95W-Ni-Fe 合金工艺缺陷的 SAM 和 XPS 分析

藉助扫描俄歇探针、Ｘ射线光电子谱等分析了９５Ｗ－Ｎｉ－Ｆｅ合金碳污染和氧化的本质。发现，碳污染试样中碳的化学状态主要为石墨，少量为铁或镍的有机化合物，这些物质的界面富集使材料脆化。钨合金氧化后，氧大量富集于钨／粘结相界面，使沿着该界面的断裂更容易发生。     

Influence of Rare-earth Elements on Mechanical Properties of Palladium

The influence of 0.1-0.6 at.-%RE additions (RE= La, Ce, Pr, Nd, Sm, Eu, Gd, Tb, Dy, Er, Yb) on themechanical properties of Pd was studied. All above RE additions increased not only the strengthproperties at ambient temperature but also the tensile strength, creep rupture time and activation en-ergy at high temperatures, simultaneously increased the elongation of Pd. In the range of dilute con-centration, the strength properties of Pd-RE alloy enhanced linearly with RE concentration. Whenthe strength properties of Pd-RE alloys were normalized at 0.1 at.-%RE, it was found that light REelements had stronger effect on the properties of Pd than heavy RE, whereas Eu, Yb, Ce had anoma-lous effect. In all Pd-RF alloys, Pd-Eu alloy had the highest strength properties, successively Pd-Yband Pd-Ce alloy. The effect mechanisms of RE in alloy, such as purifying impurities, increasingrecrystallization temperature, refining grain size. expanding crystal lattice, increasing dislocation den-sity and decreasing stacking fault energy, forming stable RE oxidation by internal oxidation, and soon, were observed. They were strengthening sensitive factors. The influence of the factors onstrength properties and elongation of Pd was discussed.     

High concentration erbium doping of silicon-rich SiO2 thin films on silicon

In this work, high concentration erbium doping in silicon-rich SiO₂ thin films is demonstrated. Si plus Er dual-implanted thermal SiO₂ thin films on Si substrates have been fabricated by using a new method, the metal vapor vacuum arc ion source implantation with relatively low ion energy, strong flux and very high dose. X-Ray photoelectron spectroscopy measurement shows that very high Er concentrations on the surfaces of the samples, corresponding to 10 at.% or the doping level of 10²¹ atoms cm⁻³, are achieved. This value is much higher than that obtained by using other fabrication methods such as the high-energy ion implantation and molecular beam epitaxy. Reflective high-energy electron diffraction, atomic force microscopy and cross-section high-resolution transmission electron microscopy observations show that the excess Si atoms in SiO₂ matrix accumulate to form Si clusters and then crystallize gradually into Si nanoparticles embedded in SiO₂ films during dual-ion implantation followed by rapid thermal annealing. Er segregation and precipitates are not formed. Photoluminescence at the wavelength of 1.54 μm exhibits very weak temperature dependence due to the introduction of Si nanocrystals into the SiO₂ matrix. The 1.54-μm light emission signals from annealed samples decrease by less than a factor of 2 when the measuring temperature increases from 77 K to room temperature.     

固体碱催化戊醛缩合的研究

自制了固体碱催化剂用于催化戊醛缩合反应 ,考察了碱金属、载体、反应温度、反应压力、空速等条件对反应的影响。研究表明 ,以介孔分子筛为载体的催化剂活性尤其是低温活性明显高于以硅胶为载体的催化剂。自制的固体碱催化剂性能稳定 ,在 2 0MPa ,2 60℃ ,1 0h-1条件下连续运转 2 7d,仍能保持转化率高于 90 %、选择性约 80 %的良好效果。     

35CrMoCe稀土钢离子硫氮碳复合渗特性研究

采用金相显微镜，Ｘ射线衍射仪，透明电子显微镜，扫描电子显微镜等仪器分析对比３５ＣｒＭｏ钢和３５ＣｒＭｏＣｅ钢离子硫氮碳复合渗特性，探讨了稀土铈和加速离子硫氮碳复合渗的原因，研究结果表明，两种钢的复合渗层均由硫化物层，氮碳化物层的扩展层构成；稀土铈显著地提高了渗层深度，铈具有细化组织的作用，提供了更多可供氮碳原子扩散的通道。     

坐标测量机激光非接触式测头的研制

本文介绍适用子精密大型测试仪器──坐标测量机的激光非接触式测头的研制。该测头采用ＰＳＤ作为敏感元件并采用单片机技术完成对测量数据的处理。     

高温超导红外探测器的电极工艺探讨

介绍了高温超导红外探测器电极材料的选择和制备。选用先蒸、后蒸金，再合金化的电极工艺。芯片装配成器件后，器件性能稳定，膜层牢固，接触电阻小。     

燃油加热炉改烧奥里油的尝试

奥里油是一种含乳化液较多的新油种，作者配合某厂机动处,对该油种进行了理论分析,并在连续加热炉上替代重油燃烧进行了有益的尝试。     

同步辐射X射线光刻掩模镀金工艺的研究

介绍了利用北京正负对撞机(BEPC)同步辐射X射线光刻装置,进行LIGA工艺技术深结构光刻实验研究,详细论述了X射线光刻使用的掩模制备过程及掩模镀金工艺,在国内最早曝光出直径为400μm、厚为27～45μm的三维立体齿轮胶图形。     

Nuclear proteins from liver and kidney bind a 37 bp sequence in the 5' upstream region of the mGAT1 gene

The mouse GABA transporter (mGAT1) gene has been shown to be exclusively expressed in brain by Northern and Western blot analyses. The interactions between the 5' flanking region of the mGAT1 gene and nuclear proteins from different mouse tissues were studied by means of gel-shift assay. Our results show that nuclear protein factors from non-nervous tissues can specifically recognize a 37 bp sequence that is conserved in the 5' flanking region between the human and mouse GAT1 genes. Similar nuclear protein factors were also found to exist in rat, rabbit and pig.