Preparation of alcalase hydrolysed rice bran protein concentrate and its inhibitory effect on soybean lipoxygenase activity

Rice bran protein concentrate (RBPC) was prepared from defatted rice bran and hydrolysed by alcalase at different hydrolysis times. As the hydrolysis times increased, the degree of hydrolysis (DHs) increased. RBPC hydrolysate obtained at 50 min (RBPCH‐50) had the highest inhibitory efficiency on soybean lipoxygenase (LOX) activity (66%). The inhibition kinetics of the reaction analysed by Lineweaver–Burk plots indicates that RBPCH‐50 is a competitive inhibitor. RBPCH‐50 inhibited soybean LOX with an IC₅₀ of 11.73 μg μL^?1 RBPCH‐50, and the obtained K_I was 4.59 μg μL^?1 RBPCH‐50. LOX inhibitory activity of RBPCH‐50 was significantly higher than that of 50 and 100 ppm butylated hydroxyanisole (BHA) and 50, 100, and 200 ppm butylated hydroxytoluene (BHT) (P ≤ 0.05); however, LOX inhibitory activity of RBPCH‐50 was similar to that of 200 ppm BHA (P > 0.05). Therefore, RBPCH might potentially be used as a natural LOX inhibitor.     

Reduction of Listeria monocytogenes in cold‐smoked salmon by bacteriophage P100, nisin and lauric arginate,singly or in combinations

Three GRAS antimicrobials including, lauric arginate (LAE), bacteriophage P100 (phage P100) and bacteriocin nisin, were evaluated either singly or in combinations for the reduction of initial load of Listeria monocytogenes in cold‐smoked salmon (CSS). The stability of phage P100 in the presence of LAE (200 ppm) and nisin (500 ppm) or at 10× and 100× of these concentrations was determined at 4 °C or 30 °C for 24 h in a broth model. Phage P100 was found to be highly stable in the presence of these antimicrobial agents as plaque‐forming units (PFU) did not vary between control and antimicrobial‐treated phage. The survival of L. monocytogenes in the presence of phage P100, nisin and LAE showed remarkable reduction within 24 h both at 4 °C or 30 °C in broth. Treatment of CSS containing 3.5 log CFU cm^?2 L. monocytogenes with phage P100 (10⁸ PFU mL^?1), nisin (500 ppm) and LAE (200 ppm) showed strong listericidal action and reduced the L. monocytogenes by 2–3 log CFU cm^?2 after 24 h. Among the combined treatments, phage P100 + LAE or nisin + LAE exhibited the most listericidal action in which L. monocytogenes cells were reduced to undetectable level within 24 h in CSS.     

Evaluation of a novel antimicrobial (lauric arginate ester) substance against biofilm of Escherichia coli O157:H7, Listeria monocytogenes,and Salmonella spp.

The purpose of this study was to evaluate the activity of a novel antimicrobial substance lauric arginate ester (LAE) against selected foodborne pathogens (Escherichia coli O157:H7, Listeria monocytogenes and Salmonella spp.) in biofilm. Minimal inhibitory concentration (MIC) and minimal bactericidal concentration (MBC) were determined and showed that LAE exhibits a strong antimicrobial activity. Biofilms were grown on abiotic stainless steel, rubber, MBEC biofilm device) and biotic (lettuce) surfaces. The efficacy of LAE (50, 100 and 200 ppm) at reducing the biofilm cells on these surfaces was examined by applying LAE for 2 h. Results revealed that LAE exhibited the reduction in biofilm bacteria up to 7 log CFU cm^?2, 3.5 log CFU cm^?2, 4.0 log CFU peg^?1 and 1.5 log CFU cm^?2 on stainless steel, rubber, MBEC and lettuce surfaces, respectively. Overall, these results suggest that LAE has been shown to be a potential alternative to control bacteria in biofilm mode in food industry.     

Evaluation of the effects of sodium chloride,potassium sorbate,nisin and lysozyme on the probability of growth of Clostridium sporogenes

The aim of this study was to evaluate the combined effect of salt (sodium chloride, 0–8% w/v), sorbate (potassium sorbate, 0–4.5% w/v), nisin (0–500 ppm) and lysozyme (0–500 ppm) on the survival of Clostridium sporogenes as a non‐toxigenic surrogate of Clostridium botulinum in terms of the probability of growth by using a central composite rotatable design. The results indicated that salt and sorbate were the most effective factors in preventing the growth of Cl. sporogenes in high‐moisture (>95%) and low‐acid conditions. The probability of growth of Cl. sporogenes in broth was reduced by combinations of salt and sorbate. Nisin and lysozyme had insignificant effects on the probability of growth of Cl. sporogenes (P > 0.05). Lysozyme individually and in combination with nisin had no inhibitory effect on Cl. sporogenes. Overall, the addition of sorbate and lysozyme may allow the salt concentration to be reduced while preventing growth.     

Application of magnetic immuno-polymerase chain reaction assay for detection of <Emphasis Type="Italic">Salmonella</Emphasis> spp. in chicken meats

Since contaminated chicken meats have been the principal foodborne source of the contamination of Salmonella to human beings and cultural detection methods are labor-intensive and time-consuming, a study evaluating the performance of the combination of two techniques that are immunomagnetic separation (IMS) and polymerase chain reaction (PCR) for the detection of Salmonella in chicken meats was conducted. The IMS and PCR assay combines selective extraction of Salmonella by specific antibodies with primer-specific (primer pair based on the sequence of invA gene) PCR amplification. Initially chicken meat samples, in which no Salmonella contamination had been determined by using ISO 6579 reference method, were inoculated with Salmonella Enteritidis culture and subsequently the shortest non-selective pre-enrichment time, that had been needed for the detection of approximately 1 or 10 CFU/mL chicken meat levels of target bacteria by magnetic immuno-PCR assay, was found by using 14, 12, 10 and 8-h periods. In conclusion, it was found that magnetic immuno-PCR assay was able to detect 1–10 CFU Salmonella/25 g chicken meat, after only incorporating a non-selective pre-enrichment period of 12 h. Therefore, an overall 16-h (magnetic immuno-PCR assay in conjunction with 12-h non-selective pre-enrichment) magnetic immuno-PCR assay statistically evaluated as sufficient (p = 0.182 > 0.05) for rapid and sensitive detection of approximately 1–10 CFU Salmonella from 25 g chicken meat samples. Accordingly, 16-h magnetic immuno-PCR assay can be promising for routine use in the detection of Salmonella in chicken meat samples, and it consequently may prevent the risk of Salmonella infections in regard to chicken meats.     

Effect of dietary olive leaves (Olea europaea L.) on lipid and protein oxidation of refrigerated stored n‐3‐enriched pork

The objective of this study was to evaluate the effect of dietary olive leaves versus α‐tocopheryl acetate on lipid and protein oxidation of raw and cooked longissimus dorsi muscle from pigs fed diets supplemented with fish oil. Enrichment of pork with the very long chain n‐3 fatty acids increased (P ≤ 0.05) lipid oxidation in both raw and cooked chops during refrigerated storage, and decreased (P ≤ 0.05) the sensory attributes of the cooked chops, but had no effect (P > 0.05) on protein oxidation of both raw and cooked chops. Dietary olive leaves or α‐tocopheryl acetate had no effect (P > 0.05) on the fatty acid composition but decreased (P ≤ 0.05) lipid oxidation while exerting no effect (P > 0.05) on protein oxidation in both raw and cooked chops during refrigerated storage. In addition, dietary olive leaves at 10 g kg^?1 feed and α‐tocopheryl acetate at 200 mg kg^?1 feed exerted (P ≤ 0.05) a beneficial effect on the sensory attributes of cooked n‐3‐enriched chops.     

Elucidation of colour development and microstructural characteristics of Allium sativum fumigated with acetic acid

It has been well known that the greening of Allium sativum cloves could be formed after immersed in acetic acid solution. Nonetheless, no investigation was reported on colour development of A. sativum in response to acetic acid vapour until now. In this study, the brief exposure of A. sativum to acetic acid vapour (200–400 ppm) was combined with controlled atmosphere (5%, 20% and 80% CO₂) packaging storage to break cell membrane and green garlic. The garlic bulbs were fumigated with acetic acid before controlled CO₂ atmosphere packaging for 25 days at 4 °C. Fumigation with 200 ppm acetic acid followed by high CO₂ atmosphere packaging (80% CO₂) facilitated the garlic greening. It was also verified that γ‐glutamyl transpeptidase was involved in garlic greening in present study, and the compromise of glacial acetic acid vapour fumigation and CO₂ gas atmosphere in package stored at low temperature could result in garlic greening as well.     

Effect of plant polyphenols and ascorbic acid on lipid oxidation,residual nitrite and N‐nitrosamines formation in dry‐cured sausage

The effects of green tea,grape seed polyphenols and ascorbic acid on pH, water activity (a_w), microbiological counts, TBARS, residual nitrite and N‐nitrosamines were determined in dry‐cured sausages during the ripening period. Results showed that TBARS increased gradually during ripening (P < 0.05), but were significantly reduced with plant polyphenols and ascorbic acid (P < 0.05). Green tea polyphenol (GTP) was most effective (P < 0.05) in reducing TBARS. Plant polyphenols and ascorbic acid significantly decreased residual nitrite, ascorbic acid being most effective (P < 0.05). The amount of N‐nitrosamines increased during ripening, but was significantly reduced with plant polyphenols and ascorbic acid (P < 0.05). Plant polyphenols had no significant effects on moisture content, a_w, pH or microbiological counts in dry‐cured sausage during ripening (P > 0.05). It was concluded that plant polyphenols and ascorbic acid were effective in maintaining the quality and safety of dry‐cured sausages.     

Enhancement of the antioxidant and starch hydrolase inhibitory activities of king coconut water (Cocos nucifera var. aurantiaca) by fermentation with kombucha ‘tea fungus’

Enhancement of antioxidant and starch hydrolase inhibitory properties of king coconut water when subjected to fermentation with the ‘tea fungus’ was evaluated. pH, colour, viscosity, ethanol content, antioxidant activity, total phenolic content, ferulic and p‐coumaric acid contents and starch hydrolase inhibitory activities were analysed for 7 days in fermented and unfermented king coconut water samples. The fermented sample had a statistically significant decrease (P < 0.05) in pH. Colour values indicated the fermented beverage to increase in ‘yellowness’ over time. A statistically significant increase in the total phenolic content and the antioxidant activity (P < 0.05) was observed from day 1 onwards in the fermented sample. The starch hydrolase inhibitory activities in the fermented beverage had statistically significantly increased (P < 0.05) by day 7. Overall, the study highlights an enhancement of the antioxidant and starch hydrolase inhibitory properties of king coconut water as a result of the kombucha‐based fermentation.     

Application of cold oxygen plasma for the reduction of Cladosporium cladosporioides and Penicillium citrinum on the surface of dried filefish (Stephanolepis cirrhifer) fillets

This study was conducted to investigate the effects of cold oxygen plasma (COP) on the reductions of Penicillium citrinum and Cladosporium cladosporioides on the surface of dried filefish fillets (Stephanolepis cirrhifer). The counts were significantly (P < 0.05) reduced with the increase in the treatment time (3–20 min) of COP on the fillets. However, no significant (P > 0.05) differences were observed in the counts between 3 and 5 min of COP. The average decrease in the counts of C. cladosporioides and P. citrinum caused by 3–20 min of COP was 0.91 and 1.04 log₁₀ CFU g^?1, respectively. A reduction of >1‐log₁₀ CFU g^?1 was observed on the fillets treated with COP for >10 min. Decimal reduction time (d_R) by Weibull model was 9.32 and 7.42 min of COP for C. cladosporioides and P. citrinum, respectively. The fillets exposed to 20 min of COP displayed increased thiobarbituric acid reactive substance (TBARS) and decreased overall sensory acceptance. However, the fillets treated with 10 min of COP received satisfactory TBARS and consumer acceptance. Therefore, a 10‐min COP could be effective in reducing >90% and inactivating of the mould without causing any deleterious changes to the physicochemical and sensory qualities of the fillet.     

Prevalence of the main food-borne pathogens in retail food under the national food surveillance system in Japan

The National Food Surveillance System in Japan was formed in 1998 to monitor the contamination of retail foods with bacterial pathogens. Approximately 2000–3000 samples were tested annually, and the data from food categories that had more than 400 samples collected during 1998–2008 were analysed. With regard to meat, the frequency of positive samples for Salmonella in chicken for raw consumption and ground chicken was 12.7% and 33.5%, respectively. Moreover, Shiga toxin-producing Escherichia coli (STEC) O157 was found in ground meat, organ meat and processed meat, although at a low frequency (0.1%). The prevalence of Campylobacter jejuni/coli was 13.3% and 20.9% in chicken for raw consumption and ground chicken, respectively. In vegetables and fruit, Salmonella was detected in cucumber, lettuce, sprout and tomato samples at a frequency of around 0.1–0.2%. With regard to seafood, Salmonella was found in 0.5% of oysters for raw consumption. Seafood was not contaminated with STEC O157 or Shigella. Serotype Infantis was the most frequently detected serotype of Salmonella in seafood, followed by the serotypes Typhimurium, Schwarzengrund and Manhattan. In ground chicken, 72.2% of the strains were identified as the serotype Infantis. E. coli, as an indicator of food hygiene, was detected in all food categories. The results show the prevalence of the above-mentioned pathogens in the retail food supplied in Japan; further, they indicate that consumption of raw food carries the risk of contracting food-borne infections.     

Sensory characteristics and storage quality indicators of surimi franks nutritionally enhanced with omega‐3 rich flaxseed oil and salmon oil

Surimi franks were fortified with flaxseed or salmon oil at 2 g/100 g sample, franks without added oil served as a control. Thiobarbituric acid reactive substances values were highest (P < 0.001) in salmon oil franks; however, these values did not change over the 21‐day storage period regardless of frank type (P > 0.05). Frank pH decreased over time (P = 0.011) for all frank types. There were differences in textural properties between frank types (P < 0.05), with the flaxseed franks being softer and less gummy, cohesive and chewy than the control franks. Participants (n = 79; age 18–35) evaluated visual appeal, colour, aroma, texture, flavour and acceptability on a hedonic scale; there were no differences (P > 0.05) between franks. Fifty‐four panellists reported consuming sausage on a weekly to monthly basis, and most (50/79) indicated interest in purchasing this type product. The surimi franks were accepted by young adult consumers, which may indicate market potential of these types of products.     

Neural network models for growth of Salmonella serotypes in ground chicken subjected to temperature abuse during cold storage for application in HACCP and risk assessment

Predictive microbiology models are valuable tools for helping to assess and manage the risk of illness from food contaminated with human pathogens, such as Salmonella. However, multiple versions of a model may be needed for different food safety applications, such as hazard analysis and critical control point (HACCP) programs and risk assessment. A neural network model for growth of Salmonella in ground chicken as a function of time (0 to 8 days) at 16 °C and serotype (n = 8) was developed. The proportion of residuals in an acceptable prediction zone (pAPZ) from ?1 log (fail‐safe) to 0.5 log (fail‐dangerous) was 0.948 for training data (n = 192) and 0.988 for testing data (n = 84). A pAPZ ≥0.7 indicated that the model provided predictions with acceptable bias and accuracy. Thus, the model was successfully validated. Different versions of the model were developed for application in HACCP and risk assessment.     

Quality changes of pork during frozen storage: comparison of immersion solution freezing and air blast freezing

This study evaluated the effects of freezing method and storage time on the quality changes of pork longissimus thoracis (LT). The results showed that, compared to air blast freezing (AF), better microstructure was observed in pork under immersion solution freezing (ISF) mainly due to higher freezing rate. ISF group had significantly lower thawing loss at 1, 31 and 91 days and higher shear force at 1 day than AF (P < 0.05). A significant reduction in TBARS value at 61 and 91 days was observed in ISF samples (P < 0.05). No significant differences were observed between the two treatments in the colour, cooking loss and sulfhydryl groups (P > 0.05). All quality indicators were significantly affected by storage time (P < 0.05). It is concluded that ISF could maintain better microstructure, improve water-holding capacity and inhibit lipid oxidation during pork LT frozen storage.     

Antioxidant activities of chicken liver hydrolysates by pepsin treatment

This study was divided into two parts: (i) an optimal hydrolysing procedure of chicken liver hydrolysates (CLHs) and (ii) the in vivo antioxidant properties of CLHs via a D‐galactose‐induced mouse model. A pepsin‐to‐raw chicken liver mass ratio (1:400, w:w) and 2‐h hydrolysing period were chosen to manufacture CLHs based on yield, peptide level and antioxidant effect. Molecular masses of CLHs were lower than 10 kDa. CLH was rich in aspartic acid and glutamic acid, and also contained both manganese and selenium, which are essential cofactors of superoxide dismutase and glutathione peroxidase, respectively. The contents of cadmium, mercury, tin, and arsenic in CLHs were very low and even no detectible. Regarding the in vivo antioxidant activity of CLHs, a dosage of 1.2 g D‐galactose kg^?1 body weight increased (P < 0.05) 2‐thiobarbituric acid reactive substances values and decreased (P < 0.05) glutathione and Trolox equivalent antioxidant capacity values, as well as superoxide dismutase, catalase, and glutathione peroxidase activities in serum and organs of mice. However, the in vivo antioxidant capacities were improved (P < 0.05) by supplementing CLHs.     

Effect of micronisation on dietary fibre content and hydration properties of lotus node powder fractions

Fibre‐rich fractions were obtained from nodes of lotus root and micronised by nine different ball‐milling treatments. The optimum milling conditions were screened out by comparing its effects on physicochemical and hydration properties of micro‐sized particles of lotus node powder fraction (LNPF). The micronisation by ball‐milling treatments was carried out at different speeds (200–400 r min^?1) and time (4–12 h). Ball‐milling treatments could effectively (P < 0.05) pulverise the LNPF particles to different micro‐sizes. As particle size decreased, a redistribution of fibre components from insoluble to soluble fractions was observed. Furthermore, micronisation treatments, especially 12 h at 300 r min^?1, could significantly (P < 0.05) increase the hydration characteristics, as well as impart lightness in colour to different extents. Our findings suggested that micronisation can improve physicochemical and hydration characteristics of the fibre components, which provide an opportunity to improve the utilisation and application of lotus node dietary fibre.     

Evaluation of physico‐chemical properties,trace metal content and antioxidant activity of Indian honeys

In this study, effect of plant sources viz. Gossypium hirsutum, Coriander sativum, Murraya koenigii and Dalbergia sisso on twelve physico‐chemical properties, phenolic content, flavonoids content as well as on trace mineral (Fe, Cu, Ni, Mn, Cd and Pb) contents of honey were investigated and compared. All the physico‐chemical values were in the range of approved limits of European Commission Regulation and the source of honey had a significant (P < 0.05) effect on physico‐chemical properties, phenol content, flavonoid content and trace mineral content. The results of positive correlations between physico‐chemical properties (colour and antioxidant properties) and compositional components (phenols and flavonoids content) established that antioxidant properties were dependent on source of honey rather than on colour of honey. Pattern recognition methods such as principal component analysis and linear discriminate analysis were performed to classify honey on the basis of physico‐chemical properties, phenolic content, flavonoids content and trace metal content. The variables proline and lead exhibited higher discrimination power.     

Polyphenolic and phytochemical content of Cucumis sativus seeds and study on mechanism of preservation of nutritional and quality outcomes in enriched mayonnaise

Oxidative rancidity in food emulsions leads to a reduction in shelf life. Synthetic antioxidants are widely used in food industry to prevent the development of rancidity. The present study was focussed on investigating the antioxidant potential of Cucumis sativus seeds (CSS) and correlates these findings with mayonnaise enrichment and extends its shelf life. CSS exhibited the highest abundance in phenolic compounds (93.5 ± 0.1 mgGAE g^?1), flavonoids (57.4 ± 0.1 mgQE g^?1), β‐carotene (19.46 ± 0.4 mg carotenoids per 100 g) and high free radical scavenging activity. CSS (200 ppm) and butylated hydroxyanisole (200 ppm) were incorporated in mayonnaise and the oxidative stability was evaluated by peroxide, p‐anisidine and TBARS values during storage at different temperatures. Organoleptic evaluations indicated that CSS enriched sample was recorded the highest overall acceptability. The results from our study will provide scientific basis for CSS as natural preservative against lipid oxidation or food enrichment while developing functional foods.     

Effect of hot water treatment of in-shell pecans on physicochemical properties and consumer acceptability of roasted pecan kernels

The effect of hot water pre-treatment of in-shell pecans on physicochemical properties, consumer acceptance and purchase intent of dehulled and roasted kernels was evaluated. In-shell pecans were first subjected to hot water at 70, 80 and 90 °C for 8.6, 6.6 and 4.6 min respectively and kernels were later dry roasted at 160 °C for 10 min. The physicochemical properties of hot water treated and untreated nuts, before and after roasting were determined. Furthermore, consumer acceptance and purchase intent of the roasted kernels were determined. Hot water treatment, alone and subsequent roasting had minimal effect on pecans’ physicochemical properties. Consumers liked (P < 0.05) the colour and aroma of treated pecans. No effect (P > 0.05) of pre-treatment was observed on the acceptability of other sensory attributes. Safety claim increased treated pecans’ overall liking; however, it decreased purchase intent. Hot water treatment showed promise as a post-harvest microbial intervention strategy without affecting the physicochemical properties and consumer acceptability.     

Effects of fat replacement with a mixture of collagen and dietary fibre on small calibre fermented sausages

Effects of fat replacement on physicochemical, microbial and sensory properties of fermented sausages were determined after drying process and 4 weeks of storage. Fermented sausages were formulated with 20% pork back fat (control), and three reduced‐fat treatments were prepared by replacing 25%, 50%, and 75% of fat with a mixture of collagen, dietary fibre and ice (1:1:8). TBARS values of reduced‐fat treatments were significantly lower compared with control after drying (P ≤ 0.05). As fat replacing ratio increased, fat content decreased significantly (P ≤ 0.05), whereas moisture, protein and ash content increased significantly (P ≤ 0.05). There was no marked difference between the treatments in terms of microbial analysis, sensory colour, flavour, off‐flavour or overall acceptability (P > 0.05) during refrigerated storage. Therefore, replacing pork back fat with a mixture of collagen and dietary fibre in fermented sausages may contribute to reduce lipid oxidation and maintain sensory properties during storage.