Effect of Drying Conditions and Level of Condensed Distillers Solubles on Protein Quality of Wheat Distillers Dried Grain with Solubles

Reduced protein quality is one of the concerns currently confronting the supply and utilization of wheat distillers dried grain with solubles (DDGS) as an animal feed ingredient. This study assessed the protein quality of wheat DDGS, expressed as acid detergent insoluble crude protein (ADICP) and lysine content, by blending wet distillers grain (WDG) with varying condensed distillers solubles (CDS) levels and drying using forced air convection, microwave, and microwave–convection methods. As the CDS level was increased, the protein content of wheat DDGS generated from the three drying methods increased. Interactions of CDS level with drying air temperature, microwave power, and microwave–convection settings had a significant effect (p < 0.05) on average ADICP and lysine contents. Higher ADICP and lower lysine contents were observed in samples dried at higher temperature, microwave power, and microwave convection settings. Further, the CDS level significantly affected the color parameters of microwave- and microwave–convection-dried samples and the drying air temperature–CDS level interaction significantly affected the color of forced air convection–dried samples. Significant lysine content–redness, ADICP–lightness color parameter, and ADICP–total color difference correlations were found in forced air convection–, microwave-, and microwave–convection-dried samples, respectively. Microwave and microwave–convection drying achieved desirable protein quality associated with low-temperature drying at much shorter times.     

Preparation of polypropylene‐based nanocomposites using nanosized MCM‐41 as support and in situ polymerization

MCM‐41 nanoparticles were used for preparing nanocomposites through the in situ polymerization of propylene. The performance of the catalytic system and the final properties of the materials obtained are highly dependent on the methodology used for impregnation of the catalyst onto the support particles, and therefore an optimization study for the impregnation methodology of the catalyst (Me₂Si(Ind)₂ZrCl₂) was carried out. Two different methodologies were used; the results in terms of catalytic activity and polymer molecular masses indicated that the most promising one involved the pre‐activation of the catalyst with the cocatalyst, methylaluminoxane, followed by impregnation onto the MCM‐41 nanoparticles. Thus, an optimized route for the preparation of polypropylene nanocomposites achieving significant improvements in catalyst activity was developed. The nanocomposite materials were characterized by GPC, TGA and DSC. The dispersion state and the size of the nanoparticles incorporated in the polypropylene matrix were investigated by transmission electron microcopy. Additionally, this methodology allows simultaneous control of the desired amount of support and the concentration of catalyst to be used in the in situ polymerization. © 2015 Society of Chemical Industry     

Synthetic Activity of Recombinant Whole Cell Biocatalysts Containing 2-Deoxy-D-ribose-5-phosphate Aldolase from Pectobacterium atrosepticum

In nature 2-deoxy-D-ribose-5-phosphate aldolase (DERA) catalyses the reversible formation of 2-deoxyribose 5-phosphate from D-glyceraldehyde 3-phosphate and acetaldehyde. In addition, this enzyme can use acetaldehyde as the sole substrate, resulting in a tandem aldol reaction, yielding 2,4,6-trideoxy-D-erythro-hexapyranose, which spontaneously cyclizes. This reaction is very useful for the synthesis of the side chain of statin-type drugs used to decrease cholesterol levels in blood. One of the main challenges in the use of DERA in industrial processes, where high substrate loads are needed to achieve the desired productivity, is its inactivation by high acetaldehyde concentration. In this work, the utility of different variants of Pectobacterium atrosepticum DERA (PaDERA) as whole cell biocatalysts to synthesize 2-deoxyribose 5-phosphate and 2,4,6-trideoxy-D-erythro-hexapyranose was analysed. Under optimized conditions, E. coli BL21 (PaDERA C-His AA C49M) whole cells yields 99 % of both products. Furthermore, this enzyme is able to tolerate 500 mM acetaldehyde in a whole-cell experiment which makes it suitable for industrial applications.     

Numerical Investigation of the Effect of Impeller Design Parameters on the Performance of a Multiphase Baffle‐Stirred Reactor

The turbulent gas‐liquid flow field in an industrial 100‐m³ stirred tank was calculated by using computational fluid dynamics based on the finite‐volume method. Turbulent effects were modeled with the shear stress transport model, and gas‐liquid bubbly flow was modeled with the Eulerian‐Eulerian approach using the Grace correlation for the drag force interphase momentum transfer. The relative motion between the rotating impeller and the stationary baffled tank was considered by using a multiple frames of reference algorithm. The effects of Rushton and pitched‐blade impeller design parameters such as blade geometry, location, and pumping direction on the mixing performance were investigated. It was found that a combination of Rushton turbines with up‐pumping pitched‐blade turbines provides the best mixing performance in terms of gas holdup and interfacial area density. The approach outlined in this work is useful for performance optimization of biotechnology reactors, as typically found in fermentation processes.     

Why Phenolic Acids Are Unlikely Primary Allelochemicals in Rice

Allelopathy in rice (Oryza sativa, L.) effective against weeds has been found in about 3.5% of tested rice germplasm in both laboratory and field experimentation. However, the allelochemicals responsible for growth inhibition of rice-associated weeds have not yet been identified. In the literature, phenolic acids are often mentioned as putative allelochemicals. If phenolic acids commonly reach growth inhibitory concentrations in rice ecosystems, it must be expected that the degree of tolerance to phenolic acids will vary among traditional rice cultivars or plant species adapted to rice environments having inherently different phenolic acid concentrations. Phenolic acids concentrations are normally greater in submerged than in aerobic soils. A dose–response study, however, showed that seedlings of rice cultivars adapted to submerged anaerobic soils did not have higher level of tolerance against p-hydroxybenzoic acid than did seedlings of varieties adapted to aerobic upland soils. Moreover, traditional rice cultivars had no greater tolerance than did improved cultivars that were recently bred for traits other than tolerance of phenolic acids. Similarly, there were no differences in tolerance of p-hydroxybenzoic acid between two Echinochloa weed species adapted to either anaerobic or aerobic growth conditions. Thus, neither the rice cultivars nor weed species had evolved different tolerance levels against the phenolic acid. However, all rice cultivars had significantly greater tolerance of p-hydroxybenzoic acid than did either weed species. In a second experiment, the rates at which rice plants released phenolic acids into solution cultures were measured for at least one month, the time period of greatest allelopathic activity following planting under field conditions. The maximum release rate of phenolic acids during the first month of growth was approximately 10 g/plant/day. At a conventional plant density, the release rate of phenolic acids would be approximately 1 mg/m²day. This order of release rate cannot provide concentrations remotely close to phytotoxic levels determined for these rice cultivars and weed species. The results presented in this paper do not preclude the possibility that phenolic acids might be one component in a mixture of chemicals that, when present simultaneously, are allelopathic.     

Classification of vegetable oils by high-resolution <Superscript>13</Superscript>C NMR spectroscopy using chromatographically obtained oil fractions

¹³C NMR spectra of oil fractions obtained chromatographically from 109 vegetable oils were obtained and analyzed to evaluate the potential use of those fractions in the classification of vegetable oils and to compare the results with the NMR analysis of complete oils. The oils included the following: virgin olive oils from different cultivars and regions of Europe and north Africa; “lampante” olive, refined olive, refined olive pomace, hazelnut, rapeseed, high-oleic sunflower, corn, grapeseed, soybean, and sunflower oils; and mixtures of virgin olive oils from different geographical origins. Oils were divided into two sets of samples. The training set (98 samples) was employed to select the variables that resulted in significant discrimination among the different oil classes. By using stepwise discriminant analysis, more than 98% of correct validated assignments were obtained; these results were confirmed when applied to the test set (11 blind samples). Results suggest that the use of oil fractions considerably increases the discriminating power of NMR in the analysis of vegetable oils.     

Low molecular weight polypeptides in virgin and refined olive oils

Twenty-eight virgin olive oils—from different regions of Spain and prepared from olive drupes of different varieties—and six refined olive oils were analyzed to determine the presence of proteins in these oils. All oils studied showed the presence of proteins in the range of 7–51 μ/100 g of oil. There were no significant differences in protein content in oils from different varieties or between virgin or refined oils. In addition, all oils exhibited analogous amino acid patterns, suggesting a similarity among protein fractions obtained from different oils. A polypeptide with an apparent M.W. of 4600 Da was common to the isolated protein fractions. These results suggest that this polypeptide is a previously unknown minor component in olive oils. No clear influence of this component on oil stability was observed when oil stabilities were estimated as a function of phenol, tocopherol, phosphorus, and protein contents of the oils.     

Synthesis,characterization, and degradation of block polyesteramides containing poly(L-lactide) segments

Random multiblock polyesteramides (PEAs) having polyester (PE) content of 20–50 wt % have been prepared by low-temperature polycondensation using sebacoyl chloride, 1,6-diaminohexane, and telechelic oligomers of L-lactide with M_n = 600–1500. The PEAs were characterized by IR and ¹H-NMR spectroscopy, wide-angle X-ray diffraction, and thermal analysis. Only the polyamide segments are able to crystallize, and the crystallinity depends on the composition and architecture of the PEAs. From viscosity and IR measurements it was established that the chain degradation of PEA powders or films suspended in buffer solutions occurs by hydrolysis of the ester linkages. The degradation rate is influenced by pH, PE content, and, to a lesser extent, by crystallinity. © 1992 John Wiley & Sons, Inc.     

Influence of β‐nucleation on polymorphism and properties in random copolymers and terpolymers of propylene

The competition between α, β, and γ polymorphs has been studied in several random copolymers and terpolymers of propylene, by performing X‐ray diffraction and differential scanning calorimetry experiments. Formation of β‐crystals, achieved by the addition of a β‐nucleating agent, was found to be highly dependent on comonomer type and crystallization conditions. Additionally, the mechanical properties have been evaluated from stress‐strain, microhardness and dynamic‐mechanical thermal analyses. POLYM. ENG. SCI., 2012. © 2012 Society of Plastics Engineers     

A Topical Formulation of Melatoninergic Compounds Exerts Strong Hypotensive and Neuroprotective Effects in a Rat Model of Hypertensive Glaucoma

Melatonin is of great importance for regulating several eye processes, including pressure homeostasis. Melatonin in combination with agomelatine has been recently reported to reduce intraocular pressure (IOP) with higher efficacy than each compound alone. Here, we used the methylcellulose (MCE) rat model of hypertensive glaucoma, an optic neuropathy characterized by the apoptotic death of retinal ganglion cells (RGCs), to evaluate the hypotensive and neuroprotective efficacy of an eye drop nanomicellar formulation containing melatonin/agomelatine. Eye tissue distribution of melatonin/agomelatine in healthy rats was evaluated by HPLC/MS/MS. In the MCE model, we assessed by tonometry the hypotensive efficacy of melatonin/agomelatine. Neuroprotection was revealed by electroretinography; by levels of inflammatory and apoptotic markers; and by RGC density. The effects of melatonin/agomelatine were compared with those of timolol (a beta blocker with prevalent hypotensive activity) or brimonidine (an alpha 2 adrenergic agonist with potential neuroprotective efficacy), two drugs commonly used to treat glaucoma. Both melatonin and agomelatine penetrate the posterior segment of the eye. In the MCE model, IOP elevation was drastically reduced by melatonin/agomelatine with higher efficacy than that of timolol or brimonidine. Concomitantly, gliosis-related inflammation and the Bax-associated apoptosis were partially prevented, thus leading to RGC survival and recovered retinal dysfunction. We suggest that topical melatoninergic compounds might be beneficial for ocular health.