Characteristics of Miniature Cheddar‐Type Cheese Made by Microbial Rennet from Bacillus amyloliquefaciens: A Comparison with Commercial Calf Rennet

Miniature Cheddar‐type cheeses were produced using microbial rennet from Bacillus amyloliquefaciens (milk‐clotting enzyme [MCE]) or calf rennet (CAR). With the exception of pH, there were no significant differences in gross composition between MCE‐cheese (MCE‐C) and CAR‐cheese (CAR‐C). The pH value of CAR‐C was significantly higher than that of MCE‐C at 40 and 60 d of ripening. The total nitrogen content of the pH 4.6‐soluble fraction obtained from MCE‐C was higher than that obtained from CAR‐C. However, nitrogen content of the 12% TCA‐soluble fraction was similar between CAR‐C and MCE‐C. The extent of α_s1‐casein and β‐casein hydrolysis, measured by urea‐PAGE, was similar in both cheese samples. The hydrolysis of β‐casein was lower than that of α_s1‐casein. Different reverse phase‐high‐performance liquid chromatography peptide profiles of ethanol‐soluble and ethanol‐insoluble fractions were obtained from CAR‐C and MCE‐C. The peptide content in the 2 cheese samples increased throughout ripening; the ratio of hydrophobic to hydrophilic peptides was lower in MCE‐C than in CAR‐C. Compared with CAR‐C, MCE‐C was softer as a result of higher protein hydrolysis. Microbial rennet from B. amyloliquefaciens contributed to higher proteolytic rates, which reduced ripening time.     

Casein breakdown during ripening of Idiazabal cheese: influence of starter and rennet type

The objective of this work was to determine the effect of starter and rennet type on casein breakdown during Idiazabal cheese ripening. Four batches of cheeses were manufactured with two rennets, commercial calf rennet and artisanal lamb rennet, and the use of natural flora or a commercial starter. Electrophoretic analysis of cheese samples showed six bands identified as α_s1‐, α_s2 + β‐, α_s1‐I‐, γ₁‐, β‐I‐ and para‐κ‐casein. As expected, the casein breakdown during cheese ripening was considerably affected by rennet type and the use of a commercial starter. The artisanal lamb rennet produced a higher hydrolysis of casein fractions than the commercial calf rennet, probably owing to its high percentage of chymosin (around 78%). The effect of addition of starter on proteolysis was dependent on the casein fractions generated by artisanal lamb rennet or commercial calf rennet. © 2000 Society of Chemical Industry     

Characterisation of the casein fraction of Ibérico cheese by electrophoretic techniques

The physicochemical characteristics of Ibérico cheese, a semi‐hard Spanish variety manufactured from mixtures of cow's, ewe's and goat's milk, were studied. The casein fraction and breakdown products of 6‐month‐old cheeses were characterised by various electrophoretic techniques: urea polyacrylamide gel electrophoresis (urea‐PAGE) at alkaline pH, isoelectric focusing (IEF) and two‐dimensional polyacrylamide gel electrophoresis (2DE). Proteins were separated in 2DE according to their charge/mass ratio by urea‐PAGE at alkaline pH in the first dimension and according to their isoelectric point by IEF in the second dimension. Some individual bands considered homogeneous by urea‐PAGE at alkaline pH (ie different grades of phosphorylation of α_s1‐casein and α_s2‐casein) or by IEF (ie overlapping of several bands of α_s2‐casein with γ‐casein bands) were found to be complex mixtures of casein components by 2DE. The two‐dimensional electrophoretic pattern was characteristic of the milk of each animal species included in Ibérico cheese. Capillary electrophoresis (CE) was also used to study the Ibérico cheeses. The high resolution of this technique allowed the identification of the main caseins of the different species (ie para‐κ‐casein, β‐casein, γ₂‐casein and γ₃‐casein). © 2002 Society of Chemical Industry     

Proteolysis texture and microstructure of low‐fat Tulum cheese affected by exopolysaccharide‐producing cultures during ripening

The objective of the study was to determine the effects of exopolysaccharide (EPS)‐producing or non‐EPS‐producing starters on proteolysis, physical and microstructural characteristics of full‐fat or low‐fat Tulum cheeses during ripening. For this purpose, Tulum cheese was manufactured using full‐ or low‐fat milk with EPS‐producing and non‐EPS‐producing starter cultures. Chemical composition, proteolysis, texture profiles and microstructure of the cheeses were studied during 90 days of ripening. Urea‐PAGE of water‐insoluble and RP‐HPLC peptide profiles of water‐soluble fractions of the cheeses showed that the use of starters resulted in different degradation patterns in all cheeses during ripening. Although β‐casein exhibited similar degradation patterns in all cheeses, small differences are present in α_s1‐casein degradation during ripening. Reducing fat in Tulum cheese changed the RP‐HPLC peptide profile of the cheeses. The use of EPS‐producing cultures improved the textural characteristics and changed the microstructure and proteolysis of low‐fat Tulum cheese.     

Use of a new milk-clotting protease from Thermomucor indicae-seudaticae N31 as coagulant and changes during ripening of Prato cheese

Prato cheeses were manufactured using coagulant from Thermomucor indicae-seudaticae N31 or a commercial coagulant. Cheeses were characterised using the following analysis: yield; fat; acidity; moisture; ash; salt; pH; total nitrogen; total protein; NS-pH 4.6/NT*100; NS-TCA 12%/NT*100; casein electrophoresis; and RP-HPLC. The results were statistically analysed and revealed that the proteolytic indices were not significantly different throughout the 60 days of ripening of cheeses made with either coagulant. Even though there were some quantitative differences in the peptide profile of cheeses, the enzyme from T. indicae-seudaticae N31 was used in the production of good quality Prato cheese without having to change the established technological parameters of the process.     

Coalho Cheese Made with Protease from Thermomucor indicae‐seudaticae N31: Technological Potential of the New Coagulant for the Production of High‐Cooked Cheese

The aim of this study was to explore the use of a new coagulant from Thermomucor indicae‐seudaticae N31 for the manufacture of a high‐cooked starter‐free cheese variety, by evaluating its physicochemical and functional characteristics in comparison to cheeses made with a traditional commercial coagulant. Coalho cheese was successfully produced with the new protease as it exhibited comparable characteristics to the one produced using the commercial enzyme: pH behavior during manufacture; cheese composition; protein and fat recovery; and cheese yield. In addition, during storage, melting was low and not affected by storage time; the increase of TCA 12% soluble nitrogen (% of total nitrogen) was lower than half of that of pH 4.6 soluble nitrogen (% of total nitrogen); concentration of β‐CN significantly decreased, whereas α_s1‐CN concentration was not affected by storage time.     

Proteolysis in rennet casein-based cheese analogues

Rennet caseins manufactured from mid- or late-lactation milk were used to prepare pilot- and commercial-scale Mozzarella-type cheese analogues. Mid-lactation rennet casein and analogues made from it contained low levels of plasmin; late-lactation rennet caseins and analogues made from them had higher levels of plasmin while pilot-scale analogues had higher levels of plasmin than commercial-scale analogues. The cheese analogues were stored at 8°C for 32 weeks during which time total bacterial counts increased from ∼10⁴ to 10⁷–10⁸ cfu g⁻¹, with non-starter lactic acid bacteria dominating the microflora. Proteolysis, as reflected by pH 4.6-soluble nitrogen and free amino acids, increased on storage of all the analogues. The increase was greater in the analogues manufactured from late-lactation rennet caseins than in those manufactured from mid-lactation rennet casein and in pilot-scale analogues than in commercial-scale analogues, reflecting the differences in plasmin levels as well as slight differences in composition. Polyacrylamide gel electrophoretograms of the cheese analogues showed that β-casein was hydrolysed more extensively than α_s1-casein and that the concentration of γ-caseins increased on storage. The degree of hydrolysis of β-casein was greater in the cheese analogues manufactured from late-lactation rennet caseins than in those manufactured from mid-lactation rennet casein and in the pilot-scale analogues than in the commercial-scale analogues reflecting the corresponding plasmin levels. Seventeen peptides in the pH 4.6-soluble extract of the cheeses were isolated and partially sequenced; all originated from the N-terminal region of β-casein; 9 peptides had Lys₂₉ of β-casein as the N-terminal, 6 peptides had Arg₁ of β-caesin as the N-terminal and the remaining two peptides had Ile₃₀ and Phe₃₃ of β-casein as the N-terminal, respectively. The pattern of casein hydrolysis in the cheese analogues suggests that plasmin was the primary proteolytic agent contributing to initial hydrolysis of the caseins while microbial proteinases and peptidases may have contributed to the high levels of free amino acids.     

地衣芽孢杆菌凝乳酶对切达干酪成熟过程中蛋白水解的影响

利用地衣芽孢杆菌凝乳酶制作切达干酪和切达干酪类似物,分析干酪成熟过程中各蛋白水解指标的变化规律,以揭示地衣芽孢杆菌凝乳酶对切达干酪成熟过程中蛋白水解的影响。结果表明,CDF组（添加地衣芽孢杆菌D3.11凝乳酶所制切达干酪）、CD3组（添加地衣芽孢杆菌D3.11凝乳酶但未添加发酵剂制成的干酪类似物）和CCF组（添加商品凝乳酶所制切达干酪）干酪蛋白含量、pH 4.6-可溶性氮、12%三氯乙酸-可溶性氮、5%磷钨酸-可溶性氮、总游离氨基酸含量均随着成熟时间延长呈显著增加趋势,并且成熟期间CDF组干酪均显著高于CCF组干酪（P＜0.05）;十二烷基硫酸钠-聚丙烯酰氨凝胶电泳分析表明,CDF组干酪α-酪蛋白水解程度较大;pH 4.6-可溶性肽段分析表明,随着干酪的成熟,总肽含量呈先增加后下降趋势,但疏水性肽与亲水性肽的比值呈持续下降趋势,在成熟第6个月时,CDF组、CD3组和CCF组干酪疏水性肽与亲水性肽比值分别为2.668、2.822、3.788。主成分分析表明,3 组干酪的蛋白水解程度与成熟度呈正相关,与疏水性肽和亲水性肽的比值呈负相关。以上结果表明,利用地衣芽孢杆菌凝乳酶制作的干酪蛋白水解度更高,但其疏水性肽比例较小,研究结果可为地衣芽孢杆菌凝乳酶在干酪生产中的应用提供理论依据。     

Proteolysis during the ripening of goats’ milk cheese made with plant coagulant or calf rennet

Powdered plant coagulant (PPC) obtained from the cardoon (Cynara cardunculus) was compared with calf rennet (CR) for the manufacture of goats’ milk cheese, by determining difference in the proteolysis throughout ripening. There were no substantial differences between the compositions of cheeses made using the two types of coagulants. However, cheeses manufactured with PPC exhibited higher levels of pH 4.6-SN than cheese made using CR. The extent of breakdown of α_s-casein, as measured by urea-PAGE, was greater in cheese made using PPC than cheese made using CR. The formation of hydrophobic peptides and the ratio of hydrophobic/hydrophilic peptides throughout the ripening were higher in cheeses made with PPC than in cheeses made with CR. Principal component analysis (PCA) of peak heights of RP-HPLC peptide profiles of the ethanol-soluble and ethanol-insoluble fractions distributed the samples according to the coagulant used in their manufacture. Quantitative differences in several peptides were evident between the two types of cheese.     

Yield,changes in proteolysis,and sensory quality of Prato cheese produced with different coagulants

The objective of this research was to compare the effect of 2 fungal proteases, one that is already commercially established as a milk-clotting agent and another produced at the laboratory scale, on Prato cheese composition, protein and fat recovery, yield, and sensory characteristics. Cheeses were produced according to the traditional protocol, using protease from the fungus Thermomucor indicae-seudaticae N31 and commercial coagulant from Rhizomucor spp. as clotting agents. A 2 × 6 factorial design with 3 replications was performed: 2 levels of coagulants and 6 levels of storage time. After 5, 12, 19, 33, 43, and 53 d of refrigerated storage (12°C), cheeses were monitored for proteolysis, firmness, and casein degradation by capillary electrophoresis. Sensory acceptance was evaluated after 29 d of manufacturing. The different coagulants did not statistically affect Prato cheese composition, protein and fat recovery, and yield. Both cheeses presented good sensory acceptance. Proteolysis increased and firmness decreased for both cheeses during the storage time, as expected for Prato cheese. Caseins were well separated by capillary electrophoresis and the results showed, with good resolution, that the cheeses exhibited similar protein hydrolysis profile. Both cheeses presented good sensory acceptance. The gathered data showed that the protease from T. indicae-seudaticae N31 presented similar action compared with the commercial enzyme, indicating its efficiency as clotting agent for Prato cheese manufacture.     

Chymosin-mediated proteolysis, calcium solubilization, and texture development during the ripening of cheddar cheese

Full fat, milled-curd Cheddar cheeses (2 kg) were manufactured with 0.0 (control), 0.1, 1.0, or 10.0 μmol of pepstatin (a potent competitive inhibitor of chymosin) added per liter of curds/whey mixture at the start of cooking to obtain residual chymosin levels that were 100, 89, 55, and 16% of the activity in the control cheese, respectively. The cheeses were ripened at 8°C for 180 d. There were no significant differences in the pH values of the cheeses; however, the moisture content of the cheeses decreased with increasing level of pepstatin addition. The levels of pH 4.6-soluble nitrogen in the 3 cheeses with added pepstatin were significantly lower than that of the control cheese at 1 d and throughout ripening. Densitometric analysis of urea-PAGE electro-phoretograms of the pH 4.6-insoluble fractions of the cheese made with 10.0 μmol/L of pepstatin showed complete inhibition of hydrolysis of α_S1-casein (CN) at Phe₂₃-Phe₂₄ at all stages of ripening. The level of insoluble calcium in each of 4 cheeses decreased significantly during the first 21 d of ripening, irrespective of the level of pepstatin addition. Concurrently, there was a significant reduction in hardness in each of the 4 cheeses during the first 21 d of ripening. The softening of texture was more highly correlated with the level of insoluble calcium than with the level of intact α_S1-CN in each of the 4 cheeses early in ripening. It is concluded that hydrolysis of α_S1-CN at Phe₂₃-Phe₂₄ is not a prerequisite for softening of Cheddar cheese during the early stages of ripening. We propose that this softening of texture is principally due to the partial solubilization of colloidal calcium phosphate associated with the para-CN matrix of the curd.     

Compositional,biochemical and textural changes during ripening of Tulum cheese made with different coagulants

In the present study, biochemical, chemical and texture changes in Tulum cheeses made using calf rennet and microbial rennets (Aspergillus niger protease and Rhizomucor miehei protease) were compared during ripening for up to 90 days. A total of 15 free fatty acids (FFAs) were detected in the cheese samples. The peroxide values (PV) of the cheeses increased significantly (P < 0.05) during ripening and the cheese made with calf rennet had the highest PV. Proteolysis in the cheeses increased as the ripening time increased. α_s1‐casein and β‐casein degradation was higher in cheeses manufactured with R. miehei protease. Cheeses made with calf rennet were significantly (P < 0.05) harder, more adhesive, more cohesive and more resilient than those made with microbial rennet.     

Influence of proteolytic Lactococcus lactis subsp. cremoris on ripening of reduced-fat Cheddar cheese made with camel chymosin

This study investigated proteolysis in reduced-fat Cheddar cheese produced with camel chymosin and Lactococcus lactis subsp. cremoris with the ability to cleave the N-terminus of α_S1-casein. The aim was to match the activity of bovine chymosin, which leads to softer cheese structure than camel chymosin. Cheeses were analysed for gross composition, casein and peptide breakdown, release of free amino acids, structure parameters and sensory characteristics. Selected Lc. lactis subsp. cremoris increased the amount of peptides and, to a limited extent, the total amount of free amino acids in the cheeses. One group of experimental cheeses was found to have a significantly firmer structure, higher stress at fracture and modulus of deformability than the reference cheeses. The addition of the selected proteolytic dairy strains of Lc. lactis subsp. cremoris to the cheeses did not result in extended breakdown of α_S1-casein or a softer cheese structure.     

Proteolysis in goat cheese made from raw,pasteurized or pressure-treated milk

Primary and secondary proteolysis of goat cheese made from raw (RA), pasteurized (PA; 72 °C, 15 s) and pressure-treated milk (PR; 500 MPa, 15 min, 20 °C) were examined by capillary electrophoresis, nitrogen fractionation and HPLC peptide profiles. PA milk cheese showed a more important hydrolysis (P<0.05) of α_s1-casein than RA milk cheese at the first stages of ripening (15 days), while PR milk cheese had a level between those seen in PA and RA milk cheeses. Degradation of β-casein was more important (P<0.05) in PA and PR than in RA milk cheeses at 15 days of ripening. However, from thereon β-casein in PR and RA milk cheeses was hydrolyzed at essentially similar rates, but at lower rates (P<0.05) than in PA milk cheeses. Pressure treatment could induce proteolysis of β-casein in a way, which is different from that produced by heat treatment. There was an increase in 4.6-soluble nitrogen (WSN) and in trichloroacetic acid (TCASN) throughout ripening in cheeses, but higher contents (P<0.05) in PA and PR milk cheeses at the end of ripening were observed. PR milk cheeses contained considerably higher content (P<0.05) of free amino acids than RA or PA milk cheeses. In general, heat and pressure treatments had no significant effect on the levels of hydrophobic and hydrophilic peptides.     

Influence of starters on chemical, biochemical, and sensory changes in Turkish White-brined cheese during ripening

Turkish White-brined cheese was manufactured using Lactococcus strains (Lactococcus lactis ssp. lactis NCDO763 plus L. lactis ssp. cremoris SK11 and L. lactis ssp. lactis UC317 plus L. lactis ssp. cremoris HP) or without a starter culture, and ripened for 90 d. It was found that the use of starters significantly influenced the physical, chemical, biochemical, and sensory properties of the cheeses. Chemical composition, pH, and sensory properties of cheeses made with starter were not affected by the different starter bacteria. The levels of soluble nitrogen fractions and urea-PAGE of the pH 4.6-insoluble fractions were found to be significantly different at various stages of ripening. Urea-PAGE patterns of the pH 4.6-insoluble fractions of the cheeses showed that considerable degradation of α_s1-casein occurred and that β-casein was more resistant to hydrolysis. The use of a starter culture significantly influenced the levels of 12% trichloroacetic acid-soluble nitrogen, 5% phosphotungstic acid-soluble nitrogen, free amino acids, total free fatty acids, and the peptide profiles (reverse phase-HPLC) of 70% (vol/vol) ethanol-soluble and insoluble fractions of the pH 4.6-soluble fraction of the cheeses. The levels of peptides in the cheeses increased during the ripening period. Principal component and hierarchical cluster analyses of electrophoretic and chromatographic results indicated that the cheeses were significantly different in terms of their peptide profiles and they were grouped based on the use and type of starter and stage of ripening. Levels of free amino acid in the cheeses differed; Leu, Glu, Phe, Lys, and Val were the most abundant amino acids. Nitrogen fractions, total free amino acids, total free fatty acids, and the levels of peptides resolved by reverse phase-HPLC increased during ripening. No significant differences were found between the sensory properties of cheeses made using a starter, but the cheese made without starter received lower scores than the cheeses made using a starter. It was found that the cheese made with strains NCDO763 plus SK11 had the best quality during ripening. It was concluded that the use of different starter bacteria caused significant differences in the quality of the cheese, and that each starter culture contributed to proteolysis to a different degree.     

The effect of exposure to pressure of 50 MPa on Cheddar cheese ripening

The possibility of acceleration of commercial Cheddar cheese ripening by exposure to a high pressure (HP) treatment of 50 MPa for 3 days at 25°C at different stages of ripening was investigated. Proteolysis was examined in the treated and untreated cheeses by measurement of pH 4.6 water soluble nitrogen, expressed as g/100 g total N (pH 4.6 SN/TN), urea-PAGE, reverse phase (RP) HPLC, analysis of molecular mass distribution by gel permeation and measurement of free amino acids (FAA) in the pH 4.6 SN. There was an immediate increase in pH 4.6 SN/TN and FAA in cheese HP-treated at 2 days of age, although this effect decreased with cheese age. Urea-PAGE analysis of cheese samples indicated that HP treatment accelerated degradation of α_s1-casein and accumulation of α_s1-I-casein (f 24-199). RP-HPLC profiles indicated quantitative but not qualitative differences between treated and non-treated samples. Confocal laser scanning microscopy did not indicate any gross structural changes in the cheese matrix as a result of exposure to 50 MPa for 3 days at 25°C. It was concluded that the enhancement of proteolysis observed may be attributed to a combination of the temperature and pressure used in the treatment.     

Primary proteolysis studied in a cast cheese made from microfiltered milk

Primary proteolysis was studied in a starter-free cheese model made from microfiltered (MF) milk (19.0% casein,<0.2% whey proteins). Specificity of plasmin and chymosin activity was investigated in the pH range 5.0–6.0, by analysis of peptide composition using high-performance liquid chromatography and liquid chromatography–mass spectrometry. Hydrolysis experiments with purified caseins were performed to aid identification of peptides released by specific activities. Plasmin had no activity in cheese below pH 5.4, while its activity increased from pH 5.4 to 6.0. Chymosin activity on the Phe₂₃–Phe₂₄ bond of α_S1-casein had an optimum pH around 5.3, while release of the bitter peptide β-casein (f193–209), effected by chymosin, was highest at pH 6.0. At pH <5.3, the specificity of chymosin on α_S1-casein changed, and the peptide bond Leu₂₀–Leu₂₁ was cleaved at an increasing rate with decreasing pH. Demineralisation of the MF retentate generally increased proteolytic activity.     

Texture Development During Cheese Ripening

The texture of a cheese is determined primarily by its pH and the ratio of intact casein to moisture. The texture generally changes markedly in the first 1 to 2 wk of ripening as the hydrolysis of a small fraction of α_s1-casein by the rennet to the peptide α_s1-I results in a general weakening of the casein network. The relatively slow change in texture thereafter is determined mainly by the rate of proteolysis, which in turn is controlled largely by the proportion of residual rennet and plasmin in the cheese, salt to moisture ratio, and storage temperature. The rise in pH that occurs during ripening is also important in many cheese varieties. Cheese texture may be significantly changed by the use of coagulants other than chymosin, addition of neutral proteases, and incorporation of whey proteins. The stretching characteristics of natural cheese curd depend upon both its pH and the proportion of colloidal calcium phosphate that has been removed. Cheese containing residual coagulant loses stretchability very rapidly with age. Eye formation in Swiss-type cheese is dependent upon the cheese pH at the time of transfer to the hot room.     

Effects of genetic type,stage of lactation,and ripening time on Caciocavallo cheese proteolysis

The objective of this experiment was to evaluate the effects of genetic type, stage of lactation, and ripening time on proteolysis in Caciocavallo cheese. One hundred twenty Caciocavallo cheeses made from the milk of 2 breeds, Italian Brown and Italian Holstein and characterized by different stages of lactation were obtained and ripened for 1, 30, 60, 90, and 150 d. Cheese proteolysis was investigated by ripening index (ratio of water-soluble N at pH 4.6 to total protein, %) and by the study of degradation of the protein fractions (α_S1-, β-, and para-κ-casein), which was determined by densitometric analysis of isoelectric focusing results. The statistical analysis showed a significant effect of the studied factors. Ripening index was higher in Italian Brown Caciocavallo cheese and in cheeses made with early lactation milk, whereas casein solubilization was greater in the first 2 mo of ripening. Isoelectric focusing analysis of cheese samples during ripening showed extensive hydrolysis of caseins. In particular, the protein fraction that underwent major degradation by proteolytic enzymes was α_S1-casein, followed by β-casein, whereas para-κ-casein was less degraded. Italian Brown cheese showed a lower residual quantity of β- and para-κ-casein, whereas Italian Holstein cheese showed a lower residual quantity of α_S1-casein. In addition, significant interactions of both first and second order were found on both ripening index and degradation of protein fractions. This study demonstrated that the analyzed factors influenced proteolysis of Caciocavallo cheese, which forms the basis of new knowledge that could lead to the production of a pasta filata cheese with specific characteristics.