Influence of lamb rennet paste on composition and proteolysis during ripening of Pecorino foggiano cheese

Rennet pastes produced by lambs subjected to three different feeding systems (mother suckling [MS], artificial rearing [AR], and artificial rearing with Lactobacillus acidophilus supplementation [ARLB]) and slaughtered at two different ages (20 and 40 d) were used for the manufacture of Pecorino foggiano cheese. Composition and proteolysis during ripening of Pecorino foggiano cheese (four replicates batches) were analyzed. Proteolysis was greater in cheeses made with rennet pastes from lambs slaughtered at 20 d, as shown by analysis of nitrogen fractions (water-soluble N and proteose peptones). Supplementation of milk substitute with L. acidophilus may have influenced the growth dynamics of lactic acid bacteria in the rennet pastes, with positive effects on levels of lactobacilli in cheese at the beginning of the ripening time. Lower pH values in ARLB cheese during ripening, together with higher cell loads, suggest that supplementation of milk replacer with L. acidophilus resulted in higher proteolytic activity, as also confirmed by the composition of the pH 4.6—insoluble nitrogen fraction. No differences were found in total concentration of free amino acids among the experimental cheeses; phenylalanine, isoleucine, leucine, lysine were found at the highest levels. The addition of probiotic bacteria to milk substitute in lamb rearing appears to give good-quality lamb rennet paste.     

Microbiological and physicochemical characteristics and aminopeptidase activities during ripening of Serrano cheese

The physicochemical and microbiological characteristics and the aminopeptidase activity variation of Serrano cheese during winter and summer were investigated. Samples from different producers varied significantly, showing nonstandardized procedures for the manufacturing and ripening of this product. There were no significant changes in aminopeptidase activity during maturation and most of the enzyme activity found in the water extracts of cheese would have their origin in lactobacillus and enterococci, suggesting autolysis of these micro-organisms. Results show an increase in free amino acids during maturation, with higher amounts in the summer product.     

快速成熟契达干酪成熟期间的理化特性变化

对天然契达(Cheddar)干酪快速成熟期间理化特性进行了研究,结果表明,在21 d内,pH值呈下降趋势(P<0.05),在21 d到35 d的成熟中,pH值缓慢增加(P>0.05);Cheddar干酪快速成熟过程中由于蛋白酶和脂肪酶的作用使蛋白发生水解,pH值为4.6醋酸溶液—水溶性氮质量分数、质量分数为12%的三氯乙酸—可溶性氮和游离氨基酸(FAA)的质量分数都呈明显增加趋势(P<0.05);成熟过程中TPA各项指标均有不同程度的变化,硬度和凝聚性呈先下降后增加的趋势,弹性和咀嚼性呈先上升后下降的趋势。     

Influences of rennet and container types on proteolysis of traditional Kurdish cheese during the ripening

The effect of rennet and container types was evaluated on proteolysis of traditional Kurdish cheese during 60 days ripening. The enzymes involved were commercial chymosin and traditional rennet from lamb abomasum. Goat skin (traditional container) and plastic containers were used as storage containers. The trend of proteolysis was determined by measuring the content of nitrogen (N) in compounds soluble in water, 12% trichloroacetic acid and 5% phosphotungstic acid along with the urea–polyacrylamide gel electrophoresis method. The results showed that the nitrogen in compounds soluble in water, 12% trichloroacetic acid and 5% phosphotungstic acid was higher in ripened cheeses into plastic containers; however, the containers had no significant effect on the breakdown of α‐ and β‐caseins (P < 0.05). Using commercial rennet caused the breakdown of α‐ and β‐caseins and the level of nitrogen in compounds soluble in water to increase. Finally, however, the amount of α‐ and β‐caseins breakdown was trivial, and α‐casein was decreased more than β‐casein in all samples.     

Residual clotting activity and ripening properties of vegetable rennet from Cynara cardunculus in La Serena cheese

Vegetable rennet extracted from Cynara cardunculus flowers is traditionally used in the manufacture of La Serena cheese. High levels of proteolytic enzymes of the flowers are responsible for its clotting activity and strong proteolytic action. The presence of residual coagulant in cheese and whey was measured by adding known amounts of vegetable rennet as internal standard. We found no differences between the residual coagulant activity of La Serena cheese compared with other types of cheese. The coagulant content detected at the end of four cheesemakings (vat of 830 l) in cheese and whey represented 27 and 78%, respectively, of the total amount added to milk. When measurements were carried out in 16 different cheeses, vegetable rennet appeared to be highly stable during cheese ripening. Cheese composition (moisture, pH, NaCl, fat and protein) was kept relatively constant during ripening, which seems to contribute to stability of residual activity. Electrophoretic analyses of water insoluble fractions from cheeses manufactured with vegetable rennet showed that α_s-casein was less susceptible to proteolysis than β-casein. The water soluble nitrogen/total nitrogen (WSN/TN) exhibited higher levels only during the first 30 days of ripening although non-protein nitrogen/total nitrogen (NPN/TN) ratio and amino acid nitrogen (NH₂-N) increased with ripening time.     

Effect of ripening time on bacteriological and physicochemical goat milk cheese characteristics

Food Science and Biotechnology - Cheese ripening involves lactose metabolism, lipolysis and proteolysis, which are affected by many factors. The aim of this study was to assess changes due to...     

Influence of the frozen storage on some characteristics of ripened Manchego-type cheese manufactured with a powdered vegetable coagulant and rennet

A study was made of the effect of freezing and nine months’ frozen storage on the chemical, microbiological and sensorial characteristics of fully ripened Manchego-type cheese. Chemical components, water activity and nitrogen compounds were not altered by freezing and frozen storage. Soluble and non-protein nitrogen were significantly higher in cheeses produced with the powdered vegetable coagulant (PVC) compared to those made with rennet. Proteolysis continued slowly during frozen storage, with higher amino acid and ammonia nitrogen rates at the end of the storage period. Micrococci (P-value <0.05, in cheese made with PVC) and staphylococci counts tended to decrease during frozen storage; however total viable, lactic acid bacteria and mold-yeasts counts were similar throughout the nine months. Changes in sensorial parameters were observed (P-value <0.05) throughout freezing and frozen storage, affecting the creaminess of cheeses made with chymosin and the taste intensity and salty taste of cheese obtained with vegetable coagulant. Cheeses obtained with PVC proved to have a more acid taste and greater taste intensity (P < 0.01) as well as displaying a more bitter taste, greater creaminess and lower degree of hardness (P-value <0.001) than those produced with rennet.     

Casein breakdown during ripening of Idiazabal cheese: influence of starter and rennet type

The objective of this work was to determine the effect of starter and rennet type on casein breakdown during Idiazabal cheese ripening. Four batches of cheeses were manufactured with two rennets, commercial calf rennet and artisanal lamb rennet, and the use of natural flora or a commercial starter. Electrophoretic analysis of cheese samples showed six bands identified as α_s1‐, α_s2 + β‐, α_s1‐I‐, γ₁‐, β‐I‐ and para‐κ‐casein. As expected, the casein breakdown during cheese ripening was considerably affected by rennet type and the use of a commercial starter. The artisanal lamb rennet produced a higher hydrolysis of casein fractions than the commercial calf rennet, probably owing to its high percentage of chymosin (around 78%). The effect of addition of starter on proteolysis was dependent on the casein fractions generated by artisanal lamb rennet or commercial calf rennet. © 2000 Society of Chemical Industry     

Influence of the technological properties of vegetable rennet (Cynara cardunculus) on the physicochemical,sensory and rheological characteristics of ‘Torta del Casar’ cheese

The purpose of this work was to investigate the influence of technological properties of vegetable rennet (Cynara cardunculus) on the characteristics of ‘Torta del Casar’ cheese to establish the parameters that can be useful for quality control of this coagulant. The physicochemical, microbial, texture and sensory properties of the cheeses were evaluated and correlated to clotting and proteolytic activities of the vegetable rennets used for their manufacture. The level of in vitro degradation of α‐casein and κ‐casein/β‐casein degradation ratio was found to be good tools to predict the effect of vegetable rennet on the rheological properties of these cheeses.     

Effect of β-casein concentration in cheese milk on rennet coagulation properties,cheese composition and cheese ripening

Effects of the use of a β-casein powder to enrich cheese milk on rennet coagulation properties of milk, cheese composition and cheese ripening were investigated. Casein content of control milk was 2.5%, whereas that for the three enriched milks was adjusted with β-casein powder at 2.7%, 2.9% and 3.1%. The β-casein to α-casein ratio of these cheese milks was, respectively, 0.70, 0.79, 0.89 and 0.99. Rennet coagulation properties were related not only to casein concentration but also to the proportion of β-casein and α_s-casein presents in milks. Milk with higher concentration of β-casein had poorer coagulation properties. Cheeses could be produced by using a miniature cheese making process. Moisture, ash and calcium contents decreased, while protein content and β-casein increased in cheese as casein and β-casein concentration increased in milk. As a result, hardness was higher in enriched cheeses than in control cheese. During cheese ripening, α-casein was hydrolyzed, but the rate of degradation of α-casein decreased as protein and β-casein concentration increased in cheese. β-Casein seemed to be not hydrolyzed. The rate of decrease of hardness was also slower for enriched cheeses.     

The role of immobilized rennet on carbon cloth in flavor development during ripening of Gouda cheese

Rennet-free Gouda (RFG) cheese was prepared to investigate the influence of rennet on the non-volatile and volatile profiles of cheese and was characterized by HPLC and GC/MS analyses. Chymosin, a major protease in rennet, was immobilized onto oxidized and chemically modified carbon cloth. The chymosin immobilization efficiency was 60.4%, and the milk-clotting activity used as an index of the stability of the immobilized chymosin decreased by around 20% in 2 weeks. However, the activity was maintained at 70–80% from 2 weeks to 32 weeks and was more stable than that of chymosin solution alone. Non-volatile (organic acids) and volatile profiles of the RFG cheese and rennet-containing normal Gouda cheese were not significantly different during ripening with a few exceptions. Therefore, it can be concluded that cheese flavor is developed by lactic acid fermentation, irrespective of the presence of rennet.     

Proteolysis during the ripening of goats’ milk cheese made with plant coagulant or calf rennet

Powdered plant coagulant (PPC) obtained from the cardoon (Cynara cardunculus) was compared with calf rennet (CR) for the manufacture of goats’ milk cheese, by determining difference in the proteolysis throughout ripening. There were no substantial differences between the compositions of cheeses made using the two types of coagulants. However, cheeses manufactured with PPC exhibited higher levels of pH 4.6-SN than cheese made using CR. The extent of breakdown of α_s-casein, as measured by urea-PAGE, was greater in cheese made using PPC than cheese made using CR. The formation of hydrophobic peptides and the ratio of hydrophobic/hydrophilic peptides throughout the ripening were higher in cheeses made with PPC than in cheeses made with CR. Principal component analysis (PCA) of peak heights of RP-HPLC peptide profiles of the ethanol-soluble and ethanol-insoluble fractions distributed the samples according to the coagulant used in their manufacture. Quantitative differences in several peptides were evident between the two types of cheese.     

Influence of rennet milk-clotting activity on the proteolytic and sensory characteristics of an ovine cheese

Roncal cheese (regulated by an Apellation of Origin) is a traditional hard cheese manufactured from raw ewe's milk in the region of Navarre in Spain. Roncal cheeses, manufactured using two lamb rennets with different milk-clotting activity levels, were evaluated to compare their chemical, proteolytic, and sensory characteristics. A preliminary study of samples of lamb rennets indicated that a large proportion of such rennets did not fulfil current microbiological requirements and likewise revealed considerable variation in the milk-clotting activity of the samples examined. Trends in the overall physicochemical parameter values (pH, dry matter, fat, and protein) were similar in both cheese batches. Proteolysis of the nitrogen fractions was observed to take place at a faster rate in the cheeses made using the rennet with the higher milk-clotting activity (soluble nitrogen, non-protein nitrogen, and amino acid nitrogen values around 13–20% higher than in the cheeses made using the rennet with the lower milk-clotting activity after 180 days of ripening). Urea-PAGE electrophoretic analysis of the caseins from the cheeses manufactured using both types of rennet showed that the β-caseins were less susceptible to proteolysis than the α_s-caseins. The effect of the different milk-clotting activity levels was most pronounced on the α_s-caseins, in which the rennet with the higher milk-clotting activity gave higher breakdown. Nevertheless, the differences in the proteolysis rates did not yield any appreciable sensory differences.     

Changes during manufacture and ripening of cheddar cheese prepared with fungal rennet substitute of Rhizopus oligosporus

Studies were made on the manufacture and ripening of cheddar cheese prepared with a milk-clotting enzyme of R. oligosporus and compared with rennet cheese. The curd working properties, yields and quality of green cheese from R. oligosporus enzyme were fairly comparable with calf-rennet. During the ripening period the changes in moisture, acidity, pH and fat content of both the cheese were similar. The soluble nitrogen was comparatively low while maturity index was higher during ripening in R. oligosporus cheese than calf-rennet cheese. Organoleptically, R. oligosporus cheese was rated lower than calf-rennet cheese, developing transient bitterness during ripening like other fungal rennet substitutes.     

Changes in physicochemical and organoleptic properties of traditional Iranian cheese Lighvan during ripening

Lighvan cheese was studied to determine the physicochemical and biochemical changes over 90 days of ripening in brine. Acidity, pH, dry matter, fat values, lipolysis level, water‐soluble nitrogen (WSN), total nitrogen (TN), ripening index (RI), trichloroacetic acid‐soluble nitrogen (TCA‐SN) and organoleptic assessments were analysed. Dry matter and fat values decreased during ripening. Lipolysis level, RI, TCA‐SN values and salt content increased continuously until the end of the ripening period, but total nitrogen decreased throughout a 90‐day storage period. The ripening stage was the main factor affecting the cheese’s sensory properties.     

木瓜蛋白酶对Mozzarella干酪成熟过程中品质特性的影响

为研究木瓜蛋白酶对Mozzarella干酪成熟过程中品质特性的影响,对两组Mozzarella干酪在成熟过程中的质构、蛋白降解、融化性、油脂析出性、色度、风味物质等进行测定。结果表明:添加木瓜蛋白酶Mozzarella干酪的硬度、弹性、咀嚼性、内聚性均显著低于对照组Mozzarella干酪(P0.05),p H 4.6 SN/TN、12%TCA SN/TN、融化性在成熟24天后显著高于对照组Mozzarella干酪(P0.05),挥发性风味化合物的种类、部分挥发性物质的含量都较对照组Mozzarella干酪少。     

Influence of residual rennet and proteolysis on the exudation of whey from Feta cheese during storage

A change in the quantity of rennet added to the cheesemilk resulted in a corresponding change in the level of residual rennet in Feta cheese. Casein proteolysis and exudation of whey from Feta cheese during storage were proportional to the quantity of residual rennet in the cheese. It is likely that with proteolysis, the three-dimensional casein network becomes weaker and gradually disintegrates. The water-holding ability of the casein gels is thereby greatly reduced and moisture is released from the interstices of the casein gel. This free moisture and soluble material, including peptides and amino acids formed during proteolysis, are released as exudate during the storage of Feta cheese.     

Changes in the physicochemical,microstructural and rheological properties of traditional Kope cheese during ripening

The effect of ripening time on the microstructural, physicochemical and rheological characteristics of traditional Kope cheese ripened in clay pots was investigated. The moisture content, pH and total nitrogen (TN)/dry matter (DM) of the cheese decreased, and DM, fat in DM and water‐soluble nitrogen/TN increased during this period. Storage and loss moduli increased, while loss tangent decreased; as a result, the elasticity characteristics were greater than the viscous characteristics of the samples. Microstructure images showed that the size of pores and casein network density increased significantly during ripening and, after 90 days, the structure of many pores became very similar to each other.     

温度对大豆奶酪成熟特性的研究

分别研究了大豆奶酪在不同的温度条件下的成熟特性.氨基酸态氮分析、质构分析以及风味品尝的结果均表明采用变温培养,即先在30℃成熟2d后再15℃成熟54d的大豆奶酪成熟度最好,其氨基酸态氮含量最高、硬度最低,品尝口感最好.