Maximizing the hydrogen photoproduction yields in Chlamydomonas reinhardtii cultures: The effect of the H2 partial pressure

Photoproduction of H₂ gas has been examined in sulfur/phosphorus-deprived Chalmydomonas reinhardtii cultures, placed in photobioreactors (PhBRs) with different gas phase to liquid phase ratios (V_g.p./V_l.p.). The results demonstrate that an increase in the ratio stimulates H₂ photoproduction activity in both algal suspension cultures and in algae entrapped in thin alginate films. In suspension cultures, a 4× increase (from ∼0.5 to ∼2) in V_g.p./V_l.p results in a 2× increase (from 10.8 to 23.1 mmol l⁻¹ or 264–565 ml l⁻¹) in the total yield of H₂ gas. Remarkably, 565 ml of H₂ gas per liter of the suspension culture is the highest yield ever reported for a wild-type strain in a time period of less than 190 h. In immobilized algae, where diffusion of H₂ from the medium to the PhBR gas phase is not affected by mixing, the maximum rate and yield of H₂ photoproduction occur in PhBRs with V_g.p./V_l.p above 7 or in a PhBR with smaller headspace, if the H₂ is effectively removed from the medium by continuous flushing of the headspace with argon. These experiments in combination with studies of the direct inhibitory effect of high H₂ concentrations in the PhBR headspace on H₂ photoproduction activity in algal cultures clearly show that H₂ photoproduction in algae depends significantly on the partial pressure of H₂ (not O₂ as previously thought) in the PhBR gas phase.     

Pathways of hydrogen photoproduction by immobilized Chlamydomonas reinhardtii cells deprived of sulfur

The green algae Сhlamydomonas reinhardtii entrapped in a thin alginate film have been shown to sustain elevated rates of hydrogen photoproduction under anaerobic incubation in sulfur/phosphorus depleted tris-acetate medium. In the present work we studied mechanisms, underlying hydrogen photoproduction by the immobilized culture, particularly, the roles of PSII and starch accumulation/breakdown. DCMU, a specific inhibitor of electron transport in PSII, is known to suppress hydrogen evolution by circa 80% in suspension cultures of S-deprived C. reinhardtii. In immobilized cells DCMU caused successive stimulatory and inhibitory effects on hydrogen photoproduction, both depending on the deprivation status of the algal cell. The inhibitory effect of DCMU was 25% at 70 h of S deficiency when maximal rates of hydrogen photoproduction were observed. Measurements of the light-induced prompt and delayed chlorophyll fluorescence transients and reflectance at 820 nm (P₇₀₀ redox transitions) revealed very rapid decline of PSII activity in the entrapped S-deprived cells as compared with the suspension culture, whereas PSI suffered less. The immobilized culture showed a high capacity to accumulate starch during early stages of S deprivation and relatively high rates of anaerobic starch degradation during the following hydrogen evolution period. DCMU partly inhibited starch breakdown. Results of the present work brought us to the conclusion that PSII-independent pathway of hydrogen evolution is elevated in the immobilized S-deprived cells rather due to the rapid inactivation of PSII, efficient starch catabolism and non-photochemical PQ reduction.     

Inhibition of photosystem 2 in starch-enriched Chlamydomonas reinhardtii cells prevents the efficient induction of H2 production in sulfur-depleted cultures

In sulfur-deprived Chlamydomonas reinhardtii cells the activity of photosystem 2 (PSII) has been shown to have a crucial role in the photosynthetic production of H₂, since it allows the synthesis of internal reserves such as starch. In the present investigation, the PSII inhibitor 3-(3,4-dichlorophenyl)-1,1-dimethylurea (DCMU) was added in starch-enriched and sulfur-depleted C. reinhardtii cultures 1) at the very end of the aerobic phase, and 2) soon after the culture started to evolve H₂. In the former case, production of H₂ on a volumetric basis was completely down-regulated, although starch mobilization was enhanced. In vitro tests showed that the hydrogenase enzyme was active, although its efficiency of utilization in vivo was lowered very soon in the experiment. When an inhibitor of Rubisco such as glycolaldehyde was added under the same conditions, no substantial improvement in H₂ production rates was noted. These findings indicate that, aside starch storage, PSII plays an active role in the induction of the H₂ production process.     

Characterization of cell growth and photobiological H2 production of Chlamydomonas reinhardtii in ASSF industry wastewater

Photobiological H₂ production in microalgae is a promising approach for the development of alternative clean and renewable energy. As a unicellular green alga, Chlamydomonas reinhardtii is regarded as an ideal candidate for sustainable photo-H₂ production. However, growth and photo-H₂ producing are still expensive and energy extensive. Wastewater has been suggested as an economical resource for microalgae growth and biofuels production. In this study, we characterized the cell growth and photo-H₂ production of C. reinhardtii CC503 cultured in waste water from pressing process of fermented sweet sorghum stalks during Advanced Solid State Fermentation (ASSF). The maximal cells concentration reached 8.9 × 10⁶ cells/mL in ASSF wastewater medium (AWM) with the fastest growth rate of 0.19 × 10⁶ cells/h, compared to 18.2 × 10⁶ cells/mL and 0.36 × 10⁶ cells/h in TAP medium and to 1.3 × 10⁶ cells/mL and 0.02 × 10⁶ cells/h in BGII medium respectively. The optimized concentration of wastewater for algae cells growth was determined to be 13.3% (7.5 folds dilution), under which, surprisingly the photosynthetic H₂ evolution was increased by more than 700% compared to the cells grown in TAP medium. This system appears to be a good strategy for the development of an economical microalgal photobiological H₂ production scheme. Finally, the possible mechanism for such an H₂ enhancement was identified as the reduction of PSII activity in AWM grown cells.     

Relationships between PSII-independent hydrogen bioproduction and starch metabolism as evidenced from isolation of starch catabolism mutants in the green alga Chlamydomonas reinhardtii

Sulfur deprivation, which is considered as an efficient way to trigger long-term hydrogen photoproduction in unicellular green algae has two major effects: a decrease in PSII which allows anaerobiosis to be reached and carbohydrate (starch) storage. Starch metabolism has been proposed as one of the major factors of hydrogen production, particularly during the PSII-independent (or indirect) pathway. While starch biosynthesis has been characterized in the green alga Chlamydomonas reinhardtii, little remains known concerning starch degradation. In order to gain a better understanding of starch catabolism pathways and identify those steps likely to limit the starch-dependent hydrogen production, we have designed a genetic screening procedure aimed at isolating mutants of the green alga C. reinhardtii affected in starch mobilization. Using two different screening protocols, the first one based on aerobic starch degradation in the dark and the second one on anaerobic starch degradation in the light, eighteen mutants were isolated among a library of 15,000 insertion mutants, eight (std1-8) with the first screen and ten (sda1-10) with the second. Most of the mutant strains isolated in this study showed a reduction or a delay in the PSII-independent hydrogen production. Further characterization of these mutants should allow the identification of molecular determinants of starch-dependent hydrogen production and supply targets for future biotechnological improvements.     

Extended H2 photoproduction by N2-fixing cyanobacteria immobilized in thin alginate films

Screening of the University of Helsinki Culture Collection for naturally good H₂ producing cyanobacteria recently revealed several promising strains. One of the superior strains is Calothrix 336/3, an N₂-fixing heterocystous filamentous cyanobacterium. Making use of an important feature of the Calothrix 336/3 cells to adhere to the substrate, we applied an immobilization technique to improve H₂ production capacity of this strain. We examined the basic properties of immobilization in Ca²⁺-alginate films in response to the production of H₂ of the Calothrix 336/3 strain and as reference strains we used a model organism Anabaena PCC 7120 and its uptake hydrogenase mutant, ΔhupL, that allow us to compare the responses of different strains to alginate entrapment. Immobilization of the Calothrix 336/3 and ΔhupL mutant cells in Ca²⁺-alginate resulted in prolonged H₂ production over several cycles. Immobilization of the Calothrix 336/3 cells was most successful and production of H₂ could be measured even after 40 days after immobilization.     

Accumulation of O2-tolerant phenotypes in H2-producing strains of Chlamydomonas reinhardtii by sequential applications of chemical mutagenesis and selection

The photoproduction of hydrogen by anaerobically induced algae is catalyzed by a bidirectional hydrogenase that is rapidly inactivated by oxygen. We isolated two generations of Chlamydomonas reinhardtii strains with H₂-evolving activities of up to 10 times the O₂-tolerance seen in the wild-type (WT). These isolates were generated by two sequential selections, consisting of random chemical mutagenesis, enrichment for H₂-metabolism clones following exposure to increasing amounts of O₂, and screening using a chemochromic sensor. The selected strains were characterized by two types of assays and classified as those that (a) can evolve H₂ following exposure to O₂ concentrations that inactive the WT strain and (b) in addition, are able to quickly reactivate H₂-production activity once O₂ is removed. These results suggest that O₂-tolerance can be increased by successive rounds of mutagenesis, selection, and screening, demonstrating that the WT phenotype can be improved by genetic means. Other results show that the hydrogenase is less sensitive to O₂ when it is actively catalyzing H₂ evolution.     

The enhancement mechanism of hydrogen photoproduction in Chlorella protothecoides under nitrogen limitation and sulfur deprivation

The aim of this study was to understand the enhancement mechanism of H₂ photoproduction in Chlorella protothecoides under simultaneous nitrogen limitation and sulfur deprivation (LNS). Nitrogen limitation (LN) rather than sulfur deprivation significantly inhibited relative variable fluorescence at K-step (W_K) and J-step (V_J), photochemical efficiency of PSII (photosystem II), F_v/F_m, during the process of incubation in the light. Under such conditions, photosynthetic O₂ evolution decreased and the anaerobiosis was established after 12 h of incubation. The algae generated large amounts of H₂ under nitrogen limitation but generated only trace amounts under sulfur deprivation. Obviously, nitrogen limitation rather than sulfur deprivation was the decisive factor that induced H₂ photoproduction in C. protothecoides under LNS. The LNS culture generated much more H₂ than the LN culture in the presence of DCMU during incubation, suggesting that a PSII-independent electron source contributed many more electrons for transfer to hydrogenase in the LNS culture. PSII electron transport includes linear electron flow (LEF) and cyclic electron flow (CEF) of PSII in C. protothecoides. In the PSII-dependent electron source for H₂ photoproduction, PSII supplies electrons to hydrogenase through the LEF. The LNS culture showed much higher LEF and lower CEF than the LN culture during the H₂ photoproduction phase, as indicated by the large lower quantum yield of PSII electron transport (Φ_PSII) in the LNS culture in the presence of DCMU. Therefore, compared with nitrogen limitation, simultaneous nitrogen limitation and sulfur deprivation enhanced H₂ photoproduction in C. protothecoides mainly due to enhanced PSII-dependent and -independent electron sources.     

Synthesis of (CuIn)xCd2(1−x)S2 photocatalysts for H2 evolution under visible light by using a low-temperature hydrothermal method

A new series visible-light driven photocatalysts (CuIn)_xCd_2(1−x)S₂ was successfully synthesized by a simple and facile, low-temperature hydrothermal method. The synthesized materials were characterized by means of X-ray diffraction (XRD), scanning electron microscopy (SEM), Brunauer–Emmett–Teller (BET) surface area measurement, X-ray photoelectron spectroscopy (XPS) and ultraviolet-visible spectroscopy (UV–Vis DRS). The results show that the morphology of the photocatalysts changes with the increase of x from 0.01 to 0.3 and their band gap can be correspondingly tuned from 2.37 eV to 2.30 eV. The (CuIn)_xCd_2(1−x)S₂ nanocomposite show highly photocatalytic activities for H₂ evolution from aqueous solutions containing sacrificial reagents, SO₃²⁻ and S²⁻ under visible light. Substantially, (CuIn)_0.05Cd_1.9S₂ with the band gap of 2.36 eV exhibits the highest photocatalytic activity even without a Pt cocatalyst (649.9 μmol/(g h)). Theoretical calculations about electronic property of the (CuIn)_xCd_2(1−x)S₂ indicate that Cu 3d and In 5s5p states should be responsible for the photocatalytic activity. Moreover, the deposition of Pt on the doping sample results in a substantial improvement in H₂ evolution than the Pt-loaded pure CdS and the amount of H₂ produced (2456 μmol/(g h)) in the Pt-loaded doping system is much higher than that of the latter (40.2 μmol/(g h)). The (CuIn)_0.05Cd_1.9S₂ nanocomposite can keep the activity for a long time due to its stability in the photocatalytic process. Therefore, the doping of CuInS₂ not only facilitates the photocatalytic activity of CdS for H₂ evolution, but also improves its stability in photocatalytic process.     

Conformational regulation of the hydrogenase gene expression in green alga Chlamydomonas reinhardtii

The direct relationship between hydrogenase gene conformation and its function in green alga Chlamydomonas reinhardtii has been investigated. We have analyzed the conformation in the 29 kilobase (kb) chromosome region containing [FeFe]-hydrogenase gene (hydA1) of C. reinhardtii in aerobic and anaerobic conditions using chromosome conformation capture technique (3C). The results showed a loop organization in the [FeFe]-hydrogenase gene region under aerobic conditions when the hydrogenase gene is silenced. In contrast, under anaerobic conditions, when the hydrogenase gene is active, no loop conformation in the gene region is present.     

Demonstration of sustained hydrogen photoproduction by immobilized,sulfur-deprived Chlamydomonas reinhardtii cells

It was demonstrated that immobilized, sulfur-deprived algal cultures can photoproduce H₂${}_2$. After identifying the optimal material and procedures for immobilization of Chlamyodomonas reinhardtii   at high cell density, we examined the effect of liquid mixing, sulfate content, acetate levels and light intensity on the H₂${}_2$-production activity of the culture. Our results indicate that (a) liquid mixing is important to provide homogeneous conditions for the immobilized culture; (b) sulfur deprivation is necessary for hydrogen production by immobilized cultures; and (c) high light intensity decreases H₂${}_2$ production. The maximum total volume of H₂${}_2$ produced by the system (160 ml of reactor volume) was 380 ml over 23 days, and the highest rate of H₂${}_2$ production observed was 45 ml day^-1${}^{-1}$. Cell immobilization significantly increased the duration of the H₂${}_2$-photoproduction phase (up to 4 weeks), maintained specific rates of H₂${}_2$ photoproduction similar to those of suspension cultures and showed potential for large increases in H₂${}_2$ production.     

Increased hydrogen photoproduction by means of a sulfur-deprived Chlamydomonas reinhardtii D1 protein mutant

The photoproduction of H₂ was studied in a sulfur-deprived Chlamydomonas reinhardtii D1 mutant that carried a double amino acid substitution. The leucine residue L159 was replaced by isoleucine, and the asparagine N230 was replaced by tyrosine (L159I-N230Y). Phenotypic characterization of the mutant showed some interesting features compared to its wild type, namely: (1) a lower chlorophyll content; (2) a higher photosynthetic capacity and higher relative quantum yield of photosynthesis; (3) a higher respiration rate; (4) a very high conversion of violaxanthin to zeaxanthin during H₂ production; (5) a prolonged period of H₂ production. In standard conditions, the mutant produced more than 500 ml of H₂, that is, more than one order of magnitude greater than its wild type, and about 5-times greater than the CC124 strain that was used for comparison. The better performance of the mutant was mainly the result of a longer production period. Biogas produced contained up to 99.5% H₂.     

Enhanced hydrogen production by means of sulfur-deprived Chlamydomonas reinhardtii cultures grown in pretreated olive mill wastewater

Under sulfur-deprived conditions, the metabolism of Chlamydomonas reinhardtii switches to the photoproduction of hydrogen. This process is sustained by both photosystem II-driven water splitting and by the fermentation of stored carbohydrates. We investigated the possibility of using diluted pretreated olive mill wastewaters (OMW), which contain organic acids and sugars, as a substrate on which to grow Chlamydomonas, in order to obtain suitable biomass to produce hydrogen. The cells grown on a mixture of pretreated OMW and TAP (tris-acetate-phosphate) (50% dilution) were found to be richer in carbohydrates and exhibited a greater production of hydrogen (150 ml H₂ l⁻¹ culture), compared to the control cells (100 ml H₂ l⁻¹ culture). In these cultures, the hydrogen production process was characterized by a shorter aerobic phase and a longer hydrogen-production period. The results offer a useful perspective for the utilization of olive mill wastewaters, which constitute an environmental problem, particularly in Mediterranean areas, and for increasing the output for hydrogen production with Chlamydomonas.     

Expression of the [FeFe] hydrogenase in the chloroplast of Chlamydomonas reinhardtii

Biological hydrogen generation from phototrophic organisms is a promising source of renewable fuel. The nuclear-expressed [FeFe] hydrogenase from Chlamydomonas reinhardtii has an extremely high turnover rate, and so has been a target of intense research. Here, we demonstrate that a codon-optimized native hydrogenase can be successfully expressed in the chloroplast. We also demonstrate a curiously strong negative selective pressure resulting from unregulated hydrogenase expression in this location, and discuss management of its expression with a vitamin-controlled gene repression system. To the best of our knowledge, this represents the first example of a nuclear-expressed, chloroplast-localized metalloprotein being synthesized in situ. Control of this process opens up several bioengineering possibilities for the production of biohydrogen.     

Stimulatory effect of ascorbate,the alternative electron donor of photosystem II,on the hydrogen production of sulphur-deprived Chlamydomonas reinhardtii

The green alga Chlamydomonas reinhardtii is capable of photoproducing molecular hydrogen following sulphur deprivation, which results in anaerobiosis and a suppression of oxygen evolution and thus an alleviation of the inhibitory effect of oxygen on the hydrogenase. At the same time it transiently maintains a limited supply of electrons arising from photosystem II (PSII) to the hydrogenase (Melis and Happe Plant Physiol 2001; 127:740–748). In this work, using fast chl a fluorescence and P700 measurements, we show that ascorbate (Asc), a naturally occurring PSII alternative electron donor, is capable of donating electrons to PSII in heat-treated and sulphur-deprived cells and this can be significantly accelerated by supplementing the culture with 10 mM Asc. It also enhances, about three-fold, the photoproduction of hydrogen in cells subjected to sulphur deprivation as shown by gas chromatography. Similar stimulation was obtained in the presence of diphenylcarbazide (DPC), an artificial PSII electron donor. Asc and DPC also facilitated the anaerobiosis of cells, probably via super reducing the oxygen evolving complex while feeding electrons to PSII reaction centres and the linear electron transport chain, and ultimately to the hydrogenase – as shown by the significant DCMU-sensitivity of the light-induced Asc- and DPC-dependent re-reduction of P700⁺ and hydrogen evolution.     

Electrochemical supercapacitor behavior of Ni3(Fe(CN)6)2(H2O) nanoparticles

Nanosized Ni₃(Fe(CN)₆)₂(H₂O) was prepared by a simple co-precipitation method. The electrochemical properties of the sample as the electrode material for supercapacitor were studied by cyclic voltammetry (CV), constant charge/discharge tests and electrochemical impedance spectroscopy (EIS). A specific capacitance of 574.7 F g⁻¹ was obtained at the current density of 0.2 A g⁻¹ in the potential range from 0.3 V to 0.6 V in 1 M KNO₃ electrolyte. Approximately 87.46% of specific discharge capacitance was remained at the current density of 1.4 A g⁻¹ after 1000 cycles.