Nearly 26% and 29% of EFS were positive for Clostridium perfringens and coagulase-positive Staphylococcus aureus, respectively . Salmonella could not be detected in any examined samples. Bacteriologically, EFS might pose a potential health hazard, making it imperative to institute sanitary measures during its production and sale .; Accepted for Publication July 2, 1997     

Ionizing Radiation Effects on Starch as Shown by Staudinger Index and Differential Thermal Analysis

SUMMARY— Corn starch in the form of raw granules at commercial moisture was irradiated at two levels: 3 × 10⁵ and 6 × 10⁶ rad from a Co⁶⁰ source. The irradiated samples were completely dissolved in alkali, indicating there was no cross linking induced in the starch molecules by irradiation. Viscosity determinations of starch solution diluted with distilled water exhibited the ion charge effect generally observed in other macromolecules.
The Staudinger indices of unirradiated, irradiated at 3 × 10⁶ rad and 6 × 10⁶ rad were 42, 22 and 16 respectively, which were an indication of depolymerization of starch macromolecules with increasing irradiation. The differential thermal analysis of the three samples also showed the depolymerization of the polymer with irradiation.
It is suggested that these two simple techniques–the Staudinger index and D.T.A.–could be usefully employed to characterize small differences in starches.     

INHIBITION OF STAPHYLOCOCCUS AUREUS AND BACILLUS CEREUS ON A VEGETARIAN FOOD TREATED WITH NISIN COMBINED WITH EITHER POTASSIUM SORBATE OR SODIUM BENZOATE

Various amounts of nisin (0, 10³ and 5 × 10³ IU/g) in combination with either potassium sorbate (0, 2, and 3%) or sodium benzoate (0, 0.06 and 0.12%) were tested for effectiveness in inhibiting growth of Staphylococcus aureus C10 and Bacillus cereus B7 inoculated on a vegetarian food. The strains used were isolated from vegetarian foods obtained commercially in Taiwan, and the test food, spice and dried bean curd, was selected for the study based on ability to support the growth of these organisms. After treatment with a preservative combination, the surfaces of sterilized food samples were inoculated, samples were stored in vacuum or nonvacuum packages at either 4C or 30C, and at appropriate times, tested for microbial growth. Growth of both isolates was unaffected by vacuum-packaging treatment; however, a bacteriostatic effect was found at 4C. Data indicated that during the 14-day storage at 4C, vacuum-packaged samples treated with 5 × 10³ IU/g nisin and 0.12% sodium benzoate significantly (p < 0.05) decreased the counts of S. aureus C10 and B. cereus B7 by 2.61 and 3.02 log₁₀ CFU/g, respectively. In the vacuum-packaged samples treated with 5 × 10³ IU/g nisin and 3% potassium sorbate, counts for C10 and B7 were decreased by 2.35 and 2.64 log₁₀ CFU/g, respectively. Thus, the combined treatment extended the shelf-life of the vegetarian food .     

MICROBIOLOGICAL QUALITY OF TRADITIONAL MARKET CURED FISH IN TANZANIA

The microbiological quality of six varieties of retail market traditionally cured fish in Morogoro, Tanzania was investigated over a five-month period. The fish were contaminated with bacteria and molds at levels of: total aerobes, 10⁶ - 1.7 × 10⁷ c.f.u/g; faecal coliforms, 1.1 × 10¹ - 2.5 × 10³ MPN/g; faecal streptococci, 1.4 × 10¹ - 1.3 × 10³ MPN/g; Staphylococcus aureus, 1.3 × 10³ - 8.6 × 10³ c.f.u/g; Aspergillus flavus group, 2.1 × 10¹ - 2 × 10² c.f.u/g of fish. Of faecal coliform, 45% of the isolates were Escherichia coli. Twenty-five percent of the S. aureus isolates were coagulase positive. Sixteen percent of A. flavus isolates were aflatoxigenic. Aflatoxin contamination ranged from O to 18.5 μg/kg of fish. Insect infestation by Dermestes spp. and mites was observed. The results of this preliminary study emphasize the importance of proper processing and handling offish in the tropics in order to safeguard public health .     

SHELF-LIFE OF FRESH FILLED PASTA. HAZARD ANALYSIS AND CRITICAL CONTROL POINTS OF THE MANUFACTURING PROCESS AND HOUSEHOLD PRACTICES

Hazard Analysis and Critical Control Point (HACCP) approach was used to assess the safety of a fresh filling pasta (ricotta-filled ravioli) manufacturing plant in La Plata region, Argentina. Household practices like cooking and holding meals before serving were also evaluated. Samples of ricotta, main raw material of the filling, showed colony counts of Enterobacteriaceae total microorganisms, molds and yeasts of (5 × 10³-1 × 10⁵), (1x10⁵−1x10⁸) and 1 × 10⁵ CFU/g, respectively. E. coli was also detected in one out of five samples, suggesting a hazardous condition of this raw material. Salmonella spp. was not isolated from any of the dough samples tested. Ricotta filling showed high colony counts of mesophilic microorganisms (6 × 10⁶ CFU/g), Enterobacteriaceae (1 × 10⁵ - 1 × 10⁶ CFU/g), while E. Coli was detected in 20% of the samples. Counts of B. cereus, S. aureus were less than 1 × 10² CFU/g in the analyzed materials. In the finished product (ricotta-filled ravioli), the colony counts of mesophilic microorganisms and Enterobacteriaceae were 3 × 10⁸ and 8 × 10⁵ CFU/g, respectively. Critical Control Points found were cooking and holding time before serving. The implementation of suggested corrections allowed the microbial quality of the final product (ricotta-filled ravioli) to be improved considerably. The growth of total microbial counts during refrigerated storage (0, 4, 8 and 10C) were measured and the shelf-life of ricotta and ricotta-filled ravioli was calculated.     

Effect of irradiation and modified atmosphere packaging on the microbiological safety of minced pork stored under temperature abuse conditions

The safety of irradiated pork packed in 25% CO₂:75% N₂ and stored at abuse temperature (10 or 15°C) was assessed by inoculation studies involving Salmonella typhimurium, Listeria monocytogenes, Escherichia coli, Yersinia enterocolitica and Clostridium perfringens . Irradiation to a dose of 1.75 kGy reduced pathogen numbers to below the detection limit of 10² cells g^-1. When higher inoculum levels were used (10⁶ cells g^-1) irradiation at 1.75 kGy reduced pathogen numbers by 1 –>5 log₁₀ cycles depending on strain. Clostridium perfringens was the most resistant, and Y. enterocolitica the most sensitive of the pathogens studied.
In all cases when high numbers (10⁶ to 10⁷g^-1) of spoilage and/or pathogenic bacteria were present initially on the pork the meat appeared spoiled, and although irradiation reduced the number of microorganisms, the meat was still unacceptable from a sensory viewpoint after treatment.
It was concluded that the microbiological safety of irradiated, modified atmosphere packaged (MAP) pork is better than that of unirradiated MAP pork.     

EXAMINATION OF THE MICROBIAL STATUS OF SELECTED INDIGENOUS FERMENTED FOODS IN NIGERIA

Four Nigerian traditionally fermented foods (wara, nono, ogi and kununzaki) were evaluated for the presence of some microorganisms of public health concern. Among the dairy foods , Staphylococcus aureus and Klebsiella sp. were isolated from wara while Escherichia coli, Salmonella sp. and Klebsiella sp. were isolated from nono. The cereal-based fermented foods (ogi and kunu-zaki) contained Bacillus subtilis, E. coli, S. aureus, Klebsiella sp. and Enterococcus faecalis. The mesophilic aerobic counts were: 5 × 10⁵ for wara; nono, 1.53 × 10⁷; ogi, 3.6 × 10⁶ and kunu-zaki, 2.6 × 10⁶ cfu/mL. The enterobacteriaceae counts on nono, wara, ogi and kunu-zaki were 1.79 × 10⁷, 4.5 × 10⁵, 4.0 × 10⁵ and 1.2 × 10⁶ cfu/mL, respectively. No Vibrio count (detection limit: <10 cfu/mL) was recorded in all the food samples considered. The yeast and mold counts ranged from 1.0 × 10⁵– 3.31 × 10⁷ among the food products. The antimicrobial susceptibility patterns of the organisms isolated from dairy products (nono and wara) revealed that they were resistant to ampicillin (100%) and sensitive to gentamicin (100%) and nalidixic acid (100%). Most isolates from cereal based products (ogi and kunu-zaki) were 100% resistant to penicillin, ampicillin and chloramphenicol. This work highlights the need to maintain hygienic standards in the preparation of our locally fermented cereal and dairy foods.     

A STUDY ON SURVIVAL OF Staphylococcus aureus IN DARK AND MILK CHOCOLATE

Dark and milk chocolate bars were inoculated with Staphylococcus aureus to establish an initial population of approximately 10², 10⁴ and 10⁶ cells per gram. Samples were stored at room temperature and examined for the survival of staphylococci at 2-day intervals for the first 6 days and every 8 days thereafter. When samples were inoculated with 10² cells per gram, absence of staphylococci was observed after 2-days in dark and 14 days of storage in milk chocolate. Bars with 10⁴ cells per gram were free of cells after 38 days in dark and 86 days of storage in milk chocolate. Dark chocolate bars with 106 cells per gram, were staphylococci free after 86 days of storage; whereas the milk chocolate bars with same level of inoculation were shown to be staphylococci free after 110 days of storage     

Microbiological quality of ice creams commercialized in some cities in the state of Rio de Janeiro, Brazil

The microbiological quality of 60 ice cream samples of three commercial brands (A, B and C) of various flavours, commercialized in some towns in the State of Rio de Janeiro, Brazil, was evaluated. Total bacteria count (TCB), coliforms at 35°C (CT), coliforms at 44°C (CF) and presence of Staphylococcus aureus were performed on all samples. TCB ranged from 2.0 × 10 ² to 6.9 × 10 ⁵ cfu/mL, CT from < 3–≥ 2400 MPN/mL, CF from < 3–1100 MPN/mL and S. aureus from < 10–1.4 × 10 ⁶ cfu/mL. The level of bacterial contamination found in this study reflects the unhygienic conditions prevalent in manufacturing and storage of ice creams. Actions are thus necessary by the Brazilian regulatory agencies to require the ice cream processing plants to adopt quality guarantee systems, such as good manufacturing practices and hazard analysis and critical control points system.     

Singlet Oxygen Oxidation Rates of ∝-, γ-, and δ-Tocopherols

ABSTRACT:  The reaction rate constants of 5 × 10⁻⁴ M, 10 × 10⁻⁴ M, and 20 × 10⁻⁴ M α-, γ-, and δ-tocopherols with singlet oxygen in methylene chloride containing 1 × 10⁻⁵ M chlorophyll under light at 25 °C for 60 min were studied. The oxidation of tocopherols determined by a spectrophotometric method showed that the losses of 20 × 10⁻⁴ M α-, γ-, and δ-tocopherols after 60 min under light were 21%, 16%, and 9%, respectively. The degradation of α-, γ-, and δ-tocopherols was undetectable in the absence of chlorophyll under light or in the presence of chlorophyll in dark. The losses of tocopherols under light were mainly due to singlet oxygen oxidation. The degradation rates of 20 × 10⁻⁴ M α-, γ-, and δ-tocopherols were 6.6 ×10⁻⁶ M/min, 5.0 × 10⁻⁶ M/min, and 2.9 × 10⁻⁶ M/min, respectively. The reaction rates between α-, γ-, or δ-tocopherol and singlet oxygen were 4.1 ×10⁶/M s, 3.3 × 10⁶/M s, and 1.4 × 10⁶/M s, respectively. The singlet oxygen oxidation rate of δ-tocopherol was significantly lower than α- or γ-tocopherol at α= 0.05. As the electron density in the chromanol ring of tocopherol increased, the singlet oxygen oxidation was increased.     

EFFECT OF SEVERAL EXPERIMENTAL PARAMETERS ON COMBINATION OF RED KIDNEY BEAN (PHASEOLUS VULGARIS) α-AMYLASE INHIBITOR WITH PORCINE PANCREATIC α-AMYLASE

Purified red kidney bean (Phaseolus vulgaris) amylase inhibitor forms a 1:1 stoichiometric complex with porcine pancreatic α-amylase leading to complete loss of enzyme activity on starch. Rate of complex formation is pH dependent and is maximal at pH 5. The rate constants for complex formation, as measured by loss of amylase activity, were 2.85 × 10⁴ M^-1 sec^-1 at pH 6.9 (ionic strength of 0.918) and 2.55 × 10⁵ M^-1 sec^-1 at pH 5 at 30°C. At pH 6.9, rate of complex formation was 4.8 times faster at 0.918 ionic strength as compared with the rate at 0.138 ionic strength. At 30°C, pH 6.9 and ionic strength of 0.168 the dissociation constant of the enzyme-inhibitor complex was determined to be 3.5 × 10^-11 M. The rate constant for dissociation of the complex was calculated to be 8.7 × 10^-8 sec^-1 under the same conditions. The rate constant for complex formation, at ionic strength of 0.168, was 1.1 × 10⁴ M^-1 sec^-1 at 37⁰ and 9.77 × 10² M^-1 sec^-1 at 25.7°C. The calculated activation energy for complex formation is 39.5 kcal/mole suggesting a rate-controlling conformational change. Oxidation of the carbohydrate moiety of the glycoprotein inhibitor caused complete loss of activity. Maltose, a competitive inhibitor of α-amylase, bound as readily to the enzyme-inhibitor complex as to free α-amylase. Trypsinized α-amylase, although still able to bind to Sephadex, did not bind inhibitor. The experiments with maltose and trypsinized amylase suggest the inhibitor may not bind at the active site of α-amylase.