Legal limit for reducing sugars in prefabricates targeting 50 μg/kg acrylamide in French fries

A legal limit for the reducing sugars in the prefabricates for French fries is a simple and efficient measure to reduce the exposure to acrylamide from the predominant source for many consumers. The acrylamide content of French fries of comparable crispiness is approximately proportional to the concentration of the reducing sugars glucose and fructose in the potato sticks. On average, optimally prepared French fries from prefabricates with a (moderately low) sugar content of 0.3 g/kg contained 32 g/kg acrylamide. With 0.15 g/kg reducing sugar even severe overfrying at 170 °C only resulted in 90 g/kg acrylamide, i.e. a low sugar content keeps acrylamide low even under inappropriate frying conditions. In the prefabricates, the sugar content is about 10% lower than in the raw potato (resulting from the effects of blanching and prefrying). It is similar to that in the finished French fries, which enables one to distinguish whether a high acrylamide content in French fries results from high sugars in the raw material or unsuitable frying conditions. An average concentration of 50 g/kg acrylamide in French fries could be targeted by limiting the reducing sugars in the prefabricates to 0.7 g/kg and the frying temperature to 170 °C. Even considerable overfrying in terms of duration can be tolerated then.     

Can umami taste be an adequate tool for reducing sodium in food preparations?

Researches indicate that the Brazilian population is still consuming sodium in excess and national epidemiological studies, have not verified the impact of taste modifications provided by the formulations available on the market and in homemade meals. The objective is to verify whether the basic umami taste, in the form of monosodium glutamate (MSG) monohydrate, is an alternative for reducing sodium in the preparation of meals. Also, to confirm the ideal concentration of MSG equivalent to acceptance with salt, and the impact of an explanatory video about warnings of salt excess on consumer behaviour, regarding the intention to use table salt in meals. For this study, three concentrations of sodium were used in the preparations rice and ground meat: one with the intrinsic sodium of the food, one with the addition of salt, 1 g for 100 g of rice and for meat, and one with salt and MSG, for 100 g of rice, 0.54% are of salt and 0.43% are of MSG and for 100 g of meat, 0.55% are of salt and 0.44% are of MSG. All quantities were suggested by a previous study, confirmed in a sensorial pre-test. The acceptability of preparations was assessed by the preference test. The levels of sodium and glutamic acid in the test preparations were also analysed. The results showed no significant difference between the exposed to the video. This study showed a sodium reduction of at least 30% in rice and 33% in ground meat, two kinds of meals widely consumed in Brazil, maintaining the same acceptance. These data suggest that the partial substitution of NaCl with MSG/umami can be an alternative to reduce sodium in meals.     

Quantification of trans fatty acid content in French fries of local food service retailers using attenuated total reflection – Fourier transform infrared spectroscopy

The contents of trans fatty acids in French fries served at the local food service retailers in Honolulu were determined by simple Fourier transform infrared (FTIR) spectroscopic technique without the pretreatment of fatty acid extraction. A horizontal attenuated total reflection (ATR) crystal made of zinc selenide (ZnSe) was used to obtain FTIR spectra of French fries with and without fatty acid extraction. Residual oil films obtained by pressing French fries directly on the ATR crystal surface without removal of any solid particles or air bubbles were scanned for the spectral measurement. The calibration set consisted of triolein (C18:1, 9-cis) and trielaidin (C18:1, 9-trans) mixed in varying ratios. All spectral data were averaged and converted into GRAMS format. The peak heights of each spectrum at 966 cm⁻¹ were found to be linearly correlated with the contents of trans fatty acids in the validation set (n = 8, R² = 0.9835). The developed calibration model was validated by comparing the results obtained from the ATR-FTIR with Mojonnier extraction and gas chromatography–mass spectrometry (GC–MS).