无铝低燃速NEPE推进剂的燃烧性能

采用水下声发射法测定了无铝低燃速NEPE推进剂的燃速,研究了增塑剂种类、高氯酸铵(AP)与奥克托今(HMX)含量、AP粒度级配以及降速剂对无铝NEPE推进剂燃烧性能的影响。结果表明,通过选择合适的增塑剂、调整AP/HMX的相对含量、AP粒度级配以及采用有效的降速剂可使推进剂基础配方在3.5MPa下静态燃速达到4.0~5.5mm/s,2~5MPa下静态压强指数可降至0.30以下;NEPE推进剂燃烧时,NO2的生成速度越慢或NO2的含量越低,则推进剂的燃速越小,反之则越高。     

CL-20含量及其粒度级配对NEPE推进剂燃烧性能的影响

采用静态与水下声发射法测试了CL-20含量及其粒度级配对NEPE推进剂燃速与压强指数的影响;采用DSC与TG-IR联用研究了CL-20对NEPE推进剂热分解行为的影响。结果表明,随着CL-20质量分数由42%增至50%,推进剂燃速与压强指数上升,燃烧效率提高,表明CL-20氧化能力高于GAP/硝酸酯含能黏合剂体系;随着CL-20/HMX、CL-20/Al质量比增高,推进剂燃速上升,燃烧效率上升;CL-20对推进剂燃速和压强指数的贡献高于HMX;随着CL-20/AP质量比增高,CL-20/AP混合体系分解产物氧化能力降低,燃烧反应速率降低,燃速降低;CL-20粒度级配对NEPE推进剂燃烧行为影响显著,当CL-20的粒径(d50)在5~50μm时,随着细粒度CL-20含量增高,推进剂燃速与燃速压强指数下降;当体系中存在超细粒度CL-20(d50=500nm)时,推进剂燃速与燃速压强指数随着超细粒度CL-20含量的增加而有所增加,4种粒度CL-20对NEPE推进剂燃速的贡献顺序为:粗粒度>中粒度>超细粒度>细粒度。     

高能低燃速NEPE推进剂的研究

采用调节 NEPE推进剂的配方组分、添加降速剂等手段进行了一系列降低燃速的研究。研究结果表明 ,增大 AP粒径、降低 NG/DEGDN的比例、适当降低 AP含量、添加少量降速剂 ,可达到降低燃速的目的。通过对 NEPE推进剂配方组分的调节 ,在没有添加降速剂时 ,其 4.0 MPa下燃速可达到 4.7mm/ s,并且实测标准比冲可达到 2 2 39.3N·s/ kg。     

AP和铝粉对AP-CMDB推进剂燃烧性能的影响

通过测定推进剂不同压强下的燃速和压强指数,研究了高氯酸铵(AP)和铝粉的粒度及含量对AP-CMDB推进剂燃烧性能的影响.结果表明,减小AP粒度和增大铝粉粒度均能有效提高AP-CDMB推进剂的燃速,推进剂在10～20 MPa压强范围内的燃速压强指数随AP和铝粉粒度的减小而明显增大;铝粉的质量分数低于14%时,调节不同比例的AP和铝粉含量对AP-CMDB推进剂的燃烧性能影响不明显,铝粉的质量分数高于14%时,由于铝粉燃烧不完全导致推进剂的燃速降低.     

GAP高能低特征信号推进剂的燃烧性能调节

研究了硝胺种类、固体组分含量和粒度、增塑剂与GAP的增塑比及燃速催化剂对GAP高能低特征信号推进剂在11~19MPa下燃烧性能的影响。结果表明,当HMX取代推进剂样品中的RDX时,推进剂的燃速较高,压强指数从0.72降至0.63;在AP和HMX总质量分数为67.5%的条件下,随着AP质量分数由5%增至30%,推进剂燃速逐渐增大,压强指数由0.82降至0.45;减小AP粒度以及在配方中添加燃速催化剂或调节过渡金属化合物J1/J2的配比,可较大幅度地增加推进剂燃速和降低压强指数,其中,J1与J2总质量分数为3%,二者质量比为2∶1和1∶1时,推进剂的压强指数较小,分别为0.50和0.48;随着HMX粒度减小及增塑剂与GAP黏合剂的增塑比的降低,推进剂的燃速和压强指数降低。     

NEPE推进剂燃烧性能研究

NEPE高能固体推进剂因其优良的综合性能具有十分良好的应用前景。通过调整氧化剂含量、种类及含能增塑剂用量,对NEPE推进剂的燃烧速度和燃速压力指数进行了调节,燃速在9．3～11．6mm／s(7.0MPa)范围内可调，燃速压力指数由0．61降为0.54。     

含CL-20的NEPE固体推进剂的性能

用高能氧化剂六硝基六氮杂异伍兹烷(CL-20)部分代替NEPE推进剂基础配方中的RDX,研究了CL-20含量、粒度大小对NEPE推进剂能量性能、燃烧性能、力学性能的影响规律。结果表明,在低铝含量NEPE推进剂中加入CL-20后,比冲可提高约54N.s/kg;加入CL-20后,NEPE推进剂在各压力点下的燃速明显比含RDX的NEPE推进剂燃速高,但压力指数差别不大;随着CL-20粒度的增加,燃速呈现先增后降的趋势,在105~125μm时达到最大值,燃速压力指数则表现为先降后增的趋势,105~125μm时最低,最低值为0.423;随CL-20粒径的变化,NEPE推进剂的力学性能有大幅度的变化,粒径为125~154μm时,其综合力学性能最佳。     

高氯酸铵(AP)粒度对端羟基聚丁二烯(HTPB)推进剂燃烧特性的影响

本文研究了含铝粉的HTPB推进剂中AP粒度对推进剂燃烧速度和燃速压力指数的影响。结果表明:AP粒度越小,推进剂燃烧速度就越高、燃速压力指数亦随之增加,并给出了相应的经验公式。本文应用Summerfield粒状扩散火焰模型对AP粒度与HTPB推进剂燃烧特性的关系进行了讨论。     

高氯酸铵(AP)粒度对端羟基聚丁二烯(HTPB)推进剂燃烧特性的影响

本文研究了含铝粉的 HTPB 推进剂中 AP 粒度对推进剂燃烧速度和燃速压力指数的影响。结果表明:AP 粒度越小,推进剂燃烧速度就越高、燃速压力指数亦随之增加,并给出了相应的经验公式。本文应用 Summerfield 粒状扩散火焰模型对 AP 粒度与 HTPB 推进剂燃烧特性的关系进行了讨论。     

铜盐和碳黑对微烟NEPE推进剂燃烧性能的影响

通过测定不同压力下推进剂的燃烧性能及熄火表面元素分析,研究了两种铜盐（AD和BC）和3种碳黑对微烟NEPE推进剂燃烧性能的影响.结果表明,适量AD可改善推进剂的燃烧性能,使推进剂在3～20 MPa压力范围内的压强指数降至0.45以下;AD在12～18 MPa压力范围内比等量BC对微烟NEPE推进剂燃烧性能的催化作用弱,这可能与AD所含铜元素在燃面的富集程度小于BC有关.3种碳黑均能改变微烟NEPE推进剂在3～18 MPa压力范围内的燃速.增加乙炔碳黑含量可使推进剂在3～20 MPa压力范围内的燃速提高,压力指数降低.     

Insect antifeedant properties of anthranoids from the genusVismia

Vismiones and ferruginins, representatives of a new class of lypophilic anthranoids from the genusVismia were found to inhibit feeding in larvae of species ofSpodoptera, Heliothis, and inLocusta migratoria.     

Direct observation of freeze-thaw instability of latex coatings via high pressure freezing and cryogenic SEM

Despite its industrial importance, the subject of freeze-thaw (F/T) stability of latex coatings has not been studied extensively. There is also a lack of fundamental understanding about the process and the mechanisms through which a coating becomes destabilized. High pressure (2100 bar) freezing fixes the state of water-suspended particles of polymer binder and inorganic pigments without the growth of ice crystals during freezing that produce artifacts in direct imaging scanning electron microscopy (SEM) of fracture surfaces of frozen coatings. We show that by incorporating copolymerizable functional monomers, it is possible to achieve F/T stability in polymer latexes and in low-VOC paints, as judged by the microstructures revealed by the cryogenic SEM technique. Particle coalescence as well as pigment segregation in F/T unstable systems are visualized. In order to achieve F/T stability in paints, latex particles must not flocculate and should provide protection to inorganic pigment and extender particles. Because of the unique capabilities of the cryogenic SEM, we are able to separate the effects of freezing and thawing, and study the influence of the rate of freezing and thawing on F/T stability. Destabilization can be caused by either freezing or thawing. A slow freezing process is more detrimental to F/T stability than a fast freezing process; the latter actually preserves suspension stability during freezing. Presented at the 82nd Annual Meeting of the Federation of Societies for Coatings Technology, October 27–29, 2004 in Chicago, IL. Tied for first place in The John A. Gordon Best Paper Competition.     

Ethanol and (−)-α-Pinene: Attractant Kairomones for Bark and Ambrosia Beetles in the Southeastern US

In 2002–2004, we examined the flight responses of 49 species of native and exotic bark and ambrosia beetles (Coleoptera: Scolytidae and Platypodidae) to traps baited with ethanol and/or (−)-α-pinene in the southeastern US. Eight field trials were conducted in mature pine stands in Alabama, Florida, Georgia, North Carolina, and South Carolina. Funnel traps baited with ethanol lures (release rate, about 0.6 g/day at 25–28°C) were attractive to ten species of ambrosia beetles (Ambrosiodmus tachygraphus, Anisandrus sayi, Dryoxylon onoharaensum, Monarthrum mali, Xyleborinus saxesenii, Xyleborus affinis, Xyleborus ferrugineus, Xylosandrus compactus, Xylosandrus crassiusculus, and Xylosandrus germanus) and two species of bark beetles (Cryptocarenus heveae and Hypothenemus sp.). Traps baited with (−)-α-pinene lures (release rate, 2–6 g/day at 25–28°C) were attractive to five bark beetle species (Dendroctonus terebrans, Hylastes porculus, Hylastes salebrosus, Hylastes tenuis, and Ips grandicollis) and one platypodid ambrosia beetle species (Myoplatypus flavicornis). Ethanol enhanced responses of some species (Xyleborus pubescens, H. porculus, H. salebrosus, H. tenuis, and Pityophthorus cariniceps) to traps baited with (−)-α-pinene in some locations. (−)-α-Pinene interrupted the response of some ambrosia beetle species to traps baited with ethanol, but only the response of D. onoharaensum was interrupted consistently at most locations. Of 23 species of ambrosia beetles captured in our field trials, nine were exotic and accounted for 70–97% of total catches of ambrosia beetles. Our results provide support for the continued use of separate traps baited with ethanol alone and ethanol with (−)-α-pinene to detect and monitor common bark and ambrosia beetles from the southeastern region of the US.     

Methyl 2,4,6-decatrienoates Attract Stink Bugs and Tachinid Parasitoids

Halyomorpha halys (Stål) (Pentatomidae), called the brown marmorated stink bug (BMSB), is a newly invasive species in the eastern USA that is rapidly spreading from the original point of establishment in Allentown, PA. In its native range, the BMSB is reportedly attracted to methyl (E,E,Z)-2,4,6-decatrienoate, the male-produced pheromone of another pentatomid common in eastern Asia, Plautia stali Scott. In North America, Thyanta spp. are the only pentatomids known to produce methyl 2,4,6-decatrienoate [the (E,Z,Z)-isomer] as part of their pheromones. Methyl 2,4,6-decatrienoates were field-tested in Maryland to monitor the spread of the BMSB and to explore the possibility that Thyanta spp. are an alternate host for parasitic tachinid flies that use stink bug pheromones as host-finding kairomones. Here we report the first captures of adult and nymph BMSBs in traps baited with methyl (E,E,Z)-2,4,6-decatrienoate in central Maryland and present data verifying that the tachinid, Euclytia flava (Townsend), exploits methyl (E,Z,Z)-2,4,6-decatrienoate as a kairomone. We also report the unexpected finding that various isomers of methyl 2,4,6-decatrienoate attract Acrosternum hilare (Say), although this bug apparently does not produce methyl decatrienoates. Other stink bugs and tachinids native to North America were also attracted to methyl 2,4,6-decatrienoates. These data indicate there are Heteroptera in North America in addition to Thyanta spp. that probably use methyl 2,4,6-decatrienoates as pheromones. The evidence that some pentatomids exploit the pheromones of other true bugs as kairomones to find food or to congregate as a passive defense against tachinid parasitism is discussed.     

2007～2008年世界塑料工业进展

收集了2007年7月～2008年6月世界塑料工业的相关资料,介绍了2007～2008年国外塑料工业的发展情况,提供了世界塑料产量、消费量及全球各类树脂的需求量及产能情况.按通用热塑性树脂(聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂)、工程塑料(尼龙、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚)、特种工程塑料(聚苯·硫醚、液晶聚合物、聚醚醚酮)、通用热固性树脂(酚醛、聚氨酯、不饱和聚酯树脂、环氧树脂)不同品种的顺序,对树脂的产量、消费量、供需状况及合成工艺、产品应用开发、树脂品种的延伸及应用的进一步扩展等技术作了详细介绍.     

2005～2006年国外塑料工业进展

收集了2005年7月～2006年6月国外塑料工业的相关资料,介绍了2005—2006年国外塑料工业的发展情况。提供了世界塑料产量、消费量及全球各类树脂生产量以及各国塑料制品的进出口情况。作为对比,介绍了中国塑料的生产情况。按通用热塑性树脂（聚乙烯、聚丙烯、聚苯乙烯、聚氯乙烯、ABS树脂）、工程塑料（聚酰胺、聚碳酸酯、聚甲醛、热塑性聚酯、聚苯醚）、通用热固性树脂（酚醛、聚氨酯、不饱和树脂、环氧树脂）、特种工程塑料（聚苯硫醚、液晶聚合物、聚醚醚酮）的品种顺序,对树脂的产量、消费量、供需状况及合成工艺、产品开发、树脂品种的延伸及应用的扩展作了详细的介绍。