Topotaxial Formation of Mg4Nb2O9 and MgNb2O6 Thin Films on MgO (001) Single Crystals by Vapor–Solid Reaction

Thin-film solid-state reactions in the system MgO–Nb₂O₅ are experimentally investigated. MgO (001) substrates are subjected to Nb-O vapor at different temperatures in high vacuum. Thin films containing the phases Mg₄Nb₂O₉ and MgNb₂O₆ are formed by a vapor–solid reaction between the Nb-O vapor and the substrate. The crystallographic orientations of these phases are studied by X-ray diffractometry including pole figure analysis. Mg₄Nb₂O₉ grows (11.4)-, (11.6)-, and (11.9)-oriented, whereas MgNb₂O₆ grows with a preferential (241) orientation. The crystallographic relationships and their origins are discussed.     

Transition and flow boiling heat transfer inside a horizontal tube

Experiments on transition and flow boiling heat transfer with refrigerant R114 inside a horizontal tube were performed at bubble flow, critical heat flux and in the transition region between bubble flow and film boiling at mass fluxes between 1200 and 4000 kg/m² s and in the pressure range between 5 and 15 bar. In comparison with pool boiling bubble flow heat transfer depends essentially on the mass flow rates and on the vapor quality. The critical heat flux depends less on the temperature difference than in pool boiling heat transfer and exhibits a maximal and a minimal value as a function of the pressure. The critical heat flux increases with mass flow rate as already shown by Collier. In the region of transition boiling the heat flux over the difference between wall and saturation temperature approaches a horizontal curve. Therefore in this region an evaporator may always be operated under stable conditions and burn out does not occur.     

Sub-zero cooling: A novel strategy for high performance cutting

In this paper, a novel cooling strategy for high performance cutting is presented. A metalworking fluid, composed of water and polyhydric alcohols is applied at temperatures below 0 °C, but above the temperatures used for cryogenic cutting. This cooling strategy is applied when rough turning Ti-6Al-4V. An analysis of temperatures, forces, tool wear and chip formation is carried out. The results are compared with those obtained using emulsion, CO₂, LN₂, and dry turning. It can be shown that when tempering the sub-zero metalworking fluid down to ?30° C, tool temperatures as well as tool wear are reduced, and favourable chips are produced.     

Synthesis and electrochemical properties of Li[Li0.07Ni0.1Co0.6Mn0.23]O2 as a possible cathode material for lithium-ion batteries

The layered Li[Li_0.07Ni_0.1Co_0.6Mn_0.23]O₂ materials were synthesized by sol-gel method with glycine or citric acid as chelating agent. The prepared materials were characterized by means of XRD, SEM and Raman spectroscopy. Li/Li[Li_0.07Ni_0.1Co_0.6Mn_0.23]O₂ cells were assembled and subjected to charge-discharge studies at different C rates, viz 0.2, 1, 2 and 4 C. Although the samples showed less discharge capacity at 4 C rate the fade in capacity per cycle is lesser than that of capacity fade at 0.2 C rate. The citric acid assisted sample is found to be superior in terms of discharge capacity, capacity retention rate and also in thermal stability to that of sample prepared with glycine as chelating agent.     

Health assessment of artisanal gold miners in Indonesia

Small scale miners use mercury to extract gold from ore in many countries. An environmental and health assessment was performed in Indonesia in two regions, Galangan in Central Kalimantan and Talawaan in Northern Sulawesi. The environmental assessment showed severe mercury contamination of the sediments, and increased mercury levels in local fish. For the health investigation 281 volunteers were recruited and examined by a standardized questionnaire, a neurological examination and neuro-psychological tests. A medical score was used consisting of significant factors of mercury intoxication. Mercury exposed workers showed typical symptoms of mercury intoxication, such as movement disorders (ataxia, tremor, dysdiadochokinesia, etc.). Blood, urine and hair samples were taken from any participant and analyzed for mercury. The mercury concentration in the biomonitors was high, partly extreme high in the working population, increased in the population living in the same habitat and low in the control group. By a standard protocol which includes a combination of threshold values of mercury in the biomonitors and a medical sum score the diagnosis of chronic mercury intoxication was made for highly burdened workers (amalgam smelters) in 55% in Sulawesi and in 62% in Kalimantan. Less exposed mineral processors and the general population in the mining areas were also intoxicated to a high percentage.     

Microbiological, epidemiological, and food safety aspects of Enterobacter sakazakii

Enterobacter sakazakii is considered to be an opportunistic pathogen and has been implicated in foodborne diseases causing meningitis or enteritis, especially in neonates and infants. The U.S FoodNet 2002 survey rate of invasive infections with this organism in infants under 1 year of age was 1 per 100,000 infants. Severity of the disease is a matter of concern. In a recent study on the occurrence of E. sakazakii in production environments from food (milk powder, chocolate, cereal, potato, and pasta) factories and households, this organism was isolated with varying frequency from nearly all environments examined, strongly indicating that it is widespread. Stationary phase E. sakazakii cells are remarkably resistant to osmotic and drying stresses compared with other species of the Enterobacteriacae. In this article, we review the literature on this organism with special respect to the information relevant for food safety.     

Germin-like protein Cit s 1 and profilin Cit s 2 are major allergens in orange (Citrus sinensis) fruits

Oranges are clinically relevant allergenic foods. To date, orange allergens have not been characterized in detail. The study is aimed at analyzing the sensitization profile in orange-sensitized subjects with and without clinical allergy, and to identify orange allergens. Fifty-six sensitized subjects with self-reported reactions to orange were grouped into reactors (anaphylaxis or multiple episodes of immediate reactions and/or positive challenge tests) and non-reactors (negative open food challenge tests). Allergens were characterized by IgE immunoblotting, N-terminal sequencing, IgE-inhibition assays, and mediator release assays were performed to determine the allergenic potency of orange profilin. Of 56 subjects, 23 were classified as orange allergic showing mainly an oral allergy syndrome. Of 23 subjects classified as orange allergic, 22 were sensitized to profilin, Cit s 2. In patients with mono-sensitization to profilin in vitro histamine releases up to 75% from basophils were induced using orange extract and purified plant profilins. Of the allergic patients 78% were sensitized to germin-like protein, Cit s 1. Both allergens showed retained IgE reactivity in heat-processed orange juice. Interestingly, subjects with and without clinical allergy showed a comparable sensitization profile. Profilin and germin-like proteins are major orange allergens. The potential clinical relevance of orange profilin was indicated by its strong capacity to release histamine from basophils. However, a predominant sensitization to both allergens in subjects without symptoms also indicates a high frequency of clinically insignificant sensitization.     

Escherichia coli O157 and non-O157 Shiga toxin-producing Escherichia coli in fecal samples of finished pigs at slaughter in Switzerland

Fecal samples from 630 slaughtered finisher pigs were examined by PCR to assess the shedding of Escherichia coli O157 (rfbE) and Shiga toxin-producing E. coli (STEC, stx). The proportion of positive samples was 7.5% for rfbE and 22% for stx. By colony hybridization, 31 E. coli O157 and 45 STEC strains were isolated, and these strains were further characterized by phenotypic and genotypic traits. Among E. coli O157 strains, 30 were sorbitol positive, 30 had an H type other than H7, and none harbored stx genes. Intimin (eae), enterohemolysin (ehxA), EAST1 (astA), and porcine A/E-associated protein (paa) were present in 10, 3, 26, and 6% of strains. Among them, one eae-gamma1-positive O157:H7 strain testing positive for ehxA and astA and two eae-alpha1-positive O157:H45 strains were classified as enteropathogenic E. coli (EPEC). The O157:H45 EPEC harbored the EAF plasmid and the bfpA gene, factors characteristic for typical EPEC. The isolated STEC strains (43 sorbitol positive) belonged to 11 O:H serotypes, including three previously reported in human STEC causing hemolytic uremic syndrome (O9:H-, O26:H-, and O103:H2). All but one strain harbored stx2e. The eae and ehxA genes, which are strongly correlated with human disease, were present in only one O103:H2 strain positive for stx1 and paa, whereas the astA gene was found more frequently (14 strains). High prevalence of STEC was found among finisher pigs, but according to the virulence factors the majority of these strains seem to be of low virulence.     

Lipoxygenase Products in the Urine Correlate with Renal Function and Body Temperature but not with Acute Transplant Rejection

Acute transplant rejection is the leading cause of graft loss in the first months after kidney transplantation. Lipoxygenase products mediate pro- and anti-inflammatory actions and thus we aimed to correlate the histological reports of renal transplant biopsies with urinary lipoxygenase products concentrations to evaluate their role as a diagnostic marker. This study included a total of 34 kidney transplant recipients: 17 with an acute transplant rejection and 17 controls. LTE4, LTB4, 12-HETE and 15-HETE concentrations were measured by enzyme immunoassay. Urinary lipoxygenase product concentrations were not significantly changed during an acute allograft rejection. Nevertheless, LTB4 concentrations correlated significantly with the body temperature (P ≤ 0.05) 3 months after transplantation, and 12- and 15-HETE concentrations correlated significantly with renal function (P ≤ 0.05) 2 weeks after transplantation. In conclusion, our data show a correlation for LTB4 with the body temperature 3 months after transplantation and urinary 12- and 15-HETE concentrations correlate positively with elevated serum creatinine concentrations but do not predict acute allograft rejection.