Survival of Salmonella, Escherichia coli O157:H7, and Listeria monocytogenes on Inoculated Almonds and Pistachios Stored at -19, 4, and 24° C

The survival of Salmonella, Escherichia coli O157:H7, and Listeria monocytogenes was determined on almonds and pistachios held at typical storage temperatures. Almond kernels and inshell pistachios were inoculated with four- to six-strain cocktails of nalidixic acid-resistant Salmonella, E. coli O157:H7, or L. monocytogenes at 6 log CFU/g and then dried for 72 h. After drying, inoculated nuts were stored at -19, 4, or 24°C for up to 12 months. During the initial drying period after inoculation, levels of all pathogens declined by 1 to -log CFU/g on both almonds and pistachios. During storage, moisture content (4.8%) and water activity (0.4) of the almonds and pistachios were consistent at -19°C; increased slowly to 6% and 0.6, respectively, at 4°C; and fluctuated from 4 to 5% and 0.3 to 0.5 at 24°C, respectively. Every 1 or 2 months, levels of each pathogen were enumerated by plating; samples were enriched when levels fell below the limit of detection. No reduction in population level was observed at -19 or 4°C for either pathogen, with the exception of E. coli O157:H7-inoculated almonds stored at 4°C (decline of 0.09 log CFU/g/month). At 24°C, initial rates of decline were 0.20, 0.60, and 0.71 log CFU/g/month on almonds and 0.15, 0.35, and 0.86 log CFU/g/month on pistachios for Salmonella, E. coli O157:H7, and L. monocytogenes, respectively, but distinct tailing of the survival curves was noted for both E. coli O157:H7 and L. monocytogenes.     

Influence of holding temperature on the growth and survival of Salmonella spp. and Staphylococcus aureus and the production of staphylococcal enterotoxin in egg products

In this study, growth and survival of Salmonella spp. and Staphylococcus aureus in steamed egg and scrambled egg held at 5, 18, 22, 37, 55 and 60 degrees C are investigated. The production of staphylococcal enterotoxin in steamed egg is also examined. Results reveal that Salmonella spp. and Staph. aureus in the egg products multiply best at 37 degrees C, followed closely by 22 and 18 degrees C. Neither pathogen showed growth in the egg products held at 5 degrees C. Initial inoculation dose, holding temperature and holding time affected the population of both organisms found in the egg products. Staphylococcal enterotoxin A (SEA) and B (SEB) are detected only in the egg products held at 37 or 22 degrees C. After holding at 37 degrees C for 36 h, scrambled egg inoculated with ca. 5.0 log cfu/g Staph. aureus contains the highest levels of SEA (> 64 ng/g) and SEB (> 64 ng/g). Although Salmonella spp. and Staph. aureus grow better in steamed eggs than in scrambled eggs, production of staphylococcal enterotoxin, in general, was higher in scrambled eggs than in steamed eggs. On the other hand, a repaid destruction of the test organisms in steamed eggs held at 60 degrees C was observed. Holding the steamed eggs at 60 degrees C, Salmonella spp. and Staph. aureus with an initial population of ca. 5.9 and 5.6 log cfu/g, respectively, reduced to a non-detectable level in 1 h.     

Application of reuterin produced by Lactobacillus reuteri 12002 for meat decontamination and preservation

Lactobacillus reuteri strain 12002 was used for reuterin production in the two-step fermentation process. A batch culture fermentation was used to produce a maximum biomass of L. reuteri. Then cells were harvested, resuspended in a glycerol-water solution, and anaerobically incubated to produce reuterin. The lyophilized supernatants (approximately 4000 activity units (AU) of reuterin per ml) were diluted in distilled water for decontamination and preservation trials. The MIC values of reuterin for Escherichia coli O157:H7 and Listeria monocytogenes were 4 and 8 AU/ml, respectively. In meat decontamination experiments, the surface of cooked pork was inoculated with either L. monocytogenes or E. coli O157:H7 at a level of approximately log10 5 CFU/cm2, incubated for 30 min at 7 degrees C, and decontaminated by exposure to reuterin (500 AU/ml). The bactericidal effect of reuterin was analyzed 15 s and 24 h after exposure at 7 degrees C. After 15 s of exposure to reuterin, viable numbers decreased by 0.45 and 0.3 log10 CFU/cm2 for E. coli O157:H7 and L. monocytogenes, respectively. After 24 h the numbers decreased by 2.7 log10 CFU/cm2 for E. coli O157:H7 and by 0.63 log10 CFU/cm2 for L. monocytogenes. In the same experiment, the combined effect of reuterin and lactic acid was also investigated. Adding lactic acid (5%, vol/vol) to reuterin significantly enhanced (P < or = 0.05) the efficacy of reuterin. No additional effect (P < or = 0.05) was found when ethanol (40%) was added to the mixture of reuterin and lactic acid. To evaluate the preservative effect of reuterin during meat storage, reuterin was added to raw ground pork contaminated with E. coli O157:H7 or L. monocytogenes. Reuterin at a concentration of 100 AU/g resulted in a 5.0-log10 reduction of the viability of E. coli O157:H7 after 1 day of storage at 7 degrees C. Reuterin at a concentration of 250 AU/g reduced the number of the viable cells of L. monocytogenes by log10 3.0 cycles after 1 week of storage at 7 degrees C.     

Comparative survival of Salmonella typhimurium DT 104, Listeria monocytogenes, and Escherichia coli O157:H7 in preservative-free apple cider and simulated gastric fluid

This study compared the survival of three-strain mixtures (ca. 10(7) CFU ml(-1) each) of Salmonella typhimurium DT104, Listeria monocytogenes, and Escherichia coli O157:H7 in pasteurized and unpasteurized preservative-free apple cider (pH 3.3-3.5) during storage at 4 and 10 degrees C for up to 21 days. S. typhimurium DT104 populations decreased by <4.5 log10 CFU ml(-1) during 14 days storage at 4 and 10 degrees C in pasteurized cider, and by > or =5.5 log10 CFU ml(-1) during 14 days in unpasteurized cider stored at these temperatures. However, after 7 days at 4 degrees C, the S. typhimurium DT104 populations had decreased by only about 2.5 log10 CFU ml(-1) in both pasteurized and unpasteurized cider. Listeria monocytogenes populations decreased below the plating detection limit (10 CFU ml(-1)) within 2 days under all conditions tested. Survival of E. coli O157:H7 was similar to that of S. typhimurium DT104 in pasteurized cider at both 4 and 10 degrees C over the 21-days storage period, but E. coli O157:H7 survived better (ca. 5.0 log10 CFU ml(-1) decrease) than S. typhimurium DT104 (> 7.0 log10 CFU ml(-1) decrease) after 14 days at 4 degrees C in unpasteurized cider. In related experiments, when incubated in simulated gastric fluid (pH 1.5) at 37 degrees C, S. typhimurium DT104 and L. monocytogenes were eliminated (5.5-6.0 log10 CFU ml(-1) decrease) within 5 and 30 min, respectively, whereas E. coli O157:H7 concentrations decreased only 1.60-2.80 log10 CFU ml(-1) within 2 h.     

Fate of Escherichia coli O157:H7 in coleslaw during storage

An outbreak of Escherichia coli O157:H7 infection associated with the consumption of coleslaw in several units of a restaurant chain prompted a study to determine the fate of the pathogen in two commercial coleslaw preparations (pH 4.3 and 4.5) held at 4, 11, and 21 degrees C for 3 days. At an initial population of 5.3 log10 CFU/g of coleslaw, E. coli O157:H7 did not grow in either coleslaw stored at the three temperatures. Rather, the population of E. coli O157:H7 decreased by 0.1 to 0.5 log10 CFU/g within 3 days. The greatest reduction (0.4 and 0.5 log10 CFU/g) in population occurred at 21 degrees C, whereas only slight decreases (0.1 to 0.2 log10 CFU/g) occurred at 4 and 11 degrees C. A pH of 4.3 to 4.5 of coleslaw had little effect on reducing E. coli O157:H7 populations. Results suggest that the tolerance of E. coli O157:H7 to acid pH, not temperature abuse, is a major factor influencing the pathogen's fate in restaurant-prepared coleslaw.     

Fate of Escherichia coli O157:H7 and Listeria monocytogenes in strawberry juice and acidified media at different pH values and temperatures

Survival and growth of Escherichia coli O157:H7 and Listeria monocytogenes in strawberry juice and acidified media at different pH levels (pH 3.4 to 6.8) and temperatures were studied. Sterile strawberry juice (pH 3.6) and acidified trypticase soy broth (TSB) media (pH 3.4 to 6.8) were inoculated with approximately 6.7 log CFU/ml E. coli O157:H7 or 7.3 log CFU/ ml L. monocytogenes, incubated for 3 days at 4 and 37 degrees C. Bacterial levels were determined after 2 h, 1 day, and 3 days using surface plating nonselectively on tryptic soy agar and selectively on sorbitol MacConkey agar for E. coli O157:H7 or modified Oxford agar for L. monocytogenes. A spectrophotometer (660 nm) was also used to study growth inhibition of L. monocytogenes in different TSB and strawberry juice media (pH 3.4 to 7.3). E. coli O157:H7 survived well at pH values of 3.4 to 6.8 at 4 degrees C, but the number of injured cells increased as pH decreased and incubation time increased. At 37 degrees C, E. coli O157:H7 was inactivated at pH of < or = 3.6 but could grow at pH 4.7. L. monocytogenes was quickly injured at pH of < or = 4.7 within 2 h of storage at 4 degrees C and then was slightly and gradually inactivated as storage time increased. L. monocytogenes survived well at pH 6.8 at 4 degrees C and grew well at 37 degrees C. Growth of L. monocytogenes at 37 degrees C was inhibited in TSB by 1% citric acid and 0.5% malic acids at pH 3.4 or by 50% strawberry juice at pH 4.7. Bacterial injury and inactivation appeared to be induced by the acids in strawberry juice. The acids, pH value, temperature, and time were important factors for bacterial survival, inactivation, and growth in the media tested.     

Effects of recovery, plating, and inoculation methods on quantification of Escherichia coli O157:H7 and Listeria monocytogenes from strawberries

Effects of different recovery and inoculation methods on quantification of Escherichia coli O157:H7 and Listeria monocytogenes from strawberries were studied. Strawberries were spot or dip inoculated with 7 to 8 log CFU per strawberry of each pathogen, air dried for 2 h, and stored for 1, 3, and 7 days at 4 degrees C. The inoculated samples were stomached or washed with phosphate-buffered saline (PBS; pH 7.2) or with modified PBS (pH 8.4). Bacterial levels were determined using a direct selective plating, thin agar layer plating, or membrane-transferring plating (MTP) with tryptic soy agar and sorbital MacConkey agar (E. coli O157:H7) or modified Oxford agar (L. monocytogenes). Under most test conditions, washing with PBS followed by MTP had significantly higher (P < 0.05) recovery for both bacteria compared with other tested methods. Within a 7-day storage period for spot-inoculated strawberries, a stomaching step resulted in an injury of 0.9 to 1.4 log CFU for E. coli O157: H7 and 1.4 to 1.7 log CFU for L. monocytogenes. When a washing step was used instead, this resulted in an injury of only 0.2 to 0.6 log CFU for E. coli O157:H7 and 0.2 to 0.7 log CFU for L. monocytogenes. Both bacteria could survive on strawberry surfaces, but their recovered levels decreased with the increase of storage time at 4 degrees C for both spot and dip inoculation methods. Dip inoculation generally had a lower recovery than spot inoculation. An ideal protocol to recover and enumerate E. coli O157:H7 and L. monocytogenes from strawberries involved shaking and washing samples with 100 ml of PBS for 15 min at 22 degrees C coupled with a MTP enumeration method.     

Inactivation of Escherichia coli O157: H7 and Listeria monocytogenes by PR-26, a synthetic antibacterial peptide.

This study reports the antibacterial effect of PR-26, a synthetic peptide derived from the first 26 amino acid sequence of PR-39, an antimicrobial peptide isolated from porcine neutrophils. A three-strain mixture of Escherichia coli O157:H7 or Listeria monocytogenes of approximately 10(8) CFU was inoculated to a final concentration of 10(7) CFU/ml in 1% peptone water (pH 7.0), containing 50 or 75 microg/ml of PR-26, and incubated at 37 degrees C for 0, 6, 12, and 24 h; at 24 degrees C for 0, 12, 24, and 36 h; or at 10 or 4 degrees C for 0, 24, 72, and 120 h. Control samples included 1% peptone water inoculated with each pathogen mixture but containing no PR-26. The surviving population of each pathogen at each sampling time was determined by plating on tryptic soy agar with incubation at 37 degrees C for 24 h. At 37 degrees C, PR-26 decreased E. coli O157:H7 and L. monocytogenes populations by >5.0 log CFU/ml at 12 h, with complete inactivation at 24 h. At 24 degrees C, PR-26 reduced E. coli O157:H7 and L. monocytogenes by approximately 3.5, 4.0, and 4.5 log CFU/ml at the end of 12-, 24-, and 36-h incubations, respectively. At 4 and 10 degrees C, the inhibitory effect of PR-26 on E. coli O157:H7 and L. monocytogenes was significantly lower (P < 0.05) than that at 37 and 24 degrees C: a 2- to 3-log CFU/ml reduction was observed at 120-h incubation. Results indicate that PR-26 could potentially be used as an antimicrobial agent, but applications in appropriate foods need to be validated.     

Inactivation of Escherichia coli O157:H7 in ground beef by single-cycle and multiple-cycle high-pressure treatments

The effect of single- and multiple-cycle high-pressure treatments on the survival of Escherichia coli CECT 4972, a strain belonging to the O157:H7 serotype, in ground beef was investigated. Beef patties were inoculated with 10(7) CFU/g E. coli O157:H7, and held at 4 degrees C for 20 h before high-pressure treatments. Reduction of the E. coli O157:H7 population by single-cycle treatments at 400 MPa and 12 degrees C ranged from 0.82 log CFU/g for a 1-min cycle to 4.39 log CFU/g for a 20-min cycle. Multiple-cycle treatments were very effective, with four 1-min cycles at 400 MPa and 12 degrees C reducing the E. coli O157:H7 population by 4.38 log CFU/g, and three 5-min cycles by 4.96 log CFU/g. The color parameter L* increased significantly with high-pressure treatments in the interior and the exterior of beef patties, whereas a* decreased in the interior, and b* increased in the exterior-changes that might diminish consumer acceptance of the product. Kramer shear force and energy were generally higher in pressurized than in control ground beef. Maximum values for these texture parameters, which corresponded to tougher patties, were reached after one 10-min cycle in the case of single-cycle treatments or two 5-min cycles in the case of multiple-cycle treatments. High-pressure treatments had no significant effect on Warner-Bratzler shear force.     

Bactericidal effects of Lactobacillus reuteri and allyl isothiocyanate on Escherichia coli O157:H7 in refrigerated ground beef

Two naturally occurring antimicrobial agents were tested in packages of refrigerated ground beef for their ability to reduce the viability of Escherichia coli O157:H7 during storage. Allyl isothiocyanate (AITC) and Lactobacillus reuteri were tested separately and together for their action against a cocktail of five strains of E. coli O157:H7 in ground beef held at 4 degrees C for 25 days. Ground beef prepared from whole, raw inside round beef roasts was inoculated with low (3 log CFU/g) or high (6 log CFU/g) levels of the E. coli O157:H7 mixture. The beef was treated with AITC (about 1,300 ppm), L. reuteri, or both, along with 250 mM of glycerol per kg of meat at two levels (3 and 6 log CFU/g) and according to a design that yielded 8 controls plus 10 different treatments. Samples were analyzed for E. coli O157:H7 survivors, numbers of total bacteria, and lactic acid bacteria on days 0 to 25 at 5-day intervals. L. reuteri at both input levels with glycerol killed E. coli O157:H7 at both inoculated levels before day 20. AITC completely eliminated E. coli O157:H7 at the low-inoculum level (3 log CFU/g) and reduced viability >4.5 log CFU/g at the high-inoculum level (6 log CFU/g) by the end of the storage period. The combination of L. reuteri and AITC did not yield an additive effect against E. coli O157:H7 viability. L. reuteri in the presence of glycerol was highly effective against E. coli O157:H7 in ground beef during refrigerated storage (4 degrees C) in modified atmosphere packages. Sensory testing is planned to evaluate effects of treatments.     

Inactivation of Escherichia coli O157:H7 and Listeria monocytogenes on plastic kitchen cutting boards by electrolyzed oxidizing water.

One milliliter of culture containing a five-strain mixture of Escherichia coli O157:H7 (approximately 10(10) CFU) was inoculated on a 100-cm2 area marked on unscarred cutting boards. Following inoculation, the boards were air-dried under a laminar flow hood for 1 h, immersed in 2 liters of electrolyzed oxidizing water or sterile deionized water at 23 degrees C or 35 degrees C for 10 or 20 min; 45 degrees C for 5 or 10 min; or 55 degrees C for 5 min. After each temperature-time combination, the surviving population of the pathogen on cutting boards and in soaking water was determined. Soaking of inoculated cutting boards in electrolyzed oxidizing water reduced E. coli O157:H7 populations by > or = 5.0 log CFU/100 cm2 on cutting boards. However, immersion of cutting boards in deionized water decreased the pathogen count only by 1.0 to 1.5 log CFU/100 cm2. Treatment of cutting boards inoculated with Listeria monocytogenes in electrolyzed oxidizing water at selected temperature-time combinations (23 degrees C for 20 min, 35 degrees C for 10 min, and 45 degrees C for 10 min) substantially reduced the populations of L. monocytogenes in comparison to the counts recovered from the boards immersed in deionized water. E. coli O157:H7 and L. monocytogenes were not detected in electrolyzed oxidizing water after soaking treatment, whereas the pathogens survived in the deionized water used for soaking the cutting boards. This study revealed that immersion of kitchen cutting boards in electrolyzed oxidizing water could be used as an effective method for inactivating foodborne pathogens on smooth, plastic cutting boards.     

Viability of Salmonella,Escherichia coli O157:H7, and Listeria monocytogenes in yellow fat spreads as affected by storage temperature

A study was conducted to characterize the survival and inactivation kinetics of a five-serotype mixture of Salmonella (6.23 to 6.55 log10 CFU per 3.5-ml or 4-g sample), a five-strain mixture of Escherichia coli O157:H7 (5.36 to 6.14 log10 CFU per 3.5-ml or 4-g sample), and a six-strain mixture of Listeria monocytogenes (5.91 to 6.18 log10 CFU per 3.5-ml or 4-g sample) inoculated into seven yellow fat spreads (one margarine, one butter-margarine blend, and five dairy and nondairy spreads and toppings) after formulation and processing and stored at 4.4, 10, and 21 degrees C for up to 94 days. Neither Salmonella nor E. coil O157:H7 grew in any of the test products. The time required for the elimination of each pathogen depended on the product and the storage temperature. Death was more rapid at 21 degrees C than at 4.4 or 10 degrees C. Depending on the product, the time required for the elimination of viable cells at 21 degrees C ranged from 5 to 7 days to >94 days for Salmonella, from 3 to 5 days to 28 to 42 days for E. coli O157:H7, and from 10 to 14 days to >94 days for L. monocytogenes. Death was most rapid in a water-continuous spray product (pH 3.66, 4.12% salt) and least rapid in a butter-margarine blend (pH 6.66, 1.88% salt). E. coli O157:H7 died more rapidly than did Salmonella or L. monocytogenes regardless of storage temperature. Salmonella survived longer in high-fat (> or = 61%) products than in products with lower fat contents. The inhibition of growth is attributed to factors such as acidic pH, salt content, the presence of preservatives, emulsion characteristics, and nutrient deprivation. L. monocytogenes did not grow in six of the test products, but its population increased between 42 and 63 days in a butter-margarine blend stored at 10 degrees C and between 3 and 7 days when the blend was stored at 21 degrees C. On the basis of the experimental parameters examined in this study, traditional margarine and spreads not containing butter are not "potentially hazardous foods" in that they do not support the growth of Salmonella, E. coli O157:H7, or L. monocytogenes.     

Survival and growth characteristics of Escherichia coli O157:H7 in pasteurized and unpasteurized Cheddar cheese whey

The objective of this study was to determine the survival and growth characteristics of Escherichia coli O157:H7 in whey. A five-strain mixture of E. coli O157:H7 was inoculated into 100 ml of fresh, pasteurized or unpasteurized Cheddar cheese whey (pH 5.5) at 10(5) or 10(2) CFU/ml, and stored at 4, 10 or 15 degrees C. The population of E. coli O157:H7 (on Sorbitol MacConkey agar supplemented with 0.1% 4-methylumbelliferyl-beta-D-glucuronide) and lactic acid bacteria (on All Purpose Tween agar) were determined on days 0, 1, 4, 7, 14, 21 and 28. At all storage temperatures, survival of E. coli O157:H7 was significantly higher (P<0.01) in the pasteurized whey compared to that in the unpasteurized samples. At 10 and 15 degrees C, E. coli O157:H7 in pasteurized whey significantly (P<0.05) increased during the first week of storage, followed by a decrease thereafter. However at the same temperatures, E. coli O157:H7 exhibited a steady decline in the unpasteurized samples from day 0. At 4 degrees C, E. coli O157:H7 did not grow in pasteurized and unpasteurized whey; however, the pathogen persisted longer in pasteurized samples. At all the three storage temperatures, E. coli O157:H7 survived up to day 21 in the pasteurized and unpasteurized whey. The initial load of lactic acid bacteria in the unpasteurized whey samples was approximately 7.0 log10 CFU/ml and, by day 28, greater than 3.0 log10 CFU/ml of lactic acid bacteria survived in unpasteurized whey at all temperatures, with the highest counts recovered at 4 degrees C. Results indicate the potential risk of persistence of E. coli O157:H7 in whey in the event of contamination with this pathogen.     

Efficacy of cetylpyridinium chloride in immersion treatment for reducing populations of pathogenic bacteria on fresh-cut vegetables.

The efficacy of cetylpyridinium chloride (CPC) immersion to reduce the numbers of three pathogenic bacteria (Listeria monocytogenes, Salmonella Typhimurium, and Escherichia coli O157:H7) on three different fresh-cut vegetables (broccoli, cauliflower, and radishes) was studied. The fresh-cut vegetables were inoculated with one of the three pathogenic bacteria at a concentration of 10(5) CFU/ml for 1 h at room temperature and then treated with 0.1 or 0.5% CPC immersion for 1 min. Both Salmonella Typhimurium and E. coli O157:H7 plates were incubated from 48 to 72 h at 37 degrees C, and L. monocytogenes plates were incubated from 72 to 96 h before being counted. The results of three experiments showed that for the average of the three vegetables treated with 0.1 and 0.5% CPC, L. monocytogenes was reduced by 2.85 and 3.70 log CFU/g, Salmonella Typhimurium by 2.37 and 3.15 log CFU/g, and E. coli O157:H7 by 1.01 and 1.56 log CFU/g, respectively, in comparison with the vegetables treated with water only. The 0.5% CPC treatment was significantly different (P < 0.05) from the 0.1% CPC treatment on reduction of L. monocytogenes, Salmonella Typhimurium, and E. coli O157:H7. The CPC residual on the treated vegetables and their washing solutions were evaluated by using high-performance liquid chromatography.     

High-pressure resistance variation of Escherichia coli O157:H7 strains and Salmonella serovars in tryptic soy broth, distilled water, and fruit juice

The effect of high pressure on the log reduction of six strains of Escherichia coli O157:H7 and five serovars of Salmonella enterica was investigated in tryptic soy broth, sterile distilled water, and commercially sterile orange juice (for Salmonella) and apple cider (for E. coli). Samples were subjected to high-pressure processing treatment at 300 and 550 MPa for 2 min at 6 degrees C. Samples were plated onto tryptic soy agar directly after pressurization and after being held for 24 h at 4 degrees C. At 300 MPa, little effect was seen on E. coli O157:H7 strains, while Salmonella serovars varied in resistance, showing reductions between 0.26 and 3.95 log CFU/ml. At 550 MPa, E. coli O157:H7 strains exhibited a range of reductions (0.28 to 4.39 log CFU/ml), while most Salmonella populations decreased beyond the detection limit (> 5-log CFU/ml reduction). The most resistant strains tested were E. coli E009 and Salmonella Agona. Generally, bacterial populations in fruit juices showed larger decreases than did populations in tryptic soy broth and distilled water. E. coli O157:H7 cultures held for 24 h at 4 degrees C after treatment at 550 MPa showed a significant log decrease as compared with cultures directly after treatment (P < or = 0.05), while Salmonella serovars did not show this significant decrease (P > 0.05). All Salmonella serovars tested in orange juice treated at 550 MPa for 2 min at 6 degrees C and held for 24 h showed a > 5-log decrease, while E. coli O157:H7 strains require a higher pressure, higher temperature, longer pressurization, or a chemical additive to achieve a 5-log decrease.     

Effectiveness of two cooking systems in destroying Escherichia coli O157:H7 and Listeria monocytogenes in ground beef patties

A rapid, high-temperature double-sided grilling-broiling (DGB) system was compared to a single-sided broiling (SSB) system for cooking of foodservice ground beef patties to reduce microbial numbers and maintain textural quality. Patties (110 g) containing either Escherichia coli O157:H7 or Listeria monocytogenes (10(6-7) CFU/g) were cooked to target internal temperatures of 60 or 68 degrees C on each cooking system and immediately removed from the grills without the additional holding time at 60 or 68 degrees C that is recommended for foodservice cooking of ground beef patties. Actual final internal temperature attained, position on the grill, degree of doneness, cooking time, after-cook weight, texture characteristics, and bacterial counts of the patties were monitored. The DGB reduced E. coli O157:H7 and L. monocytogenes populations in ground beef patties by 5.7 log10 and 5.4 log10 CFU/g, respectively, when cooked to a target temperature of 60 degrees C (actual final internal temperature of 71.2 degrees C) and by 6.1 log10 and 5.6 log10 CFU/g, respectively, when cooked to a target temperature of 68 degrees C (actual final internal temperature of 75.8 degree C). The SSB reduced E. coli O157:H7 and L. monocytogenes populations by 1.3 log10 and 1.8 log10 CFU/g, respectively, when cooked to a target temperature of 60 degrees C (actual final internal temperature of 62.7 degrees C) and by 2.9 log10 and 3.6 log10 CFU/g, respectively, when cooked to a target temperature of 68 degrees C (actual final internal temperature of 69.3 degrees C). The DGB system effected a higher, more rapid temperature increase in patties cooked to either target temperature compared to the SSB system. This higher temperature was more effective in destroying pathogens in beef patties. Texture analyses determined that patties cooked on the DGB system had significantly higher values for springiness, adhesiveness, and product height as compared to the SSB system, and patties cooked on either system had significantly higher hardness, gumminess, chewiness, and product height values at the target temperature of 68 degrees C as compared to 60 degrees C.     

Survival and growth of Listeria monocytogenes and enterohemorrhagic Escherichia coli O157:H7 in minimally processed artichokes

The ability of Listeria monocytogenes and Escherichia coli O157:H7 inoculated by immersion (at 4.6 and 5.5 log CFU/ g, respectively) to survive on artichokes during various stages of preparation was determined. Peeling, cutting, and disinfecting operations (immersion in 50 ppm of a free chlorine solution at 4 degrees C for 5 min) reduced populations of L. monocytogenes and E. coli O157:H7 by only 1.6 and 0.8 log units, respectively. An organic acid rinse (0.02% citric acid and 0.2% ascorbic acid) was more effective than a tap water rinse in removing these pathogens. Given the possibility of both pathogens being present on artichokes at the packaging stage, their behavior during the storage of minimally processed artichokes was investigated. For this purpose, batches of artichokes inoculated with L. monocytogenes or E. coli O157:H7 (at 5.5 and 5.2 log CFU/g, respectively) were packaged in P-Plus film bags and stored at 4 degrees C for 16 days. During this period, the equilibrium atmosphere composition and natural background microflora (mesophiles, psychrotrophs, anaerobes, and fecal coliforms) were also analyzed. For the two studied pathogens, the inoculum did not have any effect on the final atmospheric composition (10% O2, 13% CO2) or on the survival of the natural background microflora of the artichokes. L. monocytogenes was able to survive during the entire storage period in the inoculated batches, while the E. coli O157:H7 level increased by 1.5 log units in the inoculated batch during the storage period. The modified atmosphere was unable to control the behavior of either pathogen.     

Biodegradable polylactic acid polymer with nisin for use in antimicrobial food packaging

ABSTRACT:  Biodegradable polylactic acid (PLA) polymer was evaluated for its application as a material for antimicrobial food packaging. PLA films were incorporated with nisin to for control of foodborne pathogens. Antimicrobial activity of PLA/nisin films against Listeria monocytogenes , Escherichia coli O157:H7, and Salmonella Enteritidis were evaluated in culture media and liquid foods (orange juice and liquid egg white). Scanned electron micrograph and confocal laser microscopy revealed that nisin particles were evenly distributed in PLA polymer matrix on the surface and inside of the PLA/nisin films. PLA/nisin significantly inhibited growth of L . monocytogenes in culture medium and liquid egg white. The greatest inhibition occurred at 24 h when the cell counts of L. monocytogenes in the PLA/nisin samples were 4.5 log CFU/mL less than the controls. PLA/nisin reduced the cell population of E. coli O157:H7 in orange juice from 7.5 to 3.5 log at 72 h whereas the control remained at about 6 log CFU/mL. PLA/nisin treatment resulted in a 2 log reduction of S. Enteritidis in liquid egg white at 24 °C. After 21 d at 4 °C the S. Enteritidis population from PLA/nisin treated liquid egg white (3.5 log CFU/mL) was significantly less than the control (6.8 log CFU/mL). E. coli O157:H7 in orange juice was more sensitive to PLA/nisin treatments than in culture medium. The results of this research demonstrated the retention of nisin activity when incorporated into the PLA polymer and its antimicrobial effectiveness against foodborne pathogens. The combination of a biopolymer and natural bacteriocin has potential for use in antimicrobial food packaging.     

Validation of time and temperature values as critical limits for the control of Escherichia coli O157:H7 during the production of fresh ground beef

In order to provide beef processors with valuable data to validate critical limits set for temperature during grinding, a study was conducted to determine Escherichia coli o157:H7 growth at various temperatures in raw ground beef. Fresh ground beef samples were inoculated with a cocktail mixture of streptomycin-resistant E. coli O157:H7 to facilitate recovery in the presence of background flora. Samples were held at 4.4, 7.2, and 10 degrees C, and at room temperature (22.2 to 23.3 degrees C) to mimic typical processing and holding temperatures observed in meat processing environments. E. coli O157:H7 counts were determined by direct plating onto tryptic soy agar with streptomycin (1,000 microg/ml), at 2-h intervals over 12 h for samples held at room temperature. Samples held under refrigeration temperatures were sampled at 4, 8, 12, 24, 48, and 72 h. Less than one log of E. coli O157:H7 growth was observed at 48 h for samples held at 10 degrees C. Samples held at 4.4 and 7.2 degrees C showed less than one log of E. coli O157:H7 growth at 72 h. Samples held at room temperature showed no significant increase in E. coli O157:H7 counts for the first 6 h, but increased significantly afterwards. These results illustrate that meat processors can utilize a variety of time and temperature combinations as critical limits in their hazard analysis critical control point plans to minimize E. coli O157:H7 growth during the production and storage of ground beef.     

Fate of Escherichia coli O157:H7, Salmonella typhimurium DT 104, and Listeria monocytogenes in fresh meat decontamination fluids at 4 and 10 degrees C.

Bacterial pathogens may colonize meat plants and increase food safety risks following survival, stress hardening, or proliferation in meat decontamination fluids (washings). The objective of this study was to evaluate the ability of Escherichia coli O157:H7, Salmonella Typhimurium DT 104, and Listeria monocytogenes to survive or grow in spray-washing fluids from fresh beef top rounds sprayed with water (10 or 85 degrees C) or acid solutions (2% lactic or acetic acid, 55 degrees C) during storage of the washings at 4 or 10 degrees C in air to simulate plant conditions. Inoculated Salmonella Typhimurium DT 104 (5.4 +/- 0.1 log CFU/ml) died off in lactate (pH 2.4 +/- 0.1) and acetate (pH 3.1 +/- 0.2) washings by 2 days at either storage temperature. In contrast, inoculated E. coli O157:H7 (5.2 +/- 0.1 log CFU/ml) and L. monocytogenes (5.4 +/- 0.1 log CFU/ml) survived in lactate washings for at least 2 days and in acetate washings for at least 7 and 4 days, respectively; their survival was better in acidic washings stored at 4 degrees C than at 10 degrees C. All inoculated pathogens survived in nonacid (pH > 6.0) washings, but their fate was different. E. coli O157:H7 did not grow at either temperature in water washings, whereas Salmonella Typhimurium DT 104 failed to multiply at 4 degrees C but increased by approximately 2 logs at 10 degrees C. L. monocytogenes multiplied (0.6 to 1.3 logs) at both temperatures in water washings. These results indicated that bacterial pathogens may survive for several days in acidic, and proliferate in water, washings of meat, serving as potential cross-contamination sources, if pathogen niches are established in the plant. The responses of surviving pathogens in meat decontamination waste fluids to acid or other stresses need to be addressed to better evaluate potential food safety risks.