双水相萃取技术研究现状

近年来,双水相萃取(ATPE)已经发展成由计算机控制、在常规萃取设备中、能连续操作的分离技术。介绍了传统双水相体系(ATPS)和新型ATPS的特征、分相机理、工业应用的优缺点,指出寻找低成本易回收可循环利用的ATPS组成物质和对预分离物质有更高选择性的ATPS组成物质是研发新型ATPS的方向。论述了ATPS液液平衡的热力学模型、分配系数的关联方法,指出提高选择性及分离效率是ATPE应用研究的方向,指出总结分配系数影响因素规律、修正液液平衡的热力学模型是ATPE理论研究的方向。     

Extraction of Puerarin using Ionic Liquid Based Aqueous Two-Phase Systems

Various ionic liquid-based aqueous two-phase systems (IL-ATPS) were evaluated to extract puerarin. The results indicated that the nature of ILs, the salting-out ability of salt, and the acidity and basicity of the salt-rich solution had important influence on the extraction efficiency. Various factors were optimized systematically, that is, the amount of IL, salt, puerarin, and short-chain alcohol. Under the optimal experimental conditions (the amount of K₂HPO₄ 0.30–0.42 g/mL, [Bmim]Br 0.30–0.36 g/mL and 1.0 mL puerarin stock solution), the extraction efficiency of puerarin was over 99% by a single-step extraction, which indicated that the evaluated IL-ATPS was a prospective extraction medium. Finally, the IL-ATPS was successfully used to extract puerarin from Radix Puerariae Lobatae extracts.     

双水相体系萃取木瓜蛋白酶的研究

采用聚乙二醇(PEG)/(NH4)2SO4双水相体系对木瓜蛋白酶进行萃取分离,研究了PEG相对分子量、PEG质量分数、(NH4)2SO4质量分数和pH值对木瓜蛋白酶分配系数及酶活力回收率的影响.结果表明,最佳萃取条件为:PEG4000质量分数6%、(NH4)2SO4质量分数18%、pH值6.0,在此条件下,木瓜蛋白酶的...     

双水相萃取技术的应用进展

主要介绍了双水相萃取的基本要点及应用特点,综述了近三年来双水相萃取技术在生物工程、药物成分提取分离、环境中有害物分离测定及与其它方法配合使用等方面的应用,探讨了双水相萃取技术的应用前景.     

离子液体[BPy]BF_4双水相萃取芦丁的研究

建立了由亲水性离子液体四氟硼酸N-丁基吡啶[BPy]BF4和(NH4)2SO4形成的双水相体系萃取分离芦丁的新方法。研究了(NH4)2SO4浓度、芦丁溶液浓度、离子液体用量和溶液酸度对双水相形成和萃取率的影响。结果表明,当双水相体系组成为:(NH4)2SO41.5 g,2.0 mL离子液体,1.0~1.2 mL芦丁溶液,溶液酸度在pH4~6范围内,该离子液体双水相体系对芦丁有较高的萃取率(E%>90)。     

表面活性剂双水相分离茶多酚生产废液中的茶氨酸(英文)

Extraction of theanine from waste liquid of tea polyphenol production was studied in aqueous surfactant two-phase system (ASTP) with cationic surfactant (CTAB) and anionic surfactant (SDS). Results indicate that the region of ASTP is narrow and there is only a two-phase region of cationic surfactant. The increase in concentrations of NaBr and Na2SO4 are beneficial to the formation of ASTP. Theanine concentration in the bottom phase increases with increasing concentration of theanine, whereas the partition coefficient and extraction rate only change a little when the concentration of theanine is above 0.2 g·L-1 . With the increase of SDS concentration, the phase ratio and the partition coefficient decrease, while the extraction efficiency of theanine increases and the concentration of theanine changes a little in the range from 2.4/7.5 to 2.8/7.2 for SDS/CTAB ratio. The temperature has a notable effect on the concentration of theanine in the bottom phase, partition coefficient and extraction rate of theanine. The increase of waste liquid decreases the phase ratio, increases the concentration and extraction rate of theanine in the bottom phase, since the protein and the saccharide enter the bottom phase with theanine.     

Application of Water-Miscible Alcohol-Based Aqueous Two-Phase Systems for Extraction of Dyes

The water-miscible alcohols (ethanol, 1-propanpol, 2-propanol) were used to form aqueous two-phase systems with K₂HPO₄ and Na₂HPO₄. Meanwhile, the organic citrates were also investigated as the phase-separation salts. The effects of the types and concentrations of phase-forming substances as well as temperature on the formation of aqueous two-phase systems were discussed. The alcohol (ethanol, 1-propanpol, 2-propanol)–salt (K₂HPO₄, K₃C₆H₅O₇, (NH₄)₃C₆H₅O₇) aqueous two-phase systems were used to extract Rhodamine B and methyl orange in aqueous solution. It proved that the water-miscible alcohol–salt (inorganic salt, organic salt) aqueous two-phase systems can be both used to extract hydrophilic targets directly without adding any reaction reagents. The aqueous two-phase extraction process was also discussed.     

双水相萃取技术及其在药物分离中的应用

双水相萃取技术作为一种新型的分离技术用于药物提取分离具有广阔前景。介绍了双水相体系的组成,双水相萃取技术原理、工艺过程、应用等。     

Potassium Phosphate Salts-Based Aqueous Two-Phase Systems Applied in the Extraction of Gallic Acid from Guava

Aqueous two-phase systems (ATPS) consisting of potassium phosphate salt + alcohol or polyethylene glycol were investigated to extract gallic acid. The partitioning process was studied using purity gallic acid (GA). The constituents either promote the partition process of GA to bottom or top phase, leading to the creation of versatile systems. The salt acts as a drive force of process because it influences the value of phase pH, and consequently the deprotonation of biomolecule and its partition. The results using GA from guava are in close agreement with the model systems, validating the experimental data and supporting their applicability in real systems.     

双水相萃取废液中成相物质聚乙二醇的回收利用

研究了双水相萃取废液中聚乙二醇的回收利用,旨在降低生产成本,减少COD排放,推动双水相萃取技术的工业应用进程。以聚乙二醇-硫酸铵[PEG-（NH4）2SO4]组成的双水相体系废液为原料,采用脱色、浓缩、洗涤除去杂质的工艺技术路线,确定了从双水相废液中回收成相聚合物PEG的最佳工艺（：1）利用H2O2法脱色,最佳脱色条件：H2O2浓度为6%,脱色温度为60℃,脱色时间为4 h,体系pH值为9.0,脱色率达到85%以上（;2）采取盐析法浓缩,最佳电解质种类为Na2SO4,最佳加入量为每10 mL废液3.0 g Na2SO4,此时PEG浓缩比为3.45,PEG损失率为0.31%。按照药用级PEG产品质量标准,对干燥后的回收物进行质量检测。结果表明：回收的PEG产品外观呈浅黄色蜡状,电导率为10.8μs/cm,凝固点为37～40℃,pH值（5%水溶液）为6.33,较纯品PEG无明显差异。     

双水相萃取法应用于从白萝卜中快速提取过氧化物酶

基于双水相萃取法在化工分离上的优点,研究了其应用于从白萝卜中快速提取过氧化物酶的可行性。结果表明,相对于传统盐析法,应用聚乙二醇/硫酸铵双水相萃取法从白萝卜中提取过氧化物酶具有快速、操作简单、提取率高、成本低及可以使生产规模化等优点。本研究对于过氧化物酶制剂的工业化生产或开发利用白萝卜等具有重要意义。     

Tunable Aqueous Polymer Phase Impregnated Resins: A Combination of the Extractant Impregnated Resin Principle and Aqueous Two-Phase Systems

This scientific note introduces a concept supposed to enhance aqueous two-phase extraction by immobilizing one of the two phases of an aqueous two-phase system in porous particles. This approach, developed by the author, is based on solvent impregnated resins. The resulting so-called (tunable) aqueous polymer phase impregnated resins might avoid drawbacks of aqueous two-phase extraction, such as long phase separation times due to persistent emulsification. Due to the novelty of the idea and resulting current lack of fundamental studies, the idea is put up to discussion in order to initiate scientific exchange and hopefully widespread investigation of its true potential.     

两种双水相体系提取枇杷叶中黄酮的工艺研究

以枇杷叶为原料,利用双水相体系提取黄酮。考察了聚乙二醇-硫酸铵体系和乙醇-硫酸铵体系中各物质用量、料液比(g∶mL,下同)、pH值、提取温度、提取时间等条件对提取效率的影响,并对两种体系的提取效率进行了比较。结果表明:聚乙二醇-硫酸铵体系中,在聚乙二醇用量为2.0g、硫酸铵用量为1.5g、料液比为0.3∶10、pH值为9、提取温度为40℃、提取时间为1.5h的条件下,提取效率最高,达5.80%;乙醇-硫酸铵体系中,在无水乙醇用量为4.0mL、硫酸铵用量为1.8g、料液比为0.2∶10、提取温度为40℃、提取时间为1.0h的条件下,提取效率最高,达7.49%;可见乙醇-硫酸铵体系的黄酮提取效率高于聚乙二醇-硫酸铵体系。     

Phase Behavior of Ionic Liquid-Based Aqueous Two-Phase Systems

As an environmentally friendly separation medium, the ionic liquid (IL)-based aqueous two-phase system (ATPS) is attracting long-term attention from a growing number of scientists and engineers. Phase equilibrium data of IL-based ATPSs are an important basis for the design and optimization of chemical reactions and separation processes involving ILs. This article provides the recent significant progress that has been made in the field and highlights the possible directions of future developments. The effects of each component (such as salting-out agents and ILs) on the phase behavior of IL-based ATPSs are summarized and discussed in detail. We mainly focus on the phase behavior of ATPSs by using ILs, expecting to provide meaningful and valuable information that may promote further research and application.     

双水相分离纯化荷叶中黄酮类化合物

采用PEG/硫酸铵双水相体系分离纯化荷叶黄酮。实验结果表明：在PEG 4000的质量分率为25%,（NH4）2SO4的质量分率为10%,加入粗提液3 mL,在常温下,荷叶黄酮的萃取率可达97%以上。     

核桃叶黄酮类化合物的双水相与超声耦合提取

将超声波提取技术与丙醇-硫酸铵双水相分离技术进行耦合,从核桃叶中提取黄酮类化合物,提取率为13.9%。与传统的有机溶剂回流提取法(提取率14.2%)相比,该法的提取率略低,但提取过程中体系的温度不会大幅度升高,可有效地保持黄酮的生物活性,而且双水相分离使黄酮的纯度得以提高。     

Aqueous Two-Phase Extraction of Lactic Acid: Optimization by Response Surface Methodology

In this study a suitable alcohol/salt aqueous two-phase (ATP) system was selected for the recovery of lactic acid from an aqueous solution. From the different ATP systems studied, the ethanol/dipotassium hydrogen phosphate ATP system appeared to be favorable. To examine the potential of this ATP system, the extraction yield of lactic acid in aqueous solutions was optimized with the response surface methodology. The parameters studied were concentrations of ethanol (22.00–38.80%, w/w), dipotassium hydrogen phosphate (15.00–31.80%, w/w) and lactic acid (26.36–93.64 g/L). The optimum conditions were found to be 30.23% w/w ethanol, 18.40% w/w dipotassium hydrogen phosphate, and 80 g/L lactic acid. Under these conditions, a favorable extraction yield of lactic acid was obtained. The maximum partition coefficient of lactic acid and extraction yield was determined as 2.26 and 87%, respectively. The optimum extraction conditions were then used to guide the recovery of lactic acid from a real fermentation broth. As a result, the partition coefficient and extraction yield of lactic acid reached 2.06–80%, respectively.     

聚乙二醇-硫酸铵双水相萃取结晶紫的研究

利用分光光度法研究了结晶紫在聚乙二醇-硫酸铵双水相体系中的萃取行为,探讨了质量配比(mPEG/m(NH4)2SO4)、温度、结晶紫浓度对结晶紫的分配系数(cup/clow)及萃取率的影响。结果表明,在一定的温度和结晶紫浓度下,随着质量配比的减小,结晶紫的分配系数增大,萃取率略有降低;在一定的质量配比和结晶紫浓度下,随着温度的升高,分配系数显著增大,萃取率基本保持不变;在一定的质量配比和温度下,随着结晶紫浓度的增大,分配系数显著减小,萃取率基本保持不变;在mPEG/m(NH4)2SO4为1.25∶1、结晶紫浓度为6.536×10-5 mol.L-1、温度为50℃的条件下,萃取率高达99.81%。     

Measurement of Mass Transfer Coefficients and Their Modelling of Continuous Counter-Current Aqueous Two-Phase System in a Packed Extraction Column

Overall dispersed side volumetric mare transfer coeffcieats for protein and amino acids were measured in continuous countercurreat PEG4000/KHP aqueous two-phase systems in a 57 mm I.D. packed extraction column. A model for overall dispersed side volumetric mass transfer coefficients was derived by describing the motion of the drops based upon Navier-Stokes equation combined with the relationship between mass transfer coefficients and the drop velocity. The model provides good predictions and can be successfully used in aqueous two-phase extraction. The awrage relative deviation between calculated values and experimental date ranges from 8% to 14%.     

Partitioning of Propionic Acid in Polyethylene Glycol/ Different Salts of Sulfate Aqueous Two-Phase Systems

The extraction of propionic acid has been studied by liquid–liquid extraction with poly ethylene glycol /different salts of sulfate aqueous two-phase system (ATPS). In this study, a multilevel factorial design was applied to evaluate the effects of four independent variables (PEG molecular weight, type of salt, salt concentration, and temperature) on propionic acid extraction yield. The statistical significance of each factor was evaluated by an analysis of variance. The results indicated that the type and concentration of salt were the major contributing factors to propionic acid extraction. The PEG4000/ MnSO₄ system was suitable for the extraction of propionic acid from dilute water.