Survival of Shigella sonnei on smooth tomato surfaces, in potato salad and in raw ground beef

This study investigated the survival of a five-strain Shigella sonnei cocktail on smooth tomato surfaces, in potato salad and in raw ground beef. All inocula were resistant to the antibiotic rifampicin to allow simple detection of the target culture among the indigenous microflora of the food samples. Inoculated tomatoes were stored at 13 degrees C/85% relative humidity, the standard holding conditions for mature, green tomatoes. Inoculated potato salad and ground beef samples were stored at 2.5 degrees C and 8.0 degrees C to study the effects of varied refrigerated temperatures. Surviving populations were estimated using a three-tube most probable number (MPN) method. Tryptic soy broth tubes supplemented with 100 ppm rifampicin were inoculated with appropriate dilutions of the recovered inocula and scored for growth after overnight enrichment. S. sonnei populations declined rapidly to undetectable levels (2 days) when dried on smooth surfaces of tomatoes. S. sonnei populations did not decrease in potato salad and ground beef stored at 2.5 degrees C and 8.0 degrees C over the shelf-life of the products.     

Growth of Aeromonas hydrophila in the whey cheeses Myzithra, Anthotyros, and Manouri during storage at 4 and 12 degrees C

The fresh whey cheeses Myzithra, Anthotyros, and Manouri were inoculated with Aeromonas hydrophila strain NTCC 8049 (type strain) or with an A. hydrophila strain isolated from food (food isolate) at levels of 3.0 to 5.0 x 10(2) CFU/g of cheese and stored at 4 or 12 degrees C. Duplicate samples of cheeses were tested for levels of A. hydrophila and pH after up to 29 days of storage. At 4 degrees C, A. hydrophila grew in Myzithra and Anthotyros with a generation time of ca. 19 h, but no growth was observed in Manouri. In Myzithra, average maximum populations of 8.87 log CFU/g (type strain) and 8.79 log CFU/g (food isolate) were recorded after 20 and 22 days of storage at 4 degrees C, respectively. The average maximum populations observed in Anthotyros stored at 4 degrees C were 6.72 log CFU/g (food isolate) and 6.13 log CFU/g (type strain) and were observed after 15 and 16 days of storage, respectively. A. hydrophila grew rapidly and reached high numbers in cheeses stored at 12 degrees C. The average generation times were 3.7 and 3.9 h (Myzithra), 4.1 and 6.1 h (Anthotyros), and 8.0 and 9.2 h (Manouri) for the type strain and the food isolate, respectively. Among the different whey cheese trials, the highest A. hydrophila population recorded (10.13 log CFU/g) was in Myzithra that had been inoculated with the food isolate after 8 days of storage at 12 degrees C. To prevent A. hydrophila growth in whey cheeses, efforts must be focused on preventing postprocessing contamination and temperature abuse during transportation and storage.     

Survival of Listeria monocytogenes during storage of ready-to-eat meat products processed by drying, fermentation, and/or smoking

The survival of Listeria monocytogenes was evaluated on 15 ready-to-eat meat products made using drying, fermentation, and/or smoking. The products were obtained from six processors and included summer sausage, smoked cured beef, beef jerky, snack stick, and pork rind and crackling products. The water activity of the products ranged from 0.27 (pork rinds and cracklings) to 0.98 (smoked cured beef slices). Products were inoculated with a five-strain cocktail of L. monocytogenes, repackaged under either vacuum or air, and then stored either at room temperature (21degrees C) or under refrigeration (5 degrees C) for 4 to 11 weeks. Numbers of L. monocytogenes fell for all products during storage, ranging from a decrease of 0.8 log CFU on smoked cured beef slices during 11 weeks under vacuum at 5 degrees C to a decrease of 3.3 log CFU on a pork rind product stored 5 weeks under air at 21degrees C. All of the products tested could be produced under alternative 2 of the U.S. Department of Agriculture regulations mandating control of L. monocytogenes on ready-to-eat meat and poultry products. For many of the products, 1 week of postprocessing storage prior to shipment would act as an effective postlethality treatment and would allow processors to operate under alternative I of these regulations.     

Package systems and storage times serve as postlethality controls for Listeria monocytogenes on whole-muscle beef jerky and pork and beef smoked sausage sticks

To validate how packaging and storage reduces Listeria monocytogenes on whole-muscle beef jerky and smoked pork and beef sausage sticks, four packaging systems (heat sealed [HS] without vacuum, heat sealed with oxygen scavenger, nitrogen flushed with oxygen scavenger [NFOS], and vacuum) and four ambient temperature storage times were evaluated. Commercially available whole-muscle beef jerky and smoked pork and beef sausage sticks were inoculated with a five-strain L. monocytogenes cocktail, packaged, and then stored at 25.5 °C until enumerated for L. monocytogenes at 0, 24, 48, and 72 h and 30 days after packaging. The interaction of packaging and storage time affected L. monocytogenes reduction on jerky, but not on sausage sticks. A >2-log CFU/cm(2) reduction was achieved on sausage sticks after 24 h of storage, regardless of package type, while jerky had <2-log reductions for all packaging types. At 48 h, log reductions were similar (P. 0.05) for all types of jerky packaging, ranging from 1.26 to 1.72 log CFU/cm(2); however, at 72 h, mean L. monocytogenes reductions were >2 log CFU/cm(2), except for NFOS (1.22-log CFU/cm(2) reduction). Processors could package beef jerky in HS packages with oxygen scavenger or vacuum in conjunction with a 24-h holding time as an antimicrobial process to ensure a >1-log CFU/cm(2) L. monocytogenes reduction or use a 48-h holding time for HS- or NFOS-packaged beef jerky. A >3-log CFU/cm(2) mean reduction was observed for all beef jerky and sausage stick packaging systems after 30 days of 25.5 °C storage.     

The survival and recovery of Salmonella typhimurium phage type U285 in frozen meats and tryptone soya yeast extract broth

The survival of S. typhimurium U285 was studied in cooked minced beef, sausage mixture and tryptone soya yeast extract (TSY) broth stored at freezer temperatures (-18 degrees C to -20 degrees C) for up to 10 weeks. Survival, as indicated by changes in viable counts, was best in minced beef followed by sausage mixture and TSY broth. Metabolic injury was minimal in each substrate whereas structural injury was detected, especially in TSY broth. Recovery, as indicated by changes in viable counts during thawing at room temperature, was generally complete after thawing 10 g or 10 ml amounts for 2 h. Viable counts obtained after thawing at refrigerator temperature for 24 h were similar to those obtained after 2h at room temperature. For specimens containing low inocula of salmonellae (0.5 cells/g), more isolations were obtained with pre-enrichment than with direct enrichment for minced beef and sausage mixture.     

Validation of a manufacturing process for fermented, semidry Turkish soudjouk to control Escherichia coli O157:H7

Two soudjouk batters were prepared from ground beef (20% fat) and nonmeat ingredients and inoculated with a five-strain mixture of Escherichia coli O157:H7 to yield an initial inoculum of 7.65 log10 CFU/g. One batter contained a commercial-starter culture mixture (approximately 8.0 log10 CFU/g) and dextrose (1.5%), while the other batter relied upon a natural fermentation with no added carbohydrate. Following mixing, sausage batters were held at 4 degrees C for 24 h prior to stuffing into natural beef round casings. Stuffed soudjouk sticks were fermented and dried at 24 degrees C with 90 to 95% relative humidity (RH) for 3 days and then at 22 degrees C with 80 to 85% RH until achieving a product moisture level of approximately 40%. After fermentation and drying with an airflow of 1 to 1.5 m/s, the sticks were either not cooked or cooked to an instantaneous internal temperature of 54.4 degrees C (130 degrees F) and held for 0, 30, or 60 min. The sticks were then vacuum packaged and stored at either 4 or 21 degrees C. For each of three trials, three sticks for each treatment/batter were analyzed for numbers of E. coli O157:H7 after inoculation, after fermentation, after cooking, and after storage for 7, 14, 21, and 28 days. Reductions in numbers of E. coli O157:H7 after fermentation and drying for sticks fermented by the starter culture (pH 4.6) and for sticks naturally fermented (pH 5.5) were 1.96 and 0.28 log10 CFU/g, respectively. However, cooking soudjouk sticks produced with a starter culture and holding at 54.4 degrees C for 0, 30, or 60 min reduced pathogen numbers from an initial level after fermentation and drying of 5.69 log10 CFU/g to below a detectable level by either direct plating (<1.0 log10 CFU/g) or by enrichment. In contrast, cooking soudjouk sticks produced without an added starter culture decreased pathogen numbers from an initial level after fermentation and drying of 7.37 to 5.65 log10 CFU/g (54.4 degrees C, no hold), 5.04 log10 CFU/g (54.4 degrees C, 30 min hold), and 4.67 log10 CFU/g (54.4 degrees C, 60 min hold). In general, numbers of E. coli O157:H7 within both groups of soudjouk sticks decreased faster during storage at 21 degrees C compared to 4 degrees C. After 28 days of storage, total reductions in pathogen numbers in soudjouk sticks produced using a starter culture but that were not subsequently cooked were 7.65 and 3.93 log10 CFU/g at 21 and 4 degrees C, respectively. For naturally fermented soudjouk, total reductions varied from 4.47 to 0.45 log10 CFU/g, depending on the cooking time and storage temperature. These data provide guidelines for manufacturers of dry sausage of ethnic origin, including soudjouk, to assess the safety of their processes for control of E. coli O157:H7.     

Colonization of tomatoes by Salmonella montevideo is affected by relative humidity and storage temperature

The influences of the relative humidity (RH) and storage temperature on the colonization of tomato surfaces by Salmonella Montevideo were studied. Red, ripe tomatoes (Lycopersicon esculentum) were spot inoculated in three separate trials with 100 pl (approximately 10(6) CFU) of Salmonella Montevideo and stored for 90 min at 22 degrees C under 97% RH to facilitate attachment of cells to the blossom end of tomato surfaces. Following this attachment step, tomatoes were washed to remove loosely adhered cells and then stored at 22 or 30 degrees C for up to 10 days under RH of 60, 75, 85, or 97%. At 0, 0.4, 1, 4, 7, and 10 days of storage, three tomatoes were individually hand massaged in 50 ml of 0.1% peptone water and the washes were separately analyzed to enumerate populations of Salmonella Montevideo. The number of Salmonella Montevideo cells attached after 90 min at 22 degrees C was 3.8 log CFU per tomato; this level was determined to be the initial colonizing population. After 10 days of storage at 30 degrees C, the Salmonella Montevideo population increased to 0.7, 1.0, 1.2, and 2.2 log CFU per tomato at 60, 75, 85, and 97% RH, respectively. A similar trend was observed at 22 degrees C, although populations were lower than at 30 degrees C. Scanning electron micrographs of tomato cuticles after storage revealed a well-defined biofilm containing bacteria. These findings reinforce the importance of maintaining stored tomatoes at temperatures that do not support growth of pathogenic bacteria and demonstrate the growth-promoting effects of high humidity.     

BEHAVIOR OF STREPTOCOCCUS PYOGENES IN MASHED POTATOES

Streptococcus pyogenes is widely recognized as a human pathogen. Whereas person-to-person transmission is the most common transmission mechanism for this pathogen, some outbreaks of S. pyogenes disease have been reported to occur in association with consumption of contaminated foods such as shrimp or potato salads. In this study, the behavior of S. pyogenes was studied in mashed potatoes as a function of storage temperature, types and amount of background biota and type of ingredients. Combined mashed potatoes (potatoes, butter, milk, egg and table salt) or plain mashed potatoes (potatoes only) were inoculated with a 5-strain cocktail of S. pyogenes and stored at 7, 25, 35 or 37C. At intervals during storage, samples were collected for counting S. pyogenes in blood agar plates or blood agar added with sodium azide, polymyxin and crystal violet. Mashed potatoes obtained from fast-food restaurants were used to determine the fate of S. pyogenes as affected by changes in aerobic mesophiles, coliform and lactic acid bacteria counts. S. pyogenes was able to survive in mashed potatoes stored at 7C and to grow in mashed potatoes stored at 25 or 37C with lag phase lengths of 3 and 2 h and generation times of 26.0 and 25.3 min, respectively. The generation time of S. pyogenes in plain mashed potatoes was 30.7 min at 35 C. Presence of active background biota at 2–3 log₁₀ CFU/g concentrations did not prevent growth of S. pyogenes when stored at 35C. These results contribute to a better understanding of the potential for S. pyogenes to cause foodborne outbreaks.     

Survival and growth of Salmonella baildon in shredded lettuce and diced tomatoes, and effectiveness of chlorinated water as a sanitizer

An outbreak of salmonellosis associated with diced tomatoes occurred in the United States in 1999. Experiments were done to determine the efficacy of chlorine in killing Salmonella baildon, the causative serotype, inoculated onto shredded lettuce and diced tomatoes, and to determine survival characteristics of the organism on these produce items stored at 4 degrees C for up to 12 days and on tomatoes stored at 21 or 30 degrees C for up to 72 h. Populations of S. baildon in lettuce and tomatoes (pH 4.51 +/- 0.02) inoculated with 3.60 log10 and 3.86 log10 cfu/g, respectively, were reduced by less than 1 log when the produce was immersed for 40 s in a 120 or 200 microg/ml free chlorine solution. Produce inoculated with 0.60-0.86 log10 cfu/g was positive for the pathogen after treatment with 200 microg/ml chlorine. Initial populations of 3.28 and 3.40 log10 cfu/g of lettuce and tomatoes, respectively, decreased by about 2 log10 cfu/g during storage for 12 days at 4 degrees C. One of six samples of lettuce initially containing 0.28 log10 cfu of S. baildon per gram was positive after storage for 12 days, but the pathogen was not detected in tomatoes analyzed within 15 min of inoculation with 0.40 log10 cfu/g. While the number of viable cells decreased during storage at 4 degrees C, initial populations of 0.28 log10 cfu/g of shredded lettuce and 3.40 log10 cfu/g of diced tomatoes are not reduced to undetectable levels during storage at 4 degrees C for 12 days. Tolerance of S. baildon to an acidic pH (4.5) was not influenced by the pH (4.5, 5.8, or 7.2) of the medium in which it was grown, suggesting that this strain possesses unusual resistance to acid pH. The pathogen grew in diced tomatoes (pH 4.40 +/- 0.01) from an initial population of 0.79 log10 cfu/g to 5.32 and 7.00 log10 cfu/g within 24 h at 21 and 30 degrees C, respectively.     

THE EFFECT OF AEROBIC MESOPHILIC MICROFLORAL LEVELS ON THE ISOLATION OF INOCULATED LISTERIA MONOCYTOGENES STRAIN LM82 FROM SELECTED FOODS

The effect of aerobic mesophilic microfloral concentration on the isolation of Listeria monocytogenes LM82 was studied in 31 (18 cheeses and 7 noncheese) retail foods having standard plate counts of 10¹ to 10⁸ colony forming units (CFU)/g. Foods were spiked with L. monocytogenes and enriched at 30°C for 24 h in a selective enrichment broth used in a U.S. Food and Drug Administration method. Inoculum levels for isolation on modified McBride agar ranged from 0.1 to > 5 × 10³ with a geometric mean value of 5 inoculated CFU/g or 1.4 CFU/g. Pure Enterococcus (Streptococcus) faecalis ( 0 to 6 × 10⁶ inoculated CFU/mL ) in the absence of food matrix had no effect on the enrichment of L. monocytogenes. Ease of isolation of LM82 was independent of the food microflora concentration both generally and in the specific food type of 9 Brie cheeses. Competition, when it occurs, therefore, may be due to specific bacterial competitors rather than bacterial numbers .     

Survival differences of Escherichia coli O157:H7 strains in apples of three varieties stored at various temperatures

Differences in survival and growth among five different Escherichia coli O157:H7 strains in three apple varieties were determined at various temperatures. Jonathan, Golden Delicious, and Red Delicious apples were wounded and inoculated with E coli O157:H7 strains C7929 (apple cider isolate), 301C (chicken isolate), 204P (pork isolate), 933 (beef isolate), and 43890 (human isolate) at an initial level of 6 to 7 log CFU/g. The inoculated apples were stored at a constant temperature of 37, 25, 8, or 4 degrees C or at 37 degrees C for 24 h and then at 4 degrees C, and bacterial counts were determined every week for 28 days. By day 28, for Jonathan apples at 25 degrees C, the apple isolate counts were significantly higher than the chicken and human isolate counts. At 4 degrees C for 28 days, the human isolate inoculated into Jonathan, Golden Delicious, and Red Delicious apples was present in significantly smaller numbers than the other strains. The apple isolate survived significantly better at 4 degrees C, yielding the highest number of viable cells. By days 21 and 28, for apples stored at 37 degrees C for the first 24 h and then at 4 degrees C, the counts of viable E. coli O157:H7 apple and human isolates were 6.8 and 5.8 log CFU/g at the site of the wound, whereas for apples kept at 4 degrees C for the duration of storage, the respective counts were 5.6 and 1.5 log CFU/g. Our study shows that E. coli O157:H7 strains responded differentially to their ability to survive in these three apple varieties at 25 or 4 degrees C and produced higher viable counts when apples were temperature abused at 37 degrees C for 24 h and then stored at 4 degrees C for 27 days.     

Survival and growth of Escherichia coli O157:H7 in roast beef and salami after exposure to an alkaline cleaner

Survival and growth of wild-type (EDL 933) and rpoS-deficient (FRIK 816-3) strains of Escherichia coli O157:H7 after exposure to an alkaline cleaner for 2 min and inoculating into roast beef (pH 6.3) and hard salami (pH 4.9) at low (0.003 to 0.52 CFU/g) and high (0.69 to 31.5 CFU/g) populations were determined. Roast beef was stored at 4 and 12 degrees C; salami was stored at 4, 12, and 20 degrees C. At 4 degrees C, untreated cells of both strains showed greater reductions in populations in salami than in roast beef during a 21-day storage period. Populations of treated and untreated cells recovered from roast beef and salami stored at 4 degrees C on tryptic soy agar were significantly (P < or = 0.05) higher than on sorbitol MacConkey agar, indicating that a portion of the cells was injured. Treated and untreated cells grew in roast beef at 12 degrees C. Growth of treated cells of the FRIK 816-3 strain in roast beef at 12 degrees C was significantly slower than that of the EDL 933 strain. Populations of both strains decreased at different rates in salami stored at different temperatures (20 degrees C > 12 degrees C > 4 degrees C). E. coli O157:H7 strain EDL 933 grew more rapidly at 20 degrees C in a slurry (pH 5.97) prepared from stored salami (17 days at 20 degrees C) on which Penicillium chrysogenum had grown than in a slurry (5.23) prepared from salami showing no mold growth. Within 2 to 3 days, populations were ca. 3 log CFU/ml higher in slurry made from infected salami than in control salami. Results indicate that treatment of E. coli O157: H7 with an alkaline cleaner for 2 min does not impair resuscitation and growth of surviving cells in roast beef at 12 degrees C. Cross protection of cells exposed to an alkaline cleaner against subsequent stress conditions imposed by roast beef and salami stored at 4 degrees C was not evident in either of the test strains.     

Inhibition of growth of Enterobacter sakazakii in reconstituted infant formula by the lactoperoxidase system

Neonatal bacteremia and meningitis caused by the opportunistic pathogen Enterobacter sakazakii have been associated with the consumption of reconstituted powdered infant formula. Lactoperoxidase (LPO), present in mammalian milk, is known to inhibit the growth of enteric pathogens. We undertook a study to determine if the lactoperoxidase system (LPOS) will inhibit the growth of E. sakazakii in a milk-based powdered infant formula reconstituted with water. Initially at 0.04 CFU/ml, E. sakazakii grew to 2.40 to 2.74 log CFU/ml in reconstituted infant formula held at 30 or 37 degrees C for 8 h and to 0.6 log CFU/ ml in formula held for 12 h at 21 degrees C. The pathogen was not detected (less than 1 CFU/227 ml) by enrichment of formula treated with 10 to 30 microg/ml LPO and stored for 24 h at 37 degrees C or 30 microg/ml LPO and stored for 24 h at 30 degrees C. Populations of E. sakazakii, initially at 4.40 log CFU/ml of reconstituted infant formula containing 5 microg/ml LPO, did not increase significantly (P > 0.05) for up to 12 h at 21 and 30 degrees C. Populations either decreased significantly or were unchanged in formula supplemented with 10 microg/ml LPO and stored at 21, 30, or 37 degrees C for up to 24, 8, and 8 h, respectively. Results indicate that LPOS can be used to control the growth of E. sakazakii in reconstituted infant formula, thereby potentially reducing the risk of neonatal infections resulting from consumption of formula that may be contaminated with the pathogen.     

Effect of refrigerating delayed shipments of raw ground beef on the detection of Salmonella Typhimurium

In eight separate trials, four groups of raw ground beef samples were inoculated with 0.04 to 0.3 CFU/g of Salmonella Typhimurium (DT 104). Each group consisted of four 25-g samples (three inoculated and one uninoculated). After inoculation, these samples were shipped by overnight courier in Shipping containers with ice packs from the U.S. Department of Agriculture (USDA), Eastern Regional Research Center, in Wyndmoor, Pa., to the U.S. Food Safety and Inspection Service (FSIS), Eastern Laboratory, in Athens, Ga. A total of 128 samples (32 in each of four groups) were shipped. A temperature data logger was placed inside each shipping container to record the temperature during shipping and storage. The first group of ground beef samples was analyzed within approximately 1 h of arrival. The second group of samples was left in the original containers, with a gel ice pack, for 24 h before processing. The third and fourth groups of samples were removed from the original shipping containers and stored at room temperature (21 +/- 2 degrees C) for 6 h and then in a refrigerator at 4 +/- 2 degrees C for 24 and 48 h, respectively, before analysis. The samples were analyzed for the presence of Salmonella according to the USDA/FSIS Microbiological Laboratory Guidebook, chapter 4.02. There was no significant difference in the presence and levels of Salmonella in ground beef among the four test groups. These data show that it is acceptable to process the late-arriving ground beef samples for the detection of Salmonella if they are kept in a refrigerator (4 +/- 2 degrees C) for 24 to 48 h or when the shipments arrive late (24 h in the container with ice pack).     

Risk evaluation for staphylococcal food poisoning in processed milk produced with skim milk powder

The growth of S. aureus and the production of staphylococcal enterotoxin A (SEA) in skim milk concentrates stored at inappropriate temperatures in a recovery milk tank (tank for excess concentrated skim milk) used in the manufacture of skimmed milk powder were investigated. Also, it was estimated if a possible outbreak of food poisoning would occur if the contaminated skimmed milk powder was used in the manufacture of processed milk. Skim milk concentrates with milk solid content of 15, 25, and 35% were inoculated with S. aureus at 1-2 log CFU/ml and incubated at 15, 25, or 35 degrees C for 0 to 24 h with or without shaking. Bacterial growth and the level of SEA production were measured. At 35 degrees C with shaking, there was a significant difference (p<0.05) in one way layout analysis of variance, and it was demonstrated that the growth of S. aureus and SEA production could be milk solid content-dependent. Shaking accelerated the growth of S. aureus and SEA production at 35 degrees C. Generally, skim milk powder is produced by mixing a set percentage of skim milk concentrates (recovery milk) from the recovery milk tank into raw milk. If recovery milk contaminated with S. aureus at levels of 1-2 log CFU/ml is kept at 15 to 35 degrees C due to a power failure, it was estimated that processed milk consumption of 670-1200 ml, 420-1500 ml and 18-83 ml would trigger the onset of food poisoning symptoms when skim milk concentrates (recovery milk) are stored at 25 degrees C for 24 h, 35 degrees C for 10 h, and 35 degrees C for 24 h, respectively, during the production of the skim milk powder. Based on these consumption levels, it was concluded that, if recovery milk cannot be refrigerated and is stored at room temperature (25 to 35 degrees C), it must be used within 8 h and preferably within 6 h.     

EFFECT OF WATER ACTIVITY ON THE GROWTH OF STAPHYLOCOCCUS AUREUS AT MEAT-CHEESE INTERFACES

There is increased marketing of ready-to-eat nonrefrigerated snack foods which consist of meat or sausage products with low or intermediate moisture levels combined with high moisture food products, i.e., cheese products. Packaging the intermediate moisture meat in direct contact with a high moisture food might change the water activity (a_w) of the products sufficiently to support growth of Staphylococcus aureus at contaminated interfaces. To evaluate this possibility, sterile sausage slices (a_w= 0.60 to 0.82) were surface inoculated with log 2-3 CFU/g of S. aureus, interfaced with processed cheese slices (a_w= 0.94), vacuum packaged, and incubated at 19, 28, 37C and at cyclic temperature of 19–37–19C. S. aureus levels and water activities were determined weekly for 0 to 9 weeks. The a_w at the interface changed rapidly and reached an a_w that supported S. aureus growth. Growth of S. aureus occurred under all test conditions when the samples were stored at 28 and 37C. At 19C storage S. aureus remained viable for the length of the study.     

Antibacterial effect of water-soluble tea extracts on foodborne pathogens in laboratory medium and in a food model

The microbial inhibition of foodborne pathogens was determined in brain heart infusion broth with 10% (wt/vol) water-soluble extracts of green, jasmine, black, dungglre, and oolong tea against Escherichia coli O157:H7, Salmonella enterica serovar Enteritidis, Listeria monocytogenes, and Staphylococcus aureus. The mixed culture (approximately 6.0 log CFU/ml), which was composed of the four pathogens, was inoculated into brain heart infusion broth with and without tea extracts. After incubation at 35 degrees C for 0, 1, 3, and 5 days, proper dilution of each sample was spiral plated on each selective agar. Viable cell counts were performed after incubation at 35 degrees C for 24 to 36 h. Green, jasmine, and black tea exhibited an approximately 5.0 log suppression of S. aureus compared with the control from days 1 to 5. Green and jasmine tea also suppressed the growth of L. monocytogenes by approximately 3.0 log CFU/ml on day 5. In contrast, no tea extracts inactivated E. coli O157:H7 and Salmonella Enteritidis. Based on the result in liquid medium, green and jasmine teas of 0.1% (vol/wt) were individually evaluated for their antimicrobial activity against L. monocytogenes and S. aureus in a food model (ground beef) stored at 7 degrees C for 0, 1, 3, 5, and 7 days. Viable cell counts of total bacteria, L. monocytogenes, and S. aureus in ground beef were not significantly different among green and jasmine tea and the control.     

A model study of Escherichia coli O157:H7 survival in fermented dry sausages--influence of inoculum preparation, inoculation procedure, and selected process parameters

The influence of inoculum preparation, inoculation level, and inoculation procedure on Escherichia coli O157:H7 inactivation during the manufacture of fermented sausage was evaluated in a model study. Prior growth in glucose-enriched tryptone soya broth, which provided exposure to mildly acidic conditions (pH 4.8), had no effect on the later survival of E. coli O157: H7 strains 5-1 and ATCC 43894 under extremely acidic conditions (pH 2), but the same strains became sensitive to acidity after 7 days of incubation on the surface of refrigerated beef (as per the normal contamination route from slaughter to further processing). In subsequent sausage production trials, the extent of destruction observed for E. coli O157:H7 strains F-90, 5-1, and ATCC 43894 inoculated directly into the meat batter was unchanged when the inoculation level was decreased from 7.3 to 4.7 log CFU/g, but the level of inactivation was ca. 1 log higher when the surfaces of beef cuts, rather than the batter, were inoculated 7 days prior to processing. Regardless of processing conditions (fermentation to a pH of < or = 5.0 at 24 or 37 degrees C, drying at 14 degrees C to a water activity [a(w)] value of 0.91 or 0.79), strains F-90, 5-1, and ATCC 43894 showed similar survival capacities during the manufacture of sausage. A approximately 2-log reduction in pathogen numbers was generally obtained after samples were dried to an a(w) of 0.91, irrespective of fermentation temperature. The addition of a 5-day predrying holding stage at the fermentation temperature significantly (P < 0.05) increased pathogen inactivation when fermentation was carried out at 37 degrees C (but not when it was carried out at 24 degrees C). However, significant pathogen reductions (4 to 5 log CFU/g) were achieved only for extensively dried products (a(w) = 0.79).     

Dependence of the dynamics of the multiplication of bacteria in the genus Citrobacter on the temperature factor and on the product type in experimental contamination

A study was made of the time course of the reproduction of bacteria of the Citrobacter genus in milk, sausage meat and vermicelli during experimental contamination, with incubation of cultures at 3 temperature regimens (24, 37 and 44 degrees C). Estimation of the results of experiments was performed by counting the number of the colonies on the surface of 2% beef-extract agar. It was established that within the first 6 h, at 24 and 37 degrees C there was an identical growth of the number of microorganisms in all the foods under study. During incubation at 44 degrees C (for 4-8 h), there was a slower reproduction of bacteria in milk as compared with sausage meat. It was revealed that food consistency had an effect on the intensity of the reproduction of bacteria of the Citrobacter genus depending on the time of incubation and temperature.     

Effect of controlled atmosphere storage, modified atmosphere packaging and gaseous ozone treatment on the survival of Salmonella Enteritidis on cherry tomatoes

In recent years, outbreaks of infections associated with raw and minimally processed fruits and vegetables have been reported. The objective of this study was to analyse the growth/survival of Salmonella Enteritidis at spot-inoculated or stem-injected cherry tomatoes during passive modified atmosphere packaging (MAP), controlled atmosphere (CA) and to compare the results with those of air storage at 7 and 22 degrees C. During MAP, the gas composition equilibrated to 6% O2/4% CO2. CO2 level was maintained as 5% through the term of CA storage at 7 and 22 degrees C. The results demonstrate that S. Enteritidis can survive and/or grow during the storage of tomatoes depending on the location site of the pathogen on fruit, suspension cell density and storage temperature. During MAP, CA and air storage, S. Enteritidis with initial population of 7.0 log10 cfu/tomato survived on tomato surfaces with an approximate decrease of 4.0-5.0 log10 cfu/tomato in population within the storage period; however, in the case of initial population of 3.0 log10 cfu/tomato, cells died completely on day 4 during MAP storage and on day 6 during both CA and air storage. The death rate of S. Enteritidis on the surfaces of tomatoes that were stored in MAP was faster than that of stored in air and in CA. Storage temperature was effective on the survival of S. Enteritidis for the samples stored at ambient atmosphere; cells died completely on day 6 at 7 degrees C and on day 8 at 22 degrees C. Stem scars provided protective environments for Salmonella; an approximate increase of 1.0 log10 cfu/tomato in stem-scar population was observed during MAP, CA and air storage at 22 degrees C within the period of 20 days. Cells survived with no significant change in number at 7 degrees C. During the research, the effect of ozone treatment (5-30 mg/l ozone gas for 0-20 min) was also considered for surface sanitation before storage. Gaseous ozone treatment has bactericidal effect on S. Enteritidis, inoculated on the surface of the tomatoes and can be used for surface sanitation of S. Enteritidis on tomatoes before storage at different conditions. Ten mg/l ozone gas treatment with different time intervals of 5 and 15 min was found to be effective respectively on low and high dose inoculum levels of S. Enteritidis attached for 1 h. Another variable considered during ozone treatment was the 4 h attachment time.