Efficacy of egg cleaning compounds on eggshells contaminated with Salmonella enterica serovar Enteritidis

Salmonella Enteritidis infections of egg contents can be related to external contamination of the shell. In this study, the efficacy of three commercial cleaning and/or sanitizing compounds (sodium carbonate, sodium hypochlorite, and potassium hydroxide) was evaluated for bactericidal activity at pH values of 10, 11, and 12 against various concentrations (10(2), 10(4), or 10(6) CFU/ml) of Salmonella Enteritidis inoculated onto the eggshell surface. Efficacy of these chemical agents was also assessed against Salmonella Enteritidis in aqueous suspension. Our results indicated that none of the chemicals applied at the recommended manufacturer's concentrations (sodium carbonate, 36 ppm; other treatments, 200 ppm) could eliminate Salmonella Enteritidis from eggshells artificially contaminated with the highest bacterial concentrations (10(4) or 10(6) CFU/ml). Higher concentrations of each product, at least 5 to 20 times greater than recommended doses, were needed to destroy the bacteria on egg surfaces. However, at or slightly above the manufacturer's recommended use concentrations, all three formulations were effective against Salmonella Enteritidis in aqueous suspension (10(8) CFU/ml) or on eggshells contaminated with 10(2) CFU/ml. For both shell and suspension assays, inactivation of Salmonella Enteritidis occurred at lower concentrations at pH 12 than at pH 11 and 10. Contact time between chemicals and Salmonella apparently influenced bacterial inactivation. Extended contact times (2 to 10 min) reduced minimum chemical concentrations necessary to inactivate the bacteria. However, neither pH nor contact time influenced Salmonella Enteritidis inactivation when the initial bacterial numbers on eggshells were high.     

Incubation of egg contents pools at an elevated temperature (42 degrees C) does not improve the rapid detection of Salmonella enteritidis phage type 14b

Detecting internal Salmonella Enteritidis (SE) contamination in eggs is essential for protecting public health. Pooling together > or = 10 eggs for sampling allows many eggs to be screened for contamination, but such pools must be incubated (usually at 25 to 37 degrees C) to permit small numbers of SE to multiply before further testing. The present study determined whether incubating egg contents pools at an elevated temperature (42 degrees C) could increase the rate of multiplication of a phage type 14b strain of SE sufficiently to support the detection of contamination by a rapid lateral flow immunodiffusion method within a single day. Pools of 10 eggs were contaminated with approximately 10 CFU of SE, supplemented with concentrated broth enrichment medium, and incubated at either 37 or 42 degrees C. Incubation of contaminated egg pools at 42 degrees C resulted in significantly higher SE levels after 6, 8, 10, and 12 h. However, incubation at 42 degrees C could only generate a mean log SE concentration of 4.21 CFU/ml within a single working day (8 h), inadequate to support efficient detection by most rapid assays. Detection of SE contamination in egg pools by a rapid lateral flow immunodiffusion test was not achieved at a high frequency until 12 h of incubation at 42 degrees C.     

Standardized laboratory-scale preparation of mayonnaise containing low levels of Salmonella enterica serovar Enteritidis

Salmonella enterica serovar Enteritidis PT4 and PT6 are associated with food poisoning outbreaks and are often found in food only in low concentrations. In this study a reproducible laboratory-scale procedure for preparation of mayonnaise is presented. The mayonnaise that simulates a naturally low-level contaminated product can be used for validation of new methods and is also suitable to study the behavior of low numbers of food pathogenic spoilage microorganisms in a food environment. During processing, liquid egg was artificially contaminated with low levels of S. enterica serovar Enteritidis that resulted in levels of 1 to 3 log10 CFU/g in the final mayonnaise. Cells of S. enterica serovar Enteritidis had increased stability in the mayonnaise when they were subjected to low pH in two stages, first to pH 5.8 and afterward to pH 4.5 before addition to the mayonnaise. The pH of the mayonnaise was between 4.2 to 4.5 and remained stable over the storage period. Low-level S. enterica serovar Enteritidis remained stable in artificially contaminated mayonnaise for 4 weeks at 4 degrees C.     

Eggshell penetration of various types of hens' eggs by Salmonella enterica serovar Enteritidis

Egg weight, shell thickness, number of pores, cuticle deposition, eggshell strength (dynamic stiffness and damping ratio), and the ability of Salmonella enterica serovar Enteritidis (SE) to penetrate the eggshell were determined. Penetration was assessed by filling the eggs with a selective medium that allowed viewing of Salmonella growth on the inside of the shell and membrane complex. After inoculation of each shell with on average 2.71 log CFU, the eggs were stored for up to 14 days at 20 degrees C and 60% relative humidity. Commercially available eggs were used. At 14 days of storage, only 6.0% of the eggs from free-range hens and 16.0% of the generic (i.e., eggs from hens in conventional battery cages that were given standard feed) white eggs were penetrated. The generic brown, organic, and omega-3-enriched eggs were penetrated at a frequency of 30 to 34%. In a second experiment it was shown that the layer strains of the hen (ISA-Brown Warren versus Bovans Goldline), which were kept in furnished cages, did not affect eggshell penetration by SE. For Bovans Goldline hens, the housing system (furnished cage versus aviary) did not affect penetration, while a trend was visible toward a higher fraction of penetrated eggshells when hens were fed corncob mix rather than standard feed. Eggshell penetration was observed more frequently in the absence of cuticle spots and for eggs having lower dynamic stiffness values. Shell contamination at the end of storage was highly correlated with SE penetration.     

Protective action of Lactobacillus kefir carrying S-layer protein against Salmonella enterica serovar Enteritidis

Eight Lactobacillus kefir strains isolated from different kefir grains were tested for their ability to antagonize Salmonella enterica serovar Enteritidis (Salmonella enteritidis) interaction with epithelial cells. L. kefir surface properties such as autoaggregation and coaggregation with Salmonella and adhesion to Caco-2/TC-7 cells were evaluated. L. kefir strains showed significantly different adhesion capacities, six strains were able to autoaggregate and four strains coaggregated with Salmonella. Coincubation of Salmonella with coaggregating L. kefir strains significantly decreased its capacity to adhere to and to invade Caco-2/TC-7 cells. This was not observed with non coaggregating L. kefir strains. Spent culture supernatants of L. kefir contain significant amounts of S-layer proteins. Salmonella pretreated with spent culture supernatants (pH 4.5-4.7) from all tested L. kefir strains showed a significant decrease in association and invasion to Caco-2/TC-7 cells. Artificially acidified MRS containing lactic acid to a final concentration and pH equivalent to lactobacilli spent culture supernatants did not show any protective action. Pretreatment of this pathogen with spent culture supernatants reduced microvilli disorganization produced by Salmonella. In addition, Salmonella pretreated with S-layer proteins extracted from coaggregating and non coaggregating L. kefir strains were unable to invade Caco-2/TC-7 cells. After treatment, L. kefir S-layer protein was detected associated with Salmonella, suggesting a protective role of this protein on association and invasion.     

Inactivation of Salmonella enterica serovar Enteritidis on shell eggs by ozone and UV radiation

The presence of Salmonella enterica serovar Enteritidis in shell eggs has serious public health implications. Several treatments have been developed to control Salmonella on eggs with mixed results. Currently, there is a need for time-saving, economical, and effective egg sanitization treatments. In this study, shell eggs externally contaminated with Salmonella (8.0 x 10(5) to 4.0 x 10(6) CFU/g of eggshell) were treated with gaseous ozone (O3) at 0 to 15 lb/in2 gauge for 0 to 20 min. In other experiments, contaminated shell eggs were exposed to UV radiation at 100 to 2,500 microW/cm2 for 0 to 5 min. Treatment combination included exposing contaminated eggs to UV (1,500 to 2,500 microW/cm2) for 1 min, followed by ozone at 5 lb/in2 gauge for 1 min. Eggs that were (i) noncontaminated and untreated, (ii) contaminated and untreated, and (iii) contaminated and treated with air were used as controls. Results indicated that treating shell eggs with ozone or UV, separately or in combination, significantly (P < 0.05) reduced Salmonella on shell eggs. For example, contaminated eggs treated with ozone at 4 to 8 degrees C and 15 lb/in2 gauge for 10 min or with UV (1,500 to 2,500 microW/cm2) at 22 to 25 degrees C for 5 min produced 5.9- or 4.3-log microbial reductions or more, respectively, when compared with contaminated untreated controls. Combinations including UV followed by ozone treatment resulted in synergistic inactivation of Salmonella by 4.6 log units or more in about 2 min of total treatment time. Salmonella was effectively inactivated on shell eggs in a short time and at low temperature with the use of a combination of UV radiation and ozone.     

Growth of Salmonella enterica serovar Enteritidis in albumen and yolk contents of eggs inoculated with this organism onto the vitelline membrane

By using an in vitro model simulating the potential opportunities for Salmonella enterica serovar Enteritidis (SE) to proliferate within eggs contaminated with this organism following oviposition, we investigated growth of SE in eggs. Seventy to 140 CFU of one of three SE strains originating either from egg contents, chicken meat, or a human infection were experimentally inoculated onto the vitelline membrane of eggs collected from specific-pathogen-free flocks of chickens and incubated at 25 degrees C. SE organisms were detected in 6 of 71 yolk contents of the eggs inoculated with any of the test strains attaining levels ranging from 2.0 x 10(2) to 4.2 x 10(8) CFU/ml by day 6. The organisms were also detected in the albumen from 38 of 55 eggs tested, growing to levels ranging from 1.0 x 10(2) to 4.3 x 10(8) CFU/ml by day 6 after inoculation. An additional three yolk contents and 15 albumen samples were culture positive for SE following enrichment. There was no correlation between the number of the organisms in the yolk contents and that in the albumen from each of the eggs. When 73 to 91 CFU of the egg strain were inoculated into samples of separated albumen obtained from eggs that were stored at 4 degrees C for 1 to 4 weeks or at 25 degrees C for 1 week, slight growth (3.0 x 10(2) to 7.4 x 10(3) CFU/ml) was found in only 3 of the 60 albumen samples by day 6 after inoculation, but the organisms were recovered from 52 samples following enrichment. The results suggest that the environment on or near the vitelline membrane can be conducive to SE proliferation over time.     

Effect of thermoultrasonication on Salmonella enterica serovar Enteritidis in distilled water and intact shell eggs

The combined effects of simultaneous application of ultrasonic waves and heat treatment (thermoultrasonication) on the survival of a strain of Salmonella enterica Enteritidis was studied in both distilled water and intentionally contaminated intact eggs immersed in water. Although minor differences were observed between parameters obtained for thermoultrasonic treatment of bacteria suspended in water and those attached to the shell egg, the thermoultrasonication effects were considered to be of the same level in the range of temperatures assayed (52 to 58 degrees C). This combined process presented a clearly higher killing effect than the heat treatment alone. It decreased the decimal reduction times (D-values) by 80 to 55%, respectively, in the range of temperatures for heat treatment when the organism was suspended in water, which means a 99.5% reduction (5D to >2D) of the original bacterial load versus a 90% reduction for the heat treatment alone. The practical implications of the phenomenon are discussed.     

Survival, elongation, and elevated tolerance of Salmonella enterica serovar Enteritidis at reduced water activity

Growing microorganisms on dry surfaces, which results in exposure to low water activity (a(w)), may change their normal morphology and physiological activity. In this study, the morphological changes and cell viability of Salmonella enterica serovar Enteritidis challenged to low a(w) were analyzed. The results indicated that exposure to reduced a(w) induced filamentation of the cells. The amount of filamentous cells at a(w) 0.94 was up to 90% of the total number of cells. Surviving filamentous cells maintained their membrane integrity after exposure to low a(w) for 21 days. Furthermore, cells prechallenged to low a(w), obtained with an ionic humectant, demonstrated higher resistance to sodium hypochlorite than control cells. These resistant cells are able to survive disinfection more efficiently and can therefore cause contamination of foods coming in contact with surfaces. This points to the need for increased attention to cleaning of surfaces in household environments and disinfection procedures in processing plants.     

Architectural adaptation and protein expression patterns of Salmonella enterica serovar Enteritidis biofilms under laminar flow conditions

Salmonella enterica serovar Enteritidis is a significant biofilm-forming pathogen. The influence of a 10-fold difference in nutrient laminar flow velocity on the dynamics of Salmonella Enteritidis biofilm formation and protein expression profiles were compared in order to ascertain how flow velocity influenced biofilm structure and function. Low-flow (0.007 cm s(-1)) biofilms consisted of diffusely-arranged microcolonies which grew until merging by approximately 72 h. High-flow (0.07 cm s(-1)) biofilms were significantly thicker (36+/-3 microm (arithmetic mean+/-standard error; n=225) versus 16+/-2 microm for low-flow biofilms at 120 h) and consisted of large bacterial mounds interspersed by water channels. Lectin-binding analysis of biofilm exopolymers revealed a significantly higher (P<0.05) proportion of N-acetylgalactosamine (GalNAc) in low-flow biofilms (55.2%), relative to only 1.2% in high-flow biofilms. Alternatively, the proportions of alpha-L-fucose and N-acetylglucosamine (GlcNAc2)-N-acetylneuraminic acid (NeuNAc) polymer-conjugates were significantly higher (P<0.05) in high-flow biofilms (69.1% and 29.6%, respectively) than low-flow biofilms (33.1% and 11.7%, respectively). Despite an apparent flow rate-based physiologic effect on biofilm structure and exopolymer composition, no major shift in whole-cell protein expression patterns was seen between 168 h-old low-flow and high-flow biofilms, and notably did not include any response involving the stress response proteins, DnaK, SodB, and Tpx. Proteins involved in degradation and energy metabolism (PduA, GapA, GpmA, Pgk, and RpiA), RNA and protein biosynthesis (Tsf, TufA, and RpoZ), cell processes (Crr, MalE, and PtsH), and adaptation (GrcA), and some hypothetical proteins (YcbL and YnaF) became up-regulated in both biofilm systems relative to a 168 h-old planktonic cell control. Our results indicate that Salmonella Enteritidis biofilms altered their structure and extracellular glycoconjugate composition in response to flow and this response is suggested to be significant in the survival of this pathogen as biofilms.     

Influence of eggshell condensation on eggshell penetration and whole egg contamination with Salmonella enterica serovar enteritidis

Shells of agar-filled and whole eggs were inoculated with 10(3) to 10(4) CFU of Salmonella enterica serovar Enteritidis per eggshell. The agar-filled eggs were used to study bacterial eggshell penetration, and the whole egg results were used to characterize contamination of the egg contents. In each group, half of the eggs were stored for 21 days at 20 degrees C and 60% relative humidity (RH), and the other half was stored for 24 h at 6 degrees C and then for 20 days at 20 degrees C. The latter conditions resulted in condensation on the eggshell for 30 min from the moment the eggs were placed in the 20 degrees C chamber. Taking into account the ages at which hens were studied (39, 53, and 67 weeks), an average of 62% of the eggshells with condensate were penetrated compared with 43% for the control group; this difference was significant (P < 0.01). No significant difference in whole egg contamination was found; 18% of the control eggs were contaminated compared with 22% of the condensate eggs. Whole egg contamination was significantly higher for eggs from the hens at an older age (67 weeks). This difference probably was not due to a higher penetration potential because differences were not observed for the corresponding agar-filled eggs. Condensation on the eggshell seemed to encourage bacterial penetration of the eggshell but had a smaller impact on whole egg contamination.     

A pulsed field gel electrophoresis (PFGE) study that suggests a major world-wide clone of Salmonella enterica serovar Enteritidis

Since human infections by Salmonella enterica serovar Enteritidis (Salmonella Enteritidis) have been increasing world-wide over the past years and epidemiological studies have implicated the consumption of meat, poultry, eggs and egg products, elucidation of the predominant subtypes for this Salmonella spp. is important. In this study, 107 poultry and food isolates of Salmonella Enteritidis obtained from Germany were analyzed by pulsed field gel electrophoresis (PFGE), and the subtypes were compared with those of the 124 human isolates obtained in Taiwan. Results showed that for these 107 poultry and food isolates, when XbaI, SpeI and NotI were used for chromosomal DNA digestion followed by PFGE analysis, a total of 19, 20 and 19 PFGE patterns, respectively, were identified. Of them, 51 (47.7%), 52 (48.6%) and 42 (39.3%) strains belong to a single pattern of X3, S3 and N3, respectively, and 34 strains belong to a pattern combination of X3S3N3, which was the major subtype. When PFGE patterns of these 107 German isolates were compared with those of the 124 human isolates obtained in Taiwan, pattern combination of X3S3N3 was found as the most common pattern shared by isolates from both areas. PT4 is a major phage type for German and Taiwan isolates. Although most of the X3S3N3 strains are of this phage type, some strains of other PFGE patterns are also of this phage type. Since strains used in this study were unrelated, i.e., they were isolated from different origins in areas geographically far apart from each other, the PFGE study suggests a major world-wide clone of S. enterica serovar Enteritidis.     

Purified beta-glucan as an abiotic feed additive up-regulates the innate immune response in immature chickens against Salmonella enterica serovar Enteritidis

Functionally, the innate immune system of immature chickens is inefficient during the first week posthatch. This immunological inefficiency enables pathogens such as Salmonella enterica serovar Enteritidis (SE) to invade and colonize the visceral organs of immature chickens. The objective of this study was to evaluate the effect of purified beta-glucan as an immunomodulator of the innate immune response. beta-glucan, as a feed additive, significantly provided protection against SE organ invasion in young chickens (P<0.05). The functional efficiency of heterophils isolated from neonatal chickens fed a beta-glucan ration was significantly (P<0.05) up-regulated when compared to heterophils isolated from chickens fed a control ration as determined with an array of functional assays. Phagocytosis, bactericidal killing, and oxidative burst were significantly increased in heterophils isolated from chickens fed the purified beta-glucan ration (P<0.05). To our knowledge, this is the first report of a purified beta-glucan feed additive significantly decreasing the incidence of SE organ invasion in immature chickens and up-regulating the functional abilities of heterophils isolated from immature chickens against an invading pathogen, SE.     

Propylparaben sensitizes heat-resistant Salmonella Enteritidis and Salmonella Oranienburg to thermal inactivation in liquid egg albumen

Propyl p-hydroxybenzoic acid (propylparaben [PRPA]) is a phenolic antioxidant, known to occur in nature and used as a microbiostat in foods, feeds, pharmaceuticals, cosmetics, and medications. The U.S. Department of Agriculture, Food Safety and Inspection Service (FSIS) requires that liquid egg white (LEW) be pasteurized at 56.7°C for 3.5 min. This study evaluated the effects of PRPA on the pasteurization sensitivity of Salmonella in LEW. When LEW (pH 7.8) was pasteurized under FSIS conditions, salmonellae declined by 0.5, 4.6, 4.5, > 7.0, and > 7.0 log CFU/ml, with 0, 125, 250, 500, or 1,000 ppm of PRPA, respectively, and D(56.7°C)-values were 2.99, 1.05, 0.68, 0.26 and ≤0.16 min. Albumen (pH 8.9) pasteurized under FSIS standards incurred salmonellae reductions of 3.3, 2.8, 5.2, > 7.0, and > 7.0 log CFU/ml, with 0, 125, 250, 500, or 1,000 ppm of PRPA, respectively, while D(56.7°C)-values were 0.87, 0.99, 0.66, 0.22, and 0.09 min. Adding 500 ppm of PRPA to albumen (pH 7.8) reduced D(56.7°C)-values more than 11-fold, and reduced the time to achieve a 5-log reduction from 15.0 to only 1.3 min. A 7-log reduction in plain LEW (pH 7.8) at 56.7°C required 20.9 min, versus only 1.8 and 1.1 min with 500 and 1,000 ppm of PRPA, respectively. Furthermore, a 7-log reduction in plain LEW (pH 8.9) required 6.1 min, versus only 1.5 and 0.6 min with 500 and 1,000 ppm of PRPA, respectively. This study is the first to report the efficacy of PRPA (pK(a) = 8.4) in sensitizing Salmonella in LEW to thermal pasteurization, while documenting that PRPA retains its antibacterial efficacy at pH levels as high as 8.9.     

S．Heidelberg血清型特异性基因筛选及PCR检测方法的建立与应用

海德尔堡沙门氏菌(Salmonella enterica serovar Heidelberg,SH)是沙门氏菌属内重要的致病性血清型。通过对SH基因组序列进行BLAST比对和PCR验证,筛选出了4个SH血清型特异性基因(SeHA_C2639、SeHA_C2640、SeHA_C3259和SeHA_C3258)。以SeHA_C3258作为靶点设计引物pHAm8(350bp)和沙门氏菌属特异性引物139-141(284bp),建立SH的PCR检测方法,并对其应用效果进行评价。结果表明,经55株不同血清型的沙门氏菌和其他常见食源性致病菌证明,该检测体系具有较好的特异性,纯菌菌落灵敏度为6.1×10~2 CFU/mL。以浓度为N×10~5~N×10~1 CFU/mL的大肠杆菌或鼠伤寒沙门氏菌为干扰菌时,该体系对10~2 CFU/mL的SH检测结果无影响。人工污染SH的牛奶样品,经8h培养,检测限达1.52CFU/mL。该检测方法能快速、准确检测出食品中的SH,有利于在食品安全领域中的应用。     

Microfluidic rapid quantification of Salmonella enterica serovar Typhimurium collected from chicken meat using immunomagnetic separation after formaldehyde treatment

Foodborne pathogens such as Salmonella enterica serovar Typhimurium, which cause self-limiting gastroenteritis, are important in food safety and public health. Detection of Salmonella in complex food matrices is required for rapid and effective monitoring of contaminated food products. In this study, we collected Salmonella Typhimurium in chicken using immunomagnetic separation after formaldehyde treatment. Collected Salmonella Typhimurium cells were then quantified microfluidic device or fluorescence microscopy. The recovery ratio obtained with immunomagnetic separation after formaldehyde treatment was 77 (±5)% for the microscope count and 63 (±9)% for the microfluidic count. According to the fluorescence microscope images, the food matrix was effectively removed from the collected cell suspension. The counts of Salmonella Typhimurium cells obtained by the microfluidic device and fluorescence microscope were closely correlated (R² = 0.993) with a range of 3.3 (±0.5) × 10³ to 1.2 (±0.5) × 10⁶ cells g⁻¹. Our method provides quantitative detection of Salmonella Typhimurium within 3–4 h and could be used to efficiently evaluate microbial risk of quality control of foodstuffs and prevention of foodborne disease.     

Prevalence and characterization of Salmonella enterica serovar Weltevreden from imported seafood

During 2001-2005, 210 Salmonella enterica strains were isolated from seafood samples imported into US. Strains of S. enterica serovar Weltevreden were the most predominantly found among the 64 different serovars isolated. A total of 37 Salmonella Weltevreden isolates were characterized by pulsed-field gel electrophoresis (PFGE), plasmid profiles and antibiotic susceptibility to assess genetic diversity. Our results showed a low frequency of antibiotic resistance; 35 of the 37 isolates were sensitive to ampicillin, tetracycline, chloramphenicol, gentamicin, sulfisoxazole, streptomycin and kanamycin. Only two isolates, from samples originating in the Philippines and India, showed resistance to ampicillin and tetracycline and to streptomycin, sulfisoxazole and tetracycline, respectively. Of the 37 isolates, two isolates did not carry any plasmid and 35 isolates harbored several small and mega-plasmids. These isolates were differentiated into 10 distinct types based on plasmid profiles. Four different PFGE clusters were obtained with a genetic similarity of 66-76%. Four groups of isolates (formed by two or three isolates each) showed 100% similarity in the PFGE profiles. One of these groups included strains isolated in Vietnam in 2003, 2004 and 2005 from fish and shrimp. The other groups included strains isolated in Vietnam, Indonesia and Thailand in 2000, 2004 and 2005 from snail, shrimp and fish. Our findings show genetic diversity and temporal persistence of S. enterica serovar Weltevreden in recently monitored seafood imports.