Increasing the capacity for treatment of chemical plant wastewater by replacing existing suspended carrier media with Kaldnes Moving Bed media at a plant in Singapore.

The Kaldnes biomedia K1, which is used in the patented Kaldnes Moving Bed biofilm process, has been tested along with other types of biofilm carriers for biological pretreatment of a complex chemical industry wastewater. The main objective of the test was to find a biofilm carrier that could replace the existing suspended carrier media and at the same time increase the capacity of the existing roughing filter-activated sludge plant by 20% or more. At volumetric organic loads of 7.1 kg COD/m3/d the Kaldnes Moving Bed process achieved much higher removal rates and much lower effluent concentrations than roughing filters using other carriers. The Kaldnes roughing stage achieved more than 85% removal of organic carbon and more than 90% removal of BOD5 at the tested organic load, which was equivalent to a specific biofilm surface area load of 24 g COD/m2/d. Even for the combined roughing filter-activated sludge process, the Kaldnes carriers outperformed the other carriers, with 98% removal of organic carbon and 99.6% removal of BOD5. The Kaldnes train final effluent concentrations were only 22 mg FOC/L and 7 mg BOD5/L. Based on the successful pilot testing, the full-scale plant was upgraded with Kaldnes Moving Bed roughing filters. During normal operation the upgraded plant has easily met the discharge limits of 100 mg COD/L and 50 mg SS/L. For the month of September 2002, with organic loads between 100 and 115% of the design load for the second half of the month, average effluent concentrations were as low as 9 mg FOC/L, 51 mg COD/L and 12 mg SS/L.     

曝气生物滤池去除有机物及氨氮的影响因素分析

采用以陶粒为填料的曝气生物滤池(BAF)处理生活污水,研究气水比、水力负荷、进水COD和NH3-N负荷对BAF去除COD及NH3-N的影响,分析COD及NH3-N沿滤柱的变化规律。结果表明:当试验进水COD及NH3-N质量浓度分别为300~370mg/L和20~40mg/L时,最佳气水比为4∶1~5∶1,最佳水力负荷为1.0~2.0 m3/(m2.h)。当进水COD负荷为1.69~6.47 kg/(m3.d)时,COD去除率与进水COD负荷成正相关。BAF的硝化性能与进水NH3-N和COD负荷成负相关。     

Simple wastewater treatment (UASB reactor, shallow polishing ponds, coarse rock filter) allowing compliance with different reuse criteria.

UASB reactors followed by polishing ponds comprise simple and economic wastewater treatment systems, capable of reaching very high removal efficiencies of pathogenic organisms, leading to the potential use of the effluent for unrestricted irrigation. However, for other types of reuse (urban and industrial), ponds are limited in the sense of producing effluents with high suspended solids (algae) concentrations. The work investigates a system with coarse rock filters for polishing the pond effluent. The overall performance of the system is analyzed, together with the potential for different types of reuse. The excellent results obtained (mean effluent concentrations: BOD: 27 mg/L; SS: 26 mg/L; E. coli: 450 MPN/100 mL) indicate the possibility of unrestricted use of the effluent for agriculture and restricted urban and industrial uses, according to WHO and USEPA.     

水解酸化—好氧—Fenton氧化工艺处理制浆造纸废水工程实例

以某大型制浆造纸厂废水处理工程为例,介绍了水解酸化—好氧生物处理联合Fenton氧化深度处理工艺在造纸和制浆中段废水处理中的应用。厂内造纸废水量为0.77万～2.91万m3/d,COD为2 150～4 430mg/L,SS为1 316～2 414mg/L,经生化处理后,出水COD和SS平均分别为309mg/L和53mg/L;制浆废水量为0.84万～3.68万m3/d,COD为1 720～4 360mg/L,SS为1 184～1 994mg/L,生化处理出水COD和SS平均分别为370mg/L和56mg/L。两种废水的生化处理出水经Fenton氧化和絮凝沉淀处理后,出水COD为67～98mg/L,SS为21～29mg/L,可达《制浆造纸工业水污染物排放标准》(GB 3544—2008)排放要求。废水处理成本为2.01元/m3,具有良好的经济效益和环境效益。     

On-site treatment of a motorway service area wastewater using a package sequencing batch reactor (SBR).

A sequencing batch reactor (SBR) treating the effluent of a motorway service station in the south of England situated on a major tourist route was investigated. Wastewater from the kitchens, toilets and washrooms facilities was collected from the areas on each side of the motorway for treatment on-site. The SBR was designed for a population equivalent (p.e.) of 500, assuming an average flow of 100 m3/d, influent biochemical oxygen demand (BOD) of 300 mg/l, and influent suspended solids (SS) of 300 mg/l. Influent monitoring over 8 weeks revealed that the average flow was only 65 m3/d and the average influent BOD and SS were 480 mg/l and 473 mg/l respectively. This corresponded to a high sludge loading rate (F:M) of 0.42 d(-1) which accounted for poor performance. Therefore the cycle times were extended from 6 h to 7 h and effluent BOD improved from 79 to 27 mg/l.     

折流式曝气生物滤池设备的开发及应用研究

针对三峡库区小城镇生活污水处理特点,研发折流式曝气生物滤池(BBAF)设备,通过将多级串联组合式BAF集成在同心圆式反应器内,形成了良好的力学性能和水力条件.在设计参数下运行时,对SS、COD、NH3-N、TN和TP的平均去除率分别为76％、83％、97％、26％和45％.高气水比有利于COD和NH3-N的去除,但会削弱TN、SS的去除效能,BBAF适宜的气水比为9.当处理负荷在1.5～3.0 m3/h范围内变化时,SS、COD和NH3-N的平均去除率无明显波动,出水水质稳定,表明设备具有较强的抗冲击负荷能力,对小城镇污水量变化系数大的特点具有很好的适用性.     

Anaerobic reactor/high rate pond combined technology for sewage treatment in the Mediterranean area.

Two high-rate, anaerobic/aerobic units were used to treat the sewage of the Institut Agronomique st Vétérinaire Hassan II (Morocco) campus in a 1,100 m2-plant designed for 1,500 e.p. and receiving 63 m3 per day. The anaerobic pre-treatment consisted of a two-step up-flow anaerobic reactor (TSUAR) comprising two reactors and one external settler all in series. The aerobic line, or post-treatment, consisted of a high-rate algal pond (HRAP) and one maturation pond in series. The system totalized a hydraulic retention time (HRT) of 9 days. A gravel filter (GF) was constructed behind the TSUAR to trap low-density particles. The TSUAR removed 80% of COD and 90% of SS within 48 h. Solids retention time in the reactors averaged 32 d with a specific sludge production of 0.28 g SS g(-1) COD removed. Almost 93% of the sludge evacuated from the settler was stabilized. Specific biogas production from both reactors was 0.25m3 kg(-1) COD removed. Used in this configuration, the HRAP lost its BOD removal activity and increased its nutrients and pathogens removal capabilities (tertiary treatment). Results showed that 85% of total nitrogen and 48% of total phosphorus were removed by the HRAP. Land area requirement of this combination was less than 1 m2 per capita and filtered final effluent was of excellent quality (COD, 82 mg/l; TKN, 8.3 mg/l; total P, 2.7 mg/l, faecal coliforms, 2.4 10(3)/100 ml and zero helminths eggs).     

Vertical flow constructed wetlands for municipal wastewater and septage treatment in French rural area.

This paper presents the purification performance of 20 wastewater treatment plants with vertical reed bed filters (Macrophyltres), built between 1998 and 2003 by SAS Voisin, for communities of between 150 and 1400 PE. The first stage vertical reed bed (directly fed with raw wastewater by intermittent feeding) achieved high removal of SS, BOD and COD (mean respectively 96%, 98%, 92%). The second stage permitted compliance easily with effluent standards (SS < 15 mg/l, BOD < 15 mg/l, COD < 90 mg/l and mean TKN < 10 mg/l). Performance was not significantly influenced by variations of organic and hydraulic load, nor by seasonal variations. Rigorous operation and maintenance were required to obtain optimal performances. Another application of vertical reed beds is the treatment of septage (sludge from individual septic tanks). The results obtained on two sites operating for 2 and 3 years are presented. The first site achieved complete treatment of septage (solid and liquid fraction), the second permitted a pre-treatment for co-treatment of percolate with wastewater.     

Treatment of paper mill effluent using an anaerobic/aerobic hybrid side-stream membrane bioreactor

This paper presents the design and operational performance data of an anaerobic/aerobic hybrid side-stream Membrane Bioreactor (MBR) process for treating paper mill effluent operated over a 6 month period. The paper mill effluent stream was characterized by a chemical oxygen demand (COD) range of between 1,600 and 4,400 mg/L and an average BOD of 2,400 mg/L. Despite large fluctuations in COD feed concentration, stable process performance was achieved. The anaerobic Expanded Granular Sludge Bed (EGSB) pre-treatment step effectively lowered the organic loading by 65 to 85%, thus lowering the MBR COD feed concentration to consistently below 750 mg/L. The overall MBR COD removal was consistent at an average of 96%, regardless of the effluent COD or changes in the hydraulic retention time (HRT) and organic loading rate (OLR). Combining a high-rate anaerobic pre-treatment EGSB with a Modified Ludzack-Ettinger (MLE) MBR process configuration produced a high quality permeate. Preliminary NF and RO results indicated an overall COD removal of around 97 and 98%, respectively.     

生物过滤氧化反应器处理生活污水中试研究

以生活污水为处理对象 ,研究了生物过滤氧化反应器 (BIOFOR)在高滤速、高负荷、小的气水比情况下 ,用非常短的水力停留时间 (6 0～ 80min) ,取得了很好的出水水质的机理 ,主要水质指标 (COD、BOD、SS、氨氮 )可达到国家《污水综合排放标准》或《生活杂用水水质标准》。同时探讨了滤速及容积负荷对出水水质的影响 ,分析了主要污染物的去除规律。     

Feasibility of UASB/trickling filter systems without final clarifiers for the treatment of domestic wastewater in small communities in Brazil

The paper analyses the concept and performance of different configurations of compact UASB/TF systems, without the final clarification stage, in relation to the removal of organic matter. The experiments were carried out in two sets of UASB/TF systems operating without secondary clarifiers, as follows: (i) four shallow (2.50 m height) TFs, each one filled with a different packing material; and (ii) two deep (4.20 m height) TFs, one filled with polyethylene corrugated sheets and the other with mixed polyethylene and sponge sheets. For the conditions tested (different packing material in shallow and deep TF), the UASB/TF systems had consistently complied (90 to 100% of the results) with the Brazilian discharge standards regarding to BOD, COD, and TSS parameters. The average BOD, COD and TSS effluent concentrations stayed below 40 mg BOD L(-1), 100 mg COD L(-1) and 50 mg TSS L(-1), respectively. UASB/TF systems can constitute an attractive alternative for domestic wastewater treatment in small communities in developing countries, especially considering its operational simplicity and very low running costs.     

Design and operation of an eco-system for municipal wastewater treatment and utilization.

An eco-system consisting of integrated ponds and constructed wetland systems is employed in Dongying City, Shandong Province for the treatment and utilization of municipal wastewater with design capacity of 100,000 m(3)/d. The total capital cost of this system is 680 Yuan (RMB) or US dollars 82/m(3)/d, or about half that of the conventional system based on activated sludge process, and the O/M cost is 0.1 Yuan (RMB) or US dollars 0.012/m(3), only one fifth that of conventional treatment systems. The performance of the wastewater treatment and utilization eco-system is quite good with a final effluent COD, BOD, SS, NH3-N and TP of 45-65 mg/l, 7-32 mg/l, 12-35 mg/l, 2-13 mg/l and 0.2-1.8mg/l respectively and the annual average removals of COD, BOD, SS, NH3-N and TP are 69.1%, 78.3%, 76.4%, 62.1% and 52.9%o respectively, which is much better than that of conventional pond system or constructed wetland used separately and illustrates that the artificial and integrated eco-system is more effective and efficient than the simple natural eco-system.     

Behaviour of a full-scale expanded bed reactor with overlaid anaerobic and aerobic zones for domestic wastewater treatment.

This paper presents the behaviour of a full-scale expanded bed reactor (160 m3) with overlaid anaerobic and aerobic zones used for municipal wastewater treatment. The research was carried out in two experimental steps: anaerobic and anaerobic-aerobic conditions, and the experimental results presented in this paper refer to four months of reactor operation. In the anaerobic condition, after inoculation and 60 days of operation, the reactor treating 3.40 kg CODm(-3)d(-1) for thetaH of 2.69 h, reached mean removal efficiencies of 76% for BOD, 72% for COD, and 80% for TSS, when the effluent presented mean values of 225 mg.L(-1) of COD, 98 mg.L(-1) of BOD and 35 mg.L(-1) of TSS. Under these conditions, for nitrogen loading of 0.27 kgN.m(-3)d(-1), the reactor generated an effluent with mean N-org. of 8 mg.L(-1) and N-ammon. of 37 mg.L(-1), demonstrating high potential of ammonification. For the anaerobic-aerobic condition (118th day) the system was operated with thetaH of 5.38 h presented mean removal efficiencies of 84% for BOD, 79% for COD, 76% for TSS, and 30% for TKN. The reactor's operation time was less than two months, which was not long enough to reach nitrification. Regarding the obtained results, this research confirmed that this reactor is configured as a flexible and adequate alternative for the treatment of sewage, requiring relatively small area and only thetaH of 10 h that can be adjusted to the local circumstances.     

高浓度制药废水处理工艺的调试运行

某制药厂生产废水水质变化大,污染物浓度高,毒性大.采用气浮—兼氧-CASS工艺进行处理.实践表明,处理出水COD 450～650 mg/L,氨氮20～35 mg/L,BOD5≤100 mg/L,SS50～100mg/L,可达《污水综合排放标准》(GB 8978-1996)三级排放标准.     

Possibility of sewage and combined sewer overflow reuse with biological aerated filters.

The secondary effluent from municipal plants in Korea generally represents higher BOD with lower SS. Therefore, more soluble forms of organics and NH4-N need to be removed to improve its effluent for reuse. In this study reuse possibility of secondary effluent and CSO (combined sewer overflow) using BAF (biological aerated filter) was evaluated. The tertiary application with 1.2 h EBCT, SS, BOD and COD showed stable concentrations less than 1.3, 1.3 and 6.2 mg/L, respectively. Nitrogen could be nitrified even at 7 degrees suggesting BAF can be used for a water reuse method as well as an effective add-on facility in cold regions. However, BAF was not stable with CSO application at increased flow rates suggesting CSO must be equalised prior to application. Disinfection was necessary even during normal weather conditions.     

化学除磷-水解酸化-厌氧接触-接触氧化工艺处理榨菜废水

榨菜废水的高含盐量和高氮磷对微生物有较强的抑制作用,处理难度大.以处理规模400 m3/d的重庆某榨菜厂废水处理工程为例,其进水COD 3 000～4 000 mg/L,BOD5 1445 mg/L,盐度1.5％～2.5％(以NaCl计),氨氮80～120 mg/L,总磷25～30 mg/L.通过驯化耐盐微生物为主体菌种,采用化学除磷-水解酸化-厌氧接触-接触氧化工艺进行处理,出水COD、BOD5、氨氮、总磷以及盐度平均分别为70.5 mg/L、14.9 mg/L、9.4 mg/L、0.46 mg/L以及1.53％,可以达到《污水综合排放标准》(GB8978-1996)一级标准.     

Aerated rock filters for enhanced nitrogen and faecal coliform removal from facultative waste stabilization pond effluents.

Facultative waste stabilization ponds in the UK, loaded at 80 kg BOD/ha day, produce effluents which comply with the European Urban Waste Water Treatment Directive (i.e., < or = 25 mg filtered BOD/l and < or = 150 mg SS/l). However, the Environment Agency of England and Wales typically requires a higher effluent quality of < or = 40 mg/l unfiltered BOD and < or = 60 mg/l SS, both on a 95-percentile basis. An ammonium-nitrogen requirement might also be applied. Traditionally, maturation ponds and reedbeds have been used to upgrade facultative pond effluents, requiring large land areas. This paper describes and compares aerated and unaerated rock filter performance for BOD, SS, nitrogen and faecal coliform removals, and highlights the land-saving opportunities as maturation ponds and reedbeds become redundant.     

无动力处理方式在农村生活污水处理中的应用

论述了北方某镇采用无动力处理技术处理农村生活污水的方法,工艺流程为新型化粪池-人工湿地-氧化塘工艺。运行结果表明,工程出水中污染物日均浓度COD为35~55 mg/L、BOD5为10~20 mg/L、SS为5~18mg/L、氨氮为3~5 mg/L,均能达到《农田灌溉水质标准》(GB 5084-2005)中蔬菜a标准。处理后的出水用于周边农田灌溉,既治理了污染,又节约了资源,是绿色、低碳城镇建设的一个典范,非常适合北方乡镇新农村建设的生活污水处理和利用。     

Nitrogen dynamics in a constructed wetland system treating landfill leachate.

A pilot scale treatment system was established in 2002 at the Laflèche Landfill in Eastern Ontario, Canada. The system consists of a series of treatment steps: a stabilisation basin (10,000 m3), a woodland peat trickling filter (5,200 m2), a subsurface flow constructed wetland planted in Phragmites sp. (2,600 m2), a surface flow constructed wetland planted in Typha sp. (3,600 m2) and a polishing pond (3,600 m2). The system operates from May to December with leachate being recycled within the landfill during the winter months. Hydraulic loading was increased three-fold over four operating seasons with nitrogen and organic mass loading increasing six-fold. Excellent removal efficiencies were observed with 93% BOD5, 90% TKN and 97% NH4-N removed under the highest loading conditions. Almost complete denitrification was observed throughout the treatment system with NO3-N concentrations never exceeding 5mg L(-1). The peat filter reached treatment capacity at a hydraulic loading of 4cm d(-1) and organic loading rate of 42 kg BOD ha(-1) d(-1), which is consistent with design criteria for vertical flow wetland systems and intermittent sand filters, The first order plug flow kinetic model was effective at describing TKN and ammonium removal in the SSF and FWS wetlands when background concentrations were taken into account. Ammonium removal k-values were consistent with the literature at 52.6 and 57.7 yr(-1) for the SSF and FWS wetlands, respectively, while TKN k-values at 6.9 and 7.7 yr(-1) were almost an order of magnitude lower than literature values, suggesting that leachate TKN could contain refractory organics not found in domestic wastewater.     

Potential of organic filter materials for treating greywater to achieve irrigation quality: a review

The objectives of this literature review were to: (i) evaluate the impact of greywater generated in rural communities, with the emphasis on Jordanian conditions, on soil, plant and public health and assess the need for treatment of this greywater before it is used for irrigation, and (ii) assess the potential of different types of organic by-products as carrier material in different filter units for removal of pollutants from greywater. Greywater with high BOD5, COD, high concentrations of SS, fat, oil and grease and high levels of surfactants is commonly found in rural areas in Jordan. Oxygen depletion, odour emission, hydrophobic soil phenomena, plant toxicity, blockage of piping systems and microbiological health risks are common problems associated with greywater without previous treatment. Organic by-products such as wood chips, bark, peat, wheat straw and corncob may be used as carrier material in so-called mulch filters for treating wastewater and greywater from different sources. A down-flow-mode vertical filter is a common setup used in mulch filters. Wastewaters with a wide range of SS, cBOD5 and COD fed into different mulch filters have been studied. The different mulch materials achieved SS removal ranging between 51 and 91%, a BOD5 reduction range of 55-99.9%, and COD removal of 51-98%. Most types of mulches achieved a higher organic matter removal than that achieved by an ordinary septic tank. Bark, peat and wood chips filters removed organic matter better than sand and trickling filters, under similar conditions. Release of filter material and increase in COD in the effluent was reported using some mulch materials. In conclusion, some mulch materials such as bark, peat and woodchips seem to have a great potential for treatment of greywater in robust, low-tech systems. They can be expected to be resilient in dealing with variable low and high organic loads and shock loads.