含十二烷基苯磺酸钠废水的多级泡沫分离研究

采用多级泡沫分离装置对水中十二烷基苯磺酸钠(SDBS)进行分离富集,考察了表面活性剂溶液的浓度、离子强度、pH值、分离时间、气体流速等因素对水中十二烷基苯磺酸钠脱除率的影响。进一步采用四因素三水平正交实验进行分离条件的优化,结果表明溶液浓度为20 mg/mL,气体流速为20L/min,pH=10,离子强度为2×10-5mol/L时,分离5 min,可使SDBS的脱除率最高达到97%,三次平行试验SDBS的脱除率分别为96.61%、97.04%和93.93%。与单级环流泡沫分离塔(其脱除率为82%)相比,多级泡沫分离装置具有能耗比低、分离效率高的优点,具有更好的推广应用价值。     

细菌菌液脱除H2S的工艺条件

通过Fe2(SO4)3对H2S的吸收实验,初步研究了氧化亚铁硫杆菌培养液脱除含H2S气体的工艺条件。利用单因素实验考察了不同气体流速、吸收液初始Fe3+浓度、初始pH值等条件下,吸收过程中脱硫效率的变化。实验结果表明气体流速为影响气液传质速率的主要因素,初始Fe3+浓度及初始pH值为对其影响不大。实验得到适宜的脱硫条件为：气体流速60 mL·min－1,初始[Fe3+]为10 g·L－1,初始pH值为2.0。在该条件下,氧化亚铁硫杆菌培养液脱除H2S的脱硫效率可以稳定在90％左右。     

碳酸钠溶液吸收处理硫化氢试验研究

研究了碳酸钠(Na2CO3)溶液吸收处理硫化氢(H2S)气体的效果。常温(20℃)常压下,当Na2CO3溶液质量浓度为10 g/L、H2S空间速度和初始质量浓度分别为5 L/(L.m in)和200 mg/m3时,可以得到以下结论:碳酸钠溶液吸收硫化氢的穿透时间是570 m in;在穿透时间570 m in内吸收效率维持在80%以上;吸收液pH值维持在9~12之间;吸收液pH=9.5时,吸收效率可以维持在80%以上。     

焚烧法处理高浓度有机废水

生产甲基多巴原料药产生高浓度有机废水,CODCr的质量浓度为1.5×105~2.8×105mg/L,pH值为2~12,氨氮的质量浓度大于4200mg/L,氯离子的质量浓度高于3000mg/L,采用FSL-WO-3OL无烟焚烧装置处理高浓度有机废水,能获得较好的处理效果,排放废气中烟尘为44.7mg/m3,二氧化硫为152mg/m3,氮氧化物为156mg/m3。运转成本低、安全性能高,无二次污染,排放符合国家排放标准(GB18484)。     

甲醇精脱硫新工艺及其催化剂

该文所讨论的精脱硫是指将工艺气的总硫（壬要为H2S，COSCS2）脱除至低于0.1×10-6。这个指标如果同小氮肥厂碳化工艺气中总硫（主要为H2S，COS）10×10－6的含量相比，其精脱硫的指标高100倍。     

甲醇精脱硫新工艺及其催化剂

该文所讨论的精脱硫是指将工艺气的总硫（主要为H2S，COS，CS2）脱除至低于0．1×10－6。这个指标如果同小氮肥厂碳化工之气中总硫（主要为H2S，COS）10×10－6的含量相比，其精脱硫的指标高100倍。     

UV/Fe3+/H2O2催化-混凝联合工艺处理络合铜镍废水

采用UV/Fe3+/H2O2催化-混凝联合工艺对难处理络合铜镍电镀废水进行了研究,考察了Fe3+和H2O2初始浓度、初始pH值、温度、反应时间及混凝液pH、混凝剂质量浓度对处理过程的影响,探讨了废水的降解途径和机理.结果表明在体系初始pH=3,温度50℃,H2O2和Fe3+初始浓度分别为1.5×10-4mo1/L、2.5×10-5mo1/L,反应时间60min,混凝液pH=8及混凝剂质量浓度为500mg/L的条件下,废水的COD去除率为96.98%,Cu2+为99.91%,Ni2+为99.92%,处理水达到国家一级排放要求.同时依据GC/MS对X-GN降解最终产物的分析结果,推导出废水的基本降解机理和途径.     

Fe2+催化H2O2、S2O82-、S2O82--H2O2降解橙黄G

以偶氮染料橙黄G(OG)为目标污染物,研究Fe2+分别催化H2O2、S2O82-、H2O2-S2O82-降解0.1 mmol/LOG Fe2+/H2O2体系,[Fe2+]=1 mmol/L,pH=3,[H2O2]0=10 mmol/L,降解30 min OG脱色率为96%,随着pH值增大和[H2O2]0>10 mmol/L,OG脱色率减小,呈线性变化。Fe2+/S2O82-体系,随着S2O82-初始浓度增加OG脱色率增大,随着pH值增大OG脱色率减小,呈非线性变化。Fe2+/H2O2-S2O82-体系,pH=3,[H2O2]0=2 mmol/L,[S2O82-]0>10 mmol/L时OG脱色率持续增大。Fe2+/H2O2-S2O82-体系矿化率最高。利用乙醇和硝基苯作为分子探针,采用分子探针竞争实验鉴定该体系中产生的SO4.和OH.。     

胶束强化超滤脱除氯苯及其膜污染的研究

以十六烷基氯化吡啶 (CPC)作为表面活性剂 ,利用聚醚酰亚胺 (PEI)中空纤维超滤膜 ,对含氯苯废水进行了胶束强化超滤 (MEUF)研究 ,讨论了 CPC浓度对氯苯脱除的影响 ,以及料液流速、操作压力和操作时间对膜污染的影响。在 CPC浓度 (Cf)为 3 .1 g/L～ 1 8.6 g/L的范围内 ,氯苯浓度为 0 .45 g/L时 ,CPC的截留率可大于 95 % ,而氯苯的脱除率可达 98.0 %以上 ,渗透通量可达 1 .0× 1 0 -10 m3/m2·s·Pa。采用去离子水对膜清洗 1 h后 ,膜纯水通量恢复率可达 95 %。     

固定床无碱脱硫技术在液化气脱硫中的应用

由于原料油繁杂,厂里生产的民用液化气中有机硫含量较高。装置原采用醇胺溶剂脱除大部分H2S后再采用碱洗、水洗工艺,有机硫难脱除,液化气个别质量指标如铜片腐蚀不稳定,经常不合格;同时碱渣的处理也较困难。通过对原液化气脱硫工艺进行改进,采用液化气固定床无碱脱硫工艺及相关催化剂、脱硫剂,液化气中总硫含量由脱前的237.1mg/m^3降为脱后的104.4mg/m^3左右,主要是降低有机硫,总硫脱除率达到≥50%,液化气铜片腐蚀100%合格。     

Insect antifeedant properties of anthranoids from the genusVismia

Vismiones and ferruginins, representatives of a new class of lypophilic anthranoids from the genusVismia were found to inhibit feeding in larvae of species ofSpodoptera, Heliothis, and inLocusta migratoria.     

Direct observation of freeze-thaw instability of latex coatings via high pressure freezing and cryogenic SEM

Despite its industrial importance, the subject of freeze-thaw (F/T) stability of latex coatings has not been studied extensively. There is also a lack of fundamental understanding about the process and the mechanisms through which a coating becomes destabilized. High pressure (2100 bar) freezing fixes the state of water-suspended particles of polymer binder and inorganic pigments without the growth of ice crystals during freezing that produce artifacts in direct imaging scanning electron microscopy (SEM) of fracture surfaces of frozen coatings. We show that by incorporating copolymerizable functional monomers, it is possible to achieve F/T stability in polymer latexes and in low-VOC paints, as judged by the microstructures revealed by the cryogenic SEM technique. Particle coalescence as well as pigment segregation in F/T unstable systems are visualized. In order to achieve F/T stability in paints, latex particles must not flocculate and should provide protection to inorganic pigment and extender particles. Because of the unique capabilities of the cryogenic SEM, we are able to separate the effects of freezing and thawing, and study the influence of the rate of freezing and thawing on F/T stability. Destabilization can be caused by either freezing or thawing. A slow freezing process is more detrimental to F/T stability than a fast freezing process; the latter actually preserves suspension stability during freezing. Presented at the 82nd Annual Meeting of the Federation of Societies for Coatings Technology, October 27–29, 2004 in Chicago, IL. Tied for first place in The John A. Gordon Best Paper Competition.     

Ethanol and (−)-α-Pinene: Attractant Kairomones for Bark and Ambrosia Beetles in the Southeastern US

In 2002–2004, we examined the flight responses of 49 species of native and exotic bark and ambrosia beetles (Coleoptera: Scolytidae and Platypodidae) to traps baited with ethanol and/or (−)-α-pinene in the southeastern US. Eight field trials were conducted in mature pine stands in Alabama, Florida, Georgia, North Carolina, and South Carolina. Funnel traps baited with ethanol lures (release rate, about 0.6 g/day at 25–28°C) were attractive to ten species of ambrosia beetles (Ambrosiodmus tachygraphus, Anisandrus sayi, Dryoxylon onoharaensum, Monarthrum mali, Xyleborinus saxesenii, Xyleborus affinis, Xyleborus ferrugineus, Xylosandrus compactus, Xylosandrus crassiusculus, and Xylosandrus germanus) and two species of bark beetles (Cryptocarenus heveae and Hypothenemus sp.). Traps baited with (−)-α-pinene lures (release rate, 2–6 g/day at 25–28°C) were attractive to five bark beetle species (Dendroctonus terebrans, Hylastes porculus, Hylastes salebrosus, Hylastes tenuis, and Ips grandicollis) and one platypodid ambrosia beetle species (Myoplatypus flavicornis). Ethanol enhanced responses of some species (Xyleborus pubescens, H. porculus, H. salebrosus, H. tenuis, and Pityophthorus cariniceps) to traps baited with (−)-α-pinene in some locations. (−)-α-Pinene interrupted the response of some ambrosia beetle species to traps baited with ethanol, but only the response of D. onoharaensum was interrupted consistently at most locations. Of 23 species of ambrosia beetles captured in our field trials, nine were exotic and accounted for 70–97% of total catches of ambrosia beetles. Our results provide support for the continued use of separate traps baited with ethanol alone and ethanol with (−)-α-pinene to detect and monitor common bark and ambrosia beetles from the southeastern region of the US.     

Methyl 2,4,6-decatrienoates Attract Stink Bugs and Tachinid Parasitoids

Halyomorpha halys (Stål) (Pentatomidae), called the brown marmorated stink bug (BMSB), is a newly invasive species in the eastern USA that is rapidly spreading from the original point of establishment in Allentown, PA. In its native range, the BMSB is reportedly attracted to methyl (E,E,Z)-2,4,6-decatrienoate, the male-produced pheromone of another pentatomid common in eastern Asia, Plautia stali Scott. In North America, Thyanta spp. are the only pentatomids known to produce methyl 2,4,6-decatrienoate [the (E,Z,Z)-isomer] as part of their pheromones. Methyl 2,4,6-decatrienoates were field-tested in Maryland to monitor the spread of the BMSB and to explore the possibility that Thyanta spp. are an alternate host for parasitic tachinid flies that use stink bug pheromones as host-finding kairomones. Here we report the first captures of adult and nymph BMSBs in traps baited with methyl (E,E,Z)-2,4,6-decatrienoate in central Maryland and present data verifying that the tachinid, Euclytia flava (Townsend), exploits methyl (E,Z,Z)-2,4,6-decatrienoate as a kairomone. We also report the unexpected finding that various isomers of methyl 2,4,6-decatrienoate attract Acrosternum hilare (Say), although this bug apparently does not produce methyl decatrienoates. Other stink bugs and tachinids native to North America were also attracted to methyl 2,4,6-decatrienoates. These data indicate there are Heteroptera in North America in addition to Thyanta spp. that probably use methyl 2,4,6-decatrienoates as pheromones. The evidence that some pentatomids exploit the pheromones of other true bugs as kairomones to find food or to congregate as a passive defense against tachinid parasitism is discussed.     

2007～2008年世界塑料工业进展

收集了2007年7月～2008年6月世界塑料工业的相关资料,介绍了2007～2008年国外塑料工业的发展情况,提供了世界塑料产量、消费量及全球各类树脂的需求量及产能情况.按通用热塑性树脂(聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂)、工程塑料(尼龙、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚)、特种工程塑料(聚苯·硫醚、液晶聚合物、聚醚醚酮)、通用热固性树脂(酚醛、聚氨酯、不饱和聚酯树脂、环氧树脂)不同品种的顺序,对树脂的产量、消费量、供需状况及合成工艺、产品应用开发、树脂品种的延伸及应用的进一步扩展等技术作了详细介绍.     

2005～2006年国外塑料工业进展

收集了2005年7月～2006年6月国外塑料工业的相关资料,介绍了2005—2006年国外塑料工业的发展情况。提供了世界塑料产量、消费量及全球各类树脂生产量以及各国塑料制品的进出口情况。作为对比,介绍了中国塑料的生产情况。按通用热塑性树脂（聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂）、工程塑料（聚酰胺、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚）、通用热固性树脂（酚醛、聚氨酯、不饱和树脂、环氧树脂）、特种工程塑料（聚苯硫醚、液晶聚合物、聚醚醚酮）的品种顺序,对树脂的产量、消费量、供需状况及合成工艺、产品开发、树脂品种的延伸及应用的扩展作了详细的介绍。