High-pressure processing and antimicrobial biodegradable packaging to control Listeria monocytogenes during storage of cooked ham

The efficiency of combining high-pressure processing (HPP) and active packaging technologies to control Listeria monocytogenes growth during the shelf life of artificially inoculated cooked ham was assessed. Three lots of cooked ham were prepared: control, packaging with alginate films, and packaging with antimicrobial alginate films containing enterocins. After packaging, half of the samples were pressurized. Sliced cooked ham stored at 6 degrees C experienced a quick growth of L. monocytogenes. Both antimicrobial packaging and pressurization delayed the growth of the pathogen. However, at 6 degrees C the combination of antimicrobial packaging and HPP was necessary to achieve a reduction of inoculated levels without recovery during 60 days of storage. Further storage at 6 degrees C of pressurized antimicrobial packed cooked ham resulted in L. monocytogenes levels below the detection limit (day 90). On the other hand, storage at 1 degrees C controlled the growth of the pathogen until day 39 in non-pressurized ham, while antimicrobial packaging and storage at 1 degrees C exerted a bacteriostatic effect for 60 days. All HPP lots stored at 1 degrees C led to counts <100CFU/g at day 60. Similar results were observed when combining both technologies. After a cold chain break no growth of L. monocytogenes was observed in pressurized ham packed with antimicrobial films, showing the efficiency of combining both technologies.     

Inhibition of Listeria monocytogenes in cooked ham through active packaging with natural antimicrobials and high-pressure processing

Enterocins A and B and sakacin K at 200 and 2,000 activity units (AU)/cm2, nisin at 200 AU/cm2, 1.8% potassium lactate, and a combination of 200 AU/cm2 of nisin and 1.8% lactate were incorporated into interleavers, and their effectiveness against Listeria monocytogenes spiked in sliced, cooked ham was evaluated. Antimicrobial-packaged cooked ham was then subjected to high-pressure processing (HPP) at 400 MPa. In nonpressurized samples, nisin plus lactate-containing interleavers were the most effective, inhibiting L. monocytogenes growth for 30 days at 6 degrees C, with counts that were 1.9 log CFU/g lower than in the control after 3 months. In the other antimicrobial-containing interleavers, L. monocytogenes did not exhibit a lag phase and progressively grew to levels of about 8 log CFU/g. HPP of actively packaged ham slices reduced Listeria populations about 4 log CFU/g in all batches containing bacteriocins (i.e., nisin, sakacin, and enterocins). At the end of storage, L. monocytogenes levels in the bacteriocin-containing batches were the lowest, with counts below 1.51 log CFU/g. In contrast, HPP moderately reduced L. monocytogenes counts in the control and lactate batches, with populations gradually increasing to about 6.5 log CFU/g at the end of storage.     

Physical performance of biodegradable films intended for antimicrobial food packaging

Antimicrobial films were prepared by including enterocins to alginate, polyvinyl alcohol (PVOH), and zein films. The physical performance of the films was assessed by measuring color, microstructure (SEM), water vapor permeability (WVP), and tensile properties. All studied biopolymers showed poor WVP and limited tensile properties. PVOH showed the best performance exhibiting the lowest WVP values, higher tensile properties, and flexibility among studied biopolymers. SEM of antimicrobial films showed increased presence of voids and pores as a consequence of enterocin addition. However, changes in microstructure did not disturb WVP of films. Moreover, enterocin-containing films showed slight improvement compared to control films. Addition of enterocins to PVOH films had a plasticizing effect, by reducing its tensile strength and increasing the strain at break. The presence of enterocins had an important effect on tensile properties of zein films by significantly reducing its brittleness. Addition of enterocins, thus, proved not to disturb the physical performance of studied biopolymers. Development of new antimicrobial biodegradable packaging materials may contribute to improving food safety while reducing environmental impact derived from packaging waste. Practical Application: Development of new antimicrobial biodegradable packaging materials may contribute to improving food safety while reducing environmental impact derived from packaging waste.     

High hydrostatic pressure and biopreservation of dry-cured ham to meet the Food Safety Objectives for Listeria monocytogenes

This work aimed to evaluate the effect of nisin application (biopreservation) combined with high hydrostatic pressure processing (HHP) on the behavior of Listeria monocytogenes CTC1034 intentionally inoculated (at ca. 10(7)cells/g) onto the surface of ready-to-eat (RTE) sliced dry-cured ham. Two types of dry-cured ham, which had different water activities and fat contents were studied (a(w) of 0.92 and 14.25% fat and a(w) of 0.88 and 33.26% fat). Three batches were prepared for each type of product: (C) control, without nisin; (N) nisin directly applied (200 AU/cm(2)) and (F) nisin applied through active packaging, polyvinyl alcohol films with 200 AU/cm(2). Half of the samples were pressurized at 600 MPa for 5min. Counts of L. monocytogenes were periodically monitored throughout 60 days of storage at 8°C. The physico-chemical characteristics of the products enabled the survival of L. monocytogenes, but it was significantly reduced by the presence of nisin. The effect of biopreservation was greater when applied directly to the surface and in the product with lower water activity in comparison with the active packaging and the high water activity products, respectively. The immediate inactivation of L. monocytogenes by HHP ranged from 1.82 to 3.85 Log units, depending on the type of dry-cured ham. The lower the water activity, the less was the inactivation induced by HHP, both immediately and during storage. The reduction of L. monocytogenes immediately after HHP and during storage was more evident in batches with nisin applied directly to the surface of the product. The pathogen was not detected in some samples from day 5 of storage in the product with higher water activity. The effect of nisin applied through active packaging was lower than the direct application. The results of the present study indicated that HHP, as post-processing listericidal treatment, is more effective (both immediately and long term) than the use of nisin as an antimicrobial measure. However, the both hurdles combined (i.e. biopreservation and HHP) provided a wider margin of safety in the control of L. monocytogenes during the storage of RTE cured meat products.     

Application of enterocins as biopreservatives against Listeria innocua in meat products

The antilisterial effect of enterocins A and B in meat and meat products (cooked ham, minced pork meat, deboned chicken breasts, paté, and slightly fermented sausages [espetec]) have been shown. An infective dose of 5 to 10 most probable numbers (MPN)/g to simulate the counts of Listeria generally found in meat products was used. Enterocins at 4,800 AU/g reduced the numbers of Listeria innocua by 7.98 log cycles in cooked ham and by 9 log cycles in paté when stored at 7 degrees C for 37 days. In deboned chicken breasts stored at 70 degrees C for 7 days, 4,800 AU/cm2 of enterocins diminished the L. innocua counts in 5.26 log cycles when compared to the control batch. In minced pork meat held at 7 degrees C for up to 6 days, 1,600 AU/g kept L. innocua counts under 3 MPN/g, while the control batch reached 50 CFU/g. In espetec sausages, 648 AU/g diminished the number of L. innocua under 50 CFU/g from the fifth day until the end of the process (12 days) while the control batch kept the initial counts (3 x 104 CFU/g). This is the first report on enterocins showing an antilisterial effect in different types of meat products.     

Control of Listeria monocytogenes on ham steaks by antimicrobials incorporated into chitosan-coated plastic films

Contamination of ready-to-eat (RTE) meat products such as ham steaks with Listeria monocytogenes has been a concern for the meat processing industry. The objective of this study was to evaluate the antilisterial efficacy of chitosan-coated plastic films alone or incorporating five generally recognized as safe (GRAS) antimicrobials. Effect of chitosan-coated plastic film on the growth of L. monocytogenes was first investigated in an aqueous system of culture medium broth and chitosan-coated films were able to inhibit the growth of L. monocytogenes in a concentration-dependent manner. However, chitosan-coated plastic films were not able to control the growth of L. monocytogenes on ham steaks. Therefore, five GRAS antimicrobials were subsequently incorporated into chitosan-coated plastic films to enhance their antilisterial effectiveness. Ham steaks were surface-inoculated with a five-strain cocktail of L. monocytogenes and then packaged in chitosan-coated plastic films containing 500 IU/cm(2) of nisin, 0.01 g/cm(2) of sodium lactate (SL), 0.0025 g/cm(2) of sodium diacetate, 0.003 g/cm(2) of potassium sorbate (PB), or 0.001 g/cm(2) of sodium benzoate (SB). The samples were stored at room temperature (ca. 20 degrees C) for 10 days. Incorporating antimicrobials into chitosan-coated plastic films slowed down or inhibited the growth of L. monocytogenes. The chitosan-coated plastic film containing SL was the most effective antimicrobial film and its efficacy against L. monocytogenes on ham steaks was evaluated during 12-week storage at 4 degrees C. The film showed excellent long-term antilisterial effect with the counts of L. monocytogenes being slightly lower than the initial inoculum. Chitosan-coated plastic films containing 0.001 g/cm(2) of SL have a potential to be used on ham steaks to control L. monocytogenes.     

Antimicrobial activity of lauric arginate-coated polylactic acid films against Listeria monocytogenes and Salmonella typhimurium on cooked sliced ham

A novel type of environmentally friendly packaging with antibacterial activity was developed from lauric arginate (LAE)-coating of polylactic acid (PLA) films after surface activation using a corona discharge. Scanning electron microscopy (SEM)-based analysis of the LAE/PLA films confirmed the successful coating of LAE on the PLA surface. The mechanical properties of the LAE/PLA films with different levels of LAE-coating (0% to 2.6%[w/w]) were essentially the same as those of the neat PLA film. The antibacterial activity of the LAE/PLA films against Listeria monocytogenes and Salmonella enterica Serovar Typhimurium (S. Typhimurium) was confirmed by a qualitative modified agar diffusion assay and quantitative JIS Z 2801:2000 method. Using the LAE/PLA film as a food-contact antimicrobial packaging for cooked cured ham, as a model system, suggested a potential application to inhibit L. monocytogenes and S. Typhimurium on ham with a 0.07% (w/w) LAE coating on the PLA when high transparency is required, as evidenced from the 2 to 3 log CFU/tested film lower pathogen growth after 7 d storage but even greater antibacterial activity is obtained with a LAE coating level of 2.6% (w/w) but at the cost of a reduced transparency of the finished product. This article shows how we can simply develop functional green packaging of PLA for food with effective and efficient antimicrobial activity by use of LAE coating on the surface via corona discharge. PRACTICAL APPLICATION: The effectiveness of an innovative antimicrobial LAE-coated PLA film against foodborne pathogens was demonstrated. Importantly, the application of the LAE to form the LAE-coated PLA film can be customized within current film manufacturing lines.     

乳酸菌细菌素和超高压联合处理对低温切片火腿的防腐保鲜效果

为了揭示乳酸菌细菌素和超高压联合处理对低温切片火腿的防腐保鲜效果,并探讨乳酸菌细菌素和超高压联合处理在低温肉制品防腐保鲜应用中的可行性,在不添加任何化学防腐剂的情况下,分别以乳酸菌细菌素(enterocin LM-2)添加量320AU/g、600MPa超高压处理5min以及两者联合处理低温切片火腿,考察联合处理对样品中微生物数量、理化指标以及感官特性的影响。结果表明：enterocin LM-2和超高压技术的联合使用可明显延长低温切片火腿的货架期,有效减少贮藏过程中挥发性盐基氮的生成及脂肪氧化,并保持产品原有色泽、气味、质构等感官特性。综合微生物和理化特性分析结果,联合处理组的防腐效果最好,可将低温切片火腿的货架期延长至100d。     

Evaluation of a challenge testing protocol to assess the stability of ready-to-eat cooked meat products against growth of Listeria monocytogenes

Challenge testing of ready-to-eat (RTE) foods with Listeria monocytogenes is recommended to assess the potential for growth. The present study was undertaken to evaluate a protocol for challenge testing applied to RTE cooked meat products. In order to choose L. monocytogenes strains with a representative behaviour, initially, the variability of the response of multiple L. monocytogenes strains of human and food origin to different stress and growth conditions was established. The strains were not inhibited in their growth at moderate acid pH (5.25) and the four strains tested in particular showed a similar acid-adaptive response. Growth of the various strains under four different combined stress conditions indicated that no L. monocytogenes strain had consistently significant longer or shorter lag phase or higher or lower maximum specific growth rates. The effect of choice of strain and history (pre-incubation temperature 7 or 30 degrees C) on growth of L. monocytogenes under optimum conditions (Brain Heart Infusion, BHI) and modified BHI simulating conditions of cooked ham and paté was studied. In general, all four L. monocytogenes strains behaved similarly. In BHI, no difference in lag phase was observed for the cold-adapted and standard inoculum, whereas in BHI adjusted to ham and paté conditions, a ca. 40-h reduction of the lag phase was noted for the cold-adapted inoculum. Subsequently, microbial challenge testing of L. monocytogenes in modified atmosphere packaged sliced cooked ham and paté was performed. A mixed inoculum of four L. monocytogenes strains and an inoculum level of ca. 1-10 cfu/g was used. On vacuum packed sliced cooked ham, the concentration of 100 cfu/g, the safety limit considered as low risk for causing listeriosis, was exceeded after 5 days whereas ca. 10(5) cfu/g were obtained after 14 days when also LAB spoilers reached unacceptable numbers (ca. 10(7) cfu/g) whether standard or cold-adapted inoculum was used. The concentration of sodium lactate determined the opportunities for growth of L. monocytogenes in paté. If growth of L. monocytogenes in paté was noticed, the threshold of 100 cfu/ml was crossed earlier for the cold-adapted inoculum compared to the standard inoculum.     

Protective cultures inhibit growth of Listeria monocytogenes and Escherichia coli O157:H7 in cooked, sliced, vacuum- and gas-packaged meat

Contamination of cooked meat products with Listeria monocytogenes poses a constant threat to the meat industry. The aim of this study was therefore to investigate the use of indigenous lactic acid bacteria (LAB) as protective cultures in cooked meat products. Cooked, sliced, vacuum- or gas-packaged ham and servelat sausage from nine meat factories in Norway were inoculated with 10(3) cfu/g of a mixture of three rifampicin resistant (rif-mutant) strains of L. monocytogenes and stored at 8 degrees C for four weeks. Growth of L. monocytogenes and indigenous lactic acid flora was followed throughout the storage period. LAB were isolated from samples where L. monocytogenes failed to grow. Five different strains growing well at 3 degrees C. pH 6.2, with 3% NaCl, and producing moderate amounts of acid were selected for challenge experiments with the rif-resistant strains of L. monocytogenes. a nalidixic acid/streptomycin sulphate-resistant strain of Escherichia coli O157:H7 and a mixture of three rif-resistant strains of Yersinia enterocolitica O:3. All five LAB strains inhibited growth of both L. monocytogenes and E. coli O157:H7. No inhibition of Y. enterocolitica O:3 was observed. A professional taste panel evaluated cooked, sliced, vacuum-packaged ham inoculated with each of the five test strains after storage for 21 days at 8 degrees C. All samples had acceptable sensory properties. The five LAB strains hybridised to a 23S rRNA oligonucleotide probe specific for Lactobacillus sakei. These indigenous LAB may be used as protective cultures to inhibit growth of L. monocytogenes and E. coli O157:H7 in cooked meat products.     

超高压协同温度处理对烟熏火腿中单增李斯特菌生长预测模型的建立

为了建立超高压协同温度处理烟熏火腿中单增李斯特菌生长预测模型。本研究分别以20、30、40、50℃结合600MPa对接种106cfu/g单增李斯特菌烟熏切片火腿进行5min的超高压处理,4℃贮藏条件下,每10d测定处理后样品中单增李斯特菌的数量。结果表明:当超高压协同处理的温度高于40℃时显著延长了单增李斯特菌在烟熏火腿修复生长的延滞期,所得生长曲线用修正的Gompertz模型进行了拟合,在35、45d进行验证,建立了烟熏火腿中单增李斯特菌在超高压协同温度处理后的生长预测模型,经验证其精确因子(Af)、偏差因子(Bf)、根平均方差(RMSE)和决定系数(R2)均在较好范围内,能较好的模拟单增李斯特菌的生长情况,为低温肉制品中单增李斯特菌的控制提供理论参考。     

Shelf life evaluation for ready-to-eat sliced uncured turkey breast and cured ham under probable storage conditions based on Listeria monocytogenes and psychrotroph growth

The growth variability of three Listeria monocytogenes ribotypes in ready-to-eat (RTE) sliced uncured turkey breast and cured ham was studied under storage conditions that RTE foods are likely to encounter. Three product treatments studied were: (1) a control; (2) a formulation subjected to high pressure processing to reduce initial microbial load (HPP); (3) a formulation containing 2.0% potassium lactate and 0.2% sodium diacetate (PL/SD). After separate inoculation with individual L. monocytogenes ribotypes and packaging each treatment under air and vacuum, the packages were stored at 4, 8, or 12 degrees C and the counts of L. monocytogenes and psychrotrophic bacteria (PPC) were determined for several weeks. The Baranyi model was used to estimate lag times and growth rates. Significant effect of strain difference was noted in both sliced products (P<0.05). In the absence of antimicrobials (HPP and control), the growth rate (GR) of L. monocytogenes strains increment from 4 to 8 degrees C and from 8 to 12 degrees C was approximately 10 and 2 fold, respectively. The addition of PL/SD was effective in restricting the growth of L. monocytogenes and PPC at 4 degrees C, but at 8 and 12 degrees C significant growth was observed (more than 100-fold increase) (P<0.05). In PL/SD samples, vacuum packaging slowed down the onset and the rate of growth of L. monocytogenes at 12 degrees C in sliced ham and at 8 and 12 degrees C in sliced turkey breast. Generally, the time to increase by 2-logs was greater in control samples than as observed in HPP-treated samples. When antimicrobials were present, the current results showed that L. monocytogenes was able to grow more than 100-fold within the typical quality-based shelf life of 60 to 90 days at 8 and 12 degrees C. The findings of this study should be useful in setting the duration of a safety-based shelf life for RTE sliced meat and poultry foods.     

Inactivation of Listeria monocytogenes on ham and bologna using pectin-based apple, carrot, and hibiscus edible films containing carvacrol and cinnamaldehyde

Edible films can be used as wrapping material on food products to reduce surface contamination. The incorporation of antimicrobials into edible films could serve as an additional barrier against pathogenic and spoilage microorganisms that contaminate food surfaces. The objective of this study was to investigate the antimicrobial effects of carvacrol and cinnamaldehyde, incorporated into apple, carrot, and hibiscus-based edible films against Listeria monocytogenes on contaminated ham and bologna. Ham or bologna samples were inoculated with L. monocytogenes and dried for 30 min, then surface wrapped with edible films containing the antimicrobials at various concentrations. The inoculated, film-wrapped samples were stored at 4 °C. Samples were taken at day 0, 3, and 7 for enumeration of surviving L. monocytogenes by plating on appropriate media. Carvacrol films showed better antimicrobial activity than cinnamaldehyde films. Compared to control films without antimicrobials, films with 3% carvacrol induced 1 to 3, 2 to 3, and 2 to 3 log CFU/g reductions on ham and bologna at day 0, 3, and 7, respectively. Corresponding reductions with 1.5% carvacrol were 0.5 to 1, 1 to 1.5, and 1 to 2 logs, respectively. At day 7, films with 3% cinnamaldehyde reduced L. monocytogenes population by 0.5 to 1.5 and 0.5 to 1.0 logs on ham and bologna, respectively. Inactivation by apple films was greater than that by carrot or hibiscus films. Apple films containing 3% carvacrol reduced L. monocytogenes population on ham by 3 logs CFU/g on day 0 which was 1 to 2 logs greater than that by carrot and hibiscus films. Films were more effective on ham than on bologna. The food industry and consumers could use these films to control surface contamination by pathogenic microorganisms. PRACTICAL APPLICATION: Antimicrobial edible, food-compatible film wraps prepared from apples, carrots, and hibiscus calyces can be used by the food industry to inactivate Listeria monocytogenes on widely consumed ready to eat meat products such as bologna and ham. This study provides a scientific basis for large-scale application of edible fruit- and vegetable-based antimicrobial films on foods to improve microbial food safety.     

Fate of Listeria monocytogenes in commercial ham, formulated with or without antimicrobials, under conditions simulating contamination in the processing or retail environment and during home storage

Commercial cured ham formulated with or without potassium lactate and sodium diacetate was inoculated with Listeria monocytogenes and stored to simulate conditions of processing, retail, and home storage. The ham was sliced, inoculated with a 10-strain composite of L. monocytogenes (1 to 2 log CFU/cm2), vacuum packaged, and stored at 4 degrees C to simulate contamination following lethality treatment at processing (first shelf life). After 10, 20, 35, and 60 days of storage, packages were opened, samples were tested, and bags with remaining slices were reclosed with rubber bands. At the same times, portions of original product (stored at 4 degrees C in original processing bags) were sliced, inoculated, and packaged in delicatessen bags to simulate contamination during slicing at retail (second shelf life). Aerobic storage of both sets of packages at 7 degrees C for 12 days was used to reflect domestic storage conditions (home storage). L. monocytogenes populations were lower (P < 0.05) during storage in ham formulated with lactate-diacetate than in product without antimicrobials under both contamination scenarios. Inoculation of ham without lactate-diacetate allowed prolific growth of L. monocytogenes in vacuum packages during the first shelf life and was the worst case contamination scenario with respect to pathogen numbers encountered during home storage. Under the second shelf life contamination scenario, mean growth rates of the organism during home storage ranged from 0.32 to 0.45 and from 0.18 to 0.25 log CFU/cm2/day for ham without and with lactate-diacetate, respectively, and significant increases in pathogen numbers (P < 0.05) were generally observed after 4 and 8 days of storage, respectively. Regardless of contamination scenario, 12-day home storage of product without lactate-diacetate resulted in similar pathogen populations (6.0 to 6.9 log CFU/cm2) (P > 0.05). In ham containing lactate-diacetate, similar counts were found during the home storage experiment under both contamination scenarios, and only in 60-day-old product did samples from the first shelf life have higher (P < 0.05) pathogen numbers than those found in samples from the second shelf life. These results should be useful in risk assessments and for the establishment of "sell by" and "consume by" date labels for refrigerated ready-to-eat meat products.     

Inhibition of Listeria monocytogenes and Salmonella by natural antimicrobials and high hydrostatic pressure in sliced cooked ham

The effectiveness of nisin, lactate salts, and high hydrostatic pressure to inhibit the growth of Listeria monocytogenes and Salmonella in sliced cooked ham was studied through a combination of PCR-based detection methods, most probable number, and classical microbial enumeration techniques (International Organization for Standardization protocols). A synergistic effect to inhibit a cocktail of Listeria monocytogenes CTC1010, CTC1011, and CTC1034 was observed between potassium lactate, high hydrostatic pressure (400 MPa, 17 degrees C, 10 min), and low storage temperature when sliced cooked ham was stored for 84 days at 1 degrees C. The high hydrostatic pressure treatment also proved to be useful to inhibit a cocktail of Salmonella enterica serotypes London CTC1003, Schwarzengrund CTC1015, and Derby CTC1022.     

Effectiveness of chitosan-coated plastic films incorporating antimicrobials in inhibition of Listeria monocytogenes on cold-smoked salmon

The objective of this study was to evaluate the efficacy of chitosan-coated plastic films incorporating five Generally Recognized as Safe (GRAS) antimicrobials (nisin, sodium lactate (SL), sodium diacetate (SD), potassium sorbate (PS) and sodium benzoate (SB)) against Listeria monocytogenes on cold-smoked salmon. Salmon samples were surface-inoculated with a five-strain cocktail of L. monocytogenes and packaged in chitosan-coated plastic films containing 500 IU/cm(2) of nisin, 9 mg/cm(2) of SL, 0.5 mg/cm(2) of SD, 0.6 mg/cm(2) of PS, or 0.2 mg/cm(2) of SB, and stored at room temperature (ca. 20 degrees C) for 10 days. The film incorporating SL was the most effective, completely inhibiting the growth of L. monocytogenes during 10 days of storage. L. monocytogenes in samples packaged in the other four antimicrobial films grew, but the increase in counts was lower than the control. The antilisterial efficacy of films containing lower concentrations of SL (2.3 mg/cm(2) and 4.5 mg/cm(2)) and binary combinations SL, PS, SD, SB and nisin were subsequently evaluated. Among all the treatments, chitosan-coated plastic films with 4.5 mg/cm(2) SL, 4.5 mg/cm(2) SL-0.6 mg/cm(2) PS and 2.3 mg/cm(2) SL-500 IU/cm(2) nisin were the most effective. These three most effective antimicrobial films were then tested at refrigerated temperature. They completely inhibited the growth of L. monocytogenes on smoked salmon for at least 6 weeks. Chitosan-coated plastic films containing 4.5 mg/cm(2) SL can potentially assist the smoked-salmon processing industry in their efforts to control L. monocytogenes.     

Effects of sodium lactate and other additives in a cooked ham product on sensory quality and development of a strain of Lactobacillus curvatus and Listeria monocytogenes.

Cooked cured ham products were produced according to a standard recipe for cooked ham with various levels of sodium lactate, sodium diacetate or buffered sodium citrate. They were compared with a reference ham product with respect to sensory quality and growth of Lactobacillus curvatus and Listeria monocytogenes. For this, a part of the products was sensory analysed directly after preparation. Another part of the cooked ham products was minced and homogeneously inoculated with L. curvatus (10(4)/g) and L. monocytogenes (10(2)/g) and filled in 60-g plastic pouches. After vacuum packaging, the pouches were stored at 4 degrees C for up to 40 days. Between the different ham compositions, only minor differences were found for appearance, internal colour, structure and firmness. The addition of 0.2% Na-diacetate had a negative effect on the odour and taste of the ham product. The addition of 2.5% to 3.3% Na-lactate inhibited the growth of L. curvatus compared to the reference, while 0.1% and 0.2% Na-diacetate did not. L. monocytogenes was best inhibited by the addition of Na-lactate but also by the addition of 0.2% Na-diacetate. On the other hand, the growth of L. monocytogenes was stimulated by the addition of 1% buffered Na-citrate.     

Eradicating Listeria monocytogenes from fully cooked franks by using an integrated pasteurization-packaging system

Surface pasteurization by applying steam or hot water before or after packaging of processed foods may be used to eliminate pathogens such as Listeria monocytogenes from ready-to-eat meat and poultry products. Surface pasteurization treatment with a mixture of pressurized steam and hot water was integrated into a continuous vacuum-packaging system to reduce L. monocytogenes from fully cooked franks. The franks (2.54 cm diameter by 15.24 cm length) were surface inoculated to contain up to 6 log CFU/cm2 L. monocytogenes. The inoculated franks were treated at 121 degrees C for 1.5 s in an arrangement of six franks per packaging chamber followed by immediate vacuum sealing of the top films of food packages in the same unit. A 3-log CFU/cm2 reduction of L. monocytogenes on fully cooked franks was obtained using the integrated pasteurization-packaging system. The pasteurization depth was 1.27 mm below the surfaces of the franks. This process provides a commercially applicable means of ensuring food safety by effectively eradicating L. monocytogenes from ready-to-eat meat and poultry products at the very last possible step of food packaging before reaching retail consumers.     

Antimicrobial effects of corn zein films impregnated with nisin, lauric acid, and EDTA

Bacterial growth during food transport and storage is a problem that may be addressed with packaging materials that release antimicrobials during food contact. In a series of five experiments, EDTA, lauric acid (LA), nisin, and combinations of the three antimicrobial agents were incorporated into a corn zein film and exposed to broth cultures of Listeria monocytogenes and Salmonella Enteritidis for 48 h (sampled at 2, 4, 8, 12, 24, and 48 h). Four experiments used starting cultures of 10(8) CFU/ml in separate experiments tested against each bacterium; the fifth experiment examined the inhibitory effect of selected antimicrobial agents on Salmonella Enteritidis with an initial inoculum of 10(4) CFU/ml. L. monocytogenes cell numbers decreased by greater than 4 logs after 48 h of exposure to films containing LA and nisin alone. No cells were detected for L. monocytogenes (8-log reduction) after 24-h exposure to any film combination that included LA. Of all film agent combinations tested, none had greater than a 1-log reduction of Salmonella Enteritidis when a 10(8)-CFU/ml broth culture was used. When a 10(4) CFU/ml of Salmonella Enteritidis initial inoculum was used, the films with EDTA and LA and EDTA, LA, and nisin were bacteriostatic. However, there was a 5-log increase in cells exposed to control within 24 h. The results demonstrate bacteriocidal and bacteriostatic activity of films containing antimicrobial agents.     

Antimicrobial effects of alginate-based films containing essential oils on Listeria monocytogenes and Salmonella typhimurium present in bologna and ham

Bologna and ham slices (300 of each) were inoculated with Salmonella Typhimurium or Listeria monocytogenes at 10(3) CFU/cm(2). Alginate-based edible films that had been immersed in a 2 or 20% (wt/vol) CaC12 solution and contained 1% (wt/ vol) essential oils of Spanish oregano (O; Corydothymus capitatus), Chinese cinnamon (C; Cinnamomum cassia), or winter savory (S; Satureja montana) were then applied to slices to control pathogen growth. On bologna, C-based films pretreated with 20% CaC12 were the most effective against the growth of Salmonella Typhimurium and L. monocytogenes. L. monocytogenes was the more sensitive bacterium to O-, C-, and S-based films. L. monocytogenes concentrations were below the detection level (<10 CFU/ml) after 5 days of storage on bologna coated with O-, C-, or S-based films pretreated with 20% CaCl2. On ham, a 1.85 log CFU/cm2 reduction of Salmonella Typhimurium (P < 0.05) was found after 5 days of storage with C-based films regardless of the type of pretreatment used (2 or 20% CaC12) or when coated with O-based films pretreated with 20% CaCl2. L. monocytogenes was highly resistant in ham, even in the presence of O-, C-, or S-based films. However, C-based films pretreated with 20% CaCl2 were the most effective against the growth of L. monocytogenes. Evaluation of the availability of active compounds in films revealed a significantly higher release of active compounds in C-based films (P < 0.05) regardless of pretreatment or meat tested (bologna or ham). O-based films had the lowest release level of active compounds. The release of active compounds from O- and S-based films pretreated with 20% CaCl2 was faster than that in the same respective films pretreated with 2% CaCl2 regardless of the meat type. C-based film pretreated by immersion in a 20% CaCl2 solution was most efficient against both pathogens, and migration of active compounds was higher in C-based films than in O- and S-based films.