酶法改性提高全蛋粉起泡性能的研究

为提高全蛋粉的起泡性能,利用中性蛋白酶酶解全蛋液,采用响应面法建立了酶解改性提高全蛋粉起泡性能的二次回归模型,并验证了该模型的有效性,探讨了酶解温度、酶解时间、酶添加量三因素对全蛋粉起泡力(FA)和泡沫稳定性(FS)的影响,同时分析比较了改性前后全蛋粉的微观结构和分子量变化。结果表明最适改性条件为:酶解温度42℃,酶解时间90min,酶添加量1120u/g;与未改性全蛋粉相比,酶解改性后的全蛋粉FA从62.96%提高到77.36%,FS从20.67%提高到37.54%。      

Effect of milk homogenisation and foaming temperature on properties and microstructure of foams from pasteurised whole milk

Differently homogenised and HTST-heated milk (3.5% fat) was foamed at temperatures between 4 and 60 °C. Foaming was achieved by air injection through fritted glass. Initial foam density, drainage and corresponding bubble size were analysed. Transmission electron microscopic (TEM) images completed the study. The studies showed that whole milk was better foamable between 50 and 60 °C than at lower temperatures. This was mainly due to the completely liquid milk fat and the increased protein adsorption at the air-serum interface. The resulting bubbles of these two foams maintained their spherical shape also for 20 min of draining. However, the average bubble diameter and the drainage mass in relation to the initial foam mass increased from about 20 g/100 g after 1 min to about 80 g/100 g after 20 min. It was surprising to learn that milk homogenisation and corresponding fat globule size had only marginal effect on foam formation and stability. TEM images suggested that the air-serum interface consisted mainly of protein monomers and oligomers, while casein micelles were not directly adsorbed. The membrane of the homogenised fat globules was destroyed near the interface and coalesced liquid fat formed a restricted film on the bubble that was obviously of minor importance for the foam properties.     

Effect of heat treatments and homogenisation pressure on the acid gelation properties of recombined whole milk

The homogenisation pressure and the order of heating and homogenisation were varied in the preparation of recombined whole milks. The fat globule sizes decreased from ∼2 to 0.2 μm as the homogenisation pressure increased from 50 to 850 bar for samples heated before (HEHO) or after (HOHE) homogenisation. For acid gels prepared from the milks, small increases in elastic modulus of the set gels were observed with decreasing fat globule size. The yield strain of the acid gels increased linearly with decreasing fat globule size, and HOHE gels had higher yield strains than HEHO gels. The yield stress of the set gels increased with decreasing fat globule size, and the yield stress for HOHE gels were higher than the HEHO gels. Confocal micrographs of the gels revealed an almost continuous protein network structure without pores for gels from milks treated at low homogenisation pressures, and the large fat globules did not actively interact with the strands in the gel network. In contrast, a porous protein network structure with distinct strands was observed for the samples treated at high homogenisation pressures, and the small fat globules were intimately involved in the strands in the network structure. The HOHE gels had a more porous protein network with thicker strands than the HEHO gels. The size of the fat globules and their incorporation in the protein network during acidification is proposed to affect the acid gel structure and properties.     

豆浆加工工艺对全子叶豆腐品质影响的研究

为研究豆浆加工工艺对全子叶豆腐(Whole Cotyledon Tofu,WCT)品质的影响,以传统工艺作对照,选用去皮大豆为原料,比较研究两种豆浆加工工艺即湿法工艺(泡豆打浆)和干法工艺(制粉调浆)对制备WCT的组成成分、出品率、表观形态、色泽、质构特性的影响。结果表明:干法工艺和湿法工艺生产出的WCT的基本成分没有显著差异(p<0.05);与传统工艺相比,湿法工艺和干法工艺分别提高产量41.23%和46.67%,但后者比前者效率更高;干法工艺获得的WCT比湿法工艺外观更为顺滑细腻;两种工艺生产的WCT色泽无明显差异;干法工艺获得的WCT硬度、弹性、内聚性和咀嚼性均高于湿法工艺,且整体质构特性接近传统工艺豆腐。由此表明干法工艺比湿法工艺更适合生产品质优良的WCT,并能有效提高出品率。      

Effect of temperature on raw whole milk density and its potential impact on milk payment in the dairy industry

The objective of this study was to determine the effect of temperature on whole milk density measured at four different temperatures: 5, 10, 15, and 20 °C. A total of ninety-three individual milk samples were collected from morning milking of thirty-two Holstein Friesian dairy cows, of national average genetic merit, once every two weeks over a period of 4 weeks and were assessed by Fourier transform infrared spectroscopy for milk composition analysis. Density of the milk was evaluated using two different analytical methods: a portable density meter DMA35 and a standard desktop model DMA4500M (Anton Paar GmbH, UK). Milk density was analysed with a linear mixed model with the fixed effects of sampling period, temperature and analysis method; triple interaction of sampling period x analysis method x temperature; and the random effect of cow to account for repeated measures. The effect of temperature on milk density (ρ) was also evaluated including temperature (t) as covariate with linear and quadratic effects within each analytic method. The regression equation describing the curvature and density–temperature relationship for the DMA35 instrument was ρ = 1.0338−0.00017T−0.0000122T² (R² = 0.64), while it was ρ = 1.0334 + 0.000057T−0.00001T² (R² = 0.61) for DMA4500 instrument. The mean density determined with DMA4500 at 5 °C was 1.0334 g cm⁻³, with corresponding figures of 1.0330, 1.0320 and 1.0305 g cm⁻³ at 10, 15 and 20 °C, respectively. The milk density values obtained in this study at specific temperatures will help to address any bias in weight–volume calculations and thus may also improve the financial and operational control for the dairy processors in Ireland and internationally.     

全脂乳粉和脱脂乳粉在1kHz～10MHz下的介电特征研究

分别研究了各4种不同品种的全脂乳粉和脱脂乳粉在1kHz～10MHz波段的介电特性。结果发现:随着频率的增加,全脂乳粉和脱脂乳粉的ξ’和ξ″值呈单调递减趋势;全脂乳粉的ξ’和ξ″值都高于脱脂乳粉,相同类型乳粉各品种间的ξ’和ξ″差异不大;全脂乳粉的ξ″值在103～105Hz频率段减小趋势明显,且ξ″值的对数与频率的对数成线性反比关系,而脱脂乳粉无此规律;全脂乳粉和脱脂乳粉的穿透深度Dp随频率的提高而减小,两类乳粉的介电特性差异可能与它们各自的脂肪和乳糖含量有关。     

Effect of processing methods and protein content of the concentrate on the properties of milk protein concentrate with 80% protein

In recent years, a large increase in the production of milk protein concentrates (MPC) has occurred. However, compared with other types of milk powders, few studies exist on the effect of key processing parameters on powder properties. In particular, it is important to understand if key processing parameters contribute to the poor solubility observed during storage of high-protein MPC powders. Ultrafiltration (UF) and diafiltration (DF) are processing steps needed to reduce the lactose content of concentrates in the preparation of MPC with a protein content of 80% (MPC80). Evaporation is sometimes used to increase the TS content of concentrates before spray drying, and some indications exist that inclusion of this processing step may affect protein properties. In this study, MPC80 powders were manufactured by 2 types of concentration methods: membrane filtration with and without the inclusion of an evaporation step. Different concentration methods could affect the mineral content of MPC powders, as soluble salts can permeate the UF membrane, whereas no mineral loss occurs during evaporation, although a shift in calcium equilibrium toward insoluble forms may occur at high protein concentration levels. It is more desirable from an energy efficiency perspective to use higher total solids in concentrates before drying, but concerns exist about whether a higher protein content would negatively affect powder functionality. Thus, MPC80 powders were also manufactured from concentrates that had 3 different final protein concentrations (19, 21, and 23%; made from 1 UF retentate using batch recirculation evaporation, a similar concentration method). After manufacture, powders were stored for 6 mo at 30°C to help understand changes in MPC80 properties that might occur during shelf-life. Solubility and foaming properties were determined at various time points during high-temperature powder storage. Inclusion of an evaporation step, as a concentration method, resulted in MPC80 that had higher ash, total calcium, and bound calcium (of rehydrated powder) contents compared to concentration with only membrane filtration. Concentration method did not significantly affect the bulk (tapped) density, solubility, or foaming properties of the MPC powders. Powder produced from concentrate with 23% protein content exhibited a higher bulk density and powder particle size than powder produced from concentrate that had 19% protein. The solubility of MPC80 powder was not influenced by the protein content of the concentrate. The solubility of all powders significantly decreased during storage at 30°C. Higher protein concentrations in concentrates resulted in rehydrated powders that had higher viscosities (even when tested at a constant protein concentration). The protein content of the concentrate did not significantly affect foaming properties. Significant changes in the mineral content are used commercially to improve MPC80 solubility. However, although the concentration method did produce a small change in the total calcium content of experimental MPC80 samples, this modification was not sufficiently large enough (<7%) to influence powder solubility.     

贮藏温度对全脂羊奶粉品质稳定性的影响

本文主要研究了贮藏温度(5、25和35℃)对全脂羊奶粉品质稳定性的影响。通过测定全脂羊奶粉的酸值(AV)、过氧化值(POV值)、硫代巴比妥酸值(TBA值)、溶解度、色值等指标反应贮藏期间品质的变化。结果表明,贮藏在35℃的全脂羊奶粉贮藏期间酸值、过氧化值、TBA值变化速率较快,分别于第4个月后、第2个月后、第3个月后显著高于贮藏在5℃和25℃的全脂羊奶粉(p<0.05);所有样品的溶解度和色值变化规律相似,但差异不显著(p>0.05)。因此降低贮藏温度可提高全脂羊奶粉品质稳定性。      

Freezing kinetics and microstructure of ice cream from high-pressure-jet processing of ice cream mix

The effect of high-pressure-jet (HPJ) processing (0–500 MPa) on low-fat (6% fat) ice cream was studied by evaluating physiochemical properties before freezing, during dynamic freezing, and after hardening. An HPJ treatment ≥400 MPa decreased the density, increased the apparent size of colloidal particles, and altered rheological behavior (increased non-Newtonian behavior and consistency coefficients) of low-fat ice cream mix before freezing. During dynamic freezing, the particle size and consistency coefficient decreased but remained higher in 400 MPa–treated samples vs. non-HPJ-treated controls at the conclusion of freezing. The resulting ice creams (400 and 500 MPa–treated) had similar hardness values (3,372 ± 25 and 3,825 ± 14 g) and increased melting rates (2.91 ± 0.13 and 2.61 ± 0.31 g/min) compared with a control sample containing polysorbate 80 (3,887 ± 2 and 1.62 ± 0.25 g/min). Visualization of ice cream samples using transmission electron microscopy provided evidence of casein micelle and fat droplet disruption by HPJ treatment ≥400 MPa. In the 400 MPa–treated samples, a unique microstructure consisting of dispersed protein congregated around coalesced fat globules likely contributed to the altered physiochemical properties of this ice cream. High-pressure-jet processing can alter the microstructure, rheological properties, and hardness of a low-fat ice cream, and further modification of the formulation and processing parameters may allow the development of products with enhanced properties.     

淡炼乳稳定性研究

探讨了引起淡炼乳凝胶的因素以及防止办法。结果表明,低温短时预热如65℃,5～10min可以有效的降低凝胶的可能性;质量分数为0.1%的Na2HPO4·12H2O能防止稠化、凝胶现象的产生;MCC(微晶纤维素)或CMC(羧甲基纤维素)与阿拉伯胶复配能防止脂肪上浮而不促进稠化、凝胶现象的产生。炼乳的最佳均质条件是20MPa,5MPa。     

蛋黄免疫蛋白奶加工工艺的研究

开发了蛋黄免疫球蛋白消毒奶,研究了蛋黄免疫球蛋白消毒奶的加工工艺。得出最佳工艺条件为:IgY添加量为10%,采用低温巴氏杀菌65℃,30min。产品在4℃储藏条件下比普通巴氏乳的货架期延长8h。因此,蛋黄免疫蛋白消毒奶是一种既有营养,又具有生物活性功能的新型乳制品,且具有较长的货架期,有一定的发展前景。     

全脂牛乳粉中糖基化酪蛋白分析

研究全脂牛乳粉中糖基化酪蛋白,探讨其酶解特性。重点考察了不同pH、酸及提取方法对酪蛋白提取质量百分数的影响,并通过SDS-PAGE电泳分析酪蛋白,高碘酸—希夫碱染色法及莫氏试验鉴定糖基化酪蛋白,木瓜蛋白酶水解酪蛋白,测定其氨基酸含量。结果表明,pH 4.6时提取酪蛋白的质量百分数显著高于其他组(P0.05);质量百分数为2%的乙酸(pH 3.58)提取酪蛋白的质量百分数为(40.45±0.66)%,显著高于其他组(P0.05);鞣酸提取酪蛋白的质量百分数为(46.13±0.46)%,显著高于其他方法(P0.05);酪蛋白SDS-PAGE电泳结果表明,不同酸、不同方法提取的酪蛋白均有3条带,其分子量均分别为34,24,60ku;高碘酸—希夫碱染色结果表明,分子量为34,24ku的酪蛋白是糖基化酪蛋白;莫氏试验结果表明,乳粉酪蛋白中存在糖基化酪蛋白;酶解结果表明,乳粉酪蛋白经木瓜蛋白酶水解后游离氨基酸含量显著高于鲜乳酪蛋白(P0.05)。说明全脂牛乳粉中有糖基化酪蛋白,其分子量分别为34,24ku,易于水解。     

动态高压处理对牛乳中生物活性物质的影响

牛乳中含有乳铁蛋白、免疫球蛋白等多种有益身体健康的生物活性成分,在加工过程中如何降低其损失一直是重点关注的方向。动态高压处理技术又称超高压均质(UHPH),是一种较为新颖的加工技术手段之一。文章从美拉德反应产物、乳铁蛋白和免疫球蛋白等生物活性成分保留以及维生素损失等多个维度,总结了超高压均质在牛乳加工过程中的热负荷强度和关键营养成分保留方面的相关研究进展,并对超高压均质在乳制品加工领域的发展方向进行了展望。     

Long-term effects of ad libitum whole milk prior to weaning and prepubertal protein supplementation on skeletal growth rate and first-lactation milk production

Our objectives were to determine the effects of rapid growth rate during the preweaning period and prepubertal protein supplementation on long-term growth pattern and milk production during the first lactation. Forty-six Israeli Holstein heifer calves were fed either milk replacer (MR) or whole milk (WM) from 4 to 60 d age. Calves had free access to WM or MR for 30 min twice daily and free-choice water and starter mix for the entire day. From weaning until 150 d of age, all heifers were fed the same ration. At 150 d of age the heifers were divided into 2 subgroups, with one subgroup supplemented with an additional 2% protein until 320 d of age. Thereafter, all heifers were housed and fed together until calving. Another cluster of 20 heifers was raised on MR and WM treatments and 3 animals from each nursery treatment were slaughtered at 60 d and 10 mo age to determine effects of nursery treatment on organ and adipose tissue mass. Prior to weaning, the MR heifers consumed 0.12 kg/d more DM than the WM heifers, but metabolizable energy intake was not different. Body weight at weaning and average daily gain during the preweaning period were 3.1 kg and 0.074 kg/d higher, respectively, in the WM treatment than in the MR treatment, with no differences in other measurements. Nursery feeding treatment and added protein had no effect on growth rate in the prepubertal period, but the postweaning difference in BW between the WM and MR heifers remained throughout the entire rearing period. The age at first insemination was 23 d earlier and age at pregnancy and first calving was numerically lower for the WM heifers than for the MR heifers. Adipose tissue weights at weaning were doubled in the WM calves. First-lactation milk production and 4% fat-corrected milk were 10.3 and 7.1% higher, respectively, for WM heifers than for MR heifers, whereas prepubertal added protein tended to increase milk yield. In conclusion, preweaning WM at high feeding rates appears to have long-term effects that are beneficial to future milk production. The positive long-term effects of feeding WM on first-lactation milk production were independent of their effects on skeletal growth. Enhanced milk production observed with WM treatment may be related to the milk supply, paracrine or endocrine effects of fat tissues on mammary parenchyma, or a combination of both factors.     

充氮包装对全脂羊奶粉贮藏期间脂肪氧化稳定性的影响

采用加速氧化的方法研究充氮包装对全脂羊奶粉贮藏期间脂肪氧化稳定性的影响。通过测定全脂羊奶粉的酸值、过氧化值、硫代巴比妥酸值(TBA)、色度值等指标评价全脂羊奶粉贮藏期间脂肪的分解氧化状况。结果表明:充氮包装的全脂羊奶粉贮藏期间酸值、TBA值和色度值变化趋势较慢,分别于第6周后、第3周后、第7周后显著低于普通包装的全脂羊奶粉(p<0.05);充氮包装的全脂羊奶粉的过氧化值于第7周达到最高值13.54mmol/kg脂肪,变化速率显著小于普通包装的全脂羊奶粉(p<0.01)。说明充氮包装可延缓酸值、过氧化值、TBA值和色度值的变化速率,显著提高全脂羊奶粉脂肪的氧化稳定性。      

水分活度对全脂羊奶粉贮藏期间脂肪稳定性的影响

采用加速氧化的方法研究水分活度对全脂羊奶粉贮藏期间脂肪稳定性的影响。通过测定全脂羊奶粉的酸值、过氧化值、硫代巴比妥酸值(TBA)、颜色等指标评价全脂羊奶粉贮藏期间的氧化状况。结果表明,水分活度为0.32的全脂羊奶粉贮藏期间酸值、TBA值显著高于水分活度为0.11和0.23的全脂羊奶粉(p<0.05),且水分活度为0.32的全脂羊奶粉过氧化值变化速率较快(p<0.05),且褐变严重。因此,降低全脂羊奶粉的水分活度可以提高其贮藏稳定性。      

Effect of different colored filters on photooxidation in pasteurized milk

The effect of different colored filters and atmospheres on photooxidation and quality in milk was studied. Pasteurized bovine milk (3.9% fat) was packed in 2 different atmospheres (air and N₂) and exposed to light for 20 h at 4°C under 8 transparent filters with different light transmission properties. The following transparent, noncolored, and colored filters based on polyethylene terephthalate (PET) were used: noncolored (PET), noncolored with 2 different UV-block regions, yellow, green, amber, orange, and red. Control samples were stored in darkness and in a carton. Sensory evaluation showed off flavors significantly increased in milk stored under all filters compared with the control samples. Variation in atmosphere resulted in significant differences in formation of rancid flavor in milk stored under different filters. Milk samples stored in N₂ underwent the most sensory deterioration under orange and red filters, whereas milk samples stored in air were most deteriorated under noncolored filters. According to the oxidation compounds measured by gas chromatography, milk samples stored under noncolored and orange filters were highly oxidized, whereas red, green, and amber filters offered better protection against photooxidation. Fluorescence spectroscopy was used to examine the degradation of photosensitizers (riboflavin, protoporphyrin, and chlorophyllic compounds) in the milk samples. Degradation of protoporphyrin and chlorophyllic compounds in N₂ correlated well with sensory properties related to photooxidation (R² = 0.75-0.95). The study indicates that protoporphyrin and chlorophyllic compounds were effective photosensitizers in milk. To avoid photooxidation in milk, it is therefore important to protect it against light from the UV spectrum as well as light from the entire visible region.