Survey of aflatoxin contamination of dried figs grown in Turkey in 1986

A total of 284 dried fig samples, collected from fields during drying, and from warehouse and processing units in the Aegean region of Turkey in 1986, were examined for aflatoxin contamination. Aflatoxin B1, B2, and G1 were detected in 4, 2, and 2% of the samples, respectively, which were of the lower grade of figs taken from the drying stage. The average alfatoxin levels in positive samples were estimated to be 112.3 (B1), 50.6 (B2), and 61.4 ng/g (G1). The samples collected from storage (64 samples) and processing units (14 samples) contained no aflatoxins. The results of this survey show that aflatoxin contamination of Turkish dried figs in 1986 was highly correlated with the poorer grade of fig.     

Survey for co-occurrence of ochratoxin A and aflatoxin B1 in dried figs in Turkey by using a single laboratory-validated alkaline extraction method for ochratoxin A

A survey was carried out to determine the co-occurrence of ochratoxin A and aflatoxin B1 in dried figs from Turkey. Samples from two seasons of crops (2003 and 2004) intended for export to the European Union and the 2004 crop obtained from the domestic Turkish market were analyzed. Affinity column cleanup methods were employed for determining separately ochratoxin A and aflatoxin B1, but for ochratoxin A an alkaline extraction procedure was employed (in contrast to the conventionally employed acidic extraction), which gave consistently higher toxin recovery. In-house validation of the ochratoxin A method gave a limit of detection of 0.15 ng/g and a limit of quantification of 0.5 ng/g with a repeatability of 5.8% in the range 5 to 10 ng/g (with a mean recovery of 94% for spiked samples). Positive results for ochratoxin A were confirmed by liquid chromatography-mass spectrometry. For the 2003 export figs (58 samples), 7 samples contained only aflatoxin B1, 2 samples contained only ochratoxin A, and 2 samples contained both toxins (with maximum concentrations of 35.1 ng/g for aflatoxin B1 and 13.0 ng/g for ochratoxin A). Similarly for the 2004 export figs (41 samples), 16 samples contained only aflatoxin B1, 4 samples contained only ochratoxin A, and 2 samples contained both toxins (with maximum concentrations of 20.6 ng/g for aflatoxin B1 and 26.3 ng/g for ochratoxin A). Of 20 retail samples of dried figs from Turkey, only one sample contained ochratoxin A (2.0 ng/g) and none were contaminated with aflatoxin B1. This survey revealed a 14 to 15% incidence of occurrence of ochratoxin A for 2 years, which is higher than previously reported.     

Aspergillus section Flavi and aflatoxins in dried figs and nuts in Algeria

The presence of Aspergillus section Flavi and aflatoxin (AF) contamination was investigated in 112 samples of peanuts, almonds and dried figs collected in Algeria. The occurrence of aflatoxin B1 (AFB1), B2 (AFB2), G1 (AFG1) and G2 (AFG2) in different commodities has been determined with a sensitive method based on high performance liquid chromatography (HPLC) coupled with fluorescence detection with post-column photochemical derivatisation. Analytical results indicated that 28 samples of peanuts, 16 samples of almonds and 26 samples of dried figs contained detectable levels of AFs. A total of 69 samples (61.6%) were contaminated with AFB1 ranging from the limit of quantification to 174 µg kg^?1. AFB2 was found in 12 samples (10.7%) and varied from 0.18 to 193 µg kg^?1. Seven samples revealed AF concentrations lower than the limit of quantification. Eleven peanut and fourteen dried fig samples exceeded the European maximum limits for AFB1.     

Surveillance and control of aflatoxin contamination of dried figs and fig paste imported into the United Kingdom.

Samples of dried figs and fig pastes from Turkey supplied voluntarily by UK importers and retailers during the period November 1988 to January 1989 showed both a high incidence and high levels of contamination with aflatoxins. In the samples tested, 24% had total aflatoxin concentrations above 10 micrograms/kg, with the highest level being 165 micrograms/kg. More rigorous monitoring of the 1989 fig harvest was undertaken on bulk consignments for all figs from Turkey entering the UK. For whole dried figs 20 kg samples were taken (as 20 sub-samples), and for fig paste 5 kg samples were taken (again as 20 sub-samples). Figs were minced, blended with water and mixed prior to sub-sampling for analysis. Analysis was by immunoaffinity column clean-up with HPLC determination of aflatoxins with fluorescence detection. Examination showed that 11% of 112 consignments of fig paste and 9% of 93 consignments of whole dried figs were contaminated with total alfatoxin concentrations above 10 micrograms/kg, with the highest level of contamination being 40 micrograms/kg. As a result of this surveillance programme 14 consignments of figs were refused entry into the United Kingdom.     

COMBINED EFFECT OF pH AND HEAT TREATMENT ON DEGRADATION OF AFLATOXINS IN DRIED FIGS

Dried figs are sensitive commodities to aflatoxin contamination. Although preventive methods are the logical solution to aflatoxin problems, once the product is contaminated, decontamination procedures are inevitable. In this study, the effectiveness of a procedure consisted of acidification/alkalization, and heat treatment in degradation of aflatoxins was evaluated. The pH of dried fig extracts was adjusted to 3.1, 3.5, 6, 8 or 10 by adding acid or base. Extracts were heated at 50, 75 or 98C for 1 or 2 h, and then the residual aflatoxin B₁, B₂, G₁ and G₂ were determined. The highest level of degradation for aflatoxin B₁ (97  ±  1%) and B₂ (87  ±  1%) were observed at pH 10 in samples heated at 98 and 50C, respectively. Some treatments resulted in 100% degradation of aflatoxin G₁ and G₂ so that they could not be detected.

PRACTICAL APPLICATIONS

Aflatoxin contamination is a serious problem for a number of processed and non-processed foods, including dried figs. This not only presents severe risks to human and animal health but also causes economic problems for countries such as Turkey, U.S.A., Greece and Spain, which produce and export dried figs. It is clear that detoxifying studies are unavoidable when the amount of crop contaminated by toxins is considered. Therefore, the food industry is in search of applications that are effective in mycotoxin detoxification and adaptable to food processes. This is the first report on degradation of aflatoxins in naturally contaminated dried figs by such a promising method.     

Aflatoxins, patulin and ergosterol contents of dried figs in Turkey.

Dried figs of three different categories, palatable, fluorescent, and cull, were investigated for their contents of aflatoxins (B(1), B(2), G(1) and G(2)), patulin, and ergosterol. Samples were obtained from four fig processing plants located in a major fig producing area in the Aegean Region in Turkey. Affinity column clean-up methods were employed for aflatoxins. All aflatoxins, patulin, and ergosterol were determined using high performance liquid chromatography. Palatable figs contaminated with trace amounts of aflatoxins, patulin, and ergosterol, so they posed no risk for the consumer when national and/or international regulatory limits were considered. Fluorescent figs were contaminated with high (117.9-471.9 ppb) aflatoxin levels and cull figs with high patulin (39.3-151.6 ppb) and ergosterol (4.5-18 ppm) levels. The total aflatoxins content was significantly correlated with the patulin content (r(2) = 0.813, p < 0.002) and the ergosterol content (r(2) = 0.920, p < 0.002) only in fluorescent figs. However there was no significant correlation between patulin and ergosterol contents of fluorescent figs. Furthermore, there were no significant correlations between the contents of any two of the three substances in cull figs. This is the first report on the presence of patulin and its co-occurrence with aflatoxin in dried figs.     

Comparison of homogenization techniques and incidence of aflatoxin contamination in dried figs for export

To determine differences in mean aflatoxin contamination and subsample variance from dry and slurry homogenizations, 10 kg of six different, naturally contaminated dried fig samples were collected from various exporting companies in accordance with the EU Commission Directive. The samples were first dry-mixed for 5 min using a blender and sub-sampled seven times; the remainder was slurry homogenized (1 : 1, v/v) and sub-sampled seven times. Aflatoxin B₁ and total aflatoxin levels were recorded and coefficient of variations (CV) computed for all sub-samples. Only a small reduction in sub-sample variations, indicated by the lower CV values, and slight differences in mean aflatoxin B₁ and total aflatoxin levels were observed when slurry homogenization was applied. Therefore, 7326 dried figs, destined for export from Turkey to the EU and collected during the 2008 crop year, were dry-homogenized and tested for aflatoxins (B_1, B_2, G₁ and G₂) by immunoaffinity column clean-up using RP-HPLC. While 34% of the samples contained detectable levels of total aflatoxins (0.20–208.75 µg kg^?1), only 9% of them exceeded the EU limit of 4 µg kg^?1 in the range 2.0–208.75 µg kg^?1, respectively. A substantial increase in the incidence of aflatoxins was observed in 2008, most likely due to the drought stress experienced in Aydin province as occurred in 2007.     

THE AFLATOXIN CONTAMINATION OF FIG FRUITS IN AYDIN CITY (TURKEY)

The mold flora of 50 dried fig samples consumed in Turkey was examined and the aflatoxigenic ones were determined. Among 127 fungi isolated, 74 were Aspergillus, 24 were Trichoderma, 16 were Fusarium and 13 were Acremonium. Of the isolates, 17 were aflatoxigenic and four of them were capable to produce aflatoxin, three of which were characterized as A. flavus and one as A. parasiticus. Aflatoxin production of four strains was confirmed by high pressure liquid chromotography. The effect of UV irradiation on mold count and aflatoxin quantity was also tested. It was found that UV irradiation led to a decrease in the mold count and aflatoxin quantity.

PRACTICAL APPLICATIONS

Studies have shown that the concentration of aflatoxins may exceed the determined limits in dried figs. Its presence can be a potential threat to the health of consumers. Dried figs are one of the major agricultural export products of Turkey ( Senyuva et al. 2005 ). The effects of UV irradiation on mold flora of dried figs and aflatoxins have been examined. The Aspergillus flavus and parasiticus agar (AFPA) medium is used for detection of aflatoxigenic species, and coconut agar medium (CAM) is used to detect the aflatoxin-producing ability of aflatoxigenic strains. It was found that the reproduction of the molds in dried figs, consequently the aflatoxigenic mold strains, can be depressed by UV irradiation. It was found that increasing time of UV irradiation led to a decrease in the mold count in dried figs. In addition, a UV irradiation applied for 90 min, was found to decrease the aflatoxin quantity in dried figs in an amount of 25%. Because of inexpensiveness and easiness of the application it was concluded that the UV irradiation can be used as a practical application.     

Mycoflora and natural occurrence of aflatoxin, cyclopiazonic acid, fumonisin and ochratoxin A in dried figs

Mycoflora, the mycotoxigenic properties of moulds, and natural contamination with mycotoxins such as aflatoxins (AFs), cyclopiazonic acid (CPA), fumonisin B(1) (FB(1)) and ochratoxin A (OTA) were investigated in dried figs. Dry fig samples were collected from orchards during the drying stage in the Aegean Region of Turkey. Fungal isolates were identified using morphological, chemical as well as molecular methods. Mycotoxigenic characteristics of moulds were assessed by thin-layer chromatography (TLC) and high-performance liquid chromatography (HPLC). Mycotoxins except CPA (by TLC) were determined by HPLC. All the fig samples were contaminated with moulds and 94.7% contained one or more mycotoxigenic species. The most prevalent moulds present in dried figs belong to the Aspergillus section Nigri members, being 93.9% positive for the samples, followed by Fusarium spp., Aspergillus section Flavi and Penicillium spp. On the other hand, Fusarium spp. had the highest count and the number of fumonisin producing Fusarium was also high. A total of 48% of 115 dried fig samples contained OTA (range = 0.1-15.3 ng g(-1)), 74.7% of the samples had FB(1) (range = 0.05-3.65 mg kg(-1)), 10.0% of the samples had aflatoxin (range = 0.1-763.2 ng g(-1)) and 24.3% of the samples were tentatively identified as being contaminated with CPA (range = 25-187 ng g(-1)). Dried fig samples were contaminated with one (33.0%), two (47.0%), three (5.2%) and four mycotoxins (3.5%). A total of 11.3% of dried fig samples were not contaminated with any of the four mycotoxins. To the best of our knowledge, CPA and fumonisin have been found for the first time in dried figs.     

Carry-Over of Aflatoxins to Fig Molasses from Contaminated Dried Figs

The carry-over of aflatoxins to fig molasses produced by using two different processing techniques from contaminated dried figs (> 1000 ppb of total aflatoxins) were examined by using a HPLC technique. The effects of extraction, bleaching and concentration steps on the reduction of aflatoxin levels were also investigated. The reductions in total aflatoxin levels in fig molasses produced by using the two techniques were detected to be 62 and 38%, respectively. Extraction, bleaching and concentration steps were observed to cause 22% reduction in total aflatoxin levels.     

光化学衍生-高效液相色谱法测定 粮谷类样品中黄曲霉毒素

目的建立光化学衍生-高效液相色谱荧光法测定粮谷类样品中的黄曲霉毒素(AFT)含量。方法样品经Romer Labs免疫亲和柱净化,经SW-3光化学柱后衍生,经高效液相色谱分离和荧光检测器测定,分析其中黄曲霉毒素B_1、B_2、G_1、G_2的含量。同时对免疫亲和柱洗脱条件、流动相的洗脱程序进行了优化。结果在0.5~10 ng/mL(AFT B_1,G_1)和0.15~3.0 ng/mL(AFT B_2,G_2)线性范围内,所得回归方程的相关系数均大于0.999。黄曲霉毒素B_1、G_1方法检出限为0.15 ng/g,黄曲霉毒素B_2、G_2方法检出限为0.05 ng/g,加标回收率为89.5%~107%,精密度为1.4%~7.2%。采集粮谷类样品222件,其中有5件样品检出AFT,但均未超过国家限值标准。结论该方法灵敏度和准确度较高,可适用于粮谷类食品中黄曲霉毒素的检测。     

Mycotoxins in botanicals and dried fruits: A review

Botanicals are used in many countries for medicinal and general health-promoting purposes. Numerous natural occurrences of mycotoxins in botanicals and dried fruits have been reported. Aflatoxins or ochratoxin A (OTA) have been found in botanicals such as ginseng, ginger, liquorice, turmeric, and kava-kava in the USA, Spain, Argentina, India, and some other countries, while fumonisins have been found in medicinal wild plants in South Africa and in herbal tea and medicinal plants in Turkey. Zearalenone was identified in ginseng root. Dried fruits can be contaminated with aflatoxins, OTA, kojic acid, and, occasionally, with patulin or zearalenone. One main area of concern is aflatoxins in dried figs; bright greenish yellow fluorescence under ultraviolet light is associated with aflatoxin contamination. OTA in dried vine fruits (raisins, sultanas, and currants) is another concern. There are also reports of aflatoxins in raisins and OTA in dried figs, apricots, dried plums (prunes), dates, and quince. Maximum permitted levels in the European Union include 4 µg kg^-1 for total aflatoxins in dried fruit intended for direct consumption and 10 µg kg^-1 for OTA in dried vine fruit. This review discusses the occurrence of mycotoxins in botanicals and dried fruits and analytical issues such as sampling, sample preparation, and methods for analysis. Fungal contamination of these products, the influence of sorting, storage, and processing, and prevention are also considered.     

Aflatoxins in pozol, a nixtamalized, maize-based food

To determine whether pozol, a nixtamalized maize-based food was contaminated with aflatoxins, samples of non-fermented pozol were collected during the period November 2002 to April 2003 from local markets at Comitan in Chiapas, Mexico. The samples were analyzed for the presence of aflatoxins. Nineteen out of one hundred and eleven samples were contaminated with aflatoxin B2 (AFB2) and traces of aflatoxin B1 (AFB1). The percentage of samples contaminated with AFB2 in pozol prepared with white maize was 5.4%. Pozol mixed with toasted cacao paste had a contamination rate of 41.5%. No aflatoxins were detected in pozol prepared with yellow maize. It was found that only 1 of 19 contaminated samples had aflatoxin concentrations above 20 ppb.     

Ochratoxin A in dried vine fruit: method development and survey

A method is described for the determination of concentrations of the mycotoxin ochratoxin A in dried vine fruits (currants, raisins and sultanas) using acidic methanolic extraction,immunoaffinity chromatography clean-up and HPLC determination. The limit of detection was estimated as 0.2mug/kg, and recoveries of 63-77% were achieved at 5mug/kg. HPLC-mass spectrometric confirmation of the identity of ochratoxin was obtained. Ochratoxin A and aflatoxins were determined in 60 samples of retail dried vine fruits purchased in the United Kingdom. Ochratoxin A was found in excess of 0.2mug/kg in 19 of 20 currant, 17 of 20 sultana and 17 of 20 raisin samples examined, an overall incidence of 88% . The maximum level found was 53.6mug/kg. No aflatoxin was found in any sample analysed, using a method with a detection limit of 0.2mug/kg for each of aflatoxin B1, B2, G1 and G2.     

OCCURRENCE OF AFLATOXINS IN VARIOUS NUTS COMMERCIALIZED IN TURKEY

Nuts are important agricultural commodities in Turkey as they are exported and largely consumed domestically. Two hundred and seventeen samples of hazelnuts, pistachio nuts and peanuts were randomly collected from public markets, bazaars, supermarkets and retail stores in several regions of Turkey and analyzed for the incidence of aflatoxin (B1, B2, G1, G2) contamination by high-performance liquid chromatography. The levels of aflatoxin B1 (AFB1) and the total aflatoxins in the majority of samples analyzed (87.09%) were so low that they were not quantifiable. Thirty-one samples (14.28%) were found to have low levels of aflatoxins, below the Turkish National regulatory limits of 5 µg/kg for AFB1 and 10 µg/kg for total aflatoxins. However, four samples (1.84%) showed a level of contamination that exceeded the maximum tolerated levels set in the Turkish regulations. The highest value of AFB1 was 36.81 µg/kg in pistachio nuts. This article reports the data of the first survey on the presence of aflatoxins in nuts sampled in three distinct regions of Turkey.

PRACTICAL APPLICATIONS

The formation of aflatoxins depends not only on the genetic potential of mold strains but also on environmental factors, especially during post-harvest transportation and storage. Although further national surveys must be performed on a regular base, the results of the present study indicate a reduced level of aflatoxin contamination of nut-based products compared to earlier observations. The results conclude that implementation of stricter quality control measures, technical assistance to private sector actors and regulatory initiatives to support employment of these strategies undertaken in recent years by the National Authorities have paid back.     

The preparation, validation and certification of the aflatoxin content of two peanut butter reference materials.

The preparation of two peanut butter reference materials and the certification of their aflatoxins B1, B2, G1, G2 and total aflatoxin contents is described. The materials were prepared and certified within the BCR Programme of the Commission of the European Community as part of a broad activity to improve accuracy and agreement of measurements of importance in food and agriculture (Wagstaffe and Belliardo 1990). Reference material RM 385 was prepared from naturally contaminated peanuts, roasted and ground into a paste and then blended with uncontaminated peanut butter to achieve the desired aflatoxin concentrations. Details are given of the blending and canning procedure, and the checks to ensure homogeneity and stability of the material. Reference material RM 401 was similarly prepared but from an uncontaminated peanut butter. The certification exercise was carried out by nine laboratories using a variety of extraction and clean-up procedures, but all using high performance liquid chromatography (HPLC) as the determinative stage although operating under a variety of chromatographic conditions. RM 385 was certified as containing aflatoxins B1, B2, G1 and G2 at levels of 7.0 +/- 0.8 micrograms/kg, 1.1 +/- 0.2 micrograms/kg, 1.7 +/- 0.3 micrograms/kg and 0.3 +/- 0.2 micrograms/kg respectively (total aflatoxin content of 10.1 +/- 1.5 micrograms/kg) and RM 401 as containing aflatoxin B1, B2 and G2 at less than 0.2 micrograms/kg and aflatoxin G1 at less than 0.3 micrograms/kg (total aflatoxin content less than 0.9 micrograms/kg). The materials are intended for the verification of methods used to determine aflatoxins in nuts and nut products.     

Influence of harvesting and drying techniques on microflora and mycotoxin contamination of figs

Mould growth and mycotoxin (aflatoxins and ochratoxin A) formation were examined in the 1993 dried figs crop. The relationships between mould/mycotoxin contamination and orchard conditions, different harvesting techniques, harvesting time and intactness of fruits were investigated. The fruits were examined during drying and effects of different pretreatments, sun drying and solar drying on the mould and mycotoxin contamination in figs were also studied. Aflatoxins (B₁, B₂, G₁ and G₂) were not present in the firm or shrivelled ripe figs. Among the samples examined during drying, only one of the 32 samples was found to be aflatoxin positive. Ochratoxin A was not detected in any of the samples analysed. The moisture content, a_w and pH values of full ripe and shrivelled fruits were suitable for mould growth and mycotoxin formation while these parameters in pretreated and dried fruits were found to be too low to allow such outcome. It was observed that harvesting the fruit by hand-treating with different solutions and application of solar drying were effective in reducing contamination level.     

Aflatoxin determination in commonly consumed foods in Tunisia

BACKGROUND: To investigate natural aflatoxin occurrence, a total of 180 samples of different foods widely consumed in Tunisia were analysed by an in‐house‐validated high‐performance liquid chromatography method including affinity column clean‐up and post‐column bromination techniques. RESULTS: The method used appeared to be rapid, selective and reproducible, and its performances were established. Detection limits were 0.05 ng g^?1 for aflatoxin B1 and 0.025 ng g^?1 for aflatoxins B2, G1 and G2. Aflatoxins were detected in all investigated commodities except rice, with an overall contamination frequency of 34.4% and concentrations ranging from 0.1 to 40.6 ng g^?1. Aflatoxin B1 was found in all contaminated samples. Sorghum, spices and nuts were most contaminated. CONCLUSION: This study has provided an effective analytical method for the reliable determination of aflatoxins in food samples. Over one‐third of the samples investigated were contaminated with aflatoxins. Sorghum, spices and nuts were most contaminated, whereas rice showed no contamination. Copyright © 2010 Society of Chemical Industry     

Occurrence of aflatoxins B 1 , B 2 , G 1 and G 2 in some Brazilian pet foods

The presence of cereals and grains in the formulation of pet foods suggests the need to control aflatoxin contamination in these foods. The objective of the study was to analyse domestic pet food to determine the occurrence of aflatoxins as well as their risk to animal health. One hundred food samples (45 for dogs, 25 for cats, 30 for birds) were collected at random from pet shops in Alfenas city, south-east Brazil. Thin-layer chromatography was used for separation, identification and quantification of the compounds after validation of the method. Aflatoxins were detected in 12.0% of the samples. Levels of aflatoxins (B 1 + B 2 + G 1 + G 2 ) above the maximum limit established in Brazil (50 µg kg -1 ) for animal food were detected in five of the 12 positive samples (41.7%). The concentration of total aflatoxins was 15-374 µg kg -1 (mean 131 µg kg -1 ). All samples containing peanuts were positive for aflatoxin B 1 . Aflatoxins are carcinogenic and their consumption might be a risk for domestic animal health. The high prevalence of aflatoxin B 1 in foods prepared for birds, species highly susceptible to aflatoxins, shows the need for the re-evaluation of the use of peanuts (present in seven of the eight samples positives for aflatoxin) and/or the addition of fungicides to the food.     

Determination of aflatoxin B1 in dried figs by visual screening, thin-layer chromatography and ELISA

Aflatoxin B1-contaminated fruits were sorted out from 250 kg dried figs (five Turkish and three Greek batches) by bright-greenish-yellow fluorescence under UV light. The aflatoxins of the fluorescent figs were extracted by simple soaking in methanol. Aflatoxin B1 was determined by thin-layer chromatography. Parallel to this, an extraction for the determination of aflatoxin B1 was developed by a competitive ELISA and the two methods were compared with each other. In a highly contaminated batch of Turkish figs, statistically there was one fig among 350 which had a high aflatoxin content (greater than 100 ng/g fig) and one fig amongst 140 fruits with an aflatoxin B1 content of greater than 10 ng B1/g fig.