Influence of fat replacers on chemical composition, proteolysis, texture profiles, meltability and sensory properties of low-fat Kashar cheese

Changes in chemical composition, proteolysis, lipolysis, texture, melting and sensory properties of low-fat Kashar cheese made with three different fat replacers (Simplesse D-100, Avicel Plus CM 2159 or beta-glucan) were investigated throughout ripening. The low-fat cheeses made with fat replacers were compared with full- and low-fat counterparts as controls. Reduction of fat caused increases in moisture and protein contents and decreases in moisture-in-non fat substance and yield values in low-fat cheeses. The use of fat replacers in the manufacture of low-fat Kashar cheese increased water binding capacity and improved overall quality of the cheeses. Use of fat replacer in low-fat cheese making has enhanced cheese proteolysis. All samples underwent lipolysis during ripening and low-fat cheeses with fat replacers had higher level of total free fatty acid than full- or low-fat control cheeses. Texture attributes and meltability significantly increased with addition of fat replacers. Sensory scores showed that the full-fat cheese was awarded best in all stages of ripening and low-fat variant of Kashar cheeses have inferior quality. However, fat replacers except beta-glucan improved the appearance, texture and flavour attributes of low-fat cheeses. When the fat replacers are compared, the low-fat cheese with Avicel Plus CM 2159 was highly acceptable and had sensory attributes closest to full-fat Kashar cheese.     

Volatile composition and proteolysis in traditionally produced mature Kashar cheese

Twelve samples of raw milk mature Kashar cheese at different stages of ripening were collected from retail outlets. The average pH, moisture, fat-in-dry matter, protein, salt-in-dry matter and titratable acidity contents of the samples were 5.33, 39.39%, 45.20%, 27.33%, 6.62% and 0.65% (as lactic acid), respectively. Indices of proteolysis varied from 10.72% to 23.75% and 7.09% to 12.26% for pH 4.6-soluble and 12% trichloroacetic acid-soluble nitrogen fractions, respectively, and total free amino acid concentrations ranged from 6.36 to 36.03 mg Leu g⁻¹ of cheese. The cheeses were analysed for volatile compounds by Solid Phase Microextraction and Gas Chromatography-Mass Spectrometry (GC-MS). A total of 113 compounds were detected and identified belonging to the following chemical groups: acids (eleven), esters (sixteen), ketones (sixteen), aldehydes (six), alcohols (twenty-seven), sulphur compounds (seven), terpenes (seven) and miscellaneous compounds (twenty-three). The potential effect of each compound on the flavour profile of Kashar cheese is discussed. Acids, esters, ketones and alcohols were found at considerable levels in the samples. Kashar cheeses obtained from different retail outlets displayed some differences in terms of chemical composition, proteolysis and patterns of aroma compounds; and may be attributed to their production technologies and age-related variations.     

Effects of blends of camel and calf chymosin on proteolysis,residual coagulant activity,microstructure, and sensory characteristics of Beyaz peynir

Beyaz peynir, a white brined cheese, was manufactured using different blends of camel chymosin (100, 75, 50, 25, and 0%) with calf chymosin and ripened for 90 d. The purpose of this study was to determine the best mixture of coagulant for Beyaz peynir, in terms of proteolysis, texture, and melting characteristics. The cheeses were evaluated in terms of chemical composition, levels of proteolysis, total free amino acids, texture, meltability, residual coagulant activity, microstructure, and sensory properties during 90 d of ripening. Differences in the gross chemical composition were statistically significant for all types of cheeses. Levels of proteolysis were highly dependent on the blends of the coagulants. Higher proteolysis was observed in cheeses that used a higher ratio of calf chymosin. Differences in urea-PAGE and peptide profiles of each cheese were observed as well. Meltability values proportionally increased with the higher increasing levels of calf chymosin in the blend formula. These coagulants had a slight effect on the microstructure of cheeses. The cheese made with camel chymosin had a harder texture than calf chymosin cheese, and hardness values of all cheese samples decreased during ripening. The cheeses with a high ratio of calf chymosin had higher residual enzyme activity than those made with camel chymosin. No significant difference in sensory properties was observed among the cheeses. In conclusion, cheeses made with a high level of calf chymosin had a higher level of proteolysis, residual coagulant activity, and meltability. The cheeses also had a softer texture than cheeses made with a high content of camel chymosin. Camel chymosin may be used as a coagulant alone if low or limited levels of proteolysis are desired in cheese.     

Effect of pasture versus indoor feeding regimes on the yield,composition, ripening and sensory characteristics of Maasdam cheese

Maasdam cheese was manufactured from standardized milk derived from each of three feeding systems: grass (GRA), grass and clover pasture (CLO), and indoor feeding of total mixed ration (TMR). Pasture‐derived cheeses had significantly lower L* (whiteness) and higher b* values (yellowness) compared to TMR‐derived cheeses. Acetate levels were significantly lower in CLO and butyrate levels significantly higher in TMR compared to the other cheeses. Grass‐fed cheese had significantly higher scores for smooth texture, ivory colour and shiny appearance compared to TMR. The influence of feed type was minimal on cheese yield, composition and on glycolysis, lipolysis and proteolysis during ripening.     

Use of dry milk protein concentrate in pizza cheese manufactured by culture or direct acidification

Milk protein concentrate (MPC) contains high concentrations of casein and calcium and low concentrations of lactose. Enrichment of cheese milk with MPC should, therefore, enhance yields and improve quality. The objectives of this study were: 1) to compare pizza cheese made by culture acidification using standardized whole milk (WM) plus skim milk (SM) versus WM plus MPC; and 2) compare cheese made using WM + MPC by culture acidification to that made by direct acidification. The experimental design is as follows: vat 1 = WM + SM + culture (commercial thermophilic lactic acid bacteria), vat 2 = WM + MPC + culture, and vat 3 = WM + MPC + direct acid (2% citric acid). Each cheese milk was standardized to a protein-to-fat ratio of approximately 1.4. The experiment was repeated three times. Yield and composition of cheeses were determined by standard methods, whereas the proteolysis was assessed by urea polyacrylamide gel electrophoresis (PAGE) and water-soluble N contents. Meltability of the cheeses was determined during 1 mo of storage, in addition to pizza making. The addition of MPC improved the yields from 10.34 +/- 0.57% in vat 1 cheese to 14.50 +/- 0.84% and 16.65 +/- 2.23%, respectively, in vats 2 and 3 and cheeses. The percentage of fat and protein recoveries showed insignificant differences between the treatments, but TS recoveries were in the order, vat 2 > vat 3 > vat 1. Most of the compositional parameters were significantly affected by the different treatments. Vat 2 cheese had the highest calcium and lowest lactose contencentrations. Vat 3 cheese had the best meltability. Vat 1 cheese initially had better meltability than vat 2 cheese; however, the difference became insignificant after 28 d of storage at 4 degrees C. Vat 3 cheese had the softest texture and produced large-sized blisters when baked on pizza. The lowest and highest levels of proteolysis were found in vats 2 and 3 cheeses, respectively. The study demonstrates the use of MPC in pizza cheese manufacture with improved yield both by culture acidification as well as direct acidification.     

Low-moisture part-skim mozzarella cheese made from blends of camel and bovine milk: Gross composition,proteolysis, functionality,microstructure, and rheological properties

Camel (CM) milk is used in variety of ways; however, it has inferior gelling properties compared with bovine milk (BM). In this study, we aimed to investigate the physicochemical, functional, microstructural, and rheological properties of low-moisture part-skim (LMPS) mozzarella cheese, made from BM, or BM mixed with 15% CM (CM15%) or 30% CM (CM30%), at various time points (up to 60 d) of storage at 4°C after manufacture. Low-moisture part-skim mozzarella cheeses using CM15% and CM30% had high moisture and total Ca contents, but lower soluble Ca content. Compared with BM cheese, CM15% and CM30% LMPS mozzarella cheese exhibited higher proteolysis rates during storage. Adding CM affected the color properties of LMPS mozzarella cheese manufactured from mixed milk. Scanning electron microscopy images showed that the microstructure of CM15% and CM30% cheeses had smooth surfaces, whereas the BM cheese microstructures were rough with granulated surfaces. Low-moisture part-skim mozzarella cheeses using CM15% and CM30% showed significantly lower hardness and chewiness, but higher stringiness than BM cheese. Compared with BM cheese, CM15% and CM30% cheeses showed lower tan δ levels during temperature surges, suggesting that the addition of CM increased the meltability of LMPS mozzarella cheese during temperature increases. Camel milk addition affected the physicochemical, microstructural, and rheological properties of LMPS mozzarella cheese.     

Effect of milk centrifugation and incorporation of high-heat-treated centrifugate on the composition,texture, and ripening characteristics of Maasdam cheese

This study investigated the effect of centrifugation (9,000 × g, 50°C, flow rate = 1,000 L/h), as well as the incorporation of high-heat-treated (HHT) centrifugate into cheese milk on the composition, texture, and ripening characteristics of Maasdam cheese. Neither centrifugation nor incorporation of HHT centrifugate into cheese milk had a pronounced effect on the compositional parameters of any experimental cheeses, except for moisture and moisture in nonfat substance (MNFS) levels. Incorporation of HHT centrifugate at a rate of 6 to 10% of the total milk weight into centrifuged milk increased the level of denatured whey protein in the cheese milk and also increased the level of MNFS in the resultant cheese compared with cheeses made from centrifuged milk and control cheeses; moreover, cheese made from centrifuged milk had ～3% higher moisture content on average than control cheeses. Centrifugation of cheese milk reduced the somatic cell count by ～95% relative to the somatic cell count in raw milk. Neither centrifugation nor incorporation of HHT centrifugate into cheese milk had a significant effect on age-related changes in pH, lactate content, and levels of primary and secondary proteolysis. However, the value for hardness was significantly lower for cheeses made from milk containing HHT centrifugate than for other experimental cheese types. Overall, centrifugation appeared to have little effect on composition, texture, and ripening characteristics of Maasdam cheese. However, care should be taken when incorporating HHT centrifugate into cheese milk, because such practices can influence the level of moisture, MNFS, and texture (particularly hardness) of resultant cheeses. Such differences may have the potential to influence subsequent eye development characteristic, although no definitive trends were observed in the present study and further research on this is recommended.     

Study of the chemical composition,proteolysis, volatile compounds,and textural properties of industrial and traditional Beaten (Bieno sirenje) ewe milk cheese

The objective of this study was to determine the gross composition, proteolysis, and volatile and texture profiles during ripening of industrial (IND) and traditional (TRD) Beaten (Bieno sirenje) cheeses made by using ewe milk. In the course of the analyses, statistical differences were determined in some physicochemical parameters, nitrogen fractions, and total free amino acid levels between TRD and IND types of cheese. Higher levels of proteolysis were observed in IND cheeses than in TRD cheeses during ripening. Levels of residual β- and α_s-caseins were 72.2 and 48.7%, respectively, in 180-d-old TRD cheeses. However, the residual levels were 52.8% for β-casein and 18% for α_s-casein in IND cheeses. Similar differences were noted for the reversed-phase HPLC peptide profiles of 2 types of cheeses. Also, higher concentrations of peptides were eluted in IND cheeses than in TRD cheeses during ripening. A total of 73 volatile compounds, including alcohols (16), esters (17), acids (14), terpenes (7), ketones (5), aldehydes (4), and miscellaneous (10) were identified. The IND cheeses contained higher levels of carboxylic acids, esters, alcohols, and terpenes than the TRD cheeses; however, the same levels of methyl ketones were determined in the 2 types of cheeses at the end of ripening. These may be due to some differences (e.g., pasteurization and scalding temperature, among other factors) in the manufacture of the 2 types of Beaten cheeses. The textural profile of Beaten cheeses showed that TRD production method resulted in firmer, less fracturable, and stiffer cheeses than the IND production method. In conclusion, the results suggest that the use of industrial production method (pasteurization of cheese milk and curd scalding at 70°C) in the manufacture of Beaten ewe milk cheese enriched the volatile profile of the cheese.     

Volatile compounds and proteolysis in traditional Beaten (Bieno sirenje) ewe's milk cheese

Beaten ewe's milk cheese is a traditional autochthonous type of cheese manufactured in Macedonia with a relatively high nutritional value and sensory characteristics. The objective of this study was to characterise the gross composition, proteolysis and volatile profiles of the cheese that is supplied from different retails. The ranges for gross composition were from 31.53% to 42.83% (w/w) for moisture, 41.99% to 50.98% (w/w) for fat‐in‐dry matter, 2.03% to 8.25% (w/w) for salt content and 20.74% to 33.35% (w/w) for protein. Proteolysis results showed various levels of soluble nitrogen ranged from 3.15 to 33.50 for water‐soluble nitrogen (WSN) and from 1.11% to 6.79% for nitrogen soluble in 12% trichloroacetic acid (TCA‐SN). The ranges for total free amino acids were from 1.65 to 8.06 mg Leu/g. Lower proteolysis was observed in the cheese samples due to high salt contents. In total, 65 volatile compounds were identified in Beaten cheese. As a conclusion, the variation of the peptide profile, electrophoresis and volatile contents of Beaten cheeses are due to the lack of standardised manufacture protocols.     

Ripening of cheese made from full concentrated milk retentate with and without peptidase addition

The aim of this study was to determine ripening of cheese made from full concentrated (FC) milk retentate with and without peptidase addition. No free amino acids (FAAs) were found in FC cheese at the end of ripening. However, added peptidase increased FAA formation. Protein and peptide profile analysis showed that FAA and small peptides increased during ripening and therefore some secondary proteolysis occurred. Added peptidase increased D‐lactic acid formation during ripening of cheeses. This kind of changes in lactose fermentation should be considered during developing the making cheese with different enzyme addition.     

Effect of protein-to-fat ratio of milk on the composition, manufacturing efficiency, and yield of cheddar cheese

Twenty-three Cheddar cheeses were prepared from milks with a protein content of 3.66% (wt/wt) and with different protein-to-fat ratio (PFR) in the range 0.70 to 1.15; the PFR of each milk differed by 0.02. For statistical analysis, the 23 cheeses were divided into 3 PFR groups: low (LPFR; 0.70 to 0.85), medium (MPFR; 0.88 to 1.00) and high (HPFR; 1.01 to 1.15), which were compared using ANOVA. The numbers of PFR values in the LPFR, MPFR, and HPFR groups were 9, 7, and 7, respectively. Data were also analyzed by linear regression analysis to establish potentially significant relationships among the PFR and response variables. Increasing PFR significantly increased the levels of cheese moisture, protein, Ca, and P, but significantly reduced the levels of moisture in nonfat substances, fat-in-DM, and salt-in-moisture. The percentage of milk fat recovered in the LPFR cheese was significantly lower than that in the MPFR or HPFR cheeses. In contrast, the recovery of water from milk to the LPFR cheese was significantly higher than that in the MPFR or HPFR cheeses. Increasing the PFR led to a significant decrease in the actual yield of cheese per 100 kg of milk but a significant increase occurred in the normalized yield of cheese per 100 kg of milk with reference values of fat plus protein (3.4 and 3.3%, wt/wt, respectively). The results demonstrate that alteration of the PFR of cheese milk in the range 0.70 to 1.15 has marked effects on cheese composition, component recoveries, and cheese yield.     

Composition, yield, and functionality of reduced-fat Oaxaca cheese: effects of using skim milk or a dry milk protein concentrate

The effect of adding either skim milk or a commercial dry milk protein concentrate (MPC) to whole milk on the composition, yield, and functional properties of Mexican Oaxaca cheese were investigated. Five batches of Oaxaca cheeses were produced. One batch (the control) was produced from whole milk containing 3.5% fat and 9% nonfat solids (SNF). Two batches were produced from milk standardized with skim milk to 2.7 and 1.8% fat, maintaining the SNF content at 9%. In the other 2 batches, an MPC (40% protein content) was used to standardize the milk to a SNF content of 10 and 11%, maintaining the milk fat content at 3.5%. The use of either skim milk or MPC caused a significant decrease in the fat percentage in cheese. The use of skim milk or MPC showed a nonsignificant tendency to lower total solids and fat recoveries in cheese. Actual, dry matter, and moisture-adjusted cheese yields significantly decreased with skim milk addition, but increased with MPC addition. However, normalized yields adjusted to milk fat and protein reference levels did not show significant differences between treatments. Considering skim milk-added and control cheeses, actual yield increased with cheese milk fat content at a rate of 1.34 kg/kg of fat (R = 0.88). In addition, cheese milk fat and SNF:fat ratio proved to be strong individual predictors of cheese moisture-adjusted yield (r² ≈ 0.90). Taking into account the results obtained from control and MPC-added cheeses, a 2.0-kg cheese yield increase rate per kg of milk MPC protein was observed (R = 0.89), with TS and SNF being the strongest predictors for moisture adjusted yield (r² ≈ 0.77). Reduced-fat Oaxaca cheese functionality differed from that of controls. In unmelted reduced-fat cheeses, hardness and springiness increased. In melted reduced-fat cheeses, meltability and free oil increased, but stretchability decreased. These changes were related to differences in cheese composition, mainly fat in dry matter and calcium in SNF.     

Nutritional and sensory characteristics of Minas fresh cheese made with goat milk,cow milk,or a mixture of both

This study aimed to assess and compare the nutritional, technological, and sensory characteristics of Minas fresh cheese made with goat milk, cow milk, or a mixture of the two stored in cold conditions for 21 d. The yield and centesimal composition of the cheeses were not affected by the type of milk used in their preparation. Reductions were observed in the moisture content, pH, proteolysis index, and instrumental hardness; moreover, increases were observed in the syneresis, acidity index, and depth of proteolysis index in all cheeses. The percentages of caprylic, capric, oleic, and linoleic fatty acids were higher in goat milk cheese and cheese made with a mixture of goat and cow milk compared with cow milk cheese, and a sensory evaluation revealed differences in color, flavor, and aroma between the cheeses. The preparation of Minas fresh cheese with a mixture of goat and cow milk can be a viable alternative for dairy products in the market that can be characterized as high-quality products that meet consumer demands.     

Volatile composition and sensory properties of industrially produced Idiazabal cheese

The volatile composition and sensory properties of industrially produced Idiazabal cheeses made from ewes’ raw milk (RM) or pasteurised milk (PM) and with addition of different starter cultures were compared. Cheeses were analysed at 90 and 180 d of ripening. Acids were the major volatile compounds in RM cheeses. Methyl ketones were the major volatile compounds in PM cheeses at 90 ripening days. However, the content of acids strongly increased with ripening whereas the content of ketones decreased in PM cheeses. The concentration of esters was higher in RM cheeses than in PM cheeses. No differences were found in the content of alcohols. Most aldehydes, hydrocarbons, terpenes and furans identified were minor volatile compounds in both RM and PM cheeses. In RM cheeses, characteristic sensory attributes for the aroma of Idiazabal cheese were present at 3 months, whereas in PM cheeses those desirable sensory attributes did not appear until 6 months of ripening.     

Low-fat mozzarella as influenced by microbial exopolysaccharides, preacidification, and whey protein concentrate

Low-fat Mozzarella cheeses containing 6% fat were made by preacidification of milk, preacidification combined with exopolysaccharide- (EPS-) producing starter, used independently or as a coculture with non-EPS starter, and preacidification combined with whey protein concentrate (WPC) and EPS. The impact of these treatments on moisture retention, changes in texture profile analysis, cheese melt, stretch, and on pizza bake performance were investigated over 45 d of storage at 4°C. Preacidified cheeses without EPS (control) had the lowest moisture content (53.75%). These cheeses were hardest and exhibited greatest springiness and chewiness. The meltability and stretchability of these cheeses increased most during the first 28 d of storage. The moisture content in cheeses increased to 55.08, 54.79, and 55.82% with EPS starter (containing 41.18 mg/g of EPS), coculturing (containing 28.61 mg/g of EPS), and WPC (containing 44.23 mg/g of EPS), respectively. Exopolysaccharide reduced hardness, springiness, and chewiness of low-fat cheeses made with preacidified milk in general and such cheeses exhibited an increase in cohesiveness and meltability. Although stretch distance was similar in all cheeses, those containing EPS were softer than the control. Cocultured cheeses exhibited the greatest meltability. Cheeses containing WPC were softest in general; however, hardness remained unchanged over 45 d. Cheeses made with WPC had the least increase in meltability over time. Incorporation of WPC did not reduce surface scorching or increase shred fusion of cheese shreds during pizza baking; however, there was an improvement in these properties between d 7 and 45. Coating of the cheese shreds with oil was necessary for adequate browning, melt, and flow characteristics in all cheese types.     

Chemical and fatty acid composition of Manchego type and Panela cheeses manufactured from either hair sheep milk or cow milk

This study compared the chemical composition and fatty acid (FA) profile of Manchego type cheese and Panela cheese made from hair sheep milk and compared these with both types of cheese manufactured with cow milk as a reference. In addition, this study aimed to determine differences in sensory characteristics between Manchego type cheeses manufactured with either hair sheep milk or cow milk. A total of 25 and 14 Manchego type cheeses from hair sheep milk and cow milk were manufactured, respectively. In addition, 30 and 15 Panela cheeses from hair sheep milk and cow milk were manufactured, respectively. The chemical composition and FA profile were determined in all cheeses. In addition, a sensory analysis was performed in Manchego type cheeses manufactured from either hair sheep milk or cow milk. Moisture content was lower in Manchego type cheeses (37.5 ± 1.26 and 37.5 ± 1.26 g/100 g in cheeses manufactured from hair sheep milk and cow milk, respectively) than in Panela cheeses (54.0 ± 1.26 and 56.1 ± 1.26 g/100 g in cheeses manufactured from hair sheep milk and cow milk, respectively). Ash, protein, and sodium contents were higher in Manchego type cheeses than in Panela cheeses. Manchego type cheese manufactured from hair sheep milk contained more C4:0, C6:0, C8:0, C10:0, C12:0, C14:0, C18:2 cis-9,cis-12, total saturated FA, total short-chain FA, total medium-chain FA, total polyunsaturated FA, and de novo FA than Manchego type cheeses from cow milk. Total content of short-chain FA was higher in hair sheep cheeses (24.4 ± 1.30 and 19.6 ± 1.30 g/100 g in Manchego type and Panela cheeses, respectively) than in cow cheeses (8.89 ± 1.30 and 8.26 ± 1.30 g/100 g in Manchego type and Panela cheeses, respectively). Manchego type cheeses from hair sheep milk obtained higher scores for odor (7.05), texture (6.82), flavor (7.16), and overall acceptance (7.16) compared with those made from cow milk (6.37, 6.12, 6.17, and 6.83, respectively). In conclusion, both Manchego type cheese and Panela cheese manufactured with hair sheep milk had a similar chemical composition and contained higher levels of short-chain FA, total polyunsaturated FA, and de novo FA than those manufactured with cow milk.     

Milk fat composition modifies the texture and appearance of Cantal-type cheeses but not their flavor

Although the effects of cow diet on cheese sensory properties have been well documented, the putative interactions between the biochemical and microbial milk components and their respective roles in the development of the sensory properties of cheeses have yet to be explored in depth. The aim of this study was to evaluate the specific contribution of milk fat composition to the formation of cheese sensory properties. Two creams with different fat compositions were obtained from cows fed either pasture or maize silage. Cheeses were manufactured from the same skim milk (identical chemical and microbial composition) with either the pasture- or maize silage-origin pasteurized cream added. The gross composition and microbial composition of milks did not vary with cream origin. In milks and cheeses, the fatty acid (FA) profiles were modified by the origin of the cream. The concentrations of C18:0 and unsaturated FA such as cis-9 C18:1, trans-11 C18:1, C18:3n-3, total conjugated linoleic acids, and mono- and polyunsaturated FA were higher in milks and cheeses with the pasture-origin cream than in those with the maize-origin cream. In contrast, the maize milks and cheeses had higher concentrations of short- and medium-chain saturated FA, C16:0, and C18:2n-6. The level of lipolysis was 11% in the cheese rind and only 0.30% in the cheese core. The rind of pasture cheeses had a higher concentration of free C18:0 and C18:3n-3 and a lower concentration of free C14:0 and free C16:0 than the rind of maize cheeses. The levels of major microbial groups were similar in pasture and maize cheeses at different stages of ripening. The pasture cheeses had a more elastic and creamier texture, a yellower color, and a thinner rind than the maize cheeses, but the odor and aroma of cheeses were not affected by the origin of the cream, despite a few modifications in the balance of volatile compounds from FA catabolism. Based on these results, we conclude that milk fat composition modulated by cow diet had a direct role in the texture of the cheese but no effect on flavor. The high degree of lipolysis in cheese rind, along with the higher concentration of long-chain unsaturated free FA in pasture cheeses may be responsible for antimicrobial activity, which could explain differences in the appearance of cheese rind.     

Queso Chihuahua: effects of seasonality of cheesemilk on rheology†

Fresh semihard raw milk (RM) and pasteurized milk (PM) cheeses made by Mennonite communities in Chihuahua, Mexico were sampled in early winter, mid‐spring and late summer and evaluated during storage to determine if rheological properties were affected by the season the cheese was produced. Seasonal effects were observed in the rheology of the RM cheeses, which underwent more extensive proteolysis than the PM cheeses. The rheological properties of the PM cheeses and the composition of all cheeses were consistent throughout the year. The texture of the RM cheese is affected by season, whereas the variability in texture and composition of PM cheese is minimal, allowing for the manufacture of a uniform product.     

不同体细胞原料乳对Mozzarella干酪特性的影响

以膜过滤(M)、低体细胞(LSCC)、高体细胞(HSCC)原料乳为原料加工Mozzarella 干酪,对其成分回收率及1 、15、30、45、60d 成熟期的蛋白降解、游离脂肪酸含量、油脂析出、融化性、质构及感官等特性进行分析。结果表明：体细胞数对成分回收率的影响不显著(P ＞ 0.05)。LSCC 组与HSCC 组干酪特性差异不显著,但是微滤处理对Mozzarella 干酪特性的影响显著。体细胞数＜ 600000cells/mL时该指标并不是影响Mozzarella干酪品质的重要因素。     

Zinc supplementation of dairy cows: Effects on chemical composition,nutritional quality and volatile profile of Giuncata cheese

The effects of dietary zinc supplementation on chemical composition, nutritional quality and volatile profile of Giuncata cheese were investigated. Dietary zinc addition did not influence milk yield and composition, but induced a marked reduction of somatic cell count. Both in milk and cheese the experimental samples were characterised by a lower concentration of saturated fatty acids and an increase in oleic, vaccenic and rumenic acids. The volatile profile of Giuncata cheese samples was also affected by dietary zinc intake, with an increase in concentration of butanoic acid, hexanoic acid and hexanal. The present results suggest a positive role of zinc in improving animal health and nutraceutical properties of milk and corresponding cheese. Such findings could contribute to the production of cheeses with interesting properties, although further evaluations should be performed to confirm the consumer acceptability of these changes.