Composition of volatile compounds in bovine milk heat treated by instant infusion pasteurisation and their correlation to sensory analysis

Volatile compounds in skim milk and nonstandardised milk subjected to instant infusion pasteurisation at 80°C, 100°C and 120°C were compared with raw milk, high temperature short time pasteurised milk and milk pasteurised at 85°C/30 s. The composition of volatile compounds differed between infusion pasteurisation treated samples and the reference pasteurisations. The sensory properties of skim milk subjected to instant infusion pasteurisation were described by negative attributes, such as cardboard sour and plastic flavours, which are not associated normally with fresh milk. Partial least squares modelling showed good correlation between the volatile compounds and the sensory properties, indicating the predictive and possible causal importance of the volatile compounds for the sensory characteristics.     

Effect of pressure and fat content on particle sizes in microfluidized milk

Average diameters and particle size distributions in fluid milks with different fat contents and subjected to various homogenization pressures with a "microfluidizer" were evaluated. Skim, 2%, and whole milks were microfluidized at 50, 100, 150, and 200 MPa. Cream containing 41% milk fat was microfluidized at 50, 100, and 150 MPa. Particle sizes were determined by laser light scattering. As microfluidization pressure was increased from 50 to 100 MPa, particle sizes in skim, 2%, and whole milks decreased. Microfluidization at pressures greater than 100 MPa had little additional effect on reducing the particle sizes in skim and 2% milks compared with microfluidization at 100 MPa, but the particle sizes in whole milk increased as the microfluidization pressure was increased from 100 to 200 MPa due to formation of homogenization clusters. The particle sizes in cream increased as the microfluidization pressure was increased from 50 to 150 MPa. When the microfluidization pressure was held constant, the particle sizes increased as the milk fat concentration was increased. The coefficients of variations of the volume-weighted particle size distributions for cream were higher than for skim, 2%, and whole milks. Larger "big" particles and smaller "small" particles were formed in whole milk after microfluidization at 200 MPa than at 100 MPa. Although microfluidization can be used to produce small particles in skim, 2%, and whole milks, a higher than optimum pressure (above 100 MPa) applied to whole milk will not lead to the minimum d(43) (volume-weighted average diameter) due to formation of clusters.     

Relationship of Protease Activity to Shelf-Life of Skim and Whole Milk

This study was to investigate causes of a possible difference in shelf-life of pasteurized skim milk and whole milk. Samples of skim and whole milk were obtained the day of processing, in 235 ml containers, from commercial dairies throughout South Carolina. They were stored at 4.5°C for 0,4,8,10,12,14, and 16 days; 7°C for 0,4,6,8,10, and 12 days; and 10°C for 0,1,2,3,4,5, and 6 days. On each sampling day milks were tested for coliform count, psychrotrophic count, flavor score, and relative protease activity. The shelf-life of skim milk was significantly less than that of whole milk when both were stored at 4.5°C and 7°C, but not at 10 C. Bacteria counts were not significantly different; thus, they were of no predictive value as anticipated changes in flavor score. Relationship between flavor score and relative protease activity of skim and whole milk was linear. Also, relative protease activity was significantly higher in skim milk as compared to whole milk stored at 4.5 and 7° C. Therefore, a higher protease activity in skim milk may account partially for its decreased shelf-life.     

The status of fluoride in bovine milk

Raw, whole and skim milks containing fluoride up to 100 ppm fluoride were pasteurised by the HTST and low temperature holding (LTH), and UHT and 'in bottle' sterilization methods. The heat treated milks were stable on standing at room temperature while centrifugation at 4000 g , 12 000 g and 30 000 g showed that a fluoride containing precipitate was not formed.
Dialysis in conjunction with a fluoride ion-selective electrode showed that most of the fluoride was in an easily removable ionic complex. However a proportion of the fluoride, depending upon the heat treatment process used, was not removed by dialysis. A similar effect was observed with heat treated 0.25% casein suspension and with calcium phosphate free (CPF) milk. Examination of the non-dialysable fraction from milk, by addition of fresh fluoride and also by gel chromotography showed that the fluoride was held in a tightly bound but reversible ionic complex.
All of the fluoride could be recovered in an ionic form as shown using the ion-selective electrode on the milk after precipitation of the milk protein with 0.3 M citric acid.     

The effect of vitamin concentrates on the flavor of pasteurized fluid milk

Fluid milk consumption in the United States continues to decline. As a result, the level of dietary vitamin D provided by fluid milk in the United States diet has also declined. Undesirable flavor(s)/off flavor(s) in fluid milk can negatively affect milk consumption and consumer product acceptability. The objectives of this study were to identify aroma-active compounds in vitamin concentrates used to fortify fluid milk, and to determine the influence of vitamin A and D fortification on the flavor of milk. The aroma profiles of 14 commercial vitamin concentrates (vitamins A and D), in both oil-soluble and water-dispersible forms, were evaluated by sensory and instrumental volatile compound analyses. Orthonasal thresholds were determined for 8 key aroma-active compounds in skim and whole milk. Six representative vitamin concentrates were selected to fortify skim and 2% fat pasteurized milks (vitamin A at 1,500–3,000 IU/qt, vitamin D at 200–1,200 IU/qt, vitamin A and D at 1,000/200–6,000/1,200 IU/qt). Pasteurized milks were evaluated by sensory and instrumental volatile compound analyses and by consumers. Fat content, vitamin content, and fat globule particle size were also determined. The entire experiment was done in duplicate. Water-dispersible vitamin concentrates had overall higher aroma intensities and more detected aroma-active compounds than oil-soluble vitamin concentrates. Trained panelists and consumers were able to detect flavor differences between skim milks fortified with water-dispersible vitamin A or vitamin A and D, and unfortified skim milks. Consumers were unable to detect flavor differences in oil-soluble fortified milks, but trained panelists documented a faint carrot flavor in oil-soluble fortified skim milks at higher vitamin A concentrations (3,000–6,000 IU). No differences were detected in skim milks fortified with vitamin D, and no differences were detected in any 2% milk. These results demonstrate that vitamin concentrates may contribute to off flavor(s) in fluid milk, especially in skim milk fortified with water-dispersible vitamin concentrates.     

Cathepsin D activity in quarg

Quarg cheese was produced from raw skim milk, pasteurised skim milk, raw skim milk with rennet added and ultrafiltrated raw skim milk. Quarg was also produced from raw skim milk with pepstatin added at curd cutting and from ultrafiltration retentate of raw milk with added pepstatin. No starter bacteria were used in this model system, with the reduction of pH being achieved by addition of glucono- δ-lactone. Yields ranged between 20.25 and 23.5%, with protein levels of 13.6–15.7%. Proteolysis occurred during storage of all experimental cheese samples for 3 m at 8°C. By immunoblotting using antibodies against bovine cathepsin D, immunoreactive procathepsin D was identified in all cheese samples. Presence of cathepsin D or procathepsin D-derived activity was confirmed by a specific enzyme assay in all samples, except those which contained pepstatin. Inhibition of cathepsin D-catalysed proteolysis by pepstatin was observed in chromatograms of water-soluble extracts analysed by reverse-phase HPLC. Peptides thought to be produced as a result of cathepsin D activity were observed in cheese made from both raw and pasteurised milk, suggesting that the activity at least partially survived pasteurisation.     

Instant infusion pasteurisation of bovine milk. I. Effects on bacterial inactivation and physical–chemical properties

Two types of milk, skim milk and non-standardised raw milk, were heat treated using direct heating by instant infusion pasteurisation with treatment temperatures in the range from 72°C to 120°C and with holding times of less than 1 second. Indirect heating by HTST pasteurisation (72°C for 15 seconds) was used for comparison. The inactivation of microorganisms reached at least the same level when using instant infusion pasteurisation compared to HTST pasteurisation. Changes in the physical-chemical properties were observed in the skim milk fractions of instant infusion pasteurised non-standardised milk, whereas for instant infusion pasteurised skim milk less influence from the treatments was observed.     

Occurrence of proteolytic activity and N-acyl-homoserine lactone signals in the spoilage of aerobically chill-stored proteinaceous raw foods

Proteolytic pseudomonads dominate the spoilage flora of aerobically chill-stored proteinaceous raw foods. Proteolysis during spoilage of these food systems affects both food quality and the dynamics of the bacterial community because it increases the availability of nutrients to the community as a whole. Quorum sensing, or cell-cell signaling, is associated closely with ecological interactions among bacteria in mixed communities. The potential role of quorum sensing in proteolytic food spoilage was examined, based on the evaluation of N-acyl-homoserine lactone (AHL) signal molecules. The occurrence of proteolytic activity and AHL signals was studied during spoilage of aerobically chill-stored ground beef, fish, chicken, and raw milk. Pseudomonads dominated the psychrotrophic flora, followed distantly by members of the Enterobacteriaceae. The growth of pseudomonads was correlated with the occurrence of proteolytic activity in all food systems. AHL concentration began increasing significantly only after the onset of proteolytic activity. Widely divergent AHL profiles were revealed by thin-layer chromatography analysis of the different food samples, and these profiles were likely determined by the undefined bacterial flora in these systems and by the characterized pseudomonads and Enterobacteriaceae. Although Hafnia alvei was a major component of the Enterobacteriaceae flora in all foods tested and a strong AHL producer, the signal molecules produced by H. alvei strain EB1 did not influence protease production by Pseudomonas fluorescens strain 395 in vitro. These results do not indicate any clear correlation between the overall detectable AHL signal molecules accumulated in the food samples and proteolytic activity.     

Influence of milk fat, milk solids, and light intensity on the light stability of vitamin A and riboflavin in lowfat milk

Retinyl palmitate and riboflavin were quantified in milk samples exposed to fluorescent light. Effects of compositional factors were determined by comparing rates of loss of riboflavin and vitamin A in milks with different amounts of milk fat and milk solids. Upon exposure to fluorescent light, rates of vitamin A and riboflavin loss were lower in whole milk than in skim milk. Riboflavin degraded more slowly in skim milk with 1% added nonfat dry milk than in skim milk with no added solids. No additional protective effect for riboflavin was found when added solids were increased from 1 to 3%. Compared with milk with no added solids, 1% added nonfat dry milk did not increased protection for vitamin A, but a protective effect was noted when the skim milk was fortified with 3% nonfat dry milk. Increasing light intensity increased the rates of loss of both vitamins, and riboflavin was lost at a greater rate.     

Cottage Cheese from Ultrafiltered Skim Milk Retentates in Industrial Cheese Making

Ultrafiltered skim milk retentates were transported to a large industrial cottage cheese plant for milk supplementation leading to cottage cheese. The resulting industrial products were observed for composition, yields, whey component losses, and quality.Ten lots of small curd cottage cheese were made in vats containing up to 6593 kg skim milk. Retentate supplemented skim milks, concentrated approximately 10% (1.1:1) and 20% (1.2:1) in total protein, were very similar in initial composition to the controls. Mean cheese yield values from milks supplemented to 1.2:1 total protein were significantly higher than mean unsupplemented control milk values. Cheese yield efficiencies, per kilogram total solids, were also significantly higher in the retentate cheese but not when calculated per kilogram total protein.Total solids, total protein, and ash were higher in cottage cheese wheys from retentate supplemented cheese and were directly related to retentate supplementation concentration. Mean whey component loss per kilogram cheese exhibited significant decreases from milks of higher retentate supplementation. Retentate supplemented skim milk produced industrial cottage cheese of comparable quality to cheese made from unsupplemented control skim milks.     

The effect of commonly used dairy processing techniques and unit operations on the equol content of dairy products

Since a large portion of the milk consumed by human is processed, the aim of this study was to determine possible changes in equol content upon processing milk. Individual milks with different levels of equol content were collected from the morning milking to make skimmed milk and cream, as well as pasteurised and sterilised full fat milks. Pasteurised milk was further processed into yoghurt, kefir, cottage cheese and whey. Yoghurt and kefir were also produced from sterilised milk. Equol content was not affected by either pasteurisation or sterilisation. Compared with raw milk, a higher concentration of equol was measured in skimmed milk, but equol content in cream was lower. The concentration of equol remained unchanged after yoghurt production but was reduced by more than 50% after kefir production. The equol content in whey was low compared with that of raw milk, while it increased sharply in cottage cheese.     

The influence of milk powder characteristics on the properties of halloumi cheese made from recombined milk*

The properties of halloumi made from recombined milks that had been prepared using milk powders processed by different methods were investigated. With skim milk powder, decreases in heat treatment of the liquid skim before drying were found to improve the stretch and melt properties of the cheese. In contrast, the level of solids in the skim concentrate before drying had no effect on the cheese characteristics. Ultrafiltration was also used to concentrate milk for spray drying. The resultant powder was recombined to give protein levels equivalent to that of normal milk and to that of milk concentrated fivefold. In both cases the recombined milks could be converted into high quality halloumi.     

Children's perceptions of fluid milk with varying levels of milkfat

Schools participating in federal meal programs are limited to serving skim or low-fat (≤1%) flavored and unflavored milk. Few studies have directly addressed child perceptions and preferences for milk containing different amounts of milkfat. The objective of this study was to determine whether children can differentiate between flavored and unflavored fluid milk containing varying levels of milkfat and whether preferences for certain levels of milkfat exist. Flavored and unflavored milks containing 4 different percentages of milkfat (≤0.5, 1, 2, and 3.25%) were high-temperature, short-time processed, filled into half-gallon light-shielded milk jugs, and stored at 4°C in the dark. Milks were evaluated by children (ages 8–13 yr) following 7 d at 4°C. Acceptance testing and tetrad difference testing were conducted on flavored and unflavored milks with and without visual cues to determine if differences were driven by visual or flavor or mouthfeel cues. Child acceptance testing (n = 138 unflavored; n = 123 flavored) was conducted to evaluate liking and perception of selected attributes. Tetrad testing (n = 127 unflavored; n = 129 flavored) was conducted to determine if children could differentiate between different fat levels even in the absence of a difference in acceptance. The experiment was replicated twice. When visual cues were present, children had higher overall liking for 1% and 2% milks than skim for unflavored milk and higher liking for chocolate milks containing at least 1% milk fat than for skim. Differences in liking were driven by appearance, viscosity, and flavor. In the absence of visual cues, no differences were observed in liking or flavor or mouthfeel attributes for unflavored milk but higher liking for at least 1% milk fat in chocolate milk compared with skim was consistent with the presence of visual cues. From tetrad testing, children could visually tell a difference between all unflavored pairs except 2% versus whole milk and could not detect consistent differences between milkfat pairs in the absence of visual cues. For chocolate milk, children could tell a difference between all milk fat pairs with visual cues and could tell a difference between skim versus 2% and skim versus whole milk without visual cues. These results demonstrate that in the absence of package-related flavors, school-age children like unflavored skim milk as well as milk with higher fat content in the absence of visual cues. In contrast, appearance as well as flavor and mouthfeel attributes play a role in children's liking as well as their ability to discriminate between chocolate milks containing different amounts of fat, with chocolate milk containing at least 1% fat preferred. The sensory quality of school lunch milk is vital to child preference, and processing efforts are needed to maximize school milk sensory quality.     

Effects of calcium-chelating agents and pasteurisation on certain properties of calcium-fortified soy milk

Addition of 25 mM calcium chloride to soy milk reduced pH, increased ionic calcium and caused it to coagulate. The effects of different chelating agents were investigated on selected physicochemical properties of soy milk and on preventing coagulation. The soy milks were then pasteurised to examine how heat treatment changed some of these properties as well as to evaluate their effects on heat stability.     

Development of an improved extraction and HPLC method for the measurement of ascorbic acid in cows' milk from processing plants and retail outlets

An improved extraction (2.5% HPO₃, 5 mm dithiothreitol) and HPLC quantification methodology using a C–18 column at 35 °C and 0.1 m acetic acid (98%) and acetonitrile (2%) mobile phase was developed to quantify total ascorbic acid (AA) in commercial whole/semi‐skim/skim raw/pasteurised/UHT milk packaged in opaque bags, transparent plastic, cardboard and Tetra Brik^?. AA content ranged from 0.21 to 10 and from 3.4 to 16 mg L^?1 in milk from retail outlets and processing plants, respectively, and was higher in organic milk. For same processor/lot samples, pasteurised milk showed higher AA content than UHT milk. This was not true for retail outlets samples. AA content was similar for whole/semi‐skim and semi‐skim/skim milk, but not for whole/skim comparisons. Among UHT samples, the AA content trend was whole<semi‐skim<skim and lower for UHT milk in opaque plastic and Tetra Brik^? container. After 14 days at 4 °C in the dark, AA losses ranged 35–83% depending on milk type and preservation method with a higher AA retention in unopened containers.     

Coagulation and proteolysis of high-protein milks in the gastric environment

Gastric digestion of 2 commercial ultrafiltered milks and milk enriched with skim milk powder (to simulate concentration by reverse osmosis) was investigated and compared with the digestion of nonconcentrated milk. Curd formation and proteolysis of high-protein milks in simulated gastric conditions were studied using oscillatory rheology, extrusion testing, and gel electrophoresis. The presence of pepsin in the gastric fluid triggered coagulation at pH >6 and the elastic modulus of gels from high-protein milks was ~5 times larger than the gel from reference milk. Despite similar protein concentrations, the coagulum from milk enriched with skim milk powder showed higher resistance to shear deformation than the coagula from ultrafiltered milks. The gel structure was also more heterogeneous. During digestion, the degradation of coagula from high-protein milks was slowed down compared with the coagulum from reference milk, and intact milk proteins were still detected after 120 min. Differences in the digestion patterns of coagula from high-protein milks were observed and were associated with the proportion of minerals bound to caseins and the denaturation rate of whey proteins.     

A novel technique for differentiation of proteins in the development of acid gel structure from control and heat treated milk using confocal scanning laser microscopy

The incorporation of caseins and whey proteins into acid gels produced from unheated and heat treated skimmed milk was studied by confocal scanning laser microscopy (CSLM) using fluorescent labelled proteins. Bovine casein micelles were labelled using Alexa Fluor 594, while whey proteins were labelled using Alexa Fluor 488. Samples of the labelled protein solutions were introduced into aliquots of pasteurised skim milk, and skim milk heated to 90 degrees C for 2 min and 95 degrees C for 8 min. The milk was acidified at 40 degrees C to a final pH of 4.4 using 20 g glucono-delta-lactone/l (GDL). The formation of gels was observed with CSLM at two wavelengths (488 nm and 594 nm), and also by visual and rheological methods. In the control milk, as pH decreased distinct casein aggregates appeared, and as further pH reduction occurred, the whey proteins could be seen to coat the casein aggregates. With the heated milks, the gel structure was formed of continuous strands consisting of both casein and whey protein. The formation of the gel network was correlated with an increase in the elastic modulus for all three treatments, in relation to the severity of heat treatment. This model system allows the separate observation of the caseins and whey proteins, and the study of the interactions between the two protein fractions during the formation of the acid gel structure, on a real-time basis. The system could therefore be a valuable tool in the study of structure formation in yoghurt and other dairy protein systems.     

Effects of different skim milk fractions on activity of cow milk purified lipoprotein lipase

Hydrolysis of a long-chain triglyceride substrate by purified cow milk lipoprotein lipase, in the absence of blood serum, was changed by adding heated skim milks. Preincubation of the substrate with small amounts of several skim milks increased (+50 to 300%) lipoprotein lipase activity. By contrast, greater amounts of skim milk increased further or decreased lipoprotein lipase activity (+ 300 to -90%). The inhibitory effect was due to substrate surface protection. Results obtained after removal of casein (by isoelectric precipitation or by ultracentrifugation) and of whey proteins (by heat treatment) showed that the effect of skim milk was due to the proteose-peptone fraction. Fractionation of the proteose-peptone fraction into component 5-enriched fraction and component 3-enriched fractions suggested that the activating effect was due partially to proteose-peptone component 5, and the inhibitory effect resulted from component 3. These effects were overcome by blood serum.