Changes in lipid fractions and sensory properties of Idiazabal cheese induced by lipase addition

This work studied the addition of an adequate lipase to enhance lipolysis reactions and the development of piquant flavour and sharp odour in Idiazabal cheese, as an alternative to the use of lamb rennet paste. Cheeses were manufactured from bulk raw ewes' milk in 50 l vats with commercial bovine rennet and 80 lipase units of pregastric or 180 lipase units of fungal lipase and ripened for 180 days. A higher lipolytic activity was induced by lipase addition promoting strong changes in odour and flavour attributes. Both fungal and pregastric lipases increased the content of total free fatty acids (FFA), but the fungal lipase released mainly medium- and long-chain FFA. In contrast, the pregastric lipase preferably released short-chain FFA. Diglyceride (DG) content was considerably higher in cheeses made with added pregastric lipase compared with those made with fungal lipase or with no lipase. Monoglycerides (MG) were detected only in cheeses made with either lipase added, reaching comparable concentrations after ripening for 180 days. The cheeses made with pregastric lipase had the highest scores for odour and flavour intensity, and sharp and rennet odours, desirable attributes for the Idiazabal cheese made with lamb rennet paste. None of the texture attributes were significantly influenced by the concentrations of MG and DG in the cheeses made with either lipase. Thus, the pregastric lipase was more appropriate than the fungal lipase to develop a more traditionally-flavoured Idiazabal cheese.     

Probiotic in lamb rennet paste enhances rennet lipolytic activity, and conjugated linoleic acid and linoleic acid content in Pecorino cheese

Cheeses manufactured using traditional lamb rennet paste, lamb rennet paste containing Lactobacillus acidophilus, and lamb rennet paste containing a mix of Bifidobacterium lactis and Bifidobacterium longum were characterized for the lipolytic pattern during ripening. Lipase activity of lamb rennet paste, lamb rennet containing Lb. acidophilus, and lamb rennet containing a mix of bifidobacteria was measured in sheep milk cream substrate. Rennet paste containing probiotics showed a lipase activity 2-fold greater than that displayed by traditional rennet. Total free fatty acid (FFA) in sheep milk cream was lower in lamb rennet paste (981 μg/g of milk cream) than in lamb rennet containing Lb. acidophilus (1,382.4 μg/g of milk cream) and in lamb rennet containing a mix of bifidobacteria (1,227.5 μg/g of milk cream) according to lipase activity of lamb rennet paste. The major increase of FFA in all cheeses occurred during the first 30 d of ripening with the greatest values being observed for C16:0, C18:0 C18:1. At 60 d of ripening all cheeses showed a reduction in the amount of free fatty acids; in particular, total free fatty acids underwent a decrease of more than 30% from 30 to 60 d in cheeses manufactured using traditional lamb rennet paste, whereas the same parameter decreased 10% in cheeses manufactured using lamb rennet paste containing Lb. acidophilus and cheeses manufactured using lamb rennet paste containing a mix of B. lactis and B. longum. Cheese containing Lb. acidophilus was characterized by the greatest levels of total conjugated linoleic acids (CLA) 9-cis, 11-trans CLA and 9-trans, 11-trans CLA, whereas cheese containing bifidobacteria displayed the greatest levels of free linoleic acid. Rennet pastes containing viable cells of Lb. acidophilus and a mix of B. lactis and B. longum were able to influence the amount of FFA and CLA in Pecorino cheese during ripening.     

The evolution of free fatty acids during the ripening of Idiazábal cheese: influence of rennet type

 The object of the present study was to determine the influence of the rennet type on the free fatty acid (FFA) content of Idiazábal cheese. Varying this parameter during cheese-making resulted in significant differences in FFA content in the cheeses during ripening. The main FFAs in both cheese batches were caproic acid (C6 : 0) and capric acid (C10 : 0). The differences between the extreme values for the lipolysis rate were around 45%, which emphasizes the importance of the cheese-making procedure employed on lipolysis in this type of cheese. The use of locally made rennet in the preparation of Idiazábal cheese increased the level of lipolysis in the cheese. Received: 4 December 1998 / Revised version: 18 March 1999     

Biochemical patterns in ovine cheese: Influence of probiotic strains

This study was undertaken to evaluate the effect of lamb rennet paste containing probiotic strains on proteolysis, lipolysis, and glycolysis of ovine cheese manufactured with starter cultures. Cheeses included control cheese made with rennet paste, cheese made with rennet paste containing Lactobacillus acidophilus culture (LA-5), and cheese made with rennet paste containing a mix of Bifidobacterium lactis (BB-12) and Bifidobacterium longum (BB-46). Cheeses were sampled at 1, 7, 15, and 30 d of ripening. Starter cultures coupled with probiotics strains contained in rennet paste affected the acidification and coagulation phases leading to the lowest pH in curd and cheese containing probiotics during ripening. As consequence, maturing cheese profiles were different among cheese treatments. Cheeses produced using rennet paste containing probiotics displayed higher percentages of α_S1-I-casein fraction than traditional cheese up to 15 d of ripening. This result could be an outcome of the greater hydrolysis of α-casein fraction, attributed to higher activity of the residual chymosin. Further evidence for this trend is available in chromatograms of water-soluble nitrogen fractions, which indicated a more complex profile in cheeses made using lamb paste containing probiotics versus traditional cheese. Differences can be observed for the peaks eluted in the highly hydrophobic zone being higher in cheeses containing probiotics. The proteolytic activity of probiotic bacteria led to increased accumulation of free amino acids. Their concentrations in cheese made with rennet paste containing Lb. acidophilus culture and cheese made with rennet paste containing a mix of B. lactis and B. longum were approximately 2.5 and 3.0 times higher, respectively, than in traditional cheese. Principal component analysis showed a more intense lipolysis in terms of both free fatty acids and conjugated linoleic acid content in probiotic cheeses; in particular, the lipolytic pattern of cheeses containing Lb. acidophilus is distinguished from the other cheeses on the basis of highest content of health-promoting molecules. The metabolic activity of the cheese microflora was also monitored by measuring acetic, lactic, and citric acids during cheese ripening. Cheese acceptability was expressed for color, smell, taste, and texture perceived during cheese consumption. Use of probiotics in trial cheeses did not adversely affect preference or acceptability; in fact, panelists scored probiotic cheeses higher in preference over traditional cheese, albeit not significantly.     

Hygienic quality of ewes' milk cheeses manufactured with artisan-produced lamb rennet pastes

The use of artisan-produced lamb rennet pastes, but not any of the other commercial animal rennets, imparts a characteristic flavour to the cheese, so most Mediterranean ewes' milk cheeses are coagulated with this kind of rennet paste. In contrast to the advantages of using lamb or kid rennet pastes from the sensory point of view, questions are still raised as to their hygienic quality. The goal was to examine the microbiological and enzymic quality of lamb rennet pastes prepared by cheese manufacturers for their own use, and evaluate the hygienic quality of raw sheeps' milk cheeses made with them, using Idiazabal cheese as a model. Lamb rennet pastes prepared by artisan cheese makers from the Basque region of Spain (27), and Italy (8) were evaluated. For cheese making experiments 5 different lamb rennet pastes were selected among the 27 samples from the Basque Country region of Spain. Microbiological analyses were carried out on samples from rennet pastes, rennet extracts, milks and cheeses during ripening. Enzymic activities studied in rennet paste were: total coagulating strength and lipase. Analysis of variance and Student's t-tests was performed. The results show that the artisan-produced rennet pastes contain high levels of a variety of microorganisms. After 60 ripening days, which is the minimum ripening period required for Idiazabal cheese prior to its commercialization, no Eschericia coli, Clostridium, Salmonella spp. or Listeria monocytogenes were detected, and levels for the rest of the microorganisms were below the limits of the European legislative standards for cheese manufactured with raw milk. We can conclude that the use of artisan-produced lamb rennet pastes of questionable hygienic quality for the manufacture of raw milk hard cheeses yields products of good hygienic quality.     

Lamb rennet paste in ovine cheese manufacture. Lipolysis and flavour

In a preliminary study with commercial ewe's milk cheeses, there were statistically significant differences in the sensory evaluation scores and the amounts of short-chain (C4–C10) free fatty acids (FFAs) between cheeses made with lamb rennet paste or bovine rennet. Experimental ewe's milk cheeses were manufactured with 2 levels of artisanally produced lamb rennet paste and 2 levels of bovine rennet in 50 L vats, with a manufacturing replicate done within 1 week. Total coagulating activity was 2500 RU for cheeses manufactured with a high amount of rennet or 1000 RU for cheeses manufactured with a low amount of rennet. The two batches of lamb rennet pastes used had 4.0 (early Spring) and 6.5 U g⁻¹ lipase (late Spring), whereas no lipase activity was detected in bovine rennets. The total concentration of FFAs in cheeses manufactured with lamb rennet paste was significantly higher than in cheeses manufactured with bovine rennet, regardless of ripening time and time of the year. Lipolysis in the former cheeses increased with the total units of lipolytic activity added. The increase in lipolysis in cheeses made with lamb rennet was primarily due to higher amounts of short-chain fatty acids (C4–C10). Butyric acid was the main FFA in cheeses made with lamb rennet paste, representing 34.5 μmol 100 μmol⁻¹ (low level of rennet) and 44.2 μmol 100 μmol⁻¹ (high level of rennet) of the total FFAs, whereas it represented only 17 μmol 100 μmol⁻¹ of the total FFAs in all cheeses made with bovine rennet. The concentration of individual FFAs of chain length <C12 were significantly higher in cheeses made with lamb rennet paste than in cheeses made with bovine rennet. Cheeses made with lamb rennet paste received significantly higher intensity scores for odour and flavour intensity, sharp odour, ‘piquant’ and bitter flavours and ‘natural rennet’ odour and flavour.     

Evolution of lipolysis during the ripening of traditional Feta cheese

Lipolysis was studied during ripening of traditional Feta cheese produced in two small dairies, A and B. The cheeses were made from a thermized mixture of ewes’/goats’ milk by using yoghurt as starter and artisanal rennet from lambs’ and kids’ abomasa (cheese A) or mixed artisanal rennet with calf rennet (cheese B).The acid degree value and the free fatty acids (FFA) contents in both cheeses increased sharply up to 18 d (pre-ripening period at 15 °C) and continued to increase throughout ripening. In both mature cheeses, acetic acid was found at high levels (13–18% of the total FFAs). However, except for this, all FFA contents differed significantly (P < 0.05) between the two cheeses throughout ripening. The levels of individual and total C2:0–C8:0, C10:0–C14:0 and C16:0–C18:2 fatty acids were significantly higher (P < 0.05) in cheese A than in cheese B. Presumably the difference, especially in the C2:0–C8:0 content, was due mainly to the type of the rennet used. Butyric acid was the dominant FFA in cheese A (20% of the total FFAs at 120 d), while the most abundant FFAs in cheese B were capric (18%) and lauric acid (18%). In general, the lipolysis degree of the two cheeses was higher than those reported for the industrially-made Feta cheese.In organoleptic evaluation, cheese A had a piquant taste that was attributed to its high content of butyric acid and showed a significantly (P < 0.05) higher total score than cheese B.     

Rennet paste from lambs fed a milk substitute supplemented with Lactobacillus acidophilus: effects on lipolysis in ovine cheese

The present work was undertaken to evaluate the effects of Lactobacillus acidophilus supplementation of a milk substitute on the features of lamb rennet paste used for cheese making. Lipolysis in cheese manufactured with rennet paste from lambs receiving supplemented milk was also evaluated. Lambs were subjected to 3 different feeding regimens (mother suckling, MS; artificial rearing, AR; and artificial rearing with 7 log₁₀ cfu/mL of Lb. acidophilus supplementation of the milk substitute, ARLb) and slaughtered at 20 and 40 d of age for each feeding treatment. Abomasa of the lambs were processed to rennet paste. Microbial loads, enzymatic activities (chymosin, pepsin, and lipases), and renneting characteristics of the lamb rennet paste were determined. Free fatty acids and conjugated linoleic acids were detected in cheese at 60 d of ripening. Addition of 7 log₁₀ cfu/mL of Lb. acidophilus to the milk substitute was carried out successfully. Total recovery of viable cells was recorded in milk supplied daily to the lambs in the ARLb group. The ARLb rennet had greater amounts of lactobacilli than did the MS or AR rennet, irrespective of the slaughter age of the lambs, and the ARLb rennet had higher concentrations of lactococci when lambs were slaughtered at 40 d of age. Chymosin and lipase activities were also higher in ARLb rennet than in MS or AR rennet from lambs slaughtered at an older age. Milk supplementation of ARLb lambs resulted in improved coagulating ability of the rennet and enhanced cheese lipolysis after 60 d of ripening. A reduction of all free fatty acids was observed in all cheeses when passing from 20 to 40 d of slaughter of the lambs. Conjugated linoleic acids were more abundant in ARLb cheeses at both 20 and 40 d. Therefore, supplementation of the milk substitute with Lb. acidophilus improved the enzymatic features of rennet and the healthful and nutritional characteristics of it the ovine cheese. Moreover, the addition of lactobacilli to the milk substitute made it possible to increase the slaughter age of lambs without detrimental effects on rennet characteristics.     

Encapsulation of probiotic bacteria in lamb rennet paste: effects on the quality of Pecorino cheese

Lamb rennet pastes containing encapsulated Lactobacillus acidophilus and a mix of Bifidobacterium longum and Bifidobacterium lactis were produced for Pecorino cheese manufacture from Gentile di Puglia ewe milk. Cheeses were denoted as RP cheese when made with traditional rennet paste, RP-L cheese when made with rennet paste containing L. acidophilus culture, and RP-B cheese when made with rennet paste containing a mix of B. lactis and B. longum. Biochemical features of Pecorino cheese were studied at 1, 15, 30, 60, and 120 d of cheese ripening. The effect of encapsulation and bead addition to rennet acted on a different way on the viability of probiotic. Lactobacillus acidophilus retained its viability for 4 to 5 d and then showed a fast reduction; on the other hand, B. longum and B. lactis experienced kinetics characterized by an initial death slope, followed by a tail effect due to acquired resistance. At 1 d of ripening, the levels of L. acidophilus and bifidobacteria in cheese were the lowest, and then increased, reaching the highest levels after 30 d; such cell loads were maintained throughout the ripening for L. acidophilus, whereas bifidobacteria experienced a decrease of about 1 log cfu/g at the end of ripening. Enzymatic activities and biochemical features of cheeses were influenced by the type of rennet used for cheesemaking. Greater enzymatic activity was recorded in RP-L and RP-B cheese due to the presence of probiotic bacteria released from alginate beads. A positive correlation was found between enzymatic activities and water-soluble nitrogen and proteose-peptone in RP-B and RP-L cheeses; water-soluble nitrogen and proteose-peptone were the highest in RP-B. Principal component analysis distinguished RP-L from the other cheeses on the basis of the conjugated linoleic acid content, which was higher in the RP-L due to the ability of L. acidophilus to produce conjugated linoleic acid in the cheese matrix.     

Lipolysis in Urfa cheese produced from raw and pasteurized goats’ and cows’ milk with mesophilic or thermophilic cultures during ripening

Lipolysis was evaluated in Urfa cheese made from raw and pasteurized goats’ and cows’ milk with mesophilic or thermophilic cultures. The acid degree values (ADVs) of the cows’ milk cheeses were significantly (P < 0.05) higher until 60 d of storage than that of cheese made from goats’ milk. Total free fatty acid (FFA) contents of goats’ milk cheese were significantly (P < 0.001) lower than that of cows’ milk cheese throughout ripening, whereas goats’ milk cheese flavour was higher (P < 0.05) than cows’ milk cheese. Pasteurization of milk prior to cheese-making has a negative influence, not only on the level of lipolysis throughout ripening, but also on the relative amounts of short chain FFAs and sensory properties of the cheeses (P < 0.001). Cheese produced without starter bacteria underwent significantly (P < 0.05) higher lipolysis than cheeses produced with mesophilic or thermophilic starter bacteria, while cheese made with thermophilic starter culture had similar flavour to cheese made without starter culture.     

Influence of lamb rennet paste on the lipolytic and sensory profile of Murcia al Vino cheese

The influence of lamb rennet paste (71.1% chymosin, 177 international milk-clotting units/mL, 4.57U/g of lipase activity) during the ripening of Murcia al Vino goat cheese was studied. The aim of this study was to improve the knowledge of the effect of lamb rennet paste on the lipolytic patterns in this type of cheese by reference to the evolution of total and free fatty acids. A sensory analysis was carried out to compare cheeses made with commercial and paste rennet. The rennet paste showed higher lipolytic activity, enhancing the production of short-chain free fatty acids. In addition, the cheese produced with lamb rennet paste had a slightly more bitter and piquant taste, making it an attractive commercial alternative that can be used to develop new varieties of goat cheese.     

Use of changes in triacylglycerols during ripening of cheeses with high lipolysis levels for detection of milk fat authenticity

The triacylglycerol (TAG) compositions by carbon number during ripening of two Protected Designation of Origin (PDO) cheeses were analysed using short capillary column gas chromatography. Lipolysis levels were high in the Cabrales (blue cheese produced from cows’ milk or from blends of cows’ with goats’ milk) and Majorero goats’ milk cheeses at the end of ripening, with free fatty acid (FFA) levels of around 24 000 ppm and significant changes in the TAG composition. The level of lipolysis in an industrial blue cheese made from ewes’ milk was low, with an FFA value of around 6000 ppm and no significant changes in the TAG composition during ripening. The TAG values recorded for each cheese sample were substituted into the multiple regression equations that have been proposed for use in detecting foreign fats in milk fat. The values thus obtained were within the established ranges in early ripening. In the cheeses with high lipolysis levels during ripening, some of the values obtained fell outside the established ranges. These equations can be potentially useful for detecting foreign fats in these cheeses, when employed early in the ripening period. Furthermore, it is important to take into account that before coming to a conclusion about cheese authenticity, several individual samples should be analysed.     

Lipolysis,proteolysis and sensory properties of ewe’s raw milk cheese (Idiazabal) made with lipase addition

In this paper, we describe the effect of the addition of pregastric lipase on the composition and sensory properties of Idiazabal cheese. Free fatty acids (FFA), partial glycerides, free amino acids (FAA), gross composition and sensory characteristics were determined at different ripening times in cheeses manufactured with three different amounts of commercial animal lipase or with lipase-containing artisanal lamb rennet paste. The addition of lipase increased the content of total FFA, particularly of short-chain FFA, and that of total partial glycerides in cheeses. Unexpectedly, lipase utilization significantly affected total FAA concentration, which decreased in cheeses elaborated with high lipase amount. In general, Val, Glu and Leu were the major FAA, and their concentrations depended, mainly, on ripening time. Lipase addition had significant influence on the sensory characteristics of the cheeses, increasing scores for most of the flavour and odour attributes of the cheese. Principal component analysis (PCA) was done including dry matter, FFA, FAA, partial glycerides and odour and flavour attributes of the cheeses. It indicated that aroma and flavour parameters of Idiazabal cheese and the content of short-chain FFA and diglycerides were highly correlated to first principal component (PC1), while texture parameters, compositional variables and FAA were correlated to the second principal component (PC2).     

Modeling of proteolysis and lipolysis in Iranian white brine cheese

The simultaneous effects of processing variables such as ripening time (20–60 days), ripening temperature (6–10 °C), level of rennet added (1–2 g/100 kg milk) and brine concentration (8–14%, w/v) on the proteolysis, lipolysis and sensory score of Iranian white brined cheese (Feta type) were explored by the means of response surface methodology. The most important effect in proteolytical terms was produced by ripening temperature and ripening time in linear form, but level of rennet added and brine concentration were also significant at the 5% level. In terms of lipolysis, ripening time was dominant factor in both linear and quadratic forms; quadratic effect of ripening temperature was greater than its linear effect.     

Influence of lamb rennet paste containing probiotic on proteolysis and rheological properties of pecorino cheese

Pecorino cheeses made from heat-treated ewes’ milk using traditional lamb rennet paste (RP), lamb rennet paste containing Lactobacillus acidophilus (LA-5; RPL), and lamb rennet paste containing a mix of Bifidobacterium lactis (BB-12) and Bifidobacterium longum (BB-46; RPB) were characterized for proteolytic and rheological features during ripening. Consumer acceptance of cheeses at 60 d of ripening was evaluated. Lactobacillus acidophilus and Bifidobacterium mix displayed counts of 8 log₁₀ cfu/g and 9 log₁₀ cfu/g, respectively, in cheese during ripening. The RPB cheese displayed a greater degradation of casein (CN) matrix carried out by the enzymes associated to both Bifidobacterium mix and endogenous lactic acid microflora, resulting in the highest values of non-CN N and water-soluble N and the highest amount of α_s-CN degradation products in cheese at 60 d of ripening. The RPL cheese displayed intermediate levels of lactic acid bacteria and of N fractions. The percentage of γ-CN in RP and RPL cheeses at 60 d was 2-fold higher than in the cheese curd of the same groups, whereas the mentioned parameter was 3-fold higher in RPB cheese than in the corresponding fresh curd according to its highest plasmin content. The lower hardness in RPB at the end of ripening could be ascribed to the greater proteolysis observed in cheese harboring the Bifidobacterium mix. Although differences in proteolytic patterns were found among treatments, there were no differences in smell and taste scores.     

Short communication: Sensory profile of raw goat milk cheeses made with artisan kid rennet pastes from commercial-weight animals: Alternative to farmhouse goat cheeses

The loss of traditional kid rennet pastes in the Canary Islands (Spain), as in many other regions, is most likely due to the custom of using abomasa from very young animals killed below desirable commercial weight. In addition, the reasonable price of commercial rennets (CR) has resulted in the loss of typical sensory characteristics for most farmhouse raw goat milk cheeses, placing them at a disadvantage when local and international markets are full of different cheeses, often with aggressive marketing strategies. This paper analyzes the sensory characteristics of raw goat milk cheeses made with rennet pastes prepared from commercial kid abomasa in 2 ways: dried while full of ingested milk [full, commercial, artisan kid rennet (FCKR)], or dried after being emptied of ingested milk and refilled with raw goat milk [empty, commercial, artisan kid rennet (ECKR)]. This latter practice allows the use of empty abomasa, or abomasa with grass, soil, and so on. Sensory profiles of cheeses made with FCKR and ECKR rennets were compared with those made with CR by an expert panel (n = 7). The FCKR and ECKR cheeses had similar sensory profiles. Although scores for FCKR cheeses were somewhat higher than for ECKR cheeses, they were in the range found for traditional cheeses made with rennet prepared with abomasa from very young animals. The sensory profile of CR cheeses was very different. Almost 90% of consumer panelists (n = 90) preferred cheeses made with the experimental rennet pastes. These results demonstrate the possibility to prepare artisan rennet pastes from commercial-weight kids in an easy way for farmhouse cheese makers using local resources that would otherwise be destroyed in abattoirs.     

甲醇芽孢杆菌凝乳酶对马苏里拉干酪加工特性的影响

为了探究甲醇芽孢杆菌（Bacillus methanolicus）凝乳酶在马苏里拉干酪加工中的应用,分别以使用甲醇芽孢杆菌凝乳酶、混合酶制剂（含质量分数10%甲醇芽孢杆菌凝乳酶和90%商品凝乳酶）制作的马苏里拉干酪作为实验组,以商品凝乳酶干酪作为对照组,测定不同组别干酪成熟期间的蛋白水解特性、质构、风味和微观结构变化,研究甲醇芽孢杆菌凝乳酶对马苏里拉干酪加工特性的影响。结果表明,实验组干酪在成熟过程中pH值（4.6～5.3）、微生物数量（8.80～9.68（lg（CFU/g）））与对照组无显著差异（P＞0.05）;实验组干酪水分质量分数（混合酶干酪为（43.21±1.17）%、甲醇芽孢杆菌凝乳酶干酪为（46.15±0.94）%）均显著高于对照组（（41.08±1.04）%）,得率（混合酶干酪为（9.27±0.17）%、甲醇芽孢杆菌凝乳酶干酪为（9.46±0.16）%）也显著高于对照组（（8.98±0.13）%）（P＜0.05）;且实验组干酪的蛋白水解特性（pH 4.6时可溶性蛋白、酪蛋白水解程度和游离氨基酸质量分数）以及风味物质种类和相对含量等指标也优于对照组干酪。但是实验组中甲醇芽孢杆菌凝乳酶干酪保形性相对欠佳,感官评定得分偏低,混合酶干酪与对照组质构及感官基本得分一致,因此甲醇芽孢杆菌凝乳酶可以作为商品酶的部分代替品应用于干酪的生产中。     

Changes of composition and free fatty acid contents of Urfa cheeses (a white-brined Turkish cheese) during ripening: Effects of heat treatments and starter cultures

The influences of heat treatments (at 65 °C for 20 min or 72 °C for 5 min) applied to the milk and addition of mesophilic or thermophilic starter cultures, prior to cheese-making, on the composition and free fatty acid contents of Urfa cheeses were evaluated throughout the ripening period. Sensory evaluation of cheese samples was also performed on 90th day. The basic composition of ripened cheese samples was not significantly affected by the heat treatments and starter cultures. Heat treatments adversely affected the lipolysis and sensory properties of Urfa cheeses, particularly at 72 °C. The FFA contents of cheeses made from mesophilic and thermophilic cultures were similar. Cheese made from raw milk had a higher level of lipolysis than the cheeses made from milk inoculated with mesophilic or thermophilic lactic starters (p < 0.05).     

Changes in organic acids during ripening of cheeses made from raw, pasteurized or high-pressure-treated goats’ milk

Organic acids of cheeses made from raw (RA), pasteurized (PA; 72°C, 15 s) or pressure-treated (PR; 500 MPa, 15 min, 20°C) goats’ milk were qualitatively and quantitatively assessed during ripening. Nine organic acids (citric, pyruvic, malic, lactic, formic, acetic, uric, propionic and butyric) were analysed in each sample by HPLC.Milk treatment did not affect the total organic acids content of 1-day-old cheeses, which increased steadily from day 1 to day 60. At the end of ripening, RA and PR milk cheeses both exhibited higher concentration of organic acids than in those made from PA milk.Lactic acid was found in higher concentration in PR milk cheese from 30 days of ripening. The RA milk cheese, that showed the highest nonstarter lactic acid bacteria counts, were characterized by an elevated amount of propionic and acetic acids. These cheeses also were negatively correlated with both pyruvic and citric acid contents. The PA milk cheese showed a high level of malic acid, and was clearly differentiate from RA and PR milk cheeses by its low level of butyric acid.     

Effects of high-pressure treatment on free fatty acids release during ripening of ewes' milk cheese

The free fatty acid (FFA) profile of high pressure treated ewes' milk cheeses were studied to assess the effect of pressure treatment on cheese lipolysis. Cheeses were treated at 200, 300, 400 or 500 MPa (2P to 5P) at two stages of ripening (after 1 and 15 days of manufacturing; P1 and P15) and FFA were assayed at 1, 15 and 60 d ripening. On the first day of ripening, 3P1-cheeses showed levels of FFA twice that of the control cheeses. However, no significant differences were found between 3P1 and control cheeses at 60 d ripening. On the contrary, 4P1 and 5P1-cheeses had the lowest total FFA levels. The point at which pressure treatment was applied influenced the FFA profile of cheeses; cheeses pressurized at pressures<400 MPa on the first day of ripening were more similar to untreated cheeses than their homologues treated at 15 d.