Pressureless sintering and characterization of cordierite/ZrO2 composites

Cordierite/ZrO₂ composites with 5 to 25 wt% ZrO₂ were fabricated by conventional powder mixing and pressureless sintering method. Their densification behavior, microstructure, mechanical and thermal properties were studied. By dispersing 25 wt% (9.57 vol%) ZrO₂, densified cordierite/ZrO₂ composite with a relative density of 98.5% was obtained at an optimum sintering condition of 1440 °C and 2 h. ZrO₂ particles were homogenously dispersed within matrix grains and at the grain boundaries. The intragranular particles were finer than 100 nm and the intergranular particles were coarser. Both fracture strength and toughness could be enhanced more than two times higher, compare to those of monolithic cordierite, by dispersing 25 wt% ZrO₂ into the cordierite matrix. The toughening mechanism in the present composites was mainly attributed to martensitic transformation due to ZrO₂ dispersion. Electronic Publication     

典型含氮有机物的氯消毒副产物生成潜能研究

污水再生利用是解决我国城市水资源短缺的有效途径，消毒是保证再生水水质安全的必要措施。氯消毒可以有效杀灭病原微生物，但同时也会生成各种具有毒性和“三致”效应的消毒副产物。由于含氮有机物是污水氯消毒副产物的一类重要前体物，故选取20种基本氨基酸为研究对象，考察了它们经氯消毒后生成三氯甲烷、卤乙酸、卤乙腈、三氯硝基甲烷、1，1-二氯-2-丙酮和1，1，1-三氯-2-丙酮的潜能。结果表明，各种氨基酸的消毒副产物生成潜能与它们的R基结构密切相关，其中R基上带有活性苯环的色氨酸和酪氨酸均表现出了较高的三氯甲烷、卤乙酸和卤乙腈生成潜能。     

Mercury and selenium concentrations in the internal organs of toothed whales and dolphins marketed for human consumption in Japan

Small cetaceans (toothed whales odontoceti and dolphins delphinidae) have been traditionally hunted along the coast of Japan and fresh red meat and blubber, as well as boiled internal organs such as liver, kidney, lung and small intestine, are still being sold for human consumption. We surveyed mercury contamination in boiled liver, kidney and lung products marketed in Japan between 1999-2001. The average +/- S.D. of total mercury (T-Hg) was 370 +/- 525 (range: 7.60 approximately 1980, n = 26) microg/g in liver, 40.5 +/- 48.5 (7.30-95.1, n = 15) microg/g in kidney and 42.8 +/- 43.8 (2.10-79.6, n = 23) microg/g in lung. A high correlation was observed between T-Hg and selenium (Se) concentrations in these organs, supporting the formation of a Hg-Se complex. The formation of a Hg-Se complex probably contribute to the detoxification of Hg for cetaceans and allows a very large accumulation of Hg in livers. The provisional permitted level of T-Hg in marine foods set by the Japanese Ministry of Health and Welfare is 0.4 microg/ g, and the provisional permitted weekly intake (PTWI) set by WHO is 5 microg/kg bw/week. The maximal T-Hg detected in boiled liver (1,980 microg/g) exceeds the permitted level by approximately 5,000 times and the consumption of only 0.15 g of liver exceeds the PTWI of 60 kg of body weight of the consumer, suggesting the possibility of an acute intoxication by T-Hg even after a single consumption of the product.     

波形测量技术的发展趋势--兼谈YOKOGAWADE的示波器发展

本文着重论述了波形测量技术的最新发展趋势。     

Identification of factors that accelerate hydrogen production by Clostridium butyricum RAK25832 using casamino acids as a nitrogen source

The ability of Clostridium butyricum RAK25832 to use casamino acids as a nitrogen source was investigated. Strain RAK25832 showed the capacity to utilize different types of carbon sources. With glucose as a carbon source (10 g/L), the preferred final concentration of casamino acids was 26.67 g/L, with a cumulative hydrogen production, production rate, and yield of 2505 mL H₂/L, 160 mL/h, and 1.81 mol H₂/mol glucose, respectively. Eighteen metal elements were screened to identify the most important metals for biohydrogen production, and four elements were optimized. The optimal medium composition was MgCl₂·6H₂O (0.1 g/L), K₂HPO₄·3H₂O (6.67 g/L), NaHCO₃ (2.6 g/L), and FeCl₂·4H₂O (0.002 g/L). Vitamin supplementation of the medium showed no significant effect on hydrogen production. Under the optimized conditions, cumulative hydrogen production reached 3074 mL H₂/L. This is the first study to demonstrate the use of casamino acids as a nitrogen source by C. butyricum.     

A concentrator module of spherical Si solar cell

Spherical Si solar cell, which is made up of Si spheres with a diameter of approximately 1.0 mm, is expected to be a promising candidate for low consumption of Si feedstock and simple process technology. This paper describes the formation process and the structure of a concentrator module in detail. The concentrator lens was formed by casting with ultraviolet light hardening resin. The concentration ratio was 4.4 times and the pitch between the spheres was 2.0 mm. By this module design, it was possible to realize a consumption of the Si feedstock of about 3.0 g/W. Conversion efficiencies of 11.3% from single-sphere cell, 8.5% from a 23-spheres module and 5.2% from a 105-spheres module under AM1.5, 100 mW/cm² illumination were achieved.     

Heat transfer mechanism of a swirling impinging jet in a stagnation region

Heat transfer characteristics of a swirling impinging jet have been experimentally examined using a combined particle image velocimetry (PIV) and laser‐induced fluorescence (LIF) technique for simultaneous measurement of velocity and temperature fields. The present study shows that the radial width of the jet stretches with increasing swirl intensity, and that the stretching phenomenon contributes to the maximum local heat transfer coefficient. At the stagnation region, the flow near the heated surface is mixed intermittently by reverse flows toward upstream, and spatial distributions of temperature are correlated with instantaneous velocity vector maps. The dynamic behavior of recirculation zones, attributed to swirl number Sw and impinging distance, mainly determines the turbulent heat transfer at the stagnation region. © 2003 Wiley Periodicals, Inc. Heat Trans Asian Res, 32(8): 663–673, 2003; Published online in Wiley InterScience ( www.interscience.wiley.com ). DOI 10.1002/htj.10120     

Bioconversion of 1-adamantanol to 1,3-adamantanediol using Streptomyces sp. SA8 oxidation system

To efficiently produce 1,3-adamantanediol (1,3-ad(OH)₂) from 1-adamantanol (1-adOH), our stocks of culture strains and soil microorganisms were surveyed for hydroxylation activity towards 1-adOH. Among them, the soil actinomycete SA8 showing the highest hydroxylation activity was identified as Streptomyces sp. based on 16S ribosomal DNA sequence analysis. The reaction products were purified by silica gel column chromatography, and from NMR and MS analyses, they were identified as 1,3-ad(OH)₂ and 1,4-ad(OH)₂. Streptomyces sp. SA8 produced 5.9 g l^? 1 1,3-ad(OH)₂from 6.2 g l^? 1 1-adOH in culture broth after 120 h at 25 °C. Using resting cells, 2.3 g l^? 1 1,3-ad(OH)₂ was produced after 96 h of incubation at a 69% conversion rate. In both cases, 1,4-ad(OH)₂ was formed as a byproduct at a rate of about 15%. Strain SA8 also hydroxylated 2-adamantanol and 2-methyl-2-adamantanol.     

An analysis of the length of hospital stay for cataract patients in Japan using the discrete-type proportional hazard model

We analyze the length of hospital stays of patients hospitalized for cataract and related diseases (Diagnosis Related Groups (DRG) 2041) in Japan, utilizing the data pertaining to 3436 patients on whom one-eye lens operations are performed. We use the discrete-type proportional hazard model to analyze variables that may affect the length of stay.