Application of lysine, taurine, disodium inosinate and disodium guanylate in fermented cooked sausages with 50% replacement of NaCl by KCl

The effects of 50% replacement of NaCl by KCl and addition of the amino acids lysine and taurine and the 5'-ribonucleotide disodium inosinate and disodium guanylate on some sensory and physicochemical parameters of fermented cooked sausages were evaluated. The partial replacement of NaCl by KCl did not alter the manufacturing process; however, defects in the sensory quality were detected. Lysine at a concentration of 0.313% and a mixture of taurine (750 mg/kg) with disodium inosinate (300 mg/kg) and disodium guanylate (300 mg/kg) reduced the sensory defects caused by KCl, allowing the fermented cooked sausages to be elaborated with reduced sodium content and high sensory quality.     

The effect of yeast extract addition on quality of fermented sausages at low NaCl content

Fermented sausages with 25% or 50% of their NaCl replaced by KCl and supplemented with 1% or 2% concentrations of yeast extract were produced. The sausage production process was monitored with physical, chemical and microbiological analyses. After production, the sausage samples were submitted to a consumer study and their volatile compounds were extracted by solid-phase microextraction and analyzed by GC-MS. The replacement of NaCl by KCl did not significantly influence the physical, chemical or microbiological characteristics. The sensory quality of the fermented sausages with a 50% replacement was poor compared with the full-salt control samples. The use of yeast extract at a 2% concentration increased volatile compounds that arose from amino acids and carbohydrate catabolism. These compounds contributed to the suppression of the sensory-quality defects caused by the KCl introduction, thus enabling the production of safe fermented sausages that have acceptable sensory qualities with half as much sodium content.     

Reducing sodium levels in frankfurters using a natural flavor enhancer

Sodium chloride (NaCl; salt) contributes to important quality and food safety properties of processed meats. However, renewed interest exists in reducing sodium in the human diet. This study investigated quality and sensory impacts associated with partial replacement and/or reduction of normally added NaCl using a natural flavor enhancer (NFE) in frankfurters. Varying levels of NFE were used with NaCl and/or potassium chloride (KCl) to comprise treatments (TRT) which investigated flake salt replacement (Phase I) and sodium reduction (Phases II and III). Phase I sensory and quality results identified a 50% replacement of NaCl with NFE as the baseline for subsequent phases. Phase II indicated that the inclusion of NFE could allow for a 20% NaCl reduction without adverse effects on quality or sensory attributes. Phase III results demonstrated that it was feasible to reduce NaCl by 35% via the inclusion of KCl in NFE containing frankfurters without major quality or sensory changes.     

Combined effects of potassium lactate and calcium ascorbate as sodium chloride substitutes on the physicochemical and sensory characteristics of low-sodium frankfurter sausage

The purpose of this study was to evaluate the combined effects of sodium chloride (NaCl) substitutes, including potassium lactate (K-lactate) and calcium ascorbate (Ca-ascorbate), on the physicochemical and sensory characteristics of low-sodium frankfurter sausage (1.2% content of NaCl). Sausages produced with 40% substitution of NaCl with combined K-lactate and Ca-ascorbate showed a higher value of lightness (P < 0.001) than sausages containing 2.0% content of NaCl (control). However, the sensory panels were unable to distinguish a difference in color intensity between the control and treatment groups. Frankfurter sausages produced with 30% K-lactate and 10% Ca-ascorbate exhibited similar water-holding capacity, textural properties, and organoleptic characteristics (P > 0.05) when compared to control sausages. Thus, the use of these salt mixtures is a good way to reduce the NaCl content in meat products while maintaining the quality of meat products. These results may be useful in developing low-sodium meat products.     

Evaluation of monosodium glutamate,disodium inosinate and guanylate umami taste by an electronic tongue

An electronic tongue (e-Tongue) was used to evaluate umami taste and compare different flavor enhancers (concentration and manufacture). Monosodium glutamate and three kinds of disodium inosinate and guanylate (I + G) were analyzed. The obtained data were analyzed by principal component analysis (PCA). The first principal component represented the intensity of umami taste. Based on Euclidean distance between ‘I + G’ samples and MSG (0.5%) on the PCA score plot, the umami intensity of all samples was ranked. The ‘I + G’ samples produced by three manufactures were successfully discriminated on the second principal component with a high discrimination index (82.26). Besides, the drift phenomenon of sensor was discussed and finishing sensor analyses in a continuous time could help avoid the drift. This study showed that e-Tongue was useful in analyzing the umami taste and might be a complementary tool in evaluation of flavor enhancer.     

Reducing sodium levels in frankfurters using naturally brewed soy sauce

Sodium chloride (NaCl; salt) serves important functions in processed meats, contributing to desirable quality and food safety characteristics; however, renewed interest exists in reducing sodium in the human diet despite sodium being a required component of the diet for physiological regulation. This study investigated consumer sensory and quality impacts from replacement of normally added NaCl (flake salt) with naturally brewed soy sauce (SS). Varying levels of SS were used with NaCl and/or potassium chloride (KCl) to comprise treatments (TRT) which investigated flake salt replacement (Phase I) and sodium reduction (Phases II and III). Phase I identified a 50% replacement of NaCl with SS as the baseline for subsequent phases. Phase II indicated that the inclusion of SS could allow for a 20% NaCl reduction without adverse effects on quality or sensory attributes. Phase III results demonstrated that it was feasible to reduce NaCl by 35% via the inclusion of KCl in SS containing frankfurters without major quality or sensory changes.     

Sensory characterisation and consumer acceptability of small calibre fermented sausages with 50% substitution of NaCl by mixtures of KCl and potassium lactate

The effect of six mixtures with 50% molar substitution of KCl (0–50%) and potassium lactate (0–50%) as NaCl substitutes in small calibre fermented sausages on some sensory parameters and on the acceptability was studied. Also, the relationship between sensory profile and consumer acceptability using external preference mapping was investigated. The results showed that as the K-lactate substitution increased, pH, sweetness, crumbliness and pastiness also increased, and piquantness, hardness, cohesiveness, ripened flavour, acid taste and saltiness decreased. However, the treatments prepared with a high level of salt substitution by KCl showed scores of sensory attributes similar to those of the control.Consumer segmentation showed differences in acceptability between genders, place of residence, educational level and age group. Consumers rejected fermented sausages with high K-lactate substitution but not those with a high KCl substitution. External preference mapping split consumers up into four clusters with different preference patterns. According to these results and from a sensory point of view, it is possible to achieve a reduction of 50% of NaCl in small calibre fermented sausages and to obtain a product acceptable to most consumers.     

Effect of reducing and replacing pork fat on the physicochemical,instrumental and sensory characteristics throughout storage time of small caliber non-acid fermented sausages with reduced sodium content

The effect of pork fat reduction (from 44% to 20% final fat content) and its partial substitution by sunflower oil (3% addition) on the physicochemical, instrumental and sensory properties throughout storage time of small caliber non-acid fermented sausages (fuet type) with reduced sodium content (with partial substitution of NaCl by KCl and K-lactate) and without direct addition of nitrate and nitrite (natural nitrate source used instead) was studied. Results showed that sausages with reduced fat (10% initial fat content) and with acceptable sensory characteristics can be obtained by adding to the shoulder lean (8% fat content) during the grinding, either 3.3% backfat (3% fat content) or 3% sunflower oil, both previously finely comminuted with lean. Furthermore, sunflower oil showed to be suitable for partial pork backfat substitution in very lean fermented sausages, conferring desirable sensory properties similar to those of sausages with standard fat content. The sensory quality of the sausages was maintained after three-month cold storage in modified atmosphere.     

Effect of sodium,potassium, calcium and magnesium chloride salts on porcine muscle proteases

This study is focused on the effect of sodium chloride alternative salts (KCl, MgCl₂ and CaCl₂) on porcine muscle proteases (cathepsins, dipeptidylpeptidases and aminopeptidases). In general, KCl exerted a very similar effect to NaCl for all the studied enzymes, while the effect of divalent salts (CaCl₂ and MgCl₂) was more pronounced. Cathepsins, dipeptidyl peptidase III, dipeptidyl peptidase IV and alanyl aminopeptidase activities were strongly inhibited by all the chloride salts especially by divalent ones. Dipeptidyl peptidase II and leucyl aminopeptidase were little affected and methionyl aminopeptidase was only inhibited by divalent salts. Dipeptidyl peptidase I was strongly activated by low concentrations of the chloride salts except NaCl. Arginyl aminopeptidase was activated by NaCl and KCl and low amounts of MgCl₂, while CaCl₂ showed a strong inhibitory effect. This is very important as these enzymes play important roles in dry-cured meats and their activity is, in general, regulated by sodium chloride. Thus, reductions in the sodium concentration with subsequent increases of other alternative cations may have relevant consequences on enzyme activity that should be taken into account when processing dry-cured meats.     

发酵香肠风味物质气质分析及与发酵时间的关系

分析取样量、萃取时间、萃取温度3个因素对发酵香肠中挥发性成分萃取效果的影响,并对发酵6,9h的香肠中的香气成分进行了比较分析。结果表明:发酵香肠中风味物质的抽提条件为样品质量3.0g,萃取时间50min,萃取温度60℃。从发酵6,9h的香肠中分别鉴定出54,20种香气成分;酯类物质是发酵6h肠中主要挥发性成分,而发酵9h肠中主要成分为醇类,其中70.9%是乙醇,乙醇谱峰远高于其他化合物的谱峰,掩盖了其他化合物的谱峰。发酵6h与发酵9h的香肠中香气成分组成及相对含量具有明显的差异性。就风味物质而言,发酵6h的效果优于发酵9h的。     

Effect of chloride salt mixtures on selected attributes and mineral content of fermented cracked Aloreña olives

Sodium chloride is essential in table olive fermentation, storage and packing to guarantee safety and flavor. However, consumers are progressively concerned about sodium intake. In this work, the effect of selected attributes and mineral contents of fermented cracked Aloreña olives as a function of different chloride salt mixtures were studied, using a simplex lattice design with constrains (NaCl + CaCl₂ + KCl = 0.110 kg/l). The best fruit colour was observed at half proportions of KCl and NaCl or CaCl₂; optimum firmness was around the centre of the triangular coordinates but close to the line connecting CaCl₂ and NaCl vertexes; and the best overall quality was obtained in the 0.037 kg/l NaCl and 0.073 kg/l KCl mixture. The concentrations in the fermented olive flesh of the involved elements depended on their initial levels and on the CaCl₂ × NaCl and CaCl₂ × KCl interactions. Results demonstrate that sodium chloride can be replaced in table olives, at least partially, with potassium or calcium chlorides.     

Proteolysis and sensory properties of dry-cured bacon as affected by the partial substitution of sodium chloride with potassium chloride

Quadriceps femoris muscle samples (48) from 24 pigs were processed into dry-cured bacon. This study investigated the influence of partial substitution of sodium chloride (NaCl) with potassium chloride (KCl) on proteolysis and sensory properties of dry-cured bacon. Three salt treatments were considered, namely, I (100% NaCl), II (60% NaCl, 40% KCl), and III (30% NaCl, 70% KCl). No significant differences were observed among treatments in the proteolysis, which was reflected by SDS–PAGE, proteolysis index, amino acid nitrogen, and peptide nitrogen contents. Furthermore, there were no significant differences in the moisture content between control and treatment II, whereas the moisture content in treatment III was significantly higher (p < 0.05) in comparison with control (treatment I). The sensory analysis indicated that it was possible to reduce NaCl by 40% without adverse effects on sensory properties, but 70% replacement of NaCl with KCl resulted in bacon with less hardness and saltiness and higher (p < 0.05) juiciness and bitterness.     

Sorption isotherms of salted minced pork and of lean surface of dry-cured hams at the end of the resting period using KCl as substitute for NaCl

The effect of KCl on sorption isotherms was determined on salted minced meat (with 0%, 30% and 100% molar substitution of NaCl by KCl) at 5 °C and 25 °C and meat from a 3 mm thick slice from the surface of dry-cured hams (with 0% and 35% molar substitution of NaCl by KCl) held at 70–75%, 75–80% and 80–85% air relative humidity during the resting period.

The sorption isotherms were determined gravimetrically by exposing the meat samples to several atmospheres of known relative humidity controlled by different saturated salts according to the COST90 method. The sorption equipment consisted of a chamber containing 11 containers, covering the water activity (a_w) range from 0.112 to 0.946 at 25 °C. The hermetically closed sorption containers filled with KCl and minced meat samples were irradiated at 3 kGrey (gamma irradiation ⁶⁰Co). The water content at equilibrium was higher in minced meat with NaCl than in minced meat with KCl (100% molar substitution of NaCl by KCl) at 5 °C within the range of 0.4313 and 0.7565 a_w. However, when substitution was 30% in minced meat and 35% in hams the isotherms were similar to isotherm without substitution.     

Generation of volatile compounds in Brazilian low-sodium dry fermented sausages containing blends of NaC1, KC1, and CaC12 during processing and storage

Brazilian dry fermented sausages with different salt contents were manufactured: control (2.5% NaCl), 50% salt reduced (1.25% NaCl, F1), 50% replaced by KCl (1.25% NaCl and 1.25% KCl, F2), 50% replaced by CaCl₂ (1.25% NaCl and 1.25% CaCl₂, F3), and 50% replaced by KCl and CaCl₂ (1.25% NaCl, 0.625% KCl and 0.625% CaCl₂, F4). Changes in the composition of volatile compounds were studied during processing (0, 7, and 19 days) and storage (30, 60, and 90 days). Neither reduction nor replacement of NaCl by KCI affected the volatile compounds produced during the manufacturing process, and both increased the volatile compounds from carbohydrate fermentation and amino acid degradation during storage. The addition of CaCl₂ improved the generation of hexanal and (E)-hept-2-enal and other volatiles from lipid oxidation during processing and storage. After 90 days of storage, the control sample showed an increase in the generation of volatile compounds from lipid oxidation.     

Inulin-based emulsion-filled gel as a fat replacer in prebiotic- and PUFA-enriched dry fermented sausages

In order to produce fermented sausages with prebiotic fibre and improved fatty acid composition, 16% of pork back fat was replaced with inulin gelled suspension (I) and inulin linseed oil gelled emulsion (IO). Physico-chemical analysis, fatty acid profiles, lipid oxidation, microbiological, textural, colour and sensory analysis were carried out. The fat content was lower in I (31.38%) and IO (35.36%) modified sausages compared to control (44.37%) (P < 0.05). IO sausages had lower SFA and MUFA and higher PUFA content with an improved n-6/n-3 ratio (2.23) (P < 0.05) and α-linolenic acid increment (5.74 g per 100 g). Reformulation led to decrease in springiness, chewiness and hardness and increase in adhesiveness of the sausages. Modified sausages had lower L* and higher a* values, while b* values of I sausages did not differ compared to control sausages. Modified sausages were acceptable regarding all sensory attributes. Lipid oxidation parameters showed higher susceptibility to oxidation and lipolysis in IO sausages.     

Effect of the type of fat on the physicochemical,instrumental and sensory characteristics of reduced fat non-acid fermented sausages

Four batches of reduced fat non-acid fermented sausages were manufactured with pork-ham lean, and the addition of no fat (Lean), 5% pork backfat (BF), 5% sunflower oil (SO) and 5% diacylglycerols (DAGs). The effect of the type of fat as pork-fat substitute on some physicochemical parameters, instrumental color and texture and sensory attributes of the sausages was studied. Results showed that reduced fat non-acid fermented sausages containing less than 12.5% of fat (BF, SO and DAGs) had a good overall sensory quality. This means a fat reduction of more than 70% compared with the average fat content of standard fermented sausages of similar characteristics. Sausages with SO showed higher sensory ratings in desirable ripened odor and flavor attributes and improved texture defined by lower hardness and chewiness (both sensory and instrumental) and higher crumbliness. Sausages with DAGs showed a similar behavior to that of BF, so they could be a good alternative to produce healthier reduced fat non-acid fermented sausages.     

Potassium chloride, potassium lactate and glycine as sodium chloride substitutes in fermented sausages and in dry-cured pork loin

Salt is essential in the elaboration of dry meat products, contributing to their texture and flavour development. The effect brought about by substituting NaCl with KCl (0-60%), potassium lactate (0-100%) and glycine (0-100%) on the texture, flavour and colour characteristics of fermented sausages and dry-cured pork loins was evaluated. Texture profile analysis and a sensory analysis were performed. Important flavour defects were detected with substitutions above 40% for the three substituents in both products, and with substitutions above 30% for glycine in dry-cured loin. A loss of cohesiveness was detected by the sensory analysis in fermented sausages at substitution levels higher than 30% with potassium lactate (K-lactate) and higher than 50% with glycine. Although the instrumental analysis detected texture changes in dry-cured loin, the sensory analysis did not detect any substitution effect on texture.     

Konjac gel as pork backfat replacer in dry fermented sausages: processing and quality characteristics

The effect of replacing animal fat (0%, 50% and 80% of pork backfat) by an equal proportion of konjac gel, on processing and quality characteristics of reduced and low-fat dry fermented sausage was studied. Weight loss, pH, and water activity of the sausage were affected (P<0.05) by fat reduction and processing time. Low lipid oxidation levels were observed during processing time irrespective of the dry sausage formulation. The fat content for normal-fat (NF), reduced-fat (RF) and low-fat (LF) sausages was 29.96%, 19.69% and 13.79%, respectively. This means an energy reduction of about 14.8% for RF and 24.5% for LF. As the fat content decreases there is an increase (P<0.05) in hardness and chewiness and a decrease (P<0.05) in cohesiveness. No differences were appreciated (P>0.05) in the presence of microorganisms as a result of the reformulation. The sensory panel considered that NF and RF products had acceptable sensory characteristics.