共查询到19条相似文献,搜索用时 109 毫秒
1.
2.
3.
4.
廖袁芳 《中国石油和化工标准与质量》2011,31(4)
离子交换法除盐是传统的除盐工艺。目前,反渗透法除盐越来越多地应用于锅炉给水处理等除盐工艺中,与离子交换法相比,孰优孰劣,众说纷纭。本文在总结某纸业公司反渗透除盐系统运行数据的基础上,对反渗透和离子交换的优缺点及其工艺进行讨论,为筹建除盐系统的企业提供借鉴。 相似文献
5.
6.
7.
反渗透给水的预处理一般包括源水到反渗透给水泵之前的一切处理[1].良好的预处理是反渗透装置长期稳定运行的必要条件.通过对上海焦化有限公司除盐水二组反渗透及其预处理系统在开车初期污染频繁、保安过滤器滤芯寿命过短等异常情况进行分析,提出相应的预处理系统改进方案,实施后,消除和减少了给水污染,为反渗透系统的可靠运行打下良好基... 相似文献
8.
简介了反渗透除盐技术。详细介绍了川化股份有限公司260t/h反渗透脱盐水系统的工艺方案,建设、安装、试车过程中发现并处理的问题,以及系统的运行情况。 相似文献
9.
介绍了坑口煤矸石电厂采用离子交换技术的复床除盐工艺和采用反渗透技术的除盐工艺;通过对比分析,得出反渗透技术运行管理方便、设备少、占地面积小,而且不污染环境,虽然设备投资较高,但年运行费用低;实际生产中,应以含盐量500mg/L为分界点来确定除盐方案。 相似文献
10.
结合具体工程设计,对几种常用的纯水制备系统优缺点进行了比较。经过分析、研究,推出“阴床+混床”作为一级反渗透装置后续化学除盐工艺,对比以往常用的反渗透装置后续化学除盐工艺,具有最低的设备投资,最少的酸碱耗量及废水排放量。 相似文献
11.
12.
两级反渗透系统加碱调节pH值的分析 总被引:1,自引:0,他引:1
本文根据水中碳酸平衡原理分析了反渗透系统产水pH值的变化,得出pH值下降量等于系统对HCO3^-透过率的负对数的结果,并导出了在两级反渗透系统中加碱调节pH值至8.3加碱量的计算公式,可供系统设计和调试参考。 相似文献
13.
14.
反渗透海水淡化系统的优化设计 总被引:5,自引:0,他引:5
对反渗透海水淡化过程的设计进行了研究。首先对过程的每个单元给出了单元操作模型和相关的经济模型。通过一定的变量将这些模型相互关联,组成系统模型。系统模型主要考虑了一级流程和二级流程。将年费用最小定为目标函数,并满足过程热力学、设备选型、设计要求等约束。系统的设计问题可表达为一个混合整数非线性规划(MINLP)。当产品水的设计要求不同,给水浓度不同时,采用本文的设计方法分别得出了不同的最优设计方案。这个方法可用于海水、苦咸水淡化的工程设计,也可用于高浓度含盐废水的脱盐工艺设计。 相似文献
15.
In order to meet the growing needs of its consumers, the Metropolitan Water District of Southern California is looking for ways to desalt water from the relatively hard Colorado River. This study evaluated conventional treatment as the pretreatment step for reverse osmosis (RO) desalting. Other pretreatment options studied include microfiltration (MF) and conventional treatment with ozone and biologically active filters. Each of three pretreatment scenarios produced effluent waters generally considered appropriate for use with RO [median turbidity of less than 0.1 Nephelometric turbidity unit (NTU) and median silt density index of less than 3]. Both microfiltered and ozonated/ biofiltered waters gave steady RO performance over 3 months of testing. However, conventional treatment left the RO system vulnerable to organic and biological fouling. Despite maintaining a 2-2.5 mg/L chloramine residual, pretreatment using conventional treatment required more frequent cleanings than either MF or ozonation/biofiltration (O3/BF). The good performance for biofiltered water may have resulted from the stabilization of the natural organic matter through the O3/BF process. Microfiltration, with its superior particle and bacteriological removal characteristics, provided the best RO pretreatment technology. 相似文献
16.
17.
18.
随着R0反渗透膜技术的迅速发展,目前市场上销售的净水机中,RO(reverse osmosis)反渗透膜技术使用日益增多。为使反渗透装置能够长期稳定地运行,必须选择合适的给水预处理装置,保护好反渗透膜。该文将国产化的SPM(special powder material)作为反渗透预处理的主要材料,对比SPM与GAC、纤维滤膜、活性炭棒组合预处理效果,筛选出优化组合,同时分别考察了填料填充高度、SPM粒度及进水流速对预处理效果的影响。并分别与反渗透膜联用,选取优化的工艺条件,研究了饮用水净水机中SPM与反渗透膜组合技术的可行性及其净化效果。 相似文献
19.
An experimental RO seawater system has been in operation for two years at Eilat on the Red-Sea shore. Simplified seawater pretreatment, comprising only sand filtration and acid dosing was applied. Hollow fiber and spiral wound membranes were tested. Evaluation of pretreatment effectiveness and comparative membrane performances are reported. Investment and water cost analysis of a 4,000 m3/day RO seawater desalting system under various operating conditions is given. The analysis is based on the results of experimental site operation, current technology development and updated industrial quotations. The resulting water production cost from a one-stage system, adequate to produce desalted water acceptable for local drinking water standards, is approximately $ 1.1/m3. 相似文献