Purification and characterization of olive (Olea europaea L.) peroxidase – Evidence for the occurrence of a pectin binding peroxidase

Peroxidase from olive fruit (Olea europaea L., cv Douro) in a black ripening stage was purified to electrophoretic homogeneity, resulting in four cationic and four anionic fractions. The anionic fractions accounted for 92% of recovered activity and showed molecular masses of 18–20 kDa. The anionic fraction PODa4, the predominant fraction that comprised about 70% of total recovered activity, showed an isoelectric point of 4.4 and optimum pH and temperature of, respectively, 7.0 and 34.7 °C, and apparent K_m values of 41.0 and 0.53 mM, for phenol and H₂O₂, respectively. From the activity-temperature profile, the denaturation temperature and the changes in enthalpy and heat capacity for unfolding of PODa4 were estimated as being, respectively, 36.5 °C, 411.2 and −13.6 kJ mol⁻¹ K⁻¹. The activation energy for phenol oxidation by PODa4 was 99.1 kJ mol⁻¹, corresponding to a calculated temperature coefficient (Q₁₀) of 4. The arabinose (39 mol%) and galacturonic acid (38 mol%) content of the carbohydrate moiety indicated the existence of pectic material in the purified PODa4 fraction. Co-migration of the carbohydrate with the protein band in the isoelectric focusing electrophoresis, points to PODa4 fraction as being a pectin type binding peroxidase.     

Immobilization of naringinase from Aspergillus niger CECT 2088 in poly(vinyl alcohol) cryogels for the debittering of juices

Naringinase, induced from Aspergillus niger CECT 2088 cultures, was immobilized into a polymeric matrix consisting of poly(vinyl alcohol) (PVA) hydrogel, cryostructured in liquid nitrogen, to obtain biocatalytically active beads. The effects of matrix concentration, enzyme load and pH on immobilization efficiency were studied. Between 95% and 108% of the added naringinase was actively entrapped in PVA cryogel, depending on the conditions of immobilization used. The optimal conditions were: 8% (w/v) PVA at pH 7 and 1.6–3.7 U ml⁻¹ of enzyme load. The pH/activity profiles revealed no change in terms of shape or optimum pH (4.5) upon immobilization of naringinase. However, the optimum temperature was shifted from 60 °C to 70 °C and the activation energy of reaction, E_a, was decreased from 8.09 kJ mol⁻¹ to 6.36 kJ mol⁻¹ by immobilization. The entrapped naringinase could be reused through six cycles (runs of 24 h at 20 °C), retaining 36% efficacy for the hydrolysis of naringin in simulated juice.     

Degradation kinetics of anthocyanins in acerola pulp: Comparison between ohmic and conventional heat treatment

Degradation kinetics of monomeric anthocyanins in acerola pulp during thermal treatment by ohmic and conventional heating was evaluated at different temperatures (75–90 °C). Anthocyanin degradation fitted a first-order reaction model and the rate constants ranged from 5.9 to 19.7 × 10⁻³ min⁻¹. There were no significant differences between the rate constants of the ohmic and the conventional heating processes at all evaluated temperatures. D-Values ranged from 116.7 to 374.5 for ohmic heating and from 134.9 to 390.4 for conventional heating. Values of the free energy of inactivation were within the range of 100.19 and 101.35 kJ mol⁻¹. The enthalpy of activation presented values between 71.79 and 71.94 kJ mol⁻¹ and the entropy of activation ranged from −80.15 to −82.63 J mol⁻¹ K⁻¹. Both heating technologies showed activation energy of 74.8 kJ mol⁻¹ and close values for all thermodynamic parameters, indicating similar mechanisms of degradation.     

Neriifolin S, a dimeric serine protease from Euphorbia neriifolia Linn.: Purification and biochemical characterisation

A dimeric serine protease Neriifolin S of molecular mass 94 kDa with milk clotting activity has been purified from the latex of Euphorbia neriifolia by anion exchange and size-exclusion chromatography. It hydrolyses peptidyl substrates l-Ala-pNA with highest affinity (K_m of 0.195 mM) and physiological efficiency (K_cat/K_m of 144.5 mM s). Enzyme belongs to the class of neutral proteases with pI value of 6.8, optimal proteolytic activity displayed at pH 9.5 and temperature 45 °C. Its proteolytic activity is strongly stimulated in the presence of Ca⁺² ions and exclusively inhibited by serine protease inhibitors. Enzyme is fairly stable toward chemical denaturants, pH and temperature. The apparent T_m, was found to be 65 °C. Thermal inactivation follow first order kinetics with activation energy (Ea), activation enthalpy (ΔH∗), free energy change (ΔG∗) and entropy (ΔS∗) of 27.54 kJ mol⁻¹, 24.89 kJ mol⁻¹, −82.34 kJ mol⁻¹ and 337.20 J mol⁻¹ K⁻¹.     

Effects of light,temperature and water activity on the kinetics of lipoxidation in almond-based products

Lipoxidation in almond-derived products was investigated using the chemiluminescence (CL) and thiobarbituric acid-reactive substances (TBARS) methods to detect the first and later reaction products, respectively. The effects of light during storage at 5 °C, 22 °C and 40 °C were studied, as well as the effects of combined heat/water activity treatments in the 60–120 °C and 0.38–0.72 range. During storage, light was found to enhance the CL and TBARS values, and specific responses were observed in almond paste and the final Calisson product. During the heating of almond paste, as the initial water activity (a_w) increased, the CL rate constants increased during heating to 60 °C and 80 °C, but interestingly, these values decreased during further heating to 120 °C, whereas the maximum TBARS rate constants occurred at a_w 0.57 at all the heating temperatures tested. The activation energies, based on the CL and TBARS values, decreased specifically when the a_w increased from 0.38 to 0.72, giving overall values ranging from110 kJ mol⁻¹ to 60 kJ mol⁻¹. Likewise, in the same water activity range, the temperature-dependent rate constant enhancing factor (Q₁₀) decreased from 3.3 to 1.6.     

Effect of thermal blanching and of high pressure treatments on sweet green and red bell pepper fruits (Capsicum annuum L.)

The effect of pressure treatments of 100 and 200 MPa (10 and 20 min) and of thermal blanching at 70 °C, 80 °C and 98 °C (1 and 2.5 min), on sweet green and red bell peppers was compared. Pressure treated peppers showed a lower reduction on soluble protein and ascorbic acid contents. Red peppers presented even an increased content of ascorbic acid (15–20%), compared to the untreated peppers. Peroxidase and pectin methylesterase (whose activity was only quantifiable in green peppers) showed a higher stability to pressure treatments, particularly the latter enzyme, while polyphenol oxidase was inactivated to the same final level by the thermal blanching and pressure treatments. Pressure treatments resulted in comparable (in green pepper) to higher (in red pepper) microbial loads compared to blanching. Pressure treated green and red peppers presented similar to better firmness before and after tunnel freezing at −30 °C, compared to thermally blanched peppers, particularly those blanched at 98 °C. The results indicated that pressure treatments of 100 and 200 MPa can be used to produce frozen peppers with similar to better nutritional (soluble protein and ascorbic acid) and texture (firmness) characteristics, comparable activity of polyphenol oxidase and higher activity of pectin methylesterase, while pressure treated peppers show a higher level of peroxidase activity. It would be interesting to use higher pressures in future studies, as an attempt to cause a higher reduction on microbial load and on enzymatic activity.     

Kinetics of formation of acrylamide and Schiff base intermediates from asparagine and glucose

From the concentration of glucose and asparagine as reactants and of acrylamide as product each determined by LC–MS during reaction in an acetonitrile/water (68:32) model system at pH 7.6 (0.04 M phosphate buffer) and from the relative concentration of the Schiff base intermediate, the decarboxylated Schiff base intermediate, the Amadori product and aminopropionamide determined in the same reaction mixtures at 120 °C, 140 °C, 160 °C and 180 °C for up to 16 min, the energy of activation for formation of the Schiff base intermediate was found to have the value 50 ± 2 kJ mol⁻¹, while the apparent activation energy for formation of acrylamide was 64.4 ± 0.6 kJ mol⁻¹, for formation of the decarboxylated Schiff base intermediate 92 ± 2 kJ mol⁻¹, and for formation of the Amadori compound 59 ± 4 kJ mol⁻¹, respectively. At high temperature conditions, formation of the Schiff base is accordingly rate determining, while at lower temperatures, decarboxylation becomes rate determining. Aminopropionamide was only detected at reaction times at which acrylamide formation already is significant in favor of, a reaction path including direct formation of acrylamide from the decarboxylated Schiff base, rather than including dissociation of ammonia from aminopropionamide.     

Enzyme inactivation kinetics and colour changes in Garlic (Allium sativum L.) blanched under different conditions

The inactivation kinetics of the enzymes peroxidase, polyphenoloxidase and inulinase and changes in the color parameters L^∗, a^∗ and b^∗ of garlic cloves cut in slices, were studied during steam blanching at 100 °C and water at 80 and 90 °C. The garlic cloves were peeled, cut into slices and distributed uniformly in metal baskets and one batch placed in an autoclave generating steam at a temperature of 100 °C; and the others in water baths at 80 and 90 °C. The best blanching conditions were in steam for 4 min, where no changes in texture were observed, and the enzymatic activities were reduced by 93.53%, 92.15% and 81.96% for peroxidase, polyphenoloxidase and inulinase, respectively. Under these conditions the inulin concentration reduced by 3.72%. The color parameter L^∗ increased with increase in blanching time, the samples becoming lighter in color, and the parameters a^∗ and b^∗ decreased, obtaining slices that were greener and bluer.     

Release kinetics of nisin from biodegradable poly(butylene adipate-co-terephthalate) films into water

The release kinetics of nisin from poly(butylene adipate-co-terephthalate) (PBAT) to distilled water was studied at of 5.6, 22 and 40 °C. The release kinetics of nisin from PBAT film was described using Fick’s second law of diffusion, partition coefficient, and Weibull model. The diffusion coefficients (D) determined were 0.93, 2.29, and 5.78 × 10⁻¹⁰ cm²/s at 5.6, 22, and 40 °C, respectively. The partition coefficients (K) calculated were 0.84, 3.89, and 5.2 × 10³ at 5.6, 22, and 40 °C, respectively. The nisin release data at selected temperatures were fitted with the Weibull model (R² > 0.97) with b and n values ranging from 0.02 to 0.98 and from 0.28 to 0.45, respectively. The temperature dependence of D, K, and Weibull model parameter b was modeled using the Arrhenius equation giving values of activation energy (E_a) of 38.3 kJ mol⁻¹ (for D), 38.5 kJ mol⁻¹ (for K), and 79.5 kJ mol⁻¹ (for b).     

Effects of various pretreatments and drying methods on Salmonella resistance and physical properties of cabbage

The combined effects of pretreatment and drying methods on the resistance of Salmonella attached to vegetable surfaces as well as some physical properties, in terms of color and shrinkage, were investigated. Cabbage was used as a test vegetable and Salmonella Anatum was used as a test microorganism. Cabbage leaves were pretreated either by soaking in 0.5% (v/v) acetic acid for 5 min, blanching in hot water for 4 min or blanching with saturated steam for 2 min prior to either hot air drying, vacuum drying (10 kPa) or low-pressure superheated steam drying (10 kPa) at 60 °C. Based on an initial Salmonella contamination level of approximately 6.4 log CFU/g, soaking in acetic acid, hot-water and steam blanching resulted in 1.6, 3.8 and 3.6 log CFU/g reduction in the number of Salmonella, respectively. Drying without pretreatment could not completely eliminate Salmonella attached on the cabbage surfaces, while no Salmonella was detected on the pretreated samples at the end of the drying process. Volumetric shrinkage was not affected by the pretreatment and drying methods. Dried blanched samples exhibited greener and darker color than the dried acetic acid pretreated and untreated samples.     

Kinetic and thermodynamic study of thermal inactivation of the antimicrobial peptide P34 in milk

The knowledge on thermal inactivation of biopreservatives in a food matrix is essential to allow their proper utilisation in food industry, enabling the reduction of heating times and optimisation of heating temperatures. In this work, thermal inactivation of the antimicrobial peptide P34 in skimmed and fat milk was kinetically investigated within the temperature range of 90–120 °C. The inactivation kinetic follows a first-order reaction with k-values between 0.071 and 0.007 min⁻¹ in skimmed milk, and 0.1346 and 0.0119 min⁻¹ in fat milk. At high temperatures, peptide P34 was less resistant in fat milk, with a significant decrease in residual activity as compared with skimmed milk. At temperatures below 110 °C, the fat globules seem to have protective effect to the peptide P34. Results suggest that peptide P34 is heat stable in milk with activation energy of 90 kJ mol⁻¹ in skimmed milk and 136 kJ mol⁻¹ in fat milk.     

Thermal inactivation of lactoperoxidase in goat,sheep and bovine milk – A comparative kinetic and thermodynamic study

Using isothermal heating, inactivation of lactoperoxidase (LPO) in goat, sheep and cow milk was studied in the temperature range of 70–77 °C. Kinetic and thermodynamics studies were carried out at different time–temperature combination in order to evaluate the suitability of LPO as marker for the heat-treatment of milk and dairy products from different species. The thermal inactivation of LPO followed the first-order kinetics. D- and k-values decreased and increased, respectively with increasing temperature, indicating a more rapid LPO inactivation at higher temperatures. The influence of temperature on the inactivation rate constant was quantified using the Arrhenius and thermal death time models. The corresponding z-values were 3.38 ± 0.013, 4.11 ± 0.24 and 3.58 ± 0.004 °C in goat, sheep and cow milk, respectively. Activation energy values varied between milk species with 678.96 ± 21.43 kJ mol⁻¹ in goat milk, 560.87 ± 28.18 kJ mol⁻¹ in sheep milk and 641.56 ± 13.12 kJ mol⁻¹ in cow milk, respectively.     

Properties of polyphenol oxidase from Anamur banana (Musa cavendishii)

Polyphenol oxidase (PPO) was extracted from Anamur banana, grown in Turkey, and its characteristics were studied. The optimum temperature for banana PPO activity was found to be 30 °C. The pH-activity optimum was 7.0. From the thermal inactivation studies, in the range 60–75 °C, the half-life values of the enzyme ranged from 7.3 to 85.6 min. The activation energy (E_a) and Z values were calculated to be 155 kJ mol⁻¹ and 14.2 °C, respectively. K_m and V_max values were 8.5 mM and 0.754 OD₄₁₀ min⁻¹, respectively. Of the inhibitors tested, ascorbic acid and sodium metabisulphite were the most effective.     

Effects of hot-water and steam blanching of sliced potato on polyphenol oxidase activity

The worldwide potato production is considered the fourth-most important food sector due to the increasing use of potatoes as raw materials for high-convenience food. Enzymatic browning, due to polyphenol oxidase (PPO), is related to unacceptability by consumer. Among antibrowning agents, thermal treatments are viable alternatives. In this study, the efficacy of hot-water and steam blanching at 80–90 °C of potato slices (1-cm thick) was evaluated in terms of colour changes as well as PPO inactivation kinetics, substrate specificity and transition state parameters. In general, all treatments [1] bleached the slices, [2] inactivated PPO and [3] reduced its kinetic efficiency. Results from thermal inactivation kinetics promoted hot-water blanching at 90 °C for approx. 2 min as the fastest treatment to obtain enzymatic-stable potato slices. Moreover, steam blanching required more energy (53.93 ± 1.24 kJ mol⁻¹) than hot-water treatment (41.41 ± 4.51 kJ mol⁻¹) to reach the transition state and then to unfold the PPO enzyme.     

Quantification and characterisation of polyphenol oxidase from vanilla bean

Polyphenol oxidase (PPO) of Vanilla planifolia Andrews beans was extracted and purified through ammonium sulphate precipitation, dialysis, and gel filtration chromatography. PPO activity was measured by improved UV technique using 4-methylcatechol and catechol as substrates increasing substantial sensitivity of previous procedure. The optimum pH and temperature for PPO activity were found to be 3.0 and 3.4 and 37 °C, respectively. K_m and V_max values were found to be 10.6 mM/L and 13.9 OD₃₀₀ min⁻¹ for 4-methylcatechol and 85 mM/L and 107.2 OD₃₀₀ min⁻¹ for catechol. In an inhibition test, the most potent inhibitor was found to be 4-hexylresorcinol followed by ascorbic acid. The thermal inactivation curve was biphasic. Activation energy (E_a) and z values were calculated as 92.10 kJ mol⁻¹ and 21 °C, respectively.     

Kinetics of the formation of radicals in meat during high pressure processing

The kinetics of the formation of radicals in meat by high pressure processing (HPP) has been described for the first time. A threshold for the radicals to form at 400 MPa at 25 °C and at 500 MPa at 5 °C has been found. Above this threshold, an increased formation of radicals was observed with increasing pressure (400–800 MPa), temperature (5–40 °C) and time (0–60 min). The volume of activation (ΔV^#) was found to have the value −17 ml mol⁻¹. The energy of activation (E_a) was calculated to be 25–29 kJ mol⁻¹ within the pressure range (500–800 MPa) indicating high independence on the temperature at high pressures whereas the reaction was strongly dependent at atmospheric pressure (E_a = 181 kJ mol⁻¹). According to the effect of the processing conditions on the reaction rate, three groups of increasing order of radical formation were established: (1) 55 °C at 0.1 MPa, (2) 500 and 600 MPa at 25 °C and 65 °C at 0.1 MPa, and (3) 700 MPa at 25 °C and 75 °C at 0.1 MPa. The implication of the formation of radicals as initiators of lipid oxidation under HPP is discussed.     

Polyphenolic content and antioxidant activity of Eugenia pollicina leaf extract in vitro and in model emulsion systems

The polyphenolic profile of a leaf extract of the Mauritian endemic plant, Eugenia pollicina, was assessed as a source of natural antioxidants. The amounts of flavan-3-ol derivatives determined by HPLC, were in the order of (−)-epicatechin (EC) > (−)-epigallocatechin gallate (EGCG) > (+)-catechin (C) > (−)-epicatechin gallate (ECG) with the levels of Procyanidin B2 and B1 dimers ranging from 1 to 3 mg g⁻¹ FW. The trolox equivalent antioxidant capacity and ferric reducing antioxidant power values were 796 ??mol g⁻¹ FW and 302 ??mol g⁻¹ FW respectively. E. pollicina extracts also strongly inhibited the FeCl₃ and ascorbate-dependent microsome lipid peroxidation, a function that is linked to their flavonoid contents. The extent of DNA damage induced by the extract under study in the copper-phenanthroline assay was lower than the effect of a reference of 240 ??M ascorbate. E. pollicina extracts also inhibited lipid autoxidation in the 30% (v/v) olive oil and soybean oil oil-in-water (O/W) emulsions and was effective in slowing down the formation of hydroperoxides in the emulsions during 13 days storage at 40 °C as determined by the peroxide, conjugated diene and para-anisidine values. The high levels of total phenolics, flavonoids and procyanidins measured indicate that E. pollicina is a potential source of antioxidants relevant to the maintenance of oxidative stability of the food matrix, cosmetics and/or pharmaceutical preparations.     

Thin layer drying characteristics of rapeseed (Brassica napus L.)

This study was performed to determine the most appropriate thin layer drying model and the effective moisture diffusivity of rapeseed. The thin layer drying tests were conducted at three different combinations of drying air temperature levels of 40, 50, and 60 °C and relative humidity levels of 30, 45, and 60%. The thin layer drying characteristics of rapeseed were determined. The Page (1949) model was the most adequate model for describing the thin layer drying of rapeseed. Drying occurred in the falling rate period and the rate of moisture removal from rapeseed was governed by the rate of water diffusion to the surface of the seed. Effective moisture diffusivities were calculated based on the diffusion equation for a spherical shape using Fick’s second law. Effective moisture diffusivity during drying varied from 1.72 × 10⁻¹¹ to 3.31 × 10⁻¹¹ m² s⁻¹ over the temperature range. The dependence of moisture diffusivity on temperature was described by an Arrhenius-type equation. The activation energy for moisture diffusion during drying was 28.47 kJ mol⁻¹.     

Water absorption and starch gelatinization in whole rice grain during soaking

Hydration of rough rice grain in hot water as a function of time was studied at temperature range 25-90 °C. A simple model which considers simultaneous unsteady-state water diffusion and first-order irreversible water-starch reaction phenomenon, was used to evaluate the kinetics parameters from experimental curves. The values of the diffusion coefficients and reaction rate constants were between 1.40×10⁻¹¹ and 9.36×10⁻¹¹ m² s⁻¹ and 2.29×10⁻¹⁰ and 3.72×10⁻⁵ s⁻¹, respectively. Both parameters followed a Arrhenius-type equation with distinct activation energies below and above a break temperature of 60 °C. It was 25.4 and 289.3 kJ mol⁻¹ for the activation energies of diffusion and reaction, respectively, below 60 °C. Above this temperature the respective values of the activation energies of diffusion and reaction were 30.0 and 16.6 kJ mol⁻¹. This break temperature was in agreement with the gelatinization temperature determined experimentally.     

Drying kinetics of whole durum wheat pasta according to temperature and relative humidity

Drying kinetics of bran-free and bran-rich pasta (whole durum) was determined according to temperature (40, 60 or 80 °C) and relative humidity (65%, 75% or 85%). Compared to temperature, relative humidity in drying chamber had a greater effect on pasta effective moisture diffusivity (α<0.01), and both parameters responded to a modified Arrhenius-type equation. Activation energy of pasta (11.4 kJ mol⁻¹) was lower than reported in the literature. Bran changed the course of pasta drying, depending on temperature and relative humidity. When relative humidity was higher than 75%, effective moisture diffusivity of bran-rich pasta decreased but the reverse was observed below 75%. Above 76 °C, equilibrium moisture content of bran-rich pasta was higher than bran-free pasta. In conclusion, optimal drying conditions for bran-rich pasta were different than standard (bran-free) pasta. Close control of relative humidity in pasta drying unit would be critical, especially under high relative humidity and high temperature conditions.