木薯渣超低酸预处理后的酶水解及乙醇发酵

为提高木薯渣的酶解糖化效率,降低原料处理成本,采用超低酸(ULA)对木薯渣进行预处理,并对预处理后的木薯残渣(CR_(ULA))进行纤维素酶酶解糖化,同时探究木薯残渣附着酶的再利用以及回用过程抑制物的累积对发酵产乙醇的影响。结果表明,CR_(ULA)采用70 FPU/g_(底物)纤维素酶水解12 h后,获得47.22 g/L葡萄糖和60.61 g/L总糖。附着于CR_(ULA)上的纤维素酶循环利用5次,纤维素酶添加量从70 FPU/g_(底物)(RUN 1)下降到42 FPU/g_(底物)(RUN 5),节省了40%的新鲜酶,RUN 5的葡萄糖和总糖浓度分别为48.00 g/L和60.92 g/L。RUN 1和RUN 5的酶解液分别用于乙醇发酵,得到乙醇浓度和得率分别为21.67 g/L和0.46 g/g_(葡萄糖)、21.52 g/L和0.45 g/g_(葡萄糖),与葡萄糖培养基所得结果接近。附着酶再利用过程中抑制物乙酸、5-HMF和糠醛浓度有累积增加,而甲酸无明显的变化。由物料衡算可知,木薯渣经ULA预处理及酶水解后,葡萄糖得率为80.64%,乙醇产率为13.84%。     

木薯酒精渣同步糖化发酵制乙醇的工艺研究

研究了利用木薯酒精厂废渣为原料发酵生产乙醇的方法,结果表明:经过简单的机械粉碎后,通过同步糖化发酵生产乙醇是可行的。发酵条件为:木薯酒精渣经粉碎后取粒径小于0.85mm的部分,初始料水比1∶8,纤维素酶添加量为每克木薯渣(干重)30FPU,发酵过程中在24h内分批将剩余木薯渣加入至总料水比达到1∶2.5,利用5L发酵罐进行同步糖化发酵,发酵液中乙醇质量浓度达到52g/L,木薯酒精渣到乙醇的收率达到13%。纤维素酶的添加量对发酵效果影响显著,当达到每克木薯渣(干重)50FPU时,发酵液中乙醇质量浓度可达65g/L,乙醇收率达到16%。     

糠醛渣纤维乙醇同步糖化发酵过程研究

以过碱化处理的糠醛渣为原料,采用正交试验法进行同步糖化发酵(SSF)转化乙醇工艺条件及过程研究.通过考察反应温度、pH、纤维素酶用量和表面活性剂浓度来优化同步糖化发酵转化工艺条件.在正交优化条件基础上,进行了5 L发酵罐试验,并同步分析表征了发酵过程中还原糖浓度、乙醇浓度、酵母细胞数、纤维素含量及其结构变化.同步糖化发酵转化糠醛渣生成乙醇的优化条件为:反应温度38℃,pH 4.2,纤维素酶用量20 FPU/(g纤维素),吐温-20质量分数0.15%,酵母接种量10%.发酵罐中同步糖化发酵糠醛渣生成乙醇的转化率达到72.33%,过程分析表明反应时间为27 h时,糠醛渣糖化发酵产乙醇的转化率达到最高,比其他纤维原料的反应转化时间大大缩短.同步糖化发酵过程中,糠醛渣纤维素含量逐步降低,纤维索表观结晶度呈下降趋势,纤维素微晶尺寸减小.     

玉米芯HNO_3/HCl预处理及同步糖化发酵制乙醇

采用正交实验对玉米芯在2%HNO3/HCl中的水解条件进行优化,得出最适宜的预处理条件为：反应温度120℃,反应时间30 min,固含量15%。将经过预处理的玉米芯作为同步糖化发酵的底物,采用单因素实验考查影响发酵的因素,结果表明：在底物浓度为150 g/L、37℃、pH值为5.0、纤维素酶用量为30 FPU/g底物、酵母接种量10%、发酵周期72 h时,乙醇的产率可达到76.8%,此时乙醇溶液的浓度为41.4 g/L。     

脱木素对糠醛渣同步糖化发酵乙醇转化的影响

对碱性过氧化氢处理后的糠醛渣样品进行同步糖化发酵转化乙醇研究。结果表明,木素脱除提高糠醛渣转化乙醇得率。与未处理糠醛渣相比,脱木素糠醛渣样品发酵96h后水解液中乙醇浓度由6.8g/L提高至14.5g/L,乙醇转化率由50.6%提高至69.35%。     

菊芋秸秆的稀酸水解及乙醇发酵

菊芋作为一种非粮作物,块茎和秸秆均可以被微生物发酵生成乙醇。采用稀酸法对菊芋秸秆进行预处理,通过单因素实验,考察了预处理温度、预处理时间、稀酸浓度、料液比4个因素,得到的优化结果:料液比为1∶8,酸解温度为121℃,酸质量分数为1.5%,酸解时间为1 h。此条件下水解菊芋秸秆,还原糖得率高达53.7%;预处理后的水解液在添加纤维素酶和木聚糖酶后,考察Kluyveromyces marxianus 1727的乙醇发酵能力,其同步糖化发酵与分步糖化发酵乙醇产量分别为25.91 g/L和25.63 g/L,生产效率分别是0.54 g/L/h和0.26 g/L/h。结果表明,稀酸水解的菊芋秸秆可用作底物生产燃料乙醇。     

利用海带渣生产燃料乙醇的初步研究

对海带渣中的纤维成分进行了测定,并以海带渣为原料进行了发酵产纤维素乙醇的研究。通过实验初步建立了海带渣生产乙醇的预处理方法并确立了发酵方式,同时对南极低温纤维素酶QP7复配降解海带渣生产乙醇的效果进行了研究。实验结果表明,海带渣中纤维素含量达28.3%;稀酸预处理后,海带渣经分步糖化发酵得到的乙醇浓度高于相同条件下的秸秆乙醇浓度;在海带渣同步糖化发酵中以低温纤维素酶作为复配酶进行酶解,乙醇产量提高21%以上。海带渣作为生产纤维素乙醇的原料,具有良好的应用前景;既能为海带产业的综合利用提供新方向,而且能够为其它海藻的生物质能源开发提供数据和方法参考。     

利用树干毕赤酵母发酵玉米秸秆制备燃料酒精

采用湿热预处理(195℃,15min)与同步糖化发酵对玉米秸秆制备酒精进行了研究。结果表明:玉米秸秆经过湿热预处理后,86.5%纤维素保留在滤饼中,而大部分半纤维素被溶解。在底物质量体积含量50g/L,温度30℃,pH值5.5,摇床转速130r/min条件下,树干毕赤酵母(Pichia stipitis)利用预处理后的玉米秸秆经过192h同步糖化发酵,酒精浓度达到了12.12g/L,对应的酒精产量和生产效率分别为0.34g/g(葡萄糖+木糖)和0.065g/(L·h)。该项研究为工业化生产打下了基础。     

木糖渣的有机溶剂预处理及酶解性能

木糖渣是玉米芯经稀酸处理提取木糖后的残余物,一般作为燃料焚烧以提供部分热能。由于其含有丰富的纤维素组分,故可通过生物转化来生产多种化工产品,但残渣中大量木素的存在严重抑制了纤维素酶的水解效率。采用一些有机溶剂预处理可将部分木素溶出,因而可改善物料的酶解性能。采用乙醇对木糖渣进行预处理,研究了预处理条件（如温度、时间、固液比等）对木糖渣化学组分和纤维素酶解转化率的影响,并与玉米秸秆和玉米芯等进行了对比。结果表明预处理降低了木糖渣的木素含量,在固液（质量/体积）比1︰8、处理液中乙醇浓度50%（体积）、预处理温度210℃、预处理时间60 min时,木素脱除率为53.26%,预处理后木糖渣在酶解72 h时的纤维素转化率达到84.42%,比预处理前提高 14.58%。研究还发现,与木糖渣相比,有机溶剂乙醇更适合用于玉米芯和玉米秸秆酶解前的预处理。     

玉米芯稀酸预处理和分步糖化与发酵工艺生产燃料乙醇的中试研究

利用正交试验在中试水平考察了玉米芯的稀硫酸预处理和分步糖化与水解生产乙醇的工艺。结果:最佳预处理工艺为稀硫酸浓度1.1%,温度120℃,固液比1∶8,时间3 h;酶解糖化最佳工艺为:起始底物浓度180 g/L,滤纸酶活:纤维二糖酶活=20 IU/g底物:7 IU/g底物,pH=5.0,48 h;利用运动发酵单胞菌发酵酶解液,35℃,48 h,发酵液中乙醇浓度最高67.8 g/L。     

高底物浓度纤维乙醇同步糖化发酵工艺的比较

引言日益加剧的能源危机和环境污染,正迫使人们寻求新的可再生替代能源。纤维乙醇作为一种重要的生物质替代能源,经过近40多年的发展,已经具备了实现工业化生产的潜力。为了进一步降低纤     

Pretreatment Strategies to Enhance Enzymatic Hydrolysis and Cellulosic Ethanol Production for Biorefinery of Corn Stover

There is a rising interest in bioethanol production from lignocellulose such as corn stover to decrease the need for fossil fuels, but most research mainly focuses on how to improve ethanol yield and pays less attention to the biorefinery of corn stover. To realize the utilization of different components of corn stover in this study, different pretreatment strategies were used to fractionate corn stover while enhancing enzymatic digestibility and cellulosic ethanol production. It was found that the pretreatment process combining dilute acid (DA) and alkaline sodium sulfite (ASS) could effectively fractionate the three main components of corn stover, i.e., cellulose, hemicellulose, and lignin, that xylose recovery reached 93.0%, and that removal rate of lignin was 85.0%. After the joint pretreatment of DA and ASS, the conversion of cellulose at 72 h of enzymatic hydrolysis reached 85.4%, and ethanol concentration reached 48.5 g/L through fed-batch semi-simultaneous saccharification and fermentation (S-SSF) process when the final concentration of substrate was 18% (w/v). Pretreatment with ammonium sulfite resulted in 83.8% of lignin removal, and the conversion of cellulose and ethanol concentration reached 86.6% and 50 g/L after enzymatic hydrolysis of 72 h and fed-batch S-SSF, respectively. The results provided a reference for effectively separating hemicellulose and lignin from corn stover and producing cellulosic ethanol for the biorefinery of corn stover.     

氧气辅助湿热预处理对玉米秸秆酒精发酵的影响

为了解氧气（O₂）在玉米秸秆湿热预处理中的作用,优化玉米秸秆酒精生产工艺,本文采用三种不同湿热预处理条件处理玉米秸秆,即条件1（195℃,15min）、条件2（195℃,15min,12bar O₂）和条件3（195℃,15min,12bar O₂,2g/L Na₂CO₃）,并利用酿酒酵母对预处理后的玉米秸秆同步糖化发酵酒精工艺（SSF）进行了研究。实验结果表明：经过预处理,玉米秸秆分为固体滤饼与水解液两部分,其中绝大部分纤维素以固体形式保留在滤饼中,而半纤维素和木质素由于不稳定则发生了部分水解或降解。三种预处理条件下纤维素总体收率分别为91.2%、94.6%和95.9%,半纤维素总体收率分别为74.5%、50.3%和68.2%,固体滤饼中木质素质量分数分别为25.2%、17.5%和13.7%,纤维素酶解葡萄糖率分别为64.8%、65.8%和67.6%。表明氧气对纤维素收率影响不大,能够促进半纤维素的溶出。氧气主要与木质素发生反应,尤其与碱性物质碳酸钠（Na₂CO₃）结合,能够促进木质素降解,从而获得了较高的纤维素收率和纤维素酶解葡萄糖率。因此在底物质量分数8%,经过酿酒酵母142h发酵,经条件3处理的玉米秸秆获得的酒精浓度最高,最终酒精浓度达到25.0g/L,并且整个发酵过程没有明显的抑制作用产生。     

FED-BATCH SIMULTANEOUS SACCHARIFICATION AND FERMENTATION OF MICROWAVE/ACID/ALKALI/H2O2 PRETREATED RICE STRAW FOR PRODUCTION OF ETHANOL

The batch simultaneous saccharification and fermentation (SSF) of microwave/acid/alkali/H₂O₂ pretreated rice straw to ethanol was optimized using cellulase from Trichoderma reesei and Saccharomyces cerevisiae YC-097 cells prior to the fed-batch SSF studies. The batch SSF optima were 10% w/v substrate, 40°C, 15 mg cellulase/g substrate, initial pH 5.3, and 72 hours. Under the optimum conditions the ethanol concentration and its yield were 29.1 g/L and 61.3% respectively. Based on the optimal batch SSF, the fed-batch SSF was investigated and its operation parameters were optimized. Under its optimal conditions the ethanol concentration reached 57.3 g/L, while its productivity and yield were only slightly less than those in the batch SSF. This suggests that fed-batch SSF is a potential operation mode for effective ethanol production from microwave/acid/alkali/H₂O₂ pretreated rice straw.     

氨水浸泡稻草秸秆对纤维素酶解产糖的影响

为了有效提高木质纤维素酶解糖化率,以稻草秸秆为研究对象,采用氨水预处理实验,考察稻草秸秆粉粒度、氨水质量分数、预处理时间、预处理温度、液固比对稻草秸秆酶解糖化的影响。结果表明:稻草秸秆经60目过筛后用14%氨水按液固比9∶1在50℃处理35h,糖化率达61.42%。     

FED-BATCH SIMULTANEOUS SACCHARIFICATION AND FERMENTATION OF MICROWAVE/ACID/ALKALI/H2O2 PRETREATED RICE STRAW FOR PRODUCTION OF ETHANOL

The batch simultaneous saccharification and fermentation (SSF) of microwave/acid/alkali/H₂O₂ pretreated rice straw to ethanol was optimized using cellulase from Trichoderma reesei and Saccharomyces cerevisiae YC-097 cells prior to the fed-batch SSF studies. The batch SSF optima were 10% w/v substrate, 40°C, 15 mg cellulase/g substrate, initial pH 5.3, and 72 hours. Under the optimum conditions the ethanol concentration and its yield were 29.1 g/L and 61.3% respectively. Based on the optimal batch SSF, the fed-batch SSF was investigated and its operation parameters were optimized. Under its optimal conditions the ethanol concentration reached 57.3 g/L, while its productivity and yield were only slightly less than those in the batch SSF. This suggests that fed-batch SSF is a potential operation mode for effective ethanol production from microwave/acid/alkali/H₂O₂ pretreated rice straw.     

Bioethanol production from optimized pretreatment of cassava stem

The current ethanol production processes using crops such as corn and sugar cane are well established. However, the utilization of cheaper biomasses such as lignocellulose could make bioethanol more competitive with fossil fuels, without the ethical concerns associated with the use of potential food resources. A cassava stem, a lignocellulosic biomass, was pretreated using dilute acid to produce bioethanol. The pretreatment conditions were evaluated using response surface methodology (RSM). As a result, the optimal conditions were 177 °C, 10 min and 0.14 M for the temperature, reaction time and acid concentration, respectively. The enzymatic digestibility of the pretreated cassava stem was examined at various enzyme loadings (10–40 FPU/g cellulose of cellulase and 30 CbU/g of β-glucosidase). With respect to economic feasibility, 20 FPU/g cellulose of cellulase and 30 CbU/g of β-glucosidase were selected for the test concentration and led to a saccharification yield of 70%. The fermentation of the hydrolyzed cassava stem using Saccharomyces cerevisiae resulted in an ethanol concentration of 7.55 g/L and a theoretical fermentation yield of 89.6%. This study made a significant contribution to the production of bioethanol from a cassava stem. Although the maximum ethanol concentration was low, an economically efficient overall process was carried out to convert a lignocellulosic biomass to bioethanol.     

蒸煮助剂对低用碱量硫酸盐法预处理毛竹竹屑的影响

毛竹竹屑经10%低用碱量 (以Na₂O计)、20%硫化度、160 ℃下保温1 h预处理,木质素脱除率达到62.35%,预处理物料酶水解48 h葡萄糖和木糖得率分别为56.04%和53.47%。研究了硼氢化钠、三聚磷酸钠、2-蒽醌磺酸钠3种蒸煮助剂对毛竹竹屑10%用碱量硫酸盐预处理的成分以及糖化效果影响,其中2-蒽醌磺酸钠影响最大。在10%用碱量和20%硫化度的预处理液中添加0.15%的2-蒽醌磺酸时,160 ℃下保温1 h的葡聚糖回收率和木质素脱除率分别为94.93%和68.55%,与空白对比分别提高5.45%和9.94%;预处理物料酶解48 h葡萄糖和木糖得率分别为62.88%和58.97%,与空白对比分别提高12.21%和10.29%。     

Simultaneous saccharification and fermentation of pretreated Antigonum leptopus (Linn) leaves to ethanol

Simultaneous saccharification and fermentation (SSF) of alkaline hydrogen peroxide pretreated Antigonum leptopus (Linn) leaves to ethanol was optimized using cellulase from Trichoderma reesei QM‐9414 (Celluclast® from Novo) and Saccharomyces cerevisiae NRRL‐Y‐132 cells. Contrary to the saccharification optima (2.5% w/v substrate concentration, 50 °C, 4.5 pH, 40 FPU cellulase g⁻¹ substrate and 24 h reaction time), the SSF optima was found to be somewhat different (10% w/v substrate, 40 °C, 100 FPU cellulase g⁻¹ substrate and 72 h). Better ethanol yields were obtained with SSF compared with the traditional saccharification and subsequent fermentation (S&F) and when the cellulase was supplemented with β‐glucosidase. © 1999 Society of Chemical Industry     

蒸汽爆破麦草同步糖化发酵转化乙醇的研究

近年来对木质生物资源同步糖化发酵转化乙醇的研究较多,但是,麦草同步糖化发酵转化乙醇的最佳工艺条件还未确定。文中采用正交试验设计的方法,对在混合酶(纤维素酶Celluclast 1.5 1,β-葡萄糖苷酶Novozym 188)与酿酒酵母菌作用下,稀硫酸催化的蒸汽爆破麦草原料同步糖化发酵转化乙醇的工艺条件进行研究,详细讨论了反应温度、底物质量浓度、发酵液pH值、纤维素酶浓度对乙醇质量浓度和得率的影响。结果表明,工艺条件对乙醇质量浓度和得率的影响程度由高到低依次为:底物质量浓度、纤维素酶浓度、发酵液pH值、反应温度。最佳工艺条件为反应温度35℃,底物质量浓度100 g/L,发酵液pH值5.0,纤维素酶浓度30 FPU/g。在此条件下,随着反应时间的延长,乙醇质量浓度持续上升。反应72 h后,乙醇质量浓度和得率分别达到22.7 g/L和65.8%。