Partially acidulated phosphate rocks: Controlled release phosphorus fertilizers for more sustainable agriculture

Phosphate rocks partially acidulated either with H₃PO₄ or H₂SO₄ were compared against SSP or TSP as phosphate fertilizers for permanent pasture. Eleven field trials were conducted over periods of up to 6 yrs. Fertilizers were surface applied annually. Initial soil pHw values ranged from 5.5–6.3 and Soil P retention from 25% to 97%. The PRs used for partial acidulation were unground or ground North Carolina PR, ground Khouribga PR, and a blend of ground PRs of North Carolina, Arad and Khouribga PRs. From the DM yields, fertilizer substitution values were calculated: fertilizer substitution value was the ratio of total P applied as superphosphate to total P as PAPR required to produce the same DM yield.Rates of dissolution of the PR component of PAPRs were also determined in soils collected from two trials.Agronomic results demonstrated that 30% acidulated phosphoric PAPRs (about 50% of total P as water-soluble P) were as effective as TSP, when the PR acidulated was from unground North Carolina PR. Results from one field trial indicated that when PAPR was from ground North Carolina PR, 20% acidulated product (water-soluble P 30–40% of total P) was equally effective as TSP. Replacement of ground North Carolina PR by a less reactive Khouribga PR did not appear to decrease the yield. Results indicated that per unit P released into soil solution, PAPRs were more efficient fertilizers than TSP. With annual applications, fertilizer substitution value of PAPR 30% tended to increase with time.Sulphuric PAPRs prepared from North Carolina PR were generally inferior to phosphoric PAPRs containing similar amounts of water-soluble P. This was attributed to the presence of CaSO₄ coatings.Abbreviations DM Dry matter - PAPR Partially acidulated phosphate rock - PR Phosphate rock - SSP Single superphosphate - TSP Triple superphosphate     

Partial acidulation of an ‘unground’ phosphate rock: II. Plant availability of phosphate

Four greenhouse experiments were conducted using three soils to determine the availability to plants of P from unground North Carolina phosphate rock (PR) treated with 20% to 50% of the H₃PO₄ required for complete acidulation. The influences of soil P retention, P status, the method of preparation of partially acidulated phosphate rocks (PAPRs) and the granule size of the products were investigated. Perennial ryegrass was grown as the test plant for up to 8 months. Triple superphosphate (TSP) was used as the standard fertilizer and unground North Carolina rock was included for comparison.The dry matter yield and P uptake response curves showed that in all experiments PAPRs were markedly superior to the PR. P status of soils appeared to influence the effectiveness of PAPRs to a greater extent than P retention. In soils of low P status the degree of acidulation required for PAPR to be nearly or as effective as TSP was 50% whereas in a soil of high P status even 30% PAPR applied as a maintenance fertilizer was effective. There was a significant positive correlation between water soluble P of fertilizers and P uptake by ryegrass. However, in general PAPRs were more effective per unit of water soluble P than TSP. Granule size (< 1 mm and 1–2 mm) and method of preparation of PAPRs did not alter the effectiveness of PAPRs.     

Long-term greenhouse evaluation of partially acidulated phosphate rock fertilizers

Twelve granular partially acidulated phosphate rock (PAPR) fertilizers were compared with unacidulated phosphate rocks (PR) and superphosphate at five rates of total P in the presence and absence of supplementary sulfate and plant residue recycling treatments in a long-term green-house experiment with lucerne (Medicago sativa L., cv. CUF101). The PAPRs were prepared from two PRs (Christmas Is. A grade and Duchess, Queensland) and acidulated at two rates (25% and 50% on an H₂SO₄ to single superphosphate basis) with either H₂SO₄ or H₃PO₄. Six harvests (each bulked from three cuttings) were collected over a 2-year period. It was generally found that lucerne response to PAPRs depended closely on their water-soluble plus citrate-soluble P contents which increased with increased degree of acidulation. The H₃PO₄ tended to yield more soluble P on acidulation of PR than H₂SO₄ and acidulation of Christmas Is. PR yielded more soluble P than did acidulation of Duchess PR. There was little evidence for enhanced availability of P due to action of the triple point solution in hydrolyzing granules on residual PR in those granules.     

Solubility and agronomic effectiveness of partially acidulated phosphate rocks as influenced by their iron and aluminium oxide content

Partially acidulated phosphate rock (PAPR) has been shown to be an effective source of P for plants grown on acid soils. Less information in available, however, regarding the effect of the phosphate rock (PR) source on the solubility and agronomic effectiveness of PAPR.The effect of Fe₂O₃ + Al₂O₃ content in PR on the quality of PAPR produced was investigated in this study. Nine sources of PR from Africa, Latin America, and the United States, representing a range of Fe₂O₃ + Al₂O₃ from 0.7% to 12.4%, were used. In a single-step process, the finely ground PRs were partially acidulated with H₂SO₄ at the 30% or 50% acidulation level and granulated (–3.35 + 1.18 mm or –6 + 14 mesh). It was found that the water-soluble P content in PAPR decreased with increasing Fe₂O₃ + Al₂O content in the PR used. Apparently, the presence of Fe₂O₃ + Al₂O₃ resulted in a reversion of some of the water-soluble P to citrate-soluble P and sometimes even to citrate-insoluble P.A short-term (6 weeks) greenhouse study was conducted to evaluate crop response to PAPRs and single superphosphate (SSP); maize, the test crop, was grown on an acid soil (pH 4.5)—Hartsells silt loam (Typic Hapludults). The agronomic effectiveness of PAPRs with respect to SSP (in terms of dry-matter yield of maize) decreased with increasing Fe₂O₃ + Al₂O₃ content in PRs. Phosphorus uptake by maize from PAPRs was found to correlate well with water solubility but not with citrate solubility. The results obtained in this study show that the detrimental effect of Fe₂O₃ + Al₂O₃ content on the solubility and P availability of PAPR should be considered when selecting a PR for PAPR production.     

Differential availability of partially sulphuric and phosphoric acidulated phosphate rocks I. Plant response

A glasshouse study was conducted to determine the influence of soil pH on the agronomic effectiveness of partially phosphoric (Phos-PAPR) and partially sulphuric (SA-PAPR) acidulated phosphate rocks (PR). For Phos-PAPR ground North Carolina PR (NCPR) was acidulated with 10, 30 and 50% of acid needed for complete acidulation. For SA-PAPR a blend of NCPR, Arad and Khouribga PRs were acidulated with 60% of the acid needed. The relative agronomic effectiveness of these PAPRs were compared with superphosphate (SSP) and ground NCPR. A highly phosphate (P) retentive and P deficient pasture soil was used. Prior to addition of fertilizers to soil, the pH of soil was adjusted to 5.1 (initial soil pH) 5.4, 5.7 and 6.1 by applying varying amounts of Ca(OH)₂. Ryegrass (Lolium perenne) was grown as the test plant over a period of eight months. Fertilizers were applied at three rates plus control. Soil pH was monitored and continuously adjusted to the desired levels throughout the experimental period.The dry matter yields and P uptake in SSP treated pots were not influenced by soil pH. With increasing soil pH, agronomic performance of Phos-PAPRs and NCPR significantly (P<0.01) decreased but that of SA-PAPR was not affected. On the basis of per unit water-soluble P applied, uptake of P by plants was greater from PAPRs than SSP. Using the P uptake values of SSP and NCPR (which was used to prepare the PAPRs), the dissolution of P from the residual PR component of the PAPRs were calculated. The residual PR component of the Phos-PAPRs apparently dissolved in greater quantities than unacidulated NCPR. Dissolution of the residual PR was enhanced with increasing degree of acidulation. However, in the case of SA-PAPR, the agronomic performance of the PAPR was mostly dependent on the water-soluble P component of the PAPR. The uptake of P from the residual PR component of the SA-PAPR was insignificant.     

Agronomic evaluation of fertilizer products derived from Sukulu Hills phosphate rock

Partial acidulation of phosphate rock (PR) or compaction of PR with soluble P fertilizers can improve the usefulness of unreactive PR for use as P fertilizer. A greenhouse study was conducted to evaluate nonconventional phosphate fertilizers derived from a low reactive Sukulu Hills PR from Uganda. Raw PR (which contained 341.0 g kg^–1 Fe₂O₃), beneficiated or concentrate PR, partially acidulated PR (PAPR) and PR compacted with triple superphosphate (TSP) were evaluated. Compacted materials had a P ratio of PR:TSP = 50:50. PAPR materials were made by 50% acidulation with H₂SO₄. TSP was used as a reference fertilizer. Fertilizers were applied to an acidic (pH = 5.4) Hiwassee loam (clayey, kaolinitic, thermic Rhodic Kanhapludults) at rates of 0, 50, 100, 200, 300 and 400 mg P kg^–1 soil. Two successive corn (Zea mays L.) crops were grown for 6 weeks. Compacted concentrate PR + TSP and raw PR + TSP were 94.4 and 89.7% as effective as TSP, respectively, in increasing dry-matter yields for the first corn crop. PAPR from the concentrate was 54.8% as effective as TSP. Raw PR, concentrate PR and the PAPR from the raw PR were ineffective in increasing dry-matter yields. The same trends were obtained when P uptake was used to compare effectiveness. Ineffectiveness of the raw PR and its corresponding PAPR was attributed to a high Fe₂O₃ content in the raw PR. Bray I and Pi paper were found to be nearly equally suitable at estimating available P in the soils treated with responsive fertilizer materials. Mehlich 1 overestimated available P in soil treated with raw PR, concentrate PR or the PAPR from the raw PR.     

Agronomic evaluation of modified phosphate rock products

Phosphorus (P) is critically needed to improve the soil fertility for crop production in large areas of developing countries. The high cost of conventional, water-soluble P fertilizers constrains their use by resource-poor farmers. Finely ground phosphate rock (PR) has been tested and used as a direct application fertilizer on tropical acid soils as a low-cost alternative where indigenous deposits of PR are located. However, direct application of PR with low reactivity or with inappropriate soil/crop combinations does not always give satisfactory results. Partial acidulation of PR (PAPR) or compaction with triple superphosphate (PR + TSP) or single superphosphate (PR + SSP) represent technologies that can be used to produce highly effective P fertilizers from those indigenous deposits. Numerous field trials conducted by IFDC in Asia, sub-Saharan Africa, and Latin America have demonstrated that PAPR at 40-50% acidulation with H₂SO₄ or at 20% with H₃PO₄ approaches the effectiveness of SSP or TSP in certain tropical soils and crops. This paper discusses how the agronomic effectiveness of PAPR is affected by mineralogical composition and reactivity of PR used and by soil properties and soil reactions. The paper also indicates that if a PR has high Fe₂O₃ + Al₂O₃ content, it may not be suitable for PAPR processing because of the reversion of water-soluble P to water-insoluble P during the PAPR manufacturing process. Under these conditions, compaction of PR with water-soluble P fertilizers (e.g. SSP, TSP) at P ratio of approximately 50:50 can be agronomically and economically attractive for utilizing the indigenous PRs in developing countries.     

Use of partially acidulated phosphate rocks as phosphate fertilizers

Partially acidulated phosphate rocks (PAPRs) are manufactured by acidulation of PRs with less than the stoichiometric amounts of, usually, phosphoric or sulphuric acids. Products of similar composition to PAPRs are also prepared by cogranulating superphosphate with PRs. For most crops the agronomic value of PAPRs is determined by the availability to plants of their water-soluble P as well as their PR P component. The acid unreacted PR present in the directly acidulated PAPR, is considered to be less reactive than the original PR. This is probably the result of surface coatings of chemical compounds formed during acidulation. Under some soil conditions, in the presence of plants, the PR component probably dissolves faster than the original PR. For seasonal crops, except for fast growing ones such as squash (Cucurbita maxima), reactive PRs partially acidulated so that the final products contain about 50% of its total P in water-soluble form, are generally as effective as fully acidulated superphosphate. For permanent pastures the water P content may be reduced to about 40% of total P without reducing their agronomic effectiveness of the product. In medium P retentive soils pH seems to have little or no influence on the agronomic effectiveness of PAPRs. In highly P retentive soils increasing soil pH reduces the agronomic effectiveness of phosphoric PAPRs apparently by reducing the solubility of the PR component of PAPRs. Even at low pH the dissolution of unreacted PR in sulphuric PAPRs is less than that in phosphoric PAPRs, probably due to the possible coating of calcium sulphate on the residual PR in sulphuric PAPRs. Results on the agronomic effectiveness of PAPRs prepared from unreactive rocks were highly variable and no generalisation could be made regarding the degree of acidulation needed for the products to be consistently effective. Single superphosphate (SSP) cogranulated with reactive rocks (SSP/PR) was agronomically less effective than SSP, and also than phosphoric PAPRs of similar water-soluble P.     

Soil testing for available phosphorus in soils where phosphate rock-based fertilizers are used

Traditional soil tests for phosphorus (P) were developed to arrive at fertilizer recommendations when water-soluble P fertilizers have been used. When slowly water-soluble fertilizers such as phosphate rock (PR) have been used, soil tests using acidic extractants overestimate bioavailability of P, whereas alkaline extractants underestimate it. Therefore, separate calibration curves are needed for soluble and PR-based fertilizers. There are two soil tests that show promise as suitable tests in soils fertilized with soluble as well as PR-based fertilizers. These are the iron oxide impregnated paper (P _i ) test and the ion exchange resin paper test. In both cases, the strips act as a sink for P mobilized in a soil solution, and P measured depends only on the concentration of P mobilized in the solution and not on the source of P or properties of the soil. Both tests somewhat simulate the sorption of P by plant roots without disturbing the chemical equilibrium, unlike other tests that extract P by the destructive dissolution of specific soil P compounds. In both cases, P measured from soils fertilized with PR-based fertilizers has shown very good correlation with plant response. Field calibration with crops under different pedological and agroecological regimes is needed for using these soil tests in developing fertilizer recommendations.     

Field evaluation of partially acidulated phosphate rocks in a Ferralsol from Cuba

Phosphorus (P) is needed in large areas of developing countries toimprove soil fertility for crop production. The use of phosphate rock (PR) isan alternative to costly soluble P fertilizers, but it is ineffective usuallyin non-acid soils unless it is modified i.e. partially acidulated (PAPR). Alaboratory incubation study using the isotopic exchange kinetic method of³²P and field experiments were undertaken on a neutral Ferralsol ofCuba to evaluate the effectiveness of PAPRs as fertilizers for common bean(Phaseolus vulgaris, L.). Sulfuric-acid based PAPR using40%, 50% and 60% of the acid required to produce singlesuperphosphate were studied. In the laboratory experiment Trinidad de GuedesPAPR was effective in providing P to the soil, through increases inisotopicallyexchangeable P and the percentage of P derived from fertilizer (%Pdff). In the three field experiments carried out to compare the P sources,yields of common bean were increased by PAPR, though the response was less thanwith triple superphosphate (TSP). The relative agronomic effectiveness (RAE) ofPAPR was greater than that of unacidulated PR. Taking into account the RAEvalues and the current cost of the P sources, the choice of Trinidad de GuedesPAPR instead of TSP could be economic, although the RAE value for PAPR waslowerthan that of TSP. This result indicates that PAPR could be used in thesoil understudy to obtain the best economic return. DM yield, P uptake and grain yield ofcommon bean were significantly increased by applying P as 50% PAPR. Lowcost improvement of the agronomic value of PR can be achieved by partialacidulation, so this modification of the phosphate rock show promise forutilization of PR reserves indigenous to developing countries.     

Alleviating soil fertility constraints to increased crop production in West Africa: The experience in the Sahel

Lack of moisture limits crop production in semi-arid west Africa but poor soil fertility is a more serious constraint in the long run. Work done by IFDC and ICRISAT showed that phosphorus is the most limiting nutrient although response by millet to nitrogen when moisture and P are non-limiting can be substantial. A summary of the results of field trials in Niger showed that the sufficiency level for P estimated by regression analysis on the basis of Bray 1 extractable P is 7.9µg P/g of soil for 90% of maximum yield of millet. Application of 15–20 kg P/ha was usually adequate for optimum yields. Matam phosphate rock (PR) from Senegal, Tilemsi PR from Mali and Tahoua PR from Niger which are medium reactive were found to be suitable for direct application while partial acidulation (50% with sulfuric acid) of the less reactive phosphate rocks resulted in products with similar agronomic effectiveness as commercial superphosphates. Tests conducted by farmers showed that millet yields can be increased by more than 250% by the use of fertilizers. The need for constant monitoring of the crop needs for sulfur and potassium under continuous cultivation was highlighted.     

Comparison of efficiency of Mussoorie partially acidulated phosphate rock and single superphosphate in a shallow Alfisol of the Indian semiarid tropics

The agronomic effectiveness of a partially acidulated phosphate rock (PAPR) was measured in a field experiment with sorghum (Sorghum bicolor cv. CSH-6) in a shallow Alfisol at the ICRISAT farm, Patancheru (Hyderabad), India. The experiment compared PAPR with single superphosphate. The PAPR was made by acidulating an indigenous Indian phosphate rock (Mussoorie) with H₂SO₄ at 50% acidulation level. P response was evaluated at a single relatively high N rate (120 kg ha^–1) with five rates of P (0, 2.2, 4.4, 8.8, and 17.6 kg P ha^–1). A significant response to P was obtained at rates up to 17.6kg P ha^–1.There was no significant difference due to source of P in terms of sorghum grain yield or total P uptake. Both Olsen and Bray 1 soil tests underestimated P availability from PAPR with respect to that from SSP.A rapid rate of P uptake was observed during grain filling to maturity (81–102 days), when 40% of the total P was taken by the plant. The internal efficiency of both P sources was the same.     

Long-term greenhouse evaluation of partially acidulated phosphate rock fertilizers

The agronomic effectiveness (yield and P uptake) of twelve granular, partially acidulated phosphate rock fertilizers (PAPR) and two finely ground, unacidulated phosphate rocks (PR) were compared to that of a single superphosphate in a long-term greenhouse experiment with lucerne (Medicago sativa L., cv. CUF101), grown in a low P sorbing, moderately acid, sandy loam soil of moderate P status (Paleustaf). The PAPRs were prepared from two unreactive PRs (Christmas Is. A grade and Duchess rock from Queensland) and acidulated at two rates (25% and 50% on a H₂SO₄ to single superphosphate basis) with either H₂SO₄ or H₃PO₄. Additional products included H₂SO₄ PAPRs cogranulated with elemental S (10% w/w).Superphosphate was consistently superior to all PRs and PAPRs in agronomic effectiveness throughout this two-year study. The most effective of the PAPRs were those that were 50% acidulated with H₂SO₄ and cogranulated with elemental S; this type of fertilizer from both rocks was approximately 2/3 as effective as superphosphate when relative agronomic effectiveness indices (RAE) were calculated from cumulative yields. The increase in agronomic effectiveness relative to superphosphate (RAE value) by the partial acidulation of the PR could be attributed to its effect of increasing the P solubility in the PAPR. A curvilinear relationship existed between the RAE values of PRs and PAPRs, measured from cumulative yield or P uptake data, and the percentage of the total P in each fertilizer that was in a soluble (water + citrate soluble) form. Cogranulation with elemental S (10% w/w) significantly displaced this relationship upwards by increasing the RAE of H₂SO₄ PAPRs by more than 50%. The maximum cumulative recovery of applied P by lucerne tops after five bulked harvests (fifteen consecutive harvests) was 61.5%, which occurred at the low application rate of superphosphate. The decline in the substitution value of PRs for superphosphate, that occurred with increasing P rates tended to be offset both by increasing the level of acidulation and by cogranulating the PAPR with elemental S.     

Partially acidulated reactive phosphate rock (PAPR) fertilizer and its reactions in soil

PAPR was made by partial acidulation of North Carolina phosphate rock with H₃PO₄. The PAPRs were incubated in bands in columns of two soils of contrasting P retention. The columns were sampled after freezing and sectioning with a cryomicrotome. The movement of P in soil incubated with³³P-labelled PAPR was followed by autoradiography of polished epoxy impregnated sections of the freeze-dried soil column. PAPR solubility was also studied by a sequential dialysis process using distilled deionised water. The acid solution resulting from the dissolution of monocalcium phosphate (MCP) in PAPR moved into the surrounding soil, solubilizing soil minerals and creating a low-pH front with a high concentration of P. Depending on the soil, phosphorus moved 6–14 mm away from the fertilizer/soil interface by mass flow and diffusion in two days. The increase in 0.5 M NaOH extractable P above that of untreated soil showed a maximum at the same position as the pH minimum in the soil. In both soils, the total P movement from the fertilizer band after a two day period for 50% PAPR was comparable to that for 100% acidulation (triple superphosphate), indicating that acidulations above 50% did not necessarily increase the movement of soluble P from the fertilizer pellet. Variations in pH in the fertilizer-affected soil could be explained by the net balance of acidity resulting from incoming acid P solution and release of OH^– during P sorption. The rock residue exhibited a transient loss in solubility which was reversed on subsequent dissolution, suggesting a possible surface alteration.     

Evaluation of the agronomic effectiveness of natural and partially acidulated phosphate rocks in several soils using32P isotopic dilution techniques

The agronomic effectiveness of two natural phosphate rocks (PRs) from North Carolina (USA) and Togo and their 50% partially acidulated products (PAPRs) was evaluated in two greenhouse experiments using³²P isotopic dilution techniques, namely L and A_L values.In the first experiment rye grass was grown in a soil from Ghana. While the proportion of P in the plant derived from the P fertilizer (Pdff) ranged on. the average from about 10% for the PRs up to 80% for the PAPRs, the P fertilizer recovery was less than 1% for a 60-day growth period. In the second experiment, average values of P in the maize plants derived from the PAPRs ranged from 35% to 75% in 3 different soils. Both PRs were ineffective with the exception of North Carolina PR in the Seibersdorf soil. The P fertilizer recovery was 0.25% for the North Carolina PR in this soil whereas the recovery values ranged from 1.2% to 1.6% for the PAPRs.Mean values of the relative fertilizer efficiency estimated from the L values of each soil were less than 1% for the PRs whereas the values for the PAPRs which were dependent on soil type ranged from 20% up to 45%. The coefficient of relative effect of partial acidulation, that was calculated from the ratio of A_L values for PR and PAPR in each soil indicated that partial acidulation increased the effectiveness of the natural PRs in all soils under study.This study showed that the use of³²P isotope dilution techniques allows an accurate measurement of the P availability from natural and modified PR products to crops. Another advantage is that quantitative comparison of the P sources under study, PRs and PAPRs in this case, can be made even in soils where there is no response to the applied P sources.     

Enhancing the agronomic effectiveness of natural phosphate rock with poultry manure: a way forward to sustainable crop production

Phosphorus inputs are required in highly weathered tropical soils for sustainable crop production. However, high cost and limited access to mineral P fertilizers limit their use by resource-poor farmers in West Africa. Direct application of finely ground phosphate rock (PR) is a promising alternative but low solubility of PR hampers its use. Co-application of PR with manure could be a low cost means of improving the solubility of natural PR and improve their agronomic effectiveness. Our objective was to quantitatively estimate the enhancement effect of poultry manure on P availability from low reactive PR (Togo phosphate rock) applied to highly weathered soils. We utilized two highly weathered soils from Ghana and Brazil for this greenhouse study. Using ³²P isotopic tracers, the agronomic effectiveness of poultry-manure-amended Togo rock phosphate (TPR) was compared with partially acidulated Togo rock phosphate (PAPR) and triple superphosphate (TSP). Four rates of poultry manure: 0, low (30 mg P kg⁻¹ soil), high (60 mg P kg⁻¹ soil) and very high (120 mg P kg⁻¹ soil) were, respectively, added to a constant amendment (60 mg P kg⁻¹ soil) of the P sources and applied to each pot of 4 kg soil. A Randomized Complete Block Design was used for the greenhouse experiment and Maize (Zea mays L.) was used as a test crop. The plants were grown for 42 days after which the above ground biomass was harvested for analysis. Without poultry manure addition, the agronomic effectiveness, represented by the relative agronomic effectiveness (RAE) and proportion of P derived from fertilizer (% Pdff) was in the order TSP > PAPR > TPR = control (P₀). In the presence of low rate poultry manure addition, the agronomic effectiveness followed the order TSP > PAPR = PR > P₀. However, at the high and very high rates of poultry manure addition, no significant differences in agronomic effectiveness were observed among the P sources, suggesting that at this rate of poultry manure addition, PR was equally as effective as TSP. The study showed that direct application of PR co-applied with poultry manure at a 1:1 P ratio will be a viable option for P replenishment. Thus a combination of PR and poultry manure could be a cost-effective means of ensuring sustainable agricultural production in P-deficient, highly weathered tropical soils.     

Evaluation of the Bray 1, calcium acetate lactate (CAL), Truog and Colwell soil tests as predictors of triticale grain production on soil fertilized with superphosphate and rock phosphate

In a field experiment in Western Australia, six different levels of three different phosphorus (P) fertilizers (triple superphosphate, TSP; Queensland (Duchess) rock phosphate, QRP; North Carolina rock phosphate, NCRP) were applied at the start of the experiment in 1984. Grain yield of triticale (×Triticosecale) was measured from 1984 to 1988. In February-March of each year from 1985 to 1988, soil samples were collected to measure soil extractable P (soil test values) using four reagents (Bray 1, calcium acetate lactate (CAL), Truog and Colwell). Soil test values were related to triticale grain yields, determined either as absolute yield or percentage of the maximum yield, produced later on in each year. The relationship differed with fertilizer type, reagent and year. All four soil test reagents were equally predictive of yield. It is concluded that these soil P tests provide crude predictions of plant yield regardless of the reagent used.     

Unacidulated and Partially acidulated phosphate rock: Agronomic effectiveness and the rates of dissolution of phosphate rock

The agronomic effectiveness of unground North Carolina phosphate rock (PR) and partially acidulated phosphate rocks (PAPR) prepared by acidulation of the PR with 30%, 40% and 50% of the phosphoric acid needed for complete acidulation, was determined in a 4 year field experiment on permanent pastures. The soil developed from volcanic ash, and was highly P retentive. The rate of dissolution in soil of the PR component in PAPR and of PR applied directly was measured, together with bicarbonate extractable P. The priming effect of the monocalcium phosphate (MCP) component of PAPR on root growth was also investigated.Pasture yields showed that even the 30% acidulated PAPR was as effective as fully acidulated triple superphosphate (TSP), mainly due to the high reactivity of the PR used. The 50% acidulated PAPR tended to be superior to TSP. Soluble P in PAPR caused a marked increase in root proliferation, and dry matter yields were greater than predicted from the amounts of MCP and PR in PAPR. Directly applied PR was inferior to TSP in years 1 and 2 but was equal in year 4. (There was no pasture response to application of P fertilizers in year 3.)Dissolution rates of the PRs were determined applying a cubic model to PR dissolution data. The rate of dissolution increased with increasing acidulation and this is tentatively ascribed to increased root proliferation around PAPR granules and acidification of the clover rhizosphere during nitrogen fixation.     

A comparison of five soil phosphorus tests for five crop species for soil previously fertilized with superphosphate and rock phosphate

The P_i, Colwell, Bray 1, calcium acetate lactate (CAL) and Truog phosphorus (P) soil test reagents were assessed in two field experiments on lateritic soils in Western Australia that had been fertilized four years previously (1984) with triple superphosphate, North Carolina rock phosphate, Queensland rock phosphate, and in one experiment, Calciphos. Soil samples to measure soil P test were collected February 1987. Soil P test was related to seed (grain) yields measured later in 1987. Different crop species were grown on different sections of the same plot at each site. The species were lupins (Lupinus angustifolius), barley (Hordeum vulgare) and oats (Avena sativa) at one site, and lupins, oats, triticale (×Triticosecale) and rapeseed (Brassica napus) at the other site. For each reagent, the soil P test calibration, which is the relationship between yield, expressed as a percentage of the maximum yield, and soil P test, generally differed for different plant species and for different fertilizer types. Variations in soil P test required to produce half the maximum yield of each species at each site was least for the CAL reagent followed by the Colwell reagent.     

Differential influence of soil pH on the availability of partially sulphuric and phosphoric acidulated phosphate rocks II. Chemical and scanning elecronmicroscopic studies

Part I of this study showed that the plant availability of P from a reactive phosphate rock (PR), North Carolina PR, partially acidulated with phosphoric acid (Phos-PAPR) increased with decreasing soil pH from pH 6.1 to 5.1, whereas availability from a blend of similarly reactive PRs partially acidulated with sulphuric acid (SA-PAPR) changed little. The present study was carried out to explain the above results. Phosphate sorption maximum of soil as a function of soil pH was determined. Soil samples obtained at the completion of the pot experiment [5] were analysed for inorganic P fractions, and the amounts of PR dissolved from the PAPRs were determined. A leaching study, simulating pot experiment conditions, was conducted to determine the changes in the chemical composition and the spatial distribution of P, S and Ca in the fertilizer residues. The properties of the PAPRs were further characterised by sequential extraction of the fertilizers. Phosphate sorption isotherms indicated a smaller amount of P in solution at lower pH values, which suggested reduced P availability with decreasing soil pH. Dissolution of the residual PR-P was generally greater in Phos-PAPR treatment than in PR applied directly or in the SA-PAPR treatment. PR-P dissolution in Phos-PAPR increased with decreasing pH but not in SA-PAPR. Chemical, electron microprobe, X-ray micro-analysis and X-ray powder diffraction studies of the fertilizer residues obtained from the leaching and sequential extraction experiments showed rapid dissolution of the Ca(H₂PO₄)₂ phase of the fertilizers but the CaSO₄.XH₂O persisting as a cementing phase between the PR particles. The CaSO₄.XH₂O which intially existed mostly in an anhydrous form changed to gypsum. It was concluded that the dissolution of PR-P in the SA-PAPR was impeded by the presence of CaSO₄.XH₂O acting as a physical barrier and also by providing higher Ca in solution than that would exist in a saturated solution of the apatites. This revised version was published online in August 2006 with corrections to the Cover Date.