LC–MS/MS multi-method for mycotoxins after single extraction,with validation data for peanut,pistachio, wheat,maize, cornflakes,raisins and figs

Mycotoxin analysis is usually carried out by high performance liquid chromatography after immunoaffinity column cleanup or in enzyme-linked immunosorbent assay tests. These methods normally involve determination of single compounds only. EU legislation already exists for the aflatoxins, ochratoxin A and patulin in food, and legislation will come into force for deoxynivalenol, zearalenone and the fumonisins in 2007. To enforce the various legal limits, it would be preferable to determine all mycotoxins by routine analysis in different types of matrices in one single extract. This would also be advantageous for HACCP control purposes. For this reason, a multi-method was developed with which 33 mycotoxins in various products could be analysed simultaneously. The mycotoxins were extracted with an acetonitrile/water mixture, diluted with water and then directly injected into a LC–MS/MS system. The mycotoxins were separated by reversed-phase HPLC and detected using an electrospray ionisation interface (ESI) and tandem MS, using MRM in the positive ion mode, to increase specificity for quality control. The following mycotoxins could be analysed in a single 30-min run: Aflatoxins B₁, B₂, G₁ and G₂, ochratoxin A, deoxynivalenol, zearalenone, T-2 toxin, HT-2 toxin, α-zearalenol, α-zearalanol, β-zearalanol, sterigmatocystin, cyclopiazonic acid, penicillic acid, fumonisins B₁, B₂ and B₃, diacetoxyscirpenol, 3- and 15-acetyl-deoxynivalenol, zearalanone, ergotamin, ergocornin, ergocristin, α-ergocryptin, citrinin, roquefortin C, fusarenone X, nivalenol, mycophenolic acid, alternariol and alternariol monomethyl ether. The limit of quantification for the aflatoxins and ochratoxin A was 1.0 µg kg^?1 and for deoxynivalenol 50 µg kg^?1. The quantification limits for the other mycotoxins were in the range 10–200 µg kg^?1. The matrix effect and validation data are presented for between 13 and 24 mycotoxins in peanuts, pistachios, wheat, maize, cornflakes, raisins and figs. The method has been compared with the official EU method for the determination of aflatoxins in food and relevant FAPAS rounds. The multi-mycotoxin method has been proven by the detection of more than one mycotoxin in maize, buckwheat, figs and nuts. The LC–MS/MS technique has also been applied to baby food, which is subject to lower limits for aflatoxin B₁ and ochratoxin A, ergot alkaloids in naturally contaminated rye and freeze-dried silage samples.     

LC-MS/MS multi-method for mycotoxins after single extraction, with validation data for peanut, pistachio, wheat, maize, cornflakes, raisins and figs

Mycotoxin analysis is usually carried out by high performance liquid chromatography after immunoaffinity column cleanup or in enzyme-linked immunosorbent assay tests. These methods normally involve determination of single compounds only. EU legislation already exists for the aflatoxins, ochratoxin A and patulin in food, and legislation will come into force for deoxynivalenol, zearalenone and the fumonisins in 2007. To enforce the various legal limits, it would be preferable to determine all mycotoxins by routine analysis in different types of matrices in one single extract. This would also be advantageous for HACCP control purposes. For this reason, a multi-method was developed with which 33 mycotoxins in various products could be analysed simultaneously. The mycotoxins were extracted with an acetonitrile/water mixture, diluted with water and then directly injected into a LC-MS/MS system. The mycotoxins were separated by reversed-phase HPLC and detected using an electrospray ionisation interface (ESI) and tandem MS, using MRM in the positive ion mode, to increase specificity for quality control. The following mycotoxins could be analysed in a single 30-min run: Aflatoxins B1, B2, G1 and G2, ochratoxin A, deoxynivalenol, zearalenone, T-2 toxin, HT-2 toxin, alpha-zearalenol, alpha-zearalanol, beta-zearalanol, sterigmatocystin, cyclopiazonic acid, penicillic acid, fumonisins B1, B2 and B3, diacetoxyscirpenol, 3- and 15-acetyl-deoxynivalenol, zearalanone, ergotamin, ergocornin, ergocristin, alpha-ergocryptin, citrinin, roquefortin C, fusarenone X, nivalenol, mycophenolic acid, alternariol and alternariol monomethyl ether. The limit of quantification for the aflatoxins and ochratoxin A was 1.0 microg kg(-1) and for deoxynivalenol 50 microg kg(-1). The quantification limits for the other mycotoxins were in the range 10-200 microg kg(-1). The matrix effect and validation data are presented for between 13 and 24 mycotoxins in peanuts, pistachios, wheat, maize, cornflakes, raisins and figs. The method has been compared with the official EU method for the determination of aflatoxins in food and relevant FAPAS rounds. The multi-mycotoxin method has been proven by the detection of more than one mycotoxin in maize, buckwheat, figs and nuts. The LC-MS/MS technique has also been applied to baby food, which is subject to lower limits for aflatoxin B1 and ochratoxin A, ergot alkaloids in naturally contaminated rye and freeze-dried silage samples.     

LC-MS/MS multi-method for mycotoxins after single extraction, with validation data for peanut, pistachio, wheat, maize, cornflakes, raisins and figs.

Mycotoxin analysis is usually carried out by high performance liquid chromatography after immunoaffinity column cleanup or in enzyme-linked immunosorbent assay tests. These methods normally involve determination of single compounds only. EU legislation already exists for the aflatoxins, ochratoxin A and patulin in food, and legislation will come into force for deoxynivalenol, zearalenone and the fumonisins in 2007. To enforce the various legal limits, it would be preferable to determine all mycotoxins by routine analysis in different types of matrices in one single extract. This would also be advantageous for HACCP control purposes. For this reason, a multi-method was developed with which 33 mycotoxins in various products could be analysed simultaneously. The mycotoxins were extracted with an acetonitrile/water mixture, diluted with water and then directly injected into a LC-MS/MS system. The mycotoxins were separated by reversed-phase HPLC and detected using an electrospray ionisation interface (ESI) and tandem MS, using MRM in the positive ion mode, to increase specificity for quality control. The following mycotoxins could be analysed in a single 30-min run: Aflatoxins B1, B2, G1 and G2, ochratoxin A, deoxynivalenol, zearalenone, T-2 toxin, HT-2 toxin, alpha-zearalenol, alpha-zearalanol, beta-zearalanol, sterigmatocystin, cyclopiazonic acid, penicillic acid, fumonisins B1, B2 and B3, diacetoxyscirpenol, 3- and 15-acetyl-deoxynivalenol, zearalanone, ergotamin, ergocornin, ergocristin, alpha-ergocryptin, citrinin, roquefortin C, fusarenone X, nivalenol, mycophenolic acid, alternariol and alternariol monomethyl ether. The limit of quantification for the aflatoxins and ochratoxin A was 1.0 microg kg(-1) and for deoxynivalenol 50 microg kg(-1). The quantification limits for the other mycotoxins were in the range 10-200 microg kg(-1). The matrix effect and validation data are presented for between 13 and 24 mycotoxins in peanuts, pistachios, wheat, maize, cornflakes, raisins and figs. The method has been compared with the official EU method for the determination of aflatoxins in food and relevant FAPAS rounds. The multi-mycotoxin method has been proven by the detection of more than one mycotoxin in maize, buckwheat, figs and nuts. The LC-MS/MS technique has also been applied to baby food, which is subject to lower limits for aflatoxin B1 and ochratoxin A, ergot alkaloids in naturally contaminated rye and freeze-dried silage samples.     

Mycotoxin occurrence in feed and feed raw materials worldwide: long‐term analysis with special focus on Europe and Asia

During an 8‐year period, 17 316 samples of feed and feed raw materials from all over the world were analysed for contamination with aflatoxins, ochratoxin A, zearalenone, deoxynivalenol and fumonisins. Overall, 72% of the samples tested positive for at least one mycotoxin and 38% were found to be co‐contaminated. Mycotoxin concentrations were generally low and the majority of the samples were compliant with the most stringent EU guidance values or maximum levels for mycotoxins in feed. However, in their present state these regulations do not address co‐contamination and associated risks. Long‐term trends are difficult to establish as strong yearly variations were observed regarding mycotoxin prevalence and contamination levels. In some cases unusual weather conditions can be linked with high observed mycotoxin loads. An exception to this rule is South‐East Asia, where a steady increase of aflatoxin prevalence has been observed. The percentage of aflatoxin‐positive samples in this region rose from 32% in 2005 to 71% in 2011. © 2013 Society of Chemical Industry     

Presence of mycotoxins in sorghum and intake estimation in Tunisia

Sorghum samples (n = 60) from Tunisian markets were analysed for the occurrence of 22 of both traditional and emerging mycotoxins. Samples were extracted with a QuEChERS-like method and mycotoxins were detected by LC-MS/MS. This method was validated and adequate analytical parameters were obtained. All samples had contamination with mycotoxins and several samples had higher contamination levels than European Union legislative limits (MLs). The most frequently found mycotoxins were ENB (100%), OTA (98%), ENA₁ (63%), ENB₁ (56%), BEA (48%), AFB1 (38%) and STG (33%). Mean contaminations were 30.7, 1.93, 33.2, 51.0, 15.4, 1.49 and 20.5 µg kg^–1, respectively. While two samples were contaminated with FB2 and FB3 at mean values of 16.2 and 45.9 µg kg^–1, respectively, one sample was contaminated with AFB2 and ZEA at levels of 0.82 and 45.0 µg kg^–1, respectively. The results were used to estimate the daily intake of mycotoxins through sorghum consumption with regard to normal consumers (low-risk population) and high consumers such as babies (high-risk consumers) who are facing an alarming situation.     

Mycotoxins in corn and wheat silage in Israel

Silage is an important feed source for intensive dairy herds worldwide. Fungal growth and mycotoxin production before and during silage storage is a well-known phenomenon, resulting in reduced nutritional value and a possible risk factor for animal health. With this in mind, a survey was conducted to determine for the first time the occurrence of mycotoxins in corn and wheat silage in Israel. A total of 30 corn and wheat silage samples were collected from many sources and analysed using a multi-mycotoxin method based on LC-MS/MS. Most mycotoxins recorded in the present study have not been reported before in Israel. Overall, 23 mycotoxins were found in corn silage; while wheat silage showed a similar pattern of mycotoxin occurrence comprising 20 mycotoxins. The most common post-harvest mycotoxins produced by the Penicillium roqueforti complex were not found in any tested samples, indicative of high-quality preparation and use of silage. Moreover, none of the European Union-regulated mycotoxins – aflatoxin B1, ochratoxin, T-2 toxin, diacetoxyscirpenol and deoxynivalenol – were found above their limits of detection (LODs). The Alternaria mycotoxins – macrosporin, tentoxin and alternariol methyl ether – were highly prevalent in both corn and wheat silage (>80%), but at low concentrations. The most prominent (>80%) Fusarium mycotoxins in corn silage were fusaric acid, fumonisins, beauvericin, monilifomin, equisetin, zearalenone and enniatins, whereas in wheat silage only beauvericin, zearalenone and enniatins occurred in more than 80% of the samples. The high prevalence and concentration of fusaric acid (mean = 765 µg kg^–1) in Israeli corn silage indicates that this may be the toxin of highest potential concern to dairy cow performance. However, more data from different harvest years and seasons are needed in order to establish a more precise evaluation of the mycotoxin burden in Israeli silage.     

Occurrence of emerging mycotoxins in cereals and cereal-based products from the Korean market using LC-MS/MS

The present study aimed to investigate the occurrence of emerging mycotoxins in cereals (n = 61) and cereal-based products (n = 36) collected from Korean market. First of all, using the quick, easy, cheap, effective, rugged and safe (QuEChERS) extraction method, and ultrahigh-pressure liquid chromatography (UPLC) with triple quadruple tandem mass spectrometry (MS/MS), we developed a simple and fast method for quantitative determination of eight emerging mycotoxins including alternariol (AOH), alternariol monomethyl ether (AME), tentoxin (TEN), beauvericin (BEA) and enniatins (ENs; ENA, ENA1, ENB and ENB1). The developed analytical method was validated in parameters of linearity, precision and accuracy. For UPLC-MS/MS analysis, the recoveries of emerging mycotoxins from spiked samples at three concentration levels ranged from 82.7% to 108.8% with RSDs between 0.4% and 14.7%. Analytical methods were applied to determine the contamination of mycotoxins in cereal and cereal-based product samples. Sixty-three of the total 97 samples were contaminated with at least one emerging mycotoxin. The maximum number of emerging mycotoxins observed in a single sample was six out of eight analytes. The highest level of contamination was detected in cereal at 70.9 μg/kg for alternariol monomethyl ether (AME). However, currently there is no international standard for emerging mycotoxins in food. Accordingly, it is necessary to establish a database of emerging mycotoxins contamination through continuous monitoring.     

Aflatoxins and heavy metals in animal feed in Iran

The occurrence of aflatoxin (aflatoxin B₁, aflatoxin B₂, aflatoxin G₁ (AFG₁) and aflatoxin G₂ (AFG₂)) and heavy metal (Pb, Cd, As and Hg) contamination was determined in 40 industrially produced animal feed samples which were collected from the southwest of Iran. The results indicated that 75% of samples were contaminated by four aflatoxins and the level of AFB₁ and sum of aflatoxins were higher than the permissible maximum levels in Iran (5 and 20 µg kg^?1, respectively) in all feed samples. A positive correlation was found between four types of aflatoxins in all the tested samples (p < 0.01) and the positive correlation between AFG₁ and AFG₂ was significant (r² = 0.708). All feed samples had lead concentrations lower than the maximum EU limit, while 5%, 17% and 42.5% of feed samples had As, Cd and Hg concentrations higher than the maximum limits, respectively.     

Determination of moulds and mycotoxins in dry dog and cat food using liquid chromatography with mass spectrometry and fluorescence detection

In this study moulds and 12 mycotoxins in dry pet food samples (25 for dogs and 24 for cats) were determined. Primary moulds identified were Aspergillus, Mucor and Penicillium, found in 55% of the samples. Deoxynivalenol and zearalenone (ZEN) were detected in all samples with mean respective concentrations being 97.3 and 38.3 µg kg^?1 in cat food and 114 and 20.1 µg kg^?1 in dog food. T-2 and HT-2 toxins were present in 88% and 84% of the samples, respectively. Two samples contained fumonisins, with a maximum concentration of 108 µg kg^?1. Aflatoxin B₁ and ochratoxin A were detected in 8% and 45% of the samples, respectively. The measured mould and mycotoxin levels were consistent with results obtained by other studies. However, potential exposure to relatively high concentrations of an oestrogen mycotoxin as is ZEN, especially when in combination with other mycotoxins, needs attention.     

Multimycotoxin and fungal analysis of maize grains from south and southwestern Ethiopia

The natural occurrence of fungi, mycotoxins and fungal metabolites was investigated in 100 samples of maize grains collected from south and southwestern Ethiopia in 2015. The maize samples were contaminated by Fusarium, Aspergillus and Penicillium species. Using liquid chromatography tandem mass spectrometry 127 secondary metabolites were analysed. Zearalenone was the most prevalent mycotoxin, occurring in about 96% of the samples. Zearalenone sulfate was the second most prevalent, present in 81% of the samples. Fumonisin B1 was detected in 70% of the samples with a mean level of 606 μg kg^?1 in positive samples, while FB2, FB3 and FB4 were detected in 62%, 51% and 60% of the maize samples with mean levels of 202, 136 and 85 μg kg^?1, respectively. Up to 8% of the samples were contaminated with aflatoxins, with a maximum level of aflatoxin B1 of 513 μg kg^?1. Results were higher than earlier reports for maize from Ethiopia.     

Co-occurrence of mycotoxins in maize and maize-derived food in China and estimation of dietary intake

ABSTRACT

A total of 576 samples marketed in China, including maize, maize flour, maize grits and maize meal, was determined for the simultaneous presence of 12 mycotoxins (FB₁, FB₂, FB₃, DON, 3-DON, 15-DON, ZEN, AFB₁, AFB₂, AFG₁, AFG₂ and OTA) using a validated UPLC-MS/MS for multi-mycotoxin method. DON were the most widespread mycotoxins (63%), followed by FB₁ (57%) and ZEN (46%). 78% of the samples was contaminated with at least one of these mycotoxins. Risk assessment indicated that maize and maize-derived food intake does not pose a potential risk for general adult population with respect to individual mycotoxin. However, two or more mycotoxins were detected in 60% of all samples, and a combination of up to seven different mycotoxins was found. A particular attention should be paid to the combined exposure of mycotoxins, in this cases the estimated daily intake might increase greatly due to the high frequency of co-occurrence.     

Occurrence of Aflatoxin M1 in raw and processed milk and assessment of daily intake in Lahore,Multan cities of Pakistan

In this survey aflatoxin, M₁ was quantified in raw and processed milk from various areas of two big cities of Punjab province, i.e. Lahore and Multan. The results indicated that approximately 90% of the raw milk samples collected from Lahore city was contaminated with aflatoxin M₁. Similarly, around 92% of the raw milk samples collected from Multan city was contaminated with aflatoxin M₁. All samples of processed milk and tea whiteners were contaminated and 56% of the contaminated processed milk samples and 66% of the contaminated tea whitener samples were violating the maximum limits. The dietary exposure data of AFM₁ among six different groups was calculated, which indicated that the male children population was the most vulnerable group to AFM₁, up to 6.68 ng L^?1 per day and the least affected one was the female group above 20 years of age with 1.13 ng L^?1 per day.     

Co-occurrence of aflatoxin B1, fumonisin B1, ochratoxin A and zearalenone in cereals and peanuts from C?te d'Ivoire.

This survey examined 30 samples of rice (n = 10), maize (n = 10) and peanuts (n = 10) from C?te d'Ivoire for aflatoxin B1, fumonisin B1 and zearalenone using immunoassays, and ochratoxin A using a validated HPLC method with fluorescence detection. In C?te d'Ivoire, as in other countries, several mycotoxins are present in the same commodities. These mycotoxins are from different structural families: aflatoxin B1, fumonisin B1, zearalenone and ochratoxin A, normally produced by fungal species from Aspergillus, Penicillium and Fusarium genera. Some samples contained four mycotoxins (86%). Four peanuts samples did not show ochratoxin A (14%), whereas they contained aflatoxin B1 concentrations above the EU regulatory limits. Concentrations of ochratoxin A, zearalenone and fumonisin B1 were low and may not cause problems per se; however, fears remain that the tolerable daily intake may be exceeded due to eating habits and synergistic effects could be important with the combination of several mycotoxins. Investigations in this direction are underway, together with isolation and characterization of the fungal species involved.     

Application of an HPLC–MS/MS method for mycotoxin analysis in commercial baby foods

This article describes the validation of an analytical method for the detection of 21 mycotoxins in baby food. The analytical method is based on the simultaneous extraction of selected mycotoxins by matrix solid-phase dispersion (MSPD) followed by liquid chromatography coupled with tandem mass spectrometry (LC–MS/MS) using a hybrid triple quadrupole-linear ion trap mass spectrometer (QTRAP®). Information Dependent Acquisition (IDA), an extra confirmation tool for samples that contain the selected mycotoxins, was used. The matrix effects were evaluated, and the corrections for the matrix effects were performed using two calibration approaches: external matrix-matched calibration and internal standard calibration. Matrix-matched calibration was ultimately used for accurate quantification, and the recoveries obtained were generally higher than 70%. The analytical method was applied to the analysis of 35 samples of commercial baby foods. No sample exceeded the maximum limit (ML) fixed by the European Union for these mycotoxins in baby food. However, this survey highlighted the occurrence of mycotoxins in cereal-based infant foods.     

Assessment of exposure of broiler chicken in Brazil to mycotoxins through naturally contaminated feed

The objective of the present study was to assess the degree of exposure of broiler chicken to mycotoxins through naturally contaminated feed and the hygienic quality of feeds. For this purpose the total fungal count and occurrence of fumonisins and aflatoxins were evaluated in four feed types intended for broilers (n?=?158), collected from a poultry breeding farm in northern Paraná State, Brazil. In most feed samples (94 % pre-starter, 91 % starter, 99 % grower and 97 % finisher feeds) the total mould and yeast counts were below 1.0?×?10⁴ CFU/g, the maximum limit established to assure a good hygienic quality of the product. Fumonisins were detected in 94.9 % feed samples at mean levels ranging from 0.52 mg/kg (finisher) to 0.68 mg/kg (pre-starter and grower), while aflatoxins were detected in 72.1 % feed samples at mean levels ranging from 0.0022 mg/kg (pre-starter) to 0.0064 mg/kg (grower). The maximum estimated daily intake of fumonisin B₁ for broilers (0.057 mg/kg body weight/day) was below the Lowest Observed Adverse Effect Level (2 mg/kg bw/day). Concerning aflatoxins, most of the positive samples (97 %) showed aflatoxin levels below the maximum limit allowed by the European Commission 0.02 mg aflatoxin B₁/kg. Nevertheless, a rigorous monitoring program of the feed producing chain is essential in order to minimize human health hazards. To our knowledge, this is the first report on the degree of exposure of broilers to mycotoxins through naturally contaminated feed in Brazil.     

Aflatoxins in sunflower seeds and unrefined sunflower oils from Singida,Tanzania

A total of 61 samples comprising sunflower seeds (40) and unrefined sunflower oils (21) samples collected randomly from Singida, Tanzania were analysed by Reverse Phase-high performance liquid chromatography (RP-HPLC). 15% (6/40) of the seed samples were contaminated with aflatoxin B₁ ranging from limit of detection (LOD) to 218 ng g^?1 with three of them exceeding the European Commission/European Union (EC/EU) and Tanzania Bureau of Standards (TBS)/Tanzania Food and Drug Authority (TFDA) maximum limits of 2 ng g^?1 for AFB₁ in oilseeds. The levels of total aflatoxins (AFT) in seeds ranged from LOD to 243 ng g^?1. Other aflatoxins, except AFG₂, were also detected. For the unrefined sunflower oils, the levels of AFB₁ ranged from LOD to 2.56 ng mL^?1. About 80.9% (17/21) of the analysed oil samples contained AFB₁ of which 17.65% (3/17) exceeded the EC/EU and TBS/TFDA maximum limits of 2 ng mL^?1. Other aflatoxins were also detected in the oils. The measured levels indicate there is a need for food quality education among food processors.     

尼日利亚纳萨拉瓦州市售灌木芒果、腰果、秋葵、芝麻和高粱的真菌毒素污染情况研究（网络首发、推荐阅读）

采用LC-MS/MS真菌毒素检测法,对尼日利亚纳萨拉瓦州市场出售的食物作物（灌木芒果（n=12）、烤腰果（n=12）、干秋葵（n=12）、芝麻（n=35）、高粱（n=36））进行了分析研究。结果显示具致肝癌性黄曲霉毒素B1在灌木芒果、干秋葵和高粱样品中检出率分别为42%、25% 和19%,其平均浓度分别为19.2、8.27和4.75 µg/kg,伏马毒素B1污染了9%的芝麻样品（平均浓度为12.5 µg/kg）和47%的高粱样品（平均浓度为461 µg/kg）;同时受到黄曲霉毒素 B1和伏马毒素B1污染的高粱样本至少有19%。灌木芒果、高粱和干秋葵中检测到了具致肾毒性的赭曲霉毒素A,这是首次在干秋葵中报道检测到该毒素。可见,当地市场出售的这些食物作物受到真菌毒素的污染,可能威胁消费者的健康,需要采取积极措施防控污染。     

The Fate of Mycotoxins During the Processing of Wheat for Human Consumption

Mycotoxins are a potential health threat in cereals including wheat. In the European Union (EU), mycotoxin maximum levels are laid down for cereal raw materials and final food products. For wheat and wheat‐based products, the EU maximum levels apply to deoxynivalenol (DON), zearalenone, aflatoxins, and ochratoxin A. This review provides a comprehensive overview on the different mycotoxins and their legal limits and on how processing of wheat can affect such contaminants, from raw material to highly processed final products, based on relevant scientific studies published in the literature. The potential compliance with EU maximum levels is discussed. Of the four mycotoxins regulated in wheat‐based foods in the EU, most data are available for DON, whereas aflatoxins were rarely studied in the processing of wheat. Furthermore, available data on the effect of processing are outlined for mycotoxins not regulated by EU law—including modified and emerging mycotoxins—and which cover DON derivatives (DON‐3‐glucoside, mono‐acetyl‐DONs, norDONs, deepoxy‐DON), nivalenol, T‐2 and HT‐2 toxins, enniatins, beauvericin, moniliformin, and fumonisins. The processing steps addressed in this review cover primary processing (premilling and milling operations) and secondary processing procedures (such as fermentation and thermal treatments). A special focus is on the production of baked goods, and processing factors for DON in wheat bread production were estimated. For wheat milling products derived from the endosperm and for white bread, compliance with legal requirements seems to be mostly achievable when applying good practices. In the case of wholemeal products, bran‐enriched products, or high‐cereal low‐moisture bakery products, this appears to be challenging and improved technology and/or selection of high‐quality raw materials would be required.     

Survey of roasted street-vended nuts in Sierra Leone for toxic metabolites of fungal origin

Consumption of mycotoxin contaminated foodstuffs is common in regions where foods are not adequately controlled and routinely monitored, and this could have adverse effects on the health of consumers. In this study, 100 samples of roasted nuts (50 cashew nuts and 50 peanuts) vended within two cities of Sierra Leone were analysed for mycotoxins and other microbial metabolites by a LC-MS/MS method. The peanut samples contained detectable levels of 17 microbial metabolites, including aflatoxins B₁, B₂, G₁ and G₂ and alternariol, while none of these metabolites were found in the cashew samples. Aflatoxins (max: 5,729 μg/kg; mean: 487.8 μg/kg) and alternariol (3 μg/kg) were found in 24% and 2% of the peanut samples, respectively. One-third of the aflatoxin-contaminated peanut samples contained aflatoxins at levels exceeding the total aflatoxin limit of 4 μg/kg set by the European Union. Aflatoxin contamination of Sierra Leonean peanuts is high and requires urgent intervention to reduce consequent exposure.     

Mycotoxin contamination of sorghum and its contribution to human dietary exposure in four sub-Saharan countries

This research aimed at evaluating the safety, and the type, level and prevalence of mycotoxins in grain sorghum of four sub-Saharan African (SSA) countries (Burkina Faso, Ethiopia, Mali and Sudan). A multi-analyte LC-MS/MS method for quantification of 23 mycotoxins (nivalenol, deoxynivalenol, fusarenon X, neosolaniol, 3-acetyl deoxynivalenol, 15-acetyl deoxynivalenol, diacetoxyscirpenol, roquefortine C, HT-2 toxin, alternariol, T-2 toxin, FB1, FB2, FB3, zearalenone, aflatoxin G₁, aflatoxin G₂, aflatoxin B₁, aflatoxin B₂, sterigmatocystin, OTA, altenuene, alternariol monomethylether) was applied to different sorghum matrices. Of the 1533 analysed samples, 33% were contaminated with at least one of the following mycotoxins: aflatoxins, fumonisins, sterigmatocystin, Alternaria toxins, OTA and zearalenone. Country of origin, colour, source and collection period of sorghum samples significantly influenced the type, level and prevalence of mycotoxins. Sterigmatocystin (15%), fumonisins (17%) and aflatoxins (13%) were the most prevalent. FB1 (274 ± 585 µg/kg) had the highest mean concentration followed by FB2 (214 ± 308 µg/kg) while diacetoxyscirpenol (8.12 ± 19.2 µg/kg) and HT-2 (11.9 ± 0.00 µg/kg) had the lowest concentrations. Neosolaniol, fusarenon-X, 3-acetyl deoxynivalenol, 15-acetyl deoxynivalenol, T-2 toxin, nivalenol and roquefortine C were not detected in any of the samples. Sudan had the lowest prevalence and mean concentration of all mycotoxins. Pink sorghum had the highest concentrations of fumonisins and aflatoxins. Mycotoxins from Aspergillus spp. and Alternaria spp. are the mycotoxins of concern in SSA grain sorghum with regard to prevalence, concentration and possible health risk from exposure. Based on the performed risk characterisation, daily consumption of sorghum containing aflatoxins, alternariol, alternariol monomethyl ether, sterigmatocystin and OTA could result in exceeding the established health-based guidance values for these toxins.