高能球磨制备Al2O3/Cu复合材料

采用高能球磨法制备Al2O3/Cu复合粉末,通过X射线衍射仪(XRD)和扫描电镜(SEM)研究高能球磨时间对复合粉末的物相、晶粒尺寸和表面形貌的影响。结果表明,随球磨时间的增加,基体Cu的晶粒不断被细化,在球磨初期,晶粒尺寸减小很快,当晶粒尺寸小于20 nm时,细化速率变缓而趋于稳定;Cu颗粒形貌由树枝状变为层状,并向椭球体转变;纳米Al2O3颗粒逐渐嵌入Cu颗粒体内,且分散均匀,从而获得纳米Al2O3颗粒弥散分布的Cu基复合粉末。并探讨了高能球磨对放电等离子体烧结Al2O3/Cu复合材料导电性能和力学性能的影响,研究认为高能球磨可以促进基体的晶界强化和弥散强化,而晶界的增加并不会导致电阻率的显著增大,影响电阻率的主要因素为Al2O3的体积分数、孔隙和杂质的固溶。     

球磨工艺对Al2O3/Mo复合材料组织的影响

针对原位自生Al2O3增强钼基复合材料晶粒较大的问题,采用溶胶-凝胶与高能球磨相结合的方法细化复合材料晶粒,并利用SEM、XRD对不同球磨工艺所制备Al2O3/Mo复合粉末及复合材料的组织进行了观察和分析。结果表明:随着球磨时间的延长,Al2O3/Mo复合粉末颗粒由球状变为层片状再成为细小的球状,颗粒大小由约1.5μm细化为约500nm,其中的钼晶粒不断细化;高球料比所得粉末的分散性和破碎细化程度较好;转速提高使得粉末颗粒的尺寸均匀程度降低,且伴有结块现象,不利于粉末的细化。在球料比5∶1、转速300r/min、球磨时间60h条件下获得的复合粉末,经压坯烧结可制备出Al2O3颗粒为纳米级的钼基复合材料。     

机械合金化制备(Al_2O_3+Gr)/Cu复合材料的性能

采用机械合金化制备Al2O3、Gr(石墨)双相强化Cu基复合材料((Al2O3+Gr)/Cu),研究球磨时间对复合材料组织与性能的影响。结果表明:球磨时间为9 h时,细长条状的Gr和纳米Al2O3颗粒弥散分布在Cu基体中,(Al2O3+Gr)/Cu复合材料具有最佳的综合性能,相对密度、硬度、导电率、摩擦系数和体积磨损率分别为95.3%、142 HV、39.8%IACS、0.15和1.4×10-3mm3/m;球磨时间对(Al2O3+Gr)/Cu复合材料的摩擦系数影响较小,体积磨损率则随着球磨时间的延长先增大后减小,与Al2O3/Cu复合材料相比,(Al2O3+Gr)/Cu复合材料具有优良的减磨耐磨性能。     

原位反应合成致密Al2O3p-TiCp/Al复合材料

采用高能球磨细化晶粒、原位反应合成及热压技术制备了致密的Al2 O3 p TiCp/Al复合材料 ,并用XRD、SEM、以及EDAX等手段分析了复合材料的相组成、显微组织。结果表明 :Al TiO2 C三元体系在热压反应烧结后 ,可制得致密度较高的Al2 O3p TiCp/Al原位复合材料 ,其显微组织中Al2 O3 和TiC颗粒尺寸为 1μm左右 ,分布均匀。高能球磨有利于增强颗粒细化及弥散分布和反应。     

Al_2O_3-CeO_2-ZrO_2-Ni系球磨过程中的分散性和相变研究

运用XRD、SEM等方法研究了Al2O3-CeO2-ZrO2-Ni高能球磨体系在不同的球磨工艺条件下的组织结构转变和分散性的问题.结果表明,四种物质一起球磨时,不会发生机械合金化,但随着球磨时间的延长,Al2O3、CeO2、ZrO2粉末都会不断被细化,而Ni颗粒仍较粗大且分布很不均匀.通过改变球磨顺序,将CeO2、ZrO2和Ni先球磨30 h再添加Al2O3继续球磨30 h,却能使CeO2和ZrO2发生合金化生成固溶体,且Ni颗粒有明显的细化,分散性也明显提高.     

球磨时间对Al2O3/Mo复合材料组织与性能的影响

采用溶胶-凝胶法制备Al2O3/Mo混合粉体,利用高能球磨法细化Al2O3/Mo复合材料中氧化铝和钼的晶粒尺寸,研究了球磨时间对Al2O3/Mo复合材料组织与性能的影响,利用XRD和扫描电镜对复合粉末形貌和复合材料进行了物相和形貌分析。研究表明:随着球磨时间的延长,复合粉末的形貌经历了球状到层片状再到球状的变化,粉末粒度逐渐减小,经粉末冶金烧结后的复合材料中,氧化铝和钼的粒径逐渐减小,经过60h的球磨,氧化铝颗粒的尺寸达到500nm左右;复合材料的密度呈现先增加后减小的趋势,显微硬度则逐渐上升至403.2HV。     

机械活化-放电等离子烧结FeAl/Al2O3复合材料

利用机械活化-放电等离子烧结的方法,将Fe-Al-Al2O3粉末经机械活化后快速烧结,得到致密且晶粒细小的FeAl/Al2O3,块体复合材料.研究表明,在球粉质量比13:1、转速170r/min、球磨时间25h的球磨条件下,Fe-40%(原子数分数)Al-10%(质量分数)Al2O3粉体中的纳米级Al2O3颗粒,在细化和活化Fe、Al金属粉末的同时,还能有效地阻止金属粉末在烧结前合金化生成金属间化合物.在烧结压力40MPa、烧结温度1 050℃、加热时间15min、保温时间10min的工艺条件下,制备的FeAl/Al2O3复合材料的相对密度达96.4%.     

原位反应合成致密Al2O3p-TiCp/Al复合材料

本文采用高能球磨、原位反应合成及热压技术制备了致密的Al2O3p-TiCp/Al复合材料,并用XRD、SEM以及EDAX等手段分析了复合材料的相组成、显微组织.结果表明:Al-TiO2-C三元体系在热压反应烧结后,可制得致密度较高的Al2O3p-TiCp/Al原位复合材料,其显微组织中Al2O3和TiC颗粒尺寸为1μm左右,分布均匀.高能球磨有利于增强颗粒细化弥散分布和反应进行完全.     

高能球磨稀土高硅铝合金粉末性能表征

对快速凝固法制备得到的Al-20Si-0.35RE合金进行不同时间的高能球磨, 然后对球磨后的粉末进行多次热压变形, 采用XRD, ESEM以及TEM等表征变形前后合金粉末的显微组织, 并对变形后合金的导电性能进行了研究. 研究发现快速凝固Al-20Si-0.35RE合金粉末的显微组织主要由细小的Al-Si固溶体(0.3～0.5 μm)、初晶硅、稀土铝硅化合物(0.16～0.3 μm)组成; 随着球磨时间延长, 颗粒粒径显著减小; 经过多次热压变形后合金晶粒显著细化, 晶格畸变减小, 位错钉扎稀土化合物, 形成类似表面渗流效应, 合金导电率提高至70%IACS.     

高能球磨制备高铝锌铝合金粉末的研究

首先采用一步球磨法制备了成分为Zn-30Al-6Si-0.5Cu(质量分数/%)和Zn-30Al-3Si-3Cu(质量分数/%)的高铝锌铝合金粉末,其次采用二步球磨法制备了成分为Zn-30Al-6Si-0.5Cu(质量分数/%)的合金粉末,并利用XRD、SEM粒度分析仪对粉末的物相组成、颗粒形貌及粒度进行了表征和分析。结果表明:含硅量为6%的合金粉末的颗粒尺寸比含硅量为3%的合金粉末更为细小,尺寸分布更为集中,球磨12h之后的粉末其金相组织主要由富Al的α相、富Zn的η相以及Si相组成。经过二步球磨后的Zn-30Al-6Si-0.5Cu粉末中Al9Si相基本消失,Si相含量增加;二步球磨法制备的粉末颗粒尺寸更为细小。通过扫描电镜观察发现粉末形貌不规则,且分布不够均匀,粉末中基本未观察到类似焊片的颗粒。     

转炉炉壳热应力分析

根据实际转炉建立实体模型。以有限元为手段,考虑了炉衬和炉壳材料的物性参数随温度变化的特点和炉衬与炉壳之间膨胀间隙,计算了转炉炉壳在温度载荷和炉衬膨胀压力同时作用下的热应力。所得结果可为转炉炉壳设计提供依据。     

焦炭热性能指标意义浅析

通过对焦炭在高炉内的历程及其变化规律的剖析,阐述焦炭热性能指标的意义,形象地把焦炭在高炉内的损耗分为三部分(M1,M2,M3)。指出M2对焦比及焦炭价格有一定的指导作用。     

Results of treatment of cancer of the cardia

Cancer of the cardia is traditionally discussed with cardiac cancer of the lower portion of the esophagus and upper gastric cancer invading the esophagus, and the specific characteristics of cancer of the cardia have never been clearly defined. We reviewed the outcome of 172 patients with adenocarcinoma of the cardia who had undergone radical surgery between 1949 and 1994 in the Division of Gastrointestinal Surgery of the Cancer Institute Hospital. The centers of the tumors were located within 2 cm above and below the boundary between the esophagus and the stomach, and their longitudinal diameter was less than 8 cm. We divided the patients into an early period (1949-1979; n = 79) and a late period (1980-1994; n = 93), and focused on the historical transition. There were no differences in patient gender or histology between the two periods. However, the late period was associated with fewer cases of esophageal invasion and shorter longitudinal diameter, as the age of the population advanced. The number of advanced cancers such as the localized and infiltrative type had decreased, and early cancer and early clinical stage had become more common, but despite the fact that the number of early cancers had increased, extended dissection, such as thoracic and paraaortic lymph node dissection, was performed more frequently. By clinical stage, the long-term outcome markedly improved in Stage I patient in the late period, and tended to improve in Stage II and III patients. This appears to have been attributable to the prevention of micrometastasis by extended dissection, although the number of early cancers is another major potential cause. There were no differences in the outcome of Stage IV patients between the two periods, and further advances in multimodality therapy must be awaited. The range of resection is basically proximal gastrectomy, and if there are adequate indications, the prognosis is favorable. In view of the status of lymphatic flow and lymph node metastasis, and long-term results, lateroaortic lymph node dissection is important. Since the number of early cancer patients has been increasing, if intraabdominal recurrence is prevented, intrathoracic lymph node dissection will contribute greatly to the outcome of such patients.     

The effect of amount of possession of the trait of hostility on accuracy of perception of hostility in others.

Some theories of personality hold that an individual's perception of others is influenced by his own personality characteristics; more specifically, that a trait of low social value will be projected more into others, and that insight into the possession of these characteristics reduces this distortion. These 2 hypotheses were tested by having a group of college students rate each other (including themselves) on degree of friendliness or hostility. Agreement with group rating about self yielded the insight score. In general, the hypotheses were supported; the "friendly" Ss were most accurate in their perception of others, and insight was positively associated with accurate perception. From Psyc Abstracts 36:04:4HL16M. (PsycINFO Database Record (c) 2010 APA, all rights reserved)     

Effect of antibiotics of chemotaxis of human leukocytes

The effect of 20 different antibiotics on chemotaxis by human neutrophils was studied. Human leukocytes incubated with chloramphenicol, rifampin, sodium fusidate, and tetracyclines in vitro showed markedly depressed migration. The mechanisms by which these antibiotics affect leukotaxis are discussed.     

Quality of life of relatives of mental patients

Usage of quality of life of psychiatric patients' relatives as the parameter of estimation of the quality of psychiatric care is considered. By means of standard questionnaire elaborated by the authors as well as by means of both individual and group conversations the quality of life was analyzed in 40 relatives which lived together with psychiatric patients. Different spheres of their life and difficulties (financial, social-psychologic, production) were examined in families with such patients. The defects of psychiatric care that had direct influence on the quality of life of the psychiatric patients' relatives are outlined.