Production of fuel ethanol from steam-explosion pretreated olive tree pruning

This work deals with the production of fuel ethanol from olive tree pruning. This raw material is a renewable, low cost, largely available, and lacking of economic alternatives agricultural residue. Olive tree pruning was submitted to steam explosion pre-treatment in the temperature range 190-240 °C, with or without previous impregnation by water or sulphuric acid solutions. The influence of both pre-treatment temperature and impregnation conditions on sugar and ethanol yields was investigated by enzymatic hydrolysis and simultaneous saccharification and fermentation on the pretreated solids. Results show that the maximum ethanol yield (7.2 g ethanol/100 g raw material) is obtained from water impregnated, steam pretreated residue at 240 °C. Nevertheless if all sugars solubilized during pre-treatment are taken into account, up to 15.9 g ethanol/100 g raw material may be obtained (pre-treatment conditions: 230 °C and impregnation with 1% w/w sulphuric acid concentration), assuming theoretical conversion of these sugars to ethanol.     

蒸汽爆破麦草同步糖化发酵转化乙醇的研究

近年来对木质生物资源同步糖化发酵转化乙醇的研究较多,但是,麦草同步糖化发酵转化乙醇的最佳工艺条件还未确定。文中采用正交试验设计的方法,对在混合酶(纤维素酶Celluclast 1.5 1,β-葡萄糖苷酶Novozym 188)与酿酒酵母菌作用下,稀硫酸催化的蒸汽爆破麦草原料同步糖化发酵转化乙醇的工艺条件进行研究,详细讨论了反应温度、底物质量浓度、发酵液pH值、纤维素酶浓度对乙醇质量浓度和得率的影响。结果表明,工艺条件对乙醇质量浓度和得率的影响程度由高到低依次为:底物质量浓度、纤维素酶浓度、发酵液pH值、反应温度。最佳工艺条件为反应温度35℃,底物质量浓度100 g/L,发酵液pH值5.0,纤维素酶浓度30 FPU/g。在此条件下,随着反应时间的延长,乙醇质量浓度持续上升。反应72 h后,乙醇质量浓度和得率分别达到22.7 g/L和65.8%。     

木薯酒精渣的预处理及补料同步糖化发酵制取乙醇

木薯酒精渣的处置是制约木薯燃料乙醇大规模产业化的问题之一。本文立足于探索木薯酒精渣利用途径,分析了木薯酒精渣的主要成分,对比了氨水、氢氧化钠、氨水组合稀硫酸3种预处理方式对于木薯酒精渣纤维素和木素含量及纤维素酶水解效率的影响,分析了处理前后木薯酒精渣的表面结构及纤维素结晶度,并以氨水处理后的木薯酒精渣为底物,进行了同步糖化发酵。结果表明,3种预处理方法中组合预处理能更好地增加纤维素含量和提高纤维素酶水解效率,与未处理原料相比,组合预处理后纤维素含量增加了111.26%,木素下降了35.05%,酶水解72h纤维素转化率从42.10%增加到61.71%。氨水预处理后,原料的木素含量降低,处理后木薯酒精渣的表面变得更加粗糙,纤维素结晶度有所增加,以氨水处理后的木薯酒精渣为底物进行分批补料同步糖化发酵,当初始底物浓度为100.0g/L,分别在20h、40h、60h进行补料至最终底物浓度为400.0g/L时,发酵120h乙醇浓度达到51.0g/L。     

Study of simultaneous saccharification and fermentation for steam exploded wheat straw to ethanol

Although simultaneous saccharification and fermentation (SSF) has been investigated extensively, the optimum condition for SSF of wheat straw has not yet been determined. Dilute sulfuric acid impregnated and steam explosion pretreated wheat straw was used as a substrate for the production of ethanol by SSF through orthogonal experiment design in this study. Cellulase mixture (Celluclast 1.5 l and ?-glucosidase Novozym 188) were adopted in combination with the yeast Saccharomyces cerevisiae AS2.1. The effects of reaction temperature, substrate concentration, initial fermentation liquid pH value and enzyme loading were evaluated and the SSF conditions were optimized. The ranking, from high to low, of influential extent of the SSF affecting factors to ethanol concentration and yield was substrate concentration, enzyme loading, initial fermentation liquid pH value and reaction temperature, respectively. The optimal SSF conditions were: reaction temperature, 35°C; substrate concentration, 100 g·L^-1; initial fermentation liquid pH, 5.0; enzyme loading, 30 FPU·g^-1. Under these conditions, the ethanol concentration increased with reaction time, and after 72 h, ethanol was obtained in 65.8% yield with a concentration of 22.7 g·L^-1.     

Second-generation ethanol production from steam exploded barley straw by Kluyveromyces marxianus CECT 10875

Barley straw is nowadays being considered a potential lignocellulosic raw material for fuel-ethanol production as an alternative to starch- or sugar-containing feedstock. In this work, several configuration strategies for ethanol production from steam-exploded barley straw by Kluyveromyces marxianus CECT 10875 have been studied with the aim of obtaining higher ethanol concentrations.Different substrate loading (2-15%, w/v) were studied during enzymatic hydrolysis. The xylanase contribution on glucose production and glucan conversion at different substrate loading was also investigated. In addition, three different process configurations, separate hydrolysis and fermentation, simultaneous saccharification and fermentation and presaccharification and simultaneous saccharification, were compared at different water insoluble solids concentration (5%, 10% and 15%). The influence of xylanase addition on the ethanol yield was studied as well.Results show that endo-xylanases improved glucan conversion and ethanol yield compared with a standard enzymatic mixture, markedly at low substrate concentration. The positive effect of added xylanase was most evident at early stages of enzymatic hydrolysis. Regarding process configurations for the period of 72 h, SSF with endo-xylanases provided the best ethanol yield, nearly 70%, for 10% WIS. Nonetheless, the higher ethanol concentration, 29.4 g/l, was obtained at 15% WIS.     

Simultaneous saccharification and fermentation of pretreated Antigonum leptopus (Linn) leaves to ethanol

Simultaneous saccharification and fermentation (SSF) of alkaline hydrogen peroxide pretreated Antigonum leptopus (Linn) leaves to ethanol was optimized using cellulase from Trichoderma reesei QM‐9414 (Celluclast® from Novo) and Saccharomyces cerevisiae NRRL‐Y‐132 cells. Contrary to the saccharification optima (2.5% w/v substrate concentration, 50 °C, 4.5 pH, 40 FPU cellulase g⁻¹ substrate and 24 h reaction time), the SSF optima was found to be somewhat different (10% w/v substrate, 40 °C, 100 FPU cellulase g⁻¹ substrate and 72 h). Better ethanol yields were obtained with SSF compared with the traditional saccharification and subsequent fermentation (S&F) and when the cellulase was supplemented with β‐glucosidase. © 1999 Society of Chemical Industry     

Comparison of bioethanol production of simultaneous saccharification & fermentation and separation hydrolysis & fermentation from cellulose-rich barley straw

Cellulose rich barley straw, which has a glucan content of 62.5%, followed by dilute acid pretreatment, was converted to bioethanol by simultaneous saccharification and fermentation (SSF). The optimum fractionation conditions for barley straw were an acid concentration of 1% (w/v), a reaction temperature of 158 °C and a reaction time of 15 min. The maximum saccharification of glucan in the fractionated barley straw was 70.8% in 72 h at 60 FPU/gglucan, while the maximum digestibility of the untreated straw was only 18.9%. With 6% content WIS (water insoluble solid) for the fractionated barley straw, 70.5 and 83.2% of the saccharification yield were in SHF and SSF (representing with glucose equivalent), respectively, and a final ethanol concentration of 18.46 g/L was obtained under the optimized SSF conditions: 34 °C with 15 FPU/g-glucan enzyme loading and 1 g dry yeast cells/L. The results demonstrate that the SSF process is more effective than SHF for bioethanol production by around 18%.     

FED-BATCH SIMULTANEOUS SACCHARIFICATION AND FERMENTATION OF MICROWAVE/ACID/ALKALI/H2O2 PRETREATED RICE STRAW FOR PRODUCTION OF ETHANOL

The batch simultaneous saccharification and fermentation (SSF) of microwave/acid/alkali/H₂O₂ pretreated rice straw to ethanol was optimized using cellulase from Trichoderma reesei and Saccharomyces cerevisiae YC-097 cells prior to the fed-batch SSF studies. The batch SSF optima were 10% w/v substrate, 40°C, 15 mg cellulase/g substrate, initial pH 5.3, and 72 hours. Under the optimum conditions the ethanol concentration and its yield were 29.1 g/L and 61.3% respectively. Based on the optimal batch SSF, the fed-batch SSF was investigated and its operation parameters were optimized. Under its optimal conditions the ethanol concentration reached 57.3 g/L, while its productivity and yield were only slightly less than those in the batch SSF. This suggests that fed-batch SSF is a potential operation mode for effective ethanol production from microwave/acid/alkali/H₂O₂ pretreated rice straw.     

Study of simultaneous saccharification and fermentation for steam exploded wheat straw to ethanol

Although simultaneous saccharification and fermentation (SSF) has been investigated extensively, the optimum condition for SSF of wheat straw has not yet been determined. Dilute sulfuric acid impregnated and steam explosion pretreated wheat straw was used as a substrate for the production of ethanol by SSF through orthogonal experiment design in this study. Cellulase mixture (Celluclast 1.5 l and β-glucosidase Novozym 188) were adopted in combination with the yeast Saccharomyces cerevisiae AS2.1. The effects of reaction temperature, substrate concentration, initial fermentation liquid pH value and enzyme loading were evaluated and the SSF conditions were optimized. The ranking, from high to low, of influential extent of the SSF affecting factors to ethanol concentration and yield was substrate concentration, enzyme loading, initial fermentation liquid pH value and reaction temperature, respectively. The optimal SSF conditions were: reaction temperature, 35°C; substrate concentration, 100 g·L⁻¹; initial fermentation liquid pH, 5.0; enzyme loading, 30 FPU·g⁻¹. Under these conditions, the ethanol concentration increased with reaction time, and after 72 h, ethanol was obtained in 65.8% yield with a concentration of 22.7 g·L⁻¹. __________ Translated from Chemical Engineering (China), 2007, 35(12): 42–45 [译自: 化学工程]     

FED-BATCH SIMULTANEOUS SACCHARIFICATION AND FERMENTATION OF MICROWAVE/ACID/ALKALI/H2O2 PRETREATED RICE STRAW FOR PRODUCTION OF ETHANOL

The batch simultaneous saccharification and fermentation (SSF) of microwave/acid/alkali/H₂O₂ pretreated rice straw to ethanol was optimized using cellulase from Trichoderma reesei and Saccharomyces cerevisiae YC-097 cells prior to the fed-batch SSF studies. The batch SSF optima were 10% w/v substrate, 40°C, 15 mg cellulase/g substrate, initial pH 5.3, and 72 hours. Under the optimum conditions the ethanol concentration and its yield were 29.1 g/L and 61.3% respectively. Based on the optimal batch SSF, the fed-batch SSF was investigated and its operation parameters were optimized. Under its optimal conditions the ethanol concentration reached 57.3 g/L, while its productivity and yield were only slightly less than those in the batch SSF. This suggests that fed-batch SSF is a potential operation mode for effective ethanol production from microwave/acid/alkali/H₂O₂ pretreated rice straw.     

高底物浓度纤维乙醇同步糖化发酵工艺的比较

引言日益加剧的能源危机和环境污染,正迫使人们寻求新的可再生替代能源。纤维乙醇作为一种重要的生物质替代能源,经过近40多年的发展,已经具备了实现工业化生产的潜力。为了进一步降低纤     

糠醛渣直接同步糖化发酵生产乙醇过程比较研究

以糠醛渣为原料,直接同步糖化发酵(SSF)生产乙醇,并与水洗糠醛渣生产乙醇进行对比。通过考察不同条件来优化同步糖化发酵生产工艺条件,并分析表征了SSF过程中乙醇浓度和副产物浓度变化。优化条件为:糠醛渣底物质量分数10%,纤维素酶用量12%,无患子皂素质量浓度0.5g/L,酵母接种量7g/L,同步糖化发酵乙醇得率达到其理论得率的93.1%。与水洗糠醛渣相比,糠醛渣直接SSF过程可将原料吸附的5.50%葡萄糖部分转化为乙醇。水洗糠醛渣SSF生产乙醇所产生的副产物要远低于糠醛渣直接生产所产生的副产物,添加无患子皂素可有效抑制糠醛渣同步糖化发酵过程中副产物的产生。     

Valorization of residual woody biomass (Olea europaea trimmings) based on aqueous fractionation

BACKGROUND: Olive tree trimmings, a widely available agricultural residue lacking added value applications, were subjected to treatments with hot, compressed water under a variety of operational conditions. As a result of treatments, hemicelluloses were solubilized, and the treated solids were enriched in cellulose and lignin. Spent solids from autohydrolysis were assayed as substrates for enzymatic hydrolysis and for bioethanol production by simultaneous saccharification and fermentation. RESULTS: Liquors from the aqueous fractionation stage resulted in the formation of soluble hemicellulose‐derived saccharides (mainly of oligomeric nature) at yields up to 26.2 g per 100 g oven‐dry raw material. Enzymatic hydrolysis of spent solids from the aqueous fractionation step led to solutions containing up to 58.8 g glucose L^?1 (corresponding to cellulose to glucose conversions up to 83.2%). Simultaneous saccharification and fermentation assays using spent solids as substrates enabled the production of media containing up to 38.2 g ethanol L^?1, corresponding to 72% of the stoichiometric amount. CONCLUSION: Aqueous (or hydrothermal) processing is a technology enabling the recovery of hemicelluloses (as soluble saccharides) and the production of spent solids with high susceptibility to enzymatic hydrolysis (suitable for bioethanol production by simultaneous saccharification and fermentation). Copyright © 2011 Society of Chemical Industry     

Simultaneous saccharification and fermentation of alkaline-pretreated corn stover to ethanol using a recombinant yeast strain

Bio-ethanol converted from cheap and abundant lignocellulosic materials is a potential renewable resource to replace depleting fossil fuels. Simultaneous saccharification and fermentation (SSF) of alkaline-pretreated corn stover for the production of ethanol was investigated using a recombinant yeast strain Saccharomyces cerevisiae ZU-10. Low cellobiase activity in Trichoderma reesei cellulase resulted in cellobiose accumulation. Supplementing the simultaneous saccharification and fermentation system with cellobiase greatly reduced feedback inhibition caused by cellobiose to the cellulase reaction, thereby increased the ethanol yield. 12 h of enzymatic prehydrolysis at 50 °C prior to simultaneous saccharification and fermentation was found to have a negative effect on the overall ethanol yield. Glucose and xylose produced from alkaline-pretreated corn stover could be co-fermented to ethanol effectively by S. cerevisiae ZU-10. An ethanol concentration of 27.8 g/L and the corresponding ethanol yield on carbohydrate in substrate of 0.350 g/g were achieved within 72 h at 33 °C with 80 g/L of substrate and enzyme loadings of 20 filter paper activity units (FPU)/g substrate and 10 cellobiase units (CBU)/g substrate. The results are meaningful in co-conversion of cellulose and hemicellulose fraction of lignocellulosic materials to fuel ethanol.     

Bioethanol production from wheat straw by the thermotolerant yeast Kluyveromyces marxianus CECT 10875 in a simultaneous saccharification and fermentation fed-batch process

Solid content in the simultaneous saccharification and fermentation (SSF) broth should be as high as possible in order to reach higher ethanol concentration. In this work, several feeding strategies for ethanol production from steam-exploded wheat straw by Kluyveromyces marxianus CECT 10875 have been studied with the aim of obtaining higher ethanol concentrations. Previous fermentability tests as well as SSF processes showed the difficulty of using the slurry for ethanol production under the studied conditions. Notwithstanding, fed-batch SSF processes with water-insoluble solids (WIS) fraction resulted in better configuration, reaching the highest ethanol concentration (36.2 g/L) with an initial WIS content of 10% (w/v) and 4% (w/v) of substrate addition at 12 h, which meant 20% more ethanol when compared with batch SSF.     

木质纤维生物质同步糖化发酵(SSF)生产乙醇的研究进展

综述了有关木质纤维生物质原料同步糖化发酵生产乙醇的最新研究进展和未来发展方向:同步糖化发酵是一种用于从木质纤维原料生产乙醇的工艺过程,此工艺的优点是酶水解与发酵同时进行,可以减少最终产物对酶水解的抑制作用,并减少投资成本,是最具发展潜力和优势的工艺之一。近年来在优化预处理工艺、降低纤维素酶成本以及己糖戊糖协同发酵等方面的研究都取得了长足的进步,其中以小麦秸秆为原料进行同步糖化发酵所得到的乙醇浓度接近40g/L。     

Investigation of cellulose convertibility and ethanolic fermentation of sugarcane bagasse pretreated by wet oxidation and steam explosion

Sugarcane bagasse was pretreated by wet oxidation (WO) at 195 °C for 15 min under either alkaline, neutral or acidic conditions, and by steam explosion (STEX) at 205 °C for 10 min. Alkaline WO was more favourable than neutral and acidic WO for the following enzymatic hydrolysis of cellulose, giving 792 g kg^?1 glucose yield after 48 h. The enzymatic hydrolysis of the fibres in the whole slurry was inhibited by inhibitory compounds contained in the prehydrolysate in comparison with the hydrolysis of the washed solid fibres in buffer. The inhibition increased proportionally with formic acid concentration in the pretreated liquid fraction. Cellulose conversion was higher for simultaneous saccharification and fermentation (SSF) than for separate hydrolysis. The highest SSF conversion (829 g kg^?1) was obtained for the material treated by alkaline WO. The fermentability of the prehydrolysates by Saccharomyces cerevisiae was evaluated. Stronger inhibition of ethanolic fermentation was observed in the prehydrolysate obtained by steam explosion. The inhibition was more noticeable for the volumetric productivity than for the ethanol yield. The volumetric productivity was reduced by 94.5 and 91.2% for STEX and WO, respectively, whereas the ethanol yield was reduced only by 45.2 and 31.0%, correspondingly, for STEX and WO. Furan aldehydes seemed to be mainly responsible for the inhibition of the fermentation. Copyright © 2006 Society of Chemical Industry     

表面活性剂对麦草同步糖化发酵转化乙醇的影响

研究了5种非离子型表面活性剂(BSA, Tween-20, Tween-80, PEG-4000, PEG-6000)促进麦草同步糖化发酵的效果. 结果表明,5种表面活性剂均能促进麦草同步糖化发酵,以Tween-20效果最为显著. 反应体系中添加Tween-20可降低酶用量而保持乙醇浓度基本相同. 在pH 5.0、温度37℃、底物浓度50 g/L及Celluclast 1.5 l用量25 FPU/g、Novozym 188用量15 IU/g的反应体系中,添加0.03 g/g Tween-20,反应72 h,乙醇浓度达到18.7 g/L,比未添加表面活性剂的体系提高了14.0%,反应时间缩短了12 h.     

乙酸预浸对玉米秸秆蒸汽爆破预处理的影响

对经乙酸预浸汽爆预处理的玉米秸秆进行了组分含量和抑制物分析,并研究了玉米秸秆预处理后的酶水解性和同步糖化发酵。与未经乙酸预浸相比,乙酸预浸玉米秸秆能在相对低温下进行汽爆预处理,在提高半纤维素水解程度的同时,并不会明显增加糠醛等发酵抑制物。酶水解实验表明,玉米秸秆经乙酸预浸,再以 200 ℃ 进行汽爆后的酶水解效果较好,每克原料可获得 284 mg 葡萄糖,提高了 10.2 %,为理论值的 76.8 %;乙酸预浸玉米秸秆经过 96 h 同步糖化发酵,获得了 22.5 g/L 的乙醇浓度,为理论值的 72 %;相比未经乙酸预浸的玉米秸秆,提高了11.9个百分点。     

木薯干原料同步糖化发酵生产乙醇

提出了用木薯干为原料,同步糖化发酵(SSF)开发燃料乙醇的新工艺. 对各个影响条件进行了研究,获得了最佳的工艺条件：原料粉碎粒度0.45 mm,加水比2.8, 100℃下蒸煮30 min,a-淀粉酶、糖化酶的添加量分别为10, 180 U/g, 30℃下发酵48 h. 并与普通的先糖化后发酵(SHF)生产模式进行了对比,认为SSF具有工艺简单、能耗低、发酵迅速、醪液酒精度高等众多优点,值得工业推广.