60-day aging requirement does not ensure safety of surface-mold-ripened soft cheeses manufactured from raw or pasteurized milk when Listeria monocytogenes is introduced as a postprocessing contaminant

Because of renewed interest in specialty cheeses, artisan and farmstead producers are manufacturing surface-mold-ripened soft cheeses from raw milk, using the 60-day holding standard (21 CFR 133.182) to achieve safety. This study compared the growth potential of Listeria monocytogenes on cheeses manufactured from raw or pasteurized milk and held for > 60 days at 4 degrees C. Final cheeses were within federal standards of identity for soft ripened cheese, with low moisture targets to facilitate the holding period. Wheels were surface inoculated with a five-strain cocktail of L. monocytogenes at approximately 0.2 CFU/ cm2 (low level) or 2 CFU/cm2 (high level), ripened, wrapped, and held at 4 degrees C. Listeria populations began to increase by day 28 for all treatments after initial population declines. From the low initial inoculation level, populations in raw and pasteurized milk cheese reached maximums of 2.96 +/- 2.79 and 2.33 +/- 2.10 log CFU/g, respectively, after 60 days of holding. Similar growth was observed in cheese inoculated at high levels, where populations reached 4.55 +/- 4.33 and 5.29 +/- 5.11 log CFU/g for raw and pasteurized milk cheeses, respectively. No significant differences (P < 0.05) were observed in pH development, growth rate, or population levels between cheeses made from the different milk types. Independent of the milk type, cheeses held for 60 days supported growth from very low initial levels of L. monocytogenes introduced as a postprocess contaminant. The safety of cheeses of this type must be achieved through control strategies other than aging, and thus revision of current federal regulations is warranted.     

Behavior of Escherichia coli O157:H7, Listeria monocytogenes, and Salmonella Typhimurium in teewurst, a raw spreadable sausage

The fate of Listeria monocytogenes, Salmonella Typhimurium, or Escherichia coli O157:H7 were separately monitored both in and on teewurst, a traditional raw and spreadable sausage of Germanic origin. Multi-strain cocktails of each pathogen (ca. 5.0 log CFU/g) were used to separately inoculate teewurst that was subsequently stored at 1.5, 4, 10, and 21 °C. When inoculated into commercially-prepared batter just prior to stuffing, in general, the higher the storage temperature, the greater the lethality. Depending on the storage temperature, pathogen levels in the batter decreased by 2.3 to 3.4, ca. 3.8, and 2.2 to 3.6 log CFU/g for E. coli O157:H7, S. Typhimurium, and L. monocytogenes, respectively, during storage for 30 days. When inoculated onto both the top and bottom faces of sliced commercially-prepared finished product, the results for all four temperatures showed a decrease of 0.9 to 1.4, 1.4 to 1.8, and 2.2 to 3.0 log CFU/g for E. coli O157:H7, S. Typhimurium, and L. monocytogenes, respectively, over the course of 21 days. With the possible exceptions for salt and carbohydrate levels, chemical analyses of teewurst purchased from five commercial manufacturers revealed only subtle differences in proximate composition for this product type. Our data establish that teewurst does not provide a favourable environment for the survival of E. coli O157:H7, S. Typhimurium, or L. monocytogenes inoculated either into or onto the product.     

Occurrence of foodborne pathogens in Irish farmhouse cheese

Food safety is a critical factor in the production of farmhouse cheese. In Ireland the varieties of farmhouse cheese produced reflect a much broader range than those produced commercially and some of these cheese varieties are associated with greater microbiological risk. These include cheese produced from unpasteurised milk and soft ripened cheese such as mould or smear-ripened cheeses which have high pH and relatively short ripening times. The aim of this study was to determine the microbiological quality of farmhouse cheeses in Ireland. Three hundred and fifty one cheese samples, from 15 cheese producers, were analysed for microbiological quality on a monthly basis throughout the year. The analyses included enumeration of Escherichia coli, Staphylococcus aureus and Listeria monocytogenes (using the relevant agars) and enrichment for L. monocytogenes. The cheeses selected were produced from ovine, caprine and bovine milk. Both unpasteurised and pasteurised milk cheeses were sampled and these included hard, semi-hard and soft cheeses, internal/external mould-ripened and smear-ripened cheeses and the cheeses represented different geographic regions. Of the cheeses tested, 94% were free of L. monocytogenes, all were within the EU limits for E. coli and only one cheese variety had S. aureus levels above the recommended numbers for the first 6 months of the year. Due to a modified production process the numbers were within the guidelines for the second six months. The results indicate that Irish farmhouse cheeses are of a high microbiological quality.     

Quantitative detection of Listeria monocytogenes in raw milk and soft cheeses: Culture-independent versus liquid- and solid-based culture-dependent real time PCR approaches

A culture-independent and two culture-dependent real time (rt-) PCR approaches were developed to quantitatively identify Listeria monocytogenes in raw milk and soft cheeses. The optimised rt-PCR revealed 100% inclusivity and exclusivity. DNA- and cell-based standard curves showed a good linearity of response (R² ≥ 0.987 and R² ≥ 0.998, respectively) for five orders of magnitude (39 × 10⁵ – 3 × 10⁰ genome equivalents and 10⁶–10¹ CFU equivalents, respectively) with about 100% relative accuracy and inter-assay variability ≤0.90%. Up to 1 genome equivalent/and 10 CFU/reaction were quantified in the DNA and cell standard curves, respectively. The rt-PCR was then combined with a liquid- (MPN technique) or a solid- (ALOA and PALCAM) based enumeration. The diagnostic sensitivity of the different approaches was investigated in artificially contaminated raw milk and soft cheeses. The rt-PCR culture-independent approach performed well in raw milk and (with a lower sensitivity) in stracchino cheese-based standard curves. MPN/rt-PCR was the best approach to enumerate low levels of L. monocytogenes in raw milk and stracchino cheese, while the ALOA-based rt-PCR quantification was more effective than the PALCAM-based. These performances were confirmed when 23 real samples of raw milk and soft cheeses by both the rt-PCR approaches were assayed.     

Lactose oxidase: An enzymatic approach to inhibit Listeria monocytogenes in milk

Listeria monocytogenes is a ubiquitous pathogen that can cause morbidity and mortality in immunocompromised individuals. Growth of L. monocytogenes is possible at refrigeration temperatures due to its psychrotrophic nature. The use of antimicrobials in dairy products is a potential way to control L. monocytogenes growth in processes with no thermal kill step, thereby enhancing the safety of such products. Microbial-based enzymes offer a clean-label approach for control of L. monocytogenes outgrowth. Lactose oxidase (LO) is a microbial-derived enzyme with antimicrobial properties. It oxidizes lactose into lactobionic acid and reduces oxygen, generating H₂O₂. This study investigated the effects of LO in UHT skim milk using different L. monocytogenes contamination scenarios. These LO treatments were then applied to raw milk with various modifications; higher levels of LO as well as supplementation with thiocyanate were added to activate the lactoperoxidase system, a natural antimicrobial system present in milk. In UHT skim milk, concentrations of 0.0060, 0.012, and 0.12 g/L LO each reduced L. monocytogenes counts to below the limit of detection between 14 and 21 d of refrigerated storage, dependent on the concentration of LO. In the 48-h trials in UHT skim milk, LO treatments were effective in a concentration-dependent fashion. The highest concentration of LO in the 21-d trials, 0.12 g/L, did not show great inhibition over 48 h, so concentrations were increased for these experiments. In the lower inoculum, after 48 h, a 12 g/L LO treatment reached levels of 1.7 log cfu/mL, a reduction of 1.3 log cfu/mL from the initial inoculum, whereas the control grew out to approximately 4 log cfu/mL, an increase of 1 log cfu/mL from the inoculum on d 0. When a higher challenge inoculum of 5 log cfu/mL was used, the 0.12 g/L and 1.2 g/L treatments reduced the levels by 0.2 to 0.3 log cfu/mL below the initial inoculum and the 12 g/L treatment by >1 log cfu/mL below the initial inoculum by hour 48 of storage at refrigeration temperatures. After the efficacy of LO was determined in UHT skim milk, LO treatments were applied to raw milk. Concentrations of LO were increased, and the addition of thiocyanate was investigated to supplement the effect of the lactoperoxidase system against L. monocytogenes. When raw milk was inoculated with 2 log cfu/mL, 1.2 g/L LO alone and combined with sodium thiocyanate reduced ~0.8 log cfu/mL from the initial inoculum on d 7 of storage, whereas the control grew out to >1 log cfu/mL from the initial inoculum. Furthermore, in the higher inoculum, 1.2 g/L LO combined with sodium thiocyanate reduced L. monocytogenes counts from the initial inoculum by >1 log cfu/mL, whereas the control grew out 2 log cfu/mL from the initial inoculum. Results from this study suggest that LO is inhibitory against L. monocytogenes in UHT skim milk and in raw milk. Therefore, LO may be an effective treatment to prevent L. monocytogenes outgrowth, increase the safety of raw milk, and be used as an effective agent to prevent L. monocytogenes proliferation in fresh cheese and other dairy products. This enzymatic approach is a novel application to control the foodborne pathogen L. monocytogenes in dairy products.     

Staphylococcus aureus and Listeria monocytogenes in Norwegian raw milk cheese production

The aim of this study was to survey the presence of Staphylococcus aureus and Listeria monocytogenes during the cheese making process in small-scale raw milk cheese production in Norway.The prevalence of S. aureus in bovine and caprine raw milk samples was 47.3% and 98.8%, respectively. An increase in contamination during the first 2-3 h resulted in a 73.6% prevalence of contamination in the bovine curd, and 23 out of 38 S. aureus-negative bovine milk samples gave rise to S. aureus-positive curds. The highest contamination levels of S. aureus were reached in both caprine and bovine cheese after 5-6 h (after the first pressing). There was no contamination of L. monocytogenes in caprine cheeses and only one (1.4%) contaminated bovine cheese.This work has increased our knowledge about S. aureus and L. monocytogenes contamination during the process of raw milk cheese production and gives an account of the hygiene status during the manufacture of Norwegian raw milk cheeses.     

The occurrence of Listeria monocytogenes in cheese from a manufacturer associated with a case of listeriosis

A case of listeriosis was associated with the consumption of a soft cheese produced in England. Goats cheese and other products from the same food manufacturer were examined for the presence of Listeria over the following 11 months. Listeria monocytogenes was isolated from 16 of 25 cheese samples on retail sale, 12 of 24 cheese samples obtained directly from the factory, and from shelving within the plant. Phage-typing of 68 isolates of L. monocytogenes from cheese samples and the factory showed that 66 (97%) were indistinguishable from the strain isolated from the patient's cerebrospinal fluid and stool. L. monocytogenes was not isolated from seven goats milk or two yoghurt samples. Listeria innocua was isolated from 10 cheese samples, two of which contained no other species of Listeria. Levels of L. monocytogenes shortly after production were low (<10/g), but were higher (10⁵–10⁷ cfu/g) in six of the 16 cheese samples obtained from retail outlets. Multiplication of L. monocytogenes was demonstrated in cheeses contaminated at the factory and held at 4°C in the laboratory.     

Use of high pressure treatment to attenuate starter bacteria for use as adjuncts for Cheddar cheese manufacture

Attenuated starter bacteria cannot produce acid during cheese manufacture, but contain enzymes that contribute to cheese ripening. The aim of this study was to investigate attenuation of starter bacteria using high pressure treatment, for use in combination with a primary starter for Cheddar cheese manufacture, and to determine the effect of such adjunct cultures on secondary proteolysis during ripening. Lactococcus lactis ssp. cremoris HP and L. lactis ssp. cremoris 303 were attenuated by pressure treatment at 200 MPa for 20 min at 20 °C. Cheddar cheese was manufactured using untreated cultures of both these starter strains, either alone or in combination with their high pressure-treated equivalents. High pressure-treated starters did not produce acid during cheese manufacture and starter counts in cheeses manufactured using high pressure-treated starter did not differ from those of the controls. Higher levels of cell lysis were apparent in cheese manufactured using high pressure-treated strains than in the controls after 26 d of ripening. Small differences were observed in the peptide profiles of cheeses, analysed by reversed-phase HPLC; cheeses manufactured using high pressure-treated starters also had slightly higher levels of amino acids than the relevant controls. Overall, addition of high pressure-treated starter bacteria as a secondary starter culture accelerated secondary proteolysis in Cheddar cheese.

Industrial relevance

Attenuated starters provide extra pool of enzymes, which can influence cheese ripening, without affecting the cheese making schedule. This paper presents an alternative method for attenuation of starter bacteria using high pressure treatment and their subsequent use to accelerate secondary proteolysis in Cheddar cheese during ripening.     

Effects of ultra high hydrostatic pressure on Listeria monocytogenes and natural flora in broth, milk and fruit juices

Listeria monocytogenes was subjected to ultra high hydrostatic pressure (UHHP) treatments from 200 to 700 MPa at 25 °C in broth, raw milk, peach juice and orange juice. Survivor curves showed that cell death increased as pressure increased. After 10 min pressure treatment at 400 MPa reductions of about 2.09 and 2.76 log CFU mL^?1 in aerobic bacteria and L. monocytogenes, respectively, were produced in raw milk, this increased to 5.09 and 6.47 log CFU mL^?1, respectively, at 600 MPa. Death of bacteria at UHHP treatment was greater in orange juice than peach juice, and in peach juice than milk. Listeria monocytogenes was more sensitive to increased pressure than increased pressurization time. Injury of L. monocytogenes occurred from 0 to 100%. Factors effecting the rate of microbial inactivation are: pressure, age of cell, composition of medium, and pressurization time. UHHP inactivation can be used to extend shelf life and increase food quality during storage, and may also contribute to inactivation of L. monocytogenes.     

A review of the microbiological hazards of dairy products made from raw milk

This review concentrates on information concerning microbiological hazards possibly present in raw milk dairy products, in particular cheese, butter, cream and buttermilk. The main microbiological hazards of raw milk cheeses (especially soft and fresh cheeses) are linked to Listeria monocytogenes, verocytotoxin-producing Escherichia coli (VTEC), Staphylococcus aureus, Salmonella and Campylobacter. L. monocytogenes, VTEC and S. aureus have been identified as microbiological hazards in raw milk butter and cream albeit to a lesser extent because of a reduced growth potential compared with cheese. In endemic areas, raw milk dairy products may also be contaminated with Brucella spp., Mycobacterium bovis and the tick-borne encephalitis virus (TBEV). Potential risks due to Coxiella burnetii and Mycobacterium avium subsp. paratuberculosis (MAP) are discussed. Pasteurisation ensures inactivation of vegetative pathogenic microorganisms, which increases the safety of products made thereof compared with dairy products made from raw milk. Several control measures from farm to fork are discussed.     

Foci of contamination of Listeria monocytogenes in different cheese processing plants

Listeria monocytogenes is a ubiquitous bacterium widely distributed in the environment that can cause a severe disease in humans when contaminated foods are ingested. Cheese has been implicated in sporadic cases and in outbreaks of listeriosis worldwide. Environmental contamination, in several occasions by persistent strains, has been considered an important source of finished product contamination. The objectives of this research were to (i) evaluate the presence of L. monocytogenes within the factory environments and cheeses of three processing plants, artisanal producer of raw ewe's milk cheeses (APC), small-scale industrial cheese producer (SSI) and industrial cheese producer (ICP) each producing a distinct style of cheese, all with history of contamination by L. monocytogenes (ii) and identify possible sources of contamination using different typing methods (arsenic and cadmium susceptibility, geno-serotyping, PFGE). The presence of markers specific for 3 epidemic clones (ECI–ECIII) of L. monocytogenes was also investigated. Samples were collected from raw milk (n = 179), whey (n = 3), cheese brining solution (n = 7), cheese brine sludge (n = 505), finished product (n = 3016), and environment (n = 2560) during, at least, a four-year period. Listeria monocytogenes was detected in environmental, raw milk and cheese samples, respectively, at 15.4%, 1.1% and 13.6% in APC; at 8.9%, 2.9% and 3.4% in SSI; and at 0%, 21.1% and 0.2% in ICP. Typing of isolates revealed that raw ewe's milk and the dairy plant environment are important sources of contamination, and that some strains persisted for at least four years in the environment. Although cheeses produced in the three plants investigated were never associated with any case or outbreak of listeriosis, some L. monocytogenes belonging to specific PFGE types that caused disease (including putative epidemic clone strains isolated from final products) were found in this study.     

Behavior and control of Listeria innocua during manufacture and storage of Turkish White Cheese

The physico-chemical changes occurring in Turkish White Cheese and the survival of Listeria innocua, total aerobic count (TAC) and lactic acid bacteria (LAB) in artificially inoculated Turkish White Cheese during manufacture and storage periods (45 days), with respect to different contamination levels of L. innocua were investigated. Turkish White Cheese was manufactured by the short-set procedure in pilot-plant-sized vats in a commercial dairy plant. Pasteurized cow's milk was inoculated with L. innocua to a final level of 3.84 (low dose) and 7.12 (high dose) log₁₀ CFU/ml. Bacterial loads of inoculated milk, whey, post-ripened curd and post-salted cheese was determined during processing at 23 °C. Cheeses were stored in 16% saline solution at 4 °C up to 45 days. Samples were taken from each treatment and analyzed at 5-day intervals. Total reduction in viable cell numbers of L. innocua in Turkish White Cheese with each inoculum dose was approximately 2 log₁₀ cycles during the storage period with a first-order-rate of inactivation at 4 °C. Variations in initial number of LAB in L. innocua seeded cheeses after overnight pressing were observed as 3.84, 4.24, 5.85 log CFU/ml at conditions of high-dose, low-dose inoculation of L. innocua and without inoculation as control sample, respectively. The salt concentration, pH, starter activity and storage time were determined to be the main causes of this reduction in LAB. The results had shown that L. innocua was able to survive during the manufacture and storage due to inadequate pasteurization or post-process contamination. The storage period has been defined as a critical control point (CCP) for consumption of Turkish White Cheese and calculated to be at least 90 and 178 days at refrigeration temperature, in low and high inoculum doses of L. innocua, respectively, for a safe consumption. This study, which gives the result of behavior of low and high dose of Listeria monocytogenes during storage as CCP, can even guide the future risk assessment studies on Listeria in Turkish White Cheese.     

A study of the occurrence of Listeria species in raw sheep milk

The occurrence of bacteria from the genus Listeria in raw sheep milk and traditional local cheese was studied in three regions of the Karak district of Jordan. Conventional plating methods for the detection of Listeria species were followed to determine the average and the percentage of the contaminated samples. The result shows that there were significant differences between the regions in the study concerning the average and the percentage of positive occurrences of Listeria species in raw sheep milk. The results also showed that mainly L. monocytogenes and, to a lesser degree, L. ivanovii and L. innocua were found in the milk samples, while the occurrence of L. monocytogenes in cheese samples was very low.     

Development of a rapid, simple paddle-style dipstick dye immunoassay specific for Listeria monocytogenes

We have developed two types of new paddle-style dipstick dye immunoassays. The first is genus Listeria specific and the second is specific to Listeria monocytogenes. They are based respectively, on antisera raised against heat-killed L. monocytogenes cells and against internalin B crude extract, a virulence protein found only in the pathogenic L. monocytogenes. The minimum detectable level for L. monocytogenes is 2×10⁷ CFU ml⁻¹ for strain number 88/049 in pure culture. Detection is unaffected by the presence of high numbers (approximately log 8.0 CFU/ml) of the other microorganisms tested. When the dipsticks were applied to milk samples inoculated with L. monocytogenes reference material (ALM92), there was a strong response to the enrichment cultures. The new assay may prove useful in detection of L. monocytogenes in enrichment cultures of milk and ice cream food samples.     

Nisin treatments to control Listeria monocytogenes post-processing contamination on Anthotyros, a traditional Greek whey cheese, stored at 4°C in vacuum packages

Post-processing contamination and growth of Listeria monocytogenes in whey cheeses stored under refrigeration is an important safety concern. This study evaluated commercially available nisin (Nisaplin^®) as a biopreservative to control L. monocytogenes introduced post-processing on Anthotyros, a traditional Greek whey cheese, stored at 4°C in vacuum packages for up to 45 days. The whey used (pH 6.5–6.7) was from Feta cheese manufacture, and it was subjected either to natural acidification (pH 5.3, readjusted to 6.2 with 10% NaOH) prior to heating, or to direct acidification (pH 6.0–6.2) at 80°C with 10% citric acid. Nisin was added either to the whey (100 or 500 IU g⁻¹) prior to heating, or to the cheese (500 IU g⁻¹) prior to packaging, also inoculated with ca. 10⁴ cfu g⁻¹ of L. monocytogenes strain Scott A. In cheese samples without nisin, L. monocytogenes (PALCAM agar) exceeded 7 log cfu g⁻¹ after the first 10 days of storage, irrespective of the whey acidification method. All nisin treatments had an immediate lethal effect (0.7–2.2 log reduction) on L. monocytogenes populations at inoculation (day 0), which was more pronounced with 500 IU g⁻¹ added to the whey. This treatment also suppressed L. monocytogenes growth below the inoculation level for 30 and 45 days in naturally and directly acidified samples, respectively. All other treatments had weak antilisterial effects. Nisin reversed the natural spoilage flora of Anthotyros cheese from Gram-positive to Gram-negative, and this ecological alteration was far more pronounced in the most effective antilisterial treatments.     

Modelling the growth of Listeria monocytogenes in fresh green coconut (Cocos nucifera L.) water

The behaviour of Listeria monocytogenes in the fresh coconut water stored at 4 °C, 10 °C and 35 °C was studied. The coconut water was aseptically extracted from green coconuts (Cocos nucifera L.) and samples were inoculated in triplicate with a mixture of 5 strains of L. monocytogenes with a mean population of approximately 3 log₁₀ CFU/mL. The kinetic parameters of the bacteria were estimated from the Baranyi model, and compared with predictions of the Pathogen Modelling Program so as to predict its behaviour in the beverage. The results demonstrated that fresh green coconut water was a beverage propitious for the survival and growth of L. monocytogenes and that refrigeration at 10 °C or 4 °C retarded, but did not inhibit, growth of this bacterium. Temperature abuse at 35 °C considerably reduced the lagtimes. The study shows that L. monocytogenes growth in fresh green coconut water is controlled for several days by storage at low temperature, mainly at 4 °C. Thus, for risk population this product should only be drunk directly from the coconut or despite the sensorial alterations should be consumed pasteurized.     

Microbial and sensory changes throughout the ripening of Prato cheese made from milk with different levels of somatic cells

The objective of this research was to evaluate the effects of 2 levels of raw milk somatic cell count (SCC) on the composition of Prato cheese and on the microbiological and sensory changes of Prato cheese throughout ripening. Two groups of dairy cows were selected to obtain low-SCC (<200,000 cells/mL) and high-SCC (>700,000 cells/mL) milks, which were used to manufacture 2 vats of cheese. The pasteurized milk was evaluated according to the pH, total solids, fat, total protein, lactose, standard plate count, coliforms at 45°C, and Salmonella spp. The cheese composition was evaluated 2 d after manufacture. Lactic acid bacteria, psychrotrophic bacteria, and yeast and mold counts were carried out after 3, 9, 16, 32, and 51 d of storage. Salmonella spp., Listeria monocytogenes, and coagulase-positive Staphylococcus counts were carried out after 3, 32, and 51 d of storage. A 2 × 5 factorial design with 4 replications was performed. Sensory evaluation of the cheeses from low- and high-SCC milks was carried out for overall acceptance by using a 9-point hedonic scale after 8, 22, 35, 50, and 63 d of storage. The somatic cell levels used did not affect the total protein and salt:moisture contents of the cheeses. The pH and moisture content were higher and the clotting time was longer for cheeses from high-SCC milk. Both cheeses presented the absence of Salmonella spp. and L. monocytogenes, and the coagulase-positive Staphylococcus count was below 1 × 10² cfu/g throughout the storage time. The lactic acid bacteria count decreased significantly during the storage time for the cheeses from both low- and high-SCC milks, but at a faster rate for the cheese from high-SCC milk. Cheeses from high-SCC milk presented lower psychrotrophic bacteria counts and higher yeast and mold counts than cheeses from low-SCC milk. Cheeses from low-SCC milk showed better overall acceptance by the consumers. The lower overall acceptance of the cheeses from high-SCC milk may be associated with texture and flavor defects, probably caused by the higher proteolysis of these cheeses.     

Survey of raw milk cheeses for microbiological quality and prevalence of foodborne pathogens

Cheese may be manufactured in the United States using raw milk, provided the cheese is aged for at least 60 days at temperatures not less than 35 °F (1.7 °C). There is now increased concern among regulators regarding the safety of raw milk cheese due to the potential ability of foodborne pathogens to survive the manufacturing and aging processes. In this study, 41 raw milk cheeses were obtained from retail specialty shops, farmers’ markets, and on-line sources. The cheeses were then analyzed for the presence of Listeria monocytogenes, Salmonella, Escherichia coli O157:H7, Staphylococcus aureus, and Campylobacter. Aerobic plate counts (APC), coliform and yeast/mold counts were also performed. The results revealed that none of the enteric pathogens were detected in any of the samples tested. Five samples contained coliforms; two of those contained E. coli at less than 10² cfu/g. Three other cheese samples contained S. aureus. The APC and yeast-mold counts were within expected ranges. Based on the results obtained from these 41 raw milk cheeses, the 60-day aging rule for unpasteurized milk cheeses appears adequate for producing microbiologically safe products.     

Bactericidal activity of lauric arginate in milk and Queso Fresco cheese against Listeria monocytogenes cold growth

Lauric arginate (LAE) at concentrations of 200 ppm and 800 ppm was evaluated for its effectiveness in reducing cold growth of Listeria monocytogenes in whole milk, skim milk, and Queso Fresco cheese (QFC) at 4°C for 15 to 28 d. Use of 200 ppm of LAE reduced 4 log cfu/mL of L. monocytogenes to a nondetectable level within 30 min at 4°C in tryptic soy broth. In contrast, when 4 log cfu/mL of L. monocytogenes was inoculated in whole milk or skim milk, the reduction of L. monocytogenes was approximately 1 log cfu/mL after 24 h with 200 ppm of LAE. When 800 ppm of LAE was added to whole or skim milk, the initial 4 log cfu/mL of L. monocytogenes was nondetectable following 24 h, and no growth of L. monocytogenes was observed for 15 d at 4°C. With surface treatment of 200 or 800 ppm of LAE on vacuum-packaged QFC, the reductions of L. monocytogenes within 24 h at 4°C were 1.2 and 3.0 log cfu/g, respectively. In addition, the overall growth of L. monocytogenes in QFC was decreased by 0.3 to 2.6 and by 2.3 to 5.0 log cfu/g with 200 and 800 ppm of LAE, respectively, compared with untreated controls over 28 d at 4°C. Sensory tests revealed that consumers could not determine a difference between QFC samples that were treated with 0 and 200 ppm of LAE, the FDA-approved level of LAE use in foods. In addition, no differences existed between treatments with respect to flavor, texture, and overall acceptability of the QFC. Lauric arginate shows promise for potential use in QFC because it exerts initial bactericidal activity against L. monocytogenes at 4°C without affecting sensory quality.     

Yield, composition and rheological characteristics of cheddar cheese made with high pressure processed milk

High Pressure (HP) treatment of milk prior to cheese-making was shown to increase the yield of cheese due to increased protein and moisture retention in cheese. Cheeses were made with raw milk or milk treated with high temperature short-time (HTST) pasteurization, and HP treatments at two levels (483 and 676 MPa) at 10 °C, 483 MPa HP at 30 °C, and 483 MPa HP at 40 °C. Cheese yield, total solids, protein, fat and salt contents were evaluated, and fat and protein recovery indices were calculated. Cheeses from HP treatments of 676 MPa at 10 °C and 483 MPa at 30 °C exhibited wet yields of 11.40% and 11.54%, respectively. Protein recovery was 79.9% for HP treatment of 676 MPa at 10 °C. The use of slightly higher pressurization temperatures increased moisture retention in cheese. Visco-elasticity of cheeses was determined by dynamic oscillatory testing and a creep-recovery test. Rheological parameters such as loss (G″) and storage (G′) moduli were dependent on oscillation frequency. At high (173 rad/s) and low (2.75 rad/s) angular frequencies, cheeses made from milk treated at 483 MPa at 10 °C behaved more solid-like than other treatments. Creep tests indicated that cheeses from milk treated with 483 MPa HP at 10 °C showed the smallest instantaneous compliance (J_o), confirming the more solid-like behavior of cheese from the 483 MPa at 10 °C treatment compared to the behavior of cheeses from other treatments. Cheeses made with pasteurized milk were more deformable, exhibited less solid-like behavior than cheeses made with HP treated milk, as shown by the J_o value. With more research into bacteriological implications, HP treatment of raw milk can augment Cheddar cheese yield with better curd formation properties.