冷却方式对焙烧鲕状赤铁矿磨矿性能影响

鲕状赤铁矿有用矿物嵌布粒度细,磨矿成本高,属于典型难选铁矿石。磁化焙烧-磁选工艺是分选此类难选铁矿石的有效方法,研究了不同冷却方式对磁化焙烧矿的磨矿性能产生的影响.鲕状赤铁矿进行磁化焙烧后分别隔绝空气密闭冷却、水淬及空气中自然冷却,进行粒度筛析和磨矿试验.发现焙烧后矿石粒径变粗,从原矿的平均粒径为0.069 9mm至密闭冷却、水冷和自然冷却焙烧矿的0.088 2mm、0.084 3mm、0.087 0mm.相同磨矿条件下,原矿、密闭冷却焙烧矿、水冷焙烧矿和自然冷却焙烧矿-0.045mm含量分别为84.89%、83.89%、76.51%、77.14%.表明磁化焙烧使鲕状赤铁矿变得更为难磨,密闭冷却时磨矿效果最佳,自然冷却次之,水冷最差.     

Magnetizing roasting mechanism and effective ore dressing process for oolitic hematite ore

Magnetizing roasting of oolitic hematite ore from western Hubei Province was investigated.The mechanism for reduction roasting of oolitic hematite ore was discussed and analyzed.It is found that flash magnetizing roasting-magnetic separation process is a promising approach for the processing of oolitic hematite ore from western Hubei Province.     

某鲕状赤铁矿流化床燃煤还原焙烧-磁选研究

运用小型循环流化床锅炉,针对铁品位为49.20%、磷质量分数为1.16%的湖北某鲕状赤铁矿进行磁化焙烧-磁选试验研究.试验结果表明,将粒径为106～150 μm的鲕状赤铁矿在700 ℃下焙烧15 min,选取磨矿后粒径在74 μm以下的颗粒质量分数为85%的焙烧矿物,运用湿式磁选管在139.22 kA/m的磁场强度下对筛选后的焙烧矿物进行磁选抛尾,可以获得铁品位为55.12%、全铁回收率为70.11%、磷质量分数为0.67%的铁精矿.研究表明,运用循环流化床局部还原性气氛高速磁化焙烧铁矿石是可行的,运用该磁化焙烧-磁选工艺流程可以达到一定的提铁降磷效果.     

Effect of coal levels during direct reduction roasting of high phosphorus oolitic hematite ore in a tunnel kiln

The effect of coal levels on phosphorus removal from a high phosphorus oolitic hematite ore after direct reduction roasting have been investigated. Raw ore, coal, and a dephosphorization agent were mixed and the mixture was then roasted in a tunnel kiln. The roasted products were treated by two stages of grinding followed by magnetic separation. XRD and SEM–EDS examination of the products was used to analyze differences in the roasted products. The results show that coal is one of the most important factors affecting the direct reduction roasting process. When the inner coal levels increased from 0% to 15% the iron grade decreased linearly from 94.94% to 88.81% and the iron recovery increased from 55.94% to 92.94%. At the same time the phosphorus content increased from 0.045% to 0.231%. Increasing the inner coal levels also caused more hematite to be reduced to metallic iron but the oolitic structure of the roasted product was preserved in the presence of high coal loading. The phase of the phosphorus in raw ore was not changed after direct reduction roasting. The effect of coal on the phosphorus content in the H-concentrate arises from changes in the difficulty of mechanically liberating the metallic iron from the phosphorus bearing minerals.     

高磷铁矿碳热还原同步脱磷的实验研究

为探索高磷铁矿的有效利用途径,对高磷鲕状赤铁矿进行碳热还原同步脱磷实验研究,在含碳球团中添加CaO和Na2C O3作为脱磷剂,采用D T A-T G- M S综合热分析、X R D、SE M、E DS等方法分别对高磷鲕状赤铁矿的碳热还原过程以及还原产物进行分析. 结果表明,添加适量的CaO和Na2C O3可以显著提高脱磷率;在1 573 K、Na2C O3添加量为2 %、含碳球团碱度为1 .2的条件下,高磷鲕状赤铁矿能够被快速还原成含磷0 .09 %、含碳4 .6 %的碳饱和铁,脱磷率达到95 %;生铁中碳过饱和后以片状石墨的形态析出,生铁中的磷以夹杂物Ca3（P O4）2和Na2Ca4（P O4）2SiO4的形式存在     

我国钢铁发展对铁矿石选矿科技发展的影响

分析了我国钢铁快速增长情况下国产铁矿石生产和进口铁矿石的比例增长情况。对我国磁铁矿石提铁降硅选矿工艺和阴离子反浮选、强磁选———细筛、磁化焙烧等难选红铁矿选矿关键技术应用现状进行了分析,对选矿设备的发展动态进行了探讨,并展望了闪速磁化焙烧等复杂难选铁矿选矿技术发展前景,提出了急待解决的高效细磨设备、耐磨防堵的细筛网、磁化焙烧新装备、反浮选浮选柱、新型磁化率计、磁铁矿阳离子反浮选药剂的研究等重要问题。     

Effect of Na<Subscript>2</Subscript>CO<Subscript>3</Subscript> and CaCO<Subscript>3</Subscript> on coreduction roasting of blast furnace dust and high-phosphorus oolitic hematite

Iron was recovered from blast furnace dust and high-phosphorus oolitic hematite in the presence of Na₂CO₃ and CaCO₃ additives. The functions of Na₂CO₃ and CaCO₃ during the coreduction roasting process were investigated by XRD and SEM-EDS analyses. Results indicate that these additives not only hinder the reduction of fluorapatite, CaCO₃ also decreases the P content of direct reduced iron (DRI) by increasing the reduction alkalinity. P remains as fluorapatite in the slag, which can be removed by grinding and magnetic separation under optimal conditions. The Na₂CO₃ promotes hematite reduction and improves the iron recovery (ε_Fe) by replacing the FeO from fayalite, which results in quick growth and aggregation of metallic iron and improvement of ε_Fe in DRI. A DRI with 91.88 mass% Fe, and 0.065 mass% P can be achieved at a recovery of 87.86 mass% under the optimal condition.     

Effect of bastnaesite as reductant on hematite reduction during in-situ suspension magnetization roasting of refractory iron ore under neutral atmosphereOA

The iron tailings of Bayan Obo mines are solid waste,which occupies land area and also causes environmental pollution;however,this waste can be recycled.In this study,based on the characteristics of iron minerals and fluorocarbonate contained in Bayan Obo iron tailings,clean magnetization roasting of iron minerals by bastnaesite from iron tailings during in-situ suspension magnetization roasting in a neutral atmosphere was explored.The results show that for iron tailings with a mass of 12 g, a N...     

Mechanism for suspension magnetization roasting of iron ore using straw-type biomass reductant

As an alternative reductant for fossil fuel in the future, straw-type biomass contributes to emission reduction and green utilization in the suspension roasting process. In this study, the influences of the roasting time, roasting temperature and dose of straw-type biomass after suspension magnetization roasting (SMR) and separation were investigated. The optimal conditions were determined to be a roasting time of 7.5 min with a straw-type biomass dose of 20 wt% and a roasting temperature of 800 ℃, in which an iron grade of 71.07% and recovery of 94.17% were obtained for the iron concentrate. The maximum saturation magnetization under optimal conditions was 35.05 A·m²·g⁻¹, and the gaseous regulation of the biomass revealed that cumulative reducing gas volume was 293.93 mL at the optimal roasting time of 450 s. The transformation of hematite to magnetite was detected by X-ray diffraction (XRD). During microstructure evolution, the outer layer consisting of fissures and tiny holes continuously deepened toward the core.     

Two-step flotation recovery of iron concentrate from Donganshan carbonaceous iron ore

The flotation of pure and natural carbonaceous iron ore samples in the oleate flotation system was investigated. Starch can depress hematite effectively in a wide pH range, but cannot depress siderite efficiently in neutral conditions. The flotation recovery of pure hematite, siderite, and quartz in the oleate-starch-CaCl₂ system is significantly different when the slurry pH varies from 4 to 12. A novel two-step flotation process was developed for the separation of iron concentrate from Donganshan carbonaceous iron ore through which the siderite concentrate is first recovered and the high quality hematite concentrates with relative high iron recovery can be obtained in the second step flotation. The siderite concentrate may be utilized directly or undergo further concentration steps to increase iron grade.     

溶磷微生物的选育及除磷研究

从土壤中选育分离出8株溶磷微生物,研究了不同溶磷微生物对磷酸钙的溶解能力,其中菌株XH2对磷酸钙的溶解量最高可达415.69 mg/L。将溶磷微生物应用到高磷鲕状赤铁矿的除磷试验中,结果表明,菌株XH3的除磷最高达到79.58%的理想效果,为高磷铁矿石的脱磷技术提供了新的选择。     

Magnetic and flotation studies of banded hematite quartzite （BHQ） ore for the production of pellet grade concentrate

To identify and establish beneficiation techniques for banded hematite quartzite (BHQ) iron ore, a comprehensive research on BHQ ore treatment was carried out. The BHQ ore was assayed as 38.9wt% Fe, 42.5wt% SiO2, and 1.0wt% Al2O3. In this ore, hematite and quartz are present as the major mineral phases where goethite, martite, and magnetite are present in small amounts. The liberation of hematite particles can be enhanced to about 82% by reducing the particle size to below 63 μm. The rejection of silica par...     

硫酸渣磁化焙烧—磁选提铁降硫

硫酸渣铁品位为55.08％,其中有害元素硫的含量为1.3％.为高效利用硫酸渣,必须提高铁含量、降低硫磷等有害元素.硫酸渣试样直接进行弱磁选,得到铁精矿品位60.54％,精矿回收率仅为54.46％,采用磁化焙烧-弱磁选的方法来进行选铁试验,通过对磁化焙烧时间、磁化焙烧温度、还原剂的质量配比等条件试验,确定了在焙烧时间40 min,焙烧温度750℃,还原剂10％的最佳焙烧条件.焙烧矿磨矿至-0.074 mm 97.02％,用弱磁选管进行磁选的最佳试验条件,在此焙烧条件下,进行一粗一精的磁选,获得了铁品位64.57％,精矿回收率86.99％,硫含量降低到0.13％.     

Magnetic separation studies for a low grade siliceous iron ore sample

Investigations were carried out, on a low grade siliceous iron ore sample by magnetic separation, to establish its amenability for physical beneficiation. Mineralogical studies revealed that the sample consists of magnetite, hematite and goethite as major opaque oxide minerals where as silicates as well as carbonates form the gangue minerals in the sample. Processes involving combination of classification, dry magnetic separation and wet magnetic separation were carried out to upgrade the low grade siliceous iron ore sample to make it suitable as a marketable product. The sample was first ground and each closed size sieve fractions were subjected to dry magnetic separation and it was observed that limited upgradation is possible. The ground sample was subjected to different finer sizes and separated by wet low intensity magnetic separator. It was possible to obtain a magnetic concentrate of 67% Fe by recovering 90% of iron values at below 200 μm size.     

Selective leaching of vanadium from V-Ti magnetite concentrates by pellet calcification roasting-H_2SO_4 leaching process

A novel method of pellet calcification roasting-H_2 SO_4 leaching was proposed to efficiently separate and extract vanadium(V) from vanadium-titanium(V-Ti) magnetite concentrates.The leaching rate of V is as high as 88.98%,while the leaching rate of impurity iron is only 1.79%.Moreover,the leached pellets can be used as raw materials for blast furnace ironmaking after secondary roasting.X-ray photoelectron spectroscopy(XPS) and scanning electron microscopy with energy dispersive X-ray spectrometry(SEMEDS) analyses showed that V~(3+) was oxidized to V~(5+) after roasting at 1200℃,and V~(5+) was then leached by H_2 SO_4.X-ray diffraction(XRD) analyses and single factor experiment revealed a minimal amount of dissolved Fe_2 O_3 during H_2 SO_4 leaching.Therefore,a high separation degree of V and iron(Fe) from V-Ti magnetite concentrate was achieved through H_2 SO_4 leaching.Compared with the traditional roastingleaching process,this process can achieve a high selectivity of V and Fe,and has excellent prospects for industrial production.     

磁化矿石颗粒模型及磁选过程分析

基于磁选过程中颗粒尺寸、磁场强度和磁选精矿品位三者之间的关系,建立磁化矿石颗粒模型,对其进行理论分析与计算,确定最佳磁场强度,并进行磁化矿石的磁选研究。结果表明：在配煤量4%（质量分数）,焙烧温度850℃,焙烧时间60 min,磨矿细度-0.074 mm占60%（质量分数）,磁场强度为40 mT的条件下,得到铁品位57.7%（质量分数）,铁回收率90.3%（质量分数）的铁精矿,较好地实现了铁精矿的富集和回收。     

低品位铁矿石流化焙烧-磁选提质试验研究

针对我国低品位铁矿石嵌布粒度极细,成分复杂,难提难选的现况,运用循环流化床和磁选管进行劣质铁矿石的流化焙烧 磁选试验研究,试验采用CO、N2的混合气体营造还原性气氛（其中CO体积分数为10%）,将粒径为1 mm以下的新疆某低品位铁矿石（原矿铁品位为9.63%）于850 ℃焙烧10 min,得到强磁性的磁铁矿,将焙烧产物破碎细磨（磨至200 目以下占75%）,利用湿式磁选管在71.66 kA/m的磁场强度下进行弱磁选抛尾,可以得到铁精矿品位为46.25%,全铁回收率为25.52%的选矿指标.研究表明,运用循环流化床焙烧-弱磁选的方法提质铁矿石,可以有效地减少焙烧时间,在保证选矿达标的基础上,有效地降低生产周期.     

Evaluation of reduction roasting and magnetic separation for upgrading Mn/Fe ratio of fine ferromanganese

Low grade ferromanganese tailing was subjected to different mineralogical techniques, reduction roasting and magnetic separation to establish whether commercially acceptable manganese qualities and high Mn/Fe ratio could be obtained, and also to determine the best processing route for beneficiating this ore. The main manganese mineral within the feed sample is birnessite, with minor amounts of pyrolusite and todorokite. Size by assay analysis conducted presented a result with a yield of about 35.75% and Mn grade of 27.63% to coarse (?3.35 + 1 mm) and yield of 20.24% and Mn grade of 27.71% to (?1.18 + 0.50 mm) fraction. Two-stage high induced magnetic separations at 16,000 and 11,000 G produces Mn grades with similar grade to that obtained from the ferromanganese feed sample. Reduction roasting followed by magnetic separation on ?1.18 + 0.50 mm at 1000 G recovered 72.31% Mn with a grade of 58.44% Mn, 2.52% Fe and 3.29% Si at Mn/Fe ratio of 23.22. This study reveals the influence of roasting in converting the hematite and goethite to magnetite and the response of the roasted fraction to magnetic separation.     

铁矿粉造球及焙烧实验研究

以4种铁精矿和1种膨润土为原料,按照方案进行造球实验,分析不同方案中粒度、膨润土用量等对生球性能的影响,再通过球团焙烧实验,研究生球的焙烧性能,探索适宜的焙烧条件。结果表明,造球用铁精矿w（〈75μm粒级）≈75%,w（膨润土）=1.7%时,生球落下强度均在3次以上,抗压强度高于14 N;在温度1 150～1 200℃,时间12 min的条件下焙烧生球,获得的球团矿抗压强度高于2 000 N,完全满足工业生产要求。     

Sulfidation roasting of lead and zinc carbonate with sulphur by temperature gradient method

In order to enhance the lead and zinc recovery from the refractory Pb-Zn oxide ore, a new technology was developed based on sulfidation roasting with sulphur by temperature gradient method. The solid-liquid reaction system was established and the sulfidation thermodynamics of lead and zinc carbonate was calculated with the software HSC 5.0. The effects of roasting temperature,molar ratio of sulphur to lead and zinc carbonate and reaction time in the first step roasting, and holding temperature and time in the second roasting on the sulfidation extent were studied at a laboratory-scale. The experimental results show that the sulfidation extents of lead and zinc are 96.50% and 97.29% under the optimal conditions, respectively, and the artificial galena, sphalerite and wurtzite were formed. By the novel sulfidizing process, it is expected that the sulphides can be recovered by conventional flotation technology.