Smearing of soft cheese with Enterococcus faecium WHE 81, a multi-bacteriocin producer,against Listeria monocytogenes

Enterococcus faecium WHE 81, a multi-bacteriocin producer, was tested for its antimicrobial activity on Listeria monocytogenes in Munster cheese, a red smear soft cheese. The naturally delayed and superficial contamination of this type of cheese allowed the use of E. faecium WHE 81 at the beginning of the ripening as a surface culture. A brine solution inoculated at 10⁵ CFU of E. faecium WHE 81 per mL was sprayed on the cheese surface during the first smearing operation. On day 7, smearing of cheese samples with a brine solution at 10² CFU of L. monocytogenes per mL yielded initial cell counts of approximately 50 CFU g⁻¹ of the pathogen on the cheese surface. Although, in some instances, L. monocytogenes could survive (<50 CFU g⁻¹) in the presence of E. faecium WHE 81, it was unable to initiate growth. In control samples however, L. monocytogenes counts often exceeded 10⁴ CFU g⁻¹. In other respects, E. faecium WHE 81, which naturally existed in Munster cheese, did not adversely impact on the ripening process.     

Combined pH and high hydrostatic pressure effects on Lactococcus starter cultures and Candida spoilage yeasts in a fermented milk test system during cold storage

The combined effects of high pressure processing (HPP) and pH on the glycolytic and proteolytic activities of Lactococcus lactis subsp. lactis, a commonly used cheese starter culture and the outgrowth of spoilage yeasts of Candida species were investigated in a fermented milk test system. To prepare the test system, L. lactis subsp. lactis C10 was grown in UHT skim milk to a final pH of 4.30 and then additional samples for treatment were prepared by dilution of fermented milk with UHT skim milk to pH levels of 5.20 and 6.50. These milk samples (pH 4.30, 5.20 and 6.50) with or without an added mixture of two yeast cultures, Candida zeylanoides and Candida lipolytica (10⁵ CFU mL⁻¹ of each species), were treated at 300 and 600 MPa (≤20 °C, 5 min) and stored at 4 °C for up to 8 weeks. Continuing acidification by starter cultures, as monitored during storage, was substantially reduced in the milk pressurised at pH 5.20 where the initial titratable acidity (TA) of 0.40% increased by only 0.05% (600 MPa) and 0.10% (300 MPa) at week 8, compared to an increase of 0.30% in untreated controls. No substantial differences were observed in pH or TA between pressure-treated and untreated milk samples at pH 4.30 or 6.50. The rate of proteolysis in milk samples at pH values of 5.20 and 6.50 during storage was significantly reduced by treatment at 600 MPa. Treatment at 600 MPa also reduced the viable counts of both Candida yeast species to below the detection limit (1 CFU mL⁻¹) at all pH levels for the entire storage period. However, samples treated at 300 MPa showed recovery of C. lipolytica from week 3 onwards, reaching 10⁶–10⁷ CFU mL⁻¹ by week 8. In contrast, C. zeylanoides did not show any recovery in any of the pressure-treated samples during storage.     

Evaluation of a chitosan-based edible film as carrier of natamycin to improve the storability of Saloio cheese

The purpose of this study was to evaluate the effects of the application of chitosan coating containing natamycin on the physicochemical and microbial properties of semi-hard cheese. Three cheese groups were prepared: samples without coating, samples coated with chitosan and with chitosan containing 0.50 mg mL⁻¹ of natamycin, whose minimum inhibitory concentration was previously determinated on cheese surface. Microbiological analyses showed that natamycin coated samples presented a decrease on moulds/yeasts of 1.1 log (CFU g⁻¹) compared to control after 27 days of storage. Addition of natamycin also affected O₂ and CO₂ permeability, increasing from 7.12 to 7.68 × 10⁻¹⁵ g·(Pa s m)⁻¹, and from 10.69 to 64.58 × 10⁻¹⁴ g·(Pa s m)⁻¹, respectively. The diffusion coefficient values of natamycin from the film to phosphate buffered saline solution and to the cheese were 3.60 × 10⁻¹⁰ and 1.29 × 10⁻¹² cm² s⁻¹, respectively. This study demonstrated that chitosan-based coating/films can be used as release system containing natamycin to create an additional hurdle for moulds/yeasts in cheese thus contributing to extend its shelf-life.     

Effect of calcium alginate and resistant starch microencapsulation on the survival rate of Lactobacillus acidophilus La5 and sensory properties in Iranian white brined cheese

Two types of probiotic cheese, with free and microencapsulated bacteria, were manufactured in triplicate under the same conditions. The number of viable cells during 182 days of storage in refrigerated conditions was evaluated. The number of viable cells of Lactobacillus acidophilus was reduced significantly from day 28 to day 182 of storage period in both types of cheese, but reduction in the cheese containing free cells (5.1 ± 0.67 log cfu g⁻¹) was significantly p < 0.05 higher than the cheese containing microencapsulated cells (11.00 ± 0.58 log cfu g⁻¹). The results showed that, microencapsulation in calcium alginate gel and resistant starch was able to increase the survival rate of L. acidophilus La5 in Iranian white brined cheese after 6 months of storage.     

Loss of viability of Listeria monocytogenes in contaminated processed cheese during storage at 4, 12 and 22 °C

The behaviour of Listeria monocytogenes in a processed cheese product was evaluated over time by inoculating the product with three different L. monocytogenes strains (Scott A, CA and a strain isolated from processed cheese) at three different inoculation levels (ca. 6 × 10⁵, ca. 6 × 10³ and 10² CFU/g of cheese or less) and after storage of the contaminated products at 4, 12 or 22 °C. Growth of L. monocytogenes was not observed in any of the experimental trials (experiments involving different combinations of strain, inoculum level and storage temperature) throughout the storage period. L. monocytogenes populations decreased over time with a rate that was strain- and storage temperature-dependent. Nonetheless, for cheeses that had been inoculated with the higher inoculum and stored at 4 °C viable populations of L. monocytogenes could be detected for up to nine months post-inoculation. The L. monocytogenes survival curves obtained from the different trials were characterised by a post-inoculation phase during which the populations remained essentially unchanged (lag phase) followed by a phase of logarithmic decline. The duration of the lag phase and the rate of inactivation of L. monocytogenes in the different trials were estimated based on data from the linear descending portions of the survival curves. In addition, a non-linear Weibull-type equation was fitted to the data from each survival curve with satisfactory results. The results of the present study emphasize that, according to the definition laid down in the European Union Regulation 1441/2007, the processed cheese product tested in this work should be considered and classified as one that does not support the growth of L. monocytogenes under reasonable foreseeable conditions of distribution and storage. However, post-processing contamination of the product should be austerely avoided as the pathogen can survive in the product for extended periods of time, particularly under refrigerated storage (4 °C).     

Combined effect of enterocin AS-48 and high hydrostatic pressure to control food-borne pathogens inoculated in low acid fermented sausages

The single and combined effects of enterocin AS-48 and high hydrostatic pressure (HHP) on Listeria monocytogenes, Salmonellaenterica, and Staphylococcus aureus was investigated in fuet (a low acid fermented sausage) during ripening and storage at 7 °C or at room temperature. AS-48 (148 AU g⁻¹) caused a drastic 5.5 log cfu g⁻¹ decrease in L. monocytogenes (P < 0.001) and a significant (P < 0.01) inhibition (1.79 logs) for Salmonella at the end of ripening (10 d). After pressurization (400 MPa) and storage Listeria counts remained below 5 cfu g⁻¹ in all fuets containing AS-48 (pressurized or not). HHP alone had no anti-Listeria effect. HHP treatment significantly reduced Salmonella counts, with lowest levels in pressurized fuets with AS-48. S. aureus showed similar growth for all treatments and storage conditions. These results indicate that AS-48 can be applied alone to control L. monocytogenes and combined with HHP treatment to control Salmonella in fuets.     

Viability of Lactobacillus acidophilus La-5 added solely or in co-culture with a yoghurt starter culture and implications on physico-chemical and related properties of Minas fresh cheese during storage

The effect of a probiotic culture of Lactobacillus acidophilus (La-5), added solely or in co-culture with a starter culture of Streptococcus thermophilus, on texture, proteolysis and related properties of Minas fresh cheese during storage at 5 °C was investigated. Three cheese-making trials were prepared and produced with no addition of cultures (T1 - control), supplemented with La-5 (T2), and with La-5 + S. thermophilus (T3). Viable counts of La-5 remained above 6.00 log cfu g⁻¹ during the whole storage for T2, reaching 7.00 log cfu g⁻¹ on the 14th day. For T3, the counts of La-5 remained above 6.00 log cfu g⁻¹ after 7 days of storage. Due to the presence of S. thermophilus, T3 presented the highest proteolytic index increase and titratable acidity values. Nevertheless, these results and S. thermophilus addition had no influence on viability of La-5 which presented satisfactory populations for a probiotic food. Moreover, the use of a yoghurt culture for the production of Minas fresh cheese T3 supplemented with La-5 resulted in a good quality product, with a small rate of post-acidification, indicating that traditional yoghurt culture could be employed in co-culture with La-5 to improve the quality of this cheese.     

The effect of sodium reduction with and without potassium chloride on the survival of Listeria monocytogenes in Cheddar cheese

Sodium chloride (NaCl) in cheese contributes to flavor and texture directly and by its effect on microbial and enzymatic activity. The salt-to-moisture ratio (S/M) is used to gauge if conditions for producing good-quality cheese have been met. Reductions in salt that deviate from the ideal S/M range could result in changing culture acidification profiles during cheese making. Lactococcus lactis ssp. lactis or Lc. lactis ssp. cremoris are both used as cultures in Cheddar cheese manufacture, but Lc. lactis ssp. lactis has a higher salt and pH tolerance than Lc. lactis ssp. cremoris. Both salt and pH are used to control growth and survival of Listeria monocytogenes and salts such as KCl are commonly used to replace the effects of NaCl in food when NaCl is reduced. The objectives of this project were to determine the effects of sodium reduction, KCl use, and the subspecies of Lc. lactis used on L. monocytogenes survival in stirred-curd Cheddar cheese. Cheese was manufactured with either Lc. lactis ssp. lactis or Lc. lactis ssp. cremoris. At the salting step, curd was divided and salted with a concentration targeted to produce a final cheese with 600 mg of sodium/100 g (control), 25% reduced sodium (450 mg of sodium/100 g; both with and without KCl), and low sodium (53% sodium reduction or 280 mg of sodium/100 g; both with and without KCl). Potassium chloride was added on a molar equivalent to the NaCl it replaced to maintain an equivalent S/M. Cheese was inoculated with a 5-strain cocktail of L. monocytogenes at different times during aging to simulate postprocessing contamination, and counts were monitored over 27 or 50 d, depending on incubation temperature (12 or 5°C, respectively). In cheese inoculated with 4 log₁₀ cfu of L. monocytogenes/g 2 wk after manufacture, viable counts declined by more than 3 log₁₀ cfu/g in all treatments over 60 d. When inoculated with 5 log₁₀ cfu/g at 3 mo of cheese age, L. monocytogenes counts in Cheddar cheese were also reduced during storage, but by less than 1.5 log₁₀ cfu/g after 50 d. However, cheese with a 50% reduction in sodium without KCl had higher counts than full-sodium cheese at the end of 50 d of incubation at 4°C when inoculated at 3 mo. When inoculated at 8 mo postmanufacture, this trend was only observed in 50% reduced sodium with KCl, for cheese manufactured with both cultures. This enhanced survival for 50% reduced-sodium cheese was not seen when a higher incubation temperature (12°C) was used when cheese was inoculated at 3 mo of age and monitored for 27 d (no difference in treatments was observed at this incubation temperature). In the event of postprocessing contamination during later stages of ripening, L. monocytogenes was capable of survival in Cheddar cheese regardless of which culture was used, whether or not sodium had been reduced by as much as 50% from standard concentrations, or if KCl had been added to maintain the effective S/M of full-sodium Cheddar cheese.     

Assessing in-house monitoring efficiency by tracing contamination rates in cheese lots recalled during an outbreak of listeriosis in Austria

A cluster of 34 cases of listeriosis was traced to consumption of quargel cheese, a sour milk specialty, in Austria, Germany and Czech Republic between 2009 and 2010. After recall from the retail market all soft cheese batches (n = 18) were sent for investigation and ISO 11290 based microbiological analysis revealed all red smear-ripened batches (16/18) to be positive for Listeria monocytogenes whereas mold ripened cheeses were negative. The 16 positive batches were grouped into three categories: those having exceeded shelf-life (G1), those around shelf-life (± 4 days, G2) and those within shelf-life (G3). Tracing the contamination levels as measured after recall (CL_R) to the theoretical contamination level after processing (CL₀) was considered to provide an estimate as to whether the in-house monitoring system would have been capable of unraveling the contamination scenario. Growth simulations starting from various hypothetical initial contamination levels of cheese at the plant and considering the potential variability in growth of L. monocytogenes due to model parameters and storage conditions suggested that a very low initial contamination level (e.g., < 1 CFU/g or 5 CFU/100 g) could justify the levels of L. monocytogenes enumerated in recalled samples of G1 and G2 lots. This in turn, may have resulted in low detection probability using ISO 11290:1996. In lots of G3 group, however, high initial contamination levels or temperature abuse at retail are inferred, based on simulated outputs.     

Effect of high-pressure processing on reduction of Listeria monocytogenes in packaged Queso Fresco

The effect of high-hydrostatic-pressure processing (HPP) on the survival of a 5-strain rifampicin-resistant cocktail of Listeria monocytogenes in Queso Fresco (QF) was evaluated as a postpackaging intervention. Queso Fresco was made using pasteurized, homogenized milk, and was starter-free and not pressed. In phase 1, QF slices (12.7 × 7.6 × 1 cm), weighing from 52 to 66 g, were surface inoculated with L. monocytogenes (ca. 5.0 log₁₀ cfu/g) and individually double vacuum packaged. The slices were then warmed to either 20 or 40°C and HPP treated at 200, 400, and 600 MPa for hold times of 5, 10, 15, or 20 min. Treatment at 600 MPa was most effective in reducing L. monocytogenes to below the detection level of 0.91 log₁₀ cfu/g at all hold times and temperatures. High-hydrostatic-pressure processing at 40°C, 400 MPa, and hold time ≥15 min was effective but resulted in wheying-off and textural changes. In phase 2, L. monocytogenes was inoculated either on the slices (ca. 5.0 log₁₀ cfu/g; ON) or in the curds (ca. 7.0 log₁₀ cfu/g; IN) before the cheese block was formed and sliced. The slices were treated at 20°C and 600 MPa at hold times of 3, 10, and 20 min, and then stored at 4 and 10°C for 60 d. For both treatments, L. monocytogenes became less resistant to pressure as hold time increased, with greater percentages of injured cells at 3 and 10 min than at 20 min, at which the lethality of the process increased. For the IN treatment, with hold times of 3 and 10 min, growth of L. monocytogenes increased the first week of storage, but was delayed for 1 wk, with a hold time of 20 min. Longer lag times in growth of L. monocytogenes during storage at 4°C were observed for the ON treatment at hold times of 10 and 20 min, indicating that the IN treatment may have provided a more protective environment with less injury to the cells than the ON treatment. Similarly, HPP treatment for 10 min followed by storage at 4°C was the best method for suppressing the growth of the endogenous microflora with bacterial counts remaining below the level of detection for 2 out of the 3 QF samples for up to 84 d. Lag times in growth were not observed during storage of QF at 10°C. Although HPP reduced L. monocytogenes immediately after processing, a second preservation technique is necessary to control growth of L. monocytogenes during cold storage. However, the results also showed that HPP would be effective for slowing the growth of microorganisms that can shorten the shelf life of QF.     

Inulin and oligofructose improve sensory quality and increase the probiotic viable count in potentially synbiotic petit-suisse cheese

The influence of inulin, oligofructose and oligosaccharides from honey, combined in different proportions, on the consumers’ sensory acceptance, probiotic viable count and fructan content of novel potentially synbiotic petit-suisse cheeses was investigated. Probiotic populations varied from 7.20 up to 7.69 log cfu g⁻¹ (Bifidobacterium animalis subsp. lactis) and from 6.08 up to 6.99 log cfu g⁻¹ (Lactobacillus acidophilus). The highest fructan contents were achieved by the cheese trials containing oligofructose and/or inulin (above 8.90 g 100 g⁻¹). The control trial showed the lowest mean acceptance (6.63) after 28 days of refrigerated storage, whereas the highest acceptance (7.43) was observed for the trial containing 10 g 100 g⁻¹ oligofructose. Acceptance increased significantly during storage (P<0.05) only for cheeses supplemented with oligofructose and/or inulin. Cheeses containing honey did not perform well enough compared to the cheeses with addition of inulin and/or oligofructose, and the best synbiotic petit-suisse cheese considering sensory and technological functional features was that containing oligofructose and inulin combined, therefore encouraging the commercial product use.     

Detection and characterization of Listeria monocytogenes in Sao Jorge (Portugal) cheese production

Listeria monocytogenes is a foodborne pathogen that can cause serious invasive disease in humans. Because human listeriosis cases have previously been linked to consumption of contaminated cheese, control of this pathogen throughout the cheese production chain is of particular concern. To understand the potential for L. monocytogenes transmission via São Jorge cheese, a Portuguese artisanal cheese variety that bears a Protected Denomination of Origin classification, 357 raw milk, curd, natural whey starter, and cheese samples representative of the production chain of this cheese were collected over one year and tested for the presence of L. monocytogenes and selected physicochemical parameters. Although neither L. monocytogenes nor other Listeria spp. were detected in whey, curd, or cheese samples, 2 of the 105 raw milk samples analyzed were positive for L. monocytogenes. These 2 raw milk isolates represented a ribotype that has previously been linked to multiple human listeriosis outbreaks and cases elsewhere, indicating the potential of these isolates to cause human listeriosis. On average, physicochemical parameters of São Jorge cheese ripened for 4 mo presented values that likely minimize the risk of L. monocytogenes outgrowth during ripening and storage (mean pH = 5.48; mean moisture = 37.79%; mean NaCl concentration = 4.73%). However, some cheese samples evaluated in this study were characterized by physicochemical parameters that may allow growth and survival of L. monocytogenes. Even though our results indicate that raw milk used for São Jorge cheese manufacture as well as finished products is rarely contaminated with L. monocytogenes, continued efforts to control the presence of this pathogen in the São Jorge cheese production chain are urged and are critical to ensure the safety of this product.     

Efficacy of bacteriophage LISTEXP100 combined with chemical antimicrobials in reducing Listeria monocytogenes in cooked turkey and roast beef

The aim of this study was to verify the effectiveness of the commercially available anti-Listeria phage preparation LISTEX^™P100 in reducing Listeria monocytogenes on ready-to-eat (RTE) roast beef and cooked turkey in the presence or absence of the chemical antimicrobials potassium lactate (PL) and sodium diacetate (SD). Sliced RTE meat cores at 4 and 10 °C were inoculated with cold-adapted L. monocytogenes to result in a surface contamination level of 10³ CFU/cm². LISTEX^TMP100 was applied at 10⁷ PFU/cm² and samples taken at regular time intervals during the RTE product's shelf life to enumerate viable L. monocytogenes. LISTEX^™P100 was effective during incubation at 4 °C with initial reductions of L. monocytogenes of 2.1 log₁₀ CFU/cm² and 1.7 log₁₀ CFU/cm², respectively, for cooked turkey and roast beef without chemical antimicrobials (there was no significant difference to the initial L. monocytogenes reductions in the presence of LISTEX^TMP100 for cooked turkey containing PL and roast beef containing SD-PL). In the samples containing no chemical antimicrobials, the presence of phage resulted in lower L. monocytogenes numbers, relative to the untreated control, of about 2 log CFU/cm² over a 28-day storage period at 4 °C. An initial L. monocytogenes cell reduction of 1.5 log₁₀ CFU/cm² and 1.7 log₁₀ CFU/cm², respectively, for cooked turkey and roast beef containing no chemical antimicrobials was achieved by the phage at 10 °C (abusive temperature). At this temperature, the L. monocytogenes cell numbers of samples treated with LISTEX™ P100 remained below those of the untreated control only during the first 14 days of the experiment for roast beef samples with and without antimicrobials. On day 28, the L. monocytogenes numbers on samples containing chemical antimicrobials and treated with LISTEX^TMP100 stored at 4 and 10 °C were 4.5 log₁₀ CFU/cm² and 7.5 log₁₀ CFU/cm², respectively, for cooked turkey, and 1.2 log₁₀ CFU/cm² and 7.2 log₁₀ CFU/cm², respectively, for roast beef. In both cooked turkey samples with and without chemical antimicrobials stored at 10 °C, the phage-treated samples had significantly lower numbers of L. monocytogenes when compared to the untreated controls throughout the 28-day storage period (P < 0.0001). For roast beef and cooked turkey containing chemical antimicrobials treated with LISTEX^TMP100 and stored at 4 °C, no more than a 2 log CFU/cm² increase of L. monocytogenes was observed throughout the stated shelf life of the product. This study shows that LISTEX^™P100 causes an initial reduction of L. monocytogenes numbers and can serve as an additional hurdle to enhance the safety of RTE meats when used in combination with chemical antimicrobials.     

Growth potential of Listeria monocytogenes strains in mixed ready-to-eat salads

In this study, a microbiological challenge test in three artificially contaminated retail mixed mayonnaise-based ready-to-eat salads stored at refrigerator temperatures (3 °C and 7 °C) for 48 h was carried out. Shrimp-tomato salad, smoked ham salad and garlic cheese salad were separately contaminated by a suspension of particular Listeria monocytogenes strains. The number of L. monocytogenes, Enterobacteriaceae, staphylococci and total plate count (CFU/g) was determined. Listeria monocytogenes growth potential in the salads was calculated and evaluated.A significant increase in total plate count and L. monocytogenes count throughout storage of all three investigated salads was found. Enterobacteriaceae levels were high at the beginning in all salads but significantly (p < 0.05) decreased throughout the experiment depending on the temperature.All investigated L. monocytogenes strains demonstrated growth at both temperatures but expressed different growth potential. Especially garlic cheese salad and smoked ham salad were able to support the growth of Listeria. Shrimp-tomato salad supported growth the least. The growth potential increased with the increasing temperature and exceeded 0.5 log₁₀ CFU/g in many cases. If the potential for growth is > 0.5 log₁₀ CFU/g, food products can potentially endanger human health. Reference strain (ATCC 7644) showed the least growth potential almost in all cases in comparison with strains isolated from frozen pollock loins and from thermally treated specialty sausage containing preservatives. To eliminate the occurrence of microbiological risks, the shelf-life of the studied salads was estimated.     

Microbiological quality of fresh lettuce from organic and conventional production

Previously there was no available information on the levels of indicator bacteria and the prevalence of pathogens in fresh lettuce grown in organic and conventional farms in Spain. A total of 72 lettuce samples (18 farms for 4 repetitions each) for each type of the agriculture were examined in order to assess the bacteriological quality of the lettuces, in particular the prevalence of selected pathogens. The lettuce samples were analyzed for the presence of aerobic mesophilic, psychrotrophic microorganisms, yeasts and moulds, Enterobacteriaceae, mesophilic lactic acid bacteria, Pseudomonas spp. and presumptive Escherichia coli, Salmonella spp. and Listeria monocytogenes. The mean aerobic mesophilic counts (AM) were 6.35 ± 0.69 log₁₀ cfu g⁻¹ and 5.67 ± 0.80 log₁₀ cfu g⁻¹ from organic and conventional lettuce, respectively. The mean counts of psychrotrophic microorganisms were 5.82 ± 1.01 log₁₀ cfu g⁻¹ and 5.41 ± 0.92 log₁₀ cfu g⁻¹ from organic and conventional lettuce, respectively. Yeasts and moulds (YM) mean counts were 4.74 ± 0.83 log₁₀ cfu g⁻¹ and 4.21 ± 0.96 log₁₀ cfu g⁻¹ from organic and conventional lettuce, respectively. Lactic acid bacteria (LAB) were present in low numbers and the mean counts were 2.41 ± 1.10 log₁₀ cfu g⁻¹ and 1.99 ± 0.91 log₁₀ cfu g⁻¹ from organic and conventional lettuce, respectively. Pseudomonas spp. mean counts were 5.49 ± 1.37 log₁₀ cfu g⁻¹ and 4.98 ± 1.26 log₁₀ cfu g⁻¹ in organic and conventional lettuce, respectively. The mean counts for Enterobacteriaceae were 5.16 ± 1.01 log₁₀ cfu g⁻¹ and 3.80 ± 1.53 log₁₀ cfu g⁻¹ in organic and conventional lettuce, respectively. E. coli was detected in 22.2% (16 samples) of organic lettuce and in 12.5% (9 samples) of conventional lettuce. None of the lettuce samples was positive for E. coli O157:H7, L. monocytogenes and Salmonella spp. From the samples analyzed by principal component analysis (PCA) a pattern with two different groups (conventional and organic) can be observed, being the highest difference between both kinds of samples the Enterobacteriaceae count.     

Effects of γ-irradiation on Listeria monocytogenes population,colour, texture and sensory properties of Feta cheese during cold storage

Feta, a white brine cheese, was produced and contaminated with Listeria monocytogenes. Contamination occurred either at the beginning (pre-process contamination) or at the end of Feta manufacturing (post-process contamination). In the first case the milk was contaminated with 10³ cfu/ml, and 2 months later, in the final product, the L. monocytogenes population was approximately 10⁵ cfu/g. In the second case, the brine (NaCl, 7% w/v), in which the Feta was packaged, was contaminated with 10³ cfu/ml. Contaminated Feta samples were vacuum-packaged and exposed to irradiation doses of 1.0, 2.5 and 4.7 kGy and stored at 4 °C for a month. In the pre-process contaminated samples none of the irradiation doses eliminated L. monocytogenes; however the highest dose reduced the viable population to a level which is in compliance with EC regulations. In the post-process contamination, the 2.5 kGy and 4.7 kGy doses reduced L. monocytogenes counts below the detection limit. Irradiation had no effect on the texture of Feta. Irradiation at 4.7 kGy increased Feta's redness and decreased its yellowness and lightness. Sensorial analyses showed that at the 4.7 kGy dose, the aroma profile of Feta was temporarily affected, since it was restored after 30 days of cold storage.     

Effect of gamma and electron beam irradiation on the survival of pathogens inoculated into salted, seasoned, and fermented oyster

The objective of this study was to identify the efficacy of gamma and electron beam irradiation of the food-borne pathogens including 3-strain cocktail of Listeria monocytogenes (ATCC 19114, 19115, and 19111), Staphylococcus aureus (ATCC 6538, 25923, and 29213), and Vibrio parahaemolyticus (ATCC 17802, 33844, and 27969) in salted, seasoned, and fermented oyster (oyster Jeotkal, 8% salt), commercially available in the market. Irradiation (0, 0.5, 1, 2, and 5 kGy) significantly reduced the initial microbial level not only immediately after irradiation but also during storage at 10 °C for 4 weeks (P ≤ 0.05). No viable cell was detected at 5 kGy of irradiation at a detection limit of 10¹ CFU/g. Gamma irradiation was more effective than electron beam irradiation, and yielded D₁₀ values of 0.60, 0.71, and 0.29 kGy for L. monocytogenes, S. aureus, and V. parahaemolyticus, and those of electron beam irradiation were 0.69, 0.94, and 0.29 kGy, respectively. V. parahaemolyticus was most sensitive to irradiation and storage among all pathogens tested. Sensory quality was not affected by irradiation treatment. Results suggest that a low dose irradiation can improve the microbial quality and reduce the risk by the food-borne pathogens of oyster Jeotkal, which has limited alternative sterilization methods due to the temperature sensitivity of food products.     

Microbiological,biochemical and compositional changes during ripening of São Jorge – a raw milk cheese from the Azores (Portugal)

The microbial, compositional and biochemical profiles of São Jorge cheese (PDO) obtained from three distinct cheese plants, throughout the ripening period were determined. Fully ripened cheeses (i.e. by 130 days) contained a total of 3.1 × 10⁷ CFU g⁻¹ mesophilic bacteria, and a decrease in moisture content, concomitantly with an increase in salt content, was observed throughout the same time frame. The pH decreased until 30 days of ripening; thereafter, a slight increase was reported, up to 5.6 by the end of ripening. Urea-PAGE results showed extensive primary proteolysis, of both β-casein and α_s1-casein − degraded at essentially similar rates; plasmin and chymosin accordingly appear to be active in the cheese curd. RP-HPLC profiles of water-soluble fractions showed minor differences between 1 and 130 day old cheeses, whereas equivalent profiles of 7% (v/v) ethanol-soluble fractions contained several peaks, indicative of a heterogeneous mixture of products of proteolysis, that evolved with time.     

Synergistic antimicrobial effect of pyrophosphate on Listeria monocytogenes and Escherichia coli O157 in modified atmosphere packaged and refrigerated seabass slices

Effect of pyrophosphate (PP) in combination with modified atmosphere (MAP) (80% CO₂, 10% O₂ and 10% N₂) on the survival of Listeria monocytogenes and Escherichia coli O157 inoculated on seabass slices stored at 4 °C was investigated. PP pretreatment showed the synergistic effect on microbiological inhibition with MAP as evidenced by the lowered TVC and LAB counts, compared with samples stored in air and those kept under MAP. Microbiological changes of seabass slices inoculated with different levels of L. monocytogenes or E.coli O157 (10³ and 10⁵ cfu/g) were monitored during storage. PP pretreatment reduced colony count of E. coli O157 and extended the lag phase of L. monocytogenes. Therefore, MAP in combination with PP pretreatment not only retarded microbiological deterioration of seabass slices but also reduced or inactivated some pathogenic bacteria to some extent.     

Development of oscillation method for reducing foodborne pathogens on lettuce and spinach

In this study, the efficacy of an oscillator for reducing the numbers of foodborne pathogens on lettuce and spinach was tested. A cocktail of three strains each of Salmonella typhimurium, Escherichia coli O157:H7 and Listeria monocytogenes cells and of Bacillus cereus spores was inoculated onto lettuce and spinach leaves and followed by oscillation at 10 Hz and 20 Hz for up to 30 s. After treatment of inoculated lettuce leaf with an oscillator at 20 Hz for 30 s, 2.58, 2.82, 2.21 and 2.22 Log₁₀ CFU/g reductions were obtained with the cells of S. typhimurium, E. coli O157:H7 and L. monocytogenes and the spores of B. cereus, respectively. In the case of the oscillation treatment of spinach leaf, 2.89, 3.73, 2.46 and 2.25 Log₁₀ CFU/g reductions of those pathogens were achieved under the same condition. Statistically significant reductions were observed after oscillation treatment at 20 Hz for 5-10 s. The oscillation treatment at 10 Hz led to slightly less reductions of the pathogens tested as compared to the treatment at 20 Hz. In conclusion, the oscillation method developed shows to be highly efficacious in reducing foodborne pathogens on lettuce and spinach leaves.