Influence of Cryomilling on the Morphology and Composition of the Oxide Scales Formed on HVOF CoNiCrAlY Coatings

Commercially available, gas-atomized CoNiCrAlY powder was cryomilled to produce powder with nanocrystalline grains. The cryomilled powder and conventional gas-atomized powder were thermally sprayed using the HVOF process to prepare two coatings with fine-grain (～15 nm) and coarse-grain (～1 μm) microstructure, respectively. The two coatings were isothermally oxidized in air at 1000° C for up to 330 hr. The morphology and composition of the oxide scales formed on the two coatings were compared with each other. The results indicate that, while a fine-grain microstructure can promote the formation of a pure alumina layer on the coating by increasing the Al diffusion rate toward the surface, it can also accelerate the Al depletion by increasing the Al diffusion rate toward the substrate, which results in the formation of non-alumina oxides after long-term oxidation. The mechanisms governing the oxide formation are discussed in terms of atomic diffusion and thermodynamic stability.     

微小电偶腐蚀电流的准确测定

为了更多地获得电偶腐蚀的信息并揭示其本质规律，提出了电偶腐蚀试验实时监测模型。通过选用不同设备对试样的电偶腐蚀微小电流的测量，结果发现：选用现成设备测量试样的电偶腐蚀微小电流时，测量电流波动非常大，噪声明显超过实际信号输入——电偶腐蚀电流。经自行开发研制的MCD01电偶腐蚀计可以准确的测量腐蚀电流，特别是微小电偶腐蚀电流。     

Microstructural Investigation of Protective and Non-Protective Oxides on 11% Chromium Steel

FIB, SEM and STEM/EDX were used to investigate X20 stainless-steel samples exposed to dry O₂, or O₂ containing 40% H₂O, with a flow velocity of 0.5 cm/s or 5 cm/s, for 168 hr or 336 hr at 600°C. Thin protective Cr-rich (Cr,Fe)₂O₃ was maintained on the samples exposed to dry O₂, even after 336 hr, and on the sample exposed to O₂/H₂O mixture with the low-flow velocity (0.5 cm/s) for 168 hr. The oxide scale formed in the latter environment contained less Cr, due to Cr loss through CrO₂(OH)₂ evaporation. Breakaway oxidation occurred on the samples exposed in high-gas-flow velocity for shorter time (168 hr) or in low-gas-flow velocity (0.5 cm/s) for longer time (336 hr). The breakaway scales featured a two-layered structure: an outward-growing oxide “island” consisting of almost pure hematite (α-Fe₂O₃), and an inward-growing oxide “crater” consisting of (Cr,Fe)₃O₄. The transition from a thin protective (Cr,Fe)₂O₃ scale to a non-protective thick scale on this martensitic/ferritic steel originated locally and was followed by rapid oxide growth, resulting in a thick scale that covered the whole sample surface.     

保温条件下过共晶Al-Si合金半固态浆料的组织演变

研究了保温时间和保温温度对电磁搅拌ZL117合金半固态浆料稳定性的影响.试验结果表明：半固态浆料中初生Si的颗粒直径随着保温时间的延长而逐渐增大,但在前15 min内增长速度比较缓慢,15 min后增长较快;随着保温温度的升高而缓慢增大;初生Si的形状系数随着保温时间的延长而变得越来越大,但也在前15 min内变化较为缓慢,15 min后变大速度突然加快;初生Si的形状系数在620 ℃下保温时最小,在610～620 ℃之间随着保温温度的升高而缓慢变小;在620～650 ℃之间随着保温温度的升高而逐渐增加.     

An improved NDVI-based threshold method for estimating land surface emissivity using MODIS satellite data

This work estimated the land surface emissivities (LSEs) for MODIS thermal infrared channels 29 (8.4–8.7 μm), 31 (10.78–11.28 μm), and 32 (11.77–12.27 μm) using an improved normalized difference vegetation index (NDVI)-based threshold method. The channel LSEs are expressed as functions of atmospherically corrected reflectance from the MODIS visible and near-infrared channels with wavelengths ranging from 0.4 to 2.2 μm for bare soil. To retain the angular information, the vegetation LSEs were explicitly expressed in the NDVI function. The results exhibited a root mean square error (RMSE) among the estimated LSEs using the improved method, and those calculated using spectral data from Johns Hopkins University (JHU) are below 0.01 for channels 31 and 32. The MODIS land surface temperature/emissivity (LST/E) products, MOD11_L2 with LSE derived via the classification-based method with 1 km resolution and MOD11C1 with LSE retrieved via the day/night LST retrieval method at 0.05° resolution, were used to validate the proposed method. The resultant variances and entropies for the LSEs estimated using the proposed method were larger than those extracted from MOD11_L2, which indicates that the proposed method better described the spectral variation for different land covers. In addition, comparing the estimated LSEs to those from MOD11C1 yielded RMSEs of approximately 0.02 for the three channels; however, more than 70% of pixels exhibited LSE differences within 0.01 for channels 31 and 32, which indicates that the proposed method feasibly depicts LSE variation for different land covers.     

A modular designed bolt tightening shaft based on adaptive fuzzy backstepping control

This paper presents a modular designed autonomous bolt tightening shaft system with an adaptive fuzzy backstepping control approach developed for it. The bolt tightening shaft is designed for the autonomous bolt tightening operation, which has huge potential for industry application. Due to the inherent nonlinear and uncertain properties, the bolt tightening shaft and the bolt tightening process are mathematically modeled as an uncertain strict feedback system. With the adaptive backstepping and approximation property of fuzzy logic system, the controller is recursively designed. Based on the Lyapunov stability theorem, all signals in the closed-loop system are proved to be uniformly ultimately bounded and the torque tracking error exponentially converges to a small residue. And the effectiveness and performance of the proposed autonomous system are verified by the simulation and experiment results on the bolt tightening shaft system.     

图谱法脑部MRI图像自动分割技术发展及应用

脑部MRI图像自动分割是计算机技术运用于医学上的一个典 型工作,脑部图像分割技术对于人类研究脑部疾病具有重要意义。虽然有一些非常广泛应用 的图像分割方法,如阈值法、区域增长法、聚类法等,但在脑部MRI图像分割中,这些方法 都 没有图谱法具有更为实际的医学研究与临床价值。本文回顾了脑部图像配准、分割的发展历 程,介绍了图谱分割算法的发展及基本原理,以及当前比较前沿的多图谱分割系统的组成和 应用。最后本文对图谱法脑部自动分割在实际临床医学中的应用前景作了总结和展望。     

新时期中职体育礼仪教育的实施策略

体育是文化的重要组成部分,不管是在世界,还是在国内,都已经成为了人们日常生活的一部分,也影响着人们的生活。中职的体育教学是培养人才的重要手段,蕴含着丰富的教育功能。在中职体育教学中,通过体育礼仪的教育可以提高中职学生的礼仪修养,进而促进学生整体思想水平和境界的提升。