Inhibition of melanosis formation in Pacific white shrimp by the extract of lead (Leucaena leucocephala) seed

Lead (Leucaena leucocephala) seed extract was prepared using distilled water as a medium. An extraction yield of 26.16 g/100 g of seed was obtained after extraction at room temperature for 12 h. Total phenolic and mimosine contents in the lead seed extract powder (LSEP) were 17.4 g GAE/100 g and 8.8 g/100 g, respectively. LSEP at different concentrations (0.05%, 0.1%, 0.25%, 0.5%, and 1%, w/v) showed inhibitory activity towards polyphenoloxidase (PPO) of Pacific white shrimp in a dose dependent manner. When the whole Pacific white shrimp were treated with 0.25% and 0.5% (w/v) LSEP, the shrimp treated with 0.5% LSEP had the lower melanosis score throughout the storage of 12 days and showed a higher score for colour and odour, as well as overall likeness, compared with the control (without treatment) and 1.25% sodium metabisulphite treated samples at day 12 (P < 0.05). Meat of shrimps treated with LSEP at both levels had the increase in mimosine content up to 8 days, suggesting the migration of mimosine into shrimp muscle during extended storage. Therefore, 0.5% LSEP can be used as a novel melanosis inhibitor for Pacific white shrimp.     

Kinetics of oil uptake during frying of potato slices:: Effect of pre-treatments

Oil uptake in fresh, blanched and, blanched and dried potato slices was studied during frying. Potato slices blanched in hot water (85 °C, 3.5 min) and potato slices blanched (85 °C, 3.5 min) and then dried until to a moisture content of ∼60 g/100 g (wet basis) were deep fried in sunflower oil at 120, 150 and 180 °C. A control treatment consisted of unblanched potato slices without the pre-drying treatment (fresh samples). It was studied applying two empirical kinetic models in order to fit the oil uptake during frying: (i) a first order model; (ii) a proposed model, with a linear time behavior for short times, while time independent for long times. Oil uptake was high even for short frying times at the different temperatures tested suggesting that oil wetting is an important mechanism of oil uptake during frying. For control slices, oil uptake increased approximately by 32% as the frying temperature decreased from 180 to 120 °C at moisture contents ?1 g water/g dry solid. No apparent effect of frying temperature in oil uptake was observed at moisture contents ?0.5 g water/g dry solid in fried slices previously blanched and dried. The two kinetic models studied fitted properly the values of oil uptake during frying, with similar correlation coefficient r².     

Oxidative stability of water/oil mixtures as influenced by the addition of free Cu or Cu–alginate gel beads

The formation of Cu–alginate complexes and the impact of free or bound copper on the oxidative stability of model water/oil mixtures containing edible sunflower or corn oil were examined. Equilibrium dialysis showed that copper binding capacity of alginate increased proportionally with copper concentration and the binding was rapid. The results indicated that 25 mM CuCl₂ was necessary in obtaining beads of spherical shape and adequate mechanical strength (0.45 N at 80% compression) to avoid rupture during mixing, whereas lower CuCl₂ concentrations resulted in weak gel beads (0.34 N) of irregular shape. When Cu–alginate beads were dispersed in the aqueous phase to give 0.5 mM copper, the peroxide value of water/corn oil mixtures was 3.7 mEq peroxide/kg oil after 7 days. Corn oil-containing mixtures with 0.5 mM free Cu²⁺ in the aqueous phase had a peroxide value ∼3 times higher (P < 0.001) after the same storage time. However, copper binding by alginate did not significantly reduce the peroxide values of the water/sunflower oil mixtures. Results indicated that the binding of pro-oxidant minerals, such as copper, in alginate beads can reduce the levels of oxidation in water/oil mixtures.     

Chemical,physico-chemical and functional properties of pomegranate (Punica granatum L.) bagasses powder co-product

The aim of this work was to determine the chemical, physico-chemical and functional properties of pomegranate juice extraction bagasses, which were obtained in two different ways: (i) direct extraction that involved arils and peel (WFB) and (ii) only from arils (AB). The proximate composition analysis showed higher protein, fat and ash content in AB samples (p < 0.05) than WFB. However total dietary fibre, insoluble dietary fibre and soluble dietary fibre content is higher in WFB samples (50.3, 30.4 and 19.9 g/100 g d.w. respectively) than AB samples (45.6, 29.0 and 16.6 g/100 g d.w.). AB showed a pH of 4.40 while WFB showed a pH of 4.5. AB and WFB exhibited a water holding capacity of 4.5 and 4.9 g water/g d.w. respectively while the oil holding capacity was 5.9 g oil/g d.w. for AB sample and 5.9 g oil/g d.w. for WFB. Pomegranate bagasses powder co-products may be considered a potential functional ingredient in food products.     

Rheological properties and stability of low-in-fat dressings prepared with high-pressure homogenized yeast

The aim of present study was to investigate the feasibility of application high-pressure homogenized (HPH) yeast aqueous dispersions with low nucleic acid content for the formulation of low-in-fat dressings. The HPH treatment (1500 bar, 3 passes) in alkaline medium improved the protein dispersibility (>50%). Emulsions were prepared using sunflower oil (12.0% or 25% w/w oil), xhantan/guar gums (0.5% w/w), modified starch (0–4.0% w/w), salt, sucrose, acidulants, EDTA, and antimicrobial agents. All emulsions (pH 3.97 ± 0.27; a_w = 0.97 ± 0.01), whatever the starch content, behaved clearly as pseudoplastic fluids in steady flow measurements. Moreover, as the frequency sweep measurements were made they also exhibited a weak gel behavior. Although the presence of starch produced an increase of mean particle size (D_3,2 values), the rheological parameters (consistency index, proportionality coefficient and coordination number) also increased, so that the starch contributes to reinforce the three-dimensional network formed by oil droplets, protein aggregates and other polysaccharides. Yeast dressings were stable to coalescence after 28 days of quiescent storage (7.0 ± 0.5 °C) and only the highest starch concentration at 25% w/w oil was sufficient to maintain the stability of network.     

Using hydrocolloids to decrease oil absorption in banana chips

The aim of this research was to investigate the influence of hydrocolloids (alginate, CMC and pectin) on the oil absorption in fried banana chips. The control banana chips (no hydrocolloid treatment) had oil content as high as 40 g/100 g sample, whereas the sample blanched in 0.5 g CaCl₂/100 ml water and following with immersion in 1 g alginate/100 ml water exhibited a small decrease of oil uptake (p ≤ 0.05) to 38 g/100 g sample. The others which treated with 0.5 g CaCl₂/100 ml and 1 g pectin/100 ml water, and with 0.25 g CaCl₂/100 ml water and 1 g CMC/100 ml water absorbed much less oil (p ≤ 0.05), approximately 23 g/100 g sample. Besides, pectin-treated chips had higher sensory scores in all attributed than CMC-treated sample. These resulted showed that pectin was the most effective hydrocolloid for low fat fried banana chip production. Scanning electron microscope photographs indicted that coating banana chips with pectin was effective in protecting the cellular structure of the banana tissue from damage during deep-fat frying.     

Effects of pan-frying in margarine and olive oil on the fatty acid composition of cod and salmon

Effects on the fatty acid composition of cod (Gadus morhua) and salmon fillets (Salmo salar) after pan-frying in margarine and olive oil were determined. The fatty acids of the margarine used were 55.5% saturated (SFA), 33.0% mono-unsaturated (MUFA) and 11.5% polyunsaturated (PUFA). The olive oil used contained 15.4% SFA, 76.1% MUFA and 8.5% PUFA. Using margarine or olive oil increased the SFA and MUFA percentages, respectively, in both species. For cod fillets (lean), pan-frying increased the fat content (0.55–4.15 g/100 g and 0.55–2.30 g/100 g before and after pan-frying, with margarine and olive oil, respectively), whereas, for salmon fillets (fat), it decreased (13.91 to 10.57 g/100 g and 15.35 to 12.95 g/100 g before and after pan-frying with margarine and olive oil, respectively). In conclusion, the culinary fat selection affects the total fatty acid content and composition of the prepared fish fillet.     

Identification and quantification of phenolic compounds from sunflower (Helianthus annuus L.) kernels and shells by HPLC-DAD/ESI-MS

Phenolic compounds were extracted from defatted sunflower (Helianthus annuus L.) kernels and shells and characterised by HPLC with diode array and electrospray ionisation (ESI) mass spectrometric detection in the negative mode. Quantification of individual compounds was carried out by external calibration. Among the eleven compounds analysed 5-O-caffeoylquinic acid was predominant amounting up to 59.1 mg/100 g in the shells and 3050.5 mg/100 g in the kernels. The specific fragmentation patterns of mono- and dihydroxycinnamoylquinic acids allowed the unambiguous distinction of several stereoisomers which have not been described for sunflower seeds and seed shells so far. The total phenolic content of about 4200 mg/100 g on a dry matter basis revealed defatted sunflower meal to be a promising source of phenolic compounds that might be recovered and used as natural antioxidants. Furthermore, the press residues originating from sunflower oil extraction were shown to be still rich in phenolic antioxidants, thus, providing the opportunity to valorize these by-products in terms of sustainable agricultural production.     

Effects of pomegranate sauce on quality of marinated anchovy during refrigerated storage

Effects of pomegranate sauce on the quality of marinated anchovy during storage at 4 °C were investigated. Anchovy were marinated with 30 g/L acetic acid and 150 g/L salt, put into glass jars, filled with either sunflower oil or pomegranate sauce and stored at 4 °C. Total volatile basic nitrogen (TVB-N) and trimethylamine (TMA-N) values increased during the storage. Higher values for free fatty acid (FFA), conjugated diens (k-dien) and para-anisidine (p-Av) were found in samples with sunflower oil than those with pomegranate sauce. Samples in pomegranate sauce showed better oxidative stability. Higher taste and flavour and lower appearance scores were found for samples in pomegranate sauce than those samples in sunflower oil. It was found that pomegranate sauce was as least effective as the traditional sunflower oil to keep quality. Pomegranate sauce also produced desirable taste and flavour but the coloration should be studied in further studies.     

Effects of egg yolk powder addition to the flour dough on the lipid oxidation development during frying

Effects of egg yolk powder added to the dough on the oxidation of frying oil and lipid of fried products were studied. Flour dough containing egg yolk at 0, 3.53, 6.73, and 9.66/100 g was fried in 180 °C sunflower oil for 1.5 min, and 55 fryings were performed. Lipid damage was determined by free fatty acids (FFA), conjugated dienoic acids (CDA), and polar compounds contents, and p-anisidine values (PAV). Phospholipid (PL) classes were determined by high performance liquid chromatography. PL was not detected in frying oil and fried products without egg yolk, while the first batch of fried products added with egg yolk at 3.53, 6.73, and 9.66 in 100 g of the dough contained total PL at 3.73, 7.93, and 8.98 mg/g, respectively. Contents of PL classes tended to increase in the products fried in the oil performing more fryings. As the number of fryings of oil increased, FFA, CDA, and polar compounds contents and PAV of frying oil increased. Addition of egg yolk to the dough significantly decreased CDA and polar compounds contents and PAV of frying oil, but it increased FFA values. Lipid of fried products showed the same tendency in CDA contents and PAV. The results clearly indicate that egg yolk powder improved the oxidative stability of frying oil during frying, possibly due to PL.     

Cheese manufacture with milk with elevated conjugated linoleic acid levels caused by dietary manipulation

The objective of this study was to assess the effect of dietary supplementation of cows on pasture with sunflower oil for conjugated linoleic acid (cis-9, trans-11 CLA) enrichment of milk, for the production of CLA-enriched cheese. A group of 40 autumn-calving dairy cows were assigned to either a control group (indoor feeding on grass silage ad libitum and 6 kg/d of a typical indoor concentrate) or an experimental group (on pasture, being fed 6 kg of a supplement containing 100 g/kg of sunflower oil per d). These diets were fed for 16 d, during which time milk was collected for pilot-scale hard cheese manufacture. The pasture-based diet with sunflower oil resulted in a significant effect on the milk fatty acid CLA content. The concentration of cis-9, trans-11 CLA in the milk produced from cows on this diet increased to 2.22 g/100 g of fatty acid methyl esters (FAME) after 14 d, compared with 0.46 g/100 g of FAME in milk produced on the control indoor diet. The content of cis-9, trans-11 CLA in the cheese manufactured from the indoor control milk was 0.78 g/100 g of FAME and that from the pasture-based sunflower oil milk was 1.93 g/100 g of FAME. The cheese was assessed during the ripening period and CLA concentrations were stable throughout the 6 mo of ripening. Other cheese variables (microbiology, composition, flavor, free AA) were monitored during the ripening period, and the cheese with the elevated CLA concentrations compared favorably with the control cheese. Thus, a pasture-based diet supplemented with an oil source rich in linoleic acid resulted in an enhanced CLA content of bovine milk fat, compared with an indoor grass silage-based diet.     

Trout‐Skin Gelatin‐Based Edible Films Containing Phenolic Antioxidants: Effect on Physical Properties and Oxidative Stability of Cod‐Liver Oil Model Food

Abstract: Trout‐skin (Oncorhynchus mykiss) gelatin‐based films containing antioxidants (epigallocatechin gallate (EGCG), 50 and 250 ppm w/w) and green tea powder (1% and 20% w/w of gelatin) were tested for tensile strength, elastic modulus, and elongation, and oxygen and water vapor transmission rates, in vitro antioxidant activity using the DPPH (2,2‐diphenyl‐1‐picrylhydrazyl) assay and effect on stabilizing cod‐liver oil held under mild thermal abuse conditions. Cod‐liver oil overlaid with films was stored at 40 °C for 20 d and analyzed for peroxide value (PV) and thiobarbituric acid reactive substances (TBARS). Antioxidant activity was retained in films containing green tea powder, but was reduced (P < 0.05) in EGCG films (20 d, 23 °C). Water vapor transmission rate of the films incorporated with antioxidants did not change significantly (P > 0.05), but the oxygen transmission rate for films with 50 ppm EGCG and 20% green tea powder was significant (P < 0.05). Other physical properties varied with antioxidant incorporation. The TBARS and PV of control oil increased from 0.05 ± 0.01 to 4.71 ± 0.30 g MDA/kg oil and from 3.6 ± 0.2 to 178.3 ± 24.5 millieq peroxides/kg oil, respectively, after 20 d. For cod‐liver oil covered with control or antioxidant‐containing films, TBARS remained below 0.37 g MDA/kg oil and PV below 7 millieq peroxides/kg oil. Incorporation of antioxidants to the films did not reduce oil oxidation (P > 0.05) at the levels tested and this was confirmed by activation energy calculations. The rate of oil oxidation was more dependent upon the inherent oxygen barrier property of the films than the presence of antioxidants. Practical Application: This research has the potential to enhance the utilization of fish skins, a valuable food processing by‐product, as edible films with natural antioxidants to extend the shelf life of foods. The film physical properties and barrier to oxygen and water are investigated.     

Star-anise (Illicium verum) and black caraway (Carum nigrum) as natural antioxidants

The various solvent fractions of star-anise (Illicium verum) and black caraway (Carum nigrum), along with their spice powders and volatile oils, were prepared and evaluated for antioxygenic activity, using different methods. Star-anise powder and its ethanol/water (80:20)-soluble fraction showed strong antioxygenic activity in refined sunflower oil while the petroleum ether fraction exhibited marginal antioxygenic activity and the water-soluble fraction was practically devoid of any activity in sunflower oil. The black caraway powder showed marginal antioxygenic activity while its ethanol/water fraction (80:20) showed strong antioxygenic activity and all other fractions showed slight pro-oxygenic activity in refined sunflower oil. Both the spice powders and their extracts were also evaluated for antioxidant activity by linoleic acid peroxidaton, β-carotene-linoleate and 1, 1-diphenyl-2-picryl hydrazyl (DPPH) methods. Both the star-anise and black caraway powders, as well as their ethanol/water extracts, exhibited strong antioxygenic activity. Volatile oils from both the spices exhibited antioxygenic activity and the activity did not seem to be concentration-dependent. Volatile oils from star-anise showed relatively higher antioxygenic activity than did those from black caraway. Gas chromatography–mass spectroscopy (GC–MS) studies on star-anise and black caraway volatile oils resulted in the identification of 25 and 22 compounds, respectively, representing 94–97% of the total content.     

Effects of different levels of trans fatty acids and oxidised lipids in diet on cholesterol and cholesterol oxidation products formation in rabbit

The objective was to assess the effects of trans fatty acids and oxidised lipids, present in dietary fat by-products used in feeds, on cholesterol and oxycholesterols in meat, liver and plasma of rabbits. A palm fatty acid distillate, before and after hydrogenation (trans fatty acid trial), and a sunflower–olive oil blend (70/30, v/v), before and after use in a commercial frying process (oxidised lipid trial), were used in experimental feeds (at 3%, w/w). High trans fatty acid and oxidised lipid diets caused significantly higher cholesterol and oxycholesterol levels in all tissues of rabbit (0.01 < p ? 0.05). The content of oxycholesterols in rabbit meat, liver and plasma obtained from trans fatty acid experiments varied from 9 to 34 μg/100 g, 24 to 61 μg/100 g and 60 to 138 μg/dl, respectively, from low to high levels. In the oxidised lipid experiments, content of oxycholesterols varied from 16 to 52 μg/100 g, 14 to 108 μg/100 g and 52 to 269 μg/dl in meat, liver and plasma, respectively. As a consequence, meat products from rabbits fed a diet containing higher levels of trans fatty acids or oxidised lipids may result in higher intakes of cholesterol and oxycholesterols by humans.     

Optimisation of aqueous extraction of gum from durian (Durio zibethinus) seed: A potential, low cost source of hydrocolloid

The main goal of the present study was to investigate the effect of aqueous extraction conditions on the extraction yield and physicochemical properties of the durian seed gum. The studied aqueous extraction variables were water/seed (W/S) ratio (20:1-60:1, w/w), temperature (25.0-85.0 °C), and pH (4.0-10.0). The results indicated that the aqueous extraction variables exhibited the least significant (p < 0.05) effect on oil-holding capacity (OHC). Conversely, they had the most significant (p < 0.05) effect on the span and extraction yield. The current study revealed that the interaction effect of aqueous extraction variables showed the least significant (p < 0.05) effect on the solubility and OHC of durian seed gum. The optimum extraction condition led to the production of durian seed gum with a relatively high extraction yield (56.4%), solubility (27.9%), volume-weighted mean (98.7 μm), span (3.8), water-holding capacity (WHC) (270.6 g water/100 g gum), and OHC (146.5 g oil/100 g gum).     

Physicochemical characterisation and oxidative stability of fish oil and fish oil–extra virgin olive oil microencapsulated by sugar beet pectin

Spray-dried microcapsules were prepared at 25% and 50% w/w oil load from sugar beet pectin-stabilised emulsions (pH 3) containing fish oil, and a blend of fish oil and with extra virgin olive oil (1:1 w/w). Microencapsulation efficiencies were high (≥90%). However, deterioration in microcapsule wall integrity and an increase in oil droplet size were observed during storage (25 °C, 0–3 months). Lipid oxidation increased with both increased oil load (P < 0.05) and storage duration (P < 0.05), but was independent of oil composition (P > 0.05). These results suggest that sugar beet pectin functions poorly as a wall material and its residual metal ions exacerbate omega-3 oxidation, despite the presence of endogenous antioxidants found in extra virgin olive oil. Interestingly, under accelerated storage conditions (OxiPres® at 80 °C, 0.5 bar oxygen pressure), microcapsules containing the oil blend showed the best oxidative stability (P < 0.05), irrespective of oil load. A possible explanation for the superior oxidative stability of the microencapsulated oil blend at high storage temperature is discussed.     

Physico-chemical properties of whey protein isolate films containing oregano oil and their antimicrobial action against spoilage flora of fresh beef

Antimicrobial films were prepared by incorporating different levels of oregano oil (0.5%, 1.0%, and 1.5% w/w in the film forming solution) into sorbitol-plasticized whey protein isolate (WPI) films. The moisture uptake behavior and the water vapor permeability (WVP) were not affected by the addition of oregano oil at any of the concentrations used. A reduction of the glass transition temperature (∼10–20 °C), as determined by dynamic mechanical thermal analysis (DMTA), was caused by addition of oil into the protein matrix. A decrease of Young modulus (E) and maximum tensile strength (σ_max) accompanied with an increase in elongation at break (%EB) was observed with increasing oil concentration up to a level of 1.0% (w/w). Wrapping of beef cuts with the antimicrobial films resulted in smaller changes in total color difference (ΔΕ) and saturation difference (Δ_chroma) during refrigeration (5 °C, 12 days). The maximum specific growth rate (μ_max) of total flora (total viable count, TVC) and pseudomonads were significantly reduced (P < 0.05) by a factor of two with the use of antimicrobial films (1.5% w/w oil in the film forming solution), while the growth of lactic acid bacteria was completely inhibited. These results pointed to the effectiveness of oregano oil containing whey protein films to increase the shelf life of fresh beef.     

Oxidative stability of sunflower oil supplemented with carnosic acid compared with synthetic antioxidants during accelerated storage

In vitro antioxidant activities and protective effects in stabilising sunflower oil of three rosemary extracts high in carnosic acid (CA) were tested. The CA contents (w/w) of the extracts were 24.9% (CA25), 60.5% (CA60) and 98.3% (CA98). Total phenolic contents of CA25 and CA60 were (3.58 ± 0.026 g/100 g) and (8.20 ± 0.027 g/100 g), (3.91 ± 0.029 g/100 g) and (8.10 ± 0.056 g/100 g) expressed in gallic acid and catechin equivalents, respectively. Reducing power of CA and other antioxidants at 0.5 mg/ml followed the order of l-ascorbic acid > CA98 > TBHQ > BHA > CA60 > BHT > CA25. The IC₅₀ values in the DPPH assay obtained for CA25, CA60, CA98, BHA, BHT and TBHQ were 0.30 ± 0.002, 0.20 ± 0.003, 0.12 ± 0.002, 0.19 ± 0.002, 0.42 ± 0.010, and 0.09 ± 0.001 mg/ml, respectively.     

Cholesterol-lowering effect of phytosterol-containing lactic-fermented milk powder in hamsters

Male hamsters were fed six different diets for 4 weeks. Group 1, fed with control diet of regular rodent chow. Group 2, fed with high-fat-high-cholesterol diet containing cholesterol and corn/coconut oil mixture. Group 3, the positive control fed with high-fat-high-cholesterol diet containing 0.74% (w/w) phytosterols. Groups 4–6 were the high-fat-high-cholesterol diet mixed with phytosterol-containing lactic-fermented milk powder (PSFMP) which contains 0.37%, 0.74% and 1.85% (w/w) of phytosterols, respectively. Results demonstrated that PSFMP could significantly decrease (P < 0.05–P < 0.001) the levels of total cholesterol (serum cholesterol), serum triacylglycerol, liver lipids and atherogenic index (LDL-C/HDL-C), while it could also significantly (P < 0.001) increase the level of fecal cholesterol. The pronounced hypolipidemic effects of PSFMP might be attributed to its ability to enhance cholesterol excretion. These results suggest that PSFMP could be used as a potential cholesterol-lowering ingredient in the management of hypercholesterolemia.     

Production of conjugated linoleic acid by Propionibacterium freudenreichii

Two strains each of Propionibacterium freudenreichii ssp. shermanii and P. freudenreichii ssp. freudenreichii were tested for their ability to produce conjugated linoleic acid (CLA) in sodium lactate medium (SLM), De Man-Rogosa-Sharpe (MRS) medium and skim-milk. Data showed that both strains were able to produce CLA in three media supplemented with different concentrations of sunflower oil. Maximum production of CLA (78.8 μg/ml) was observed after 36 h of incubation in MRS containing 12 mg/ml of sunflower oil by P. freudenreichii ssp. shermanii. Moreover, the growths of both strains were inhibited by sunflower oil and a positive relationship between CLA production and ability to tolerate sunflower oil was observed. At the same time, it was also observed that the inhibitory effects on P. freudenreichii ssp. shermanii and P. freudenreichii ssp. freudenreichii in three media follow the order SLM > skim-milk > MRS and SLM > MRS > skim-milk, respectively. Micro aerobic conditions were in favour of increasing the amounts of CLA. The amounts of CLA increased from 0 to 36 h under micro aerobic conditions and no significant (p > 0.05) increases in total CLA levels were observed after 80 h of incubation. Results showed that P. freudenreichii may have potential for producing CLA.