Fate of Staphylococcus aureus in cheese treated by ultrahigh pressure homogenization and high hydrostatic pressure

We evaluated the influence of ultrahigh pressure homogenization (UHPH) treatment applied to milk containing Staphylococcus aureus CECT 976 before cheese making, and the benefit of applying a further high hydrostatic pressure (HHP) treatment to cheese. The evolution of Staph. aureus counts during 30 d of storage at 8°C and the formation of staphylococcal enterotoxins were also assessed. Milk containing approximately 7.3 log₁₀ cfu/mL of Staph. aureus was pressurized using a 2-valve UHPH machine, applying 330 and 30 MPa at the primary and the secondary homogenizing valves, respectively. Milk inlet temperatures (T_in) of 6 and 20°C were assayed. Milk was used to elaborate soft-curd cheeses (UHPH cheese), some of which were additionally submitted to 10-min HHP treatments of 400 MPa at 20°C (UHPH+HHP cheese). Counts of Staph. aureus were measured on d 1 (24 h after manufacture or immediately after HHP treatment) and after 2, 15, and 30 d of ripening at 8°C. Counts of control cheeses not pressure-treated were approximately 8.5 log₁₀ cfu/g showing no significant decreases during storage. In cheeses made from UHPH treated milk at T_in of 6°C, counts of Staph. aureus were 5.0 ± 0.3 log₁₀ cfu/g at d 1; they decreased significantly to 2.8 ± 0.2 log₁₀ cfu/g on d 15, and were below the detection limit (1 log₁₀ cfu/g) after 30 d of storage. The use of an additional HHP treatment had a synergistic effect, increasing reductions up to 7.0 ± 0.3 log₁₀ cfu/g from d 1. However, for both UHPH and UHPH+HHP cheeses in the 6°C T_in samples, viable Staph. aureus cells were still recovered. For samples of the 20°C T_in group, complete inactivation of Staph. aureus was reached after 15 d of storage for both UHPH and UHPH+HHP cheese. Staphylococcal enterotoxins were found in controls but not in UHPH or UHPH+HHP treated samples. This study shows a new approach for significantly improving cheese safety by means of using UHPH or its combination with HHP.     

Effect of high-pressure processing on reduction of Listeria monocytogenes in packaged Queso Fresco

The effect of high-hydrostatic-pressure processing (HPP) on the survival of a 5-strain rifampicin-resistant cocktail of Listeria monocytogenes in Queso Fresco (QF) was evaluated as a postpackaging intervention. Queso Fresco was made using pasteurized, homogenized milk, and was starter-free and not pressed. In phase 1, QF slices (12.7 × 7.6 × 1 cm), weighing from 52 to 66 g, were surface inoculated with L. monocytogenes (ca. 5.0 log₁₀ cfu/g) and individually double vacuum packaged. The slices were then warmed to either 20 or 40°C and HPP treated at 200, 400, and 600 MPa for hold times of 5, 10, 15, or 20 min. Treatment at 600 MPa was most effective in reducing L. monocytogenes to below the detection level of 0.91 log₁₀ cfu/g at all hold times and temperatures. High-hydrostatic-pressure processing at 40°C, 400 MPa, and hold time ≥15 min was effective but resulted in wheying-off and textural changes. In phase 2, L. monocytogenes was inoculated either on the slices (ca. 5.0 log₁₀ cfu/g; ON) or in the curds (ca. 7.0 log₁₀ cfu/g; IN) before the cheese block was formed and sliced. The slices were treated at 20°C and 600 MPa at hold times of 3, 10, and 20 min, and then stored at 4 and 10°C for 60 d. For both treatments, L. monocytogenes became less resistant to pressure as hold time increased, with greater percentages of injured cells at 3 and 10 min than at 20 min, at which the lethality of the process increased. For the IN treatment, with hold times of 3 and 10 min, growth of L. monocytogenes increased the first week of storage, but was delayed for 1 wk, with a hold time of 20 min. Longer lag times in growth of L. monocytogenes during storage at 4°C were observed for the ON treatment at hold times of 10 and 20 min, indicating that the IN treatment may have provided a more protective environment with less injury to the cells than the ON treatment. Similarly, HPP treatment for 10 min followed by storage at 4°C was the best method for suppressing the growth of the endogenous microflora with bacterial counts remaining below the level of detection for 2 out of the 3 QF samples for up to 84 d. Lag times in growth were not observed during storage of QF at 10°C. Although HPP reduced L. monocytogenes immediately after processing, a second preservation technique is necessary to control growth of L. monocytogenes during cold storage. However, the results also showed that HPP would be effective for slowing the growth of microorganisms that can shorten the shelf life of QF.     

A comparison between E-beam irradiation and high pressure treatment for cold-smoked salmon sanitation: microbiological aspects

The effectiveness of electron beam irradiation and high pressure treatment for the sanitation of cold-smoked salmon from two points of view, microbial safety and shelf-life extension, was compared. From the response of L. monocytogenes INIA H66a to irradiation, a D value of 0.51 kGy was calculated. For samples stored at 5 °C, 1.5 kGy would be sufficient to attain a Food Safety Objective (FSO) of 2 log₁₀cfu/g L. monocytogenes for a 35-day shelf-life, whereas 3 kGy would be needed in the case of a temperature abuse (5 °C + 8 °C). Pressurization at 450 MPa for 5 min was considered to be an insufficient treatment, since the FSO of 2 log₁₀cfu/g L. monocytogenes was only attained for a shelf-life of 21 days at 5 °C. However, treatment at 450 MPa for 10 min achieved this FSO for samples held during 35 days at 5 °C, or during 21 days under temperature abuse (5 °C + 8 °C) conditions. Irradiation at 2 kGy kept the microbial population of smoked salmon below 6 log₁₀cfu/g after 35 days at 5 °C, with negligible or very light changes in its odor. Pressurization at 450 MPa for 5 min also kept the microbial population below 6 log₁₀cfu/g after 35 days at 5 °C and did not alter odor, but affected negatively the visual aspect of smoked salmon.     

Bactericidal activity of lauric arginate in milk and Queso Fresco cheese against Listeria monocytogenes cold growth

Lauric arginate (LAE) at concentrations of 200 ppm and 800 ppm was evaluated for its effectiveness in reducing cold growth of Listeria monocytogenes in whole milk, skim milk, and Queso Fresco cheese (QFC) at 4°C for 15 to 28 d. Use of 200 ppm of LAE reduced 4 log cfu/mL of L. monocytogenes to a nondetectable level within 30 min at 4°C in tryptic soy broth. In contrast, when 4 log cfu/mL of L. monocytogenes was inoculated in whole milk or skim milk, the reduction of L. monocytogenes was approximately 1 log cfu/mL after 24 h with 200 ppm of LAE. When 800 ppm of LAE was added to whole or skim milk, the initial 4 log cfu/mL of L. monocytogenes was nondetectable following 24 h, and no growth of L. monocytogenes was observed for 15 d at 4°C. With surface treatment of 200 or 800 ppm of LAE on vacuum-packaged QFC, the reductions of L. monocytogenes within 24 h at 4°C were 1.2 and 3.0 log cfu/g, respectively. In addition, the overall growth of L. monocytogenes in QFC was decreased by 0.3 to 2.6 and by 2.3 to 5.0 log cfu/g with 200 and 800 ppm of LAE, respectively, compared with untreated controls over 28 d at 4°C. Sensory tests revealed that consumers could not determine a difference between QFC samples that were treated with 0 and 200 ppm of LAE, the FDA-approved level of LAE use in foods. In addition, no differences existed between treatments with respect to flavor, texture, and overall acceptability of the QFC. Lauric arginate shows promise for potential use in QFC because it exerts initial bactericidal activity against L. monocytogenes at 4°C without affecting sensory quality.     

Mixed species biofilms of Listeria monocytogenes and Lactobacillus plantarum show enhanced resistance to benzalkonium chloride and peracetic acid

We investigated the formation of single and mixed species biofilms of Listeria monocytogenes strains EGD-e and LR-991, with Lactobacillus plantarum WCFS1 as secondary species, and their resistance to the disinfectants benzalkonium chloride and peracetic acid. Modulation of growth, biofilm formation, and biofilm composition was achieved by addition of manganese sulfate and/or glucose to the BHI medium. Composition analyses of the mixed species biofilms using plate counts and fluorescence microscopy with dual fluorophores showed that mixed species biofilms were formed in BHI (total count, 8-9 log₁₀ cfu/well) and that they contained 1-2 log₁₀ cfu/well more L. monocytogenes than L. plantarum cells. Addition of manganese sulfate resulted in equal numbers of both species (total count, 8 log₁₀ cfu/well) in the mixed species biofilm, while manganese sulfate in combination with glucose, resulted in 1-2 log₁₀ more L. plantarum than L. monocytogenes cells (total count, 9 log₁₀ cfu/well). Corresponding single species biofilms of L. monocytogenes and L. plantarum contained up to 9 log₁₀ cfu/well. Subsequent disinfection treatments showed mixed species biofilms to be more resistant to treatments with the selected disinfectants. In BHI with additional manganese sulfate, both L. monocytogenes strains and L. plantarum grown in the mixed species biofilm showed less than 2 log₁₀ cfu/well inactivation after exposure for 15 min to 100 μg/ml benzalkonium chloride, while single species biofilms of both L. monocytogenes strains showed 4.5 log₁₀ cfu/well inactivation and single species biofilms of L. plantarum showed 3.3 log₁₀ cfu/well inactivation. Our results indicate that L. monocytogenes and L. plantarum mixed species biofilms can be more resistant to disinfection treatments than single species biofilms.     

Microbiological quality of raw milk used for small-scale artisan cheese production in Vermont: Effect of farm characteristics and practices

This study 1) evaluated the overall milk quality and prevalence of 4 target pathogens (Listeria monocytogenes, Staphylococcus aureus, Salmonella spp., and Escherichia coli O157:H7) in raw milk used for small-scale artisan cheesemaking and 2) examined specific farm characteristics and practices and their effect on bacterial and somatic cell counts (SCC). Raw milk samples were collected weekly from 21 artisan cheese operations (6 organic) in the state of Vermont that manufactured raw-milk cheese from cow (12), goat (5), or sheep (4) milk during the summer of 2008. Individual samples were examined for standard plate counts (SPC), coliform counts (CC), and SCC. Samples were also screened for target pathogens both quantitatively and qualitatively by direct plating and PCR. Overall, 86% of samples had SPC <10,000 cfu/mL, with 42% <1,000 cfu/mL. Additionally, 68% of samples tested were within pasteurized milk standards for coliform bacteria under the United States’ Grade A Pasteurized Milk Ordinance at <10 cfu/mL. Log₁₀ SPC and CC did not differ significantly among species. Similarly, method of sample delivery (shipped or picked up), farm type (organic or conventional), and duration of milking (year-round or seasonal) did not have significant effects on farm aggregated mean log₁₀ SPC, CC, or SCC. Strong positive correlations were observed between herd size and mean log₁₀ SPC and between log₁₀ SPC and CC as well as SCC when data from all animal species were combined. Although SCC for cow milk were significantly lower than those for goat and sheep milk, 98, 71, and 92% of cow, sheep, and goat milk samples, respectively, were within the compliance limits of the United States’ Grade A Pasteurized Milk Ordinance for SCC. Fourteen of the 21 farms (67%) were positive for Staph. aureus, detected in 38% of samples at an average level of 20 cfu/mL. Neither L. monocytogenes, E. coli O157:H7, or Salmonella spp. were detected or recovered from any of the 101 samples tested. Our results indicate that the majority of raw milk produced for small-scale artisan cheesemaking was of high microbiological quality with no detectable target pathogens despite the repeat sampling of farms. These data will help to inform risk assessments that evaluate the microbiological safety of artisan and farmstead cheeses, particularly those manufactured from raw milk.     

Effects of ultra-high pressure homogenization on microbial and physicochemical shelf life of milk

The effect of ultra-high pressure homogenization (UHPH) on microbial and physicochemical shelf life of milk during storage at 4°C was studied and compared with a conventional heat preservation technology used in industry. Milk was standardized at 3.5% fat and was processed using a Stansted high-pressure homogenizer. High-pressure treatments applied were 100, 200, and 300 MPa (single stage) with a milk inlet temperature of 40°C, and 200 and 300 MPa (single stage) with a milk inlet temperature of 30°C. The UHPH-treated milks were compared with high-pasteurized milk (PA; 90°C for 15 s). The microbiological quality was studied by enumerating total counts, psychrotropic bacteria, lactococci, lactobacilli, enterococci, coliforms, spores, and Pseudomonas. Physicochemical parameters assessed in milks were viscosity, color, pH, acidity, rate of creaming, particle size, and residual peroxidase and phosphatase activities. Immediately after treatment, UHPH was as efficient (99.99%) in reducing psychrotrophic, lactococci, and total bacteria as was the PA treatment, reaching reductions of 3.5 log cfu/mL. Coliforms, lactobacilli, and enterococci were eliminated. Microbial results of treated milks during storage at 4°C showed that UHPH treatment produced milk with a microbial shelf life between 14 and 18 d, similar to that achieved for PA milk. The UHPH treatments reduced the L* value of treated milks and induced a reduction in viscosity values of milks treated at 200 MPa compared with PA milks; however, these differences would not be appreciated by consumers. In spite of the fat aggregates detected in milks treated at 300 MPa, no creaming was observed in any UHPH-treated milk. Hence, alternative methods such as UHPH may give new opportunities to develop fluid milk with an equivalent shelf life to that of PA milk in terms of microbial and physicochemical characteristics.     

Control of Listeria monocytogenes in whole milk using antimicrobials applied individually and in combination

Dairy product recalls and dairy-related illnesses are often the result of contamination with Listeria monocytogenes, which can occur throughout the dairy production and supply chains. The use of antimicrobial compounds is one practical approach for controlling pathogen survival and growth in foods. The goal of this study was to use fluid milk as a model system to identify listeristatic or listericidal treatments that show promise for application in fluid milk and for further evaluation in other dairy products (e.g., cheese). Caprylic acid (CA), ε-polylysine (EPL), hydrogen peroxide, lauric arginate (LAE), and sodium caprylate (SC) were added individually or in combination to whole milk inoculated with L. monocytogenes at ?4 log₁₀ cfu/mL. Samples were stored at 7°C for 21 d, and L. monocytogenes counts were determined weekly. Inhibitory concentrations of LAE (800 mg/L) and EPL (100–400 mg/L), as well as SC and CA (3,200 mg/L each), were identified. The addition of EPL at 800 mg/L reduced L. monocytogenes counts by >3 log₁₀ cfu/mL from initial inoculation levels after 21 d. Addition of hydrogen peroxide to milk reduced counts by >3 log₁₀ cfu/mL from initial inoculation within 24 h (400 and 800 mg/L) or by d 7 (200 mg/L). Although the combinatory treatments of EPL + CA, EPL + LAE, and LAE + SC were characterized as indifferent, EPL + SC worked synergistically to reduce L. monocytogenes populations in milk over 21 d. Overall, these data identify potential antimicrobial treatments to control L. monocytogenes in milk and serve as a foundation for the continued development of antimicrobial controls for L. monocytogenes in dairy products.     

Efficacy of bacteriophage LISTEXP100 combined with chemical antimicrobials in reducing Listeria monocytogenes in cooked turkey and roast beef

The aim of this study was to verify the effectiveness of the commercially available anti-Listeria phage preparation LISTEX^™P100 in reducing Listeria monocytogenes on ready-to-eat (RTE) roast beef and cooked turkey in the presence or absence of the chemical antimicrobials potassium lactate (PL) and sodium diacetate (SD). Sliced RTE meat cores at 4 and 10 °C were inoculated with cold-adapted L. monocytogenes to result in a surface contamination level of 10³ CFU/cm². LISTEX^TMP100 was applied at 10⁷ PFU/cm² and samples taken at regular time intervals during the RTE product's shelf life to enumerate viable L. monocytogenes. LISTEX^™P100 was effective during incubation at 4 °C with initial reductions of L. monocytogenes of 2.1 log₁₀ CFU/cm² and 1.7 log₁₀ CFU/cm², respectively, for cooked turkey and roast beef without chemical antimicrobials (there was no significant difference to the initial L. monocytogenes reductions in the presence of LISTEX^TMP100 for cooked turkey containing PL and roast beef containing SD-PL). In the samples containing no chemical antimicrobials, the presence of phage resulted in lower L. monocytogenes numbers, relative to the untreated control, of about 2 log CFU/cm² over a 28-day storage period at 4 °C. An initial L. monocytogenes cell reduction of 1.5 log₁₀ CFU/cm² and 1.7 log₁₀ CFU/cm², respectively, for cooked turkey and roast beef containing no chemical antimicrobials was achieved by the phage at 10 °C (abusive temperature). At this temperature, the L. monocytogenes cell numbers of samples treated with LISTEX™ P100 remained below those of the untreated control only during the first 14 days of the experiment for roast beef samples with and without antimicrobials. On day 28, the L. monocytogenes numbers on samples containing chemical antimicrobials and treated with LISTEX^TMP100 stored at 4 and 10 °C were 4.5 log₁₀ CFU/cm² and 7.5 log₁₀ CFU/cm², respectively, for cooked turkey, and 1.2 log₁₀ CFU/cm² and 7.2 log₁₀ CFU/cm², respectively, for roast beef. In both cooked turkey samples with and without chemical antimicrobials stored at 10 °C, the phage-treated samples had significantly lower numbers of L. monocytogenes when compared to the untreated controls throughout the 28-day storage period (P < 0.0001). For roast beef and cooked turkey containing chemical antimicrobials treated with LISTEX^TMP100 and stored at 4 °C, no more than a 2 log CFU/cm² increase of L. monocytogenes was observed throughout the stated shelf life of the product. This study shows that LISTEX^™P100 causes an initial reduction of L. monocytogenes numbers and can serve as an additional hurdle to enhance the safety of RTE meats when used in combination with chemical antimicrobials.     

The effect of sodium reduction with and without potassium chloride on the survival of Listeria monocytogenes in Cheddar cheese

Sodium chloride (NaCl) in cheese contributes to flavor and texture directly and by its effect on microbial and enzymatic activity. The salt-to-moisture ratio (S/M) is used to gauge if conditions for producing good-quality cheese have been met. Reductions in salt that deviate from the ideal S/M range could result in changing culture acidification profiles during cheese making. Lactococcus lactis ssp. lactis or Lc. lactis ssp. cremoris are both used as cultures in Cheddar cheese manufacture, but Lc. lactis ssp. lactis has a higher salt and pH tolerance than Lc. lactis ssp. cremoris. Both salt and pH are used to control growth and survival of Listeria monocytogenes and salts such as KCl are commonly used to replace the effects of NaCl in food when NaCl is reduced. The objectives of this project were to determine the effects of sodium reduction, KCl use, and the subspecies of Lc. lactis used on L. monocytogenes survival in stirred-curd Cheddar cheese. Cheese was manufactured with either Lc. lactis ssp. lactis or Lc. lactis ssp. cremoris. At the salting step, curd was divided and salted with a concentration targeted to produce a final cheese with 600 mg of sodium/100 g (control), 25% reduced sodium (450 mg of sodium/100 g; both with and without KCl), and low sodium (53% sodium reduction or 280 mg of sodium/100 g; both with and without KCl). Potassium chloride was added on a molar equivalent to the NaCl it replaced to maintain an equivalent S/M. Cheese was inoculated with a 5-strain cocktail of L. monocytogenes at different times during aging to simulate postprocessing contamination, and counts were monitored over 27 or 50 d, depending on incubation temperature (12 or 5°C, respectively). In cheese inoculated with 4 log₁₀ cfu of L. monocytogenes/g 2 wk after manufacture, viable counts declined by more than 3 log₁₀ cfu/g in all treatments over 60 d. When inoculated with 5 log₁₀ cfu/g at 3 mo of cheese age, L. monocytogenes counts in Cheddar cheese were also reduced during storage, but by less than 1.5 log₁₀ cfu/g after 50 d. However, cheese with a 50% reduction in sodium without KCl had higher counts than full-sodium cheese at the end of 50 d of incubation at 4°C when inoculated at 3 mo. When inoculated at 8 mo postmanufacture, this trend was only observed in 50% reduced sodium with KCl, for cheese manufactured with both cultures. This enhanced survival for 50% reduced-sodium cheese was not seen when a higher incubation temperature (12°C) was used when cheese was inoculated at 3 mo of age and monitored for 27 d (no difference in treatments was observed at this incubation temperature). In the event of postprocessing contamination during later stages of ripening, L. monocytogenes was capable of survival in Cheddar cheese regardless of which culture was used, whether or not sodium had been reduced by as much as 50% from standard concentrations, or if KCl had been added to maintain the effective S/M of full-sodium Cheddar cheese.     

Aerobic bacterial, coliform, Escherichia coli and Staphylococcus aureus counts of raw and processed milk from selected smallholder dairy farms of Zimbabwe

A cross sectional study was conducted to enumerate total viable bacteria (TBC), coliforms, Escherichia coli and Staphylococcus aureus in raw (n = 120) and processed (n = 20) milk from individual farms from three smallholder dairy schemes of Zimbabwe between October, 2009 and February, 2010. Data on management factors were collected using a structured questionnaire. A standard pour plate technique was used to enumerate total viable bacteria, while for coliforms, E. coli and S. aureus, counts were assessed by the spread plate technique. The association of total viable bacterial counts and management factors was assessed using univariable and a linear regression model. The log₁₀ TBC for raw milk differed significantly (P < 0.05) amongst the schemes with the lowest (5.6 ± 4.7 log₁₀ cfu/ml) and highest (6.7 ± 5.8 log₁₀ cfu/ml) recorded from Marirangwe and Nharira respectively. The mean log₁₀ of TBC of processed milk (6.6 ± 6.0 log₁₀ cfu/ml) were marginally higher than those of raw milk (6.4 ± 5.6 log₁₀ cfu/ml) but not significant (P > 0.05). The coliform, E. coli and S. aureus counts for raw milk significantly differed (P < 0.05) amongst the study areas. The variation in TBC, coliforms, E. coli and S. aureus counts amongst the schemes could be attributed to differences in milking hygiene where farms with more access to training and monitoring of microbiological quality of milk had lower counts. Linear regression analysis revealed dairy scheme, delivery time and season of milking as independently associated with increased TBC of raw milk. The high TBC of raw and processed milk generally indicated low levels of milking hygienic practices, and high level of post-processing contamination, respectively. The high TBC, coliform, E. coli and S. aureus counts of both raw and processed milk may present a public health hazard. Thus, educating the farmers on general hygienic practices, quickening the delivery of milk to collection centres, or availing cooling facilities on-farm will improve the microbiological quality and safety of milk.     

Effects of γ-irradiation on Listeria monocytogenes population,colour, texture and sensory properties of Feta cheese during cold storage

Feta, a white brine cheese, was produced and contaminated with Listeria monocytogenes. Contamination occurred either at the beginning (pre-process contamination) or at the end of Feta manufacturing (post-process contamination). In the first case the milk was contaminated with 10³ cfu/ml, and 2 months later, in the final product, the L. monocytogenes population was approximately 10⁵ cfu/g. In the second case, the brine (NaCl, 7% w/v), in which the Feta was packaged, was contaminated with 10³ cfu/ml. Contaminated Feta samples were vacuum-packaged and exposed to irradiation doses of 1.0, 2.5 and 4.7 kGy and stored at 4 °C for a month. In the pre-process contaminated samples none of the irradiation doses eliminated L. monocytogenes; however the highest dose reduced the viable population to a level which is in compliance with EC regulations. In the post-process contamination, the 2.5 kGy and 4.7 kGy doses reduced L. monocytogenes counts below the detection limit. Irradiation had no effect on the texture of Feta. Irradiation at 4.7 kGy increased Feta's redness and decreased its yellowness and lightness. Sensorial analyses showed that at the 4.7 kGy dose, the aroma profile of Feta was temporarily affected, since it was restored after 30 days of cold storage.     

Growth characteristics of Listeria monocytogenes as affected by a native microflora in cooked ham under refrigerated and temperature abuse conditions

This study examined the growth characteristics of Listeria monocytogenes as affected by a native microflora in cooked ham at refrigerated and abuse temperatures. A five-strain mixture of L. monocytogenes and a native microflora, consisting of Brochothrix spp., isolated from cooked meat were inoculated alone (monocultured) or co-inoculated (co-cultured) onto cooked ham slices. The growth characteristics, lag phase duration (LPD, h), growth rate (GR, log₁₀ cfu/h), and maximum population density (MPD, log₁₀ cfu/g), of L. monocytogenes and the native microflora in vacuum-packed ham slices stored at 4, 6, 8, 10, and 12 °C for up to 5 weeks were determined. At 4-12 °C, the LPDs of co-cultured L. monocytogenes were not significantly different from those of monocultured L. monocytogenes in ham, indicating the LPDs of L. monocytogenes at 4-12 °C were not influenced by the presence of the native microflora. At 4-8 °C, the GRs of co-cultured L. monocytogenes (0.0114-0.0130 log₁₀ cfu/h) were statistically but marginally lower than those of monocultured L. monocytogenes (0.0132-0.0145 log₁₀ cfu/h), indicating the GRs of L. monocytogenes at 4-8 °C were reduced by the presence of the native microflora. The GRs of L. monocytogenes were reduced by 8-7% with the presence of the native microflora at 4-8 °C, whereas there was less influence of the native microflora on the GRs of L. monocytogenes at 10 and 12 °C. The MPDs of L. monocytogenes at 4-8 °C were also reduced by the presence of the native microflora. Data from this study provide additional information regarding the growth suppression of L. monocytogenes by the native microflora for assessing the survival and growth of L. monocytogenes in ready-to-eat meat products.     

Identification of dairy farm management practices associated with the presence of psychrotolerant sporeformers in bulk tank milk

Some strains of sporeforming bacteria (e.g., Bacillus spp. and Paenibacillus spp.) can survive pasteurization and subsequently grow at refrigeration temperatures, causing pasteurized fluid milk spoilage. To identify farm management practices associated with different levels of sporeformers in raw milk, a bulk tank sample was obtained from and a management and herd health questionnaire was administered to 99 New York State dairy farms. Milk samples were spore pasteurized [80°C (176°F) for 12 min] and subsequently analyzed for most-probable number and for sporeformer counts on the initial day of spore pasteurization (SP), and after refrigerated storage (6°C) at 7, 14, and 21 d after SP. Management practices were analyzed for association with sporeformer counts and bulk tank somatic cell counts. Sixty-two farms had high sporeformer growth (≥3 log cfu/mL at any day after SP), with an average sporeformer count of 5.20 ± 1.41 mean log₁₀ cfu/mL at 21 d after SP. Thirty-seven farms had low sporeformer numbers (<3 log cfu/mL for all days after SP), with an average sporeformer count of 0.75 ± 0.94 mean log₁₀ cfu/mL at 21 d after SP. Farms with >25% of cows with dirty udders in the milking parlor were 3.15 times more likely to be in the high category than farms with ≤10% of milking cows with dirty udders. Farms with <200 cows were 3.61 times more likely to be in the high category than farms with ≥200 cows. Management practices significantly associated with increased bulk tank somatic cell count were a lack of use of the California mastitis test at freshening and >25% of cows with dirty udders observed in the milking parlor. Changes in management practices associated with cow cleanliness may directly ensure longer shelf life and higher quality of pasteurized fluid milk.     

Antimicrobial activity of nisin, reuterin, and the lactoperoxidase system on Listeria monocytogenes and Staphylococcus aureus in cuajada, a semisolid dairy product manufactured in Spain

The inhibitory activity of nisin (N), reuterin (R), and the lactoperoxidase system (LPS), added individually or in combination, against Listeria monocytogenes and Staphylococcus aureus was investigated in “cuajada” (curdled milk), a semisolid dairy product manufactured in Spain. Cuajada was manufactured from UHT skim milk separately inoculated with L. monocytogenes and Staph. aureus, each at approximately 4 log cfu/mL, and held under conditions of temperature abuse (10°C). On d 3, a synergistic bactericidal activity was observed for the combinations of biopreservatives assayed, with L. monocytogenes counts of only 0.30 log cfu/mL in cuajada made with N + R + LPS vs. 8.31 log cfu/mL in control cuajada. After 12 d, L. monocytogenes could not be detected in cuajada made with added N + LPS or N + R + LPS. Staphylococcus aureus was more resistant than L. monocytogenes to biopreservatives added individually. On d 3, the synergistic effect of the 3 biopreservatives against Staph. aureus resulted in counts of 3.03 log cfu/mL in cuajada made with N + R + LPS vs. 6.40 in control cuajada. After 12 d, Staph. aureus counts were 2.61 log cfu/mL in cuajada made with N + R + LPS, whereas they ranged from 6.11 to 7.70 log cfu/mL in control cuajada and in cuajada made with other combinations of biopreservatives. The most pronounced decrease in pathogen counts was achieved by the triple combination N + R + LPS, which acted synergistically on the inactivation of L. monocytogenes and Staph. aureus in cuajada over 12 d at 10°C. The treatment combining these 3 natural biopreservatives at low concentrations, within the hurdle concept of food preservation, might be a useful tool to control the growth of pathogenic microorganisms in nonacidified dairy products.     

Direct application of supercritical carbon dioxide for the reduction of Cronobacter spp. (Enterobacter sakazakii) in end products of dehydrated powdered infant formula

The objective of this study was to develop a viable new method for inactivation of Cronobacter spp. that could be applied directly to dehydrated powdered infant formula (PIF) using supercritical carbon dioxide (SC-CO₂). Samples inoculated with Cronobacter spp. were subjected to SC-CO₂ treatment under various conditions (temperature: 63, 68, and 73°C; pressure: 15, 20, and 25 MPa; time: 10, 20, and 30 min). The survival of Cronobacter spp. was assayed, as were any changes in the quality of the treated PIF. Inactivation of Cronobacter spp. by SC-CO₂ was enhanced as temperature and pressure conditions increased (>6.32 log₁₀ cfu/g). In a validation assay using low-level inoculation (3.21 log₁₀ cfu/g), treatment at 73°C and 15 MPa for 30 min, 20 MPa for 20 and 30 min, or 25 MPa for 20 and 30 min reduced Cronobacter spp. to undetectable levels, with no recovery of cell viability. There was no significant change in water activity, pH, and color of the treated PIF. Overall, the optimum conditions for elimination of Cronobacter spp. were determined to be 73°C and 20 MPa for 20 min. These parameters for effective SC-CO₂ treatment are feasibly applicable to end product of dehydrated PIF. The results of our study may contribute to the development of an efficient method for improving the microbiological safety of PIF.     

Heat-treatment of bovine colostrum. II: effects of heating duration on pathogen viability and immunoglobulin G

Batches (30-L) of first-milking bovine colostrum, inoculated with Mycoplasma bovis (10⁸ cfu/mL), Listeria monocytogenes (10⁶ cfu/mL), Escherichia coli O157:H7 (10⁶ cfu/mL), Salmonella enteritidis (10⁶ cfu/mL), and Mycobacterium avium subsp. paratuberculosis (Map; 10³ cfu/mL), were heat-treated at 60°C for 120 min in a commercial on-farm batch pasteurizer system. Duplicate 50-mL subsamples of colostrum were collected at 15-min intervals throughout the heat-treatment process for the purpose of bacterial culture and for measurement of IgG concentration (mg/mL) and antibody activity [log₂(bovine viral diarrhea virus type 1 serum neutralization titer)]. Four replicate batches of colostrum were run for each of the 5 pathogens studied. There was no effect of heating moderate- to high-quality colostrum at 60°C for at least 120 min on mean IgG concentration (pre = 60.5 mg/mL; post = 59.1 mg/mL). Similarly, there was no effect of heat-treatment on the mean log₂ bovine viral diarrhea virus type 1 serum neutralization titer (pre = 12.3; post = 12.0). Viable M. bovis, L. monocytogenes, E. coli O157:H7, and S. enteritidis added to colostrum could not be detected after the colostrum was heat-treated at 60°C for 30 min. Average bacteria counts showed that Map was not detected when batches were heated at 60°C for 60 min. Although the authors believe that heat-treating colostrum at 60°C for 60 min should be sufficient to eliminate Map from colostrum in most situations, further research is needed to determine whether these findings may be replicated, given that variability was observed in Map culture results.     

Antimicrobial activity of acid-hydrolyzed Citrus unshiu peel extract in milk

Citrus fruit (Citrus unshiu) peels were extracted with hot water and then acid-hydrolyzed using hydrochloric acid. Antimicrobial activities of acid-hydrolyzed Citrus unshiu peel extract were evaluated against pathogenic bacteria, including Bacillus cereus, Staphylococcus aureus, and Listeria monocytogenes. Antilisterial effect was also determined by adding extracts at 1, 2, and 4% to whole, low-fat, and skim milk. The cell numbers of B. cereus, Staph. aureus, and L. monocytogenes cultures treated with acid-hydrolyzed extract for 12 h at 35°C were reduced from about 8 log cfu/mL to <1 log cfu/mL. Bacillus cereus was more sensitive to acid-hydrolyzed Citrus unshiu peel extract than were the other bacteria. The addition of 4% acid-hydrolyzed Citrus unshiu extracts to all types of milk inhibited the growth of L. monocytogenes within 1 d of storage at 4°C. The results indicated that Citrus unshiu peel extracts, after acid hydrolysis, effectively inhibited the growth of pathogenic bacteria. These findings indicate that acid hydrolysis of Citrus unshiu peel facilitates its use as a natural antimicrobial agent for food products.     

Pilot-scale crossflow-microfiltration and pasteurization to remove spores of Bacillus anthracis (Sterne) from milk

High-temperature, short-time pasteurization of milk is ineffective against spore-forming bacteria such as Bacillus anthracis (BA), but is lethal to its vegetative cells. Crossflow microfiltration (MF) using ceramic membranes with a pore size of 1.4 μm has been shown to reject most microorganisms from skim milk; and, in combination with pasteurization, has been shown to extend its shelf life. The objectives of this study were to evaluate MF for its efficiency in removing spores of the attenuated Sterne strain of BA from milk; to evaluate the combined efficiency of MF using a 0.8-μm ceramic membrane, followed by pasteurization (72°C, 18.6 s); and to monitor any residual BA in the permeates when stored at temperatures of 4, 10, and 25°C for up to 28 d. In each trial, 95 L of raw skim milk was inoculated with about 6.5 log₁₀ BA spores/mL of milk. It was then microfiltered in total recycle mode at 50°C using ceramic membranes with pore sizes of either 0.8 μm or 1.4 μm, at crossflow velocity of 6.2 m/s and transmembrane pressure of 127.6 kPa, conditions selected to exploit the selectivity of the membrane. Microfiltration using the 0.8-μm membrane removed 5.91 ± 0.05 log₁₀ BA spores/mL of milk and the 1.4-μm membrane removed 4.50 ± 0.35 log₁₀ BA spores/mL of milk. The 0.8-μm membrane showed efficient removal of the native microflora and both membranes showed near complete transmission of the casein proteins. Spore germination was evident in the permeates obtained at 10, 30, and 120 min of MF time (0.8-μm membrane) but when stored at 4 or 10°C, spore levels were decreased to below detection levels (≤0.3 log₁₀ spores/mL) by d 7 or 3 of storage, respectively. Permeates stored at 25°C showed coagulation and were not evaluated further. Pasteurization of the permeate samples immediately after MF resulted in additional spore germination that was related to the length of MF time. Pasteurized permeates obtained at 10 min of MF and stored at 4 or 10°C showed no growth of BA by d 7 and 3, respectively. Pasteurization of permeates obtained at 30 and 120 min of MF resulted in spore germination of up to 2.42 log₁₀ BA spores/mL. Spore levels decreased over the length of the storage period at 4 or 10°C for the samples obtained at 30 min of MF but not for the samples obtained at 120 min of MF. This study confirms that MF using a 0.8-μm membrane before high-temperature, short-time pasteurization may improve the safety and quality of the fluid milk supply; however, the duration of MF should be limited to prevent spore germination following pasteurization.     

Response of two Salmonella enterica strains inoculated in model cheese treated with high hydrostatic pressure

The aim of this work was to determine the response to high hydrostatic pressure and the ability for survival, recovery, and growth of 2 strains of Salmonella enterica (Salmonella enteritidis and Salmonella typhimurium) inoculated in a washed-curd model cheese produced with and without starter culture. Inoculated samples were treated at 300 and 400 MPa for 10 min at room temperature and analyzed after treatment and after 1, 7, and 15 d of storage at 12° C to study the behavior of the Salmonella population. Cheese samples produced with starter culture and treated at 300 and 400 MPa showed maximum lethality; no significant differences in the baroresistant behavior of both strains were detected. Nevertheless, when starter culture was not present, the maximum lethality was only observed in cheese samples treated at 400 MPa, in the case of S. enteritidis. Ability to repair and grow was not observed in model cheese produced with starter culture and cell counts of treated samples decreased after 15 d of storage at 12° C. In cheese produced without starter culture, Salmonella cells showed the ability to repair and grow during the storage period, reaching counts over 3 log₁₀ (cfu/mL) in both applied treatments and serotypes. These results suggest that high hydrostatic pressure treatments are effective to reduce Salmonella population in this type of cheese, but the presence of the starter culture affects the ability of this microorganism to repair and grow during the storage period.