Relative efficacy of sodium hypochlorite wash versus irradiation to inactivate Escherichia coli O157:H7 internalized in leaves of Romaine lettuce and baby spinach

Pathogenic bacteria that become internalized in leaf tissues are protected from the antimicrobial effects of surface treatments. Ionizing radiation is known to penetrate food tissues, but the efficacy of the process against internalized bacteria is unknown. Leaves of Romaine lettuce and baby spinach were cut into pieces, submerged in a cocktail mixture of three isolates of Escherichia coli O157:H7, and subjected to a vacuum perfusion process to force the bacterial cells into the intercellular spaces in the leaves. Scanning electron microscopy was used to evaluate the efficacy of the perfusion process. The inoculated leaves were then treated with a 3-min water wash, a 3-min wash with a sodium hypochlorite sanitizing solution (300 or 600 ppm), or various doses of ionizing radiation (0.25 to 1.5 kGy). Leaves were stomached to recover the internalized pathogen cells, which were enumerated. The vacuum perfusion effectively forced bacteria into the leaf vasculature and apoplast, as confirmed by scanning electron microscopy. For spinach leaf pieces, neither the water nor the sodium hypochlorite washes resulted in significant reductions of E. coli O157:H7 cells relative to the untreated control. For Romaine lettuce leaf pieces, 300 and 600 ppm sodium hypochlorite each resulted in less than 1-log reduction; water wash was ineffective. Ionizing radiation, in contrast, significantly reduced the pathogen population, with 4-log (Romaine lettuce) or 3-log (spinach) reductions at the highest dose tested. In Romaine leaves, the reduction was dose dependent across the range of doses tested, with a D10-value (the amount of irradiation necessary to reduce the population by 1 log unit) of 0.39 kGy. In spinach leaves, the pathogen had a biphasic response, with a D10-value of 0.27 kGy in the range of 0 to 0.75 kGy but only slight additional reductions from 0.75 to 1.5 kGy. In this study, ionizing radiation but not chemical sanitizers effectively reduced viable E. coli O157:H7 cells internalized in leafy green vegetables, but the response of the pathogen to irradiation was more complex in spinach leaves than in Romaine lettuce leaves.     

Whole-Leaf Wash Improves Chlorine Efficacy for Microbial Reduction and Prevents Pathogen Cross-Contamination during Fresh-Cut Lettuce Processing

Abstract: Currently, most fresh-cut processing facilities in the United States use chlorinated water or other sanitizer solutions for microbial reduction after lettuce is cut. Freshly cut lettuce releases significant amounts of organic matter that negatively impacts the effectiveness of chlorine or other sanitizers for microbial reduction. The objective of this study is to evaluate whether a sanitizer wash before cutting improves microbial reduction efficacy compared to a traditional postcutting sanitizer wash. Romaine lettuce leaves were quantitatively inoculated with E. coli O157:H7 strains and washed in chlorinated water before or after cutting, and E. coli O157:H7 cells that survived the washing process were enumerated to determine the effectiveness of microbial reduction for the 2 cutting and washing sequences. Whole-leaf washing in chlorinated water improved pathogen reduction by approximately 1 log unit over traditional cut-leaf sanitization. Similar improvement in the reduction of background microflora was also observed. Inoculated “Lollo Rossa” red lettuce leaves were mixed with noninoculated Green-Leaf lettuce leaves to evaluate pathogen cross-contamination during processing. High level (96.7% subsamples, average MPN 0.6 log CFU/g) of cross-contamination of noninoculated green leaves by inoculated red leaves was observed when mixed lettuce leaves were cut prior to washing in chlorinated water. In contrast, cross-contamination of noninoculated green leaves was significantly reduced (3.3% of subsamples, average MPN ≤−0.3 log CFU/g) when the mixed leaves were washed in chlorinated water before cutting. This result suggests that whole-leaf sanitizing washes could be a practical strategy for enhancing the efficacy of chlorine washes for pathogen reduction and cross-contamination prevention. Practical Application: Freshly cut leafy greens release large amount of organic matter that negatively impact the chlorine washing efficacy. Implementing the primary antimicrobial intervention step of chlorine washing prior to cutting can significantly improve the efficacy of microbial reduction and minimize pathogen cross-contamination.     

Effect of storage temperature and duration on the behavior of Escherichia coli O157:H7 on packaged fresh-cut salad containing romaine and iceberg lettuce

This study investigated the impact of storage temperature and duration on the fate of Escherichia coli O157:H7 on commercially packaged lettuce salads, and on product quality. Fresh-cut Romaine and Iceberg lettuce salads of different commercial brands were obtained from both retail and wholesale stores. The packages were cut open at one end, the lettuce salad inoculated with E. coli O157:H7 via a fine mist spray, and resealed with or without an initial N(2) flush to match the original package atmospheric levels. The products were stored at 5 and 12 °C until their labeled "Best If Used By" dates, and the microbial counts and product quality were monitored periodically. The results indicate that storage at 5 °C allowed E. coli O157:H7 to survive, but limited its growth, whereas storage at 12 °C facilitated the proliferation of E. coli O157:H7. There was more than 2.0 log CFU/g increase in E. coli O157:H7 populations on lettuce when held at 12 °C for 3 d, followed by additional growth during the remainder of the storage period. Although there was eventually a significant decline in visual quality of lettuce held at 12 °C, the quality of this lettuce was still fully acceptable when E. coli O157:H7 growth reached a statistically significant level. Therefore, maintaining fresh-cut products at 5 °C or below is critical for reducing the food safety risks as E. coli O157:H7 grows at a rapid, temperature-dependent rate prior to significant quality deterioration. PRACTICAL APPLICATION: Specific information regarding the effect of temperature on pathogen growth on leafy greens is needed to develop science-based food safety guidelines and practices by the regulatory agencies and produce industry. Temperature control is commonly thought to promote quality of leafy greens, not safety, based at least partially on a theory that product quality deterioration precedes pathogen growth at elevated temperatures. This prevalent attitude results in temperature abuse incidents being frequently overlooked in the supply chain. This study demonstrates that human pathogens, such as E. coli O157:H7, can grow significantly on commercially packaged lettuce salads while the product's visual quality is fully acceptable. Packaged fresh-cut salads are marketed as "ready-to-eat" while lacking an effective pathogen kill step during their preparation. Thus, maintaining storage temperature at 5 °C or below is critical to prevent pathogen proliferation and mitigate food safety risks should pathogen contamination inadvertently occur during crop growth or postharvest fresh-cut processing.     

Acids in combination with sodium dodecyl sulfate caused quality deterioration of fresh-cut iceberg lettuce during storage in modified atmosphere package

Recent studies showed that sodium acid sulfate (SAS) and levulinic acid (LA) in combination with sodium dodecyl sulfate (SDS) was effective in inactivating human pathogens on Romaine lettuce. The present study investigated the effects of LA and SAS in combination with SDS (as compared with citric acid and chlorine) on the inactivation of E. coli O157:H7 and sensory quality of fresh-cut Iceberg lettuce in modified atmosphere packages during storage at 4 °C. Results showed that LA (0.5% to 3%) and SAS (0.25% to 0.75%) with 0.05% SDS caused detrimental effects on visual quality and texture of lettuce. LA- and SAS-treated samples were sensorially unacceptable due to development of sogginess and softening after 7 and 14 d storage. It appears that the combined treatments caused an increase in the respiration rate of fresh-cut lettuce as indicated by higher CO(2) and lower O(2) in modified atmosphere packages. On the positive side, the acid treatments inhibited cut edge browning of lettuce pieces developed during storage. LA (0.5%), SAS (0.25%), and citric acid (approximately 0.25%) in combination with SDS reduced population of E. coli OH157:H7 by 0.41, 0.87, and 0.58 log CFU/g, respectively, while chlorine achieved a reduction of 0.94 log CFU/g without damage to the lettuce. Therefore, compared to chlorine, LA and SAS in combination with SDS have limited commercial value for fresh-cut Iceberg lettuce due to quality deterioration during storage.     

Efficacy of sanitizers to inactivate Escherichia coli O157:H7 on fresh-cut carrot shreds under simulated process water conditions

Chlorine is widely used as a sanitizer to maintain the microbial quality and safety of fresh-cut produce; however, chlorine treatment lacks efficacy on pathogen reduction, especially when the fresh-cut processing water contains heavy organic loads. A more efficacious sanitizer that can tolerate the commercial processing conditions is needed to maintain microbial safety of fresh-cut produce. This study evaluated the efficacy of Escherichia coli O157:H7 reduction on fresh-cut carrots using new and traditional sanitizers with tap water and fresh-cut processing water scenarios. Fresh-cut carrot shreds inoculated with E. coli O157:H7 were washed in sanitizer solutions including 200 ppm chlorine, citric acid-based sanitizer (Pro-San), 80 ppm peroxyacetic acid-based sanitizer (Tsunami 100), and 1,000 ppm acidified sodium chlorite (SANOVA) prepared in fresh tap water or simulated processing water with a chemical oxygen demand level of approximately 3,500 mg/liter. Samples were packaged and stored at 5 degrees C. Microbial analyses performed at days 0, 7, and 14 indicate that the organic load in the process water significantly affected the efficacy of chlorine on pathogen removal and was especially evident on samples tested during storage. Acidified sodium chlorite provided a strong pathogen reduction even under process water conditions with up to a 5.25-log reduction when compared with the no-wash control. E. coli O157:H7 was not recovered on acidified sodium chlorite-treated samples during the entire 14 days of storage, even following an enrichment step. These results suggest that acidified sodium chlorite holds considerable promise as an alternative sanitizer of fresh-cut produce.     

Efficacy of adding detergents to sanitizer solutions for inactivation of Escherichia coli O157:H7 on Romaine lettuce

Numerous Escherichia coli O157:H7 outbreaks have been linked to consumption of fresh lettuce. The development of effective and easily implemented wash treatment could reduce such incidents. The purpose of this study was to evaluate the addition of food-grade detergents to sanitizer solutions for inactivation of E. coli O157:H7 on Romaine lettuce. Freshly-cut leaves of Romaine lettuce were dip-inoculated to achieve a final cell concentration of 7.8 ± 0.2 log CFU/g, air-dried for 2 h, and stored overnight at 4 °C. Leaves were then washed for 2 min in an experimental short chain fatty acid formulation (SCFA) or in one of the following solutions with or without 0.2% dodecylbenzenesulfonic acid or 0.2% sodium 2-ethyl hexyl sulfate: 1) deionized water; 2) 100 ppm chlorine dioxide; 3) 100 ppm chlorine; and 4) 200 ppm chlorine. Following wash treatment, samples were blended in neutralizing buffer (1:3) and surface plated on the selective media CT-SMAC. The efficacy of wash treatments, with or without the detergents, in inactivating E. coli O157:H7 cells on lettuce leaves were not significantly different. The most effective wash solution was SCFA, which was capable of reducing E. coli O157:H7 populations by more than 5 log CFU/g. The rest of the wash treatments resulted in a population reduction of less than 1 log CFU/g. The effectiveness of SCFA surpasses that of other sanitizer treatments tested in this study and requires further research to optimize treatments to preserve lettuce quality. Conventional detergents did not enhance the efficacy of any of the wash treatments tested during this study.     

绿芥末对即食鲜切生菜的保鲜效果

为明确绿芥末对即食鲜切生菜的保鲜效果,以清水和NaClO常规处理为对照组,考查了不同浓度的绿芥末液浸泡保鲜处理对即食鲜切生菜的失重率、腐烂率、褐变指数、感官评价、微生物菌落总数、沙门氏菌、单增李斯特菌、大肠埃希氏菌O157∶H7等指标的影响。结果表明,冷藏温度4℃,相对湿度85.6%~95%条件下,不同浓度的绿芥末均对即食鲜切生菜具有一定的保鲜效果。其中,以16 g/L的绿芥末对鲜切生菜的保鲜效果最好,保鲜期为7 d。该浓度下,生菜的感官品质最好,无腐烂、萎蔫、黄化,褐变指数最低(仅为1.67%),菌落总数为1.1×10⁵ CFU/g,且无沙门氏菌、单增李斯特菌和大肠埃希氏菌O157∶H7检出。该研究有望为今后生产上采用绿色保鲜剂替代化学保鲜剂,改善产品品质,延长产品货架期提供有益参考和借鉴。     

Irradiation compared with chlorination for elimination of Escherichia coli O157:H7 internalized in lettuce leaves: influence of lettuce variety

ABSTRACT:  Pathogenic bacteria internalized in leaf tissues are not effectively removed by surface treatments. Irradiation has been shown to inactivate leaf-internalized bacteria, but many aspects of targeting these protected pathogens remain unknown. Bacterial cells of a cocktail mixture of 3 isolates of Escherichia coli O157:H7 were drawn into the leaves of iceberg, Boston, green leaf, and red leaf lettuce using vacuum perfusion. The inoculated leaves were treated with a 3-min wash with sodium hypochlorite solution (0, 300, or 600 ppm) or various doses of ionizing radiation (0.25 to 1.5 kGy). Leaves were stomached to recover the internalized cells and survivors enumerated. Washes with 0 ppm (water), 300 ppm, and 600 ppm chlorine solutions each gave reductions of less than 1 log. These reductions were statistically significant only in the case of green leaf lettuce. In contrast, irradiation effectively reduced E. coli O157:H7 on all varieties examined, with all doses tested being significantly reduced from the untreated control. The specific variety influenced the efficacy of irradiation. The greatest reduction obtained was 5 logs on iceberg lettuce treated with 1.5 kGy. The D ₁₀ values (the dose necessary to achieve a 1 log reduction) were significantly ( P < 0.05) different among the varieties of lettuce tested, and ranged from 0.30 kGy (iceberg) to 0.45 kGy (Boston). These values were observed to be notably higher than previous irradiation D ₁₀ values for E. coli O157:H7 surface inoculated onto these 4 lettuce varieties. This study has shown that irradiation is able to effectively reduce viable E. coli O157:H7 cells internalized in lettuce, and that the variety of lettuce influences the specific response.     

Efficacy of neutral electrolyzed water (NEW) for reducing microbial contamination on minimally-processed vegetables

Consumption of minimally-processed, or fresh-cut, fruit and vegetables has rapidly increased in recent years, but there have also been several reported outbreaks associated with the consumption of these products. Sodium hypochlorite is currently the most widespread disinfectant used by fresh-cut industries. Neutral electrolyzed water (NEW) is a novel disinfection system that could represent an alternative to sodium hypochlorite. The aim of the study was to determine whether NEW could replace sodium hypochlorite in the fresh-cut produce industry. The effects of NEW, applied in different concentrations, at different treatment temperatures and for different times, in the reduction of the foodborne pathogens Salmonella, Listeria monocytogenes and Escherichia coli O157:H7 and against the spoilage bacterium Erwinia carotovora were tested in lettuce. Lettuce was artificially inoculated by dipping it in a suspension of the studied pathogens at 10(8), 10(7) or 10(5) cfu ml(-1), depending on the assay. The NEW treatment was always compared with washing with deionized water and with a standard hypochlorite treatment. The effect of inoculum size was also studied. Finally, the effect of NEW on the indigenous microbiota of different packaged fresh-cut products was also determined. The bactericidal activity of diluted NEW (containing approximately 50 ppm of free chlorine, pH 8.60) against E. coli O157:H7, Salmonella, L. innocua and E. carotovora on lettuce was similar to that of chlorinated water (120 ppm of free chlorine) with reductions of 1-2 log units. There were generally no significant differences when treating lettuce with NEW for 1 and 3 min. Neither inoculation dose (10(7) or 10(5) cfu ml(-1)) influenced the bacterial reduction achieved. Treating fresh-cut lettuce, carrot, endive, corn salad and 'Four seasons' salad with NEW 1:5 (containing about 50 ppm of free chlorine) was equally effective as applying chlorinated water at 120 ppm. Microbial reduction depended on the vegetable tested: NEW and sodium hypochlorite treatments were more effective on carrot and endive than on iceberg lettuce, 'Four seasons' salad and corn salad. The reductions of indigenous microbiota were smaller than those obtained with the artificially inoculated bacteria tested (0.5-1.2 log reduction). NEW seems to be a promising disinfection method as it would allow to reduce the amount of free chlorine used for the disinfection of fresh-cut produce by the food industry, as the same microbial reduction as sodium hypochlorite is obtained. This would constitute a safer, 'in situ', and easier to handle way of ensuring food safety.     

Switchgrass extractives to mitigate Escherichia coli O157:H7 and Salmonella enterica serovar Typhimurium contamination of romaine lettuce at pre- and postharvest

The antimicrobial potential of switchgrass extractives (SE) was evaluated on cut lettuce leaves and romaine lettuce in planta, using rifampicin-resistant Escherichia coli O157:H7 and Salmonella Typhimurium strain LT2 as model pathogens. Cut lettuce leaves were swabbed with E. coli O157:H7 or S. Typhimurium followed by surface treatment with 0.8% SE, 0.6% sodium hypochlorite, or water for 1 to 45 min. For in planta studies, SE was swabbed on demarcated leaf surfaces either prior to or after inoculation of greenhouse-grown lettuce with E. coli O157:H7 or S. Typhimurium; the leaf samples were collected after 0, 24, and 48 h of treatment. Bacteria from inoculated leaves were enumerated on tryptic soy agar plates (and also on MacConkey's and XLT4 agar plates), and the recovered counts were statistically analyzed. Cut lettuce leaves showed E. coli O157:H7 reduction between 3.25 and 6.17 log CFU/leaf, whereas S. Typhimurium reductions were between 2.94 log CFU/leaf and 5.47 log CFU/leaf depending on the SE treatment durations, from initial levels of ∼7 log CFU/leaf. SE treatment of lettuce in planta, before bacterial inoculation, reduced E. coli O157:H7 and S. Typhimurium populations by 1.88 and 2.49 log CFU after 24 h and 3 h, respectively. However, SE treatment after bacterial inoculation of lettuce plants decreased E. coli O157:H7 populations by 3.04 log CFU (after 0 h) with negligible reduction of S. Typhimurium populations. Our findings demonstrate the potential of SE as a plant-based method for decontaminating E. coli O157:H7 on lettuce during pre- and postharvest stages in hurdle approaches.     

Efficacy of gamma radiation and aqueous chlorine on Escherichia coli O157:H7 in hydroponically grown lettuce plants

Interaction of Escherichia coli O157:H7/pGFP with hydroponically grown lettuce plants was evaluated in this study. Lettuce seedlings were planted in contaminated Hoagland's nutrient solution and thereafter subjected to gamma radiation at 0.25, 0.5, and 0.75 kGy, and aqueous chlorine at 200 ppm. There was no trace of E. coli O157:H7/pGFP in lettuce leaves harvested from noncontaminated nutrient solution (control); however, for plants grown in contaminated nutrient solution, the pathogen was recovered from the leaves disinfected with 80% ethanol and 0.1% mercuric chloride. Most of the lettuce seedlings grown in contaminated nutrient solution tested negative for E. coli O157:H7/pGFP under controlled conditions. Gamma radiation at 0.25 and 0.5 kGy, and aqueous chlorine at 200 ppm failed to eliminate E. coli O157:H7/pGFP in lettuce tissue completely; however, the bacteria were not detected in 0.75-kGy treated plants. The presence of E. coli O157:H7/pGFP in lettuce leaves is an indication that the pathogen migrated from the contaminated hydroponic system through the roots to the internal locations of lettuce tissue. Due to inaccessibility and limited penetrating power, aqueous chlorine could not eliminate the bacteria localized in the internal tissue. Findings from this study suggest that gamma irradiation was more efficacious than was aqueous chlorine to control internal contamination in hydroponically grown lettuce. Gamma irradiation is a process that processors can use to inactivate E. coli O157:H7 and therefore, consumers benefit from a safer food product [corrected]     

Determination of free chlorine concentrations needed to prevent Escherichia coli O157:H7 cross-contamination during fresh-cut produce wash

This study was conducted to investigate the effect of free chlorine concentrations in wash water on Escherichia coli O157:H7 reduction, survival, and transference during washing of fresh-cut lettuce. The effectiveness of rewashing for inactivation of E. coli O157:H7 on newly cross-contaminated produce previously washed with solutions containing an insufficient amount of chlorine also was assessed. Results indicate that solutions containing a minimum of 0.5 mg/liter free chlorine were effective for inactivating E. coli O157:H7 in suspension to below the detection level. However, the presence of 1 mg/liter free chlorine in the wash solution before washing was insufficient to prevent E. coli O157:H7 survival and transfer during washing because the introduction of cut lettuce to the wash system quickly depleted the free chlorine. Although no E. coli O157:H7 was detected in the wash solution containing 5 mg/liter free chlorine before washing a mix of inoculated and uninoculated lettuce, low numbers of E. coli O157:H7 cells were detected on uninoculated lettuce in four of the seven experimental trials. When the prewash free chlorine concentration was increased to 10 mg/liter or greater, no E. coli O157:H7 transfer was detected. Furthermore, although rewashing newly cross-contaminated lettuce in 50 mg/liter free chlorine for 30 s significantly reduced (P = 0.002) the E. coli O157:H7 populations, it failed to eliminate E. coli O157:H7 on lettuce. This finding suggests that rewashing is not an effective way to correct for process failure, and maintaining a sufficient free chlorine concentration in the wash solution is critical for preventing pathogen cross-contamination.     

超声-次氯酸钠-植酸联合处理提高鲜切生菜的保鲜效果

本文从自来水、超声波、微酸性电解水、超声波结合微酸性电解水、超声波结合植酸、次氯酸钠结合植酸、超声-次氯酸钠-微酸性电解水联合处理和超声-次氯酸钠-植酸联合处理8种方法中选出对鲜切生菜清洗后抑菌效果最好的方法超声-次氯酸钠-植酸联合处理,测定该方法处理后的鲜切生菜在贮藏期间的品质指标,以无菌蒸馏水作为对照。探讨超声-次氯酸钠-植酸联合处理对鲜切生菜表面大肠杆菌O157:H7抑菌效果和贮藏品质的影响。结果表明,超声-次氯酸钠-植酸联合处理的抑菌效果最好,抑菌率达到99.97%。处理后的鲜切生菜在贮藏第14 d,质量损失率为3.45%,总色差为5.39,Vc含量为2.93 mg/100 g,叶绿素含量为0.56 mg/g,水分含量为90.54%,均优于对照组;与对照组相比,过氧化物酶和多酚氧化酶活性被有效抑制,总酚含量保持较高的水平。因此,超声-次氯酸钠-植酸联合处理有利于提高鲜切生菜表面大肠杆菌O157:H7的抑菌效果和改善鲜切生菜的贮藏品质。综上表明,超声-次氯酸钠-植酸联合处理可以有效提高鲜切生菜的保鲜效果,延长货架期。     

Escherichia coli O157:H7 Biofilm Formation on Romaine Lettuce and Spinach Leaf Surfaces Reduces Efficacy of Irradiation and Sodium Hypochlorite Washes

Abstract: Escherichia coli O157:H7 contamination of leafy green vegetables is an ongoing concern for consumers. Biofilm-associated pathogens are relatively resistant to chemical treatments, but little is known about their response to irradiation. Leaves of Romaine lettuce and baby spinach were dip inoculated with E. coli O157:H7 and stored at 4 °C for various times (0, 24, 48, 72 h) to allow biofilms to form. After each time, leaves were treated with either a 3-min wash with a sodium hypochlorite solution (0, 300, or 600 ppm) or increasing doses of irradiation (0, 0.25, 0.5, 0.75, or 1 kGy). Viable bacteria were recovered and enumerated. Chlorine washes were generally only moderately effective, and resulted in maximal reductions of 1.3 log CFU/g for baby spinach and 1.8 log CFU/g for Romaine. Increasing time in storage prior to chemical treatment had no effect on spinach, and had an inconsistent effect on 600 ppm applied to Romaine. Allowing time for formation of biofilm-like aggregations reduced the efficacy of irradiation. D₁₀ values (the dose required for a 1 log reduction) significantly increased with increasing storage time, up to 48 h postinoculation. From 0 h of storage, D₁₀ increased from 0.19 kGy to a maximum of 0.40 to 0.43 kGy for Romaine and 0.52 to 0.54 kGy for spinach. SEM showed developing biofilms on both types of leaves during storage. Bacterial colonization of the stomata was extensive on spinach, but not on Romaine. These results indicate that the protection of bacteria on the leaf surface by biofilm formation and stomatal colonization can reduce the antimicrobial efficacy of irradiation on leafy green vegetables. Practical Application: Before incorporating irradiation into the overall GMP/GHP chain, a packer or processor of leafy green vegetables must determine at what stage of processing and shipping the irradiation should take place. As a penetrating process, irradiation is best applied as a postpackaging intervention. Time in refrigerated storage between packaging and processing may alter the antimicrobial efficacy of irradiation. Irradiation on a commercial scale should include efforts to minimize the time delay between final packaging and irradiation of leafy vegetables.     

Efficacy of acidified sodium chlorite treatments in reducing Escherichia coli O157:H7 on Chinese cabbage

Efficacy of acidified sodium chlorite for reducing the population of Escherichia coli O157:H7 pathogens on Chinese cabbage leaves was evaluated. Washing leaves with distilled water could reduce the population of E. coli O157:H7 by approximately 1.0 log CFU/g, whereas treating with acidified chlorite solution could reduce the population by 3.0 log CFU/g without changing the leaf color. A similar level of reduction was achieved by washing with sodium chlorite solution containing various organic acids. However, acidified sodium chlorite in combination with a mild heat treatment reduced the population by approximately 4.0 log CFU/g without affecting the color, but it softened the leaves. Moreover, the efficacy of the washing treatment was similar at low (4 degrees C) and room (25 degrees C) temperatures, indicating that acidified sodium chloride solution could be useful as a sanitizer for surface washing of fresh produce.     

Inactivation of Escherichia coli O157:H7, Salmonella enterica serotype enteritidis,and Listeria monocytogenes on lettuce by hydrogen peroxide and lactic acid and by hydrogen peroxide with mild heat

Iceberg lettuce is a major component in vegetable salad and has been associated with many outbreaks of foodborne illnesses. In this study, several combinations of lactic acid and hydrogen peroxide were tested to obtain effective antibacterial activity without adverse effects on sensory characteristics. A five-strain mixture of Escherichia coli O157:H7, Salmonella enterica serotype Enteritidis, and Listeria monocytogenes was inoculated separately onto fresh-cut lettuce leaves, which were later treated with 1.5% lactic acid plus 1.5% hydrogen peroxide (H2O2) at 40 degrees C for 15 min, 1.5% lactic acid plus 2% H2O2 at 22 degrees C for 5 min, and 2% H2O2 at 50 degrees C for 60 or 90 s. Control lettuce leaves were treated with deionized water under the same conditions. A 4-log reduction was obtained for lettuce treated with the combinations of lactic acid and H2O2 for E. coli O157:H7 and Salmonella Enteritidis, and a 3-log reduction was obtained for L. monocytogenes. However, the sensory characteristics of lettuce were compromised by these treatments. The treatment of lettuce leaves with 2% H2O2 at 50 degrees C was effective not only in reducing pathogenic bacteria but also in maintaining good sensory quality for up to 15 days. A < or = 4-log reduction of E. coli O157:H7 and Salmonella Enteritidis was achieved with the 2% H2O2 treatment, whereas a 3-log reduction of L. monocytogenes was obtained. There was no significant difference (P > 0.05) between pathogen population reductions obtained with 2% H2O2 with 60- and 90-s exposure times. Hydrogen peroxide residue was undetectable (the minimum level of sensitivity was 2 ppm) on lettuce surfaces after the treated lettuce was rinsed with cold water and centrifuged with a salad spinner. Hence, the treatment of lettuce with 2% H2O2 at 50 degrees C for 60 s is effective in initially reducing substantial populations of foodborne pathogens and maintaining high product quality.     

A pilot plant scale evaluation of a new process aid for enhancing chlorine efficacy against pathogen survival and cross-contamination during produce wash

Developing food safety intervention technology that can be readily adopted by the industry often requires test conditions that match as closely as possible to those of commercial food processing operations; yet biosafety risks inherent in pathogen studies constrain most experiments to laboratory settings. In this study, we report the first semi-commercial pilot-scale evaluation of a new process aid, T128, for its impact on enhancing the antimicrobial efficacy of chlorinated wash water against pathogen survival and cross-contamination. A non-pathogenic, BSL-1, strain of Escherichia coli O157:H7 was inoculated onto freshly harvested baby spinach leaves and washed with large amounts of freshly cut un-inoculated iceberg lettuce shreds in wash water with free chlorine periodically replenished, in the presence or absence of T128. Changes in water quality and pathogen survival and cross-contamination were monitored at every 2min intervals for up to 36min for each treatment during the wash operation. Results indicated that the use of T128 did not significantly (P>0.05) influence the rate of wash water deterioration, nor the pathogen populations remaining on the inoculated spinach leaves. However, in the absence of T128 (control), survival of E. coli O157:H7 in wash water and cross-contamination of un-inoculated lettuce frequently occurred when free chlorine in solution dropped below 1mg/l during the wash process. In contrast, the use of T128 significantly reduced the occurrence of E. coli O157:H7 surviving in wash water and of cross-contamination to un-inoculated shredded iceberg lettuce under the same operational conditions, suggesting that the application of T128 in a chlorine-based fresh produce sanitization system could increase the safety margin of process control on fresh-cut operations.     

Effect of modified atmosphere packaging on the persistence and expression of virulence factors of Escherichia coli O157:H7 on shredded iceberg lettuce

Fresh-cut leafy greens contaminated with Escherichia coli O157:H7 have caused foodborne outbreaks. Packaging conditions, coupled with abusive storage temperatures of contaminated lettuce, were evaluated for their effect on the potential virulence of E. coli O157:H7. Shredded lettuce was inoculated with 5.58 and 3.98 log CFU E. coli O157:H7 per g and stored at 4 and 15°C, respectively, for up to 10 days. Lettuce was packaged under treatment A (modified atmosphere packaging conditions used for commercial fresh-cut produce, in gas-permeable film with N(2)), treatment B (near-ambient air atmospheric conditions in a gas-permeable film with microperforations), and treatment C (high-CO(2) and low-O(2) conditions in a gas-impermeable film). E. coli O157:H7 populations from each treatment were determined by enumeration of numbers on MacConkey agar containing nalidixic acid. RNA was extracted from packaged lettuce for analysis of expression of virulence factor genes stx(2), eae, ehxA, iha, and rfbE. E. coli O157:H7 populations on lettuce at 4°C under all treatments decreased, but most considerably so under treatment B over 10 days. At 15°C, E. coli O157:H7 populations increased by at least 2.76 log CFU/g under all treatments. At 15°C, expression of eae and iha was significantly greater under treatment B than it was under treatments A and C on day 3. Similarly, treatment B promoted significantly higher expression of stx(2), eae, ehxA, and rfbE genes on day 10, compared with treatments A and C at 15°C. Results indicate that storage under near-ambient air atmospheric conditions can promote higher expression levels of O157 virulence factors on lettuce, and could affect the severity of E. coli O157:H7 infections associated with leafy greens.     

Influence of punctures, cuts, and surface morphologies of golden delicious apples on penetration and growth of Escherichia coli O157:H7

The ability of Escherichia coli O157:H7 to penetrate and grow within punctures, fresh-cut surfaces, and calyces of Golden Delicious apples was investigated. A three-strain cocktail of E. coli O157:H7 resistant to ampicillin was used to inoculate fresh and 48-h-old punctures, fresh-cut surfaces, and open or closed calyces. A concentric cutting procedure was used to evaluate depth of penetration within punctures and prevent cross contamination during sampling. Within 2 h, E. coli O157:H7 penetrated vertically through the fresh punctures and 3.4 mm within the underlying parenchyma. After 48 h, E. coli O157: H7 cells penetrated up to 5.5 mm within the punctures and >2.6 mm horizontally away from fresh punctures. However, 48-h-old punctures did not permit penetration beyond their boundaries. Fresh-cut surfaces permitted up to 2.8 mm penetration after 24 h. Onset of growth of E. coli O157:H7 occurred 4 to 8 h postinoculation on fresh punctures and fresh-cut surfaces with populations increasing by 3 logs after 48 h. E. coli O157:H7 penetrated within calyces regardless of the extent of opening or method of inoculation. However, E. coli O157:H7 was never recovered from the inner core of apples. Computed tomography scan imaging revealed that closed calyces effectively prevented penetration of sodium iodide solutions within the calyx cavity. Lack of solution penetration may explain why sanitizing treatments are ineffective in inactivating microbial cells within the calyx. Understanding the role of morphological differences in permitting or restricting bacterial penetration may lead to development of more effective strategies to enhance the safety of fresh horticultural products.     

Efficiency of sodium hypochlorite, fumaric acid, and mild heat in killing native microflora and Escherichia coli O157:H7, Salmonella typhimurium DT104, and Staphylococcus aureus attached to fresh-cut lettuce

The effect of the disinfectant sodium hypochlorite (NaClO), with or without mild heat (50 degrees C) and fumaric acid, on native bacteria and the foodborne pathogens Staphylococcus aureus, Escherichia coli O157:H7, and Salmonella Typhimurium DT104 attached to iceberg lettuce leaves was examined. The retail lettuce examined consistently harbored 6 to 7 log CFU/g of native bacteria throughout the study period. Inner leaves supported 1 to 2 log CFU/g fewer bacteria than outer leaves. About 70% of the native bacterial flora was removed by washing five times with 0.85% NaCl. S. aureus, E. coli, and Salmonella allowed to attach to lettuce leaves for 5 min were more easily removed by washing than when allowed to attach for 1 h or 2 days, with more S. aureus being removed than E. coli or Salmonella Typhimurium. An increase of time for attachment of pathogens from 5 min to 2 days leads to decreased efficiency of the washing and sanitizing treatment. Treatment with fumaric acid (50 mM for 10 min at room temperature) was the most effective, although it caused browning of the lettuce, with up to a 2-log reduction observed. The combination of 200 ppm of sodium hypochlorite and mild heat treatment at 50 degrees C for 1 min reduced the pathogen populations by 94 to 98% (1.2- to 1.7-log reduction) without increasing browning.