Case Study of an Aerosol Explosion and a Method to Determine Explosion Temperatures

A failure analysis case study is presented for a two-piece aerosol containing tetrafluoroethane, commonly referred to as Refrigerant 134a. A gentleman was preparing to recharge the air conditioning system of an automobile when the bottom exploded off the aerosol container, propelling the body of the aerosol container like a rocket, which hit the man in the eye and blinded him in that eye. The aerosol was never connected to the air conditioner, therefore backpressure from the air conditioner (AC) compressor was ruled out as a cause for the explosion. The objective of the study was to determine why the aerosol exploded. Several recently developed test methods were used, including two types of heat-to-burst tests and a puncture chamber to measure the pressure-versus-temperature behavior of aerosols. More common test methods were also used, such as water bath pressure tests, hydro pressure burst tests, pneumatic pressure burst tests, hardness measurements, weight measurements, metallography, scanning electron microscopy (SEM), energy-dispersive spectroscopy (EDS), and an accident scenario recreation. A semi-empirical correlation between the hardness and weights of the container bottoms was used to determine the explosion temperature and/or pressure. This semi-empirical correlation agrees in principle with an analysis of the explosion pressures using finite-element analysis (FEA). The root cause for the explosion was determined to be a lack of strength of the bottom of the two-piece aerosol coupled with heating the aerosol to temperatures significantly above room temperature.     

KATRIN NEG pumping concept investigation

The Karlsruhe Tritium Neutrino experiment (KATRIN) is going to use a very large electro-static tandem spectrometer to measure the electron spectrum from the tritium beta decay, where several kilometers of non-evaporable getter (NEG) strips (type ST707) are to be used to achieve the UHV requirements. Different geometrical configurations of the NEG strips have been studied by Monte Carlo simulations. It is shown that the resulting pumping speed of the getter pumps will allow to get a pressure below 10⁻¹¹ mbar in the huge vessel with a volume of 1400 m³. By systematic assessment of the statistics of the pumping surfaces, it could be demonstrated that the design is sound.     

Adaptive generation of surfaces in volume data

A widespread approach to generating polygonal approximations of iso-surfaces or contour surfaces in volume data is the socalled marching-cubes algorithm. This algorithm, however, has the disadvantage that the number of polygonal chains generated is considerable. The splitting-box algorithm presented here reduces the number of polygonal chains by adapting their size to the shape of the surface. The resulting polygonal chains offer a wide spectrum for representing the contour surface. An exact representation is achieved by a new type of generic patches calculated from the polygonal chains. Approximations of different quality may be obtained by combining the algorithm generating the patches with simple triangulations.     

Results of irradiation treatment in patients with non-resectable oesophageal cancer

Forty-eight patients with non-resectable cancer of the oesophagus and oesophagogastric junction (Group A: Stage I/II, 32; Group B: Stage III/IV, 16) underwent intraluminal Iridium-192 high dose-rate afterloading therapy (5-7 Gy/session, total dose: 5-21 Gy, mean: 12.4 Gy) and external beam irradiation (Karnofsky > or = 80% 50-60 Gy/2 Gy per day; Karnofsky 60-79%: 30 Gy/3 Gy per day). Durable satisfactory palliation (intake of at least semi-solid food) was demonstrated in 96% of patients. The mean survival for group A was 19.1 months and that for group B, 6.9 months, with a 12-month survival rate of 66% (group A) and 0% (group B) (P < 0.001). Local tumour response and complication rate were significantly dose-related with a predicted response rate of 70.5%, and a complication rate of 50% at ERD 129.3 Gy.     

Acute bilateral amaurosis in sphenoid empyema caused by Streptococcus pneumoniae

PATIENT: A 14-year-old boy suffered from an acute bilateral blindness which occurred in 24-h time, accompanied by headache and raised temperature, with inconspicuous optic nerve head and fundus. After diagnosis of empyema with magnet resonance tomography (MRT) the sphenoid sinus was fenestrated and streptococcus pneumoniae isolated. Liquor and serology being inconspicuous, there was no evidence of leucaemic or autoimmune disease, intoxication or intracranial tumor. CLINICAL COURSE: The condition of the patient improved under systemic antibiotic therapy. The bilateral amaurosis remained and opticus atrophy developed. CONCLUSION: A bilateral amaurosis with descending opticus atrophy as a consequence of a sphenoiditis and spreading inflammation to the meninges and the optic nerve in the area of the chiasm is a rare event. The imaging technique of the MRT offers new opportunities for an early and more pointed diagnosis and therapy.     

Interfacial tension between coexisting polymer solutions in mixed solvents and its correlation with bulk thermodynamics: phase equilibria (liquid/gas and liquid/liquid) for the system toluene/ethanol/PDMS

Vapor pressures, phase equilibria and interfacial tensions σ were measured for solutions of poly(dimethylsiloxane) (PDMS, M_w[equals]75 kg/mol and M_n[equals]50 kg/mol) in mixed solvents of toluene (TL) and ethanol (EtOH) at 30, 40, 50 and 60 °C. The experimental ternary phase diagrams can be modeled quantitatively from the determined concentration and temperature dependent binary interaction parameters χ_ij if the experimentally inaccessible composition dependence of χ_EtOH/PDMS is adjusted. The relations between σ and the equation of state of the system differ from that applying to single solvents. The exponents as well as the amplitude prefactors of the corresponding scaling laws (e.g. the dependencies of σ on the length of the tie lines or on the hump energy, i.e. on the intrusion into the two phase regime quantified in terms of Gibbs energies) change considerably with temperature. However, this variation can be reduced significantly by normalizing the independent variables. Dividing the length of the tie lines by the length for the corresponding binary subsystem proves more efficient than the distance of these tie lines from the critical point of the ternary system relative to the maximum distance of the binary subsystem. A combined normalization does not improve the situation.     

Scheduling constraint generation for communicating processes

This paper describes a new algorithm for generation of scheduling constraints in networks of communicating processes. Our model of communication intertwines the schedules of the machines in the network: timing constraints of a machine may affect the schedules of machines communicating with it. This model of communication facilitates the modular specification of timing constraints. A feasible solution to the set of constraints generated gives a schedule for each machine in the network such that all internal constraints of each machine are satisfied and communication between machines is statically coordinated whenever possible. Static scheduling of communication saves on the cost of handshake associated with dynamic synchronization. Our algorithm can handle complex, state-dependent and cyclic timing constraints. Experimental results show that our algorithm is both effective and efficient     

High-power etched-facet lasers

We demonstrate, for the first time, laser diodes with anetched facet fabricated by chemically assisted ion beametching, producing 1?7 W pulsed and 470mW CW output power from one facet. The devices were coated and bonded junction-side-up and tested at room temperature. The single 40 ?m stripe, 300 ?m-long devices exhibit 94 mA threshold current and differential quantum efficiencies of 80% pulsed (78% CW).     

Dopamine and intestinal mucosal tissue oxygenation in a porcine model of haemorrhage

Haemorrhage is associated with intestinal mucosal hypoxia and impaired gut barrier function. Dopamine increases oxygen delivery to the intestinal mucosa and may thus counteract haemorrhage-induced mucosal hypoxia. Jejunal mucosal tissue oxygen tension (mucosal PO2) and jejunal oxygen saturation of mucosal microvascular haemoglobin (mucosal HbO2) were measured in 14 anaesthetized pigs. Seven animals served as controls (group C) and seven received continuous infusion of dopamine 16 micrograms kg-1 min-1 (group D) while 45% of blood volume was removed in three equal increments. Resuscitation was performed using shed blood and fluid. Mean arterial pressure and systemic oxygen delivery decreasing significantly during haemorrhage and returned to baseline after resuscitation in both groups. Mucosal PO2 decreased from 4.4 to 1.7 kPa after haemorrhage (P < 0.01) and further to 1.5 kPa after resuscitation (P < 0.01) in group C whereas group D showed an increase from 3.9 to 5.9 kPa after the start of the dopamine infusion (P < 0.05), but no significant difference from baseline after haemorrhage (2.3 kPa) (ns) or resuscitation (3.1 kPa) (ns). Mucosal HbO2 decreased from 52 to 32% after haemorrhage (P < 0.05) and increased to near baseline (37%) (ns) after resuscitation in group C whereas group D showed no significant changes from baseline (54%) throughout the experiment. Comparison between groups showed higher mucosal PO2 and HbO2 values for group D animals after the start of the dopamine infusion (P < 0.05 each), after the first two steps of haemorrhage (P < 0.01 each) and after resuscitation (P < 0.05 each). We conclude that i.v. dopamine 16 micrograms kg-1 min-1 improved tissue oxygenation of the small intestinal mucosa during moderate haemorrhage and subsequent resuscitation.